Nissan Murano 2003

ENGINE MAY STALL INCREASING THE RISK OF A CRASH.

DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.

DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.

DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.

DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.

DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.

IF THE GEAR DISPLAYED IS DIFFERENT FROM THE GEAR ENGAGED, THIS COULD RESULT IN UNEXPECTED VEHICLE MOVEMENT AND A CRASH.

DEALERS WILL CHECK THE AFFECTED NUT IN THE TRANSMISSION SHIFT LEVER LINKAGE, AND TIGHTEN IT IF NECESSARY. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

On certain vehicles, the intake air ducts, which are connected to the intermediate resonator in the air intake system of the engine, may separate from the resonator with engine movement. This separation occurs due to the premature ageing of the material used in the intake air ducts which causes excessive shrinking. If the air duct pulls off the resonator, the airflow meter will not accurately measure the intake airflow rate, which could result in unstable idling, poor acceleration, or engine stalling. Engine stalling would result in lost propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Correction: Dealers will replace the intake air duct with an updated version.

Certain vehicles may have received an incorrect replacement Body Control Module (BCM). Specifically, if, during service, the BCM was replaced with P/N 284B1-CA508 or P/N 284B1-CA509, the Daytime Running Lights (DRL) could become inoperative. As a result, these vehicles would no longer comply with CMVSS 108. Since this action deals with replacement parts, it is a deemed a Service Campaign and is not being conducted under the Safety Act. Correction: Dealers will replace affected BCMs.

On certain vehicles, the webbing of a rear outboard seat belt may contact the rear seat back hinge where it can be cut by the sharp edge of the metal portion of the hinge during a frontal crash. As a result, the seat belt may not properly restrain seat occupants, increasing the risk of personal injury. Correction: Dealers will install a plastic cover over the lower part of the webbing and the floor anchor.

On certain vehicles, the fuel tank may be punctured by road debris that has been picked up and thrown by the front tires. A fuel leak, in the presence of an ignition source, could result in a fire. Correction: Dealers will install a shield in front of the fuel tank.

On certain vehicles equipped with a Continuously Variable Transmission (CVT), an open circuit in the alternator can occur due to wire fatigue caused by movement of the rotor coil during rapid changes in engine speed. Higher engine compartment temperature in the Murano compared to other Nissan models may also be a contributing factor to the wire fatigue. When an open circuit occurs in the alternator, the charge warning and brake warning lamps come on. If the driver does not seek immediate assistance and continues to drive the vehicle in this condition, the vehicle will operate normally for about one hour. After this time, the battery voltage will drop to a level that causes the engine control module to go into a fail safe mode. During fail safe mode, which lasts about ten minutes, vehicle speed will be reduced due to the throttle plate being held in a fixed position. After this time period, the engine will stop running. Correction: Dealers will replace the alternator with an updated version.

On certain vehicles, the circuit board for the crank position sensor may have an improper solder joint. This could cause the Service Engine Soon warning light to come on, create a no start condition, cause reduced engine power, or cause the engine to stop running without warning during vehicle operation. Correction: Dealers will replace the crankshaft position sensor and both camshaft position sensors.

On certain vehicles, the nut that attaches the transmission gear selector shaft to the control valve lever in the transmission may not have been adequately tightened at the transmission plant which had been diverted from the production line for repair. This may result in the transmission not actually being in the gear indicated by the gear selector lever and lead to unexpected vehicle movement. Correction: Dealer will torque the nut to specifications.