Nissan Frontier 2003

THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.

THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.

ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

WHEN INSTALLED ON THE FRONT OF THE VEHICLE, THE WHEEL RIM WILL CONTACT THE BRAKE CALIPER CAUSING A LOUD RUBBING NOISE AND COULD RESULT IN WEAR ON THE CALIPER AND/OR WHEEL RIM IF DRIVING CONTINUES. CONTINUED USAGE OF THE SPARE TIRE WHEEL AT THE FRONT LOCATION CAN ALSO RESULT IN LOOSENING OF THE LUG NUTS AND DETERIORATION IN BRAKING PERFORMANCE. THIS COULD EVENTUALLY CAUSE THE WHEEL ASSEMBLY TO SEPARATE FORM THE VEHICLE AND RESULT IN LOSS OF CONTROL AND A CRASH.

DEALERS WILL REPLACE THE SPARE TIRE WHEEL RIM WITH A NEW ONE, AND REMOUNT THE SPARE TIRE ON IT. OWNER NOTIFICATION BEGAN JANUARY 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

On certain vehicles, corrosion may form in the lower steering column joint and limit the movement of the joint. Limited movement of this joint may create excessive load on the lower steering column shaft and, if the vehicle continues to be driven in this condition, may lead to cracking of the shaft during low speed manoeuvres that require large steering inputs. In an extreme case, the shaft may break which would result in loss of steering control and could result in a crash. Correction: Dealers will replace the affected column shafts and joints.

Certain Hidden Hitch brand accessory trailer hitches P/N 64-3528 installed by Nissan dealers on 2002 to 2004 Frontier vehicles. With continued use, load forces may cause a side bracket of the trailer hitch to fatigue and eventually break, possibly allowing the towed unit to separate from the towing vehicle. Correction: Dealers will replace all suspect Hidden Hitch brand hitches originally installed by Nissan dealers in Canada.

On certain vehicles, the fuel pump terminal on the fuel sending unit can develop a crack. When exposed to heavy concentrations of road salt in the winter, if road salt enters the crack, the terminal strip will corrode and eventually could break due to corrosion. This will cause the fuel pump to stop operating and will result in not being able to start the engine or cause the engine to stop running without warning. Correction: Dealer will replace the fuel sender unit.

On certain XE models, the size of the spare tire wheel rim is incorrect. The wheel rim does not fit properly on the front hubs and will contact the brake caliper. Continued usage of the spare tire wheel on a front hub can also result in loosening of the lug nuts and an increase in brake fluid temperature. This may eventually cause the wheel to separate from the vehicle and/or deterioration in braking performance. Correction: Dealers will replace the wheel rim and re-install the spare tire.

On certain four wheel drive vehicles, water may enter the rear axle housing due to inadequate sealing of the ABS sensor in the axle housing. This may result in corrosion and eventually failure of the wheel bearing. If this occurs, the wheel assembly could separate from the vehicle. Correction: Dealer will inspect the rear axle for water intrusion and replace any affected components. The ABS sensor will be resealed to prevent water intrusion.