Audi A6 Avant 2000

In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.

Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.

THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.

DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.

DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.

RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.

On certain vehicles, if a plastic cover is not securely installed to the drivers-side support crossmember, the headlight switch wiring harness could short out on the crossmember and cause a fire. Note: Further evaluation revealed that only U.S. vehicles are affected. Canadian-market vehicles are equipped with a different headlamp switch wiring harness which includes Daytime Running Lights (DRL). As a result Canadian vehicles will not experience this type of electrical wiring problem, therefore the recall is cancelled.

On certain Audi S6, A6 and A6 Allroad Quattro, contact between the left driver's side crash element and the headlight switch wiring harness could eventually result in an electrical short. Even though such an electrical short is not very likely, it could result, in a worst-case scenario, in a fire originating in the left dashboard area. Correction: Dealer will install a protective covering on the crash element and inspect the wiring harness for damage.

On certain Audi A6 Quattro, sulphur in the fuel interacting with certain additives found in widely available fuel can become deposited on certain contact points on three sending units mounted inside the fuel tank. Low electrical resistance at contact points of any unit signals that the tank is full. The accumulation of sulphur deposits on contacts would increase the resistance and erroneously signal that the tank is filled with fuel while in fact it may not be full or could be empty. If a driver is not cognizant of the miles driven and the potential driving range of their vehicle from a fuel fill, the erroneous fuel level signal could cause the vehicle to become inoperable without prior warning. Correction: Fuel sending units will be replaced with redesigned sending units.