Volvo V70 1998 — Problemas reportados

SEVERE TIRE SIDEWALL BUBBLES ON ALL FOUR TIRES AFTER ONLY 2 YEARS OF NORMAL USE. TIRE BRAND AND TYPE: DUNLOP 195/60R15 888 H SIGNATURE II.

THE IGNITION SWITCH FREQUENTLY JAMS, LOCKED, IN THE "OFF" POSITION. THE KEY CAN BE INSERTED, BUT THE IGNITION LOCK WILL NOT TURN, MAKING IT IMPOSSIBLE TO START AND OPERATE THE VEHICLE OR TURN ON ACCESSORIES OR TURN THE STEERING WHEEL, RENDERING THE VEHICLE COMPLETELY INOPERATIVE. WHEN THE IGNITION IS IN THE "ON" POSITION, IT CAN BE TURNED OFF WITHOUT DIFFICULTY. WHEN IT IS "OFF," HOWEVER, IT FREQUENTLY CAN NOT BE TURNED "ON". A QUICK INTERNET SEARCH REVEALED THAT THIS IS A RATHER COMMON PROBLEM.

I WAS ON THE ENTRANCE RAMP TO I-94 WHEN THE ACCELERATOR STOMPED FLUSH TO THE FLOOR. THE ENGINE REVVED UNCONTROLLABLY AND I TRIED TO CLUTCH IT DOWN BUT KEPT ON ACCELERATING. AT THIS POINT I TURNED OFF THE IGNITION BUT THAT DID NO GOOD. ALL THE INSTRUMENTATION TURNED OFF BUT THE ENGINE WAS MAXED OUT AND WAS GOING BERSERK. I HAD A CLUTCH SO I PUSHED IT INTO NEUTRAL BUT THE RPMS WENT TO THE 7,000S. WITH THE KEYS OFF, I PULLED OF THE INTERSTATE DESPERATELY TRYING TO SLOW DOWN THE RPMS BUT NOTHING WORKED. I FINALLY PUT IT INTO GEAR TO TRY AND STOP IT AND IT LITERALLY 'BLEW UP'. IT'S TOTALED. WHAT I WANT TO KNOW IS IF THIS HAS BEEN PREVIOUSLY REPORTED, IF THERE HAS BEEN ANY KIND OF RECALL ON THIS. VOLVO WOULDN'T ANSWER ANY OF MY QUESTIONS. IT WAS A GREAT CAR BUT IT WAS A VERY DANGEROUS SITUATION THAT I HAVEN'T BEEN ABLE TO GET ANY ANSWERS ABOUT. IT APPARENTLY WAS SOME KIND OF A COMPUTER MALFUNCTION AS A MECHANICAL FAILURE WOULD HAVE BEEN SOLVED BY TURNING THE KEY 'OFF'! I WANT TO LODGE A COMPLAINT BUT DON'T KNOW WHERE TO START.

TL* THE CONTACT OWNS A 1998 VOLVO V70. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, AN ABNORMAL SOUND WAS PRESENT COMING FROM THE REAR PASSENGER SIDE. WHILE INSPECTING THE VEHICLE IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE BRAKE ROTOR HAD CRACKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000. MA 10/25/15

PURCHASED THIS CAR THIS MONTH FOR MY SON FOR HIM TO COMMUTE TO SCHOOL. MY SON TOLD ME THAT THE SEAT MOVES TO DIFFERENT POSITION WHEN THE CAR HIT THE POT HOLE. IT IS VERY DANGEROUS IF THE DRIVER HAS SHORT LEGS. THERE IS PRESET POSITION FOR THE SEAT. NO SURE WHAT TO DO WITH THIS. *TR

AFTER FILLING FUEL TANK THE CHECK ENGINE LIGHT CAME ON AND THERE IS A VERY STRONG GASOLINE SMELL OUTSIDE THE CAR AND WHEN STOPPED INSIDE CAR. THE ENGINE CODE IS FOR A GROSS EVAP LEAK.I CAN SEE FUEL UNDER GAS TANK COMING FROM THE TOP OF THE TANK. I REMOVED FUEL PUMP ACCSESS DOOR AND CAN SEE FUEL BUBBLING OUT OF THE TOP OF THE FUEL PUMP AND OVERFLOWING THE AREA. THERE IS A VISABLE CRACK ON THE TOP OF THE PUMP. *TR

I JUST PURCHASED ABOUT 2 MONTHS AGO A 1998 VOLVO V70 USED ON 4/3/2014 FOR 3000.00 . THE VEHICLE DROVE JUST FINE UP UNTIL TWO WEEKS AGO WHERE THE TRANSMISSION SEEMS TO BE SLIPPING. WHILE I WAS RIDING ON I695 AND WAS GOING ABOUT SIXTY MILES PER HOUR WHEN THE CAR JERKED AND CUT OFF, MEANING BLINKING IN AND OUT OF THE ELECTRICAL SYSTEM ALONG WITH THE ENGINE AS I WAS PULLING OVER ON THE SHOULDER, WHICH IS TERRIBLY UNSAFE. I ASSUMED AND THOUGHT VOLVO'S WERE GREAT ON MILES AND TRANSMISSION SO I DIDN'T EXPECT IT TO BE HAVING THESE TYPE OF ISSUES. I AM A FIRST TIME VOLVO PURCHASER AND HIGHLY DISAPPOINTED AND IT'S TO EXPENSIVE FOR ALL THE HASSLES. ALL OF THE MINOR ISSUES WERE EXPECTED BECAUSE OF THE VEHICLE BEING A USED CAR. ALSO, I CANNOT EVEN CHECK THE TRANSMISSION FLUID LEVELS IN ORDER TO SEE IF ALL I NEED IS SOME TRANSMISSION FLUID, THE DIPSTICK THAT LEADS TO THE TRANSMISSION IS STUCK, AS IN I HAVE TRIED PULLING, TWISTING AND TURNING BUT TO NO AVAIL. AFTER PURCHASING A 300 DOLLAR KEY PAD FROM THE DEALER I EXPECT MORE FROM THE MANUAL AND AT LEAST TO BE ABLE TO CHECK ALL FLUIDS ON THE VEHICLE. IF THESE MINOR ISSUES DIDN'T EVOLVE INTO MAJOR ISSUES WITH MY VOLVO VEHICLE I WOULD NOT HAVE AN ISSUE. YET THE PROBLEM IS THAT THESE MINOR ISSUES ARE INDEED CAUSING MAJOR REPAIRS WHICH IS SIMPLY UNACCEPTABLE AND CAUSING UNSAFE DRIVING HAZARDOUS SITUATIONS THAT COULD INDEED AFFECT THE LIFE OF MYSELF AND OTHER DRIVERS. THANK YOU VERY MUCH FOR LISTEN AND HOPEFULLY DIRECTLY ADDRESSING MY CONCERNS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 12/8/2014 *JS

DRIVERS SIDE DOOR HINGE/STRAP FAILED CAUSING DOOR TO BREAK FROM FRAME AND BECOME DYSFUNCTIONAL. AS IT WORSENED OVER A FEW DAYS THE DOOR BECAME INCREASINGLY DIFFICULT TO OPEN WHERE IT BECAME A SAFETY CONCERN. VOLVO MECHANIC REFERRED TO AUTO METAL SERVICE SHOP WHICH REPLACED/REPAIRED DOOR STRAP AND WELDED DOOR BACK TO FRAME AND CONFIRMED THIS WAS A KNOWN "WORKMANSHIP" DEFECT WITH A NUMBER OF VOLVO MODELS AND YEARS. VOLVO N.A. WAS NOTIFIED OF THIS 9/13/13 AND WAS INTERESTED TO SEE THE REPAIR INVOICE, WHICH WAS PROVIDED TO THEM, BUT IN THE END THEY DECLINED TO REIMBURSE FOR THIS FLAW STATING THE CAR WAS NO LONGER COVERED BY A MANUFACTURER'S WARRANTY. WHEN THE DRIVERS SIDE DOOR BECOMES DYSFUNCTIONAL FROM FAULTY WORKMANSHIP THAT INDICATES A SAFETY ISSUE THAT THE MANUFACTURER SHOULD "MAN UP" AND REPAIR/RECALL OR REIMBURSE THE OWNER FOR, REGARDLESS IF THE VEHICLE IS NO LONGER UNDER MANUFACTURER'S WARRANTY. DOORS SHOULDN'T JUST BREAK OFF FROM THE FRAME UNDER NORMAL USE. THERE WAS NO CRASH OR ABUSE INVOLVED WITH THIS DOOR. IT JUST BROKE LIKE A CHEAP, INFERIOR PRODUCT. *TR

IGNITION KEY CYLINDER MALFUNCTIONING. INSERT KEY TO START CAR, KEY ROTATES 360 DEGREES WITHOUT ENGAGING. TAKES SEVERAL ATTEMPTS TO GET THE KEY TO NOT ROTATE AND ACTUALLY START THE CAR. I HAVE SPOKEN TO SEVERAL MECHANICS AND HAVE SEEN MULTIPLE THREADS ON FORUMS THAT THIS IS NOT AN UNCOMMON ISSUE WITH THESE CARS AND IT SEEMS TO BE SOMETHING THAT OCCURS AFTER 100,000 MILES. ESTIMATED COST OF REPAIR IS $600 - TO $800.

EXTERIOR LIGHTING: HEADLIGHTS GOING OUT WHILE DRIVING, BRAKE LIGHTS DO NOT WORK. FUSES ARE GOOD AND BULBS ARE GOOD AS WELL! BRAKES HAVEN'T WORKED SINCE THE DRIVE HOME HEADLIGHTS GO IN AND OUT. COULD RESULT IN AN ACCIDENT! *TR

TL* THE CONTACT OWNS A 1998 VOLVO V70. THE CONTACT STATED THE REAR SEAT BELT BECAME LODGED AND COULD NOT BE USED. THE CONTACT ATTEMPTED TO REPAIR THE FAILURE HIMSELF BUT WAS UNSUCCESSFUL. THE MANUFACTURER ADVISED THE VEHICLE WARRANTY WAS EXPIRED AND WOULD NOT OFFER ANY FURTHER ASSISTANCE. THE SEAT BELT REMAINED LODGED FOR OVER THREE MONTHS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 139,000 AND THE CURRENT MILEAGE WAS 143,000.

TL* THE CONTACT OWNS A 1998 VOLVO CROSS COUNTRY V70. TWICE WITHIN THE YEAR, THE RACK AND PINION HAD TO BE REPAIRED. AFTER THE FIRST REPAIR THE STEERING COLUMN CONTINUED TO LOCK WHILE DRIVING. THE FIRST REPAIR COST $1000.00. THE SECOND REPAIR WAS PERFORMED AT AN EXPENSE OF $14000.00. THE FAILURE MILEAGE WAS 100000 . THE CURRENT MILEAGE WAS 115000.

WE HAD TONS OF PROBLEMS WITH THE CAR IMMED. AFTER PURCHASE-CHECK ENGINE LIGHT WAS ALWAYS COMING ON,CAR STALLING,LIGHT COMING ON DASHBOARD,CAR NOISES, ENGINE LEAKS. THE CAR COULD NOT BE FIXED BY CARMAX AS FAR AS CHECK ENGINE LIGHT IS CONCERNED SO WE BROUGHT THE CAR TO A VOLVO DEALER. CHECK ENGINE LIGHT WAS REPAIRED NUMEROUS TIMES YET STILL CAME BACK ON. I NEVER GOT ANY RECALL LETTERS CONCERNING FRONTAL AIRBAG ISSUES IN 1998 VOLVO. I ALWAYS HAD A FEAR THAT ALL OF THE ELECTRICAL PROBLEMS-DASHBOARD LIGHTS,CHECK ENGINE LIGHT-WOULD RESULT IN A SAFETY PROBLEM. I WANT TO KNOW IF THE AIRBAGS WERE CONNECTED AND IF THE CAR HAD PREVIOUSLY BEEN IN A WRECK. DID CARMAX CHECK TO SEE IF THE SRS SYSTEM WAS WORKING?*TR

TIRES HAVE NOT FAILED. SIDEWALL CRACKS/DETERIORATION NOTICED DURING ROUTINE STOP FOR GAS. I PLAN TO REPLACE ALL 4 TIRES IMMEDIATELY. *TR

TL*THE CONTACT OWNS A 1998 VOLVO V70. WHILE DRIVING BETWEEN 35-40 MPH, THE CONTACT ATTEMPTED TO MAKE A LEFT TURN AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. BOTH VEHICLES SUSTAINED FRONT END DAMAGE AND WERE TOWED. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 60,000. UPDATED 03/06/08. *LJ

TL*THE CONTACT OWNS A 1998 VOLVO V70. WHILE DRIVING BETWEEN 10-60 MPH, THE ENGINE REVVED. THE VEHICLE SHOOK AND THE BRAKES MADE A GRINDING NOISE, ALTHOUGH THEY WERE NOT APPLIED. THE ABS WARNING INDICATOR LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE STOPPED NORMALLY. THE ABS CONTROL UNIT (PART NUMBER 860266) WAS REPLACED. THE FAILURE CEASED FOR 30,000 MILES BEFORE IT RECURRED. THE FAILURE MILEAGE WAS 22,000 AND CURRENT MILEAGE WAS 105,000.

TL*THE CONTACT OWNS A 1998 VOLVO V70. THE CONTACT STATED THAT THE SIDEWALL ON ONE OF HIS SUMITOMO TIRES COMPLETELY FAILED WHILE DRIVING 50 MPH. THE CONTACT WAS UNSURE OF THE DOT NUMBER. THE CURRENT AND FAILURE MILEAGES WERE 124,000. THE TIRE INFORMATION WAS UNAVAILABLE.

ABS / TRAC LIGHTS INTERMITTENT FAILURE, CAUSING OCCASIONAL LOSS OF BRAKING FOR 1-2 SECONDS. *JB

THE ABS / TRACTION CONTROL UNIT ON THESE CARS FAIL IN UNREASONABLY HIGH NUMBERS. IT'S SUCH A BIG BUSINESS, THAT MECHANICS SELL THOUSANDS OF REFURBISHED UNITS ON EBAY. VOLVO CHARGES OVER $700 FOR THE PARTS, AND IS AVOIDING REPAIRING THIS ITEM BECAUSE I'M SURE SOME ACTUARY TOLD THEM IT'S CHEAPER TO PAY CLAIMS AND DEFEND LAWSUITS THAN TO PROTECT THEIR CUSTOMERS. I HAVE NOT EXPERIENCED AN ACCIDENT OR CRASH AS A RESULT, BUT I'M SURE HUNDREDS OF PEOPLE HAVE. *NM

THE HEADLIGHT SWITCH MALFUNCTIONED. *NM

DT*: THE CONTACT STATED WHILE PARKED IN THE DRIVEWAY FOR ONE DAY, SMOKE WAS NOTICED COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE WIRING HARNESS CAUSED THE FIRE. THE WIRING HARNESS WAS REPLACED. THE DEALER WAS NOT NOTIFIED. UPDATED 10/18/2006 - THE VEHICLE WAS LAST DRIVEN ABOUT 14 HOURS PRIOR TO THE VEHICLE CATCHING ON FIRE. THE SERVICE DEALER REPLACED THE HARNESS TO THE ABS CONTROL UNIT. *NM

DT*: THE CONTACT STATED THE PADS AND CALIPERS CAME INTO CONTACT WITH THE ROTORS. THE REAR PADS, ROTORS AND CALIPERS WERE REPLACED THREE TIMES. THE FRONT PADS, ROTORS AND CALIPERS WERE REPLACED TWICE. PRIOR TO EACH REPLACEMENT, THE BRAKES MADE A LOUD SQUEAKING SOUND AND THE FRONT AND REAR END SHOOK WHEN THE BRAKES WERE APPLIED. CURRENTLY THE BRAKES MADE A LOUD SQUEAKING NOISE AND THE FRONT END SHOOK WHEN THE BRAKES WERE APPLIED. THE DEALERSHIP WAS NOTIFIED.

THE FUEL TANK ON MY 1998 VOLVO V70 HAS FAILED. THE CHECK ENGINE LIGHT CAME ON IN MY CAR ABOUT 6 MONTHS AGO. AFTER REPLACING ALMOST MY ENTIRE FUEL EVAP SYSTEM, VOLVO DETERMINED MY FUEL TANK HAD A LEAK. I REQUESTED THAT VOLVO REPLACE MY FUEL TANK AT THEIR EXPENSE, BECAUSE I FEEL THAT A FUEL TANK SHOULD BE EXPECTED TO LAST MORE THAN 8 YEARS. VOLVO HAS REFUSED TO RECALL THE TANK AND HAS ABSOLVED THEMSELVES OF ANY RESPONSIBILITY FOR THE FAILURE. *NM

DT*: THE CONTACT STATED WHILE DRIVING 20 MPH THE REAR HATCHBACK OPENED WITHOUT WARNING DUMPING THE CARGO ONTO THE HIGHWAY. A CRASH WAS AVOIDED AND THE POLICE WERE NOT CONTACTED. THE VEHICLE WAS SEEN BY A DEALER WHO DETERMINED THE HATCHBACK LOCK WAS INOPERABLE AND NEEDED TO BE REPLACED. THE HATCHBACK LOCK WAS REPLACED ONCE BEFORE DUE TO A SIMILAR INCIDENT. UPDATED 05/04/06. *JB

THE TIMING BELT HOLDER BROKE ON MY 1998 VOLVO WHILE ON DRIVING ON US ROUTE 40 IN CHAPEL HILL NORTH CAROLINA. THIS CAUSED A COMPLETE LOSS OF ACCELERATION. FORTUNATELY WE WERE IN THE RIGHT LANE AND WERE ABLE TO PULL OFF THE ROAD. *JB

AUTOMOBILE: VOLVO V70 WAGON 1998 ON THE DRIVER'S SIDE DOOR, THERE IS A SWING ARM THAT ATTACHES TO THE DOOR AND THE CAR FRAME. ITS PURPOSE APPEARS TO STOP THE DOOR FROM HYPER EXTENDING. THE SWING ARM ATTACHES TO CAR FRAME VIA A BRACKET. THIS BRACKET IS WELDED ON THE FRAME. IN MY CASE THE BRACKET CAME UNWELDED AND ON THE FORWARD SIDE OF THE ATTACHED AREA, PUNCHED THREW THE FRAME COLUMN. ON THE REAR SIDE OF THE BRACKET, IT REMAINS WELDED TO THE CAR FRAME. IT IS NOT CLEAR TO ME WHETHER IT HAS WEAKENED THE FRAME COLUMN THAT RUNS FROM THE FLOOR TO THE ROOF. THE DAMAGE WAS DUE TO NORMAL OPENING AND CLOSING THE DOOR AND WOULD APPEAR TO BE DUE TO METAL FATIGUE. UPON VISITING A FEW BODY SHOPS IN THE SAN FRANCISCO AREA, SOME HAD TOLD ME THAT THIS IS A WIDE SPREAD PROBLEM WITH VOLVO. ALSO, UPON SEARCHING ON THE INTERNET FOR OTHER PEOPLE WHO MAY HAVE HAD THIS PROBLEM, THERE WERE NUMEROUS. HENCE, THE REASON FOR MY COMPLAINT. THE BODY SHOP INFORMED ME THAT THEY WOULD NEED TO REPLACE THE METAL COLUMN THAT RUNS FROM THE FLOOR OF THE CAR PAST THE WHERE THE DOOR ATTACHES TO THE FRAME AND ENDS IN PROXIMITY OF THE FRONT WINDOW SHIELD. SINCE THE COST WILL BE APPROXIMATELY $2,400 AND THE CAR IS A 98, I HAVE NOT DECIDED IF I WILL GET IT REPAIRED. TO INSTALL THIS METAL COLUMN, THE DASH PANEL WOULD NEED TO BE REMOVED. *JB

MY CAR IS A 1998 VOLVO V70 T5 WITH 75,000 MILES ON THE ODOMETER. AT ABOUT 7PM ON DECEMBER 28TH, 2005, I MOVED THE CAR FROM MY DRIVEWAY OUT ONTO THE STREET IN FRONT OF MY HOUSE, IN ORDER TO ALLOW A SECOND TANDEM-PARKED CAR OUT. THE VOLVO REMAINED PARKED ON THE STREET, DOORS LOCKED AND WINDOWS UP, UNTIL ABOUT 10PM. AT 10PM I WENT TO MOVE IT BACK INTO THE DRIVEWAY, ONLY TO DISCOVER THAT THE INTERIOR HAD CAUGHT FIRE - THE FIRE WAS NO LONGER BURNING. THE PASSENGER SEAT WAS BURNT DOWN TO THE FRAME, AND SOME OF THE SURROUNDING TRIM ON THE DOOR, DASH AND CENTER CONSOLE WAS BURNED AND MELTED. THE REST OF THE INTERIOR WAS NOT BURNED BUT WAS COVERED WITH SOOT. MY INSURANCE COMPANY - COMMERCE INSURANCE OF MASSACHUSETTS - APPRAISED THE CAR AND DECLARED IT TO BE A TOTAL LOSS. I CAN'T SAY CONCLUSIVELY, BUT, IT APPEARS TO ME THAT THE PASSENGER SIDE SEAT HEATER WAS THE CAUSE OF THE FIRE. I NOTE THAT FOR MODEL YEARS 1996 AND 1997 THERE WAS A RECALL AGAINST VOLVO 850 SEAT HEATERS RELATED TO A FIRE HAZARD, BUT THIS RECALL DOES NOT APPLY TO 1998 MODELS. PERHAPS THE RECALL SHOULD BE EXTENDED TO LATER MODELS. *NM

VOLVO V70 1998 - FIRE IN ENGINE COMPARTMENT - CAR DESTROYED DURING ROUTINE DRIVING, ENGINE STOPS. DRIVER NOTICES SMOKE COMING FROM ENGINE COMPARTMENT AND ELECTRICAL SYSTEMS (LIGHTS) BLINKING. IN A FEW MINUTES THE CAR IS TOTALLY DESTROYED BY FIRE. WHEN I VISITED THE WRECKER'S YARD I FOUND A VOLVO 850 WAGON THAT WAS DESTROYED BY FIRE IN THE SAME WAY! *NM

MY WIFE WAS DRIVING ABOUT 30 MPH ON A LOCAL STREET WHEN SHE FELT A PULL WHEN TURNING LEFT THEN SHE HEARD AND FELT A SOUND LIKE THE MUFFLER WAS FALLING OFF AND HEARD A GRINDING NOISE COMING FROM THE FRONT WHEELS. SHE IMMEDIATELY TURNED INTO A SHOPPING PLAZA AND SHUT OFF THE CAR. WHAT WE FOUND WAS THAT THE AXLE NUT AND PART OF THE AXLE HAD BROKEN OFF AND FALLEN OUT OF THE RIGHT FRONT REAR WHEEL. THE WHEEL COULD HAVE POTENTIALLY FALLEN OFF AND LUCKILY SHE WAS NOT ON A HIGHWAY MOVING FAST. THE VOLVO DEALER BELIEVES THAT THE CV JOINT FOR SOME REASON (WHICH HAVE NOT YET EXPLAINED) SEIZED AND CAUSED THE AXLE TO BREAK. THE DEALER RECOMMENDS REPLACING THE CV JOINT AND BEARING AND THE AXLE. THE ROTOR WAS ALSO IRREPARABLY DAMAGED AND NEEDS TO BE REPLACED. I WILL KEEP THE OLD PARTS. *NM

IN LATE FEBRUARY 2005, MY WIFE NOTICED THAT THE CHILD SEATS IN OUR 1998 VOLVO V70 WOULD LOOSEN UP WHEN OUR CHILDREN WOULD GET IN OR MOVE IN THEIR SEATS. THESE CHILD SEATS WERE OF THE STATIONARY TYPE AND OF DIFFERENT MAKES. AS ONE OF THE REAR OUTBOARD SEAT BELTS HAD ALREADY BEEN REPLACED AT NO CHARGE FOR A SIMILAR CONCERN IN JUNE 2003, WE VISITED OUR REGIONAL VOLVO DEALERSHIP TO REPORT THE ISSUE. NEW BELT ASSEMBLIES WERE ORDERED AND ON MARCH 15TH OF THIS YEAR, BOTH OUTER REAR SEAT BELTS WERE REPLACED. THIS TIME, SINCE WE HAD TO PAY FOR THE REPAIR, I RETRIEVED THE FAILED PARTS. EXAMINATION OF BOTH SEAT BELTS BUCKLES SEEM TO SUGGEST THAT THE FAILURE OF THE BELTS' CHILD SEAT LOCKING TAB, WHICH IS PART OF THE BUCKLE, PREVENTED THE CHILD SEAT FROM STAYING SECURELY HELD IN POSITION. THESE ASSEMBLIES ARE AVAILABLE FOR YOU TO ANALYZE AND DRAW AN EXPERT CONCLUSION. WE REQUESTED A REVIEW OF THE PROBLEM BY THE DISTRICT SERVICE MANAGER AND FILED AN E-MAIL COMPLAINT WITH VOLVO'S CUSTOMER ASSISTANCE CENTER. THE VIN OF THE CAR IS [XXX]. *NM UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DT: VEHICLE STALLED/DIED, AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK

STALLING AND CHECK ENGINE LIGHT. STALLING AT NORMAL OPERATING SPEED WITH RESULTING LOSS OF POWER, STEERING AND BRAKES. THE MASS AIR SENSOR AND INTAKE HOSE WERE REPLACED. *JB

VEHICLE RANDOMLY SHUTS OFF WHILE DRIVING. ENGINE SHUT-DOWN WITH LOSS OF POWER STEERING CONTROL. DISABLED VEHICLE WITH GROCERIES AND SMALL CHILDREN INSIDE ON A 90+ DEGREE (VERY HOT!!)AFTERNOON IN MID-JULY. $322 FOR REPLACEMENT OF AIR FLOW DEVICE (METER OR SENSOR?) TO CORRECT PROBLEM. APPROX. $50, LOSS OF PERISHABLE FOOD. *JB

1998 VOLVO V70A EXPERIENCED PROBLEMS WITH THE DRIVERS SIDE SHOULDER HARNESS. *MR THE SHOULDER HARNESS WAS FRAYED. ONE WOULD HAVE TO PULL THE SEAT BELT TO UNLOCK AND THEN PULL IT DOWN WHICH CAUSED IT TO WEAR. *SC *JB

THE CAMSHAFT BELT TENSIONER BROKE WHICH CAUSED THE BELT TO COME OFF AND THE VEHICLE TO LOST POWER WHILE DRIVING 70 MPH. THE OWNER HAS CONTACTED THE MANUFACTURER WHO REFUSED TO DO ANYTHING ABOUT THIS. *JB TIMING BELT TENSIONER, BELT AND VALVES AND HEAD GASKET NEEDED TO BE REPLACED. *TT

THE ABS SYSTEM FAILED DURING A PANIC STOP, CAUSING THE BRAKES TO LOCK UP AND THE CAR TO SKID UNCONTROLLABLY INTO THE MIDDLE OF AN INTERSECTION. FORTUNATELY IT DID NOT RESULT IN ANY SIGNIFICANT DAMAGE. *AK THERE HAD BEEN NO INDICATION OF A PROBLEM PRIOR TO THE INCIDENT AND THE ABS LIGHT WAS ON AFTER THE INCIDENT AND HAD NOT BEEN ON PREVIOUSLY. THE PROBLEM WAS REPAIRED BY REPLACING THE ABS CONTROL MODULE. UPON DISCUSSIONS WITH THE TECHNICIAN, IT WAS CLEAR THAT THIS IS A VERY COMMON FAILURE WITH THESE MODELS AND IT LEAVES THE THE ABS SYSTEM COMPLETELY DISABLED WHEN IT OCCURS. AS MY INCIDENT SHOWS, THIS FAILURE CAN OCCUR WITHOUT WARNING AND CAUSE A VERY DANGEROUS SITUATION WHERE THE DRIVER IS RELYING ON THE ABS SYSTEM AND INSTEAD HAS THE BRAKES LOCK UP CAUSING AN UNCONTROLLABLE SKID. IN ADDITION TO THIS INCIDENT, THE TECHNICIAN ALSO TOLD ME THAT THE MODULE HAD ALREADY FAILED AND BEEN REPLACED PREVIOUSLY AT 31K MILES. THIS APPEARS TO BE A DEFECT THAT IS VERY COMMON AND WILL CAUSE UNSUSPECTING DRIVERS TO SUDDENLY LOSE CONTROL OF THEIR VEHICLES IN A PANIC STOP SITUATION.

AT ONLY 70,000 MILES MY ABS UNIT FAILED AND HAD TO BE REPLACED. THIS IS SUCH A COMMON PROBLEM THAT THE DEALER AGREED TO PAY HALF. VOLVO SHOULD REPLACE THIS CRITICAL SAFETY COMPONET ON EVERY VEHICLE AT THEIR EXPENSE. *JB

FRONT PASSENGER'S SIDE SEAT BELT RETRACTOR BROKE. MANUFACTURER REFUSED TO REPLACE IT. *AK *SC

CONSUMER STATED VEHICLE EXPERIENCED THE SAME PROBLEM AS STATED IN RECALL 99V235000. TOOK VEHICLE INTO THE DEALER FOR REPAIRS,. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

THE CONSUMER'S VEHICLE WAS TESTED AND FOUND TO HAVE HIGH LEVELS OF CARBON MONOXIDE. *NM BLACK SMOKE WAS BELCHING OUT OF THE EXHAUST PIPE. *SC THE TRANSMISSION FAILED. *JB