Volkswagen Golf SportWagen 2016 — Problemas relatados

SRS/airbag warning light illuminated. A diagnostic scan (VCDS) confirmed stored fault codes for both front airbag crash sensors: driver's side 'short to ground' and passenger's side 'open or short to plus.' Upon further inspection, water was found pooled at the airbag control module connector, located under the center dash. The AC condensate drain line is routed directly above this module, and appears to be the source of the water intrusion — water drained from the connector itself when disconnected, and dampness was present at both the upper and lower AC drain hose connections near the module. After drying and reconnecting all components, an attempt was made to clear the fault codes via VCDS. The airbag module returned a 'not acknowledged' response to the clear command, indicating the fault condition and/or internal component damage may still be present. This vehicle's VIN was checked against active airbag recalls for this model year and found not to be included. However, given the safety-critical nature of the SRS system and the apparent design proximity of the AC drain to the airbag module connector, this may represent a broader risk for this chassis. Multiple independent repair shops declined to service this issue, citing liability concerns related to airbag system water intrusion. Volkswagen customer service denied a goodwill repair request, citing vehicle age/mileage without reviewing supporting documentation (VCDS diagnostic report and photos).

I am reporting a severe safety system failure regarding the airbag deployment force on a 2016 Volkswagen Golf SE. The vehicle was involved in a collision where the frontal/side air bag safety systems engaged. While the impact speed was moderate, the airbag deployment was violently disproportionate, resulting in severe, direct injuries to the occupant rather than providing the intended safety cushioning or protection. The force of the deployment appeared heavily uncalibrated, acting as a primary source of trauma rather than an emergency restraint. In contrast, the secondary vehicle involved in the identical impact matrix sustained similar property damage but experienced a completely stable, non-injurious environment with no air bag enaged at all. I am requesting that NHTSA review this incident against existing vehicle data logs for 2016 Volkswagen Golf models to determine if there is an active trend of excessive pyrotechnic deployment force or uncalibrated SRS module sensors.

Junction between thermostat and water pump failed leading to total loss of coolant. At the time I was driving north on I-75 in heavy morning traffic at 65 MPH. I was able to steer the vehicle off the road without hitting anyone or coming to a complete stop. Had the vehicle towed to Jim Ellis VW of Kennesaw where they diagnosed the problem and replaced the water pump. The car had 18,762 miles on it at the time. Mechanic stated that the problem was oil from cam covers leaking onto water pump and was frequently seen. Vehicle had low coolant warning lights twice and I added several ounces of distilled water each time. Car had an engine warning light and was being taken to dealer for service that day. When the incident happened, there was an audible alarm for loss of coolant and a flashing yellow light on the dashboard. The car had been serviced and inspected at the dealership annually, there had been no reports of leaking oil from cam covers. There was no indication the water pump would catastrophically fail. The waterpump should not fail with this few miles on it. .

The fuel pump on my 2016 Volkswagen Golf SportWagen failed approximately three months after a safety recall repair for the suction jet pump (recall 20Y6). My independent mechanic explained that failure of the suction jet pump can cause fuel leakage or vapor transfer into the EVAP system, which may create pressure or vacuum imbalance inside the fuel tank. This can potentially damage other fuel-system components, including the fuel pump. My vehicle had no prior fuel-system issues. After the recall repair, the vehicle began experiencing symptoms consistent with fuel delivery problems, and the fuel pump ultimately failed. The mechanic who performed the repair noted that the failure was “highly likely related” to the suction-jet-pump defect because of the short time between the recall repair and the component failure. Volkswagen’s customer-service team stated that the fuel pump and suction jet pump are “unrelated,” but did not provide a technical explanation for that conclusion. Because both components interact within the sealed fuel/EVAP system, I am concerned that the recall defect or repair may have contributed to the fuel-pump failure. This problem may indicate a pattern of post-recall fuel-system failures involving suction-jet-pump malfunction, tank pressure changes, or collateral damage to in-tank components. I am submitting this report so NHTSA can review whether similar issues are occurring in other vehicles.

Component: Sunroof / Roof Assembly - Water Ingress Make / Model / Year: 2016 Volkswagen Golf SportWagen VIN: [XXX] Mileage: ~40,000 Sunroof leaks water while closed and glass intact. First replacement frame arrived damaged. Repair extended into second week. Known manufacturer defect (VW bulletin MC-10241196-0001). Volkswagen denied reimbursement based on time expiration despite incredibly low mileage ~40,000. Effect: Interior damage to headliner/carpets, possible electrical damage, disruption of daily use. Requested Action: Document for safety/recall investigation; use data to support future recall or enforcement action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The EPC light has luminated 3 times in the last several months. The vehicle stutters and will not accelerate past 25 MPH. Shutting off the engine and restarting it clears the light and vehicle drives normally. The check engine light does not illuminate and no OBDII codes are stored. Manual states to take vehicle to authorized dealership for diagnosis if light stays illuminated.

My car started smelling like gas 10 days ago. There was no visible leak. We took it to the shop still can’t figure out the issues. Took it to pick up my son from school, it started leaking fuel (I had 1/4 of a tank left). I turned off the car and it stopped leaking fuel. Needing a fix quick, I then drove 4 miles to get to the shop. Before I started driving I checked and it said I had enough gas to drive 15 miles. However, while at a stop light, the car shuddered and completely died. We then had it towed to the shop and hour away. The dealership had had it since then and found that it was related to the fuel pump suction recall. However, because the problem has gotten so bad, I now need a new fuel tank. Because it will in fact continue to keep leaking fuel and no matter how much gas you put it will just leak out. This is a safety hazard not only for me as a driver but also to other drivers. After diagnosing the problem, the dealership called VW corporate to inquire whether they will cover the fix since the recall was what caused the issue. 10 days later, VW is still looking into it, and I’ve now spent over $1500 on a rental car and towing fees. This car was completely unsafe to drive. And it is completely irresponsible for VW to allow customers to drive an unsafe vehicle and make us pay for repairs for issues that we didn’t cause.

I was driving my vehicle on the highway when a driver stopped me and warned me that my vehicle was leaking a huge amount of gasoline. I had a technician inspect the car to see if it might be a fuel line, the technician told me the fuel.lines were good and there were no signs of the gas coming from the lines and no cracks on the tank either. I received a letter from Volkswagen about the recall and I researched it and it says that if that is the problem the car would be leaking gas and it was dangerous as an ignition might cause a fire. I towed my vehicle to the Volkswagen here in Laredo after calling and speaking to someone from service and told yes I could bring it in and the recall part would be replaced free but I would have to leave the vehicle there. When I arrived they told me I would have to pay a diagnostic of 185 dlls and the repair. Which was not what I was told when I called earlier. So I had to pay again to have the vehicle removed from the premises without having the recall part changed.

Car began spraying fuel upon turning the key in the ignition. Recall work pertaining to the suction jet pump was recently performed and is the only likely cause of this issue. Car did not leak when fuel pump was disengaged. Very lucky that issue occurred in a parking lot while not moving and did not lead to a fire or crash.

My EPC light began to appear randomly in early 2024. I received a recall notice on the gear shift trim around the same time, so called Jack Ingram VW in Montgomery to schedule a time for them to fix it (and also ensure they had the part). I asked them to also check on why the EPC light was coming on. Brought in my car on 2/28/24. Service Dept then tells me they weren't sure what was causing the EPC light to come on, and they didn't have the gear shift trim part. They quoted me a lot of work to do, which I wasn't prepared financially to have completed. EPC light continued to appear at random. Each time it did, my car would shake and it would feel like I was losing control of the vehicle. I received another recall notice for the suction jet pump inside the fuel tank. When I called Jack Ingram VW to schedule this work, I asked if this had anything to do with my EPC light coming on. They weren't sure. The recall work for both the suction jet pump inside the fuel tank and the gear shift trim were completed on 8/28/24. Car worked fine until about a month later and the EPC light came on again. Called another VW mechanic in Montgomery (Powell's Automotive) to see if they can fix it. On 9/20/24 they replaced battery, spark plugs, ignition coil, and did an oil change. Worked great until [XXX] when my engine failed and left me stranded in the road. There were no warning lights prior to the engine failing. Could not restart car. Had it towed to Powell's who could not fix it, then to Jack Ingram VW. I asked them if this had anything to do with the recall work that was done. They said this would be the first if it was. They told me the in tank fuel pump needed replacing. Work completed 10/25/24. How can they work on the suction jet pump inside the fuel tank and not get a diagnostic that the in tank fuel pump was failing? I've already paid a lot of money to try to resolve the issue, and my EPC light is still coming on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VW USA is offering no help in getting our recall work done. Their only suggestion is for us to work with our shipper. Our car is located in Italy because we are an active duty family stationed under orders at naval air station Sigonella. Our shipper has contacted VW Italy, and they refuse to help. The shipper also notes that they can’t ship the car anywhere anyways because the recall has to do with the fuel system. In effect, our car is now trapped in Italy, unable to be shipped off the continent. Perhaps NHTSA could persuade VW USA to perform our recall work here in Italy?

See attached document for complaint.

The contact owns a 2016 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while starting the vehicle, there was an abnormally strong fuel odor inside the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the fuel tank suction jet pump had failed, causing damage to the fuel tank. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 36,018. VIN tool confirms parts not available.

The contact owns a 2016 Volkswagen Golf. The contact stated there was fuel leaking from the charcoal canister. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.

We are unable to fill up the gas tank due the recall issue. The dealership says we can bring it in and they will repair but at this time we would have to pay for the repair. VW has not come up with a fix for the recall problem at this time. This problem has rendered our vehicle not drivable. What is the recourse? Fuel also leaks out when trying to fill the gas tank. It could start a fire.

It has been 3 months since the issue below was reported (per NHTSA) and no repair is available. I called and asked what I can do in the meantime to ensure safety of me and my 6 year old and was not provided with any information. Feb 14,2024 Manufacturer Recall Number20UF NHTSA Recall Number24V110 Recall StatusRecall Incomplete, remedy not yet available Summary The suction jet pump inside the fuel tank is designed to purge fuel from the Evaporative Emissions (EVAP) system. If a specific seal inside an affected suction jet pump fails, the fuel may flow directly into the EVAP system. If this happens, fuel could accumulate in the EVAP system and may leak through the charcoal canister filter element. Leaking fuel, in the presence of an ignition source, may result in a fire. Safety Risk Leaking fuel, in the presence of an ignition source, may result in a fire. Remedy REPAIR NOT YET AVAILABLE Manufacturer's Notes If you should have any questions, please contact Volkswagen using your preferred method of communication at www.vw.com/contact or by calling 800-893-5298.

My vehicle is leaking fuel. I have been unable to drive it for a few weeks due to the recall not having an approved repair. The dealership did not offer me any solution other than to pay for the repair out of pocket. This has been a known issue since February and no remedy is available from Volkswagen.

Despite settling a class action lawsuit re: moonroof leakage, VW refuses to cover the same repair for my VW Golf Sportwagen. I have the same issue but could not participate in the class action suit due to mileage. I routinely have to bail 1/2 - 1 gallon of water out the spare tire area if its been raining. Water now also collects in the footwell behind the driver's seat/in front of my child's seat. The bolts affixing the seatbelts to the floor are rusted and there is mold under the carpet. The car now has electrical issues, including the alarm no longer sounding when I am reversing and someone is approaching in my blind spot. In addition, when the weather has been wet, the back up camera does not work and, mid trip, the car alarms sound, indicating the car must be serviced and the brakes and airbags are not working. These problems disappear after a few days of dry weather.

When refueling, the gasoline spills out and can't fill the tank. Took the car to the dealer and they are asking for 2,500$ for repair.

I have had this car since 2021, when I first bought it they had to keep it for another week due to a coolant break error? Had to fix it but later on I had to put tons of money into the car almost more money than it’s worth. And I’ve had a engine light on religiously for the entirety of the car, however my cars engine lights flash at times when I am driving and it gets hard to accelerate and reeks of gas- I’ve given up on dealerships because they have done everything else but what I have asked them to do and I still leave and the engine light turns on after. I did some research and learned my car has a recall since 2/14/2024 and I’ve had no update on my vehicles recall or if it’s repairable. My car will refuse to start at times and I’ve told this dealership this car will most likely kill me since I’ve put so much money into it for nothing to be fixed? And if it’s been this recall error what do I do? Please help me bought from Allen web Mitsubishi. All the symptoms are there but I’m scared

Performed NH Safety Inspection. Found upon Inspection Left Rear, Driver Side, Coil Spring has failed. Broken. This will make over Ten VW or Audi vehicles we have seen in the last year with this problem.

Clockspring failure. VW does not cover this critical safety part under warranty. Air bag is non functional (air bag light on) horn is non functional. Other controls on steering wheel not functional.

My VW golf has experienced rear door lock issues where both rear dock locks no longer work (lock or unlock) when pressing the lock button on the key or inside the vehicle. The only way to get the doors to lock is by manually locking the doors via a little slot in the door sill on each side. While it can be unlocked internally by just pulling the handle one time. This is a safety issue as door locks are a necessity for a vehicle to prevent theft of vehicle or items inside. It can also cause safety concerns for passengers in the rear(which is usually children. This also poses a danger to children due to the ease of unlocking from inside the rear passenger seats. The problem was confirmed to be the rear door latches via a dealer on 2/23/2024, however after replacing both latches with new parts, nothing was resolved. This issue is not the first time, as it is known that VW locks and many electrical components may randomly stop working, I have experienced the issue with a previous Volkswagen vehicle as well (2009 VW Jetta). There are no warning lights on the dashboard or other signs of the failure.

The contact owns a 2016 Volkswagen Golf. The contact stated while driving approximately 35 MPH, there was an abnormally strong gasoline odor in the cabin of the vehicle. The contact drove to the residence and became aware that there was a puddle of gasoline under the passenger’s side rear wheel nearby the fuel tank. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 41,000.

I have a leak in my trunk from water leaking from my pressure valve in the rear of my car. Found that this is a common issue with my car. The seal around the pressure valve doesn't prevent water from entering into the trunk of my car. I got a flat tire on the highway and opened the hatch to get my spare and there was water flooded there and it rusted my spare tools. I could not put on my spare tire.

GFF TEST PLAN ON STORED ENGINE LIGHT. RECOMMEND REPLACING THERMOSTAT HOUSING CAUSING THE CHECK ENGINE LIGHT. RECOMMNED REPLACE THERMOSTAT HOUSING. SEEP/SLIGHT COOLING LEAK. ADVISED TO WATCH COOLANT LEVELS UNTIL FIXED.

After parking car and turning off engine, I exited vehicle and noticed a cascade of fuel falling to the pavement by the rear wheel near the fuel tank. Fire Department was called as I was in a public parking lot. Vehicle was towed to dealer.

The contact owns a 2016 Volkswagen Golf Sportwagen. The contact stated while driving at high speeds, the vehicle started to shake abnormally. No warning lights were illuminated. The vehicle was taken to an auto body shop where it was diagnosed and determined that the rear axle coil springs had fractured and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 135,000.

aftermarket/replacement rim purchased from CAR-ID in May 2023 and installed on vehicle in May 2023. On September 15, 2023, wheel/rim suffered a total and catastrophic failure. The wheel/rim face separated from the rest of the rim while driving.

The headlight assembly design, prevents owners from changing a light bulb own their own. Per the law, a car must have functioning headlights. The design on the HID headlight assembly, requires hours of work, removing the bumper, the grill, other parts that require many tools and skilled knowledge of the brand. Considering this is a headlight that is required to be street legal, an owner can't change the bulb in emergencies. An owner must wait for an appointment with a dealer or certified Volkswagen mechanic with the proper training to change a light bulb. Regulation should prevent such designs, as the current design can make it dangerous for the driver. Just as when a driver needs to change a tire that's flat, and use the spare, a light bulb is just as critical to prevent accidents.

The fuel system is completely shot, with fuel leaking from the gas tank after a ride once and pressure building up in the gas tank. Gas pumps click off after only putting one to two gallons in the tank, despite the tank being nearly empty. Mechanic replaced Evap canister and fuel suction pump, seemingly solving the problem temporarily only for them to resurface. Fuel leaking from the tank while driving severely risks my safety, as it is possible that pressure could cause the fuel to leak onto the engine, thus causing rapid combustion of the vehicle. The dealership has not assessed the problem, only a qualified mechanic has. It has not been inspected by manufacturer, police, insurance representatives, but has been inspected by a mechanic. No warning lights or messages have appeared in relation to this problem.

The rear coil spring fractured and caused a suspension issue. This is the same issue as reported in NHTSA campaign number: 19V188000 covering the same vehicles built a few months after mine. The vehcile is being repaired now and the issue has been confirmed. The component has been inspected by a service technician and the issue has been confirmed. Parts have been retained for evidence. There were no warnings, messages or symptoms. VW has been notified, but confirmed this is not their issue to fix. This issue should result in an extended recall to cover the same vehcile, just earlier models, so there are no resulting accidents, injuries, or deaths.

My vehicle is unable to fuel up, when attempting to fuel at the pump the fuel will build up in the filler neck causing the pump ti stop and fuel spill out from the filler neck and when driven, fuel will begin to leak from the EVAP canister located on the right rear of the vehicle. Dealership is unwilling to correct this issue as it is a known issue to them of the problem

Thermostat and Gasket repair quoted by VW dealership. The coolant is leaking according to their inspection. Car could malfunction unexpectedly and leave me stranded as a road hazard Many more claims in this thread. They quote $1,600 to repair. https://www.reddit.com/r/GolfGTI/comments/drna5m/mk775_thermostat_housing_issue_and_coolant_loss/

Car loses power due to clogged wastegate actuator and EPC light turns on and off. This has been confirmed by 2 different service centers. I have seen several cases of people saying they had the same problem which requires you to replace the entire turbo, which my car only has 67,000 miles. I have a 16 year old son who will drive my car and this could cause him an accident if he is not able to accelerate. This is clearly a faulty part as they've discontinued using the model of the original turbo.

May 27 and May 28: The car turned on the EPC and check engine lights while on parking mode and on. Started to loose power and didnt want to start again. Later on, the lights turned off and it started again. While trying to fill the fuel tank at the gasoline station it stopped and it was only half tank.(The system didnt allowed to continue). While driving in the highway, started to loose power and a strong smell of fuel was inside the car so the driver had to open all the windows to avoid an intoxication with emissions(as it seemed to be). When the driver got to the destination in the highway, near San Juan, the smell of fuel was so strong that had to turn off the car and call a tow truck because the return travel would be long and the smell of fuel was stronger… it seemed to be spilling fuel and it was not safe to drive the car back home. Tow truck carried the car home because the dealer was closed on Sunday. On monday 29, the car was towed again but from home to the Flagship dealer in Ponce, PR. In the dealer they say it doesnt “have anything” . It seems they didnt care about the hazzards being discussed. The dealer returned our car and insisted there wasnt a recall or issue to attend. As soon as the dealer returned the car we drove home and the fuel odor or emissions were perceived inmediately inside the car. The car was stopped at home and a fuel leak was visible on the road. We need help inmediately. It is a matter of safety and risks. Please advice us and help with this issue. It is my only car.

Dealer found thermostat housing leak and recommended housing and pump replacement at a cost of over $2K. Thermostat is housing leak could cause loss of coolant which could strand you in the middle of the road. There were no warning lamps active. This appears to be a common issue with these vehicles. The thermostat should not be having problems like this at this mileage. The component has not been inspected by insurance, manufacturer, or police, only the dealer.

The EPC light has been continuously coming on for almost a year. It has been taken to the dealership 5 times and they cannot fix it or find the cause of it. At times when driving it enters "limp mode". Other times it has acted like it was overheating. And twice it has completely shut down. The vehicle is now out of warranty and no fix has been put in place. The EPC light will still randomly come on. VW has not addressed or come up with cause for this very common issue on their vehicles.

Airbag light came on, then all electrics to steering wheel failed, including the horn. Clock spring failed. Safety issue with no airbag and no horn. Known that VWs have a problem with clock spring failure. Should be a recall.

Both rear coil springs broken

Fuel was found to be leaking from the rear passenger side wheel well. A secondary flame source could cause a significant fire risk. Issue is being investigated by local VW dealer. There are no warning lamps or messages prior to the failure. Dealer recommends a replacement of the charcoal filter and N80 valve in order to have the ability to test the fuel pressure and fuel pump. My particular VIN number is not part of an existing recall on the fuel pump where fuel leak, bad charcoal canister, and N80 valve are symptomatic (secondary failures) of a bad fuel pump (primary failure). I question if the parts under the existing recall should be expanded to include a larger population.

While driving down the highway around 60 mph, nowhere near any other vehicles or pedestrians, the sunroof spontaneously shattered. The break goes outward/upward from the cabin.

Sunroof Frame Cracked. Leaky sunroof. Drains are cleaned. A pillars get wet where airbags and wiring are located. Could cause a short.

While accelerating from a traffic light, loud bang from left rear corner of car. Investigation found left rear coil spring had broken at the lower bas of the spring where it contacts the lower control arm

My driver seat belt comes unbuckled when i'm driving. It's intermittent and random, and i'm very careful to lock in the belt and i pull on it before i start driving to make sure it's locked in, and it still comes undone. I then have to relock it while i'm driving, which is distracting, as well as worrisome that i am without a seatbelt until i can lock it again, especially if i'm on the freeway. I've taken it to my mechanic who drove the car and said the same thing happened to him several times while he was driving.

The vehicle overheated during normal driving. The car advised the driver to stop immediately. The car was inspected later the same day by a VW dealer service department that determined the water pump and thermostat housing required replacement. Estimated cost is $1400.

The sunroof leaks water into the passenger side A pillar

The contact owns a 2016 Volkswagen Golf. The contact received notification of the NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact mentioned that a recall notice was received confirming the remedy was available and to contact a local dealer however, the dealer informed that the part was not available for the recall remedy. The manufacturer was notified of the issue and confirmed that parts were unavailable. The contact had not experienced a failure. Parts distributions disconnect.

Fuel leaking and pooling from the rear right tire well. Tire well saturated with fuel. Occurs after engine hesitation at high speeds, similar to running out of gas. Opening the gas cap causes some fuel splashing around the opening and gurgling and hissing sounds. Difficulty re-fueling after incident, gas pump keeps shutting off. Fuel siphon pump was tested, and vehicle has been inspected by dealership, problem is not reproducible on demand. No warning lamps turn on.

First, the airbag warning light came on, then followed by the horn not working and cruise control was lost. I also suspecting the power steering is also gone. This is related to the clock spring failure from my research online. This should have been recall because this is a safety hazard.

Front passenger door opened on its own with a bang while making a left turn. Driving alone, passenger door had been securely locked for over a week, during left turn going 25 mph, a loud banging sound occurred, passenger door opened and indicator warning light in dash came on. Door opened approx 1 cm. Car is not safe to drive for fear of door opening again randomly. VW of America nonchalantly stated they are sorry my door opened and stated they would not cover any potential repairs.

The contact owns a 2016 Volkswagen Golf Sportwagen. The contact received notification of NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The manufacturer advised the contact to avoid using the front passenger’s side seat. The contact had not experienced a failure. VIN tool confirms parts not available.

Vehicle exhibits multiple electrical and systems faults related to the airbags, TMPS, ABS, etc, as similarly described in 07/26/2019 Volkswagen Technical Tip 97-1902TT. Vehicle interior and sunroof tray is wet in various places. These issues raise concerns as they relate to safety and drivability. Upon inspection, the plastic sunroof tray is apparently cracked in multiple places as described in 12/06/2016 Volkswagen TSB 2045403 (supersedes V601608 November 22, 2016) and referenced again in Volkswagen Update 60C7. According to dealership records, the sunroof tray was claimed repaired per Volkswagen Update 60C7. This does not seem to be true.

In late summer (August 2022) I started seeing a warning but it would disappear so fast. Now it's popping up more: Yellow triangle appears. Engine is giving code# B116229 - "Selector lever park position lock switch Implausible signal" (mileage 104814 km). I originally received a recall notice like this and brought the car into the dealer. He said there was a VIN "Mix up" - something about the last two digits being reversed with another customer. Reading off my dash, this is my VIN [XXX] This sounds a lot like the "Shift Lever Micro Switch" recall which is a safety issue. Thank you INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Fuel leaking and pooling from the rear right tire well. Tire well saturated with fuel. Occurs after engine hesitation at high speeds, similar to running out of gas. Opening the gas cap causes some fuel splashing around the opening and gurgling and hissing sounds. Difficulty re-fueling after incident, gas pump keeps shutting off. Fuel siphon pump was tested, and vehicle has been inspected by dealership, problem is not reproducible on demand. No warning lamps turn on.

Takata recall. The contact owns a 2016 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

While driving car on highway heard a loud boom from rear right side. Stopped car and inspected, but no obvious damage. Resumed driving, and began hearing a repeated squeaking noise and some body lean in corners. Took vehicle to tire shop, where they removed right rear tire and found the right rear spring had snapped at the mounting location near the top of the spring. The attached photo of the spring suggests the mount may have been defective. Dealer confirmed spring damage and is now replacing both rear springs. However, no coverage of the damaged part even though multiple 2016 VW Golf’s have been recalled for rear spring issues.

At 80. 7k miles the car began to smell heavily of gasoline and I found gasoline leaking from the back right bumper just in front of the tire. I took the car to the dealership the next day and today they've told me that it could be a number of parts but what we have on order is the evap canister and the n80 purge valve. If this does not fix it then it is the entire gas tank, very expensive. There were no warning lamps and this issue was reproduced at the dealership. They've told me there's no recalls or warranties but I have read that many other people in the local VW group have had this issue. Volkswagen needs to own up to their previous emissions hang-ups.

I was driving my 2016 Volkswagen Golf on a roadtrip from Pennsylvania to North Carolina on 8/13. I did the 60k mile service and had my mechanic do a safety check before the roadtrip. I spent the night of 8/13 in Richmond, VA. I went to put gas in the car the next day and it was not taking the gas instead it was propelling it out of the car. The gas station attendant managed to get some gas in the tank and chalked it up to the new pumps. I stopped in NC to get more gas and none would go in. I noticed there was gas coming out of the car on the passenger side, right behind the rear tire. I had to get the car towed to my destination in NC. A dealer in NC looked at the car and diagnosed that there was a problem with the evap system. They tried this "to start with the remedy of the fuel issue on the golf we will need to start by replacing the charcoal canister -AND LDP valve (one unit) N80 purge valve. Now if it came down to replacing that fuel tank (a rough idea) there may be some additional parts we could need with replacement of the tank because it is an updated unit compared to the original. that is a big job, the rear subframe does need to be removed and in doing so the car will need to be aligned afterwards. you could be looking at an additional..." At no part in the journey were there any warning lights that indicated something was wrong with the car. Others here have pointed out that there was a recall for the EVAP system for this model and year of car. https://auto-recalls.justia.com/volkswagen/gti/2016/16v647000/ Like others I called VW Customer Care and they told me that my vehicle was not covered under any current recall and they would not confirm the 2016 recall happened at all.

at 80.7k miles the car began to smell heavily of gasoline and I found gasoline leaking from the back right bumper just in front of the tire. I took the car to the dealership the next day and today they've told me that it could be a number of parts but what we have on order is the EVAP cannister and the N80 purge valve. If this does not fix it then it is the entire gas tank, very expensive. There were NO warning lamps and this issue was reproduced at the dealership. They've told me there's no recalls or warranties but I have read that many other people in the MK7 group have had this issue. Volkswagen needs to own up to their previous emissions hang-ups

I am having the same safety issue that is outlined in this safety recall: https://static.nhtsa.gov/odi/tsbs/2022/MC-10206794-0001.pdf However, Volkswagen says that my VIN number is not included. Pictures: https://imgur.com/a/TKfal3R I would like my car included in this safety recall. The foil cracked initially from a manufacturing defect and has now cut me to the point of bleeding multiple times.

The contact owns a 2016 Volkswagen Golf Sportwagen. The contact stated that there was an odor of gasoline in the vehicle. Additionally, the vehicle was stalling while driving. The contact stated she stopped at a gas station and attempted to add gasoline; however, the tank was already full. The contact was able to drive home safely. After the vehicle was parked, the contact noticed that gasoline was leaking underneath the vehicle. The dealer was contacted and informed that the vehicle had experienced the failure listed in NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine And Engine Cooling) however, the vehicle was previously repaired under the recall. The contact was informed that the repair would be an out-of-pocket expense. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 86,400.

Dealer maintained 2016 VW Golf Sportwagen - coolant level kept getting low. Recent dealer visit indicated a leak in the thermostat housing. This seems to be a common issue with many such VWs, and in some cases other owners have reported multiple repeated failures of this housing. My car only has 66K miles and i haven't had any of my other cars have this issue over 25years of various car ownership.

The passenger side rear coil spring snapped without any warning and with in normal highway and city street use with only 46,244 miles and 5 years of age. The was manufactured in August of 2015, was delivered in November of 2015, and the spring failed in the last week of June 2021. The vehicle is used on road and has had all maintenance done on time or early. I drove the vehicle on June 25th and when I was about 2 miles from home I slowed for an intersection and heard a clank sound from the rear of the vehicle, the remainder of the drive was uneventful. The next day when exiting our garage my wife and I heard a loud clanking sound. I test drove the car around the block and every turn, deceleration, and bump resulted in a clank from the back rear wheel area. The VW dealer confirmed the rear spring had snapped and also noted they had had a number of occurrences on MQB platform VWs and had a Tiguan (same chassis/platform) of similar age in the shop for the same reason. I drove slowly and on low roads to the dealer but it was clear the handling was compromised as it was not predictable in terms of both motions over bumps or when turning or reaction to steering inputs. I spoke with VW corporate and they confirmed an earlier recall on rear coil springs on VW Golf Sportwagens but that recall impacted the 2015. They were unable to assist with the repair but suggested I contact NHTSA. It is fortunate that the failure occurred when it did and not at highway speeds or severe weather. It is also fortunate no fragments of the spring impacted the tire or break components. I have owned many cars with significantly higher miles and managed armored and police vehicle fleets but have never had a car with so few miles have a spring snap.

1. I BELIEVE THE DRIVER'S SIDE AIRBAG MAY HAVE FAILED OR BEEN DISABLED DURING A RECENT COLLISION THAT OCCURRED ON 5/25/21. A DEER STRUCK THE FRONT END OF MY VEHICLE WHILE TRAVELING ON A 55MPH STATE HIGHWAY. THE VEHICLE IS CURRENTLY AT A COLLISION REPAIR SHOP GETTING AN ESTIMATE. THE SHERIFF'S DEPUTY WHO RESPONDED TO THE SCENE GAVE AN INITIAL DAMAGE ESTIMATE OF $9000.00. 2. IMMEDIATELY UPON IMPACT THE AIRBAG ERROR LIGHT ILLUMINATED BUT DID NOT DEPLOY. 3.ON 5/26/21, THE DAY AFTER MY ACCIDENT, I RECEIVED A WARRANTY EXTENSION NOTICE DUE TO A POTENTIAL CLOCK SPRING FAILURE THAT COULD RESULT IN THE DRIVER'S SIDE AIRBAG NOT DEPLOYING. 4. VEHICLE HAS BEEN INSPECTED BY SHERIFF'S DEPT AND IS CURRENTLY BE EVALUATED BY COLLISION SPECIALIST AND INSURANCE ADJUSTER. 5. THE AIRBAG ERROR LIGHT HAD NEVER ILLUMINATED PRIOR TO THE ACCIDENT.

EXISTING NHTSA RECALL 69L2 BUT ON DIFFERENT MODEL YEAR - VW DRIVER SIDE AIRBAG AND HORN/STEERING WHEEL BUTTONS DISABLED. MY AIRBAG WARNING LIGHT CAME ON AND MY HORN AND STEERING WHEEL BUTTONS BECAME DISABLED SIMULTANEOUSLY AS I WAS IN MOTION DRIVING DOWN THE ROAD. NOW MY AIRBAG AND HORN/BUTTONS ARE NOT WORKING INCLUDING CRUISE CONTROL. VW RECALLED EARLIER-MODEL VEHICLES BUT THIS APPEARS TO BE A PROBLEM THAT STILL HASN'T BEEN SOLVED AND AFFECTS MORE THAN JUST THE MODELS LISTED IN THE ORIGINAL RECALL. I CALLED VW CARE TO SEE IF MY VEHICLE WAS COVERED UNDER A CAMPAIGN OR EXTENDED WARRANTY. HOWEVER THE PERSON I SPOKE TO TOLD ME THAT MY CLOCK SPRING WAS NOT COVERED AND I WOULD HAVE TO PAY OUT OF POCKET. THIS IS INFURIATING BECAUSE IT'S A KNOWN ISSUE THAT'S DISABLING MY AIRBAG AND HORN BUT VW IS REFUSING TO TAKE RESPONSIBILITY. JUDGING BY HOW MANY COMPLAINTS I'VE SEEN I AM DEFINITELY NOT ALONE. MY VEHICLE ONLY HAS ~66K MILES. HERE IS A RELATED VW EXTENDED WARRANTY BULLETIN I FOUND POSTED TO YOUR WEBSITE: HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2018/MC-10149942-9999.PDF INVESTIGATION INTO WHETHER VW DIDN'T RECALL ENOUGH MODELS: HTTPS://WWW.FORBES.COM/SITES/JENSEN/2018/04/21/FEDS-INVESTIGATE-WHETHER-VW-SHOULD-RECALL-MORE-MODELS/?SH=159D58364C60 CUSTOMERS CONTINUING TO HAVE PROBLEMS EVEN AFTER FIXING, SUGGESTING VW HAS NOT FIXED THE ISSUE: HTTPS://WWW.RATCHETANDWRENCH.COM/ARTICLES/6185-VW-CLOCK-SPRING-RECALL-MAY-HAVE-FAILED HTTP://WWW.VWPROBLEMS.COM/CLOCK-SPRING-FAILURE/ MORE COMPLAINTS: HTTPS://WWW.VEHIE.COM/COMPLAINTS/VOLKSWAGEN?VEHIE_MODEL=GOLF+SPORTWAGEN HTTPS://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/GOLF_SPORTWAGEN/2016/SEAT_BELTS_AIR_BAGS/CLOCK_SPRING_BROKEN.SHTML ARTICLE MENTIONING THAT 15/16 SPORTWAGENS NOTORIOUSLY HAVE CLOCK SPRING ISSUES: HTTPS://WWW.WHEELS.CA/CAR-REVIEWS/BUYING-USED-2015-2019-VOLKSWAGEN-GOLF-SPORTWAGEN/

I PURCHASED MY 2016 VW GOLF SPORTWAGEN IN 2019. SOON AFTER, THERE WAS A RAINSTORM, AND I REALIZED THE PANORAMIC SUNROOF WAS LEAKING HEAVILY ALONG THE BACK PANEL OF THE CAR. THE DEALERSHIP I PURCHASED THE VEHICLE FROM HAD THE CAR FOR ABOUT A MONTH, AND WAS ABLE TO CORRECT THE PROBLEM, AS WELL AS REPLACE THE HEADLINER. VW ISSUED A RECALL ON THE FRONT SUNROOF DRAINS IN 2020, IN WHICH THEY MODIFIED THE DRAINS. ONCE THIS WAS PERFORMED, THE SUNROOF BEGAN LEAKING AGAIN. I HAVE HAD TO REPLACE THE REAR SENSORS, WHICH WERE DAMAGED DUE TO WATER DAMAGE. THIS REPAIR WAS EXTREMELY COSTLY, BUT I WAS TOLD I COULD DO NOTHING ABOUT IT, BECAUSE VW WON'T COVER COSTS FROM FAULTY PARTS. I AM NOW LOOKING AT ANOTHER COSTLY REPAIR OF THE SUNROOF, AND A SECOND HEADLINER REPLACEMENT, WITHIN 2 YEARS OF OWNING THIS VEHICLE.

MY STEERING CLOCK SPRING FAILED AT 37K MILES, THERE'S A RECALL BUT VW SAID MY CAR IS NOT AFFECTED, HOWEVER MANY PEOPLE ON THE FORUMS AND CAR GROUPS HAVE HAD THIS ISSUE MORE THAN ONCE, SOME COVERED SOME NOT.

AIRBAG WARNING LIGHT STAYS ON

CLOCK SPRING HAS FAILED WITH HORN AND AIRBAG MALFUNCTION.

2016 VW GOLF SPORTWAGEN EXPERIENCED A COOLANT LEAK AT THE THERMOSTAT HOUSING/WATER PUMP AT APPROXIMATELY 76,000 MILES. THIS SEEMS TO BE A COMMON ISSUE WITH THE 1.8 ENGINE. DIAGNOSED BY THE VW DEALER AS WELL AS A SEPARATE INDEPENDENT REPAIR SHOP. BOTH RECOMMENDED REPLACEMENT OF THE THERMOSTAT HOUSING/WATER PUMP.

THERMOSTAT HOUSING LEAKING WITH JUST A LITTLE OVER 60K MILES - JUST OUTSIDE OF WARRANTY. COST IS ABOUT $1000 AS IT IS POORLY PLACED FOR REPLACEMENT. HAVE READ MANY OTHER COMPLAINTS OF THIS.

48K MILES, 2016 VW SPORTSWAGEN, FAULTY CLOCKSPRING. REVERSING OUT OF A PARKING SPACE AND TURNING THE STEERING WHEEL WHEN THERE WAS A CRINKLING,CRUNCHING SOUND WHICH CAME FROM THE STEERING WHEEL COLUMN, VERY INNOCUOUS NOISE, LIKE A PIECE OF PAPER WAS CAUGHT IN THE COLUMN. IMMEDIATELY A WARNING APPEARED ON THE CONSOLE 'AIRBAG ERROR' WHICH REMAINED ON FOR THE SHORT DRIVE HOME. THE VEHICLE WAS THEN PARKED, TURNED OFF AND UPON TURNING IGNITION ON AGAIN, THE SAME ERROR WARNING DISPLAYED. UNKNOWN IF OTHER COMPONENTS WERE AFFECTED. DEALERSHIP SERVICED THE VEHICLE DETERMINING THE CLOCK SPRING REQUIRED REPLACEMENT. THIS RESULTED IN $712 IN REPAIR COSTS AS REPAIR IS NOT COVERED UNDER WARRANTY. SEEMS LIKE AN ONGOING ISSUE WITH VW.

TL* THE CONTACT OWNS A 2016 VOLKSWAGEN GOLF SPORTWAGEN. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE ODOR OF FUEL WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. ALSO, WHILE REFUELING THE FUEL SPEWED BACK OUT OF THE FUEL FILLER NECK SOAKING THE PERSON FUELING THE VEHICLE. THE NEXT DAY WHILE AT A STOP LIGHT, THE VEHICLE SUDDENLY SHUTOFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER CHARLES MAUND VOLKSWAGEN LOCATED AT 6900 BURNET RD, ALSTON, TX 78757, WHO DIAGNOSED THAT FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 16V647000 (FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING). THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 66,000.

CLOCKSPRING FAILURE AT 32K MILES. TURNED CAR ON AND GOT AN AIRBAG WARNING AND ALL CONTROLS ON THE STEERING WHEEL ARE DEAD. OUT OF WARRANTY AND NOT PART OF THE RECALL ACCORDING TO VWOA. *TR

MY FIANCE'S VEHICLE HAS THE COMMON CLOCKSPRING ISSUE WHICH RENDERED ALL ELECTRICAL COMPONENTS OF THE STEERING WHEEL INACTIVE (HORN, CRUISE CONTROL, AIR BAG, AND RADIO CONTROLS). ONE DAY SHE STARTED THE CAR AND SAW THE CHECK ENGINE LIGHT COME ON. I SCANNED THE VEHICLE AND IT HAD THE KNOWN "B10001 DRIVER AIRBAG IGNITER: RESISTANCE TOO HIGH" CODE. THE DEALER THOUGHT IT WOULD BE COVERED SO LONG AS IT HAD THE CORRECT CODE BUT VWOA DENIED IT. THIS HAS BEEN A VERY WELL KNOWN ISSUE AND HER VEHICLE SHOULD QUALIFY UNDER THE RECALL/EXTENDED WARRANTY. SHE WAS DENIED BECAUSE HER VIN WAS NOT ON THE LIST EVEN THOUGH HER VEHICLE HAS THE EXACT SAME PARTS AS OTHERS WHICH DO QUALIFY. HER VEHICLE HAD THE SAME CODES REQUIRED ON NHTSA PDF HTTPS://WWW.GOOGLE.COM/URL?SA=T&SOURCE=WEB&RCT=J&URL=HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2018/MC-10149942-9999.PDF&VED=2AHUKEWIZWQZOK_ROAHXJGJQIHU3CBWAQFJABEGQICXAH&USG=AOVVAW3QKZUFKSVTKALROKUEK92M I RECIEVED A WARRANTY EXTENSION FOR MY 2017 GTI BUT FOR SOME REASON THE GOLF SPORTWAGEN IS NOT COVERED. SEEMS RIDICULOUS TO ONLY COVER SOME MODELS THAT HAVE SAME HARDWARE WHEN ALL SHOULD BE COVERED.

I JUST PURCHASED A PRE-OWNED 2016 SPORTSWAGEN FROM A VW DEALERSHIP IN HOUSTON TEXAS, I'VE ONLY HAD THE VEHICLE FOR 3 AND A HALF WEEKS AND MY EPC LIGHT HAD CAME ON 4 TIMES SINCE THEN ONLY THIS LAST TIME IT COMPLETELY AFFECTED MY DRIVING BY DROPPING MY SPEED ON THE FREEWAY SUBSTANTIALLY TO WHERE IT ALMOST CAUSED ME TO GET INTO AN ACCIDENT. I'VE BEEN READING UP ONLINE ON THESE ISSUES AND IT SEEMS TO BE A REOCCURRING ISSUE WITH A FEW OF VOLKSWAGEN'S MODELS YET NOBODY HAS ADDRESSED THIS ISSUE YET, IS HAPPENING WITH VEHICLES COMING RIGHT OFF THE LOT AND VEHICLES THAT ARE A FEW YEARS OLD. I FEEL THIS ISSUE NEEDS TO BE ADDRESSED BECAUSE WHO KNOWS HOW BAD IT CAN GET FURTHER DOWN THE ROAD, MAYBE NEXT TIME IT COULD HAPPEN TO A MOTHER OF FOUR AND THE VEHICLE SLOWS DOWN BECAUSE OF THE EPC FAILURE AND CAUSES HER TO GET INTO IN ACCIDENT OR WORSE CASE SCENARIO, ME WITH MY KIDS. I LOVE THIS VEHICLE BUT I DO BELIEVE SOMEONE OF HIGHER AUTHORITY SHOULD DO SOMETHING ABOUT THIS.

TOOK CAR IN FOR A USED CAR INSPECTION, COOLANT LEAK NEAR THERMOSTAT HOUSING WAS FOUND. COULD SMELL COOLANT WHILE DRIVING. FIXED UNDER WARRANTY.

VW SERVICE ACTION 60E5 APPLIES TO THE FRONT SUNROOF DRAIN CLEANING AND MODIFICATION. WE HAD UNSEASONABLY HEAVY RAINS OVER THE LAST 2 DAYS. THE RAINWATER BEGAN POURING OUT UNDER THE STEERING WHEEL/FUSE BOX AREA AND CAME THROUGH THE ENTIRE PERIMETER OF THE SUNROOF INTO THE CABIN OF THE CAR. VW TOLD ME THAT ALL REPAIRS RELATING TO THE SUNROOF LEAK WOULD BE COVERED UNDER THE SERVICE ACTION. MY DAUGHTER HAS A COMPROMISED IMMUNE SYSTEM AND IS VERY SENSITIVE TO MOLD AND ALLERGENS. THE SERVICE ADVISOR SAID THE HEADLINER AND ALL ELECTRICAL WOULD BE DRIED WITH FANS AND CLEANED AS NECESSARY. PLEASE TAKE A LOOK AT THE THREE ATTACHED PHOTOS. THIS DAMAGE IS A RESULT OF A KNOWN DEFECT WITH THE DESIGN OF THE SUNROOF AND I FEEL IT HAS NOT BEEN REPAIRED TO THE STATE IT WAS IN BEFORE THE LEAK OCCURRED. THIS IS JUST THE VISIBLE WATER DAMAGE. WE DO NOT KNOW THE EXTENT OF ANY POSSIBLE DAMAGE TO ANY ELECTRICAL COMPONENTS.

THERMOSTAT HOUSING FOUND TO BE LEAKING WHEN CAR WAS TAKEN IN FOR UNRELATED SERVICE. MANY, MANY VW GOLF/GTIS ARE AFFECTED BY THIS ISSUE.