Toyota Tundra 2025 — Reported problems

Mutplie times am have a delay on the accrelations have taken it to the dealer to be told thats just how the hybirds are this can cause a crash there should not be a delay when trying to speed up

Here's your description, about 1,750 characters, so it fits the 2,000 limit: --- My 2025 Toyota Tundra has two intermittent defects that have not been repaired despite multiple visits to Berglund Toyota in [XXX] 1. Driver's door will not unlock. Intermittently, when I press unlock on the key fob, all doors unlock except the driver's door. I have video showing me standing outside the truck with the fob in hand while the driver's door stays locked and the other doors open normally. The dealer disassembled the door and checked the wiring and connections but could not duplicate the problem and found no codes. A Toyota field technician also inspected the truck. No parts have been replaced because the failure could not be reproduced in the shop. When this happens I cannot get into the driver's seat of my vehicle, which is a safety concern, especially in an emergency or bad weather. 2. Tailgate fails in two ways. Sometimes when raised it will not latch closed. Other times it becomes stuck in the down position and cannot be raised, even manually. On one occasion this happened in a store parking lot, and I had to secure my load with a cargo net across the open bed to drive home. The truck has been to the dealer for the tailgate more than once. The dealer has ordered latch parts, but it has not been confirmed that this will correct the stuck-down condition. Both problems are intermittent and can occur at any time. My wife and I are in our [XXX] and rely on this vehicle. Toyota has been notified in writing. Other 2025 Tundra owners have reported the driver's door locking when the tailgate is operated, which may indicate the two problems are related. Root cause: UNKNOWN. No warning lights or codes appeared before the door failures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Two issues happening at the same time. “Key not detected” and “TPMS System Malfunction”. Key not detected: Happens at various times, either at startup or while driving, an error message that says “Key not detected “ comes on the dash and a loud beeping. My concern is that I may become stranded somewhere if the system cannot detect the key when trying to start the truck. The issue has been confirmed by both the dealer and Toyota and has not been fixed to date. TPMS System Malfunction: At various times while driving, a warning message is displayed on the dashboard that states there is a malfunction with the tire pressure monitoring system and that it should be checked by the dealership. My concern is that the TPMS system is unable to monitor the tire pressure and that could cause a dangerous situation. The issue has been confirmed by both the dealer and Toyota and has not been fixed to date. The truck has been back to the dealership 5 times for these issues and has been there for four days as of this writing.

Possible issue with the safety of others: My tailgate for my 2025 Tundra crewmax came opened (unknown to me) and contents of my Truck bed dumped onto the road. The incident as it happened. I was backed into a parking spot, truck was off, when I got in my remote was in my pocket and the truck would not start. So I pulled the remote out of my pocket and put it in the console. The truck would then start. I wasnt observant to the dashboard warnings if they were there. While driving home I heard all my bed contents fall out. Fortunatly I noticed it before it affected anyone. The best I can figure is that other objects in my pocket may have pushed the tailgate button. Since I was backed in and the tailgate lowering is so quiet, I didnt hear it or see it. I feel unsafe now to carry anything in my truck bed without backup protection. I would rather have a manual tailgate and totally disable the auto function but as I understand it, only the auto close mode can be disabled. I have not presented this to the dealership yet nor have I tried to duplicate the issue yet.

On 06/02/2026, at approximately 20,000 miles, the driver's front interior door handle on my 2025 Toyota Tundra TRD Pro failed. An internal component connecting the handle to the latch mechanism broke, and the door could not be opened from inside. I was unable to exit the vehicle through the driver's door using the interior handle. I had to lower the window and open the door using the exterior handle to exit the vehicle. The vehicle was repaired under warranty at Loyalty Toyota (Chester, VA), repair order 7245169/1. The dealer initially suggested the failure might be classified as improper use. They later informed me that Toyota considers it a known manufacturing defect, and the handle was replaced. On 09/06, at approximately 25,000 miles, the driver-side rear interior door handle failed in the same manner. The vehicle is currently at the same dealer awaiting parts, repair order 7255879/1. I asked the dealer to replace the remaining interior door handles because the failure is a known defect. The dealer said Toyota will replace each handle only after it fails. This is a safety concern. The interior door handles are the primary way for occupants to exit the vehicle. If a handle fails during a crash, fire, submersion, or other emergency, an occupant may be unable to open the door and could be trapped. Passengers, including children or anyone unfamiliar with the vehicle, are unlikely to know to use the window and exterior handle as a workaround. Because the failures occur without warning, there is no way to know which remaining handle will fail next. Other owners of 2025 Tundra's report the same failure on owner forums, and similar interior handle failures have been reported on the 2025 Tacoma. I am asking NHTSA to review whether this is a defect pattern affecting 2025 Tundra and Tacoma interior door handles that warrants investigation or a recall.

The side panel for the seat had cracked and pinched my wife's leg causing a minor injury when she was entering the vehicle.

When using the cruise control and lane keeping system the truck will jerk into oncoming traffic and try to swerve off to turning lanes. I took it to Toyota and they couldn't find any problem. no warning lights or any indication of a problem shows on the dash. At this point the system is unusable. I have seen many post of similar incidents on the internet.

The contact owns a 2025 Toyota Tundra. The contact stated that while driving 6 MPH and parking the vehicle, the brake pedal was depressed, and the brake lights became inoperable. Additionally, the rear cross traffic warning light was failing. An unknown warning light was illuminated with an audible alert, and the temperature warning light was displayed for a short while before turning off. There was an abnormal plastic burning odor during the failure. The contact received notification of NHTSA Campaign Number: 25V322000 (Exterior Lighting); and associated the failure with the recall. However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 238.

The alignment has consistently been an issue since I purchased the truck in March 2025. I've had the wheels aligned 3 times since I purchased it. I took it in for the 25000 mile service and it's out of alignment again. I've never had a vehicle go out of alignment let alone 4 times in 18 months.

On July 20, the vehicle experienced a catastrophic mechanical failure resulting in a total engine seizure while operating. The failure caused an immediate, sudden loss of motive power, forcing the vehicle to become completely immobilized on the Interstate highway. This unexpected loss of propulsion created an immediate and severe highway crash hazard for myself and surrounding traffic. The vehicle was towed to an authorized Toyota dealership on July 20 under the 5-year/60,000-mile factory powertrain warranty. The vehicle has remained completely out of service since that date. The dealership has tentatively scheduled the engine repair and replacement to begin on August 24 or 25, meaning the vehicle will have been non-operational and out of service for over 35 consecutive days before repairs even commence.

The contact owns a 2025 Toyota Tundra. The contact stated that while attempting to defrost the windshield on several occasions during the winter months, the windshield defroster failed to operate properly. The vehicle was taken to a dealer on two separate occasions and remained there for weeks. However, the dealers were unable to determine the cause of the failure and were awaiting approval from the Corporate Office to proceed with the diagnostic test. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 17,000.

The plastic piece that is where the drivers power seat controls had cracked again for the 2nd time and it could pinch someone or poke them as it’s sharp

I am reporting a severe thermal and electrical safety hazard regarding the OEM wireless charging pad in a 2025 Toyota Tundra. During standard vehicle operation, the integrated charging pad overheats to extreme temperatures. On a recent drive, the heat generated by the vehicle's charging pad was so intense that it physically melted, blistered, and deformed a MagSafe-compatible protective case on a Samsung Galaxy S25 Ultra. This safety issue has been brought to an authorized dealership, Toyota of Hollywood (Repair Order #[XXX]), for a second consecutive time. The dealership officially documented the property damage in writing on the invoice, stating: 'Phone got melted from how hot it gets.' However, they refused to perform repairs or disable the system, explicitly noting: 'Vehicle was compared to another and both doing the same.' By admitting that multiple new vehicles exhibit this exact overheating behavior, the manufacturer is confirming a systemic and unaddressed design or manufacturing defect. An in-dash electrical component capable of melting plastic poses an immediate cabin fire hazard, risks triggering thermal runaway in the mobile device's lithium-ion battery, and directly threatens occupant safety. Toyota Corporate has opened Case #[XXX], but no remedy or safety recall has been provided." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Toyota Tundra 2025 Limited stalled at highway speeds. The vehicle flashed "Parking Brake Support" message, but dealer says it has to do with an engine failure. Vehicle came to a grinding stop and would only advance in short spurts before dying on the side of the road. I was in the left lane of a major highway during rush hour. Luckily, traffic was behind me, and I was able to limp to the shoulder before traffic arrived. I noticed nothing prior. A loose gas cap may have prompted the system to send failure message. I haven't heard yet why it stalled. But my safety was definitely put at risk, and I was lucky to not be rearended

Heads up display(HUD) and windshield incompatibility issues from factory making HUD display blurry. Very distracting while driving because you’re too busy trying to see clearly and it takes away time from playing attention to the road. Lots of reports online about blurry HUD with 3rd generation toyota tundra from the beginning model year all the way up to most recent model year- it seems like they’re not doing anything about it. People online have reported getting dizzy while driving when trying to focus on the HUD- possible cause of accidents? Please look into this!

The truck has had three alignments and it still pulls to the right.

Have owned the 2025 Toyota Tundra for about 18 months. Multiple instances of delayed acceleration when stopped or almost stopped, sometimes as much as 3 or 4 seconds. Last time was in early June, 2026. This is very dangerous because when I pull out into an intersection it will start to go but then lose all power for a few seconds with traffic coming behind me. This is something Toyota needs to look into.

I have experienced a severe hesitation or delay in acceleration when accelerating from a stop or near-stop condition. While the issue has only occurred a few times over the past several months, on multiple occasions it happened while merging into traffic and nearly resulted in an accident. Toyota has issued Technical Service Bulletin (TSB-0032-26) addressing this condition. However, when I brought my vehicle to the dealership, Toyota documented that they were unable to reproduce or confirm the hesitation, and no repair was performed. This defect presents a significant safety risk. Unexpected loss of acceleration during traffic merges, intersections, or other situations requiring immediate power can place drivers and passengers in danger and could lead to serious injury or death. Given the safety implications and the fact that the remedy appears to be a software update requiring less than an hour to perform, I believe this issue warrants a formal safety recall rather than a voluntary Technical Service Bulletin. I urge NHTSA to investigate this matter and require Toyota to provide a recall remedy for all affected vehicles.

The contact owns a 2025 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V322000(EXTERIOR LIGHTING); however, the part to do the recall repair was unavailable. The contact stated that the passenger's side brake light and turn signal lights had become inoperable. The local dealer was contacted and confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 23,000

The contact owns a 2025 Toyota Tundra. The contact stated that the vehicle was leaking oil. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the gasket needed to be replaced. The vehicle was not repaired. The contact requested a buyback. The manufacturer was not notified of the failure. The failure mileage was approximately 34,000.

The contact owns a 2025 Toyota Tundra. The contact stated that while attempting to reverse, the rearview camera displayed a solid pink image. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 22,498.

Problem - throttle lag/hesitation/lurch. Truck won't go when throttle is pressed for a couple seconds cold or hot. Mentioned the problem on my 5000 mile service. Service tech said he could not reproduce the problem but happens with my drives 95% of the time. No warning lights have appeared.

The contact owns a 2025 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V322000 (Exterior Lighting). The local dealer was contacted, who confirmed the recall status. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The contact had not experienced a failure.

285/65R18 All four tires have accelerated wear on the outside edge at approximately 20k miles while the middle and inside o the tires has about 80% tread left. I believe the tire was not cambered correctly as delivered from the factory settings.

When coming to a rolling or quick stop and then attempting to maneuver across traffic, my truck hesitates for about a full second before accelerating. This delay can create a dangerous situation for myself, other drivers, and pedestrians. I believe this is a safety issue that Toyota needs to address promptly.

The issue I’m having is the transmission/engine when it comes to the hesitation for stopping and either slowing down or just a rolling stop. Sometime I would feel like I need to precisely control the brake pedal in order to go smooth stop, but no. It feels like it’s ’jumping’ in mini burst. I have the hybrid engine of the V35A-FTS. I did check for recalls but nothing found but found a TSB from Toyota T-SB-0032-26, but my hybrid is not covered, only the non-hybrid Tundra. Please help. Thanks

Excessive outer tire wear at 15,000 miles. Dealer advised that alignment was out of spec due to “Michigan roads” but I noticed this at 10,000 miles too and it’s still occurring.

There rear tailgate does not function. I have it in to Ourismon Toyota Chantilly for the third time. The tailgate does not come down. Issues with the tailgate started a week after I bought it in June 2025. It only has 8500 miles and has been in three times for this issue.

I was crossing two lanes of a 4-lane highway from a stop. I floored the accelerator to cross traffic and the truck hesitated for approximately 1-2 seconds in the middle of the highway before finally accelerating. During this time I was completely exposed to oncoming traffic with no ability to move the vehicle. This is not the first time I have experienced throttle hesitation on this vehicle but this was by far the most dangerous instance. The truck has ~17,000 miles and is a 2025 model year

While driving on the interstate, my sunroof suddenly exploded and glass shattered from the moveable portion of the sunroof. It sounded like a shotgun or a very loud pop. There was nothing above me on the road (i.e. no overpasses, etc) and no vehicles in front of me at the time. The sunshade was closed which saved me from pieces of glass falling on me, in my eyes, and potentially cutting me. It was very sudden, unexpected, and on a vehicle that is only ~18 months old. This was very loud, unexpected, and sudden. A potentially very dangerous situation.

My 2025 Toyota Tundra’s air conditioning is not cooling properly. The A/C does not perform as expected, especially in hot weather. I am concerned this may be a defect in the HVAC/climate control system. I am also concerned about driver safety because poor A/C performance in extreme heat can affect the driver and passengers, and HVAC issues may also affect proper window defogging/defrosting. I am requesting that NHTSA review this issue and track similar complaints for possible investigation. Not blowing cold wind, temperature changes and blows less air as temperature changes from hot to cold or cold to hot. at one point drove around 5 miles away from home before cool air started to blow.

My truck engine seized at highway speeds on 4/29/2026. Machining debris seized to the engine’s bearings causing oil to dump from the engine and the engine to completely seize. This is the same issue that NHSTA forced Toyota to issue a recall on 2022-2024 Toyota Tundras.

I own a 2025 Toyota Tundra TRD PRO. Bought in May of 2025. Has around 10,000 miles on odometer. Multiple times since I purchased this vehicle I have tried to accelerate into the flow of traffic from a stop and the truck would barely make it into the roadway and then suddenly lose acceleration leaving me without power when I needed it most. This caused panic and near collision with other vehicles coming towards me. This has happened a few times on a four lane with a turning lane in the middle. This is serious flaw and could end up causing a collision. This is the only vehicle I have ever experienced this problem with. Since I purchased this problem has occurred five or six times on my Tundra and twice it happened to me on my wifes 2025 Toyota 4runner TRD PRO.

At low outdoor (40* or less)temperatures, safety feature remain off line. Side mirrors squeak during actuation open or close. Plastic modeling cracked on driver seat, tail gate stays open and doesn't reset without manually closing the tailgate by hand.

The contact owns a 2025 Toyota Tundra. The contact stated that after driving from a complete stop, the vehicle hesitated to accelerate while the accelerator pedal was depressed. There was no warning light illuminated. The vehicle was dealer, who was unable to duplicate the failure. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 0111-22 (Hesitation From Stop and Surge Concerns ); however, the year and vehicle were not covered under the TSB. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 2,700.

While driving approximately 10–15 mph approaching a green light, a truck in front of me suddenly slammed on its brakes. As soon as I saw the brake lights I immediately applied my brakes before any system alert activated. I stopped within approximately 3–5 feet of the vehicle in front of me. At the same time, a truck behind me was approaching quickly. To avoid being rear-ended I pressed the accelerator to move out of the way. However my vehicle would not respond. Despite pressing the gas pedal the truck remained in a braking or non-responsive state and would not accelerate. I attempted to switch between the brake and gas pedal but the vehicle still would not move. This condition lasted approximately 30–60 seconds leaving me stopped in active traffic and unable to take evasive action. This created a serious safety hazard as I was at high risk of being rear-ended due to the vehicle’s failure to respond to acceleration input. The delay was critical and could have resulted in a collision. There were no warning lights or messages prior to or during the incident. The issue occurred suddenly without any indication. This appears to be related to the Pre-Collision System (PCS) and/or the vehicle’s throttle/acceleration system. The vehicle is available for inspection upon request. The issue has not yet been reproduced or confirmed by a dealer or service center and the vehicle has not yet been inspected by the manufacturer or other parties BUT I did call yesterday and haven’t received a response so I will be taking it to Gulf Coast Toyota today [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The malfunctioning part is the front left brake pads. The faulty brakes pads could pose a problem when stopping the vehicle. This problem was brought to the attention to my dealer in November 2025. The vehicle was inspected by the dealer in the spring of 2026 and acknowledged Toyota Corporate in 2026. There were no indications of problems when the vehicle was sold to me in August 2025. However, there was knowledge by Toyota of a problem with the brakes. See Toyota Technical Service Bulletin #s XXX May 6, 2024, & February 10, 2025. My case numbers with Toyota Corporate include #XXX, #XXX, #XXX. There are many videos on YouTube with the same problems as mine. There seems to be no interest by Toyota or my dealership to remedy the problem. I paid a lot of money for this vehicle and pay a sizable monthly note to listen to squealing brakes and wondering if they may fail. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am seeking a case review regarding a persistent and unresolved drivetrain issue with my 2025 Toyota Tundra (non-hybrid) that began immediately following a dealership service visit and has continued for over one month without resolution despite multiple repair attempts. Since that time, the vehicle has exhibited consistent transmission-related defects including failure to shift properly into higher gears (notably not reaching 10th gear at highway speeds), RPM hanging under light throttle, delayed acceleration followed by sudden surges in power, and harsh or erratic downshifting that causes the vehicle to lurch forward when slowing to a stop. The vehicle also demonstrates inconsistent torque delivery, where boost builds but power is not transferred until a delayed and abrupt engagement occurs. These issues are most pronounced during normal highway driving conditions and significantly impair drivability and safety, particularly when merging or maintaining speed. I have brought the vehicle to multiple Toyota dealerships for inspection, where diagnostic scans have not produced any fault codes and I have repeatedly been told the vehicle is operating “within normal parameters,” despite the ongoing and reproducible performance issues. The dealerships have been unable to replicate or resolve the problem, and I have received inconsistent explanations ranging from normal operation to speculative driving pattern causes. I have an active case open with Toyota corporate, but after a month of delays, lack of diagnosis, and no corrective action, the issue remains unresolved. Given the ongoing safety concerns, repeated repair attempts, and inability of Toyota to identify or fix the defect, I am now left without a resolution & am instructed to drive the vehicle despite drivetrain issues.

I am reporting multiple safety-related defects on my 2025 Toyota Tundra (approx. 18.5k miles, purchased 07/25). Toyota has been made aware and has not resolved these issues. The most serious defect is deterioration of the driver-side air intake housing. While replacing the air filters, I observed the airbox shedding internal material directly onto the engine air filter. This is not external debris and there are no signs of rodent intrusion, indicating internal component breakdown. This vehicle shares the V35A engine platform, which is subject to recall for debris contamination leading to main bearing failure, engine stall, and loss of drive power. The presence of internally generated debris upstream of the engine creates a credible risk of engine damage or sudden failure while driving. Toyota’s recall documentation confirms debris contamination can cause engine stall and loss of drive power. The windshield cracked during extreme cold weather. The crack originated near the lower edge at the wiper/cowl interface and propagated upward in a pattern consistent with stress or thermal failure, not impact, affecting visibility and structural integrity. Additionally, the lower front bumper trim cracked without meaningful impact, and the rear bumper failed under minimal load in cold conditions. These failures indicate material brittleness and raise concern for reduced crash protection and increased risk of injury in a collision. Other issues include driver-side seat trim cracking and premature paint and trim degradation. Similar failures, including windshield cracking, trim failure, and cold-weather brittleness, are widely reported by other 2022+ Tundra owners, indicating a potential systemic defect. Given the known engine recall and active internal material degradation in the intake system, there is a credible safety risk of engine stall, sudden loss of power at speed, reduced visibility, and increased injury risk due to compromised bumper integrity.

Center console glossy trim around the gear shift gives off a blinding glare from the sunlight coming through the front windshield. Almost side swiped the adjacent vehicle on my right when blinded. This was noted and photographed after just owning the vehicle for one day. Talked to Toyota Corporate who told me to take it to local dealership. Toyota of Fort Worth said there is nothing they can do and referred back to Toyota Corporate. Toyota Corporate has yet to respond. The start/stop is faulty. Engine does not turn off at red lights (bypass not activated). At red lights, the "press brake further to activate" light will come on, the truck will shake, then the "battery charging" warning light will come on. Dealership response is I am not breaking hard enough or I just need to learn to press the bypass every time I start the vehicle. The vehicle will automatically turn off the engine when I park the vehicle, but as soon as I take my foot off the brake (while still parked in the driveway), the truck will automatically restart. Basically, the start/stop does not work while driving but will work when parked. Per Toyota of Fort Worth Service Dept, that is normal operation.