Toyota Tacoma 2011 — Problemas reportados

I purchased a vehicle from a car dealer "as is" with a clean title. About two months after purchase I took it to a mechanic after I got an airbag light and he told me the vehicle was missing airbags and was in a hard enough collision that it caused the airbags to deploy. This was not listed on the Carfax report and was not disclosed to me. I would have never purchased a vehicle if I knew it was missing airbags.

The contact owns a 2011 Toyota Tacoma. While inspecting underneath the vehicle, the contact discovered that the vehicle was only equipped with three leaf springs instead of four. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no recall for the failure associated with the VIN. The failure mileage was unknown.

The contact owns a 2011 Toyota Tacoma. The contact stated that over time the horn intermittently became inoperable; however, the horn operated while in the middle of making a turn. The contact was concerned about the failure because the horn and the air bag in the steering wheel were connected by the clockspring. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not associated with a recall related to the failure. The local dealer confirmed that the VIN was not included in a recall related to the failure. The manufacturer was notified of the failure. The failure mileage was 88,000.

The contact owns a 2011 Toyota Tacoma. The contact stated that while performing a routine engine oil change, extensive corrosion was observed across the entire undercarriage. The severe rust damage fully compromised the vehicle's structural frame, control arms, and several underbody components. The dealer was not notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 200,000.

Chassis recall under Toyota Recall Program ZKA/LSC K0D. While the window of this recall closed in 2017, my vehicle was sold to me several years after 2017. The vehicle chassis is in a critical state and is likely to snap in half. I have sent a letter and photos to: Toyota Motor Corp., Federal Highway Admin, Toyota Clearwater, Consumer Financial Protection Bureau, FL House of Rep and BBB Natl Programs. All of the above were sent via trackable and signature required USPS. The vehicle should have been prohibited from any resale if the recall can be closed. As i understand it, technically there should be no expiration date on a significant failure. I do not have $13,000 to get a new vehicle and I do not want to resell to shift the risk to someone else. At minimum Toyota should be forced to buy back the vehicle , replace the chassis or offer a safe used replacement option. Please help me understand where I go from here. Looking for your support and resolution.

2011 Tacoma, 4x4. Leaf spring is broken on the passenger side. 130,000 miles. According to Toyota my vin is not included under recall 14V-604. I do believe this is either an error or deliberate oversight to avoid responsibility. Manufacturer date 05/11 so according to the recall notice it falls within the date range but not the effected Vins.

I purchased the truck December 6th 2025 within a thousand Miles within the end of the year I experienced brake failure on the highway I laid under the truck to patch the brake failure and found a cracked leaf spring suspension component which there's already a recall for that exact make and model just not my VIN number for that cracked leaf spring there was a recall for frame rust and just rust in general and my brake lines rusted out but a certified technician from the used car dealership said it was safe and road Worthy I experienced a brake fire on the front calipers shortly after this brake failure the fire caused 7800 worth of damage I got quoted from Toyota to fix it and that doesn't cover the $2,000 worth of leaf springs which there was already an exact recall for this exact model of truck for the exact damage depicted but somehow my VIN is not applicable for this repair.

The contact owns a 2011 Toyota Tacoma. The contact stated that while attempting to have an inspection completed on the vehicle, the contact was informed by the mechanic that the inspection could not be completed due to several holes in the underbody frame of the vehicle. The dealer was not contacted. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 168,000.

Blower Fan had been cutting off. Only running intermittent on High. Took to Toyota dealer June 2025. Was told it was a Cabin Air Filter Clogged. Paid for replacement and clean out of system. Continued to not work. Called a mechanic and asked for a diagnostic. Was told it was a “known issue” with Toyota Tacomas. Had been a recall in later years. I ordered the blower motor resistor and wiring harness from Toyota parts department. It was on back order due to the issue being widespread. July 2025 parts came in. Returned truck to the shop. The techichian replaced the motor blower resistor and the new wiring harness. However, he cut the burnt wires off and spliced the new wires into old wires back to the motor. Aug 2025 motor has stopped working again. Back to the Toyota shop. The truck needs a new blower motor. The labor will be 1200. Plus the labor I’ve already paid for three other shop visits plus parts. The motor blower is on back order till mid September. The motor has been let unplugged due to “risk of fire”. But I’ve been given the vehicle again to drive. It has had a risk of fire since June. The wires have been overheating and smelling. This should have been a recall in 2011. Just as it was in the later Toyota Tacoma. Pleas investigate

The underside of my 2011 Toyota Tacoma is experiencing tremendous rust. Dealer said since there was not perforation, nothing to be done. Brackets holding wiring, body panels and now gas tank have rusted and failed. The gas tank strap is a major concern. It is available for inspection. The gas tank is held up now by one unrusted strap and rubber bungee cords I applied. Dealer or independence service center has not seen it. Nearest dealer is a ferry ride away, I live on an island. No inspection by manufacturer etc. No warning lights or messages.

I am the third owner of a 2011 Toyota Tacoma Access Cab 2.7L. I purchased it in Oct. 2024 in NY. At that time, there were no visible signs of frame rust. Within 6 months, it developed severe corrosion, including deterioration at the suspension mounts. The vehicle is no longer safe to drive and is available for inspection. Toyota previously recalled earlier Tacomas for the same issue, but for 2011–2017 models, they issued a Limited Service Campaign (K0D) and Customer Support Program (ZKA), which expired after only 12 years (vs. 15 years previously). This was not classified as a recall, despite serious safety concerns. The prior owner appears to have driven zero miles from 2020–2022, when the campaign was active. The vehicle was registered in Vermont, where statewide COVID restrictions closed dealerships and suspended non-essential services. No extension or accommodations were provided by Toyota. I discovered the corrosion on [XXX], during a frame inspection immediately after investing $4,800 in bodywork. The mechanic noted the corrosion was extensive and abnormal for a 2011 model—more consistent with a truck from the 1980s. Toyota’s decision to time this campaign at the height of COVID and shorten the eligibility window appears negligent and possibly strategic. Now in 2025, many owners are finding catastrophic frame rot after Toyota's limited program has ended. I urge NHTSA to investigate this as a true safety defect, not a service courtesy. Owner testimonials of frame failure after expiration: [XXX] [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The locking mechanism, the vechile was park we put the child in to turn it rear facing and it wouldn’t lock into place, so we turned it forward facing and it still wouldn’t lock into place. The child’s seat will not lock into position. Then we noticed where the lock off is the plastic is bent upward from the seat belt itself. The chest clip is also Magnetic and had to be replaced all ready by manufacturer due to it not latching. This will not let me upload the video

Severe Frame rust

The contact owns a 2011 Toyota Tacoma. The contact stated that while working underneath the vehicle, he noticed a hole in the frame rail, passenger's side, rear of the vehicle. The vehicle was taken to a local dealer where it was inspected under a Service Bulletin however, the vehicle was not repaired. The manufacturer was made aware of the failure; however, the manufacturer confirmed that the vehicle was no longer under Warranty for the repair and a case was opened. The vehicle was not repaired. The failure mileage was approximately 150,000.

Steering shaft u- joint seizure causing loss of vehicle steering. Very dangerous.

The horn on my truck no longer works. Cruise control is intermittent at times. Vehicle was taken to my independent repair shop I've been told it is the clock spring in my steering wheel. My concern is the air bag would quit working. Been told same vehicle from 2012 and newer was fixed by Toyota for same problem.

1.) Headlights are yellowing. 2.) Hard to see at night. 3.) Everyone has the same problem. The government should mandate going back to glass headlights for safety reasons. Buffing them only lasts a short period of time and the elderly can't afford to buy new OEM headlights every 6 years as they are very, very expensive. This is a safety issue, as yellow lenses equal more nighttime accidents, fact. This should have been addressed years ago.

The contact owns a 2011 Toyota Tacoma. The contact stated that after taking the vehicle for repair, the contact was made aware of rust on the steering shaft and the support arms and the front end of the vehicle. The contact took the vehicle to the dealer and the contact was informed that there was no fix for the failure. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 144,000.

My vehicle failed the state of Maine safety inspection due to a broken leaf spring. I had the vehicle further inspected at a Toyota dealership and they reported the same issue. They gave me an estimate to replace the rear springs for a total cost to me of $2321.00. This an expense that I do not believe should have to bare, as this vehicle is only used for personal use. The heaviest load this vehicle has carried is a few bags of fertilizer.

Vehicle was brought to dealer to replace ROTTED transmission cooler lines. During inspection it was noticed that the vehicles rack & pinion steering tube is almost completely ROTTED through as well, this is a complicated and expensive repair, which if it completely fails will render the vehicle unsafe for the road, a danger to myself and others on the road. The vehicle has only 127,000 miles. I was also informed that the vehicle no longer qualifies for frame replacement under recall ' because I waited too long '

Toyota Tacoma was sprayed in 2020 for frame rust. Rust has began again on the frame. Also the suspension and behind the two rear wheels rust is rampant. Lots and lots of rust but no new holes since was sprayed. Pictures attached of the 2011 Toyota Tacoma with 68,000 miles.

The contact owns a 2011 Toyota Tacoma. The contact stated that the driver's and passenger's side headlights were inoperable. Upon inspection, the contact noticed that the headlight assemblies were extremely hot and had melted. The vehicle was taken to the dealer where it was diagnosed that the driver's and passenger's side headlight assemblies needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 210,000.

This VIN number was totaled due to a bent frame after being rear ended on June 10th. I fear my insurance company (USAA) will attempt to commit fraud by not reporting the title as salvage.

The contact owns a 2011 Toyota Tacoma. Upon purchase of the vehicle, the contact received a Carfax report from the independent dealer that the vehicle had been placed under a service campaign for frame corrosion. The contact took the vehicle to a dealer where he was denied the service campaign because his vehicle was in a non-cold climate state. The manufacturer was also notified, and also denied his claim. The contact stated that he had discovered corrosion on the sub frame of the vehicle. The vehicle was not repaired. The failure mileage was unknown.

MY VEHICLE FAILED VA INSPECTION DUE TO THE HORN NOT WORKING. I HAVE TO GET THE SPIRAL CABLE REPLACED PER THE AUTO REPAIR SHOP. THIS WAS A RECALL ON TACOMA'S UP TO 2009 (RECALL B1801) BUT NOT MY YEAR. MY YEAR SHOULD BE PART OF THE RECALL. I BELIEVE THIS ALSO IMPACTS THE AIRBAG DEPLOYMENT FROM THE STEERING WHEEL.

RUBBER STRIP DOWN THE PASSENGER SIDE OF THE ROOF GONE.

TOYOTA SCRANTON IS WILLFULLY DEFRAUDING OWNERS ENTITLED TO REMEDY FOR SEVERELY RUSTED FRAME UNDER CASE NUMBER 2:15-CV-02171, US DISTRICT COURT, CENTRAL DISTRICT OF CALIFORNIA. SEE ATTACHED DOCUMENTATION AND PHOTOGRAPHS.

PASSENGER SIDE REAR SUSPENSION WAS MAKING NOISE. LOUD CLUNKING. UPON FURTHER INSPECTION, REAR LEAF SPRING IS BROKEN IN 2 PLACES. THE PREVIOUSLY INSTATED RECALL DOES NOT COVER MY VEHICLE??

REAR LEAF SPRINGS ARE VERY WEAK AND ARE NOT AS SUPPORTIVE AS THEY SHOULD BE. AS SHOWN IN THE PHOTO THE SPRING IS PRETTY MUCH STRAIGHT AND IT SHOULD HAVE SOME CURVE AS THERE IS NO LOAD ON THE VEHICLE.

MY DAYLIGHT RUNNING LIGHT KEEPS BURNING OUT AND SPLITTING THE LENS. IT'S THE SECOND SET OF LIGHT I'VE HAD TO REPLACE THEM.

UPON INSPECTION TO TROUBLESHOOT A MINOR POWER STEERING FLUID LEAK, I NOTICED THAT THE PINION INPUT SHAFT HOUSING (RIGHT SIDE OF POWER STEERING RACK) HAD EXCESSIVE RUST BEYOND NORMAL WEAR AND TEAR. THE REST OF THE RACK DID NOT EXHIBIT THE SAME DEGREE OF CORROSION, SUGGESTING A MANUFACTURING OR ASSEMBLY DEFECT. THE CONDITION WAS INSPECTED BY AN INDEPENDENT CERTIFIED MECHANIC AND BY TOYOTA TECHNICIANS. THE CERTIFIED MECHANIC STATES THAT THE CONDITION IS BEYOND NORMAL WEAR BUT THE TOYOTA TECHNICIAN DENIES THAT ANYTHING BUT A BOLT IS CORRODED.

BOTH LEFT SIDE AND RIGHT SIDE DAY TIME RUNNING LIGHT LENS INSIDE HEAD LIGHT ASSEMBLY ARE BURNED AND DISCOLORED. HEAD LIGHT ASSEMBLY LENS ARE CRACKED.

I WAS DRIVING AND AT ANY SPEED THE STEERING WOULD LOCK UP WHILE TURNING. THE LOWER INTERMEDIATE SHAFT HAS DETERIORATED TO FAILURE. I'M GLAD THAT I DIDN'T HAVE AN ACCIDENT BUT CAME CLOSE. WHEN SEARCHING THE INTERNET TO SEE IF ANYONE ELSE HAD THE SAME PROBLEM I FOUND THAT IT WAS A COMMON OCCURRENCE FOR ANYONE LIVING IN A AREA (NOT JUST IN THE USA) THAT IS A SNOW AREA WHERE SALT IS USED. TOYOTA CONSIDERS THIS A WEAR ITEM. THIS SHOULD NOT BE CONSIDERED A WEAR ITEM WHEN FAILURE CAN HAPPEN AT ANY GIVEN SECOND WHEN DRIVING AND NOT ALLOWING THE VEHICLES DRIVER TO BE IN CONTROL

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR LEAF SPRING FRACTURED AND DETACHED FROM THE VEHICLE. THE FAILURE WAS DISCOVERED BY TOYOTA OF SCRANTON (3400 N MAIN AVE, SCRANTON, PA 18508) WHILE THE VEHICLE WAS BEING INSPECTED. THE CONTACT WAS ALSO INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,304.

THE VEHICLE TAKES LONG TO STOP EVEN AFTER CHANGING THE BRAKE PADS , ROTORS, BRAKE SHOES, WITH NEW COMPONENTS. THE REAR MAKES A THUD SOUND WHEN ACCELERATING OR COMING TO A STOP. THE LEAF SPRINGS ALSO SQUEAK AND I NOTICED AFTER THEY CHANGED MY FRAME THE LEAF SPRINGS WERE NOT CHANGE EVEN THOUGH THERE IS A RECALL ON THE LEAF SPRINGS AND IT WAS RUSTING? THE STEERING INTERMEDIATE SHAFT STARTED TO MAKE THIS LOUD THUD SOUND WHEN GOING OVER BUMPS AROUND 5-10 MPH. THERE IS ALSO A RECALL ON THIS, BUT MY LOCAL DEALER SAYS THERE ISN'T ONE? WHY DOESN'T THE MAIN BRANCH TALK TO OR UPDATE THE SYSTEM FOR ALL TOYOTA BRANCHES FOR RECALLS? *TR

YES, I WENT TO THE DEALER WHO IS SELLING THIS VEHICLE AND NONE OF THE 9 RECALLS HAVE BEEN CORRECTED. DISTURBING! I CHECKED THE SAFETY SITE FOR THE INFORMATION

TL* THE CONTACT OWNS A 2011 TOYOTA COROLLA. THE CONTACT STATED THAT THE VEHICLE BENCH SEAT FALLING APART, DETACHED FROM THE WELL, THE STEEL BAR POINTED OUT RIPPING THROUGH THE MATERIAL AND THE FRAME DETACHED CAUSING THE DRIVE TO UNABLE TO SEAT PROPERLY TO DRIVE. THE VEHICLE WAS TAKEN TO DCH FREEHOLD TOYOTA DEALER, (4268 ROUTE 9, SOUTH ST, FREEHOLD TOWNSHIP, NJ 07728) AND INFORMED THE CONTACT THAT DUE TO THE AGE OF THE VEHICLE, THEY COULD NOT SERVICE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED DUE TO THE DIAGNOSTIC AND REPAIR FEE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.

ABOUT 1 MONTH AGO I NOTICED MY BRAKE PEDAL FELT SPONGY. CHECKED FLUID LEVEL, PADS AND SHOES, OK. NO SIGN OF A FLUID LEAK. 1 WEEK LATER I WAS DOING 65MPH AND HAD TO COME TO AN EMERGENCY STOP. MY BRAKE PEDAL FADED ALL THE WAY TO THE FLOOR AND I HAD NO BRAKING AT ALL, COULDN'T PUMP THEM UP AND STEERED FOR THE OPEN SHOULDER. I LIMPED HOME, CHANGED MY SHORTS AND LOOKED UP THE PROBLEM ON SEVERAL TACOMA FORUMS ON THE WEB. IT SEEMS TO BE A VERY COMMON PROBLEM AND NOBODY HAS AN ANSWER, PEOPLE HAVE REPLACED EVERY COMPONENT INCLUDING THE FLUID WITH NO LUCK. I HOOKED UP MY OBD2 READER THAT HAS ABS FUNCTIONALITY AND IT SHOWED NO FAULT CODES. THIS SEEMS TO BE A COMMON PROBLEM AND EVERYBODY IS JUST GUESSING WHAT CAUSES THE FAILURE. IT IS THE BRAKES!, THE MOST IMPORTANT SAFETY FEATURE ON ANY CAR. MY TRUCK HAS BEEN PARKED AND WILL STAY THAT WAY UNTIL SOMEONE (HOPEFULLY TOYOTA) FIGURES OUT WHAT IS WRONG AND WHY.

THE HORN IN MY 2011 TOYOTA TACOMA QUIT WORKING. I WENT TO USE IT MY HORN, AND IT DID NOT WORK. I'VE TAKEN MY TRUCK TO SEVERAL PLACES TO SEE IF IT COULD BE FIXED. I HAVE BEEN READING WHERE THIS IS A COMMON PROBLEM FOR MANY TOYOTA OWNERS. ALSO, THE WHITE PAINT ON MY CAR IS STARTING TO FLAKE OFF. THE TRUCK ISN'T EVEN 10 YEARS OLD AND HAS BEEN MAINTAINED. YET AGAIN, THERE ARE THOUSANDS OF CONSUMERS AFFECTED BY THIS. APPARENTLY THERE ARE TWO TYPES OF WHITE PAINT THAT TOYOTA KNOWS TO BE AN ISSUE ON CERTAIN YEAR MODELS, BUT THEY HAVE NOT ISSUED A RECALL. HAVING A PAINT JOB IS AN EXPENSE THAT MOST CAN NOT AFFORD! I COULD SEE IF IT WAS SOMETHING THAT WAS CAUSED FROM AN ACCIDENT OR THE OWNERS FAULT, BUT THIS IS RIDICULOUS. MINE IS STARTING TO PEEL AND FLAKE ON MY PASSENGERS SIDE DOOR AROUND THE WINDOW. THERE WAS NO PRELIMINARY FLAKING OR PEELING OF THE CLEAR COAT, IT WENT STRAIGHT FROM WHITE PAINT TO GRAY. NUMEROUS PEOPLE HAVE WRITTEN IN ABOUT BOTH OF THIS ISSUES AND THERE IS NOTHING BEING DONE! THERE IS NO REASON WHY THEY CAN'T FIX OUR HORNS. I LIVE IN N.C. AND MY TRUCK WILL NOT PASS INSPECTION WITHOUT IT. THIS LEADS TO OTHER TICKETS AND FINES THAT SHOULDN'T BE HAPPENING. I CAN'T TELL YOU HOW MANY TIMES I HAVE NEEDED MY HORN, AND IT DOESN'T WORK.

HORN NOT WORKING .WAS TOLD IT WAS IN STEERING WHEEL