Toyota RAV4 2016 — Problemas reportados

Mechanic said he thought rear lower rearward; non-adjustable control arms, lateral arms were a recall. They were falling apart. I've been complaining about a clunky noise for a year or so. Thank you for your help [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving 9/3 and my left blinker light came on solid. I was not using my blinker. Within a few seconds my check engine light came on and another light. Then within 2 minutes the front left engine/tire caught fire.

​"The red master warning triangle and an 'SRS Airbag System Malfunction' message illuminated unexpectedly on the dashboard of my 2016 Toyota Rav4 XLE under normal driving conditions. I contacted a certified Toyota dealership, and they confirmed that this dashboard warning indicates the vehicle's airbag system is completely disabled, leaving the occupants without airbag protection in the event of a collision. However, the dealership stated they will not cover the cost to diagnose or repair the system because there is not yet an active safety recall for this specific VIN. I am filing this complaint to formally report this critical safety defect. A premature failure of the vehicle's primary safety restraint system is an immediate and severe safety hazard that warrants a formal NHTSA investigation and a mandatory recall."

The repair shop I was able to pull into as I was experiencing the issue with my vehicle reported: "Battery is unstable and is arcing off of the positive terminal. Battery tray, battery hold down tie, and battery j hook hold down were missing upon arrival." The issue was fixed by a Brakes Plus location, given I was able to pull in there - it was around the corner from where I was driving. The issue has been fixed, and I have no issue with inspection of the vehilce. The car died while I was driving on a main street. The recall note states that the vehicle could have caught on fire, though no fire or crash happened. I made a simple right-hand turn and almost every light imaginable illuminated on the dashbard. I was able to turn the vehicle off and on again and get the car to the Brakes Plus location. This location had to order the parts from Kansas. I called the Toyota Dealership informing them what had happened, that the car was unable to be moved and got the response that I needed to take it to them for repair. I called at least two times since I received the notice for the fix in the mail and I was told that I would be contacted when they were ready to fix my car specifically. I was informed they would call, but they did not take down my contact information. I reached out to Toyota and they opened a claim where I uploaded documents - the original recall notice, the letter informing of the fix, the invoice from Brakes Plus, proof of purchase On Friday,XXX, I received a letter notifying me that my claim was not eligible for reimbursement. Since I tried to reach out and get an appointment scheduled inspection and the fix (if needed), and I never received a call to schedule after being told the dealership would reach out to me when they were ready, I believe they should have paid me back for the repair. I can provide the Toyota Brand Engagement Case number as requested. I am hesitant to upload documents here as these documents contain name, address, etc.

Intermittent stalling in various conditions including idling, highway driving and city driving.

I am filing a complaint regarding Toyota sending out letters to RAV4 owners reference factory paint peeling. The letter stated, “Customer Support Program Notification Paint Peeling (Vehicles Painted with factory-applied blizzard pearl or super white paint). In this letter it stated that it is a possibility veh’s painted with this paint may experience paint peeling off. In the letter it states that if you are not experiencing this issue, there is nothing you need to do at this time. I did not experience any issues at the time. The letter was sent approximately 6-7 years ago. On May 20th 2026 I noticed on the roof of my vehicle between the windshield and sun roof a large softball size area of metal where the paint peeled/flaked off. In contacting Toyota dealership they said there is nothing they can do. Contact was made today 6/15/26 ( I didn’t notice the paint peeling off until 6/13/26). I then called Toyota Corporate and they said since the extended warranty expired 12/11/2025 I have to pay for the fix and they will not. Online there are thousands of others experiencing the same issue. I received a quote of $1600 and $2300 dollars just to strip and repaint the roof. I have the video showing the paint peeling off by itself. This is ridiculous and Toyota needs to be held accountable. According to Toyota the cause of this issue is due to sunlight over time degrades the adhesion between the factory-applied paint primer coat layer and the base metal electrodeposition layer causing the paint to peel from the metal body panel.

Vehicle: 2016 Toyota RAV4 Color: Factory Super White / Blizzard Pearl (whichever applies) I am filing a complaint regarding a well-known latent manufacturing defect involving peeling factory paint on my 2016 Toyota RAV4. The original factory-applied white paint is peeling and delaminating from the exterior metal body panels under normal use and maintenance conditions. The paint failure appears unrelated to any accident, impact, misuse, neglect, or environmental damage. The failed component is the factory-applied exterior paint and coating system on the vehicle’s metal body panels. The affected areas are available for inspection upon request. The paint is separating from the primer/base layer and peeling off in sheets, exposing underlying surfaces and creating risk of corrosion and reduced vehicle value. Toyota has publicly acknowledged widespread issues involving “Super White (040)” and “Blizzard Pearl (070)” paint on numerous Toyota models, including RAV4 vehicles, through Customer Support Program ZKG and multiple Technical Service Bulletins. Toyota documents specifically state the issue involves paint adhesion failure during the manufacturing process causing peeling on exterior metal body panels. This issue creates safety concerns because exposed metal surfaces may eventually corrode or rust, reducing long-term structural integrity and potentially creating visibility distractions while driving as paint continues to separate and peel unexpectedly. Large peeling sections can also detach while driving and create roadway debris hazards for other motorists. The condition has been widely reported by consumers across online forums, complaint databases, and dealerships for many years. Numerous owners of white Toyota vehicles have reported identical failures involving factory paint peeling and delamination. The problem has been visually confirmed by dealership personnel / independent body shop personnel (modify if applicable). And they have refused to cover it at all

I called for a jumpstart for my truck after it cut off while I was turning onto a parking lot I hit a bump and it just cut off. I had to turn the truck completely off then start it again, after it started I made it completely onto the lot and parked it. When I went to start it again it wouldn’t turn over or startup. I used my State Farm app to request for a jumpstart or possible tow 2/23/25. On 3/9/25 the truck wouldn’t start again and I requested for another jumpstart. The engine light came on shortly thereafter saying that the AWD wasn’t available and that the FWD train was only available. I took it in for a battery replacement and that seemed to help for a couple of months, then my headlights started going out one at a time. The passenger side bulb went out first. I replaced it with a new one at Valvoline and then the driver side bulb went out two weeks or so later and I replaced it then the check engine light came back on and I eventually had to take into the dealership for repairs and maintenance. They said they fixed it. It worked for about a 12 days and then the headlights started dimming over time as the week went on the engine light came back on and the driver side bulb was out again. So from 12/23/25 to 1/5/2026 was the length of time the truck worked but still poorly performance wise. The gas goes very quickly still and I have to fill it way too often now in its condition. I’ve spent about $5400.00 in total with trying to repair and keep gasoline in it to work. I’m taking it back to the dealership today after reporting this to NHTSA.

Air bags malfunction. There is a warning ️ pop up message on my dashboard that says, Air bags malfunction contact manufacturer dealer. This is clearly a safety issue and it should be part of a recall or a recall needs to be started with this issue.

Odometer Fraud. The contact purchased a 2016 Toyota Rav4. It was discovered that there was a mileage discrepancy. The vehicle was purchased from a private seller. At the time of the purchase, the mileage was 98,000. The vehicle was taken to an independent mechanic, and a Carfax report indicated that in November 2025, the mileage was reported at 170,000.

The contact owned a 2016 Toyota Rav4. The contact stated while driving 30-40 MPH and attempting to change lanes, the contact looked through the sideview mirrors and then looked forward. The contact noticed that the vehicle in front of the vehicle had stopped. The contact depressed the brake pedal, but the vehicle did not stop in time and rear-ended the other vehicle. The contact's dog was occupying the front passenger's side seat and was not wearing a seat belt. The contact stated that it was a fender-bender; however, the driver's side and passenger's side curtain air bags deployed in addition to the front air bags, causing the vehicle to be totaled. The contact stated that the front driver's side air bag deployed and hit the contact's face, and the contact's eyeglasses caused a bruise on the contact's eyebrow. The contact also sustained a bloody nose and soreness on the forehead. The contact sustained bruises from the shoulder to the elbow after being hit by the driver's side curtain air bag. A police officer called medical personnel, who took the contact's blood pressure, checked the contact's injuries, and confirmed that an ambulance was not needed. The contact had not sought medical assistance. The contact stated that the hood of the vehicle opened and closed upon impact, and one of the coolant hoses was leaking. The trunk of the other vehicle opened and closed upon impact, and the other vehicle sustained minor damage to the fender. The other vehicle was drivable, and the other driver did not sustain injuries. A police report was filed, but the police report information was not available. The vehicle was towed and deemed a total loss by the insurance company. The dealer and Pedersen Toyota(4455 S College Ave Fort Collins, CO 80525) were notified of the failure, but no assistance was provided. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000.

The contact owns a 2016 Toyota Rav4. The contact stated that the liftgate failed to properly close while pressing the electrical buttons on both the key fob and the two liftgate buttons located inside or outside the vehicle. The contact stated that the liftgate had to be closed manually to securely close the liftgate. The contact stated that after her daughter had loaded groceries inside vehicle, the liftgate failed to latch properly but was closed after several attempts. The vehicle was taken to the dealer, and the contact's daughter was informed that the hinges and liftgate needed to be replaced. The contact was provided with an estimate for the repair. The manufacturer was notified of the failure and provided the contact with a case number. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 108,000.

Rear seat belt passenger side would not unlatch, trapping the passenger. This was and is the only time we have ever used this seat belt.It took two people to help get her thru the upper part of seat belt,had to exit over the top of back seat passenger. This life saving mechanism was and is unsafe and could of caused death if in the event of accident with fire. We have Owned two other Toyota's. Never any other dangerous life threatening events. Our request is the right thing to do. Replace this inoperative major defective part at an authorized Toyota Dealership here in. Dayton Ohio? Do we need to report this to the Highway Safety Dept.? [XXX] & [XXX] . Please respond. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact leased a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) and requested to be removed from the recall distribution list because the contact no longer had the vehicle. The dealer and the manufacturer were contacted.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

UNKNOWN - UNABLE TO COMPLETE REPAIR IN VEHICLE’S CURRENT LOCATION. This car is currently being stored in England and requires shipment back to the United States per my lienholder and military orders. Because of the recall that is currently open, the government’s provided shipment service (Mildenhall VPC) refuses to ship the vehicle unless I can get this repair performed locally. I’ve contacted numerous Toyota dealerships regarding this recall, and none of them have been able to address the repair due to the car not being made within the country, lack of OEM parts, etc. I’ve been back in the United States for over a month now, and the car is being stored with my friend/power of attorney until I’m able to get some resolution to this situation. I’ve tried to ship it numerous times now and they are refusing to do so unless the repair can be performed (which isn’t possible) or it is cleared from the VIN’s recall notice.

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

The contact owns a 2016 Toyota Rav4. The contact received a notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owned a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); and requested to be removed from the recall distribution list. The local dealer was not contacted; however, the manufacturer was contacted.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the battery charge was reduced, and the vehicle would not immediately start and the vehicle occasionally stalled. The contact also stated that the battery was replaced on four occasions. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The failure mileage was 91,475. Parts distribution disconnect.

The contact owns a 2016 Toyota Rav4. The contact stated that the battery warning light was illuminated, and the battery was replaced at the local independent mechanic. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Headlights and taillights are fogging/hazing up to where they dimmed out the lights when turned on making is somewhat difficult to see or others behind me to see me.

shudder in the torque converter of certain 2013–2018 Toyota RAV4 models. The shudder could occur while driving at light throttle between 25–50 miles per hour. 

I had a significant car accident in 2020 and luckily only broke my thumb. I was rear ended. The car I had at the time was a brand new Toyota Rav4, which luckily did have side airbags and they deployed appropriately. However, I have since had the opportunity to drive other vehicles and would like to ensure the safety of myself and others on the road whether the car be foreign or domestic. Please see the following requests: 1. Toyota's electronics freeze intermittently. This is not the first Toyota Rav4 that I have had and it seems to have done this in the majority of them (2/3). This is dangerous as it can become a distraction to the driver if not familiar with this abnormality. The backup camera also variously changes it's functions, preferences, and layout. 2. The navigation system has to be updated by a chip instead of updated wirelessly. 3. It is not an electric vehicle. 4. I should not have to pay for gasoline or electricity if the sun can be used as a fuel source. Please research the and utilize solar cell panel paint to charge all electric cars and implement that into all domestic and foreign electric cars as soon as possible due to the inflating economy. 5. With full self driving availability please ensure that all cars on the road, whether they be electric or gas, have this capability due to safety issues as well as the extent of morbidity and mortality cases due to trauma patients. I have already emailed you on this problem. Please follow up. 6. Due to the younger generation and their addiction to social media as well as their cell phones, please ensure that there is voice capability within all cars. It may also be beneficial for a camera to be installed inside of the car since the younger generation is so prone to filming themselves. This would also help with liability issues if an accident were to occur. 7. Ensure there is a way to charge a cell phone without needing to plug in the phone.

The contact owns a 2016 Toyota Rav4. The contact stated that after driving and parking the vehicle, the vehicle failed to restart. The contact opened the hood and saw smoke. The contact stated that the battery had melted. There were no warning lights illuminated. The local dealer was contacted, and the vehicle was inspected at the residence. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was towed to the local dealer, where it was diagnosed and determined that the failure was related to the electrical system. There was also fluid leaking from the battery. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 130,000. VIN tool confirms parts not available.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The braking system malfunctioned during Winter and snowy road conditions. Several instances happened during the month of December 2023 and 2024. Latest were December 10 and 13, 2024. The brake pad was soft when depressed that the car accelerated instead of stopping.

PBD has not worked properly since I purchased the car [XXX]. It was a 2016 used Rav4 with 54,000 miles. I have taken the car to two different dealerships complaining several times in person or on the phone stating my PBD either won't open or won't close. It has gotten to the point where I have to manually shove the door closed. There is a lawsuit currently that was filed against Toyota for knowingly and concealing the issue. "Who: Plaintiff [XXX] filed a class action lawsuit against Toyota Motor Sales USA Inc. Why: [XXX] claims Toyota failed to disclose an alleged defect in power liftgates on its model year 2014-2021 RAV4s. Where: The Toyota power liftgate class action lawsuit was filed in California federal court." I have also called Toyota's Corporate office to make a formal complaint. Case # [XXX] . At the time of purchase, I had also purchased an extended warranty on the vehicle through Toyota that Toyota did not honor. There are several forums online where many people have complained about this well-known problem. Toyota has refused to acknowledge this issue. If the hinges do completely break, the door will detach from the vehicle causing an accident. They need to replace the hinges with a larger or more stable material, so the PBD can function correctly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sunroof exploded while driving on the freeway, approximately 60 MPH.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while his wife was driving approximately 30 MPH, the instrument cluster and the infotainment display were turning off and on and resetting. The contact stated that his wife parked the vehicle and while attempting to restart the vehicle, the vehicle was not starting. The contact was able jumpstart the vehicle. The contact's wife drove the vehicle to a battery store where the battery was checked and was confirmed that it was within normal operating procedure. The failure reoccurred and the contact was able to drive the vehicle to a dealer where it was diagnosed and determined that the battery needed to be replaced. The contact questioned the dealer about NHTSA Campaign Number: 23V734000 (Electrical System) and was informed by the dealer that the recall repair was completed. The vehicle was not repaired. The failure mileage was approximately 96,000. VIN tool confirms parts not available.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Headlights are cloudy to the point of dimming the visibility of the light. When I asked the dealer, they could not clean headlight apparatus. I also cannot clean the buildup as it is on the inside of the headlight cover. I feel that this is a defective part that could potentially be the cause of an accident.

I needed a battery change so I changed it.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Numbers: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

On July 13th I was driving at a slow speed and I was making a right turn and the steering wheel felt like it was locked in not being able to turn into my lane and so a car coming into my direction, so quickly I had to stop across the opposite lane to let the car go by me, Then I looked at the dashboard it had the steering wheel and brake symbol illuminated, so I tried to restart the motor but it made the clinching noise telling me that still running so I stopped and restarted the motor and the symbols went off and continued driving with caution, made it home safe

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.