Toyota RAV4 2011 — Reported problems

Airbag light is on

Odometer Fraud. The contact purchased a 2011 Toyota Rav4. The contact discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 89,000. It was later discovered upon checking the Carfax report that the mileage was 230,000.

The contact owns a 2011 Toyota Rav4. The contact stated that while driving at various speeds, there was an abnormal clunking sound coming from the rear end of the vehicle. The contact stated that the vehicle felt as if the rear suspension had failed. The vehicle was taken to a certified mechanic, who determined that the rear suspension arms were detaching from the subframe. The dealer was contacted and informed the contact that the vehicle was previously included in TSB: 0042-14, NHTSA ID Number: 10060729 (Suspension), and was repaired in 2013. The contact was informed that the VIN was not included in NHTSA Campaign Number: 16V596000 (Suspension), and the campaign had since expired in 2019; and the repair was not covered. The vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that the campaign had expired. The failure mileage was approximately 195,000.

The contact owns a 2011 Toyota Rav4. The contact stated that while driving and depressing the brake pedal to come to a complete stop, the vehicle continued to accelerate unintendedly. The contact continuously depressed the brake pedal and shifted to neutral(N), and the vehicle responded as intended. The contact stated that the failure recurred while at a complete stop and while reversing from the driveway onto the roadway. The failure only occurred while the cruise control was activated but not set. The contact previously owned another 2011 Toyota Rav4 vehicle, which also experienced the failure. An independent mechanic informed the contact that the manufacturer had previously provided a remedy for the failure. The dealer and the manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 135,000.

I bought a pre-own car for my daughter in November 2022 from CARMAX in the City of Colma, California. The car is white color 2011 Toyota Rav4. In March 2025, my daughter started noticing the paint peeling off from the roof and driver side front panel. I found out that the paint issue is due to the defects from manufacturer when I visited paint shop to repair. I did researched online and found out Toyota had Customer Support Program until December 2022 for the issue. I contacted Toyota Corporate office but was told that CSP has ended and nothing they can do. Even though I am now aware that CSP has ended in December 2022, I found that it is unfair for the owner whose car just started exhibiting the issue after the program ended especially for the second owner like me who has never received any notice about the issue and bought the Toyota believing it will be a good investment. Can you please look into the issue and help for those owner like me who are unfairly left out? The attached picture shows the current condition of my car for your reference.

Odometer Fraud. The contact purchased a 2011 Toyota Rav4. The contact discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 146,000. It was later discovered, upon checking with the local State Secretary, that the mileage was 190,000.

Electric power steering problem, steering wheel is very stiff and wont return to center ,car is very difficult to drive, I have read that nhtsa issued some safety recalls on 2011 toyota rav4 related to this mfg. defect in the circut board -ecu -electronic control unit in the electric power steering , I purchased this used car on 9/17/2025 .I am taking it to Toyota dealer 10/9/2025

The contact's sister owns a 2011 Toyota Rav4. The contact stated while the vehicle was at the dealer for a service appointment, the dealer performed the recall repair of NHTSA Campaign Number: 16V096000(Seat Belts); however, after the recall repair, the seat belts became inoperable. The dealer was made aware of the failure and informed the contact that a diagnostic fee was required. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the vehicle back to the dealer. The failure mileage was 120,000.

The contact owns a 2011 Toyota Rav4. The contact stated while reversing to park the vehicle, the vehicle unintendedly accelerated. The contact depressed the brake pedal, and the vehicle stopped. The contact stated that after turning off the vehicle and entering the residence, the vehicle independently restarted. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.

235/55R 18 I took my car for a tire rotation at a tire shop. I was told that the right front tire was not good so I asked to be replace with another new tire I had, which was exactly the same Yokohama tire my car had on. When I drove off the shop the tire started making a weird loud noise so I drove back to the shop. They switch the tire to the rear and there I noticed that was a different tire, not the new tire I have provided them. I asked the guys where my tire was and why they had switched it with an old-use worn tire. They denied doing so and refused to give me back my tire. Besides putting a used-worn out tire, the tire also has a different speed rate than the rest of my tires. Since it is raining in Houston and having different speed tires is itself dangerous, I found this improper and in disregard of putting my safety in danger. My tire was a Yokohama Brand; The shop switched it to a worn-used Dimax brand with a different speed.

A lot oil consumption from oil change to 1000 miles 4 quarts of oil consumption no warning light until car stops I’m been charging oil every 4 k miles now I have to check oil every day is been almost 4years with this problem

I understand there is a recall on Rav4 starting fire from 2013. Our vehicle is a 2011 and started on fire in our driveway and is a total loss. May need to include other years.

After pressing the accelerator pedal, I released the pressure on the pedal because of traffic and the accelerator continued to accelerate. had to hold the brake pedal down and then shifted to Park and shutoff engine. When restarted the car operate normally. This has happened in the past and is very scary and unsafe. My internet research on problem shows that there have been two problems associated with this occurrence. One, accelerator trapped by floor mats and the second was because the accelerator pedal could "stick". The floor mats are secured by manufacture securing systems so it must be the in the sticking pedal. I am contacting Toyota but not optimistic...is there anything the NHTA can do for Toyota at least checking my car for a sticking accelerator pedal sticking. Finally, has there been any other reports of this happening?

Everything working

I bought my RAV4 in May 2018, and it currently has just under 100,000 miles. My local mechanic says he "was kneeling on the driver's seat while reinstalling the center console after replacing the e-brake cable, when the side curtain air bags deployed!" He is frantic as this has never happened before, and his shop insurance won't cover the replacement costs. I know that insurance companies tend to "total" cars after air bags have deployed. Have you ever heard of such an incident with the recalled 2011 RAV4 air bags?

Unknown

The contact owns a 2011 Toyota Rav4. The contact stated while stopped at a red light with the brake pedal depressed, the vehicle accelerated and rolled forward. The contact quickly put the vehicle in park and was able to pull over down the road. The contact stated that while pulling over and then shifting from park to drive with the brake pedal depressed, the vehicle accelerated, and the contact quickly shifted back into park. There were no warning lights illuminated. The vehicle was left in front of an independent mechanic shop. The independent mechanic diagnosed that the canister purge valve needed to be replaced and the throttle body needed servicing. The vehicle was repaired. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 193,751.

The contact owns a 2011 Toyota Rav4. The contact stated while driving at slow speeds, there was a loud banging sound coming from the rear of the vehicle. Upon inspection, it was discovered that the subframe was severely rusted and the rear differential fluid was leaking from the vehicle. The cause of the failures was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 111,000.

Side curtain airbag failed to deploy in side-impact crash. Passenger suffered significant concussion and broken ribs.

To begin with, the 2011 Toyota Rav4 in question was a loaner provided to me by Fiore VW AUDI (1000 S. Logan Blvd in Hollidaysburg, PA 16648) at @ 10:45 AM on 9/16/23. My 2018 Toyota Sienna was being serviced at this location on 9/18/23 and they provided me the 2011 Rav4 in the meantime. The brakes failing, the steering wheel locking up, and the sudden acceleration of this 2011 Rav4 occurred later that afternoon @ 4 PM in a Sheetz parking lot at 3261 W. College Ave. State College, PA 16801. As I was turning left into an open parking space at the rear entrance of this Sheetz, I began to turn the steering wheel to the right, straighten out, and park properly in the parking space; I also began to press down on brake to stop the car. As I pressed down on the brake pedal, the brakes quickly locked up and became unresponsive. Simultaneously, the steering wheel locked up becoming unresponsive with the front wheels still slightly turned to the left. I was still coming out of my turn when this vehicle failure began. I quickly took my foot off the brake, then the car suddenly burst forward with an intense acceleration. I immediately put my foot back down on the brake, but the car still proceeded forward towards the building; moving slightly to the left due to the steering wheel still locked in place and unresponsive. I slowly rolled into a metal obstruction at the end of the parking space, hitting it at an angle. I had my seat belt on and no air bags were deployed. No injuries to me, but some cosmetic damage to the front of the Rav4. There were no warning lights or audible warnings prior to this vehicle failure. I didn't notice any warning lights or alarms during the failure. Prior to this incident everything seemed fine. After the incident, I drove the car home, drove it to my insurance agent on 9/18/23, and I drove it back to the dealer on 9/20/23. That was it. I would believe Sheetz has this complete incident recorded w/security cameras at that back entrance way.

Sudden acceleration when braking caused crash of 2011 Toyota RAV4 and driver injury. Making a right turn into a parking space that faces a concrete wall, I had my foot on the brake to slow the car down to park, going about five miles an hour. Still riding the brake, never having moved my foot off it, when I was about two feet from the wall I pressed on the brake to ease into a stop. Instead, the car suddenly accelerated with a loud rev and crashed into the wall. The car was going so fast the airbag deployed and thrust me against my seatbelt. Airbag caused fracture of 5th metacarpal in my right hand. Was unable to drive for 12 weeks. When I got the car back from the Toyota Body Shop ($9000+ in repairs), I took it over to the dealer and began filing a case with the Toyota Customer Experience Center to have Toyota inspect the car. I am especially concerned about the brake sensor system. Case is pending

In hot weather the steering wheel sticks and is hard to turn and will not allow car to straighten up after the turn.

For the past three months, in increasing frequency, whenever parking, firm pressure on brake pedal engages sudden burst of acceleration, with engine loudly revving at 1000 revs or higher (audibly beyond the cabin to passers by on the street), that lurches vehicle forward.Within close spaces of parking garage pillars or walls or while parallel parking this is a hazard and threatens sudden accident of 1 mph or less up to 5-10 mph and a 1-2 yard-long jerking lurch to try to recover from. This occurred, twice this week, and 4 times within past 3 months’ time, to where this is no longer a fluke or due to my immediate reactions. This is an increasing pattern that threatens myself and others. I am headed to local dealership, within the hour, to request diagnostics and to attempt to have technician repeat this issue.

The contact owns a 2011 Toyota Rav4. The contact stated that while driving approximately 25 mph, the vehicle in front of her abruptly stopped for an animal that jumped onto the road, as a result, the vehicle accelerated and crashed into the rear of a Toyota Prius. The brake pedal was continuously depressed. The "low tire" message was displayed. The driver sustained injuries to her knee, neck, and chest, and medical attention was provided. There was not a report of any fire, air bag deployment, or police report being filed. The vehicle was taken to her residence. The vehicle was towed to the collision center. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 143,000.

Driver's side rear passenger seat belt keeps getting jammed in the intake storage and hard to nearly impossible to engage. Had it fixed a few times but passengers continue to have difficulty pulling the seat belt from its storage position.

There has not been an incident yet. The problem is that the steering is slightly stiff and what I would call jerky. It kind of sticks as you turn and you have to exert a little more pressure on the steering wheel and it lets go and moves on to where you wanted. It is not intermittent and it is getting worse all the time. The car has 74,000 miles on it. Is there a danger of this locking up some day to where a person would loose control of the car, or is it just an aggravating nuisance ? The exact date this started is not known but it has probably been at least 18 months. It is the worst at slow speeds.

When applying the brakes to stop at a stoplight, I noticed the brake pedal was very hard and was not stopping the vehicle as it normally did. The stop at the light was not a sudden stop. At the time this incident occurred, the brakes were being gradually applied as the vehicle was coasting to a slow stop. As the vehicle came to rest, the engine started to race with tachometer showing 4500 rpm. I placed the transmission into neutral fearing the car would accelerate through the stoplight. As I placed the car into neutral, the engine raced up to 6500 rpm. When the light turned green, I made a right turn into a parking lot, and the engine stopped racing and the brakes and engine began performing properly. Today was the first time this happened. The stop was being made on level ground at time of incident. The car's speed before the incident had been 35 mph and was at less than 5 mph when issue began happening. Prior to traveling in the 35 mph zone, the car had recently been on the highway traveling between 55-70 mph for 20 minutes. Mileage on vehicle is currently 141,295. The vehicle is available for inspection. Slow response braking and unintended acceleration place vehicle occupants as well as other vehicles at risk for collision and possible injury. Problem has not been reproduced nor inspected by a dealer or independent service station yet. No parties have inspected the vehicle yet. No warning lights or messages were generated at the time of the incident. There have been no prior symptoms or similar problems which would have indicated this brake/acceleration issue may occur.

I have replaced the front suspension and the back suspension. I have replaced the driveshaft and the muffler and tail pipes. Now they say the entire undercarriage and the brake lines are all rusting out. This car is 2011 and has just 34,607 miles on it and has been keep in a garage its entire time. Now it is unsafe to drive. Drive Shaft fell off in December.2022.

The contact owns a 2011 Toyota Rav4. The contact stated that while pulling into a parking space the vehicle suddenly experienced unintended acceleration and accelerated forward crashing into a parked van. During the incident, the airbags did not deploy. No injuries were reported and no police report was taken. the vehicle was later towed to a collision center and repaired. The cause of the failure was not determined. The contact indicated that the same failure had occurred after the husband stopped at a red light. During the incident, the vehicle suddenly accelerated forward and crashed into the rear of a second vehicle. No injuries were reported and no police report was taken. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failures. The VIN was not available. The failure mileage was 85,000.

Spare tire rear mount cover. The cover is made out of metal and fabric. After a few years the thread holding the material that holds the cover on deteriorates causing the metal cover to fall off. This happens while driving the car having the paint matched metal disk to fall off while driving leaving a tire sized metal disk bouncing around in traffic endangering other cars and drivers. Thread and zipper need to be made out of a better material or a hard latched metal band could be used to hold it on like many other manufacturers do.

Steering : Steering is tight to a point where it takes effort to get the steering wheel to turn . I tried adjusting the column up and down . It may ease the problem temporally , but it returns .

I have discovered that my 2011 rav4 is part of the NHTSA Recall No. : 16V-596 even thought my vin doesn't list it as being part of the recall. As I recently tried to get a rear wheel alignment done due to misaligned rear tires (bowing out). The 3rd party mechanic stated that doing a rear wheel alignment was impossible due to NHTSA Recall No. : 13V-383 repair/fix done by a Toyota dealer where epoxy resin was used to seal the right and left Rear Suspension Lower Arm No. 1 (“arm”) for looseness. The only way to complete the alignment safely would be to completely replace the right and left Rear Suspension Lower Arms. Which perfectly matches the required fixed from the newer NHTSA Recall No. : 16V-596 which remedies the improper temporary repair/fix done by the Toyota dealer to fix the earlier NHTSA Recall No. : 13V-383. As such the VIN range and manufacture date for the NHTSA Recall No. : 16V-596 likely need to be extended to cover all rav4 2011 models.

The car had 115,000 miles on the engine and was just at 3,000 miles post oil change. Making a left turn over oncoming traffic the car died. Barely missed having an accident. As the car sat it did restart. No lights on the dash for engine issues. Drove 2 miles directly to my mechanic. The car had half a quart of oil remaining! Car now closely monitored burns 1/2 quart every 500 miles and more if highway driven.

I was Driving down the road, and the engine quit. At that time smoke started pouring out of the hood and into the car, through the vents. I pulled over, the power breaks no longer worked but I was able to stop. I got out of the car quickly to avoidmore smoke inhalation. Flames were already starting to come out. Within a few minutes the entire car was engulfed in fire. Possibly the fuel line had a problem. Car was a total loss. Police were present. there were no warning lights or symptoms before hand. It was the best car I ever had and was working perfectly.

Making a left hand turn across traffic and the car completely shut down. Restarted car. A mile later making a right turn and the car completely shut down. Took the car to my mechanic and they had it fail 3X while turning. Only 2000 miles since last oil change I had less than a quart of oil remaining. Oil burning / consumption put me and others at serious risk for a car accident.

when i driving around 50 miles the car is producing a grinding noise, stalling and reducing the speed, putting in danger the cars driving behind us. that kind of fail is on and off.

The contact owns a 2011 Toyota Rav4. The contact stated that the vehicle was leaking differential fluid. The local dealer was contacted and informed of the failure. The contract was informed that the vehicle was not covered under the extended warranty. The vehicle was taken to an independent mechanic and the contact was informed that the viscous coupling unit needed to be replaced. The manufacturer was notified of the failure however, no further assistance was provided. The failure mileage was approximately 80,000.

The contact owns a 2011 Toyota RAV4 equipped with Kelly Tires (Brand Unknown), Tire Size: 225/65/R17 DOT NUMBER: (Unknown). The contact stated that upon start of the vehicle, her tire pressure warning light would illuminate on the instrument panel. The contact stated that she would frequently add air to her front, driver side tire as the air pressure would frequently run low. The tire had yet to be replaced. The tire was a replacement tire. The tire failure mileage was approximately 3,000. The vehicle failure mileage was approximately 90,000.

TL* THE CONTACT OWNED A 2011 TOYOTA RAV4. THE CONTACT STATED THAT THE TRACTION, ANTI LOCK BRAKING SYSTEM AND THE 4 WHEEL DRIVE WARNING LIGHTS WOULD INTERMITTENTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO GARY FORCE HONDA (2325 SCOTTSVILLE RD, BOWLING GREEN, KY 42104) WHERE SHE PURCHASED THE VEHICLE AND THEY DIAGNOSED THE VEHICLE WITH A DEFECTIVE TRACTION, ANTI-LOCK BRAKE AND 4 WHEEL DRIVE SENSORS. THE CONTACT WAS GIVEN AN ESTIMATE FOR THE REPAIRS BUT THE VEHICLE WAS NOT REPAIRED. ONE DAY WHILE DRIVING AROUND A CURVE AT 30 MPH, THE VEHICLE HYDROPLANED AND FLIPPED OVER, LANDING UPSIDE DOWN. THE SIDE AIR BAGS DEPLOYED UPON IMPACT; HOWEVER, THE DRIVER AND PASSENGER AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AT THE SCENE. THE CONTACT WAS TREATED AT THE SCENE FOR MINOR CUTS TO HER FACE. THE CONTACT WENT TO THE HOSPITAL THE NEXT DAY FOR CHECK UP, DESPITE BOTH THE CONTACT AND THE PASSENGER EXPERIENCING SORENESS DUE TO THE ACCIDENT, NO MAJOR INJURIES WERE REPORTED. THE VEHICLE WAS TOTALED AND TOWED TO AN INDEPENDENT JUNK YARD. THE MANUFACTURER NOR A TOYOTA DEALER HAD BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. *DT*LN*JB*JB

AIRBAG LIGHT HAS BEEN ON ENTIRE OWNERSHIP ALONG WITH SEATBELT LIGHT FLASHING FOR PASSENGER SEATBELT. WHETHER BUCKLED OR UNBUCKLED. OR EVEN WHEN NOBODY IS IN THE FRONT PASSENGER SEAT. CONSTANT ISSUE WHETHER STATIONARY, IN MOTION, AND ON HIGHWAYS/CITY STREETS.