Toyota Highlander 2004 — Problemas relatados

Hello, I am the Buyer of the subject Vehicle, Upon doing my research, I found out several reports stating that The subject vehicle's 2.4L engine has manufacturing defect, that causes Head Bolts to get stripped/melt down in to oil causing Engine failures and Life threating risk in the middle of the road.

My car malfunctioned my tire locked up while I was driving on the high way causing me to spin out of control and skid all the way into a guard rail totalled my car out and not one air bag went off

The passenger airbag occupancy sensor in my car has stopped sensing a passenger has been stuck on "OFF" for the past 2-6 months (I believe) even when an adult is sitting in the seat. I don't know exactly when this problem began because there was never any warning light or error message which is a massive safety oversight since I could have been in accident with no knowledge that it wasn't working properly. The car is currently at the dealership and they are telling me it's $1300 to replace the sensor and that there is no way to bypass the sensor and just have it "ON" for the safety of my passenger. There is already a recall for this same system in newer Highlanders, but why is there no support for older Highlanders?

The contact owns a 2004 Toyota Highlander. The contact stated while driving at an undisclosed speed, the front bumper inadvertently detached. The vehicle was taken to an independent mechanic where it was determined that the front lower bumper covers had been attached with mounting tabs and that the bumper assembly had failed and needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 190,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE AND PRESSING TO BRAKE PEDAL, THE PEDAL FAILED TO RETURN TO THE IDLE POSITION. THE VEHICLE STABILITY CONTROL MESSAGE DISPLAYED ON THE INSTRUMENT PANEL AND THE VEHICLE FAILED TO EXCEED 40 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS THEN DRIVEN TO THE LOCAL DEALER GROOVE TOYOTA LOCATED AT 5460 S BROADWAY, ENGLEWOOD, CO 80113 HOWEVER, THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE MANUFACTURER WAS NOT YET CONTACTED. THE FAILURE MILEAGE WAS 126,000.

WHILE TRAVELING THROUGH A HIGHWAY CONSTRUCTION ZONE MY CAR SUDDENLY BECAME HARD TO STEER, AND MY SPEED BECAME GREATER, TRIED TO (BREAK) DECELERATE THE CAR BEGAN SLIDING OUT OF CONTROL-PLOWING INTO THE ROAD CONSTRUCTION BARRIERS PART LODGED IN FRONT PASSENGER WINDSHIELD. THE CAR WENT THROUGH THE DITCH BECAME AIRBORNE THROUGH A ROD IRON FENCE SHATTERED THE REAR SECOND-ROW RIGHT SIDE WINDOW SPUN OUT , AND CAME TO REST JUST FEET FROM THE SOME PILEINGS. THIS IS THE INFORMATION OF MY DAUGHTER WHOM IS AN OUT OF STATE COLLEGE SENIOR AND VERY SHAKEN UP FROM THIS ORDEAL, THIS HER STATEMENT TO THE BEST OF MY KNOWLEDGE. POSSIBLY THE PLACEMENT OF THE 🚧 COULD HAVE BEEN A CONTRIBUTOR, AND THE UNCONTROLLABLE ACCELERATION. VEHICLE WAS BOUGHT USED A YEAR AGO. CAN YOU HELP UP LEARN WHY?

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS LOW SPEEDS, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. UPON APPLYING MINIMAL PRESSURE TO THE ACCELERATOR PEDAL, THE ACCELERATOR PEDAL BECAME STUCK AND THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE, A DUMPSTER, AND ALMOST STRUCK A GROUP OF CHILDREN BEFORE COMING TO A STOP. IN AN ATTEMPT TO STOP THE VEHICLE, PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL AND THEN THE BRAKE PEDAL. THE VEHICLE FINALLY STOPPED AND WAS TURNED OFF. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SEVERE PAIN TO THE NECK AND BACK, WHICH REQUIRED MEDICAL ATTENTION. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE CRASH. THE VEHICLE WAS SUBJECT TO NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT ASSEMBLY MALFUNCTIONED AND THE FABRIC MATERIAL STRAP BECAME FRAYED AND SHREDDED AT THE BUCKLE LOCATION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (ATLANTIC TOYOTA IN LYNN, MASSACHUSETTS) AND MANUFACTURER WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 150,000. *JS

THE TRANSFER CASE IS LEAKING AFTER ONLY 68000 MILES. THE LEAKING OIL DROPS OVER THE HEATED EXHAUST PIPE WHICH CAUSES FUME IN THE CABIN THROUGH AIR CONDITION AND FAN

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, WHILE DEPRESSING THE BRAKE PEDAL, THE PEDAL TRAVELED TO THE FLOOR. THE TRACTION CONTROL, CHECK ENGINE, VSC, AND BRAKE INDICATORS ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 10V499000 (SERVICE BRAKES), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT OBSERVED BRAKE FLUID LEAKING FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,489.

MY TRAC OFF LIGHTS, ENGINE AND OIL LIGHT CAME ON WHEN I WAS DRIVING TO WORK. I WORK FAR FROM HOME SO I TOOK IT TO THE VALVOLINE NEAR MY JOB TO CHECK THE OIL. I DIDN'T WANT TO DRIVE MY CAR HOME IF THERE WAS NO OIL. THEY CHECKED THE OIL, UNDERNEATH MY CAR AND SAID EVERYTHINGWAS FINE AND TO TAKE TO MY MECHANIC TO CHECK THE ENGINE. I TOOK IT TO MY MECHANIC WHO KEPT IT FOR 4 DAYS AND SAID ITS THE OIL SLUGE AND HE WAS TRYING TO SAVE THE ENGINE. MY MECHANIC SAID THEY HAD A LEXUS IN THE WEEK BEFORE WITH THE SAME PROBLEM. I CHECKED ONLINE AND FOUND OUT THERE WAS RECALL FOR THIS PROBLEM IN 2002, AND TOYOTA ONLY CONTACTEDTHE ORIGINAL OWNERS NOT ALL PEOPLE WHO HAD REGISTERED CARS. I BOUGHT THIS SECOND HAND THROUGH CAR MAX IN 2010 AND THIS SHOULD HAVE BEEN CORRECTED THEN. MY CAR HAS 145,000.00.

THE OUTER RING OF THE CRANK SHAFT PULLEY HAS PULLED AWAY FROM THE INNER RING CAUSING DAMAGE TO ALL SYSTEM AND CAN AFFECT STEERING. THIS ALREADY HAS A RECALL FOR MY MAKE, MODEL AND YEAR, BUT NOT FOR MY VIN NUMBER. IT SEEMS STRANGE THAT THIS EXACT SAME THING THAT HAS THE RECALL AFFECTS MY CAR, BUT REPAIR IS NOT COVERED. SHOULD RECALL BE EXPANDED TO INCLUDE OTHER VIN NUMBERS??

THE PASSENGER SIDE IN THE REAR WINDOWS ARE DEFECTIVE. THEY WILL NOT POWER UP OR DOWN THE WINDOWS IN THE BACK OF SUV. ALSO THE FRONT PASSENGER SIDE IS NOW NOT OPERATING UP OR DOWN. THE POWER WINDOW PARTS HAVE FAILED TWO YEARS AGO, AND NOW IT'S HAPPENING AGAIN. THIS 2004 SHOULD BE INCLUDED IN THE OTHER RECALLS ON NEWER MODELS.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE REQUIRED GREATER EFFORT TO STEER. WHILE STEERING THE VEHICLE, THERE WAS AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WERE IT WAS DIAGNOSED THAT THE STEERING INTERMEDIATE STAFF ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 123,000.

THIS HAS BEEN GOING ON FOR TWO DAYS NOW. THERE IS A BUZZING LIKE SOMETHING IS MALFUNCTIONING ON MY PASSENGER SIDE COMING FROM THE DASH I BROUGHT THE VEHICLE TO PEP BOYS AND THEY SAID THAT MY AIR BAG IS MALFUNCTIONING. IS RESULT OF THIS MY JOB WON'T LET ME DRIVE PATIENTS BECAUSE OF THE DANGER. THIS REALLY NEEDS TO BE FIXED. I KNOW FOR A FACT IT'S THE AIRBAG BECAUSE TOYOTA TOLD WHEN I BROUGHT IT THERE BECAUSE PEP BOYS TOLD GO TO THE DEALERSHIP FOR THEM TO CONFIRM AND IT WAS!. THIS HAPPENS IN MOTION AND A LITTLE WHILE IN MOTION. WHEN IT IS HUMID OUTSIDE THE BUZZING IS EVEN WORSER TO WHERE THE SIDE PANEL VY DRIVERS LEFT LEG VIBRATE.

TL* THE CONTACT OWNED A 2004 TOYOTA HIGHLANDER. WHILE DRIVING 20 MPH AND MAKING A RIGHT TURN, THE VEHICLE ACCELERATED TO APPROXIMATELY 75 MPH. THE VEHICLE CRASHED INTO AN OAK TREE. THE CONTACT WAS KNOCKED UNCONSCIOUS AND TAKEN TO THE HOSPITAL. THE CONTACT SUSTAINED KNEE, BACK, SHOULDER, AND CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND LATER DEEMED DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. *TR

I WAS DRIVING ABOUT 15 MPH ON A CITY STREETAND THE VSC INDICATOR LIGHT CAME ON AND THE VEHICLE STARTED BREAKING ON ITS OWN. A LOUD SCRAPPING SOUND WAS HEARD. IT WAS ABOUT 70DEGREES AND SUNNY AND THE CAR THOUGHT I WAS GOING DOWN A SLIPPERY SLOPE. I STOPPED THE VEHICLE. EVERY TIME I GOT ABOVE 8-10 MPH THE LIGHT WOULD COME ON AND THE CARE WOULD START BREAKING BECOMING UNABLE TO DRIVE.

IN FEB 2005 WHILE DOING ABOUT 30 MPH THE VSC LIGHT CAME ON AND STARTED BRAKING, ON IT'S OWN, TO THE RIGHT MAKING IT ALMOST IMPOSSIBLE TO DRIVE. THE NEXT MORNING THE CAR WAS TOWED TO THE TOYOTA DEALER. THE CAR DISPLAYED NO CODES AND THEY SAID THAT THEY HAD CALIBRATED THE STEERING ANGLE SENSOR. WE HAD NO FURTHER PROBLEMS UNTIL MAR 24, 2016. THIS TIME THE VSC INDICATOR CAME ON AT ABOUT 40 MPH. IF I SLOWED DOWN TO ABOUT 20 MPH THE INDICATOR WOULD GO OFF. WE WERE ABLE TO DRIVE THE CAR HOME BUT THE CAR BRAKED, ON IT'S OWN, SEVERAL TIMES. WE HAVE AN APPOINTMENT WITH THE TOYOTA DEALER. I'M AFRAID THAT THE EXPENSE TO REPAIR IT MAY COME CLOSE TO WHAT THE CAR IS WORTH. NHTSA NEEDS TO WAKE UP AND INVESTIGATE THIS ISSUE. IT'S BEEN GOING ON FOR A LONG TIME. THIS PROBLEM COULD RESULT IN A SERIOUS ACCIDENT IF IT OCCURRS AT HIGHWAY SPEEDS. I CAN'T IMAGINE WHAT WOULD HAPPEN IF THE CAR BRAKES ON IT'S OWN AT 75 MPH.

CAR IN MOTION @45 MILES AN HOUR AT 8AM 12/29/14. DRIVER LOST CONSCIOUSNESS DUE TO MEDICAL EVENT, WHICH RESULTED IN AUTO RUNNING OFF ROAD AFTER HITTING CURB AND SIDEWALK, THEN HITTING A ROADSIDE FENCE AT AN ESTIMATED 45 MPH. THE CAR THEN ROLLED AND LANDED ON ROOF. DRIVER WAS SEAT-BELTED. NONE OF THE AIRBAGS DEPLOYED DURING THE COLLISION. DRIVER SUFFERED TRAUMA TO HEAD AND OTHER INJURIES. CAR WAS RATED BY INSURER AS COMPLETELY TOTALED.

HEAT DOESN'T WORK AND A/C INTERMITTENTLY BLOWS COLD OR HOT. WINDSHIELD AND WINDOWS WILL FOG UP IN BAD WEATHER AND WITHOUT HEAT I CAN'T DEFOG THEM FORCING ME TO PULL OVER AND MANUALLY WIPE THE FOG OFF EVERY FEW MINUTES.

TRACTION CONTROL CAME ON DURING NORMAL DRIVING

WE HAVE A VEHICLE WITH A 2.4LITER/4 CYLINGER ENGINE THAT IS LOOSING OIL AT A RATE OF 1QRT PER 1000 MILES AND NOW THERE IS A COOLANT LEAK COMING FROM THE GASKET SEAL BETWEEN THE ENGINE BLOCK AND HEAD. THERE IS NO GUAGE THAT TELLS YOU HOW MUCH OIL IS MISSING UNTIL IT'S TOO LATE AND THE ENGINE STARTS TO OVER HEAT. BOTH THE OIL AND COOLANT IS LEAKING ON ROADS, PARKING LOTS AND DRIVEWAYS, WHAT WE HAVE FOUND IS THAT THE BOLTS THAT ARE NEAREST THE LEAK ARE STRIPPED, THEY EITHER STRIPPED IN ASSEMBLY OR FLAILED DO TO OVERHEATING OF THE BLOCK DO TO THE ENGINE BLOCK NOT HAVING SUFFICIENT COOLING BECAUSE OF A HEAVY FOAM PAD THAT RESTRICTS AIR FLOE AROUND THE ENGINE CAUSING THE HEAD TO FLEX AND LEAK AT THE GASKET SEAL BASED ON ONLINE COMPLAINTS THERE ARE HUNDREDS, IF NOT THOUSANDS OF OWNERS WITH THIS SAME PROBLEM. SEEMS THAT SOME OF THESE ENGINES ARE HAVING SUCCESS BY DRILLING, TAPPING AND INSERTING NEW COILS INTO THE ALUMINUM BLOCK, WHICH MAY OR MAY NOT BE A PERMANENT SOLUTION. IT SEEMS THAT TOYOTA IS AWARE OF THE PROBLEM AND REFUSES TO REPAIR THE DAMAGE. THE MOST COMMON SUGGESTED REPAIR IS TO REPLACE THE MOTOR AND WE ASSUME THAT THEY PROBLEM WILL HAPPEN AGAIN SINCE THEY HAVE REDESIGNED THE PROBLEM.. REPLACEMENT IS AT THE OWNERS COST FOR MATERIALS AND LABOR AT APPROX $6,000-$8,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH MICHELIN LTX M/S2 TIRES, SIZE: P225/75/R16 (NA). WHILE DRIVING 55 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE REAR OF THE VEHICLE BEGAN TO SHAKE. UPON INSPECTION, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE TIRE BLEW OUT AND THE THREAD SEPARATED FROM THE BELT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 98,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.

BEGAN DRIVING VEHICLE A WEEK AGO, USED TO BE MY WIFE'S VEHICLE. I NOTICED A SQUEAK IN THE DRIVER'S SEAT, AND NOTICED IT WIGGLED. I EXAMINED THE MOUNTING BOLTS, AND ALL 4 SEAT BOLTS WERE LOOSE, NOT EVEN FINGER TIGHT. THE ONLY SERVICE PERFORMED ANYWHERE NEAR THE SEAT WAS RECALL WORK ON THE FLOOR MAT RETAINING CLIP AND A SEAL IN THE BRAKE MASTER CYLINDER, BOTH RECALLS WERE DONE SIMULTANEOUSLY AT RUDY LUTHER TOYOTA, 8805 WAYZATA BLVD, GOLDEN VALLEY, MN 55426. RECALL WORK WAS DONE A COUPLE YEARS AGO. I TIGHTENED THE BOLTS WITH MY OWN TOOLS. PASSENGER SEAT BOLTS WERE TIGHT.

GAS STATION DID NOT CLOSE HOOD COMPLETELY AND IT BLEW OPEN WHILE TRYING TO ENTER THE HIGHWAY AT JUST OVER 40 MILES PER HOUR.THE SECONDARY SAFETY CATCH DID NOT HOLD OR WORK ! THE HOOD BLEW OPEN AND SHATTERED THE WINDSHIELD AND BENT THE HOOD UP INTO THE ROOF.THE TOPS OF THE FENDERS NEAR THE HINGES WERE ALSO RIPPED UP.

WHEN DRIVING THE HEATER OR THE AIR WILL JUST COME ON, USUALLY WHEN YOU WOULD DRIVE OVER A ROUGH SPOT IN THE STREET.USUALLY THE AIR WILL COME ON IN THE WINTER AND THE HEATER WILL COME ON IN SUMMER.CALL TOYOTA THEY SAID COST ABOUT 800.00. I HAD IT FIX BY AN INDEPENDENT GARAGE.IT STILL COST ME 370.00. THEN I GO ON LINE AND OUT THERE'S HUNDREDS IF NOT LOTS MORE PEOPLE THAT HAVE THE SAME PROBLEM.I THINK SINCE THERE IS SO MANY PEOPLE THAT THIS SAME PROBLEM THAT TOYOTA SHOULD REIMBURSE US AT LEAST PARTLY. *TR

WAS DRIVING ON THE HIGHWAY ABOUT 60-65 MPH WHEN ENGINE BEGAN OVER HEATING. PULL OVER RADIATOR WAS LOW. PUT ANTIFREEZE IN DROVE HOME CHECK WAS ALLOW AGAIN. THE NEXT CALLED TOYOTA DEALER, WITH OUT EVEN LOOKING THEY SAID YOU PROBABLY HAVE A BLOWN HEAD GASKET. BUT WHEN WE TEAR IT DOWN AND IF THE HEAD BOLTS ARE STRIPPED OUT IT WILL COST UPWARDS OF 2000.00. SO NOW I HAVE THE CAR IN AN INDEPENDENT SHOP. I'M OUT ALMOST 800.00 NOW, AND THE CARS STILL NOT FIXED. I BELIEVE TOYOTA KNEW ABOUT THIS PROBLEM LONG BEFORE I BOUGHT THIS CAR. I WENT ON THE INTERNET AND FOUND THE HAS BEEN HAPPENING IN 2001-2006 MODELS.I THINK THEY SHOULD BE HELD RESPONSIBLE. *TR

MY CAR BEGAN OVERHEATING AT 140K MILES. TOOK IT TO A MECHANIC AND HAD THE WATER PUMP AND THERMOSTAT REPLACED. THE CAR OVERHEATED AGAIN A WEEK LATER. TOOK IT BACK TO THE MECHANIC AND HE TOLD ME THE HEAD GASKET WAS BLOWN AND HAD TO BE REPLACED. WHEN HE WENT TO REPLACE THE GASKET HE FOUND THAT THREE HEAD BOLTS WERE STRIPPED ON THE BLOCK. THE CYLINDER HEAD BOLTS SEPARATING FROM LOWER PART OF ENGINE BLOCK CAUSED A COOLANT LEAK. THIS IS OBVIOUSLY A MANUFACTURING ERROR. THIS CAR WAS BOUGHT BRAND NEW AND HAS BEEN DRIVEN BY THE SOLE OWNER. HAD OIL CHANGES EVERY 3,000 MILES AND NEVER HAD AN ISSUE BEFORE NOW. PLEASE PLACE A RECALL FOR THIS DEFECT. THIS IS NOT THE OWNERS FAULT, NOR SHOULD IT BE THEIR RESPONSIBILITY. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH, THE BATTERY INDICATOR LIGHT ILLUMINATED AND THE POWER STEERING FAILED SUDDENLY. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE VEHICLE WAS NOT REPAIRED. THE VIN PROVIDED WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

AS SHOWN ON YOUR COMPLAINT SECTION I AMONG MANY MANY OTHERS HAVE BEEN SOLD A DEFECTIVE 2.4 LITER ENGINE 4 CYLINDER. THE HEAD BOLTS BECOME STRIPPED AND MIGRATE LOOSE OVER TIME AND THERE IS NO REPAIR SOLUTION. YOU HAVE TO SCRAP THE ENGINE AND MAYBE THE WHOLE VEHICLE NO MATTER HOW GOOD OF CONDITION ITS IN. THIS PROBLEM CAUSES A BLOWN HEAD GASKET AND RESULTING MAJOR LEAKAGE OF ANTIFREEZE WHICH IS A LIFE THREATENING CHEMICAL BABIES AND PETS DRINK AND DIE FROM. I FIRST FOUND THIS POOL OF ANTIFREEZE ON MY GARAGE FLOOR AND I HAVE 2 DOGS! NOT TO MENTION GETTING STRANDED OUT IN TRAFFIC OR A DESOLATE AREA WHEN ENGINE OVERHEATING OCCURS PUTTING YOUR OWN LIFE IN DANGER FROM BECOMING A STRANDED MOTORIST. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SEAT BELT FAILED TO RETRACT AND WOULD ALSO INTERMITTENTLY SEIZE. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. UPDATED 1/7/15*CN UPDATED 06/3/2015 *JS

MY VEHICLE IS HAVING AN ISSUE WHERE THE VEHICLE STABILITY CONTROL AND ABS ARE BEING DISABLED. THIS IS THE DEFAULT MODE WHENEVER THERE IS AN ISSUE. IT IS NOW OCCURRING EVERY TIME I START MY CAR. *TR

THE PASSENGER AIRBAG INDICATOR WARNING LIGHT CAME ON WHILE NOBODY WAS EVEN IN THE PASSENGER SEAT, WHILE TRAVELING ON A CALIFORNIA HIGHWAY. A CHECK OF THE TOYOTA OWNER'S MANUAL STATED THAT THE ENTIRE AIRBAG SYSTEM WOULD NOT FUNCTION IF THIS LIGHT CAME ON AND STAYED ON FOR NO REASON AT ALL. SINCE WE LIVE NO WHERE NEAR A DEALER, NEAREST DEALER IS 100 MILES AWAY, I LET IT STAY THAT WAY FOR AWHILE. THERE WAS ALSO A SAFETY PROBLEM WITH DEFECTIVE HEADLIGHTS ON THIS MODEL, WHERE THE ALWAYS ON DAYLAMPS MELT THE FRONT HEADLIGHTS AND LEAVE A VISIBLE MELTED BUBBLE, THAT THE DEALER REFUSES TO FIX BECAUSE THEY DIDN'T MANUFACTURE THE HEADLIGHTS AND THE VEHICLE YEAR AND MILEAGE IS OUT OF WARRANTY- BUT, WE STILL HAVE THE VEHICLE- THEY SHOULD STAND BEHIND THEIR PRODUCT. THEN, MOST RECENTLY, A SHUFFLING SOUND FROM BEHIND THE INSTRUMENT PANEL/ BEZEL CLUSTER OCCURRED AND MAKES THE WEIRD SOUND FOR 3 OR SO MINUTES SOMETIMES WHEN THE CAR IS TURNED ON. IT DOESN'T HAPPEN EVERY TIME, ABOUT EVERY 2 TIMES NOW. THE SOUND USED TO MAKE A CLICKING SOUND FOR ONLY 1 MINUTE- SO, IT'S GETTING LOUDER, AND LONGER. WE WERE ALSO TOLD BY A MECHANIC THAT THE SUSPENSION/RODS/SHOCKS ARE BAD AND WILL NEED REPLACED- THAT IS AN EXPENSIVE FIX. *TR

BRAKE PEDAL GOES TO FLOOR VERY SLOWLY AND VEHICLE SLOWLY CREEPS FORWARD. MASTER CYLINDER WAS REPLACED WITH NEW. (HISTORY: AT 79000 MILES THE TOYOTA FACTORY RECALL TO REPLACE THE MASTER CYLINDER CUP KIT WAS PERFORMED BY TOYOTA DEALER ). *TR

DRIVERS SIDE SUN VISOR WILL NOT STAY IN PLACE IN THE UP POSITION AND DROPS DOWN UNEXPECTEDLY. *TR

TRANSMISSION JUMPS AT DIFFERENT SPEEDS. *TR

I NOTICED THAT MY ORIGINAL EQUIPMENT/MANUFACTURER PASSENGER-SIDE LOW-BEAM HEADLIGHT LENS HAD A BURNT SPOT ON THE INSIDE OF THE LENS (CLEARLY MELTED LENS MATERIAL). I CHECKED THE HEADLIGHT BULB, WHICH IS A FACTORY-INSTALLED KAITO MODEL HB3 LOW-BEAM BULB. THE BULB WAS DISCOLORED BLACK AND SMOKY LOOKING WITH AN OBVIOUS BULGE OF MELTED GLASS IN ONE SIDE OF THE BULB. THE LOW-BEAM HEADLIGHTS STILL WORK, BUT THE BULB SEEMINGLY HAS OVERHEATED, MELTING BOTH THE BULB GLASS AND THE INSIDE OF THE LENS ASSEMBLY. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT CRASHED INTO ANOTHER VEHICLE AS A RESULT. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE CONTACT ALSO RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL) HOWEVER, THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH HANKOOK DYNAPRO HT TIRE, SIZE: P225-70-16T, AND DOT NUMBER: 7ADHUH. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE FRONT DRIVER'S SIDE TIRE DEFLATED. THE CONTACT ADDED AIR TO THE TIRE AND DISCOVERED THAT THE TIRE BELT WAS SEPARATED AND BUBBLING. THE TIRE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS 10,000. THE VEHICLE FAILURE MILEAGE WAS 95,995.

VEHICLE HAD LOST SOME WATER/COOLANT AND BEGAN TO GET HOT. REPLACED FLUID AND DROVE HOME. KEPT LOOSING FLUID, SO I TOOK IT TO THE SHOP. THEY THOUGHT IT HAD A BLOWN HEAD GASKET. TOOK IT TO ANOTHER SHOP WHICH DISCOVERED THAT 3-4 OF THE HEAD BOLTS ARE STRIPPED; THEY ARE STEEL AND THE BLOCK IS ALUMINUM. REPAIR KIT EXISTS AND HAS BEEN ORDERED. SO, TOYOTA MUST KNOW ABOUT THIS PROBLEM AND COULD HAVE ISSUED AN ADVISORY TO ALL OWNERS. EXPECTED THIS MOTOR TO LAST 150-250 THOU MILES, BUT THIS IS A BUILT IN PROBLEM THAT COULD HAVE BEEN AVOIDED. TOYOTA SHOULD COVER THE REPAIR COSTS. *TR