Toyota FJ Cruiser 2007 — Problemas relatados

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that while the vehicle was parked, the passenger seated in the front passenger's seat unlatched the seat belt; however, the front passenger's seat belt failed to retract. The vehicle was taken to an independent mechanic, where it was diagnosed with front passenger’s seat belt retractor failure. The contact was informed that the front passenger's seat belt retractor needed to be replaced. The dealer was contacted and made aware of the failure. The manufacturer was contacted, and a case was filed. The contact was informed that the repair was not covered under recall. The failure mileage was approximately 207,000.

Took FJ in for an inspection and was informed the frame was rusted to the point it could not pass inspection.

Frame is rusted to the point of failure

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that while her son was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic; however, no cause for the failure was found. The independent mechanic informed the contact that the undercarriage and subframe were severely corroded. The contact was informed that the vehicle should not be driven because the wheels might detach from the vehicle. The vehicle remained with the dealer unrepaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 185,000.

I was driving the vehicle to work and was unable to stop. I had to use the emergency brake system.

Silver paint is peeling off the hood, bumper, doors, ect

Frame and undercarriage have excessive wear for age of vehicle despite normal maintenance and care. Rust and corrosion has made the vehicle unsafe to drive.

I am the owner of a Toyota FJ Cruiser (Year:2007), VIN: [XXX] ]) equipped with the TRD High-Performance Brake Kit, which is under recall campaign C0R / NHTSA 12E046. I recently experienced a serious safety issue involving the front TRD brake crossover tube. While driving, I suddenly noticed a soft brake pedal and significant loss of braking power. I was unable to stop the vehicle properly and nearly crashed into another car at an intersection. I had to swerve at the last moment, which could have caused a more serious accident. Upon inspection, I found that brake fluid was leaking from the crossover tube—exactly the defect described in the TRD brake recall. This failure happened without warning, and my safety and the safety of others was clearly at risk. This is unacceptable for a safety recall. I am requesting immediate investigation, assistance, and a permanent solution. Toyota must ensure this part is properly redesigned and replaced, and that no vehicle is left on the road with this faulty setup. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the front driver's side seat belt failed to retract. The contact related the failure to NHTSA Campaign Number: 13V098000 (Seat Belts). The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 158,305.

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that after it had rained, the front driver's side seat belt was wet, even though the windows were rolled up and the doors were closed securely. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to Technical Service Bulletin: 00707 (Structure); however, the vehicle was not included in the TSB. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

-Toyota recalled the vehicles using the same/similar frame has the same rusty issues, like Tacoma. This recalled made me pay attention on this issue and I found the my FJ cruiser is no longer 100% safe while driving. -The frame of the body is very rusty after years which is not normal. I believe most owners of this model having the same issue. There are rust everywhere under the body, when change some parts, it was really hard to do so, need the fire gun to burn all the screws. And the exhaust system all rusty and leaked as well, cost me a lot of money to fix. -The frame may broken anytime while driving which is risky to me and my passengers. -No dealers would like to fix that frame for me unless to pay a huge amount of Labour costs, which is higher than the value of the car. -it has been inspected by more than 5 car specialists and body shop workers, saying that frame is dying and won’t last for long, maybe will completely broken in a few years. -There is no issues on mechanics, just the under body rust. It happened a lot of years maybe 5-7 years before. -I’m from Canada.

While towing my boat, the rear frame to which the trailer hitch is a part of, ripped down both side of the frame. Basically, the rear frame of the truck is barley holding on by rust. The hitch and frame section are dangling down. Rust has completely eaten through the entire frame after closer inspection.

My fj cruiser has terrible rust on the frame. It literally looks like it was stored in the ocean for 50 years. This vehicle is from 2007 and should not have this much rust.

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the driver's side seat belt failed to retract, causing the contact to have to manually put the seat belt in place. The contact stated that the failure recurred several times and progressed where the seat belt would not retract. The contact discovered NHTSA Campaign Number: 13V098000 (Seat Belts) and the dealer was contacted, and it was confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 191,700. The contact stated vehicle has been repaired, and this case may be closed.

DRIVER SIDE SEATBELT DOES NOT RETRACT ON MY 2007 TOYOTA FJ CRUISER.

The fj cruiser is a common issue for rot/ rust on the frame of the vehicle, I have clean the frame often during the winter months and my frame is continuously rusting and rotting the frame of the vehicle I have decided to not drive the vehicle till the frame is either replaced or repaired due to the safety concern of driving it on the road, numerous others have same incidents of the holes in the frame due to rust the manufacturer did not put any kind of corrosion treatment on the frame to stop this from happening the frame flexes when accelerating and is not safe for anyone to including my passengers or other people on the road

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the front driver’s side seat belt retractor and locking mechanism was inoperable, failing to secure the driver as needed. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 13V098000 (Seat Belts). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 100,000.

The gas tank strap rusted so the gas tank was hanging low. I fixed the problem myself

I own a 2007 FJ Cruiser with very low mileage (below 80,000). It has a terrible carriage rust problem. I thought I'd had it remediated, finally, after endlessly searching for someone to address it. Dry ice treatment and undercoating were applied recently. I replaced the wheels and tires, as well. All seemed well and it passed inspection. But, then the power steering started stiffening. So I had that attended to. The mechanic then told me the rack and pinion and a plethora of other issues were happening due to rust and corrosion - at an additional $$$$$$ cost. So far, this summer, I have spent close to $5,000 to resurrect this vehicle. I can't afford to invest anymore or justify doing so. I am looking to sell. But first I am investigating the FJ class-action against Toyota. I understand this class-action was denied in part last year in California. I plan to check any legal status that might still exist. My hope is that Toyota will acknowledge the problem with the FJs, recall and FIX the problem or at least reimburse me all my repair/remediation expenses. I know they won't do anything unless there is a lot of pressure and outcry to do so. Although, my FJ spent the first 16 years of its life in NJ (which many claim is the cause and of course is plausible - I don't disagree but not to this degree), it was not driven that much, garaged and well cared for. I did not really notice the rust issue until January 2021 when I took it to the local Toyota dealership. I think I was taking it there for an oil change. They were surprised that I'd driven it there because the brakes were so bad. I had it towed home and spent the next many months searching for someone to fix it. No one wanted to touch it until this summer 2023. The gentleman who dry iced and coated informed me about the lawsuit. I never received any kind of notice (thus far) from Toyota about any recall. So now I am garnering information and investigating the best I can. My FJ looks brand new except for frame corro

I was driving down the street after filling up my fuel tank. I drove approximately 1/2 mile when I heard a sound, felt a clunk and stopped immediately. My fuel tank was hanging down on the ground. I called AAA and requested a flatbed and to bring a strap. He did not bring a strap and when my truck arrived at the mechanic the fuel tank had completely separated from the vehicle. The other complaint I have is the rusted frame. I purchased this vehicle used. I did not notice that the tube before the rear axle which holds suspension supports to the frame were completely broken off and separated from the rusted out frame that has failed. It has been welding but the rusted frame is very difficult to weld to.

Frame rust prematurely affecting integrity of the rear lower control arm mounts. Back half of frame almost completely rusted through requiring a full frame replacement.

Our 2007 FJ Cruiser when brought in for annual inspection has been deemed unsafe for use due to crack in frame due to corrosion. The vehicle has no other mechanical issues and runs as if new. We invested in 5 new tires and now find ourselves possibly having to purchase a new vehicle. We witnessed all the other Toyota vehicles frames being replaced due to the recall regarding insufficient undercoating and excessive rust. We inquired if our vehicle was included and if there was reason for concern and were told No. We also own a 2010 Prius which we purchased new. We had no reason to question the validity of the answer. Years later we are grateful we did not experience any incident and crack was discovered before one happened. We now want to know why we did not get a replacement as did all the other models.

Rust is inherently bad on these vehicles. The other day i heard a weird noise under my truck driving down the road. As if I flung a rock up and hit a spring or something. To my dismay, I noticed the fuel tank hanging. One of the straps rusted to the point that it broke allowing the fuel tank to droop.

I recently purchased the used 2007 Toyota FJ with 101,000 miles. During maintenance and inspection, it was found that the fuel tank straps are rusted out and need to be replaced. The rear brake lines are rusted out and need to be replaced. The frame is severely rusted out and failing at the factory welds. I was referred to submit a report and investigate filing a class action lawsuit against the manufacturer for negligence, as this is apparently a known issue. I am hoping that the will reach someone that is able to help all the owners with the same issues as this should be recalled and repaired to prevent unnecessary injury or death. This is a huge financial burden for those expecting a quality vehicle that will be safe. Failing brakes, loose gas tanks and weakened frames are recipe for disaster.

The frame on my 2007 Toyota FJ Cruiser has severe corrosion, compromising it's roadworthiness and the safety of occupants. It is available for inspection. Frame would not protect occupants during a crash, and may fail during normal operation. The problem has been confirmed by two independent mechanics. It has not been further inspected. There were no warning lamps or symptoms until discovered by mechanic. Anecdotal information seems to indicate broad and serious corrosion problems with FJ Cruiser frames, but no warnings, recalls, or service bulletins have been issued.

Serviced 99% of the time at Toyota dealer. Within a week of having the vehicle serviced by the dealer, I noticed a rattling/banging. One gas strap had completely rusted through, and the other was hanging on by about a quarter inch of material. I always ask the dealer to inspect the frame due to the history of rust problems on FJs—they have never flagged anything but I inspect it as I can myself, but have no way to lift the vehicle up thoroughly. I also have the service fluid applied by Rust Check to prevent/inhibit deterioration. On a sidebar, this summer I was traveling on the interstate when the rear-most crossmember rusted out while I was using a hitch haul to move a dresser to South Carolina.

This is a 2007 vehicle I have owned since 2009. One of the two Fuel Tank straps broke in April of 2021. This left one strap holding the tank in place. This happened while driving allowing the tank to drag on ground. I stopped before it became a more serious problem. The strap was completely rusted through. Both straps were replaced. The remaining strap had serious rust as well.

the frame and associated components are severly corroded putting the vehicle in danger of the back axel detaching . i was informed of this by a repair shop who were concerned of the safety of operating vehicle. there is some type of coverage for related vehicles but not for this model. i think this is the same platform which was recalled under a truck model. toyota refuses any coverage or help for this problem. the vehicle has 70k miles but is unsafe to operate. photos are available. although the top of the vehicle is what you would expect with 70k miles, it is unsafe to operate because the back axel could fall off at any time

took the vehicle to a toyota dealership which stated the frame is dangerous and rusted very badly. they told me to file a complaint since the delaer was not covered under the lemon law

I was planning on trading in my FJ Cruiser, so I took it to our local mechanic to look it over. After he put it on the lift, he showed me that the frame and gas tank straps were rusted out and that it wasn't safe to drive. I took it to another body repair shop and after putting it up on the lift, he said he has never seen a frame so rusted out in his twenty five years of doing body work. I contacted Toyota and they said they would NOT repair the frame.

Backing out of my driveway we heard a slight pop and a dragging feel on the right passengers front.( thought I ran over a landscape brick) Stopped and inspected nothing was under the vehicle starting to leave my complex vehicle started to shake some. When I got up to 20 MPH it was obvious I should not drive. Called tow truck. Thought I needed ball joints or something similar. Mechanic said frame was completely rusted out and unfixable. The Toyota FJ cruiser is suppose to be a tough off road SUV which I never used for off road driving They even advertised how tough the frame is in commercials . I see there has been recalls for other Toyota models of SUV and trucks of the same year and their is a class action lawsuit already started I think in California. If I would have continued to the freeway A serious accident would had happened. I contacted Toyota and opened a case # [XXX] which after two communications they closed because there is no recall on the vehicle. The car is in great condition other wise. A frame should last more than 15 years on a truck \SUV designed for off road driving . her are some details of the pending lawsuit: Plaintiffs allege that a manufacturing defect causes excessive rust and corrosion to the frames of 2007-2014 FJ Cruiser vehicles. The suit claims the defect weakens the structure of the vehicle, therefore posing a serious safety threat to vehicle occupants. In some cases, vehicles failed to pass safety inspection and are no longer safe to drive. As a result, owners find themselves stuck with a vehicle that is no longer legally allowed on the roads with a greatly diminished resale value. Toyota Activity Marketed the FJ Cruiser with Special “Electrocoat Deposition” Rust Protection Coating Despite Toyota’s marketing highlighting the “Electrocoat Deposition” protective coating, plaintiff’s claim FJ Cruiser frames prematurely rust and corrode at an accelerated rate. The suit states Toyota had been aware of the frame defect, but fail INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I was hauling a hitch hauler in my hitch which was carrying a portable fish house that weighed approximately 80 lb. As I was leaving the parking lot, I heard a loud clunk noise in which when I look back the hitch hauler and my fish house were laying on the road. The vehicle behind me had to swerve out of the way. I had to haul the fish house to the side of the road and as I was inspecting my vehicle realized the hitch and the frame were cracked and not usable. I had to leave my equipment there because I had no way of hauling it back. I brought the truck to an auto body repair shop and there he told me that I have extensive damage and my frame was rotten. I paid him to repair the damage to the best of his ability. He said that the frame was too bad and that I would have to bring it to another specialist. Since then the front body mounts have rotted off.

Frame is rusting out.

I filled up my truck with gas. Upon driving to work I noticed a loud clank. I looked under the vehicle but it was dark and saw nothing obvious. I continued down the road and heard knocking only when braking hard. When examined in daylight, I could see that the Fuel Tank Support Strap (Rear) rusted thru and the weight of the tank/fuel caused it to shift toward and rub against the Drive Shaft. The loud clank I would hear was caused by the tank being struck by the Drive Shaft balancing weight. The more I research, the more I see others have experienced the same thing. I made it safe until I could procure parts and make the repair. I examined the area and the replaced straps. The rear strap is doomed to fail. The OEM part is painted but exposed in the left rear tire well. Basically, the strap is doomed to be sandblasted by road debris, salt, sand and plain old dirt. Photos and descriptions of others with similar problems are always in the same location. I feel Toyota should make the Straps from a better quality material not as susceptible to corrosive properties of Salt. This is a serious fuel tank issue. If there was a problem with the front strap the rear strap failure could have dropped the tank on the road. Will it take the death(s) of the occupants of affected vehicle should a fire or explosion occur for Toyota to step up and assume responsibility? Or maybe if the tank falls out of the vehicle and car that runs over it then it explodes and kills those occupants will get Toyota's attention? I have retained the failed part should it be needed at a future date for inspection, etc.

Toyota used interior metal to make the frame and it has rusted to the point the whole frame needs to replaced.

Frame rust has become a major safety issue even though we do rust prevention twice a year.

The frame has rusted to the point the car is not driveable. This is caused by the rust protectant that Toyota used on their FJs frames.

Massive amounts of rust underneath the car on the frame and pretty much everything is affected around it. Concerned for my families safety…Toyota needs to address this immediately!!!

The contact owns a 2007 Toyota FJ Cruiser. The contact stated while having the vehicle routinely serviced, the mechanic observed that the subframe showed severe corrosion. The contact had taken the vehicle to another independent mechanic and had the subframe inspected. The contact was informed that the subframe was dangerously corroded and perforated and that the vehicle should not be driven. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 160,000.

I purchased this vehicle used in April 2022. It was not driven much until June 2022 because the car was purchased for our son, who attends school at the US Air Force Academy in Colorado Springs. The goal was to get him a car before his 3 week summer break and he and his sister and his best friend would drive it out to Colorado for him to use throughout his last two years. Their trip began on June 16, 2022, leaving central Ohio. We started getting texts from our daughter about loud noises the car was making while she was sitting in the back seat. Then we started getting texts from our son about noises by the rear tire. We had him check the tires for proper inflation or for any damage. None was reported. My daughter complained about the handling of the vehicle when she was driving. Saying it was not easy to control when going 70 through the plains of the US. They were very pleased to arrive in one piece out in Colorado. My son started to think it was a suspension issue because of the way it handled going over bumpy roads. He took it to a dealer and the dealer took video of the frame, and the black goo used to try and cover the holes and cracks in the frame. $21,000 was their estimate to put a brand new frame on the vehicle. This is a known defect with this vehicle. We should not have to pay for such poor manufacturing.

The vehicles frame and other underbody components have rusted extremely badly. The fuel tank straps broke due to rust, the radiator splash guard fell off while driving due to being very rusty, exhaust clamps have also broken due to rust.