Tesla Model S 2014 — Problemas reportados

Active safety recall (NHTSA Campaign 21V-035 / Tesla TSB SB-21-21-001) for touchscreen and Media Control Unit (MCU) failure remains unperformed due to service refusal and unlawful conditioning at the Tesla Authorized Service Center in [XXX]. Following a 6-week delay, an appointment was kept on XXX. After holding the vehicle for 4 hours, service staff explicitly conditioned execution of the mandatory safety recall upon authorizing ~$3,000 in unrelated retail repairs. When declined, the Service Manager publicly disparaged the vehicle in a crowded waiting room, falsely claimed "there is no recall," and threatened that "if we do the recall, the car may not operate or be drivable afterward," flatly refusing service. As a 40-year automotive industry veteran (former Service Manager), I recognize this as an egregious attempt to leverage mandatory safety recall work for retail service revenue, violating federal compliance obligations under 49 U.S.C. Chapter 301. The unrepaired MCU failure creates an acute safety hazard, disabling critical functions including defrosters, climate controls, and rear-view display visibility. Logistics & Scope: Consumer refuses return to Franklin, TN facility due to hostility/obstruction. Requesting NHTSA record this non-compliance violation and compel Tesla Corporate to coordinate mobile service or transport to an alternative regional facility with loaner coverage, with full restoration of vehicle operability at zero cost to the owner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle's front hood unexpectedly released and struck the windshield while driving at full speed on the interstate. I was able to pull over safely. After stopping, the vehicle displayed a warning indicating that it could not detect whether the front trunk was latched. The resulting collision repairs included replacement of the hood, windshield, hood latch, striker, hood support struts, and related components. We requested that Tesla review this incident as a potential vehicle safety defect and determine whether it is consistent with any known hood-latch defect or applicable recall condition. We specifically request consideration of the relevance of Recall 21V-00B / Tesla campaign SB-21-11-003, while recognizing that we have not independently established whether our VIN was included in the recall population. Tesla has not provided a substantive response.

The main battery failed without warning/notice. it will not charge anymore. the tesla service center in louisville kentucky did not disclose the exact cause for the failure. one day the car displayed a message stating the car is unable to charge, contact service center and never charged again.

Dashboard is leaking glue out the bottom center causing the computer screen and dash control panels to move. I'm not feeling safe driving as I'm not sure if they will drop down or stop functioning at any point. Tesla wants $1500 to fix, and I don't have that money being retired. How can Tesla glue their cars together, and it only last for about 10 yrs?? I feel like this is a safety issue that they should be fixing.

This issue appears to be related to a known MCU failure affecting early Tesla Model S vehicles. The touchscreen exhibits screen melting/discoloration and eventually goes blank or becomes inoperative. When this occurs, critical functions including occupant detection indicators, seatbelt warnings, and windshield defrost controls may become unavailable. The loss of these functions creates potential safety risks involving visibility, occupant protection, and driver awareness while operating the vehicle."

I have been driving my Model S Tesla for 13 years. On 30 April as I was pulling into a parking space at my local grocery store, I applied the brakes to ease into the space and my car surged forward with unintended acceleration. I smashed into the concrete base of a light pole, the airbags deployed and my car ricocheted back about 8 feet. There were no warning messages. I was taken to the emergency room and had whiplash and a burn on my leg from the airbag. No one else was hurt. I know it was the car that malfunctioned because my foot was still on the brake after the collision and the airbags bruised the right side of my right leg. It could not have bruised it in that way if my foot had been on the accelerator. The insurance company inspected and declared a total loss. I obtained the black box data from Tesla and am uploading the documents below. The car is currently at the Tesla collision center. They do not seem interested in evaluating the problem.

Motor suddenly failed after a required update while driving, nearly causing a crash with multiple commercial vehicles and pedestrians, leaving brake lights dangerously always on and alarm sounding, killed 12v as well.

**Incident / Defect Description for NHTSA Safety Complaint** **Vehicle Information** - Make: Tesla - Model: Model S - Year: 2014 - VIN: [XXX] - Approximate Mileage: 148,129 miles - Date of Discovery / Failure: 04/23/2026 **Description of the Defect** This vehicle is equipped with Tesla’s Large Drive Unit (LDU / rear drive unit), which was used in the majority of 2012–early 2020 Model S vehicles (RWD and Performance models). The LDU design routes coolant through the hollow rotor shaft. Over time, the rotor seal fails and allows ethylene glycol coolant to leak internally into the motor and inverter. Evidence of this failure is easily visible by removing the rear speed sensor, where blue coolant, corrosion, and debris are present. This is a well-documented design flaw affecting thousands of vehicles. **Consequences of the Defect** Coolant intrusion causes: • Corrosion and rust in the stator windings • Washing out of bearing grease • High-voltage isolation faults • Inverter damage • Complete drive unit failure **Safety Risks** This defect presents an unreasonable risk to motor vehicle safety because: • Drive unit failure can occur suddenly and without warning while driving, resulting in total loss of propulsion. This is especially dangerous on highways, in traffic, or at high speeds. • Coolant inside high-voltage electrical components increases the risk of electrical shorts, arcing, or fire. • Reduced power or complete shutdown can lead to loss of vehicle control and potential crashes. I have experienced complete drive unit failure. Many other owners report identical issues, often between 50,000–120,000 miles. Tesla has not issued a recall despite this being a widespread, predictable design defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Agency: National Highway Traffic Safety Administration I am submitting a complaint regarding repeated denial of access to charging infrastructure for my electric vehicle due to fraudulent billing activity within Tesla’s Supercharger network. I own a 2014 Tesla Model S located in Alabama. My Tesla account has repeatedly recorded Supercharging sessions in California that were not performed by my vehicle. Tesla customer support representatives have acknowledged that this issue appears to involve VIN cloning or a flaw in their charging identification system. Because I blocked my credit card to prevent fraudulent charges, Tesla’s system repeatedly flags my account as having unpaid balances and automatically disables my vehicle’s access to the Supercharger network until those balances are resolved. This creates a situation where my vehicle can be denied access to charging infrastructure even though the charges are fraudulent and unrelated to my vehicle’s actual activity. The issue has occurred multiple times over several months and requires repeated calls to Tesla customer support to restore charging functionality. Loss of access to charging infrastructure can significantly impact the usability and operational reliability of an electric vehicle. I am requesting that this issue be investigated as a potential defect in the Supercharger billing or authentication system that could affect multiple vehicle owners.

Rear Door handles are inoperable again after repairs made by dealer. The fault is due to design fault with the wiring harness on the door handles. Manufacturer refuses to make repairs under warranty

The rear door handle has failed and now the door pops open when parked.

This is regarding a 2014 Model S fully electric vehicle. Any reference to an 'engine' simply implies the motor. Accelerator pedal became unresponsive and abruptly lost drive power while going ~55mph on the highway. The PRND display on the display panel went red. Car was towed to the service center Immediately after this malfunction, I somehow cruised along towards the shoulder with just with brakes and hazard lights. Total loss of motor power caused vehicle to slow down and vehicles behind me had to slow down (and honk). After coming to complete stop and shifting to Park the PRND display turned white again indicating function was restored. Shifting to D seem to re-engage the motor and I could pull away to the nearest exit and then into a parking lot. At this location it no longer responded to R or D positions and had to finally towed. Frequent drive unit failure is apparently a prevalent issue on certain models. Not sure if anyone else was in a similar situation. Service centers admit this as well as there is evidence on online forums Warning sign (PRND turning red) appeared at the exact moment of failure. On stopping and going back to Park it would go away. No persistent errors remained on the screen. After the motor had completely failed, various other warnings started appearing (ref photos)

The contact owned a 2014 Tesla Model S. The contact stated that while driving at an undisclosed speed on the highway, the vehicle exited into a tunnel. The contact stated that his hands were on the steering wheel and that the steering wheel did not move; however, the vehicle inadvertently made a sharp left turn, and the passenger-side headlight struck the tunnel wall. The vehicle spun rapidly, and the contact's head snapped to the right. The air bags did not deploy. The contact received medical attention for whiplash. Police were made aware of the crash but did not arrive on the scene. There was no police report filed. The contact pulled over on the shoulder of the road and then restarted the vehicle. The vehicle had driven for a mile when the tire pressure dropped to zero. The vehicle was towed to the residence and then to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000.

I am the current owner of a 2014 Tesla Model S equipped with MCU1. While driving, including at freeway speeds, the center touchscreen has rebooted unexpectedly, showing only the Tesla logo before recovering. During these reboots, critical vehicle functions are unavailable, including the rearview camera, HVAC/defrost controls, and other essential features. This failure matches the exact safety defect described in NHTSA Recall 21V-035 related to the MCU/eMMC failure. I reported this safety issue to Tesla Service and provided photo evidence of the screen rebooting while driving. Tesla has refused to address this as a recall or safety repair. Tesla claims the recall was previously completed under a prior owner but refuses to provide any documentation proving that the recall repair was actually performed, citing prior owner privacy. Tesla has further stated that diagnosis of this active safety defect would be customer-paid due to the basic warranty being expired and has indicated that the only path forward is a paid infotainment upgrade. Tesla is effectively requiring payment to diagnose and resolve a known safety defect. As the safety defect is actively occurring while driving and Tesla has marked the recall as complete without providing proof or correcting the issue, I am requesting NHTSA review whether Tesla is improperly closing out recalls without ensuring the defect has been remedied and whether charging customers to diagnose known safety defects is appropriate. After entering my VIN into NHTSA’s recall lookup, NHTSA shows Recall 21V-035 (MCU/eMMC failure) as Recall Incomplete for my vehicle. This directly contradicts Tesla’s claim that the recall was previously completed. Tesla has refused to provide documentation and is requiring paid diagnosis and a paid infotainment upgrade despite the recall being listed by NHTSA as unresolved.

My [XXX] mother owns a 2014 Tesla Model S P85+ (VIN: [XXX] ) with only 50,367 miles. The vehicle suddenly became completely inoperable without warning. It would not turn on, would not charge, and the charge port would not open. The vehicle had to be towed. Tesla diagnosed failures of the high-voltage battery contactors, the onboard charger assembly, and HV circuit integrity. These are essential high-voltage components that should not fail at such low mileage. When these parts fail, the vehicle loses all ability to charge, loses all propulsion capability, and becomes a stranded hazard. This represents a safety concern because the vehicle can shut down without warning and cannot be moved, which could leave occupants stuck in unsafe conditions or traffic. The charge port failing to open is also a safety issue, as the vehicle cannot be charged in an emergency and the owner has no way to safely get the vehicle off the road once it loses power. Tesla quoted nearly $4,000 for repairs and refused goodwill assistance even though this is a known early Model S issue and these components have been redesigned in later models. My mother is on a fixed Social Security income and cannot afford the repair or even the diagnostic fee. This situation may cause her vehicle to be repossessed through no fault of her own. I am requesting NHTSA to review premature high-voltage component failures on early Tesla Model S vehicles, as these failures pose safety risks and leave owners stranded with no warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After a high-voltage junction box repair performed by Tesla, the vehicle shut down 15 miles after leaving the service center. Tesla replaced the high-voltage harness at no cost but provided no explanation. After the HV harness replacement, new proximity/sensor alerts began triggering that were not present before their HV work. Multiple reasonable diagnostic procedures were refused, including bench-testing the sensors. Tesla is pressuring me to take possession of the vehicle without providing written confirmation that it is safe to operate following the HV system failure and subsequent replacement of HV components. I am concerned the vehicle may have unresolved high-voltage or wiring issues that could pose a safety hazard.

The main touchscreen (MCU1) and instrument cluster on my 2014 Tesla Model S frequently freeze, reboot, or go blank while driving. When this happens, I lose access to defrost, turn signals, backup camera, and speed display. I contacted Tesla Service, but they refused to repair or replace the unit under recall EA20-003 or the extended warranty, even though the symptoms match the known eMMC 8GB memory failure. The black screen and frozen instrument cluster create a clear safety risk. Tesla should cover this issue under the recall or provide an equivalent MCU2 replacement if MCU1 parts are unavailable.

Vehicle Information: 2014 Tesla Model S VIN: [XXX] Incident Date: [XXX] Component Affected: Suspension / Air Suspension / Ride Height Control Problem Description: On [XXX], while driving, my 2014 Tesla Model S suddenly raised itself to and/or beyond maximum ride height without any driver input. Immediately afterward, the front driver-side suspension collapsed completely, leaving the vehicle unsafe to operate. This appears to be an uncommanded overinflation event caused by Tesla’s suspension control system. It is not normal wear but a manufacturer-induced malfunction. If this failure had occurred at highway speeds, it could have caused catastrophic loss of control. The collapse of a suspension system without warning is a serious safety defect. Tesla’s service center in Moraine, OH, has refused to review the vehicle logs (which would confirm this sequence of failure) and has instead classified the incident as a standard part failure. As a result, Tesla is attempting to push full financial liability onto the owner instead of addressing what is clearly a safety-critical defect. Safety Concern: A sudden, uncommanded suspension height change followed by collapse could lead to total loss of vehicle control and a crash. This poses an ongoing risk to both Tesla drivers and the public. Requested Action: I am requesting that NHTSA investigate this failure mode as a safety defect in Tesla Model S vehicles and require Tesla to address these failures appropriately. Service Center Involved: Tesla Service Center 1927 W Dorothy Ln Moraine, OH 45439 Owner Information: [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2014 Tesla Model S. The contact stated while driving at various speeds, the digital screen intermittently blacked out and several safety features were inoperable. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the resort block remained at 90%, and the same EMMC ID that should have been covered under NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Coolant ingress found on second Model S large drive unit in rear. After this leak destroyed my first vehicle, second was checked as a precaution and was found to have coolant leaking into drive unit as well.

the recirculation button takes 3 presses to engage/disengage or 1. sometimes 2. it's supposed to be an "intelligent" design. I'm sure there's software programming that determines when 2 presses are required vs 3 or 1 but to a driver it can be dangerous while focusing on the road. It should just be 1 press engages or disengages recirculation PERIOD just like other vehicles. Also, those buttons should be on the main page of the ipad screen. it shouldn't take opening 2-3 different pages on the screen to get to the recirculation button. Buttons that should be on the main page that you don't need to open several pages to get to: 1. recirculation button 2. AC button (it is a serious safety issue when trying to defrost on a humid day but it takes pressing several different buttons to get to the AC button that should just be out in the open like any other car. 3. suspension height (sometimes you need to quickly change for clearance and if distracted by opening several pages to get to the suspension button, it is a safety issue) All those buttons should be lined up on the far left edge of the screen closest to the driver and preferably towards the top. It's a serious safety issue to be distracted by fidgeting around on the screen to get to those buttons that are supposed to be "right there".

I was driving my car on the freeway on cruise control, when there was a sudden/automatic violent break of 65 MPH to 0 MPH. There was no car in front of me, and there was nothing above my car (no direction sign, no bridge, no FASTRAK billboard, nothing). This was a "phantom break" and it was violent and sudden. Tesla needs to fix this!

The contact owns a 2014 Tesla Model S. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System); however, the OTA update had not been received. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that the OTA update was available. The manufacturer was notified of the failure, a case was opened, and it was confirmed that the OTA update was available. Later, the case was closed after the manufacturer confirmed the OTA update had been pushed to the vehicle. The contact had not experienced a failure. Parts distribution disconnect.

My instrument cluster goes off while driving making it impossible to know my current speed. It also will cut off when i put it in park and the car will not move until it completely reboots. Sometimes it will just freeze and say the car is off and in park while the car is in Drive moving. One time the cluster showed that the car was in reverse but when i hit the accelerator, car moved forward. Cluster is constantly rebooting itself. 2014 Tesla models S 85. I have an attached video where all warning signs are illuminated,no speedometer and shows its in park while im driving

Drivers door handle failed to operate, occupant was locked out of vehicle, safety of operator was compromised as elderly operator has to climb over passenger and center console to enter drivers area. Problem is ongoing as door handle will not operate at all. Vehicle has not been inspected yet. No symptoms, door handle failed and cannot be opened from the outside at all.

The drive unit was leaking coolant into the electrical inverter space. The issue was verified by a mechanic who then repaired the drive unit to prevent additional coolant intrusion.

The rotor seal on the Large Drive Units on Tesla Model S and X fail, causing coolant to leak into the drive unit, flooding it and damaging the inverter. This leads to a replacement cost from Tesla for approximately $7 - $8,000. As this is a design failure this should be a recall and Tesla should at least repair all units prior to their failure or replace them with an updated motor.

Overnight while plugged in and after the battery showed it was fully charged, the battery suddenly lost charge, and the car sent repeated alerts to immediately pull over and stop driving. A notice on the car showed mileage was reduced and to immediately schedule a service call. After returning home, I downloaded to the car a recent software update that cleared the error. However, after the software upgrade, Tesla messaged that they did removed tests and the high voltage battery must be replaced.

Vehicle failed to charge at a tesla charging point. 60 miles from home , raining, had to have vehicle towed to house. Failed to charge at home charging point. Cost to have tesla fix, too expensive. Took 4 months to find another charge port for vehicle Vehicle continues to have issues

The steering assist failed while driving. Causing near collision and very difficult to drive.

LCD dashboard is bubbling and liquid seems to be leaking within the dashboard screen. In some online research, there are concerns that contaminants can infilitrate the cabin when this happens. The problem seems to be pervasive for cars made by Tesla from 2012 to 2014. There were no warnings for when this problem ocurred. Tesla is saying that the part needs to be replaced at a cost of $1900.

I have put my car in the shop 11 times since I purchased it 3 years ago. Now my suspension is having issues. I don't qualify for the lemon law due to the age of my car. I paid over 30,000 for a car that is not going to last till its paid off.

The contact owns a 2014 Tesla Model S. The contact stated that while the vehicle was in park(P), a person approached the driver’s side rear door, and the door unintendedly opened slightly. The contact stated that prior to entering the vehicle, the driver’s side rear door opened slightly, and while reversing, the door opened completely. The contact closed the door; however, the failure recurred. There were no alerts during the failure; however, afterwards the contact's door was opened, and the App showed a message that the door was opened. The contact stated that all the doors were not opening from inside or outside the vehicle unless the vehicle was in park. The contact stated that the driver's side door was not opening whether in park or drive. The contact added Velcro to the door handle that was used to pull the door handle open. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

My drivers door will randomly open while driving and or while making turns, yes it is available for inspection if need be. This is put my safety at risk because its very dangerous for a door to open while driving at any speed, and if it happens to a back door items in my back seat could fall out causing a very serious accident. When the problem first started I paid to have a new door handle put in but it did not fix the problem, even after the repair the door would sometimes not close stay closed properly and the tech said he wasn't sure because he never seen a door not close every time, after looking online many people have had the same issues, I again reported this to Tesla and they set up an appointment with me to fix the door handle. I have been dealing with this issue for 6 months now. I would say the vehicle was inspected by my mobile tech, but he advised he never seen anything the issue with the door not closing or staying closed every time, said he would ask around and get back to me, I was told by another rep I had to pay for a new latch, but they couldn't confirm if this is the issue. There are only warning messages when the door opens while driving, also the door will open even if it shows its locked.

My 2014 P85D model S electric rear motor failed. I heard a loud noise coming from it so I took it in to Tesla and they agreed the motor was failing and needed to be replaced, Cost $6,582.04. If I had driven the car and the motor seized up it while on the highway it would have been catastrophic. I would have lost control as the motor froze the rear wheel. Tesla knows of this problem, has replaced many of them, unfortunately post warranty. They know the seals leak and coolant leaks into the motor and causes the motor to fail. They have made a number of design changes including the latest where they eliminate a cooling branch going through the motor. Prior to this change none of the fixes have eliminated the problem.

Allows driving without speedometer, was just showing Tesla branding in place.

While driving, my back wheel fell off. I had the car in for suspension work twice in Q4 2023, and then on March 7, 2024 my back wheel fell off. When speaking with Tesla, they said that this sometimes happens and they have seen this issue before. The also told me that they think it only happens at low speeds, but I have found articles where people were on the highway and their wheel fell off. China has made Tesla do a recall for suspension and wheel issues, why haven't we? I now have had my vehicles suspension worked on at least 4 times, this is dangerous and scary.

On February 11, 2024, as I was entering my house garage at a very low speed, the car suddenly accelerated and hit the wall of my garage, causing damage to the garage and interior of my house. The car was insured by State Fram. It was towed to a shop for repair at which time the insurance company notified me that the car could not be repaired. The car had been totaled. Over the following several weeks, I repaired the damage to my house and bought another car.

The vehicles MCU storage files are 100% full, and unable to read or write new data.the caches and nodes to have been cleared several times to restore data storage and writing capabilities. 12v power resets have also been Performed as well as factory reset to eliminate potentially corrupt data and free storage space.while at Tesla they Reformatted gateway SD card. The Vehicle is still unable to take firmware update and unable to unlock vehicle gateway, therefore, a new key fob is not able to be programmed to vehicle. Tesla Tested vehicle app remote start capabilities and verified proper functionality. The tech had me uninstall then reinstall the Tesla mobile app, then pair phone to vehicle. They then informed me that a new Key fob will not be able to be paired to vehicle until infotainment upgrade is performed. no further repairs possible until info upgrade. To which that isn’t right and my car is inoperable for the second time because of this issue

Premature wear on almost all front suspension parts relating to control arms and sway bar links. Recently had to pay out of pocket to have two steering rack bolts tightened, they were not torqued properly from the factory apparently

Front control arms left and right FR SUSP FORE LINK ASSY , only the replacement is available for inspection upon request. The safety that was put at risk is unknown. It was repaired by Tesla at my expense. There were no warning lamps, messages the only symptoms was noise, metal banging.

Can't open driver's side door from outside, safety issue for parents/first responders. Online search shows this is a common defect that needs a safety recall, the wiring is defective and costly to repair. Thank you

Defective brake light seal went bad, brake light is filling with water and broke red LEDs right away, family is now not safe from rear colissions and Tesla wants $1000. Thank you