Saturn Ion 2004

If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.

UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).

If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.

DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.

ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.

IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.

DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.