Rivian R1T 2022 — Reported problems

My Rivian R1T is experiencing a recurring problem with the 12-volt battery system. Around 2023, while I was traveling in San Francisco, my vehicle displayed a warning stating that the 12V battery needed to be replaced and instructed me to keep the vehicle connected to a charger. I was concerned that the vehicle could become inoperable and leave me stranded away from home. Rivian subsequently replaced the 12V battery. I am now experiencing the same warning again. The vehicle is once again telling me there is a problem with the 12V battery and that I need to keep the vehicle connected to a charging port. I depend on this vehicle for transportation to work, and I am concerned that if I disconnect it and drive to work, the 12V system could fail and leave me stranded or unable to operate the vehicle. I am concerned that having the same 12V battery issue occur again only a few years after the previous battery was replaced indicates a recurring durability or design problem with the low-voltage electrical system. A failure of this system can potentially make the vehicle inoperable even when the main high-voltage battery has sufficient charge. I am asking NHTSA to investigate recurring and premature 12V battery failures in Rivian R1T vehicles and determine whether there is a safety-related defect. I am particularly concerned about the possibility of being stranded without adequate warning and having to repeatedly replace a critical component of the vehicle’s electrical system.

I was driving with items in the truck bed, including a cooler. There was wind noise, which I initially attributed to the items in the back, but it seemed to be getting louder. The truck didn't feel right. As I was traveling approximately 70 mph (with cruise control engaged), it felt like regenerative braking was occurring. There were no warnings or warning lights. I decided to exit the highway to check things out. As I slowed down, the truck decelerated much more abruptly than normal. I pulled onto the shoulder and got out. There was a burning smell that reminded me of either an electrical fire or brakes that had been rubbing. Those were the only two things that came to mind. As I attempted to drive to a nearby gas station, the truck was extremely jerky and then abruptly stopped. We had it towed to our workplace. In our parking lot, I drove under 5 mph while my wife and coworker observed. The wheels initially rotated normally for several revolutions before the right rear wheel began wobbling laterally and instantly locked. The other three wheels continued rotating, moving the truck forward while the locked wheel skidded along the pavement. When I stopped, the wheel released. We repeated this sequence multiple times with the same result. I am concerned that if the right rear wheel had locked at highway speed while the other three wheels continued moving the truck forward, I could have lost control of the vehicle. No warning lights, error messages, or alerts appeared at any point. The truck is currently at Rivian Atlanta, received October 15, 2026. Rivian's October 20 estimate (WO-000002692556), Item 1, documents rear drive unit noise and unknown fluid leaking onto underbody panels. Rivian proposes replacing the rear drive unit and draining/refilling its fluid under warranty. I do not know whether Rivian reproduced the wheel lockup. Rivian has inspected the vehicle, which remains at its Atlanta location.

The backup cameras and sensors stopped working after update 2026.31.0 pushed by Rivian. The camera just doesn't load anymore, and proximity sensors stopped working. Multiple soft and hard resets did not resolve.

I have had a late model 2022 Rivian R1T since July of 2024. It had ~1500 miles on it, but has needed 12 services in just two years. This includes having to have the 12v batteries (2) replaced 11/2024 at ~6,000 total miles driven and again just 21 months later at 25,000 miles. Rivian would not replace the batteries this most recent time claiming they are not warranted since they were replacements and the vehicle is more than 3 years old. they did give me one of the 2 batteries for free most recently, but I still paid $542. It would have been ~$800. I requested to speak to a manager about it. after a couple attempts Carlo Tan at the Eastvale, CA service center spoke to me on the phone and stated this is not a reoccurring issue (even though there are forums full of same examples all over the internet) and that the batteries are out of warranty so he is not doing anything else. I asked to escalate it. He said OK, but never called me back. I phoned multiple times including waiting on hold for an hour with no call back. So I emailed the service manager who forwarded it to Carlo who then replied that upper management reviewed my case and declined to do anything else. I replied to that email on [XXX] and asked to speak with upper management myself or i would file a complaint with you. It has been 6-weeks and still no reply. I love my Rivian. I have two actually, but this is a problem particularly with early model years that Rivian won't take ownership of. I could have been stranded or worse my wife at night somewhere alone or who knows. at any rate, I just want this fixed for good and don't think i should have to pay a penny for it. thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When shifting into reverse, sometimes it will takes 2 or more seconds for the rear/backup camera to display on the screen. Sometimes while in reverse and the rear/backup camera is being displayed, the camera image will freeze. This may happen when the vehicle is moving or stopped. Sometimes while in reverse and the rear/backup camera is being displayed, the alignment lines on the screen will not adjust when the steering wheel is turned. This may happen whether the camera image is frozen or active.

2022 Rivian R1T, ~102,600 mi. Front suspension dampers (hydraulic/air suspension) failing again. Front end rises under acceleration and suspension is soft. In rain the front tires lose traction during acceleration. Current parts are installed; vehicle available for inspection. Prior replaced parts were kept by Rivian; whether they still exist is UNKNOWN. SAFETY RISK: Front tires lose grip accelerating on wet roads, from a stop, merging, and turning across traffic, risking loss of steering control and a crash. On XXX the vehicle also limited itself to 50 mph without warning, a hazard in highway traffic. I now avoid driving in rain. CONFIRMED BY DEALER: Current failure not yet confirmed; Rivian diagnosis set for XXX ([XXX]). Rivian has repeatedly repaired the same system: front dampers replaced XXX, XXX; rear dampers XXX; air compressor XXX. In XXX Rivian identified debris in the hydraulic suspension as a root cause, but failures continue after each repair. OTHER INSPECTIONS: Rivian only. No police or insurance inspection. WARNINGS: On or aboutXXX, after parking over an hour on flat pavement, the display showed "service suspension" and speed was limited to 50 mph. A vehicle reset cleared it; the rising front end and soft suspension began right after. Traction loss in rain first noticed XXX. Vehicle has Rivian OEM 12V batteries; Rivian performed 12V calibration XXX. Fault codes from XXX requested from Rivian in writing; not provided. MANUFACTURER RESPONSE: Written report sent to Rivian XXX no response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Put vehicle in reverse. Instead of showing the reverse camera immediately, the system lagged and the vehicle's infotainment system became non-responsive. No reverse camera image was shown. Approximately one minute later, having finished backing up and started driving, the camera interface came up. At this point the interface for the infotainment was missing. I could not bring up any HVAC controls, and so had uncomfortable air blowing on my that I did not want, but could not control. (No manual controls on the vents.)

The contact owns a 2022 Rivian R1T. The contact stated that while driving 20 MPH, the steering wheel was extremely loose. The steering wheel failed to turn as intended. The tow truck driver was able to duplicate the failure. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The technicians were unable to duplicate the failure. After retrieving the vehicle for sixteen days, while driving at highway speeds and making a turn, the failure reoccurred. The vehicle was taken back to the local dealer, where it was diagnosed with a fractured steering rack. The vehicle was repaired. The contact believed that the dealer was negligent. The Rivian service hotline was called, and the contact was advised to tow the vehicle to the dealer. The failure mileage was approximately 54,000.

I am reporting repeated suspension and structural failures involving my 2022 Rivian R1T. In April 2026, at approximately 90,537 miles, Rivian performed a comprehensive inspection and found both front lower control arm bushings torn, the right rear damper leaking, and the rear subframe cracked. Rivian’s own service documentation specifically stated that the vehicle was “unsafe to operate due to damage to the rear subframe” and recommended that the vehicle be towed. Rivian subsequently replaced the rear subframe, both front lower control arms, the right rear damper, and serviced the hydraulic damper system. The April repair invoice totaled approximately $9,953. Approximately five months later, at approximately 96,956 miles, the vehicle developed another significant suspension problem. The front passenger side began sitting noticeably lower. The ride became extremely rough over bumps, I could feel significant vibration through the vehicle, and the vehicle repeatedly attempted to adjust its ride height. I also received warnings telling me not to move the vehicle while the air suspension was adjusting, and I was unable to properly adjust the ride height. I brought the vehicle back to Rivian in September 2026. The current Rivian service estimate calls for replacement of both front dampers, the air-suspension compressor/ASU, and the left and right front hydraulic suspension jounce lines, along with suspension diagnostics. The suspension repair estimate is approximately $7,121. I was informed that the ASU/compressor was tried as part of diagnosing the problem but did not resolve the condition, and the front dampers are now suspected. I was also informed that because the front suspension functions as a connected system and the replacement components are an updated design, both sides/components may need to be replaced. I am concerned about the repeated failure of safety-critical suspension and structural components on the same vehicle. In approximately five months .

The seat belt came completely dislodged from the seat base as my passenger was getting into the car and fastening their seat belt

After gently removing the fabric cover of our Cybex Eternis S All-In-One car seat to wash it according to the manufacturer's care instructions, and then putting the cover back on, the car ride immediately following, the red plastic pieces designed to hold the cover in place completely snapped off. This structural failure exposed two sharp, unshielded metal screws directly in the child's seating area. Because these screws were left fully exposed by the broken plastic, they created an immediate laceration hazard. As a direct result of this defect, my young daughter's leg was cut by the exposed screws while using the seat.

SYSTEMS AFFECTED: Electrical System (12V Power Supply / Low-Voltage), Climate Control (HVAC System / Thermal Management), Towing / Recovery DESCRIPTION OF SAFETY HAZARD & DEFECT: My 2022 Rivian R1T experienced a sudden, complete electrical failure due to a defective HVAC system, resulting in a dangerous hard-bricked state that rendered the vehicle totally inoperable. Approximately 30 days prior to the incident, the vehicle underwent a comprehensive inspection at a Rivian Service Center where both the HVAC system and 12-volt battery system were tested and cleared. Shortly after, a primary internal failure/glitch within the HVAC equipment created a high parasitic power draw on the vehicle's low-voltage circuit while parked. The HVAC module failed to enter sleep mode, continuously draining the dual 12-volt AGM battery array below critical operating thresholds. This rapid, deep-discharge condition completely disabled the vehicle's primary high-voltage contactors and low-voltage control modules, locking out all vehicle functions, electronic doors, and drive controls. The vehicle could not be restarted, jump-started normally, or safely shifted into neutral, necessitating an emergency flatbed tow to the service center. Technicians confirmed that the primary HVAC equipment failure directly caused the full depletion and destruction of the 12-volt electrical system. This defect presents an immediate safety risk. An uncommanded HVAC-induced power drain that completely depletes the 12-volt system can cause sudden electrical failure, vehicle bricking, loss of hazard lights, and lock-out conditions, potentially stranded occupants in dangerous environments or busy roadways. Rivian is treating this catastrophic multi-system failure as non-warranty maintenance, refusing to address a clear pre-existing latent defect in their low-voltage power management and thermal architecture. REQUESTED ACTION: Investigation into 2022 Rivian R1 HVAC power management defects causing severe 12V drain

In July of 2025 while driving my entire air suspension collapsed on the highway slamming the vehicle down onto it's bumpstops. Rivian covered a "fix" of this under warrant. In December the rear shock was leaking. Now in July of this year while driving the front air suspension collapsed to it's bump stop again.

The R1T has four cameras to assist the driver and provide warnings for lane changes, etc. The cameras are routinely failing while I am driving the vehicle. This started after an OTA software update. A software reset will turn the cameras back on, though they have repeatedly failed. Rivian attempted to correct the issue by replacing the front camera, which they determined was faulty. The cameras have continued to fail since then.

Vehicle gave a warning to service the electrical system and then shut down preventing any operation. Luckily I was in a parking lot and not on a roadway impeding traffic or jeopardizing safety while driving. Could smell burnt electrical from within cabin. Had to have towed to service center and explained that condensation from air conditioner leaked onto high voltage heater coils and shorted out electrical system. Seems like a poor design that this was even possible. Dealer indicated this was not uncommon.

Rear Suspension Dampers leaking prematurely which could cause unsafe driving issues.

Subframe has cracked. It is a known issue for my vehicle as the welded subframe isn’t strong enough to hold the weight of my vehicle over time. Thus compromising the structural integrity over time, leading to severe safety hazards like unpredictable handling, poor stability, and potential failure of critical components. This can lead to accidents if not resolved. Rivian currently knows this is an issue and charges customers who are out of warranty over $11k to repair.

12 volt battery was replaced under warranty on date 07/08/2024 at miles 14059. Again, 12 volt battery needs to be replaced at 29343 miles as of today's date 04/12/2026. This is highly unusual. Please look into it. Prakashkumar Patel, MD

Passenger front suspension failure due to failed hydraulic pump (at 67k miles), resulting in wheels rubbing against interior, making vehicle almost inoperable without placing occupants at risk. It was immediate and without warning inside vehicle. When I spoke with technician they informed me that it was occasionally reported in earlier models. I was unable to view component.

We were driving on the highway going 70 MPH when we heard a loud bang, and then the car immediately catapulted to the right off the road and slammed into the concrete right median, spun around hit a sign and then ended up in the right bridge barrier (shoulder). During the crash 6 airbags deployed from the impact of the crash. The highway patrolman stated that you could see the driver-side rear wheel started skidding based on the marks on the road. We thought it was a blown tire. But the tires were all in tact. The driver-side rear wheel was turned out and it was clear that the toe-link joint had separated from the wheel axel and this is what caused our crash. The car has been totaled by insurance company and taken salvage yard in Knightdale, NC. We were both wearing seatbelts, and I (the passenger) was thrown around during the crash and ended up going to the hospital with neck and back pain. I have severe neck misalignment and soft tissue damage on my neck and back. I was unable to work for 4 days after the accident and still am not able to sleep well due to pain. We were in the right hand lane of the highway and did not hit any other cars, but if we had been in a different lane we could have hit another car and caused more injuries and damage. The problem that caused the accident was the problem that was listed on the product recall, we had an appointment to get it fixed the next day. We had the car towed to the Rivian service center where they verbally confirmed it was the toe link that separated. It was inspected by the police, the Rivian Service Center and our insurance adjuster. There was zero warning prior to the loud bang other than the recall notice We

The 2022 R1Ts has a welded subframe that is prone to cracking due to the vehicles weight. The symptoms are a metal on metal clunking and creaking sound from the front end. In 2023 Rivian replaced the welded subframe on the R1T with a cast subframe that is stronger. I raised this issue to Rivian on 3 separate service appointments over the course of 3 years while my vehicle was under warranty, each time I was told that the sounds are normal. Now that my vehicle has just passed the 60,000 mile warranty period I am now being told that the truck needs the subframe replaced with the gen 2 retrofit kit at a cost of $11,500. As you can see by this Reddit thread, this is a systemic issue with the 2022 R1T and many customers have experienced cracks in the welded subframe- [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Massive damper leak. Per research online, this is happening with a lot of the same vehicles. If it fails, it will place the vehicle in turtle mode even on the freeway which could be dangerous.

I was driving late night to a campsite in a very rural part of the Big Island of [XXX] , about 45 minutes from where I live. I was by myself except for my dog, in the passenger seat. I was on a country road with a 30 mph speed limit, going about 25 mph. I engaged the cruise control and it immediately went up to 40-45 mph, far faster than the limit and far faster than was safe given the wet conditions and windy road. As I tried to slow the car down, using the steering while cruise control adjustment buttons, I steered through a curve and rather than turn with the road, as I had intended, the truck slid off the road to the left, effectively hydroplaning, into two trees, at about 40 mph. The airbags deployed as the truck came to a complete halt against the two trees. The car automatically called 911 as I sat there trying to assess what had just happened, whether I was hurt, and whether my dog was hurt. I told the 911 operator that the truck had called them automatically adn that I was ok and I would call in the morning after assessing what had happened. I am waiting for the police report and also waiting for the incident report from Rivian, which has an on-board log of events. I don't know why the cruise control engaged at such a high speed, rather than at the posted speed limit, but this appears to be a known flaw with Rivian's cruise control that I was not aware of. The cruise control and software are available for inspection by NHTSA. There is also an active recall on this vehicle that I was aware of but had been unable to schedule for service yet b/c it required shipping the truck to [XXX] on a barge. I had only had the truck on island for a little more than a month. From previous operations I had no reason to believe that the cruise control was faulty. It is possible that the recall issue may have been a contributing factor to the crash but I don't know b/c the vehicle has not been inspected yet by Rivian. They have scheduled an adjuster to come on April 14. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2022 Rivian R1T, VIN [XXX] . Recurring suspension defects since delivery June 2022, documented across 18 service visits over 3.5 years. Rivian performed multiple repairs including Gen 2 suspension component replacement. This defect has never been permanently resolved. On July 11, 2025, El Segundo service center [XXX] ) repaired the front end lowering in standard parking mode — causing the vehicle to sit unlevel and knock the tires out of alignment when driving off. They repaired the suspension and corrected the alignment. In August 2025 a related defect appeared: when exiting camp leveling mode, the vehicle does not return to drive height. Instead it behaves as though still entering camp mode, forcing a slow drive-away during which the vehicle behaves erratically, knocking tires out of alignment — the same mechanism as the July parking mode issue. I reported this to Rivian in fall 2025. Despite scheduling three appointments — January 21, February 10, and March 14, 2026 — El Segundo failed to complete service all three times due to inability to provide a promised loaner vehicle. Suspension unserviced since July 11, 2025 — 9 months. On March 31, 2026 I filmed the front end lowering in parking mode recurring — same defect supposedly repaired July 2025. Vehicle self-leveled when I manually raised the suspension, but recurrence after a Rivian repair attempt is a safety concern. Video dated March 31, 2026 available. Service appointment also deleted from Rivian app March 14, 2026 including active recall remedies FSAM-1795 and FSAM-1794 — addressed in separately filed NHTSA complaint. Surviving record altered by Rivian Service to state ride height appears normal before any inspection, contradicting my report and app video submitted January 2, 2026 at 9:34am. Formal complaint delivered to Rivian CEO via USPS Certified Mail March 18, 2026. No substantive response as of April 1, 2026. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2022 Rivian R1T, VIN [XXX] . On March 14, 2026, my service appointment at El Segundo Rivian service center [XXX] ) was deleted from the Rivian app along with all service requests and a timestamped customer message thread documenting my visit that day. Deleted items included active recall remedies FSAM-1795 (seat belt retractor bolts improperly torqued, NHTSA notification mailed ~March 9, 2026) and FSAM-1794 / NHTSA 26V003 (rear toe link improper reassembly, risk of joint separation while driving, notification mailed ~February 24, 2026), plus tire rotation, windshield replacement, and suspension repair. Both recalls were issued within 3 weeks of the deletion. This was the third of three consecutive failed appointments — all failed because El Segundo could not provide a promised loaner vehicle (January 21, February 10, March 14, 2026). The only surviving record [XXX] ) was altered by Rivian Service — they inserted the statement that ride height appears to be as expected and does not show variance before any inspection, directly contradicting my written report and a video I submitted through the Rivian app on January 2, 2026 at 9:34am documenting the defect. Rivian also added an all-caps requirement to replicate the issue on a test drive prior to intake despite existing written and video documentation. Rivian has a federal obligation to complete FSAM-1795 and FSAM-1794. Neither has been reinstated as of April 1, 2026. Formal complaint delivered to Rivian CEO via USPS Certified Mail March 18, 2026. Only response was a generic form letter (Inquiry #xxx) stating matter appears resolved. See also separately filed NHTSA complaint re suspension defect, same VIN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Overview: In late February 2026, at approximately 114,000 miles, this 2022 Rivian R1T suffered a comprehensive failure of its kinetic (hydraulic) suspension system. The failure occurred during normal on-road operation at approximately 60 mph in temperate (60F) conditions. The vehicle has no history of off-road use or heavy hauling. Safety Risk & Critical Failure Mode: The suspension is a safety-critical system essential for vehicle stability, emergency braking, and predictable handling. A loss of hydraulic integrity in this system directly compromises the vehicle’s ability to maintain ride height and damping control. High-Speed Exposure: The initial failure manifested while traveling at 60 mph. Although a warning lamp was triggered, the vehicle’s functional safety logic failed to initiate a "limp mode" or restricted speed state. This allowed the 7,000lb vehicle to continue at highway speeds with a compromised high-pressure hydraulic circuit, posing an unreasonable risk of loss of control. Lack of System Redundancy: A localized hydraulic leak resulted in a cascading collapse of the entire architecture. Per the 10,662 service estimate, the repair requires replacing the front and rear dampers, hydraulic pump, manifold, and all fluid lines. This suggests a design-level vulnerability where a single-point failure in the hydraulic circuit necessitates a total system overhaul, indicating a lack of modularity or redundancy. Safety Protocol Gap: After diagnosing the leak, the authorized service center deferred to my personal judgment regarding operational safety. This forced an untrained consumer to make a critical safety determination on a high-pressure system while the vehicle remained capable of full highway speeds. Technical Confirmation: An authorized Rivian service center confirmed the failure on March 3, 2026, and determined a full system-wide replacement is required. All components are available for inspection. No prior warnings or symptoms were presen

The vehicle experienced a failure of the air suspension system, initially presenting with warnings indicating the vehicle was raising and advising not to drive to avoid damage. Shortly thereafter, the vehicle became visibly uneven, tilting approximately 2–3 inches to the driver side. I took the vehicle to Rivian service, where they confirmed the air suspension had failed. The repair was not covered under warranty, so I initially declined service while attempting to escalate the issue. During this time, the condition worsened significantly, with the vehicle continuing to tilt and the suspension actively lowering while driving. On multiple occasions, the vehicle became unstable and began bouncing uncontrollably, making it difficult to steer and maintain control, creating a serious safety risk and potential for collision. The issue was ongoing and reproducible. I ultimately proceeded with the repair and had the suspension system replaced; however, following the repair, the vehicle is now tilting in the opposite direction (passenger side), indicating a continued or recurring failure. The vehicle is available for inspection, and a follow-up service appointment is scheduled. The cause appears to be a failure of the air suspension system and/or improper repair, though the exact root cause is unknown.

My vehicle is subject to an active safety recall involving a rear toe bolt that Rivian has identified as potentially shearing and causing loss of vehicle control and a crash. I am located in Ketchikan, Alaska. Rivian does not offer mobile or field service for this recall and requires the vehicle to be transported to either Anchorage or Seattle for repair. Transport to Anchorage is not possible, and while transport to Seattle is possible, there is no viable or predictable way to return the vehicle to my location, potentially leaving me without my primary vehicle for several months. Rivian has stated they will not cover transport and has not provided a feasible alternative. This leaves me without reasonable access to a safety recall remedy and effectively requires me to either operate a vehicle with a known safety defect or surrender it indefinitely. I am reporting this as a lack of reasonable access to a safety recall repair.

Initially, my instrument screen on my vehicle went black and stopped working. I had to drive roughly 10 miles home without the use of my speedometer. After replacing the AXM module, the cruise control and lane-keeping functions intermittently stop working. The vehicle was at the service center on and off for 57 days before it was returned to me without a resolution. I’m told this issue is affecting 30 vehicles in the Rivian fleet; however, they don't yet have a permanent fix. I brought up my safety concerns and was assured that this issue will not affect the automatic emergency braking and other safety features, which I hope is true.

the electronic door handles are malfunctioning and not opening or staying open. when they stay in and dont present, the door remains locked and cannot be opened from the outside. This is a safety hazard if an occupant cannot exit the vehicle in an emergency and the door cannot be opened from the outside. I have already had one (drivers door) replaced and now both rear passenger doors are malfunctioning. this is an intermittent problem. I believe this to be a manufacturing defect that should be covered at the cost of the manufacturer.

I was driving about 35-40mpg when the right rear toe link snapped due to inproper torquing. I believe the bolt had backed out then snapped. When I contacted rivian they initially blamed me for it before even in before inspecting the vehicle. Once they inspected it they stated it would be covered under warranty. There was no paint on the bolt to show proper torque had been applied. Which is a standard process for rivian. I had asked them to please check the left rear toe link as well and make sure it’s all torque properly or even replace the link since they are one time use parts. They did not check it they did not paint mark any of the left side. They did paint mark the right side. The result of this link snapping out my family in great danger by sliding across the road and almost going into the mountain side. We were on the freeway while this happened I would not be writing the report. I beg you to please look into this matter. I no longer feel safe putting my family into the vehicle as I am scared something else was not put on correctly. They also stated in the service report that the halfshafts were not seated properly which could have caused a catastrophic accident. Thank you

Vehicle was flagged for software update 2025.34.01. Upon installation, the software produced an error. In response to initial support request, OEM pushed an unreleased and unpublished software update versioned 2025.34.20. The new update also produced the same errors, and additionally prevented the vehicle from being able to be shifted into the Drive position, rendering the vehicle immobile and unusable for a defined period of time.

Vehicle making excessive noise due to the half shaft. Half shaft has been changed twice in the last 3 years and still experiencing the same issue. Sometimes this results on excessive vibration on the steering wheel.

Vehicle lurched to a stop in a parking lot, unable to shift into gear. Warnings: “motor fault detected”, “system fault detected”, “all wheel drive permanently engaged”, “replace 12v battery. “ Currently being repaired under manufacture warranty. Manufacturer confirmed drive unit needed to be replaced. This could have been a terrible accident if it happened on the freeway. My wife and dog were in the car with me. There were no warning signs leading up to this moment. We were stranded 400 miles from home and needed several tows to get home and to the service center.

while driving on 85 south warning message appeared.

HVAC dumping water into drivers side carpet, creating mold, mildew, and slippery carpet. Vehicle was at Rivian service center 2 weeks ago to address this and other issues. This problem continues. Not sure if water is also intruding into electrical areas.

Tonight starting at 7:15pm to 8:00pm vehicle switched from all lights +foglights on to daytime driving lights or parking lights. It did this three times. I live in rural setting with hardly any public lighting and a lot of wildlife. I have contacted Rivian regarding this issue multiple times, they tell me the auto high beam selector must be on, auto high beam is not on, they tell me it must be a setting I enabled to which I sent them a recording of the settings showing them I have not enable any settings and anyhow why would auto high beam setting cause all headlights to go off and automatically switch to auto lights or parked lights? Vehicle was taken to rivian service center two weeks ago, picked up vehicle Wednesday 27th august 2025 afternoon. At the most recent service visit this issue was to be addressed, handled and rectified. I was unable to capture it on recording and this evening I installed a camera to record this problem.

The suspension system has failed three times. The entire system has been replaced by the dealership twice under warranty. The most recent failure has not been addressed, as the dealer is now refusing to make further repairs. The suspension issues significantly affect vehicle handling and steering during normal operation. Under heavy acceleration, the vehicle becomes difficult to control, posing a serious safety risk.

Catastrophic failure of rear upper control arm / suspension resulting in temporary loss of control. Occurred driving straight at 35mph without any prior damage or symptoms.

Defective charge port door that has no manual release. If it gets stuck, the vehicle can no longer be charged, potentially stranding the driver. Only solution is a service visit.

The vehicle brakes stopped working on the highway moving at 75 MPH. It felt like the brakes were locked mechanically after all the vehicle electronic fault codes appeared in the dash. The incident occurred [XXX] traveling down a highway right after a vehicle battery charge at a charging station. While driving, all error lights came on, including turtle mode, high voltage battery pack fault, front collision warning failure, failure in all 4 motors, failure of ABS and traction control, and most importantly failure in brake. Tried pulsating the brake, pressing as hard as possible on the brake pedal, but the brakes would not activate. The pedal was mechanically locked like when you try to turn a steering wheel without a key - that kind of lock. We pulled to the emergency lane and let the vehicle coast to a stop. We did a soft vehicle reset and then a hard vehicle reset. It continued locked. After about 5 minutes, all the error lights went out and vehicle worked again. Drove it home and called Rivian, who had the vehicle towed to their repair facility. While this is the first time the brakes failed, it was not the first time all the error lights came on after a battery charge at a charging station. The first time it happened, i took it to Rivian and they said it was a software glitch and gave it back to me without any repair. If a software glitch can cause your brakes to lock up at highway speeds, this needs to be addressed. This has happened 3 times since December of 2024. I also have a video that i can’t upload, but can provide through email. I can’t trust this vehicle with my life anymore. The vehicle has been in service over 12 times with suspension components replaced multiple times, vehicle error faults that can’t be traced to an issue, and now brake failure. This needs to be thoroughly investigated or someone can get killed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The front passenger seat sensor does not respond to a 135lb 5’9” person resulting in the airbag being disabled. This has been an issue since we purchased the vehicle and has not been resolved with 4+ visits to the service center. No other vehicles we have driven have ever had this problem.

Our rear passenger interior door handle stopped working today. We were unable to open the door from the inside of the car. I messaged Rivian support and we tried a software reset and checked to make sure the the child safety lock wasn’t on. Neither worked so I have scheduled a mobile service appointment for 2/11/2025. Checked inside the door panel and part of the door pull was broken off and loose inside the door. It looks like the cable barrel for the door release could have been anchored there a that was the point of failure.

Rear center seatbelt not bolted down at manufacture. Vehicle was brought in to a Rivian service center, for an NVH complaint coming from the rear seats. It was discovered that the rear seat belt was not secured properly to the vehicle frame.

Rivian updated it's the dashboard screen software on or about February 7th 2024 This update introduced a Short Cuts Access Panel UI change that displays from the left side of the center dashboard screen, 1. when the icon 3rd from the top-left is pressed, 2. The vehicle in shifted into Park. The delay time for this access panel UI to graphically slide in and display new buttons takes about 1.5 - 2 seconds after the vehicle is placed into Park. The driver may have the intent to use currently displayed buttons on the screen, like 'camera selection', 'open garage'. With driver intent underway and finger in motion or on touch screen surface, the Short Cuts panel is presented interrupting an intended press, or causing a complete different vehicle action to happen, such an example: the 'Open Tailgate' button was slid into position over the 'change rear camera' button. Where the driver's intent was to change the camera view because that was the button present to the driver just before and just after shifting the vehicle into Park, the move was made to press the 'change camera' button. Instead just before the finger could register the press on screen, the panel displayed a new button under the drivers finger and unsecured the vehicles tailgate. Had this unintended press happen while the vehicle was in a space that would have released the load or it would be otherwise dangerous to exit the vehicle and re-secure the tailgate all because the UI changed without the driver intent to display this changed panel of buttons. Rivian should not presume the drivers intent is to access the 'Short Cuts' panel, The panel should present on request of a button press, or by optional means that still puts driver intent back into UI display changes. If a driver has no intent to use 'Short Cuts' that are not always present on screen, the panel presentation is instead interfering with presently displayed input and causing unintended or even unsafe side effects.

The passenger airbag does not engage for my 115 lb girlfriend. The answer from Rivian is dangerous and takes no responsibility. Official complaint and answer from Rivian. Concern: - Customer states Their partner is unable to to trigger the airbag when sitting in the front seat Timestamp: 7:04-7:05 PM PST 2/4 Cause: - OCS operating as designed. Future OTA being planned to potentially address issue. How does a "future" update help keep my loved ones safe now???