Suzuki GSX-R1000

Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2017-2018 Suzuki DL650A, DL650XA, GSX-R1000, GSX-R1000R, and 2018 GSX-S750 motorcycles. During installation, the fuel pump O-ring may have been twisted, reducing the sealing performance and possibly resulting in a fuel leak.

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Suzuki will notify owners, and dealers will replace the fuel pump O-ring and the fuel tank inner vessel, free of charge. The recall began October 31, 2018. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 2A86-2A88.

Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2017-2018 GSX-R1000, GSX-R1000A, GSX-R1000RA, and GSX-R1000RZA motorcycles. When upshifting between first and second gear, if the rider fails to engage second gear, a neutral condition will exist and may cause very high engine RPM. If the rider then shifts into second gear without disengaging the clutch, the motorcycle’s chain may stretch or break.

If the drive chain breaks, the motorcycle will lose power, increasing the risk of a crash.

Suzuki will notify owners, and dealers will replace the Engine Control Module (ECM), and inspect and replace the drive chain and sprockets, as necessary, free of charge. The recall began on January 25, 2018. Owners may contact Suzuki customer service at 1-714-572-1490. Suzuki's numbers for this recall are 2A76 to 2A81.

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2011-2014 GSX-R750 and 2009-2014 GSX-R1000 motorcycles. If a gear is missed while upshifting, the strain applied to the drive chain after the next shift may cause the rear axle to move, damaging the left-side drive chain adjuster.

If the drive chain adjuster gets damaged, the drive chain may come off, removing power to the rear wheel, and increasing the risk of a crash.

Suzuki will notify owners, and dealers will replace the left-side chain adjuster with an improved part. The recall began on October 17, 2014. Owners may contact Suzuki customer service at 1-714-572-1490. Suzuki's numbers for this recall are 2A40, 2A41, 2A42 and 2A43.

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2013 GSX-R600 and GSX-R750, and model year 2005-2013 GSX-R1000 motorcycles. In combination with older brake fluid, corrosion of the brake piston inside of the front brake master cylinder generates gas that may result in a reduction of fluid pressure transmission to the front brake.

As a result, front braking power may be reduced increasing the risk of a crash.

Suzuki will notify owners, and dealers will replace the front brake master cylinder, free of charge. The recall began on November 18, 2013. Owners may contact Suzuki at 1-800-572-1490. Suzuki's campaign numbers for this recall are: 2A (31, 32, 33, 34, 35, and 36).

SUZUKI IS RECALLING CERTAIN MODEL YEAR 2012 GSX-R1000 MOTORCYCLES. DUE TO LOOSE BOLTS THE SIDE STAND INTERLOCK SWITCH MAY FAIL.

ON THE GSX-R1000 MODELS, FAILURE OF THE SWITCH WILL TERMINATE THE IGNITION CIRCUIT. AS A RESULT, THE ENGINE WILL STOP RUNNING, INCREASING THE RISK OF A CRASH.

SUZUKI WILL NOTIFY OWNERS, AND SUZUKI DEALERS WILL REPLACE THE SIDE STAND INTERLOCK SWITCH BOLTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 7, 2012. OWNERS MAY CONTACT SUZUKI AT 1-714-996-7040.

AMERICAN SUZUKI (SUZUKI) IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 26,082 MY 2005-2006 GSX-R1000 MOTORCYCLES. CRACKING OR BREAKAGE OF THE MOTORCYCLE FRAME CAN OCCUR IN CERTAIN EXTREME SITUATIONS WHERE UNUSUALLY HIGH STRESS IS PLACED ON THE FRAME. REPEATED HARD LANDINGS FROM HAZARDOUS MANEUVERS SUCH AS EXTREME OR EXTENDED WHEELIES OR OTHER STUNTS MAY GENERATE SUFFICIENT STRESS TO CAUSE THIS PROBLEM.

IF THE FRAME BECOMES BROKEN DURING EXTREME USE, A CRASH COULD OCCUR.

DEALERS WILL INSPECT THE FRAME FOR CRACKS. IF NO CRACKS ARE FOUND, A FRAME REINFORCEMENT BRACE WILL BE ATTACHED TO THE FRAME USING BOLTS AND EPOXY ADHESIVE. SHOULD CRACKS BE FOUND DURING THE INSPECTION, THE FRAME WILL BE REPLACED WITH A NEW FRAME THAT HAS THE REINFORCEMENT BRACE INSTALLED. THE CAMPAIGN BEGAN ON JANUARY 21, 2009. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.

MOTION PRO IS RECALLING 10,000 AFTERMARKET BRAKE LEVERS, MODEL NO. 14-0415, SOLD FOR USE ON CERTAIN MY 1999 THROUGH 2008 SUZUKI AND MY 1998 THROUGH 2003 YAMAHA MOTORCYCLES. THE LOBE HEIGHT ON SOME OF THESE LEVERS ARE SMALLER AND DO NOT PROPERLY ENGAGE THE STOMP LAMP SWITCH WHICH WILL NOT DEACTIVATE WHEN THE DRIVER RELEASES THE BRAKE LEVER. THE LEVER CAN BE IDENTIFIED BY THE MARKING "JY 378" AT THE BASE OF THE LEVER NEAR THE PIVOT BUSHING.

IF THIS OCCURS, THE STOP LAMP WILL REMAIN ON WHICH COULD POSSIBLY RESULT IN A CRASH.

MOTION PRO WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE RECALL BEGAN ON SEPTEMBER 11, 2008. OWNERS MAY CONTACT MOTION PRO AT 1-877-438-7831.

ON CERTAIN MOTORCYCLES, EACH TIME THE IGNITION SWITCH IS TURNED OFF, THE ENGINE CONTROL MODULE (ECM) PRE-SETS THE POSITION OF THE IDLE SPEED CONTROL (ISC) VALVE FOR SUBSEQUENT ENGINE STARTING BY OPENING THE VALVE COMPLETELY AND THEN CLOSING IT TO A START-UP POSITION.

DUE TO IMPROPER SHAPE OF THE INTERNAL MECHANISM THAT MOVES THE ISC VALVE, THE VALVE MAY REMAIN IN THE OPEN POSITION INSTEAD OF MOVING TO THE CORRECT START-UP POSITION. THIS CAN RESULT IN NO-LOAD ENGINE IDLE SPEEDS AS HIGH AS 5000 RPM THE NEXT TIME THE ENGINE IS STARTED. IF THE RIDER CHOOSES TO OPERATE THE MOTORCYCLE IN THIS CONDITION, THE RIDER MAY HAVE DIFFICULTY OPERATING THE MOTORCYCLE, WHICH COULD RESULT IN A CRASH.

DEALERS WILL REPLACE THE ISC VALVE WITH AN IMPROVED PART, AND WILL ALSO REPLACE THE ECM. THE RECALL BEGAN ON AUGUST 22, 2007. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.