Mitsubishi Lancer Evolution 2008 — Problemas relatados

The contact owns a 2008 Mitsubishi Lancer. The contact stated that after a while the system would erase any safety information used to track mileage and only show the GPS feature on the digital screen with information from 2004. The contact stated he used the digital screen for the safety features. Upon further inspection, the battery would be drained at an abnormal rate while using the Bluetooth features, and the Bluetooth would not work outside of the local dealer parking lot. The vehicle was taken to a local dealer where it was diagnosed that the digital screen and transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 98,000.

We had car at a car dealer and the manufacturer declined doing the recall on the car for corrison on the front crossmember, telling us due to car has a total loss record on Carfax. The vehicle total loss record was for a accident that didn't effect that part of the car that's under recall, it was due to vehicle repairs were more then what car was worth. The piece I think they call it crossmember has rust holes through it and is about to come apart at the rusted holes on the part. We buy the car JA3AU86U18U016308 in 2022 for our daughter to drive to college. Just finding out when we took it into the car place to perform this recall they won't do the recall because of Mitsubishi. I filled this out for my dad, he bought car for me.

The dealership that is repairing the drive belt recall, is attempting to charge me for the replacement of a damaged pulley.

The contact owns a 2008 Mitsubishi Lancer. The contact stated while her daughter was driving 45 mph, the vehicle began to roll out of the road and she was unable to steer back into the road. The contact stated no warning light was illuminated. The vehicle rolled over into a ditch. The contact stated no air bags deployed. The contact stated the driver hit her head and sought medical attention. A police report was filed. The vehicle was not drivable and was towed to the contact's residence. The vehicle was not diagnosed or repaired. A dealer was not contacted. The VIN was associated with NHTSA Campaign Number: 20V279000 (Structure, Suspension). The manufacturer had not been informed of the failure. The failure mileage was approximately 116,000.

Our car crashed after getting off the highway in NJ. This appears to be related to Safety Recall Report 20V-279. The cross member has completely rusted and the driver side control arm came off, crashing the car and severely damaging the car, with loss of control. I have contacted Mitsubishi Motors but have received no response from them. There was no warning sign, and the car was on the highway at highway speeds before an exit ramp was taken when the car crashed.

The airbags light came on after I bought the car and I am afraid of I get in an accident they will not deploy my mechanic said I would have to go to a car dealership about it... The brakes also fail if I try to stop abruptly they go to the floor and do not stop the vehicle... The brakes are the worst when I am driving slowly and try to come to a stop. I have taken my car to the dealership and was told that my brakes are in good condition and the mechanic didn't understand why the car was having issues stopping.

Air bag light turn on and off

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT STATED WHILE HIS WIFE WAS DRIVING AT 25 MPH, WHEN THE CROSS MEMBER SNAPPED AND DETACHED FROM THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE DRIVER WAS UNABLE TO CONTROL THE VEHICLE AND JUMPED THE CURB. THE DRIVER SUSTAINED A DISLOCATED RIGHT THUMB AND DID NOT SEEK MEDICATION ATTENTION. NO POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC AND WAS INFORMED THE CROSS MEMBER, UNKNOWN TIE ROD AND BALL JOINT WAS NEEDING TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V279000 (STRUCTURE, SUSPENSION), HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED TO UNKNOWN DEALER WHERE IT WAS CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN. (RECALL RELATED INCIDENT) TS

FRONT LOWER CONTROL ARMS -TEARING BUSHINGS, TORN BOOTS BOTH OUTER TIE ROD ENDS - TORN BOOTS TIMING COVER SEPARATE

I HEARD A CLUNKING NOISE. PARKED AND FOUND ROTTEN PARTS ON TIRE. MECHANIC SAID IT CANNOT BE FIXED. EVERYTHING ROTTED. NEEDS WHOLE NEW FRAME. WE COULD HAVE BEEN KILLED.THANK GOD I WAS CLOSE TO HOME. NOW I HAVE NOTHING BUT AN EXISTING CAR LOAN FOR IT.

I RECENTLY PURCHASED A 2008 MITSUBISHI LANCER THERE IS A PROBLEM WITH THE CVT TRANSMISSION OVERHEATING THE LIGHT STATING SLOW DOWN APPEARS ON DASHBOARD I HAVE TO PULL OFF THE ROAD TURN OFF ENGINE AND WAIT BETWEEN 10 TO 20 MINS BEFORE IM ABLE TO DRIVE AGAIN THERE ARE MANY COMPLAINTS REGARDING THE TRANSMISSION OVERHEATING ON THE 2008 ,2009 AND 2016 FROM MY UNDERSTANDING ITS THE TRANSMISSIONS THAT WERE USED ON ON THOSE YEARS OF VEHICLES NOW WEATHER OR NOT ITS MECHANICAL OR POOR DESIGNED TRANSMISSIONS THE MANUFACTURER SHOULD HAVE PUT A RECALL ON THESE VEHICLES THE MANUFACTURER SHOULD HAVE A RECALL ON THESE VEHICLES TO REPLACE THE TRANSMISSIONS

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V279000 (STRUCTURE, SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED SUNNYSIDE MITSUBISHI (7630 PEARL RD, MIDDLEBURG HEIGHTS, OH 44130; (440) 243-7711) WHERE IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.*DT*JB

MY SRS LIGHT JUST STARTED COMING ON A FEW YEARS AGO BEFORE WE WERE IN AN ACCIDENT. WHEN WE TOOK IT TO THE DEALER TO CHECK IT, THEY SAID IT WAS A COSTLY REPAIR AND IS ONLY TO REMOVE THE LIGHT...BUT THAT THE AIRBAGS WOULD STILL DEPLOY IF WE WERE IN AN ACCIDENT. SINCE THEN, WE'VE BEEN IN AN ACCIDENT WHERE WE WERE REAR-ENDED (WHICH WOULD NOT DEPLOY THE AIRBAGS) BUT IT PUSHED US INTO THE CAR IN FRONT OF US (WHICH SHOULD HAVE DEPLOYED THE AIRBAGS). SEEING AS THIS LIGHT JUST CAME ON WAY BEFORE ANY ACCIDENTS AND COULD NOT HAVE BEEN CAUSED BY ANYTHING WE DID, I BELIEVE IT TO BE FAULTY FROM THE MANUFACTURER. WHEN GOOGLING THIS ISSUE, I FOUND A LOT OF PEOPLE COMPLAINING ABOUT THE SAME THING HAPPENING. YET, MITSUBISHI HAS NEVER BEEN PUSHED TO MAKE THEIR SEAT BELT PRETENSIONER FLAW INTO A SAFETY RECALL AND EXPECTS TO JUST MAKE MONEY OFF MITUBISHI OWNERS COMING IN TO PAY TO HAVE THIS FIXED.

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL NUMBER: 20V279000 (STRUCTURE, SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. SERRA HONDA (951 INTERSTATE PKWY, AKRON, OH 44312) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE FOR THE RECALL REPAIR. THE CONTACT STATED WHILE DRIVING 10 MPH, WITHOUT WARNING, THE CONTACT LOSS CONTROL OF THE STEERING WHEEL AS THE DRIVER'S SIDE OF THE VEHICLE LOWERED INDEPENDENTLY. THE VEHICLE WAS TOWED TO THE RESIDENCE AND INSPECTED. THE CONTACT BECAME AWARE THAT THE DRIVER'S SIDE LOWER CONTROL ARM WAS FRACTURED. THE VEHICLE WAS TOWED TO JIM SHORKEY MITSUBISHI (13339 RTE 30, IRWIN, PA 15642) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE DRIVER'S LOWER CONTROL ARM FRACTURED AND DAMAGED THE CROSSMEMBER. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATE 32,393.

THE CONTROL ARM WAS CORRODED AND SPRING RUSTED THROUGH AND BROKE. HAD REPAIRED IN MARCH OF 2019. SHOULD BE COVERED UNDER RECALL. SENT INVOICE AND RECEIPT TO MITSUBISHI HOWEVER THEY ARE SAYING IT DID NOT MEET TIME FRAME FOR REPAIR AND ARE REFUSING TO REFUND ANY OF MY REPAIR COSTS.

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT STATED THAT THE CROSSMEMBER BEAMS WERE RUSTED THROUGH. THE VEHICLE WAS TAKEN TO MAX MATSON MITSUBISHI DEALER LOCATED AT 3990 OGDEN AVE, AURORA, IL 60504, WHERE THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V279000 (STRUCTURE, SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER DECLINED TO PROVIDE A REIMBURSEMENT BECAUSE THE REPAIRS WERE OVER TWO YEARS OLD. THE FAILURE MILEAGE WAS 116,727.

HAS ACTIVE RECALL I WANT THE SUNROOF REPLACE NOT JUST INSPECTED I WANT IT FIXED TO AVOID FUTURE PROBLEM OF FLYING OFFER LEAKING

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL BECAME VERY LOOSE. THE CONTACT STATED THAT THE STEERING WHEEL MOVED FROM THE CENTER WHILE ATTEMPTING TO DRIVE STRAIGHT. THE CONTACT PULLED OVER AND HAD THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CROSSMEMBER ON THE DRIVER'S SIDE OF THE VEHICLE HAD RUSTED THROUGH AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE MANUFACTURER INFORMED THAT THE CONTACT THAT NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION) WAS FOR VEHICLE MODEL YEAR 2002-2007 AND NOT FOR 2008. THE APPROXIMATE FAILURE MILEAGE WAS 168,000.

I PURCHASED A USED 2008 MITSUBISHI LANCER WITH 163K MILES ON IT FROM A THIRD PARTY. I TOOK IT TO THE DEALERSHIP FOR TWO OPEN RECALLS. THE DEALER CALLED ME THE NEXT MORNING AND EXPLAINED TO ME THAT THE SUBFRAME IS CORRODED AND WILL NEED TO BE REPLACED. IN FACT THE DEALER ADVISED THE VEHICLE NOT BE DRIVEN AND THE PART BE REPLACED IMMEDIATELY BECAUSE IT IS UNSAFE TO DRIVE. NOW I HAVE A VEHICLE I CAN'T DRIVE OR SELL. THE REPAIR ITSELF IS MORE THAN THE CAR IS WORTH. THE SUBFRAME IS PART OF THE FRAME AND IS NOT A MAINTENANCE ITEM AND SHOULD LAST THE LIFE OF THE VEHICLE. THIS IS A MANUFACTURING DEFEAT AS SHOWN IN THE RECALL FOR CANADA ON 2008-2013 LANCER MODELS. I CALLED THE FACTORY AND WAS GIVEN THE RUN AROUND. I ASKED FOR A MEETING BETWEEN THE DEALERSHIP AND A FACTORY REP TO FIND AN APPROPRIATE SOLUTION BUT NOTHING HAS MATERIALIZED. THIS IS A SAFETY ISSUE AND NEEDS TO BE ADDRESS BY THE MANUFACTURER BEFORE SOMEONE GETS INJURED OR KILLED. THERE ARE THOUSANDS OF LANCERS ON THE ROADS TODAY AND I WOULD HATE TO KNOW HOW MANY OF THESE HAVE CORRODED SUBFRAMES WHERE THE LOWER FRONT CONTROL ARMS COULD FALL TO THE GROUND.

I WAS DRIVING MY CAR TO WORK THIS MORNING AND ALL OF A SUDDEN I FELT A DRASTIC PULL TO THE LEFT. I GET OUT OF THE CAR AND LOOK AT ALL SIDES OF THE VEHICLE AND DON'T NOTICE ANYTHING RIGHT AWAY. THEN I NOTICE MY LEFT FRONT WHEEL IS TURNED SLIGHTLY WHILE THE STEERING WHEEL IS STRAIGHT. I LOOK UNDER THE VEHICLE TO FIND THE SUB FRAME ROTTED AND RUSTED AWAY FROM THE CONTROL ARM. THIS IS A HUGE SAFETY ISSUE AS THIS CAR HAS 123K MILES AND BEING A 2008 CAR, JUST 1 YEAR LATER THAN THE RECALLS CURRENTLY UP TO 2007 FOR THE SAME EXACT ISSUE. THE RECALL SHOULD BE EXTENDED TO THE 2008 VEHICLES AS WELL DUE TO THE INSANE AMOUNT OF COMPLAINTS ON THIS SPECIFIC SUB FRAME ROTTING ISSUE.

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO TURN, THE CROSSMEMBER ON THE DRIVER'S SIDE FRACTURED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

DURING MY LAST TWO VISIT WITH TECHNICIAN (LAST ONE WITH MITSUBISHI DEALER, AND ONE BEFORE WITH OTHER SERVICE PLACE), THE VEHICLE TECHNICIAN NOTICE EXCESSIVELY RUSTED CROSS-MEMBER. THE TECHNICIAN AT MITSUBISHI DEALER ALSO PUT THE NOTE IN "COMPUTERIZED VEHICLE REPORT". WHEN I ASKED THE TECHNICIAN ABOUT HOW BAD IS THIS AND HOW TO FIX THIS, HE MENTIONED THAT OTHER MITSUBISHI LANCER VEHICLES ARE AFFECTING WITH THE SAME PROBLEM AND MITSUBISHI IS RECALLING VEHICLES YEAR BY YEAR, SO HOPE THEY WILL RECALL THIS MODEL TOO. AND FOR SAFETY, I NEED TO MAKE SURE TO KEEP EYE AND NEED TO PAY ATTENTION TO ANY CHANGE TO VEHICLE WHILE DRIVING AS THIS MAY CRACK AND I AM END UP IN ACCIDENT. *TR*JB

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V070100 (VISIBILITY). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. RICARDO CABALLERO MITSUBISHI AUTO CORP (LOCATED AT 10, 4 CLL 5, COAMO, 00769, PUERTO RICO, +1 787-303-4457) CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

ALL MITSUBISHI LANCER EVOLUTION X FROM YEARS 2008 THROUGH THE CARS FINAL GEAR IN 2015 SUFFER FROM A DESIGN FLAW TO THE S-AWC SYSTEM. THE ACTIVE YAW CONTROL / ACTIVE CENTER DIFFERENTIAL SYSTEM RELIES ON A PUMP IN ORDER TO OPERATE . THE LOCATION IS UNPROTECTED FROM THE ELEMENTS AND THOUSANDS OF THEM HAVE FAILED TO DATE. . MINE FAILED WHICH RENDERED MY CAR TO NO LONGER DRIVE IN A PREDICTABLE OR SAFE MANNER. THE ALL WHEEL DRIVE AND STABILITY CONTROL SYSTEM WAS COMPROMISED AND TRACTION CONTROL NO LONGER FUNCTIONS AS EXPECTED. INSTEAD OF THIS BECOMING A RECALL MITSUBISHI EXTENDED A WARRANTY TO REPLACE THIS EXACT COMPONENT RATHER THAN ADMITTING FAULT FOR AN OBVIOUS DESIGN FLAW. THEY REFUSED TO WARRANTY MINE AS THIS EXCEPTION WAS ONLY MADE AFTER MY WARRANTY HAD ALREADY EXPIRED EVEN THOUGH MY PUMP FAILED BEFORE I HIT 100K MILES. THE ACD / AYC PUMP IS CRITICAL COMPONENT TO THE SAFETY AND STABILITY OF THE LANCER EVOLUTION 10 . EXTENDING THE WARRANTY TO ONLY COVER A SMALL PORTION OF FAILURES IS UNACCEPTABLE AND DISHONEST. THE DESIGN IS UNSAFE AND THE REPAIR AND REPLACEMENT OF THIS AND OTHER AFFECTED COMPONENTS IS EXTREMELY COSTLY. THIS SHOULD BE A RECALL. ALL PUMPS WILL EVENTUALLY FAIL AS THE SEALS EVENTUALLY FAIL AND CORROSION OF THE PUMP OR ELECTRIC MOTOR . THIS EFFECTS ALL EVOLUTION 10S REGARDLESS OF CLIMATE. HERE ARE OTHERS FACING THE SAME HTTPS://WWW.EVOLUTIONM.NET/FORUMS/EVO-X-ENGINE-TURBO-DRIVETRAIN/660431-ACD-AYC-PUMP-FAILURE-REPORTS-11.HTML HERE IS ONE COMPANY SELLING A KIT TO RELOCATE THE PUMP TO THE TRUNK OF THE CAR AS THIS HELPS TO PROTECT THE PUMP FROM THE ELEMENTS AND ULTIMATELY PREMATURE FAILURE HTTPS://WWW.DRIVEN-FABRICATION.COM/PRODUCTS/EVO-X-ACD-AYC-RELOCATION-KIT-PRE-ORDER THERE ARE ALSO AFTERMARKET COMPANIES OFFERING UPGRADED O RINGS AND REBUILD KITS SINCE MITSUBISHI ONLY REPLACES PUMPS WITH NEW ONES AND HASN'T ACTUALLY FIXED THE DESIGN

BRAKES ON VEHICLE WENT TO THE FLOOR AND STARTED TO MAKE AN AIR SUCKING SOUND TOOK A COUPLE MINUTES TO PUMP THE BRAKES BACK UP BEFORE COULD START DRIVING AGAIN.

TUESDAY, 11/27/18, MORNING MY CAR (100,00 TOTAL MILES DRIVEN) STARTED TO MAKE A PERIODIC SQUEAKING NOISE WHILE DRIVING ON THE FREEWAY TO WORK. I THEN TOOK IT TO AN AUTO REPAIR SHOP THAT SAME MORNING TO HAVE IT CHECKED. THEY SAID THAT THE PROBLEM WAS COMING FROM MY DRIVE BELT AND PULLEYS. THEY REFERRED ME TO THE FOLLOWING LINK: HTTPS://WWW.CARS.COM/RECALLS/MITSUBISHI-LANCER-2008/. ACCORDING TO THIS WEBSITE, MY CAR HAS A RECALL FOR THE DRIVE BELT AND PULLEYS. SO I WENT ON MITSUBISHI'S RECALL WEBSITE TO PUT IN MY VID NUMBER, BUT IT WAS SHOWING THAT MY CAR DOES NOT QUALIFY FOR THE RECALL. SO I PROCEEDED TO HAVE THE AUTO REPAIR SHOP REPAIR MY CAR ACCORDING TO THE RECALL INSTRUCTIONS SHOWN ON THE WEBSITE THAT HE REFERRED ME TO, WHICH INVOLVES REPLACING THE DRIVE BELT, PULLEYS, AND DRIVE BELT TENSIONER. IT SEEMED TO HAVE FIXED THE PROBLEM, BUT THE NEXT DAY (11/28) ON MY BACK HOME FROM WORK, I STARTED HEARING ANOTHER NOISE AFTER COMING OFF THE FREEWAY. I NOTICED THAT MY DRIVE BELT HAD BEEN TORN. PLEASE REFER TO THE ATTACHED PICTURE. SO I CONTACTED THE AUTO REPAIR SHOP TO LOOK INTO IT AGAIN. THEY HAVE REPLACED THE DRIVE BELT AGAIN, BUT RECOMMENDED THAT I TRY TO CONTACT MITSUBISHI AGAIN. ACCORDING TO THEM, THE SYMPTOMS MATCH THE INFORMATION IN THE RECALL, BUT AGAIN, MITSUBISHI'S WEBSITE SAYS THAT MY CAR DOES NOT QUALIFY FOR THIS RECALL. PRIOR TO THIS EVENT, I HAD MY DRIVE BELT AND BATTERY REPLACED. IS MITSUBISHI IN NO WAY RESPONSIBLE FOR THIS? I DO NOT RECALL RECEIVING A LETTER BACK IN 2014 ABOUT ANY RECALL, BUT I MAY NOT BE REMEMBERING CORRECTLY. IS IT POSSIBLE TO SEE THE HISTORY OF RECALLS THAT WERE DONE ON MY CAR? THANK YOU, (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AYE/ HYDRALIC PUMP WAS NEVER CHANGED OUT WAS TOLD WHEN I WENT TO DO A MANUFACTURING RECAL THAT IT WORKED FINE WHEN IT DIDNT AND AFTER WARDS HIT PAST THE 100,000 MILES AND WAS AUTOMATICALLY UNABLE TO GET THE REPLACEMENT.

IN 2015 MY 2008 MITSUBISHI LANCER DID NOT PASS CA STATE SMOG. MY LOCAL MECHANIC DID THE NECESSARY TESTS AS DIRECTED BY THE LOCAL STATE REFEREE, THEY SAID THE PROBLEM WAS THE 02 SENSOR. ENDED UP BEING DIRECTED BY REFEREE TO MITSUBISHI OF EL CAJON AND PAID $125.00 FOR THEM TO TEST IT. THEY SAID THEY COULD NOT FIND THE PROBLEM. THEN WAS TOLD TO MAKE APPT WITH THE REFEREE ON YET ANOTHER DAY FOR THEM TO TEST IT AND ENDED UP RECEIVING A 2YR PASS BECAUSE THE CAR STILL WOULD NOT COMPLETE RUN TEST. REPORT STATES: FAILED DUE TO VEHICLE OBD SYSTEM HAS NOT SET THE READINESS MONITOR(S). I DID NIT HAVE TJE MONEY TO FIX THE ISSUE IN 2015 SO HAD TO KEEP IT PARKED UNTIL NOV 2016 FROM WHICH POINT THE ABOVE WAS DONE. NOW ITS 2YRS LATER IT'S STILL NOT PASSING. REFEREE HAS ONCE AGAIN REFERRED ME TO MITS MOTORS, NOTING THAT RECENTLY ALL OTHER TYPES OF MITS MODELS WITH SAME ISSUE HAD ALREADY BEEN REPAIRED AND THAT THEY WILL NOT ISSUE ANOTHER PASS TO ME EVEN THO MY CAR WASN'T ON A RECALL LIST THAT BECAUSE SO MANY OF MITS MODELS HAD THIS SAME ISSUE, THEY SHOULD BE REQUIRED TO REPAIR THIS PROBLEM FREE OF CHARGE. MITS STATES THAT TODAY, ON THIS DAY OF OCT. 8TH 2018 THAT I MUST STILL PAY ANOTHER $125.00 FOR INSPECTION. IF AND ONLY THEY FIND THAT THIS SAME ISSUE FROM ACTUALLY 3YRS AGO IS ON A TBS LIST, THAT ONLY THEN WILL THEY COVER PARTS AND SERVICE. I LIVE ON A VERY TIGHT BUDGET AND HAD TO DRIVE CLEAR FROM OCEANSIDE TO HAVE IT LOOKED AT AGAIN. I FEEL LIKE IM GETTING THE RUN AROUND AND BEING COMPLETELY SWINDLED. I CANNOT AFFORD TO KEEP DEALING WITH THIS SAME ISSUE WITH I KEEP MY CAR TOTALLY MAINTAINED ON A REGULAR BASES AND ALL OIL CHANGES EVERY 3 MONTHS. THIS PROBLEM WAS ON THE THE TSB LIST FOR MANY OF MITSUBISHI'S OTHER MODELS AND THEY WERE DIRECTED BY THE STATE TO FIX THE ISSUES FREE OF CHARGE. BUT IM STILL REQUIRED TO CONTINUE JUMPING THRU HOOPS AND PAYING OUT OF POCKET. WHY? CAR RUNS FINE!

WHILE DRIVING ON BACK STREET THE CAR STARTED PULLING DRAMATICALLY TO THE LEFT. ON FURTHER INSPECTION IT WAS NOTICED THAT WHERE THE WHEEL CONNECTS TO THE SUBFRAME THERE WAS EXCESSIVE ROT THE POINT THE WHEEL WAS NO LONGER ATTACHED AT THE BOTTOM OF THE SUBFRAME. CONTACTED MITSUBISHI. THEY SAID THE LANCER (AND OTHER MODELS) HAD A RECALL ON EXCESSIVE SUBFRAME ROT BUT ONLY YEARS 2002 TO 2007 FOR THE LANCER. MINE BEING 2008 IS NOT RECALLED. I WILL HAVE TO PAY FOR REPAIRS $2000. THIS IS A HUGE SAFETY ISSUE AS THE SUBFRAME HOLDS THE WHEELS ON, AND THE ENGINE IN PLACE AND IT HAD A CATISTROPIC FAILURE WHICH COULD HAVE EASILY RESULTED IN LOSS OF CONTROL AND LOSS OF LIFE. I WAS NOT NOTIFIED OF THIS OR I COULD HAVE INFORMED MY MECHANIC TO CAREFULLY LOOK FOR SUBFRAME ROT (MOST INSPECTIONS ARE JUST BY SITE). HAD ANYONE HIT THIS SUBFRAME WITH A HAMMER THEY WOULD HAVE SEEN IT WAS DISSINTEGRATING. THE CAR DOES LOOK LIKE ITS RECALLED IN CANADA " TRANSPORT CANADA RECALL 2016317, WHICH WAS ISSUED ON JUNE 21, 2016. THE RECALL INVOLVES 64,305 MITSUBISHI OUTLANDER AND LANCER MODELS MANUFACTURED BETWEEN 2003 AND 2013." MITSUBISHI CUSTOMER RELATIONS HAS INFORMED ME TODAY THAT I WILL BE RESPONSIBLE FOR THE REPAIR. THIS IS NOT RIGHT. FAILURE OF A SUBFRAME IS A VERY RARE EVENT. ITS CLEAR THIS SUBFRAME HAS THE SAME EXACT PROBLEM AS THE LANCERS BUILT THE YEAR BEFORE. THE OUTLANDER ALSO HAS THE EXACT SAME SUBFRAME. THE DEALER HAS MY SUBFRAME IN STOCK BECAUSE ITS EXACTLY THE SAME AS THE OUTLANDER (WHICH IS COVERED). I AM HOPING THEY REALIZE THAT NOT INFORMING CUSTOMERS OF THIS DANGEROUS SITUATION COULD RESULT IN POSSIBLE LOSS OF LIFE. INFORMING THE LANCER OWNERS UP TO 2013 (AS THEY DID IN CANADA) COULD SAVE LIVES.

MAR 29,2012 MANUFACTURER RECALL NUMBERSR-12-002 NHTSA RECALL NUMBER12E012 RECALL STATUSRECALL INCOMPLETE SUMMARY THE HEADLAMPS USED FOR PRODUCTION VEHICLES ALLOW FOR HORIZONTAL ADJUSTMENT DURING THE VEHICLE ASSEMBLY PROCESS, BUT THE ADJUSTMENT IS SEALED AFTER THE HEADLAMPS ARE INSTALLED SO THAT NO FURTHER ADJUSTMENTS CAN BE MADE. THESE HEADLAMPS WERE MISTAKENLY SHIPPED TO DEALERS AS A SERVICE PART WITHOUT FIRST DISABLING THE ADJUSTMENT FEATURE. SAFETY RISK WITHOUT THE HORIZONTAL ADJUSTMENT MECHANISM DISABLED, THE HEADLIGHT CAN BE ADJUSTED TO EITHER REDUCE THE DRIVER’S VISIBILITY OR BLIND ONCOMING TRAFFIC. BOTH CONDITIONS INCREASE THE RISK OF A CRASH AND CAN OCCUR WITHOUT PRIOR WARNING. REMEDY THE DEALERSHIP WILL INSPECT YOUR VEHICLE TO DETERMINE IF THE HORIZONTAL ADJUSTMENT MECHANISM ON YOUR HEADLAMPS HAS BEEN DISABLED. IF NECESSARY, THE DEALER WILL REPAIR YOUR HEADLAMPS BY SEALING AND DISABLING THE HORIZONTAL ADJUSTMENT MECHANISM, FREE OF CHARGE SO BASICLY I WOULD LIKE TO KNOW WHERE I CAN GET THIS FIXED AND GET A FREE PAIR OF HEADLIGHT FOR DRIVING MY CAR FOR SO LONG WITHOUT BEING NOTIFIED. THE ONLY REASON I FOUND OUT WAS BECAUSE I WAS TRYING TO PUT IN A NEW RADIO IN MY CAR AND THE RECALL NOTICE CAME UP.

WHEN I WAS ON MY WAY HOME FROM WORK, I STOPPED AT THE STORE TO GRAB A FEW THINGS. WHEN I WAS DONE, I GOT IN MY CAR AND STARTED TO BACK OUT OF THE PARKING SPOT. I THEN HEARD A CLUNK NOISE, BUT DISMISSED IT BECAUSE I WASN'T SURE WHAT IT WAS. I THEN PULLED OUT OF THE PARKING LOT AND STARTED TO DRIVE ROUGHLY 5-10MPH, WHEN MORE CLUNKS HAPPENED AND THE STEERING WHEEL WENT ALL OVER AND I LOST CONTROL AND WAS FORCED TO STOP IN THE MIDDLE OF THE ROAD. I GET OUT OF SEE WHAT HAPPENED, AND I CAN SEE THAT THE WHOLE SUBFRAME CROSSMEMBER WAS COMPLETELY ROTTED THROUGH, AND THE LOWER CONTROL ARM HAD BROKEN FROM ALL THE ROT AND WAS LOOSE. THIS ALSO CAUSED MY CV AXLE/DRIVESHAFT TO SNAP AS WELL. THERE WAS NO INDICATION THAT ANYTHING WAS WRONG UP TO THIS POINT, AND I WAS COMPLETELY UNAWARE THAT THIS COULD ACTUALLY HAPPEN. HAD THIS HAPPENED 10 MINUTES EARLIER WHEN I WAS DRIVING ON A HIGHWAY AND I LOST CONTROL, I MIGHT NOT BE HERE TYPING THIS MESSAGE. IT IS ALSO ONLY ON THE FRONT DRIVER SIDE CROSSMEMBER THAT HAS ALL THE ROT. THE PASSENGER SIDE LOOKS FAIRLY NORMAL, WHICH I DON'T UNDERSTAND WHY. SOMETHING WITH THE FRONT DRIVER SIDE WAS CLEARLY IGNORED IF IT IS ONLY AFFECTED ON THAT SIDE. THERE IS ALSO COMPLAINTS AND POSTS ONLINE ABOUT THE SAME ISSUE, SO IT IS NOT JUST AFFECTING ME. THERE IS ALSO A RECALL FOR THE SAME EXACT ISSUE, SUBFRAME CROSSMEMBER ROT, FOR THE 2002-2007 LANCER, BUT THIS SHOULD HAVE BEEN EXTENDED TO 2008 OR HIGHER BECAUSE THIS IS A SERIOUS ISSUE AND PEOPLE COULD LOSE THEIR LIVES OVER THIS. ALSO, MY CAR WAS BUILT IN 2007, SO IT'S POSSIBLE THAT I MAY BE AFFECTED IN THE RECALL FOR THE 2002-2007 GROUP, BUT MY CAR IS CLASSIFIED AS A 2008. IT ALSO ONLY HAS JUST OVER 32,000 MILES, THIS SHOULDN'T HAVE HAPPENED.

MITSUBISHI RECALL 09V077000 IN THE PAST FEW DAYS, I NOTICED THAT WHILE IN MOTION MY BREAKS WERE NOT REACTING WITH THEIR TYPICAL SPEED. WHEN I TOOK MY CAR INTO A MECHANIC, THEY SAID IT WAS AN ISSUE WITH MY CAR'S BRAKE BOOSTER CHECK VALVE AND THAT THERE WAS A SAFETY RECALL REGARDING THIS BACK IN 2009. I WAS CONCERNED AS I HAVE TAKEN MY CAR IN FOR, FRANKLY, MORE RECALLS THAN I CAN EVEN REMEMBER, SO I CALLED MY DEALERSHIP TO SCHEDULE THE MAINTENANCE. AFTER A LOT OF BACK AND FORTH WITH BOTH THE DEALERSHIP AND MITSTUBISHI'S CUSTOMER SERVICE, IT TURNS OUT THAT MY CAR WAS NOT CONSIDERED AS IT WAS MADE "SIX MONTHS BEFORE." THIS IS REALLY ODD AS, FROM ALL THE DESCRIPTIONS OF THE RECALL, NO TIMELINES WERE SPECIFIED, JUST THE MODEL YEARS AFFECTED. IF MY CAR WAS TRULY NOT IN THE NEED OF THE RECALL, THAT'S COMPLETELY FINE, BUT THE ANSWERS I RECEIVED REGARDING THIS REALLY DIDN'T MAKE SENSE TO ME, AND I'D RATHER REPORT IT IN CASE MORE PEOPLE ARE AFFECTED THAN JUST TAKE IT AT FACE VALUE.

I BROUGHT MY CAR INTO THE DEALERSHIP IN 2016 FOR A FLASHING TARAMIC LIGHT AND THEY TOLD THERE WASN'T ANYTHING WRONG. WHICH I LATER FOUND OUT THAT THEY NEGLETED TO LOOK INTO THE ISSUE. I HAD NO IDEA WHAT THIS ISSUE WAS UNTIL 6 MONTHS LATER AND I JUST HAD REACHED 100,500 MILES ON THE CAR. I FOUND ON A FORM IT COULD BE THE A FLUID ISSUE, SO I WENT TO MITSUBISHI TO GET FLUID AND THE SERVICE MANAGER INFORMED ME OF THE 100,000 MILE WARRANTY. I EVENTUALLY TOOK MITSUBISHI TO COURT FOR NEGLIGENCE AND LACK OF CARE AND THE CASE WAS THROWN OUT. I'M SICK OF DEALING WITH THIS ISSUE.

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING 5 MPH, AN ABNORMAL NOISE WAS HEARD WHILE THE FRONT DRIVER'S TIRE FACED THE OPPOSITE DIRECTION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CROSS MEMBER SUBFRAME WAS CORRODED, FRACTURED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

CONTROL ARM BECAME DETACHED FROM CROSS MEMBER DUE TO EXTREME CORROSION. VEHICLE WAS IN MOTION WHEN THIS HAPPENED. THERE WERE RECALLS FROM EARLIER MODELS DUE TO THE SAME EXACT THING HAPPENING.

AT 50 KM/H, WHEN TURNING THE STEERING WHEEL TO THE LEFT OF 90 DEGREE, THE VEHICLE WAS NOT TURNING AND GOING STRAIGHT FORWARD. SOME SOUND OF TIRE-METAL WAS BEING HEARD FROM THE FRONT LEFT WHEEL. WITH SOMEONE OUTSIDE, WE WERE SEEING AT LOW SPEED THAT THE WHEEL WAS ROTATING OFF AXIS AND EVEN TOUCHING THE CAR BODY. AFTER BEING TOWING TO A CANADIAN TIRE, THE TECHNICIAN MENTIONED THAT THE CROSS MEMBER WAS SO ROTTEN IT WAS ACTUALLY BREAKING IN TWO PARTS AND IT WAS SO DANGEROUS, HE COULD NOT LET ME GO WITHOUT PART REPLACEMENT. THE MECHANIC TECHNICIAN TOLD ME THAT OTHER LANCER HAD THE PROBLEM EVEN A 2009 LANCER. THEY REFERRED ME TO THE TRANSPORT CANADA RECALL # 2016317, HOWEVER THIS ONE IS ONLY FOR LANCER 2003 TO 2006 (AND ALSO OUTLANDERS). NOTE THAT MY PROBLEM WAS THE SAME CAR PART AS THE RECALL MENTIONED ABOVE. I CALLED THE DEALER SHIP TO VERIFY THE CROSS MEMBER CAR PART VS THE OLDER MODEL AND THE PART NUMBER WAS DIFFERENT. I'M WONDERING HOW DIFFERENT FROM 2003 TO 2006 THE CART PART IS! THEY ALSO MENTIONED THAT DODGE CALIBER HAS THE SAME CAR PART IN PROBLEM WITH EXTENDED WARRANTY. I FOUND THIS ARTICLE RELATED TO THIS HTTPS://CHRYSLER.OEMDTC.COM/457/FRONT-AND-REAR-CROSSMEMBER-CORROSION-X69-WARRANTY-EXTENSION-2008-2012-DODGE-CALIBER-JEEP-COMPASSPATRIOT/2

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING VARIOUS SPEEDS, A BURNING ODOR WAS PRESENT AND AN ABNORMAL NOISE WAS HEARD COMING FROM THE GLOVE BOX. NO VISIBLE FLAMES WERE PRESENT. THE CONTACT, WHO WAS ASE CERTIFIED, DIAGNOSED THAT THE BLOWER MOTOR ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE FAN BLADE WAS CLEANED OFF AND ASHES WERE VISIBLE. THE VEHICLE WAS NOT REPAIRED. THE DEALER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V233000 (VISIBILITY). THE MANUFACTURER WAS CALLED AND CONFIRMED THAT THE VEHICLE WAS NOT ABLE TO BE SERVICED PER THE RECALL. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 183,032.

HAVE DONE TRANSMISSION OIL CHANGE ASK REQUESTED IN MANUAL, HOWEVER IF ITS A HOT DAY AND YOU DO 65 THE TRANSMISSION BEGINS TO GRIND, THEN IT SLOW YOU DOWN. IT ACTUALLY TELLS YOU TO SLOW DOWN, WE USUALLY HAVE TO STOP FOR 5 MINUTES BEFORE WE CAN GET GOING AGAIN. I AM GIVING TODAY'S DATE BUT IT BEGIN LAST YEAR MAY OF 2016

AYC PUMP FAILED CODE C161E. I SEARCHED ONLINE AND FOUND OUT THAT THE PUMP WAS FAILING DUE TO SALT CORROSION. THIS SHOULD OF BEEN A RECALL SINCE NURMEROUS OF OTHER CARS ARE HAVING THE SAME ISSUE.

ACD/ACY RECALL. I PURCHASED MY 2008 EVO WITH 95000 MILES ON IT. SHORTLY AFTER I BOUGHT THE VEHICLE I WAS HAVING ISSUES WITH IT RUNNING LEAN AND MY AYC SERVICE LIGHT APPEARED ON THE DASH. I THEN TOOK THE VEHICLE TO THE DEALERSHIP WITH 96000 MILES ON THE CAR IN HOPES FOR THEM TO HELP ME FIX THESE ISSUES WITH MY CAR AND YET THERE WAS NO HELP AT ALL. SO THEN I WENT ON MY WAY AND I HAD ANOTHER DEALERSHIP FIX MY PROBLEMS AND I WAS GOOD FOR ABOUT 4200 MILES MY CAR THEN HAD 100,200 MILES ON IT AND I HAD TO GO TO THE DEALERSHIP TO GET A REAR DIFF FLUID CHANGE IN THE TRANSMISSION OIL CHANGE AND THE DEALERSHIP THEN TOLD ME THAT THERE WAS A EXTENDED WARRANTY FOR THESE AYC PUMPS AND AND NEVER TOLD ME ABOUT THIS ISSUE WHEN I WAS IN SIX MONTHS PRIOR TO THIS I CONTACTED MITSUBISHI THEMSELVES AND THEY SAID THAT THEY WOULD DO ABSOLUTELY NOTHING FOR ME EVEN THOUGH THE DEALERSHIP TOLD THEM THAT I WAS THERE BEFORE HAND WITH THE SAME ISSUE AND THEY DIDN'T DO ANYTHING ABOUT IT. I FEEL LIKE I WAS SCAMMED AND IT'S HORRIBLE TO HAVE TO FIGHT WITH MITSUBISHI ABOUT A PUMP THEY CAN RISK MY SAFETY AND THE OTHERS IN MY CAR . I WAS SCREWED OUT OF WARRANTY THAT I WAS NEVER TOLD ABOUT .

TL* THE CONTACT OWNS A 2008 MITSUBISHI LANCER. WHILE DRIVING APPROXIMATELY 30 MPH, THE CROSS MEMBER AND K FRAME FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER. THE VEHICLE WAS PLACED ON A LIFT, INSPECTED THE VEHICLE, AND DIAGNOSED THAT THERE WAS EXTENSIVE RUST AND CORROSION. THE DEALER INDICATED THAT THE PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS LEFT AT THE DEALER. THE CONTACT WAS WAITING ON A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THE CONTACT WOULD APPROVE THE DEALER'S REPAIR. THE VIN WAS EXCLUDED FROM A MANUFACTURER RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

BLOWER MOTOR HAS FAILED THREE TIMES. BLOWER MOTORS ON LATER MANUFACTURED VEHICLES WERE RECALLED SEVERAL YEARS AGO BECAUSE THE BLOWER MOTOR MAY FAIL. THIS VEHICLE EXHIBITS THE SAME SYMPTOMS DESCRIBED AS THAT RECALL BUT IS OUTSIDE THE SCOPE.

AYC PUMP FAILURE AT 44 THOUSAND MILES.

FAILURE OF TRANSMISSION CENTER DIFFERENTIAL PINS IN MANUAL 2008 MODELS. I WAS DRIVING MY CAR AT HIGHWAY SPEEDS WHEN THE CAR POPPED OUT OF GEAR TO NEUTRAL, THEN I SHIFTED TO 4TH AND POPPED OUT AGAIN TO NEUTRAL, I HAD TO QUICKLY SWERVE TO THE SHOULDER AND THE ENTIRE TRANSMISSION LOCKED UP CAUSING THE CAR TO SKID. UPON TOWING IT TO THE DEALER THEY SAID THE CENTER DIFFERENTIAL PINS HAVE BACKED OUT THEY SAID "IT HAPPENS BUT NOT THAT COMMON." I WAS IN DISBELIEF THE PINS HAD CAUSED A CRACK IN THE TRANSMISSION CASING AND ALL THE OIL IN THE TRANSMISSION HAD LEAKED OUT CAUSING THE THE GEARS TO CEASE UP NEARLY CAUSING AN ACCIDENT. SEE PICTURES, UPON RESEARCH I HAVE SEEN MANY SIMILAR SITUATIONS ON THE EVO FORUMS AND IN FACT 2 MAJOR COMPANIES JACKS TRANSMISSION AND SHEPTRANS OFFER "UPGRADES" TO PREVENT THIS! UPGRADES? TO CAUSE A TRANSMISSION FROM COMPLETELY FAILING. APPARENTLY MITSUBISHI RECOGNIZED THIS AND UPGRADED THE PINS HEAT COATING IN 2010 TO PREVENT THIS BUT I AM STUCK WITH A 5000 DOLLAR REPAIR BILL AND I AM OUT OF WARRANTY. I TRIED TO REMEDY THIS WITH MITSU USA AND IT HAPPENED A YEAR AGO BUT I AM STILL UPSET NO RECALL HAS BEEN ISSUED AND I STILL DRIVE THIS CAR TO THIS DAY. I WOULD LIKE THIS TO BE REVIEWED IT IS VERY DANGEROUS. 2008 LANCER EVO GSR MODELS

2008 MITSUBISHI LANCER OIL TRANSMISSION COOLER HAS CORRODED FROM NORMAL USE. THE CAR WAS MAKING A WANING NOISE WHILE DRIVING BECAUSE ALL THE FLUID HAD LEAKED OUT FROM THE TRANSMISSION COOLER DUE TO CORROSION. NO SENSORS OR ANYTHING WENT OFF, ONLY NOTICED UPON INSPECTION OF THE CAR ONCE I ARRIVED HOME. SIMILAR RECALL WAS MADE ON THE 2010 MITSUBISHI GALANT (HTTP://WWW.MITSUBISHISUCKS.COM/CARS/RECALLS/USA/201003.HTML) SO IT IS NO DOUBT THAT THE LANCER MOST LIKELY HAD A SIMILAR ISSUE WITH A SIMILAR PART.

I RECEIVED 3 LETTERS IN THE MAIL REGARDING A IMPORTANT SAFETY RECALL CONCERNING MY DRIVE BELT SYSTEM I CALLED THE LOCAL MITSUBISHI DEALER SHIP AS WELL AS THEIR CORPORATE HEADQUARTERS. THEY INFORMED ME THAT THE PART THAT NEEDS TO BE FIXED IS ON BACK ORDER. I DO NOT FEEL SAFE IN MY CAR AND ITS BEEN SINCE OCT 2014 ITS OVER 6 MONTHS AND I'VE NOT HEARD FROM EITHER THE DEALER SHIP OR THE CORPORATE HEADQUARTERS. EVERY TIME YOU CALL AND ASK FOR AN UPDATE THEY SAY THEY DON'T HAVE A CONFIRMED TIME WHEN THE PART WILL BE IN STOCK AND THEY CONTINUE TO GIVE ME THE RUN AROUND. AT THIS RATE MY CAR WILL GROW OLD, BEFORE ANYTHING CAN BE DONE. *TR

TL*THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER. HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

TL*THE CONTACT OWNS A 2008 MITSUBISHI LANCER. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V562000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO INFORM WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

RECALL FOR DEFECT, NOTICE OCTOBER 2014. *TR

ACD/ AYC PUMP FAILURE, ONE TIME I WAS DOING FLUID INSPECTION ON MY CAR WHEN I NOTICE THE CARS ATF FLUID RESERVOIR IN THE TRUNK IS LOSING OIL. LOOKED AT THE FLOOR FOUND SOME RED OIL DRIPPING. IT MAY HAVE SEEM THAT PUMP MAY HAVE BEEN FAILING TO HOLD PRESSURE AND LOSE OIL. POSSIBLE GASKET FAILURE OR PUMP CRACK. BEEN SEARCHING ONLINE FOR SIMILAR PROBLEMS, I FOUND OUT IT SEEMED TO BE MOSTLY EVERY OWNERS PROBLEM. IS THIS SUPPOSE TO BE COVERED BY MANUFACTURER? SEEM LIKE POOR MATERIAL BUILD. *TR

VEHICLE WAS IN COLD WEATHER, AYC SYSTEM LIGHT TURNED ON. I CHECKED THE FORUMS AND FOUND THAT THIS IS A COMMON ISSUE THAT INDICATES THE PUMP IS BAD. THIS IS A VERY COMMON PROBLEM. *TR

IT WAS A COLD WINTER DAY, I STARTED DRIVING MY EVO TO A NEARBY GROCERY STORE. ENROUTE, THE AWD SYSTEM WOULD THROW A WARNING AND A DASHBOARD LIGHT LIT UP. I WAS CONCERNED, STOPPED THE VEHICLE AND FOUND NO LEAKS OR NO WEIRD NOISES. THE VEHICLE WAS UNABLE TO SHIFT INTO SNOW/TARMAC/GRAVEL MODE. FORTUNATELY I WAS NOT STRANDED ON THE ROAD SIDE. UPON FURTHER INVESTIGATION I CAME TO KNOW THAT THE ACD PUMP FAILED AND HENCE IT THREW AN AWD ERROR. ITS COSTING ABOUT 2200 DOLLARS TO FIX THIS ISSUE. *TR

WHEN STARTING MY 2008 MITSUBISHI LANCER EVOLUTION GSR, I RECEIVED A WARNING MESSAGE ON THE CLUSTER DISPLAY SHOWING A YELLOW-ORANGE SYMBOL THAT SHOWS 4 WHEELS CONNECTED BY AXLES AND THE MIDDLE-SHAFT, WHERE THE FRONT TWO WHEELS ARE FACING AT AN ANGLE TO THE SIDE. THE ERROR CODE READ AS C161E: DTC C161E: ELECTRIC PUMP RELAY CIRCUIT SYSTEM (STUCK). THIS HAS BECOME A VERY COMMON ISSUE WITH THE 2008 MITSUBISHI LANCER EVOLUTION. SO COMMON THAT WHEN YOU SEARCH FOR THE CODE C161E, YOU CAN FIND COUNTLESS FORUM DISCUSSIONS ON MULTIPLE WEBSITES COMMENTING ON THE FREQUENCY OF THIS ISSUE. INCLUDING MYSELF, A SINGLE DISCUSSION IDENTIFIES AT LEAST 48 UNIQUE CARS, 42 OF WHICH ARE THE 2008 MODEL YEAR, WHERE THE ACD PUMP FAILED, ALL OF WHICH HAVING DRIVEN FEWER THAN 75,000 MILES AND NEARLY 60% WITH LESS THAN 50,000 MILES (HTTP://WWW.EVOXFORUMS.COM/FORUMS/SHOWTHREAD.PHP?T=58221&HIGHLIGHT=C161E&PAGE=1). SEVERAL OF THESE VEHICLES REQUIRED MULTIPLE REPLACEMENTS OF THE SAME PART. THIS PROBLEM AFFECTS THE SAFETY AND EFFECTIVENESS OF THE VEHICLE'S ALL-WHEEL-DRIVE SYSTEM, LIKELY INCLUDING THE VEHICLE'S TRACTION CONTROL AND NEEDS TO BE RECALLED IMMEDIATELY. *TR

LOSS OF ELECTRONIC STABILITY CONTROL. AYC/ACD PUMP FAILURE DUE TO POOR ENGINEERING. CAR HAS NO STABILITY CONTROL AND DRIVER IS MORE LIKELY TO LOSE CONTROL IN SEVERE WEATHER CONDITIONS. *TR

I HAVE BEEN THE ONLY OWNER OF THIS CAR AND AM LEARNING MUCH NOW THAT MY WARRANTY HAS EXPIRED. I TOOK MY CAR TO BE DIAGNOSED AT FITZGERALD MITSUBISHI IN ANNAPOLIS MD, AND WAS TOLD THAT IT WAS AN 800 OR 3100 DOLLAR FIX, DEPENDING ON WHICH JOB NEEDED TO BE DONE. THE BIG FIX IS THE AYC/ADC HYDRAULIC UNIT THAT PRESSURIZES THE CLUTCHES IN THE DIFFERENTIAL. WHAT CAUSES THE FAILURE IS CORROSION. THIS UNIT IS PLACED BEHIND THE RH REAR TIRE AND HAS VERY LITTLE PROTECTION FROM THE ELEMENTS. THIS UNIT NEEDS TO BE RELOCATED OR BETTER SHIELDING NEEDS TO BE ATTACHED. READING THE EVOLUTIONM.NET FORUMS, I HAVE FOUND THAT THIS CORROSION IS VERY POPULAR AND THE REPAIRS ARE EXTREMELY PRICEY. *TR

ACTIVE YAW CONTROL (AYC) AND ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILED. NOT COVERED UNDER POWER TRAIN WARRANTY PUMP WAS CORRODED AND COULD NO LONGER PRODUCE ENOUGH PRESSURE. PUMP IN LOCATED DIRECTLY BEHIND PASSENGER REAR WHEEL EXPOSED TO WATER, SALT, AND OTHER ROAD DEBRIS. *TR

WENT TO DEALER FOR TRANSMISSION CHECK AND AFTER A MILE AWC LIGHT CAME ON THEY SAID IT HAD NOTHING TO DO WITH COMPUTER UPDATE THEY DID.MIND YOU MY TRANNY WAS GOING BAD AND DEALER DID NOT WANT NOTHING TO DO WITH IT EVEN UNDER WARRANTY. *TR

ELECTRONIC STABILITY CONTROL / S-AWC (TARMAC/GRAVEL/SNOW) INOPERABLE. TERRAIN SELECTION CAN BE PERFORMED AT 0MPH HOWEVER WHEN THE CAR IS PLACED IN MOTION: FORWARD / REVERSE, THE INSTRUMENT PANEL INDICATES THERE IS SERVICE REQUIRED IN THE AWD TRACTION CONTROL SYSTEM. THIS IS APPARENTLY A COMMON PROBLEM, FROM THE MULTITUDE OF COMPLAINTS FOR THIS SPECIFIC ISSUE POSTED HERE. *TR

ACD (ACTIVE CENTER DIFFERENTIAL) PUMP HAS FAILED AND WITHOUT THIS PUMP PROVIDING PRESSURE TO THE ALL WHEEL DRIVE SYSTEM, THE VEHICLE GETS STUCK ON DRIVEWAYS AT A STOP WHERE THE TIRE AND WHEEL PACKAGES ARE ON DIFFERENT ELEVATED SURFACES. THE REASON THE PUMP HAS FAILED IS DUE TO PLACEMENT OF THE PUMP ON THE VEHICLE. MITSUBISHI HAS DESIGNED THE VEHICLE TO HAVE THE PUMP TO BE LOCATED DIRECTLY BEHIND THE REAR PASSENGER WHEEL. DUE TO THIS, WHILE DRIVING ON SEVERE WEATHER ROADS (PARTICULARLY SNOW SALTED ROADS), THE DIRT, WATER AND SALT GETS KICKED UP TO THE POSITION OF THE PUMP WHICH CORRODES THE FITTINGS AND THE PUMP ITSELF. THIS THEN CAUSES THE PUMP TO FAIL OVER TIME. IT COULD HAVE BEEN EASILY REMEDIED BY RELOCATING THE PUMP OR ANTI-CORROSION PROTECTION AND BETTER SEALING. BEING LOCATED IN SOUTHERN CALIFORNIA, I WOULD HAVE THOUGHT THAT THIS WOULD HAVE NEVER HAPPENED TO ME, BUT EVEN DRIVING ONLY TWICE THROUGH SNOW ROADS IN THE PAST 3 YEARS HAS CORRODED THE PUMP TO FAILURE. MITSUBISHI HAS DENIED THAT THIS IS PART OF THE POWER TRAIN WARRANTY, WHICH MEANS IT WILL BE A $2000+ DOLLAR FIX. *TR

ACD (ACTIVE CENTER DIFFERENTIAL) PUMP FAILURE AT 43000 MILES. WAS REPAIRED UNDER WARRANTY BUT FAILED AGAIN 2 MONTHS AGO (LESS THAN 60000 MILES) JANUARY 2014. SO THE NEW PUMP INSTALLED DID NOT LAST FOR MORE THAN 15000 MILES. THIS IS A COMMON AND KNOWN ISSUE FOR ALL MITSUBISHI MODELS EQUIPPED WITH THAT ACD STABILITY CONTROL. *TR

AS MANY EVOLUTION OWNERS WHO LIVE IN THE MIDWEST CAN ALSO ATTEST, MY EXAMPLE NOW JOINS THE CLUB OF MODELS WITH DEFECTIVE ASC/AYC PUMP FAILURE. THE PUMP FAILS WHEN OUTSIDE TEMPERATURES RUN CLOSE TO FREEZING, ON TOP OF THE UNIT CORRODING, AND EVOLUTION OWNERS ARE BEING FORCED TO SHELL OUT $1800 MINIMUM TO MITSUBISHI FOR THE PUMP ALONE, NOT INCLUDING LABOR. I BELIEVE THIS HAS ONLY OCCURRED TO MY MITSUBISHI AFTER SIX YEARS BECAUSE I'VE BEEN VERY GOOD ABOUT KEEPING THE UNDERBODY CLEAN, AND IT'S NEARLY ALWAYS PARKED IN A HEATED GARAGE. WITHOUT THE PROPER FUNCTIONING OF THIS INTEGRAL DRIVETRAIN EQUIPMENT, WE AREN'T ABLE TO CONTROL POWER DELIVERY FRONT TO BACK AND THE VEHICLE COMPUTER GOES INTO A TYPE OF LIMP MODE WHERE NO CONTROL OF THE DELIVERY OF POWER TO THE WHEELS IS POSSIBLE. OF COURSE THE BRAKES WORK AND THE THROTTLE WORKS, BUT WHEREAS THE VEHICLE USED TO BE SELECTABLE FOR SNOW OR GRAVEL MODES, GREATLY IMPROVING TRACTION AND THE ABILITY TO LIMIT SLIPPAGE OF THE REAR WHEELS, WE INSTEAD STARE AT A DIGITAL READOUT INSTRUCTING US TO SERVICE THE UNIT THAT'S CORRODED AND THE PUMP HAS OVERHEATED AND ALSO FAILED AS A RESULT. WWW.EVOXFORUMS.COM AND WWW.EVOLUTIONM.NET HAS PLENTY OF OTHER CUSTOMERS WHO ARE BELONG FRUSTRATED WITH THIS ISSUE THAT MITSUBISHI DOESN'T WANT TO ADDRESS. NEARLY ALL OF US HAVE SPENT GOOD MONEY ON A VEHICLE WE THOUGHT WOULD BE A SOLID PERFORMER IN BOTH THE DRY, WET, AND SNOW AND INSTEAD, SOME OWNERS HAVE TO PAY NOT ONCE TO REMEDY THIS UNIT THAT'S FAILING ON ALL OUR CARS, BUT I'VE HEARD OF OWNERS HAVING TO DO IT TWO AND EVEN THREE TIMES. OWNERS ARE TRYING TO SAVE MONEY BY BREAKING DOWN THE UNIT AND REPAIRING THE INTERNAL MOTOR. PEOPLE ARE EXPERIMENTING WITH WAYS TO PREVENT THE UNITS THEY PURCHASE TO PREVENT THEM FROM RUSTING AND CORRODING. PLEASE PLEASE PLEASE CONTACT MITSUBISHI AND HELP US?? *TR

CAR SYSTEMS ACD PUMP SYSTEM HAS FAILED. *TR

ACD PUMP WENT OUT ON MY CAR. NO REAL REASON OTHER THAN THE LIE OF IT BEING COLD.... 20 DEGREES ISN'T TO COLD TO ME. EITHER WAY, WITHOUT THE ACD PUMP THE CARS AWD DOESN'T WORK TO STANDARD. WHAT AWD CAR ISN'T MADE FOR COLD. RIDICULOUS. HAPPENS TO ALOT OF EVOS. NEEDS RECOGNIZED AND RECALLED. ALSO MY TIMING CHAIN WENT AT 36K. NO TIMING CHAIN SHOULD GO OUT THAT EARLY NO MATTER WHAT. THEY TOLD ME ITS BECAUSE I DIDN'T CHANGE THE OIL TILL THEY DROPPED THE OIL PAN AND SAW THAT THEY WERE WRONG. THE CHAIN ISN'T MEANT TO HANDLE THE TORQUE OF THE CAR. THAT'S A MANUFACTURE MESS UP. ANOTHER ONE THAT SHOULD BE A RECALL WITH THE AMOUNT OF PEOPLE THAT HAVE/HAD THE ISSUE. AND ONE MORE, THE P.O.S. FUEL RELAY THAT DIES ON YOU AND COULD POSSIBLY BLOW YOUR MOTOR. THE FUEL PUMP AND TIMING CHAIN HAVE BOTH BEEN UPDATED YET NOT RECALLED. WHY? DOESN'T MAKE SENSE THAT THEY NOTICE THE PROBLEM, MAKE A NEW PART FOR THE PROBLEM, BUT DON'T FIX IT UNDER THEIR MISTAKE. *TR

VERY COLD DAY OUT, ABOUT -15 F, WARMED UP MY VEHICLE FOR ABOUT 5 MINUTES PLUS. ONCE I BEGAN DRIVING, ABOUT 10 MPH MY SERVICE REQUIRED LIGHT CAME ON FOR MY AYC PUMP. DEALER SAID THAT IS WAS NOT COVERED UNDER WARRANTY OF ANY KIND. MITSUBISHI HAS KNOWN THAT IS A COMMON ISSUE IN COLD CLIMATES THAT USE SALT ON THE ROADS. THE SALT CORRODES THE PUMP AND MAKES IT FAULTY/MALFUNCTION. THIS IS A SAFETY ITEM THAT NEEDS TO BE RECALLED DUE TO THE KNOWLEDGE THAT AN EVO DRIVER HANDLES THEIR CAR [THAT THEY PURCHASED AS SUCH] AND LOOSES THAT RIGHT WITH A FAULTY AYC PUMP. *TR

I STARTED MY CAR AND THE AWC SERVICE LIGHT CAME ON. IT WAS ABOUT 0 DEGREES OUT THAT DAY, WHICH IS A VERY UNUSUAL TEMPERATURE FOR S. INDIANA. WHEN I STARTED THE CAR IT SCREECHED FOR JUST A SECOND AND THEN POPPED UP THE CODE. I RESTARTED THE CAR, JUST AS THE MANUAL HAD SAID AND WHEN I RESTARTED IT THE LIGHT WAS STILL ON. I WAS ABLE TO GET THE CODE READ IT THREW A C161E CODE WHICH IS AN ACD/AYC PROBLEM. AFTER DOING A LOT OF RESEARCH I FOUND OUT ITS A COMMON PROBLEM AND ITS AN EXPENSIVE PROBLEM, ABOUT $2,000+. I CALLED THE DEALER AND WAS TOLD MY WARRANTY DOES NOT COVER THIS, IT IS NOT PART OF THE POWER TRAIN. *TR

I STARTED MY CAR AND THE AWC SERVICE LIGHT CAME ON. I CAME TO A CONTROLLED STOP, AND RESTARTED THE CAR PER THE INSTRUCTIONS IN THE VEHICLE MANUAL. UPON RESTART, THE SAME SERVICE LIGHT CAME ON. AFTER THE DEALER RAN A DIAGNOSTIC, IT WAS FOUND THAT THE HIGH PRESSURE PUMP FOR THE ACTIVE STABILITY CONTROL SYSTEM HAD FAILED. I WAS TOLD THAT THIS PART WAS NOT PART OF THE DRIVE TRAIN AND WOULD NOT BE COVERED UNDER WARRANTY. THE DAY THE PUMP FAILED IT WAS VERY COLD AND THERE WAS PACKED SNOW ON THE ROADWAYS. IF I WAS DRIVING AT HIGHER SPEEDS AND THIS PUMP HAD FAILED, I BELIEVE THE AUTOMOBILE WOULD NOT HAVE BEHAVED AS EXPECTED WITH THE AWC STABILITY ACTIVE. *TR

THIS IS REPORT OF A KNOWN FAILURE BY MITSUBISHI MOTOR CORP. AT 50,800 MILES ON 12/17/2013 MY CARS SUPER-ACTIVE CENTER DIFFERENTIAL (S-ACD) STARTED BLINKING AT ME. IT WOULD NOT ALLOW CHANGING OF THE SETTINGS ANYMORE FOR TARMAC/GRAVEL/SNOW. IMMEDIATELY THERE AFTER, THE DRIVER INFORMATION PANEL POPPED UP WITH A YELLOW "AWD SERVICE REQUIRED" INDICATOR. I BROUGHT MY CAR TO NASHUA, NH MITSUBISHI/HYUNDAI FOR DIAGNOSIS ON 12/19/2013. THERE THEY APPLIED TSB-SC11-002. THIS UNFORTUNATELY DID NOT RESOLVE THE ISSUE. I WAS THEN INFORMED THAT THE CAR REQUIRED A REPLACEMENT ACD PUMP AND WAS QUOTED $1,995 FOR THE REPAIR, WHICH CONFUSED ME DUE TO THE FACT THAT MY CAR WAS STILL UNDER MANUFACTURERS POWER TRAIN WARRANTY, AND A PUMP, THAT CONTROLS THE AWD SYSTEM OF A CAR, SEEMS TO BE POWER TRAIN RELATED, AT LEAST IN MY EYES. THE NORTH EAST REGIONAL REPRESENTATIVE WAS CONTACTED ON MY BEHALF BY THE DEALERSHIP TO REQUEST COVERAGE OF THIS ITEM, WHICH WAS ULTIMATELY DENIED. THIS IS A SEVERE SAFETY ISSUE, AS THE CAR NO LONG HANDLES PROPERLY IN CONDITIONS IT WAS DESIGNED FOR. I AM NO LONGER ABLE TO SELECT THE CAR FOR SNOW, LIVING IN THE NORTH EAST, DRIVING A CAR MARKETED IN THE NORTH EAST, THIS IS A HUGE PROBLEM. TO FURTHER THE ISSUE, THIS PROBLEM IS WELL KNOWN BY MITSUBISHI, IT HAS BEEN DOCUMENTED WELL, TRACING ALL THE WAY BACK TO CARS MANUFACTURED IN 2006. 90% OF ALL PUMP FAILURES COULD BE COMPLETELY ELIMINATED BY ADDING A SEAL TO STOP CORROSION INSIDE THE PUMP WHICH LEADS TO THE UNTIMELY FAILURES. IF NO RECALL IS ISSUED FOR THIS FAILURE, AT THE VERY LEAST, MITSUBISHI MOTORS SHOULD BE FORCED TO COVER THIS UNDER POWER TRAIN WARRANTY FOR 5YRS/60K MILES. INSTEAD OF LIMITING IT TO 3YRS/36K BUMPER TO BUMPER. LINK TO DOCUMENTED CASES - HTTP://FORUMS.EVOLUTIONM.NET/EVO-X-GENERAL/655162-THOSE-YOU-ACD-PUMP-FAILURES-MERGED.HTML. *TR

DUE TO COLD WEATHER HERE IN MN, MY SAWC PUMP HAS FAILED(ALL WHEEL DRIVE CONTROL UNIT, HYDRAULIC PUMP FAILS DUE TO COLD WEATHER). I'VE RESEARCHED AND MANY PEOPLE WITH THE SAME MAKE AND MODEL HAVE HAD ISSUES OF THE SAME. BOUGHT THE CAR IN FEB 2013, USED WITH 38KMILES. IM AFRAID THE DEALER WONT COVER THE EXPENSES OF GETTING THIS REPLACE. IT IS A KNOWN ISSUE AS I'VE RESEARCHED WITH MANY PEOPLE COMPLAINING. *TR

WAS DRIVING VEHICLE AND WARNING LIGHT "SERVICE REQUIRED" AND A SYMBOL INDICATING THE ALL-WHEEL DRIVE SUSPENSION APPEARED. HAD CODE READ AND MY VEHICLE SUFFERED A ACD PUMP FAILURE. IT IS A CRUCIAL FEATURE TO THE SOPHISTICATED AWD STABILITY CONTROL SYSTEM THAT MAKES AN EVO "SPECIAL". THIS IS A PART OF THE DRIVE TRAIN THAT IS NOT COVERED IN THE DRIVE TRAIN WARRANTY. THEY ALL FAIL AND THEY ARE EXPENSIVE AND THEY BECOME CORRODED DUE TO LOCATION, DESIGN, AND LACK OF PROPER PROTECTION FROM THE ELEMENTS AND ROAD SPLATTER. THIS SHOULD BE A RECALLED ITEM FROM THE MANUFACTURER. THIS IS NOT CAUSED BY ANYTHING OTHER THAN POOR DESIGN ALLOWING FOR A CORROSION PROBLEM THAT LEADS TO PUMP FAILURE. *TR

(COMPLAINT IS APPLICABLE ONLY TO GSR TRIM EQUIPPED WITH A 5MT TRANSMISSION) - DIFFICULTY SHIFTING FIRST TO SECOND GEAR, AND SECOND TO THIRD. GEARSHIFT IS NOTCHY AND HARD TO ENGAGE. CAUSES LONGER THAN DESIRABLE TIME-GAP IN POWER TO THE WHEELS, RESULTING IN LOSS OF SPEED DURING ACCELERATION PHASE FROM A STOP. - GEARSHIFT IS NOT SMOOTH IN GENERAL. KEYWORDS : NOTCHY, GRINDING. - IT IS A WIDELY REPORTED PROBLEM IN THIS PARTICULAR MODEL AS EVIDENT FROM OWNER SURVEYS ON A PROMINENT INTERNET FORUM (SEE HTTP://FORUMS.EVOLUTIONM.NET/EVO-X-ENGINE-TURBO-DRIVETRAIN/333385-OFFICIAL-EVO-X-NOTCHY-GRINDING-TRANSMISSION-THREAD.HTML). *TR

MY 08 EVO IS GETTING THE "SERVICE REQUIRED" LIGHT INDICATING THE S-AWC PUMP HAS FAILED. I HAVE DONE SOME RESEARCH AND A LOT OF THE EVO'S ARE GETTING THIS. ITS B/C THE PUMP LOCATED BEHIND THE PASSENGER SIDE REAR TIRE IS EXPOSED THE ELEMENTS AND GET CORRODED, ALSO THE LIQUID GETS TOO THICK IN THE WINTER AND THE FLUID CANNOT FLOW PROPERLY AND THE PUMP FAILS. MINE FAILED 2 MONTHS OUTSIDE OF THE DRIVE TRAIN WARRANTY IN MIND JUNE IN NEBRASKA SO IT WAS MID 70'S AT LEAST, CALLED THE DEALER AND THEY WANT $120 JUST TO LOOK AT IT THEN $2000+ TO REPLACE THE PUMP. FAULTY PARTS LIKE THIS NEED TO BE COVERED UNDER WARRANTY. MY CAR IS ALSO 100% STOCK. *TR

BECAUSE OF THE LOCATION (REAR WHEEL WELL) AND DESIGN OF MITSUBISHI'S ACTIVE CENTER DIFFERENTIAL PUMP, THEY ARE PRONE TO FAILURE. SEVERAL FACTORS AID IN THE GALVANIZED CORROSION OF THE PUMP'S INTERNAL PLATE, SOME OF WHICH INCLUDE TEMPERATURE FLUCTUATION AND WEATHER. VEHICLES THAT ARE IN SERVICE THROUGHOUT THE SNOW BELT STATES IN THE US AND WELL INTO CANADA SEEM TO BE THE MOST AFFECTED. MY VEHICLE WAS JUST OUTSIDE OF THE VEHICLE WARRANTY RANGE FOR TIME BUT VERY WELL INSIDE THE RANGE FOR MILEAGE. *TR

THIS VEHICLE IS EQUIPPED WITH AN ACTIVE CONTROL DIFFERENTIAL (ACD) WHICH IS ACTUATED BY THE ACD HYDRAULIC PUMP. THE ACD IS A PART OF THE VEHICLE'S ALL WHEEL DRIVE SYSTEM. AFTER GIVING THE ENGINE AN 8 MINUTE WARM UP ON IDLE, THE VEHICLE WAS BEING DRIVEN ON A 20F OF AMBIENT TEMPERATURE. THE VEHICLE WAS ON A STOP LIGHT, AND UPON GENTLY ACCELERATING THE CAR ON GREEN LIGHT A WARNING LIGHT CAME UP ON THE VEHICLE'S DASH BOARD. THE VEHICLE WAS BROUGHT TO THE NEAREST MITSUBISHI SERVICE SHOP 4 DAYS AFTER THE INCIDENT WITH THE WARNING LIGHT STILL ON THE VEHICLE'S DASH BOARD. AFTER SERVICE TECHNICIAN WORKED ON THE VEHICLE, THE SERVICE MANAGER SAID THAT THE ACD PUMP IS THE PROBLEM WHICH NEEDS TO BE REPLACED AND WILL COST $2100 OF PARTS AND LABOR. 8 MONTHS PRIOR TO THE INCIDENT, THE MITSUBISHI SERVICE SHOP RE-FLASHED MY VEHICLE'S ALL WHEEL DRIVE ECU TO SPECIFICALLY PREVENT THE FAILURE OF THE PUMP ESPECIALLY IN COLD ENVIRONMENTS. MITSUBISHI REPLACED THE ACD PUMP AT MY EXPENSE, AND IT'S BEEN APPROXIMATELY 2 YEARS THAT MY VEHICLE IS ON THE REPLACEMENT PUMP. THE SERVICE MANAGER TOLD ME THAT THE COMBINATION OF THE HYDRAULIC FLUID BECOMING THICK ON COLD WEATHER AND THE CORROSION ON THE HYDRAULIC PUMP THAT THE SALTED WINTER ROADS BRING IS WHAT MAKES THE ACD PUMP FAIL. AFTER RESEARCHING ON THE INTERNET CAR FORUMS, THIS OCCURRENCE WHERE THE ACD PUMP FAILS ON COLDER REGIONS IS NOT UNCOMMON EVEN WITH THE PREVIOUS GENERATIONS OF THIS VEHICLE THAT ARE EQUIPPED WITH THIS ACD SYSTEM. *TR

STARTED MY CAR 1N 30 DEGREE WEATHER AND LET IT IDLE FOR A COUPLE MINUTES PULLED OUT ON MY STREET WHERE I LIVE AND MY ACD/AYC QUIT WORKING I HAD A PICTURE OF ALL FOR WHEELS ON MY INFO CENTER WITH THE FRONT WHEEL ON AN ANGLE . TOOK IT TO THE DEALER AND THEY SAID MY ALL WHEEL DRIVE PUMP WAS BAD AND THAT SINCE MY CAR IS AN EVO IT WAS NOT COVERED.I PAID TO HAVE IT FIXED AND GOT MY CAR BACK AND MY TIMING CHAIN BROKE DEALER SAID IT WAS NOT COVERED ALSO SINCE IT WAS AN EVO 3500.00 IN 1 MONTH. *TR

THE S-AWC OR SUPER ALL WHEEL CONTROL SYSTEM ON THE MITSUBISHI LANCER EVOLUTION HELPS THE ALL WHEEL DRIVE TO ACTUALLY WORK. I HAD A SERVICE MESSAGE POP UP ON MY CAR WITH THE S-AWC SYSTEM BEING INDICATED. AFTER REVIEWING THE CAR'S MANUAL AND THE INTERNET TO HELP DIAGNOSE THE ISSUE OF WHY IT WAS CAUSING IT, I'M TOLD THERE IS AN EVER-INCREASING NUMBER OF VEHICLES WITH THIS S-AWC PUMP FAILURE EITHER IN SUPER COLD CONDITIONS OR VERY HOT CONDITIONS. THIS HAS THE POTENTIAL TO BE VERY DANGEROUS IF THE PUMP ENDS UP GOING OUT WHEN SOMEONE IS MAKING A TURN OR IS RELYING ON THE ALL-WHEEL DRIVE TO ACTUALLY WORK IN ADVERSE CONDITIONS. THE ONLY NOTABLE CHANGE IS A DIFFERENCE IN STEERING FEEL AND THE SERVICE MESSAGE POPPING UP AFTER SEVERAL MINUTES OF DRIVING, THOUGH DUE TO SAFETY REASONS, I AM TRYING NOT TO PUSH THE CAR TOO HARD UNTIL THE PROBLEM IS ADDRESSED. *TR

AWC PUMP STARTED TO FAIL. IT IS NOW COMPLETELY FAILED AND NOT WORKING. AFTER SOME RESEARCH DETERMINED THAT IT IS A COMMON PROBLEM ON THESE VEHICLES DUE TO NOT BEING SEALED PROPERLY AND CORROSION GETTING IN TO DAMAGE THE PUMP MOTOR. PART SHOULD BE RECALLED/REPLACED UNDER WARRANTY BUT THEY REFUSE TO DO SO. *TR

THE CAR IS DISPLAYING AN S-AWC SERVICE LIGHT, IT HAS YET TO BE DIAGNOSED BY THE DEALERSHIP BUT I HAVE BROUGHT IT IN PREVIOUSLY FOR THE SAME ISSUE. LOOKING ONLINE THERE IS A WHOLE MASS OF FORUMS STATING THAT AT 40,000+ MILES THE AYC PUMP BREAKS. THIS SEEMS RATHER SUSPECT GIVEN SO MANY INDIVIDUALS ARE EXPERIENCING THE SAME PROBLEM WITHIN THE SAME TIME SPAN. MITSUBISHI HAS BEEN REPORTEDLY TURNING DOWN WARRANTY COVERAGE FOR THIS UNDER THEIR POWER-TRAIN WARRANTY, WHILE I AM UNSURE IF THEY WILL DO THE SAME FOR ME, THE ISSUE IS SEEMINGLY PREVALENT ENOUGH THAT THEY SHOULD KNOW ABOUT IT. *TR

THIS IS A VERY COMMON PROBLEM ON THE MITSUBISHI EVO X IF YOU LIVE IN A COLD AREA AND ROADS ARE SALTED FOR SNOW. THE LOCATION OF THE AWC PUMP IS NOT ENCLOSED ENOUGH SO THE SALT, ROAD CRAP GETS TO THE PUMP AND IT FAILS. MITSUBISHI SAID IT WOULD COST $2 GRAND TO REPLACE THE PUMP. YES $2 GRAND FOR A PUMP!!! MITSUBISHI NEEDS TO STEP UP AND DO SOMETHING ABOUT THIS. I KNOW MANY PEOPLE THAT HAVE HAD THIS HAPPEN AND READ ABOUT THOUSANDS OF OTHERS. PLEASE HELP! *TR

DURING COLD WEATHER (APPROXIMATELY 40 DEGREES OR LESS) DURING THE EVENING, MY SUPER ALL-WHEEL-CONTROL SERVICING LIGHT WAS TRIGGERED DURING A LOW SPEED TURN. THIS INDICATES A FAULTY OR FAILING AWC/AYC PUMP, A MECHANICAL COMPONENT WHICH PROVIDES AYC FLUID TO THE FRONT AND REAR DIFFERENTIAL OF THE VEHICLE, AIDING IN STABILITY CONTROL. WHEN THE PUMP IS INOPERABLE, DECREASED (OR NO) PRESSURE/FLUID IS SENT TO THE DIFFERENTIALS OF THE VEHICLE, WHICH CAN CAUSE SERIOUS DRIVETRAIN DAMAGE AND FAILURE-- THUS THE AYC PUMP IS RECOGNIZED BY MITSUBISHI AS A CRITICAL COMPONENT OF THE DRIVE TRAIN. HOWEVER, IT IS NOT COVERED UNDER MITSUBISHI'S 5 YEAR/60,000 MILE DRIVETRAIN WARRANTY, WHICH I FEEL IS DISINGENUOUS. THIS IS A A SERIOUS SAFETY CONCERN AS A FAULTY OR FAILED PUMP EFFECTIVELY DISABLES THE AWD COMPONENT OF THE VEHICLE AND MAKES THE DRIVE TRAIN MORE LIKELY TOSUFFER CATASTROPHIC DAMAGE DURING USE, WHICH CAN RESULT IN CRASHES AND INJURY. MITSUBISHI IS AWARE OF THIS ISSUE AND THAT THESE PUMPS ARE POORLY-DESIGNED FOR PROVIDING THE AYC FLUID TO THE DIFFERENTIALS DURING COLD WEATHER; THE FLUID BECOMES EXTREMELY VISCOUS AT LOW TEMPERATURES AND THE PUMP IS EITHER UNABLE TO CONTINUE TO FLOW THE FLUID TO NECESSARY COMPONENTS OR THE PUMP COMPLETELY FAILS IN THE ATTEMPT, REQUIRING EXPENSIVE REPLACEMENT AT THE OWNER'S EXPENSE. *TR

ON MONDAY 2013 APRIL 22 I [XXX] (OWNER OF VEHICLE) WAS GETTING OFF MY SHIFT AT APPROXIMATELY 0700 HOURS FROM BETHEL TWP PD; WHERE I WORK AS A PATROLMAN. THE TEMPERATURE WAS FAIRLY MILD 60-65F, I STARTED MY 2008 MITSUBISHI EVOLUTION 10 TO LET IT WARM UP LIKE I ALWAYS HAVE FOR APPROXIMATELY TEN MINUTES. I PUT MY EVO IN GEAR AND ON THE CENTER L.E.D. SCREEN I RECEIVED THE C161 MESSAGE WHICH INDICATES S-AWC FAILURE OR SUPER ALL WHEEL CONTROL. THIS EFFECTS EVERYTHING WITH THE CARS' SUSPENSION STABILITY, YAW CONTROL, AND THE "SMART BREAKING" FEATURE. FOR AN UN-EXPERIENCED DRIVER THIS COULD BE CATASTROPHIC. KNOWING THE IMPORTANCE OF THIS I WAS FORCED TO BRING THE CAR TO SPRINGFIELD MITSUBISHI IN SPRINGFIELD, PA. 1(484)574-8434. NOW I'M STUCK WITH A $2132.00 BILL AND THE CAR IS STILL IN THE LOT BECAUSE I DON'T HAVE THE $2132.00 TO "SHELL" OUT. I WENT TO TWO SEPARATE FORUMS WWW.EVOXFORUMS.COM AND WWW.EVOLUTIONM.NET, AND I DON'T KNOW WHATS SCARIER THE THOUSANDS THAT HAVE THIS PROBLEM AND ARE TOLD BY THEIR LOCAL DEALER ITS SAFE TO OPERATE IN THAT CONDITION OR THE FACT THAT NO BODY IS DOING ANYTHING TO ASSIST OR FIX THE PROBLEM. PLEASE BE THE ONES WHO MAKE THE DIFFERENCE HERE..... THANK YOU [XXX] PS I APOLOGIZE I AM WRITING YOU AGAIN, I NEVER RECEIVED ANY RESPONSE THE FIRST TIME....... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR