Mercedes-Benz E-Class 2007 — Problemas relatados

I first noticed the problem around March 2026. When I fill the fuel tank of this 2007 Mercedes-Benz E350, gasoline pools on top of the tank beneath the rear seat, inside the passenger cabin. I have breathed gasoline fumes from it. There was no fire or crash. An independent Mercedes specialist's records include a March 2026 recommendation noting a very fine EVAP leak at the fuel tank and/or vapor line and that the tank is no longer available. On May 29, 2026 (65,138 miles), with the check-engine light on and a strong fuel smell inside the vehicle, the shop replaced a leaking left fuel pump and seal. A fuel-system test that day indicated further checks were required. The gas pooling continued after the pump was replaced. On July 28, 2026 (66,067 miles), the shop noted that the fuel tank is warped. I wrote to Mercedes-Benz USA on October 13 and October 16, 2026 with my service records and have not received a response.

The contact owns a 2007 Mercedes-Benz E-350. The contact stated that while driving approximately 62 MPH, the contact heard a loud sound coming from the roof, and the sunroof exploded. The contact had previously observed wind whistling near the sunroof seal. The vehicle was taken to the dealer, where the contact was informed that the repair was not covered under a recall. The dealer stated that the vehicle was previously included in a recall during which a stress test was performed, and it was concluded that a repair was not necessary at the time, leading to the closure of the recall. The vehicle was repaired at the owner's expense. The manufacturer was informed of the failure, and a case was opened. The failure mileage was 140,000.

Odometer Fraud. The contact purchased a 2007 Mercedes-Benz E350. The contact stated that while attempting to sell the vehicle to the dealer, the contact was informed that the Carfax History report indicated a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 113,192, however, the Carfax History Report listed the mileage at 257,710 on October 16, 2023.

sunroof

The sunroof seems like it has gone off the track . I am not sure it's locked in and worried it will fly open and fly off the roof of the car

The contact owns a 2007 Mercedes-Benz E350. The contact received notification of NHTSA Campaign Number: 19V918000 (Visibility); and would like to be removed from the recall distribution list. The local dealer and manufacturer were contacted and referred the contact to the NHSTA Hotline for assistance.

When I filled up gas and start the car, it has gas smell. seems like fuel is pooling on the left side on top of the fule filter module underneath the cushion. Searched the internet and found out it is a common problem on Mercedes.

My 2007 Mercedes-Benz E63 AMG, which has developed a fuel system defect resulting in a leak. This issue poses a significant safety risk, including the potential for fire and explosion, and is directly related to a known defect that Mercedes-Benz USA has previously acknowledged through an extended warranty campaign.Safety Risk: Fuel system leaks pose an imminent danger, including the potential for fire and explosion, to vehicle occupants and others on the road. Manufacturer Acknowledgment: The warranty extension campaign underscores Mercedes-Benz’s recognition of this defect as a manufacturing issue, Repeat Occurrence: Having experienced this defect in my previous 2005 E500 4MATIC and now my 2007 E63 AMG, it is evident this issue is systemic and not isolated.Ethical and Legal Responsibility: Safety defects do not have an expiration date. Mercedes-Benz has an obligation to address this issue regardless of warranty status.Mercedes-Benz USA recognized the severity of this defect by extending the warranty coverage to 15 years and unlimited mileage for “Covered Fuel Tank Components” in specific models, including the 2003–2009 E-Class (W211). I received a notice in 2015 outlining this warranty extension, which covered the fuel tank, fuel filter/sender, fuel pump, and all related gaskets, seals, and retention rings. Additionally, Mercedes-Benz USA formally notified the U.S. Department of Transportation's National Highway Traffic Safety Administration (NHTSA), specifically the Office of Defects Investigation (ODI), of this extended warranty campaign in 2014. While the ODI concluded that the nature of the leaks "does not appear to present an unreasonable risk to motor vehicle safety," I strongly disagree. Any defect involving fuel system leaks represents a substantial safety hazard, including the potential for fire, explosion, and environmental harm.

Noticed strong smell of diesel fuel by left rear tire, in several days a leak was under left tire, had fuel tank sending unit gasket replaced, no visible leaks but fumes are still present 1 year after repair. When repair was made all related parts were cleaned of residential fuel. Want to know if MB has dealt with splits or cracks in fuel tanks.

VIA REGULAR MAIL AND ONLINE SUBMISSION RE: VIN # [XXX] – Mercedes Benz 2007 E 63 Dear NHTSA – We would like to bring to your attention the failure of the Fort Lauderdale Mercedes Benz dealership to properly honor the repair and replacement of parts and labor covered under a recall for Fuel Tank Components for MODEL 211 (E-Class) years 2003-2009. A copy of the Recall notice which provided for an extension of the Recall thru 01/31/2021 is attached. Also attached please find a recent repair invoice for the respective repairs which should have been repaired under this recall. Mercedes Benz undertook a “partial” repair of the parts covered under this recall and at the time of that repair failed to properly repair all of the parts related to this issue/recall. Instead, they only replaced one fuel tank/fuel pump while the extended warranty coverage was in place and left the issue to materialize/manifest in the remaining fuel pump/tank despite the fact that conditions indicated it would likely fail in the near term at the time of the partial repair. Of further concern is the fact that an active Recall for the exact same item exists and remains active for later model years. Clearly, they have not fixed the cause of failure for this vital car part and continue to place drivers/owners at considerable risk. NHTSA – ODI It is incredulous to me, a 25+ year dedicated Mercedes Benz customer that an experienced dealership would attempt to evade responsibility for such a significant safety recall item. When this issue exists, the smell and fumes of petroleum/gas can be easily smelled from the exterior of the car. If you were to light a cigarette – you would likely cause the car to explode. When this issue existed, the interior cabin of the car would fill with petroleum/gas fumes again placing the driver at considerable risk. Please review the attached documentation and require Mercedes Benz to acknowledge that their half-hearted repair done during the recall INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Recently my wife and I noticed a very strong fuel smell from cabin of this car. When I inspected and lifted the seat there was a puddle of fuel leaked over the sending unit. This is extremely dangerous and potentially deadly for my family especially with 2 young children who are always seating in back seat. Upon checking with Benzel Busch Mercedes dealer in Englewood New Jersey, they said they cannot fix my issue because my warranty has expired. I am now writing to you to help me as I feel this should strictly be a recall and Mercedes USA should be required to fix this leak free of charge. Please understand that out of pocket will be more than $8,000 for this repair and I do have the means to come up with that amount of money. Upon checking on internet there are many E class Mercedes Benz between years 2003-2009 that have this issue. Could you please help me resolve this matter especially this being an extremely dangerous situation. I can be contacted via email: [XXX] or phone: [XXX] . Thank You Sincerely [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle began shaking on the highway. It was coming from under the front hood and was shaking the steering wheel. The check engine light came on. I pulled over and had it towed to the Mercedes repair shop. They said it was related to a bad balance shaft and that it was a systemic problem with the engine in certain Mercedes e350s. I was told I needed to replace the camshaft and it would cost $6,000!!! After some research, it looks like Mercedes agreed, back in 2015, to cover only certain of these Mercedes, but there was no recall. I could have been killed if I was rear ended.

Vehicle headlight burned out while driving at night time reduced visibility. Upon inspection found the headlight wires insulation located behind the passenger's light bulb connector melted/burnt causing short circuit. Temporary fixing it with an electrical tape.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that while refueling the vehicle, the vehicle emitted an abnormally strong gasoline odor inside and outside the vehicle. The vehicle was taken to the dealer and the contact was informed that the failure was related to an unknown NHTSA ID Number; however, the campaign had expired. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 77,000.

The contact owns a 2007 Mercedes-Benz E350. The contact stated while driving at various speeds, the sunroof detached from the vehicle and was manually reattached to the vehicle. The contact had experienced the failure several times. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 22V954000 (Visibility) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 138,000.

FUEL SMELL COMING FROM THE REAR, CAR IS A PZEV AND OUT OF WARRANTY, SMELL IS VERY STRONG AND I AM UNABLE TO DRIVE IT WITH A CHILD IN THE BACK BECAUSE THEY GET DIZZY. UNABLE TO FILL UP WITH GAS UP TO A CERTAIN POINT OR SMELL WILL LINGER.

Fuel sending unit warranty was extended but only for a short time. Mine has failed and gas is leaking into the car and MB won’t honor warranty because it expired on my car and entire fuel tank has to be replaced.

FUEL TANK AND FUEL PARTS LEAKING. 2 REPAIRS AND CAR OFTEN SMELLS OF GASOLINE ESPECIALLY IN THE GARAGE.

Fuel tank fuel leak, NHTSA Action Number EA13003 I purchased a 2007 Mercedes E Class used a few months ago, and recently I noticed a fuel leak, strong fuel smell outside of vehicle when fuel tank is filled higher. More fuel means more fuel odor. Upon research, it seems like there was a warranty extension for 15 years, and with my luck, warranty extension ran out just after I bought the car but before I noticed the problem. As fuel is a safety issue and can easily ignite, and also affects emissions, I feel like the remedy should not just be a 15 year warranty extension, but longer as cars are staying on the road longer and longer. I'm sure I'm not the only one with this issue out of warranty extension period.

2007 MERCEDES BENZ E 350. CONSUMER WRITES IN REGARD TO ILLUMINATED CHECK ENGINE LIGHT.

I HAVE A SMELL OF FUEL ON THE REAR DRIVER-SIDE WHEEL. SEEMS LIKE THERE IS A FUEL LEAK FROM EITHER THE FUEL FILTER MODULE OR IT IS A TANK LEAK. I TOOK OFF THE REAR CUSHION AND WE CAN SEE AND SMELL FUEL VISIBLY ON THE LEFT SIDE UNDER THE SEAT QUESHON AND OVER THE FUEL FILTER MODULE. SEEMS LIKE THERE WAS A SIMILAR PROBLEM WITH THE 2003-2006 E CLASS AND THE 2006 CLS CLASS VEHICLE. I THINK THIS IS A SAFETY ISSUE AS I HAVE SEEN ONLINE MANY OTHER CUSTOMERS ARE HAVING A SIMILAR ISSUE. I THINK IT WILL BE A FIRE AND SAFETY HAZARD AND SHOULD BE INVESTIGATED.

Due to the odor of gasoline both inside and outside my car I brought my car to the local Mercedes’ dealership. Upon inspection they found a small crack in my fuel tank which allowed gasoline to leak into another compartment. The dealer stated they would not be able to replace fuel pump without replacing the gasoline because of the “danger and risk of fire”. I believe that the leakage of gasoline and the fumes associated inhaled presents a very real danger, and risk to health. Upon research I found that this is a major issue that has been addressed by your department. After a 3 year investigation this investigation was closed due to the extension of the manufactures warranty to 15 years. My car is 8 months out of the extended warranty. When speaking to Mercedes’ Benz hotline, the representative stated receiving several phone calls recently with reports of the same issue. I appreciate your attention to this matter. I am hoping this case with be reopened, and the manufacturer held responsible for replacing faulty fuel tanks.

Vehicle fuel system known component issue, fuel pump failure, intermittent. Driving vehicle can lose power at speed, causing potential loss of control as hydraulic assist to steering and braking fails with engine. This known issue has intermittently cause our car to fail to start, or fail in operation. This was a known issue, the manufacturer was allowed to avoid a recall by extending the warranty for this component (fuel pump in fuel tank assembly) to 15 years. Our car started showing this around that time (3 months ago, when extended warranty expired), however we were not then aware of said warranty. Now that we've been two months of diagnosis and discussions with MBUSA Customer Care, they are not willing to replace the known failure point as warranty expired 3 months ago. This should have been a recall from the beginning, and now we, and many others to come, will have the value and usefulness of our vehicles reduced or eliminated. Those not aware of the potential failure of this very expensive part, will be at risk every time they operate their cars at speed on the public highways. NHTSA should never have allowed this warranty extension scheme to substitute for a recall. There is no way to predict failure, and entire fuel tank assembly replacement is <$4,000. Fuel pump is not individually accessible or available for replacement, only entire tank assembly in these PZEV vehicles is available. Mercedes-Benz is shirking responsibility here, and flipping it over to the dealerships and consumers.

The contact owns a 2007 Mercedes-Benz E350. The contact stated while driving approximately 65 MPH, the check engine warning light illuminated and with an abnormal sound coming from the gear shifter. The contact stated there was a failure with the transmission and the vehicle would not exceed 65 MPH. The transmission was replaced. The contact was unable to reach the manufacturer; however, several voicemails left for the manufacturer. The approximate failure mileage was 100,000.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that while the vehicle was parked in the garage and turned off, the entire rear end of the vehicle inadvertently lowered to the ground. The contact stated that the failure was related to NHTSA Campaign Number: 12V264000 (Suspension) however, the vehicle was not included in the recall. The vehicle had not been diagnosed or repaired. The manufacturer and the dealer were not made aware of the failure. The approximate failure mileage was 140,000. The consumer stated the rear air suspension is functioning as designed. Upon restarting the vehicle the air compressor was recharged.

Engine code p0016 and p0017. Defective balance shaft and sprockets

The component/s that have failed are (reputedly) the fuel system resulting in significant fuel fumes permeating into the cabin of the vehicle as well as being very evident around the rear outside of the vehicle. This seems to be more obvious after the car has been filled with fuel. Having fuel fumes leaking into the cabin of the car should be self evident as a risk to anyone travelling in the vehicle, especially in the rear seats. The fumes eminating from the car, externally, are a potential fire hazard should anyone walk by with a cigarette or naked flame. This is an on going problem well known to Mercedes Benz and one that should have been the subject of immediate recalls by MB and not subject to a Mileage, Time Frame or VIN number. Why should I, or anyone, have to foot a fairly significant bill, for fixing a manufacturing fault just because the previous owners didn't get the problem fixed and I purchased the vehicle after some 15 year warranty time frame? This issue could result in someone's death if Mercedes is not forced to remedy it and by remedy it I mean for ALL 2007 E350's to be recalled unconditionally. Consumer would like to amend the complaint to include the recall of ALL Mercedes E350 for the years 2006 and 2009 for inspection of the cause of the problem and the repair of those vehicles where repairs are needed at Mercedes Benz cost.

Fuel tank leak at the top of the tank. MB has well documented gasoline leaks for MB model 211 years 2003-2008. Notices were sent to owners of gas powered auto's but none were sent to DIESEL auto owners. The exact same procedure and parts are needed to repair DIESEL tanks as gasoline tanks. Either this is a oversight by MB or the problem was ignored. My DIESEL tank is leaking exactly as other documented gasoline MB vehicles model 211.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that while the vehicle was parked with the engine running, the contact heard a loud rattling sound coming from the engine compartment. The contact called an independent mechanic and was informed that the camshaft balancer was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 257,000.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that the vehicle leaked gasoline into the rear driver’s side seat causing a pool of gasoline under the seat. The contact stated that the check engine warning light was illuminated. The vehicle was diagnosed but not yet repaired. The manufacturer was informed of the failure. The contact was provided information of a possible manufacturer’s recall. The failure mileage was approximately 104,000.

AFTER I FILLED UP MY GAS TANK AND CAME HOME AND PARKED MY CAR IN THE GARAGE. AFTER A FEW HOURS I SMELL STRONG GAS SMELL. WHEN I RESEARCHED MBWORLD, I SAW MANY PEOPLE HAVING THE SAME / SIMILAR ISSUE, AND MERCEDES BENZ HAD EXTENDED THE WARRANTY TO 15 YEARS TOWARDS FUEL LEAK ISSUES. THERE WERE MANY ARTICLES ON THE FORUM. WHEN I CALLED MY DEALER, HE SAID THAT I THERE ARE NO RECALLS ON IT. HOW DO I RESOLVE THIS ISSUE?

CAM GEAR DETERIORATED

CAM GEAR DETERIOATED

WHEN I FILL THE GAS TANK TO THE TOP, I SMELL FUEL IN THE CABIN, I THINK THERE WAS A RECALL FOR THAT, BUT DEALERSHIP SAYS NO, THERE IS A VIDEO ON THIS ISSUE ON YOUTUBE AS WELL, I GOT THIS RECALL NUMBER FROM A FRIEND NHTSA#13003, COULD YOU PLEASE CHECK AND HELP ME OUT.

WHEN I FILL UP THE GAS TANK I NOTICE A GAS SMELL FROM OUTSIDE OF THE CAR ON THE REAR DRIVERS SIDE. WHEN THE FUEL LEVEL DROPS TO 3/4 FULL THE SMELL DISAPPEARS. I'M AFRAID OF AN EXPLOSION IF I PARK IN AN ENCLOSED GARAGE

ENGINE LIGHT CAME ON WHEN I WAS DRIVING. DID DIAGNOSTIC AND IT SAYS CAMSHAFT SENSOR PROBLEM. WHICH MEANS IT'S NOT ONLY THE DIESEL MODELS WITH THIS ISSUE.

BRAKES DID NOT CATCH LIKE I PUSHED BRAKES ALL THE WAY.I HAVE TO PUMP BRAKES 3-4 TIMES BEFORE DRIVING AND WHEN REVERSING THEY LOCK.I TOOK IT TO A MECHANIC AND THE ABS CONTROL MODULE IS NOT WORKING NOW IT NEEDS TO BE REPLACED.I CAN'T DRIVE IT SINCE THE BRAKE LINES HAV ENO BRAKE FLUID RUNNING THROUGH THEM.

I RECENTLY BOUGHT AN 07 MERCEDES E350 I'VE FOUND THIS SAME COMPLAINT ON NUMEROUS WEBSITES THE WHOLE CAB OF THE CAR FILLS WITH A TERRIBLE FUEL SMELL ONLY ON THE INSIDE OF THE CABIN BUT ITS SO BAD ID HESITATE LIGHTING A LIGHTER IN THE CAR UNTIL THE WINDOWS HAVE BEEN ROLLED DOWN AND AIRED OUT ITS SUPPOSEDLY UNDER THE VERY SPOT MY 5 YEAR OLD GRANDDAUGHTER WOULD BE SEATED THIS IS NOT ONLY HIGHLY DANGEROUS AND FLAMMABLE BUT WILL GIVE THE DRIVER AND OCCUPANTS TERRIBLE HEADACHES, NAUSEA AT TIMES AND IN MY OPINION IS A NOT ONLY FIRE HAZARD BUT ALSO A HEALTH HAZARD AND IT DOES THIS SITTING STATIONARY WITHOUT THE CAR RUNNING I'VE TRIED EVERYTHING NOT FILLING THE CAR TO THE TOP BUT EVEN AT A HALF TANK YOU HAVE THE SAME PROBLEM ITS SO BAD I WOULD RETURN THE CAR IF THE DEALER WOULD TAKE IT BACK THIS IS EXTREMELY UNHEALTHY

CAR SMELLS LIKE GAS INSIDE AND OUT UNTIL ABOUT HALF A TANK AFTER REVIEWING MERCEDES BENZ FORMS IN THE BENZ WORLD WEBSITE IT IS A VERY COMMON PROBLEM WITH THE E500 AND E550 IN THE YEARS BETWEEN 2005 AND 2008 VEHICLES THERE ARE NUMEROUS COMPLAINTS ABOUT IT AND NOT SURE WHEN IT STARTED I'VE JUST RECENTLY PURCHASED THE VEHICLE BUT THE PREVIOUS OWNER PREVIOUS OWNER MENTIONED IT TO ME AS WELL I DIDN'T THANK TO MUCH ABOUT IT TILL THE SMELL HAS GOTTEN SO BAD THAT THE WINDOWS HAVE TO BE ROLLED DOWN TO BE ABLE TO BREATHE IN THE VEHICLE

I HAVE 2007 E350 CLASS 4-MATIC SPORT PACKAGE, THE PANORAMIC SUNROOF DOES NOT OPEN AND WHEN I PUSH BOTTOM TO OPEN THE MOTOR SOUND LIKE IS GRINDING THE CAR HAS ONLY 75000 MILES ON IT AND THE DEALER DOES NOT WARRANTY IT. THE COST TO HAVE REPAIRED AT MERCEDE DEALERSHIP IS $1500.

SPENT OVER $2K JUST ON DIAGNOSIS AND WRONG FIXES. IT STARTED WITH PROBLEMS CRANKING. I REPLACED THE KEY FOB, REPLACED THE BATTERY, REPLACED THE ALTERNATOR, HAVE HAD MERCEDES DIAGNOSE WITH NO ANSWERS. MY USUAL MECHANIC DIAGNOSE WITH NO ANSWERS. A EUROPEAN SPEACIALIST REPLACED THE ALTERNATOR AND TENSIONER PULLEY. TOOK IT TO A FRIEND AND WE DISCOVERED THAT THERE WAS A LEAK IN THE SUNROOF RUNNING DOWN THE SIDE OF THE CAR INTO THE BATTERY COMPARTMENT. AT THIS POINT VARIOUS PROBLEMS ARE GOING ON. THE WINDOWS, DOOR LOCKS, RADIO, CRANKING, ALL INTERMITTENT BUT NOT ALWAYS AT THE SAME TIME. TOOK IT TO ANOTHER MECHANIC WHO SAID THE SANS MODULE IS BAD, AT LEAST. AN $800 FIX, THEN THEY COULD MOVE TO THE NEXT MODULE AND THE NEXT. ALSO MAYBE UNRELATED BUT MAYBE NOT. LOW CAR LIGHT CAME ON. ENGINE 'DIED' (VEHICLE LOST ALL POWER) WHILE TRAVELING AT HIGHWAY SPEED OR WILL JERK DOWN GEARS AND ONLY CONTINUE TO FUNCTION IN DRIVE @ 40MPH OR LOWER. I HAD TO PULL VEHICLE OVER ON SIDE OF THE ROAD WITH NO POWER ASSISTANCE STEERING OR BRAKING. THIS PROBLEM OCCURRED WITH NO WARNING AND AT HIGHWAY SPEEDS CREATING AN IMMENSE SAFETY RISK. MANY OTHERS HAVE REPORTED THE SAME ISSUE WITH THIS AND RELATED CARS FOR THIS AND NEARBY MODEL YEARS. LIKE THEM, I WONDER WHY THERE IS NO RECALL. MERCEDES BENZ WILL NOT REPLACE THESE DEFECTIVE PARTS WILLINGLY AND THERE ARE MANY OF THESE CARS DRIVING DOWN OUR HIGHWAYS PLACING NOT ONLY THE PASSENGERS AT RISK BUT OTHER DRIVERS AROUND THEM.

OIL COOLER SEAL LEAKING GASKET CAUSING FIRE HAZARD