Lincoln MKX 2016 — Reported problems

"AWD Temporarily Disabled" warning notification came on while driving 55 mph in the middle lane of an expressway during late afternoon/early evening hours. The roadway was clear of debris and the weather was sunny. There was no further instruction of what to do from the dashboard. However, after the warning came on, the vehicle started to smell bad and a noise from the rear passenger side could be heard. While slowing down to a stop, the vehicle started to vibrate and steering became tight and difficult to maneuver. Once I read through the manual, it mentioned to let the vehicle cool for 10 minutes before moving again. I waited 5 hours to drive the car again and the same thing occurred. I pulled over and waited 25 minutes and the vehicle would not go into Drive. It would go into Reverse. I had to go into Reverse twice before the vehicle would move into Drive. The "AWD Temporarily Disabled" warning kept coming on continuously until I could pull over again. Each time I slowed down or was coming to a stop, the vehicle would vibrate as if it was wanting to stall and the steering was tight and difficult to maneuver. The safety of myself and others were at risk because I may have lost the ability to steer myself to safety if I had slowed down too much or too soon before reaching a safe place and I could have caused a fatal or severe accident to myself and/or others with multiple cars all going at highway speeds. I have notified the dealer and have a set appointment for the end of this week. There were no warnings, messages or symptoms prior to this occurring while I was driving on the expressway.

The contact owns a 2016 Lincoln MKX. The contact stated that while driving 30 MPH, the brake pedal became inoperable, and the brake warning light was illuminated. The contact pulled away from oncoming traffic to ensure that the vehicle stopped and avoided a crash. The vehicle was taken to an independent mechanic, where it was diagnosed with a failure of the front caliper and brake hydraulic system, which needed to be replaced. The vehicle was repaired multiple times. The contact later received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part was not yet available. The dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure via telephone. The approximate failure mileage was 85,446.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer confirmed that parts were not yet available for the recall repair. The contact stated that there was increased brake pedal travel while coming to a complete stop. There was no warning light illuminated. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.

Unknown there were no incidents But the recall is almost 1 year old I received the notice September 2025 regarding a possible brake hose defect waiting almost 1 year for a Fix is Rediclous there had been no updates from Ford/Lincoln motor company brake issue should be taken more Seriously

The contact owns a 2016 Lincoln MKX. The contact stated that while operating the vehicle and depressing the brake pedal, the vehicle failed to immediately stop with the message “Low Brake Fluid” displayed. Brake fluid was later added to the brake reservoir, and the vehicle was driven to the local mechanic, who diagnosed that the brake hoses were faulty and needed to be replaced. The brake hoses were replaced, and the vehicle was repaired. The contact previously received notification of NHTSA Campaign Number: 20V469000 (SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC). Additionally, the contact stated that the back over prevention camera had intermittently failed. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet contacted. The failure mileage was approximately 52,000.

It has been almost a year since this recall came out and there is not a remedy available. the manufacturer has failed to provide a remedy for it since it came out on August 25, 2026

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds and depressing the brake pedal, the vehicle slowly responded, requiring hard braking, causing the stopping distance to become extended. Several warning lights illuminated with the message "Parking Aid" displayed. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2016 Lincoln MKX. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The ABS warning light was illuminated. The brake pedal was depressed to the floorboard, and the vehicle slowly stopped. The vehicle almost rear-ended another vehicle. The contact stated that while the vehicle was parked, the contact became aware that there was brake fluid on the ground at the rear passenger’s side of the vehicle. The vehicle was towed to the dealer where it was diagnosed with a cracked brake hose. The contact was informed that the brake hose needed to be replaced. The vehicle was not repaired. The contact was informed that parts were unavailable to repair the vehicle. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that while coming to a complete stop and depressing the brake pedal, the brake pedal went to the floorboard, requiring hard braking to stop the vehicle. The contact stated that the failure had occurred several times while driving. The message "Hydraulic Brake Fluid Low" was displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear flexible brake hoses and the corroded rear brake calipers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 64,200.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was unavailable. The vehicle was scheduled for the recall repair. The contact was later informed that parts were unavailable to repair the vehicle. The contact stated that the vehicle was unsafe to drive with the open recall repair. The manufacturer was not contacted. The contact had not experienced a failure.

Tuesday June 2, 2026 my car went into the shop. At which time the viscous coupler was replaced for the rear AWD differential. This was a Ford OEM Part that had failed. Upon replacing it shut up they found the rear differential gear assembly was in fact also in need of being replaced. The needed part is called a rear final drive. It is now June 30, 2026. My car has been in the shop now for 28 days. The rear final drive part needed is on backorder. “We are more than 100 on the list.” Therefore, I will not be getting my car back any time soon. Upon researching and discussions with dealerships, this is and has been a known problem with the Lincoln and Ford vehicles. However, there has never been a recall, or any justification for this known problem. I would like some answers to why anyone would have to wait that long for a part for their vehicle! I am without a car and will be for an extended period time!

I am writing to file a formal safety complaint regarding the extreme delay in the recall remedy for my vehicle. Despite the recall being issued months ago, Ford Motor Company/Lincoln has failed to resolve this critical safety issue in a timely manner. Here are my vehicle details: Year/Make/Model: 2016 Lincoln MKX VIN [XXX] NHTSA Recall Number: 25V544 Manufacturer Recall Number: 25S87 Component Affected: Rear Flexible Brake Hoses Description of the Safety Concern: The recall notice explicitly states that a failure in the rear flexible brake hoses can lead to a loss of brake fluid, resulting in increased brake pedal travel and significantly increased stopping distances, which greatly elevates the risk of a crash. Recently, I have started experiencing a noticeable softening in the brake pedal ("increased pedal travel"), which makes driving the vehicle extremely hazardous. When I contacted my local Lincoln dealership, I was informed that they do not have the necessary parts in stock and could not provide a definitive timeline for the repair. As a consumer, I am being forced to drive a vehicle with a known, severe braking defect because the manufacturer has failed to supply the remedy parts. This is a direct threat to my life, my family’s safety, and the safety of others on the road. Furthermore, this prolonged delay is causing me significant financial hardship and stress. I urgently request NHTSA to intervene and hold Ford Motor Company accountable for expediting the parts distribution for this critical safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle is very hard to stop . The recall was in August of2025 for my back break hoses, as of today Ford/Lincoln doesn't have the part . This is very Dangerous. I'm financing my vehicle therefore I don't have funds to repair it myself. I'm at risk of crashing and I take my kids to school daily, I'm putting my family life in danger every time I get behind the wheel Please can someone help me keep my family safe

See attached document for complaint.

FOR THESE LAST SEVERAL MONTHS, NEAR OR AROUND DECEMBER OF 2025 MY 2016 LINCOLN MKX HAS BEEN SHORTING OUT OR HAVING GLITCHES IN THE CENTER CABIN. THE CROSS TRAFFIC SYSTEM AND BLINDSPOT SYTEM FAULT HAVE TURNED ON AND OFF SIMULTANEOUSLY CREATING A SHORT IN THE CABIN RESULTING IN THE ac OR hEAT TURNING OFF AND ON. THIS ALSO CREATES A SHORT WHERE THE THE WINDOWS WILL NOT ROLL DOWN, THE GLOVE BOX WILL NOT OPEN OR THE TRUNK, THE DOORS CANT OPEN FROM THE OUTSIDE. AND MOST SERIOUS, MY KEY FOB WILL NOT OPEN THE VEHICLE. THE lINCOLN DEALERSHIP IS AWARE OF THE PROBLEM BUT HAS REFUSED TO ADDRESS THE PROBLEM BECAUSE THEY CLAIM THEY CANNOT REPLICATE THE ISSUE. THE DEALERSHIP HAS WITNESSED THE PROBLEM, YET THEIR TECH IS NEVER AVAILABLE. THE DEALERSHIP IS AWARE OF THE ISSUE, AND HAS SEEN VIDEOS OF THE PROBLEM BUT REFUSES TO ADDRESS. ORIGINALLY CAR MAX REFERRED THE CAR TO LINCOLN BECAUSE CARMAX CLAIMED THEY DO NOT HAVE THE TECHNOLOGY TO ADDRESS THE LINCOLN'S ISSUES. LINCOLN CLAIMS THEY CANNOT REPLICATE AND THAT I SHOULD WAIT FOR THE CAR TO BREAK DOWN.

The internal water pump failed, dumping a half gallon of antifreeze into the engine oil. This caused the engine to suddenly stall and lose all power while driving in the middle of active traffic, creating a severe crash hazard .

Rear axle joint degraded, the vehicle cannot steer smoothly, indicator shows AWD temporarily disabled; large vibrations and unsafe to drive. In the end the vehicle was having troubles turning directions.

The contact owns a 2016 Lincoln MKX. The contact stated that while pulling into the ATM at approximately 10 MPH and depressing the brake pedal, the vehicle made an abnormal popping sound, and the brake warning light illuminated. The vehicle was driven to the residence. The vehicle was then driven to an independent mechanic, and was diagnosed with brake failure. The mechanic determined that the rear passenger’s side brake hose had ruptured, and the rear driver’s side brake hose needed to be replaced. The mechanic replaced both rear brake hoses, and the vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, and a request for reimbursement was made. The manufacturer informed the contact that the reimbursement would be provided once the part for the recall repair was available. The failure mileage was approximately 57,532.

Unknown Still waiting for solution for possible brake failure. Not comfortable just waiting for an accident to happen while driving.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (SERVICE BRAKES, HYDRAULIC); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and informed that there would be another notification when the parts became available. The contact had not experienced a failure.

I have an oil pan leak and when I went online to see what the problem may be, I found that many people were having the same problem as I have for my year make and model vehicle, but it has not been recalled for the manufacture to repair.

2 recalls, saftey notice,#25S87,25E02,first is from September 25,secons,December 25,no update or any information.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (SERVICE BRAKES, HYDRAULIC); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed but traveled down to the floorboard, and the vehicle failed to respond as needed. Additionally, there was an abnormal grinding sound coming from the brakes. The brake fluid warning light was illuminated. The contact stated that on a separate occasion, the brake fluid reservoir was refilled, and days later, the low brake fluid warning light was illuminated. Most recently, the contact stated that when the vehicle was started, it rolled away. The vehicle was parked and was no longer driven due to safety concerns. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. However, no assistance was provided. The failure mileage was 122,934.

While driving home from work during rush hour, a warning light illuminated on my dashboard and my vehicle suddenly lost braking ability. When I pressed the brake pedal, the vehicle did not slow or stop. I was forced to pull onto the shoulder of the road and pump the brake pedal extremely hard multiple times before the vehicle finally came to a stop. This occurred in heavy traffic and created an immediate and severe safety risk. The vehicle was towed to a dealership for inspection. I was informed that only a “temporary fix” could be performed, and I was required to pay approximately $500 for this repair in order to regain use of the vehicle. The vehicle has not received a permanent repair, and the dealership has taken several months without completing a permanent fix. I have also been waiting several months for reimbursement of the almost $500 paid for the temporary repair, with no resolution. I am concerned that I was charged for a temporary repair related to a serious safety failure and that continued delays in both reimbursement and permanent repair place me at ongoing risk. I am filing this complaint due to the dangerous nature of the brake failure, the lack of a permanent repair, the extended delay in resolving a critical safety issue, and the financial burden placed on me for a temporary solution.

Catalytic Converter Issues with Ford after Emissions Recall I recently had an emissions recall on my 2016 Lincoln MKX by Ford (25E02) in which the "vehicle has an emissions control system that does not account for certain in-use conditions and might not control tail pipe emissions effectively over time." Now one of the catalytic converters in the car is not working and needs to be replaced. The safety issue is the emissions being released as a result of the emissions control system not working properly for years and damaging the catalytic converter. I believe the company is aware of the issue but is refusing to include catalytic convertors in the recall. This is an environmental hazard that should fall on Ford to resolve.

Ford Customer Satisfaction Programs (CSPs) 23B11/24E04 for P0420/P0430 codes they did the update and now the check engine light is on all the time and they will not replace catalytic converter

My car is currently under two recall notices however only one of the issues has been communicated to me of resolution. One being emissions control 25E02 and second being Recall 25S87 REAR BRAKE FLEXIBLE HOSE LEAK. Recall 1- emissions has been a problem for about 2 years now. Emissions are connected to my engine thus having my check engine light come on. My car failed an emissions test but was only 4 years old and the catalytic converters are not broken, have hole, anything leading to failed test, car repair fees and non-registered vehicle. The second recall is not being fixed, and I have had to replace my brake house, line and rear right brake twice this year. Lastly, I have collision warning however it does not work properly if at all. I was in a minor fender bender when I went to push on brakes the sound to warn me of a collision did not go off until after the crash! I am unsure of the process but if connected to my braking system it failed and if it is a preventative measure it sucks.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (SERVICE BRAKES, HYDRAULIC). However, the part to do the recall repair was not yet available. The contact stated that an unknown warning light was illuminated. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 140,000.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Glove book hanging down. Rear cup holder in arm rest is stuck.

I have had to replace my rear brake pads, rotors, and the whole braking system (not related to sensors) three times in a year. I received the recall notice after the third time and had a mechanic fix my brake hose as a short-term remedy for my car. Not only does my car have a delay in breaking it is a delay in the monitoring service. Technically the sounds related to my vehicle are not related to braking at all by the speed in which a car slows down before it breaks. In this case that mean if I slam on my breaks the "emergency sound" does not go off. I have a minor fender bender as well due to these two problems associated with my braking system.

The contact owns a 2016 Lincoln MKX. The contact received notification of NHTSA Campaign Number: 25V544000 (SERVICE BRAKES, HYDRAULIC); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Condensation build up in my passenger headlamp has caused the led rope lighting to stop working.This shows a recall but one not offered at this time.I have never received any recalls through the mail form.I recently moved and my address is as follows: [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Lincoln MKX. The contact stated that while driving at 60 MPH, the brake pedal was depressed and went to the floorboard. The contact stated that the "Low Brake Fluid" warning light was displayed while the contact pumped the brake pedal before the vehicle drifted to a stop. Due to the failure, the vehicle was towed to an independent mechanic, and was diagnosed with a rear brake hose failure. The contact then received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulics); however, parts for the recall were not yet available. The dealer was notified of the failure, and the vehicle was towed to the dealer. The dealer acknowledged the recall, and the contact was provided an estimate for the repair. The manufacturer was notified of the failure, and the contact was informed that a claim could be filed to be reimbursed for any out-of-pocket repairs on the vehicle related to the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 100,000.

The contact owns a 2016 Lincoln MKX. The contact received notifications of NHTSA Campaign Numbers: 20V469000 (SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC) and 25V544000 (SERVICE BRAKES, HYDRAULIC); however, the parts to do the recall repairs were not yet available. The contact stated that while approaching a traffic light, the brake pedal was depressed; however, the vehicle failed to respond in a timely manner. The vehicle then slowed down and stopped; however, the contact stated that added force was used to depress the brake pedal. No warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The failure mileage was unknown.

The right headlight is filling up with condensation which is shorting out the battery. Replaced it more condensation is back in it. Mechanic says seals are no good says its a common problem in all lincolns. Lights and adaptive module cost well over 5K for one light not including the labor. This is a potential for a fire hazard.

The contact owns a 2016 Lincoln MKX. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The check engine warning light was illuminated. The message "Coolant Overheated" was displayed on the digital display screen. The contact stated that the vehicle failed to restart as intended. The vehicle was towed to a local dealer, where it was diagnosed with an air intake valve fracture and abnormal engine oil consumption. The vehicle was not repaired. The local dealer related the failure to NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 54,000.