Lincoln Aviator 2020 — Problemas relatados

The contact owns a 2020 Lincoln Aviator. The contact stated that while driving or while reversing, the steering wheel intermittently seized while turning left or right. The messages "Service Advance Track," "Drive Control Malfunction, Service Required," "Pre-Collision Assistance not Available," "Check Headlamp System, See Manual," and "Adaptive Steering not Available" were displayed. The vehicle was taken to a dealer, where it was diagnosed with a failed steering gear assembly and rack and pinion system, and the parts needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was returned to the dealer, where the rack and pinion was cleaned, and the steering wiring harness was cleaned of corrosion and repaired; however, the failure persisted. The vehicle received no additional repairs. The manufacturer was notified of the failure. The failure mileage was 116,000.

2020 Lincoln Black Label Aviator with 70,000 miles. Around April 13, 2026, while driving, we received an error message indicating a steering wheel issue. We took it to the shop immediately to have the code checked. At that time, we were told the steering wheel had failed, and the car was inoperable. A week or so later, we were told Lincoln didn't have any parts to repair it and would need to build a new steering wheel. At the time, we were told it would take up to 6 weeks. We followed up after six weeks, only to be told Lincoln wouldn't build the steering wheel and could provide one in a completely different trim. The service consultant did not feel comfortable with the solution. As of today, it's been sitting at the dealership without a solution, and the car remains undriveable.

Transmission died at 92000 miles. The car shifted to park while my wife was driving it. Shortly after the transmission started jerking in gears 1,2 and 7. Took it to the dealership and had to have the whole transmission replaced at about $7200. A transmission should last more than 92000 miles and should never shift to park while driving.

Transmission started shifting hard when going from 1-2, up and down shifting. Sometimes there is a grinding sound and then a very hard shift into 2nd gear. 1 time it would not shift at all after coming to a stop. Diagnosed by Ford as bad A clutch and needing to be replaced.

My car slammed into park while I was driving on the highway and now is in limp mode only going into neutral and I am stranded without a vehicle. The Lincoln dealership wants to charge me 1500 to diagnose it but that’s the problem.

I am filing this complaint regarding the recurring infotainment screen failure on my 2020 Lincoln Aviator. The center display repeatedly goes completely black while driving or when using Apple CarPlay. When this occurs, I lose the backup camera, navigation, audio, climate controls, and other vehicle functions. The loss of the backup camera creates a serious safety hazard when reversing. The vehicle has been taken to an authorized Lincoln dealership numerous times for this same issue. The dealership has performed software updates, module programming, module replacement, diagnostics, and recall-related repairs. Despite these repeated repair attempts, the defect remains unresolved. I was informed there is currently no permanent repair for this recurring problem. I have spent significant time and money returning the vehicle for repairs and have opened multiple cases with Lincoln/Ford requesting a permanent solution and vehicle repurchase. Despite repeated unsuccessful repairs, Ford denied my request. This is an intermittent safety defect that occurs without warning and continues after multiple repair attempts. I respectfully request that NHTSA investigate this defect and determine whether the current recalls and repair procedures adequately correct this safety issue, as I believe other 2020 Lincoln Aviator owners may be experiencing the same unresolved problem.

The contact owns a 2020 Lincoln Aviator. The contact stated that on several occasions while shifted to reverse(R), and occasionally while in drive(D), the vehicle jerked violently and did not stop jerking until the brake pedal was depressed. The vehicle was taken to a dealer where it was diagnosed and determined that the rear differential needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2020 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving 70 MPH, the vehicle shutoff while coming to a complete stop, with an abnormally rough grinding sound coming from the vehicle. The vehicle was restarted after several attempts but was undrivable. The vehicle was towed to a local dealer where it was diagnosed with transmission failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 84,464.

The contact owns a 2020 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train). The contact stated that while stopped at a stop sign, the transmission unexpectedly shifted into park(P), and the gear shifter could not be shifted out of park(P). The vehicle was towed to a dealer to be diagnosed. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired, and the part to do the recall repair was not yet available. The manufacturer was notified of the failure. The failure mileage was 78,000.

TRANSMISSION MAY BRIEFLY ENGAGE IN PARK WHILE THE VEHICLE IS STILL MOVING.

My fiance went out to start the car. The car wouldn't start, but the starter kept clicking for around 5 minutes even when she was out of the vehicle with the door shut. During that 5 minutes the car started to smoke really bad and you could smell an electrical fire. She ran in the house to get me. We started moving our other cars away from the Lincoln. As I was getting ready to call 911 the starter stopped clicking and the smoke from underneath the car went away. It has currently been at a Ford/Lincoln dealership for the past 2 weeks. They said that the starter fried that battery. This was really traumatic for my fiance because she constantly drives our kids around in the car. Now she's terrified that the car will catch fire again. We have video but it will not let me upload.

The contact owns a 2020 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. Upon taking the vehicle to a collision repair shop, the contact was informed that the gear shifter had failed to shift out of park(P). The vehicle was taken to the dealer, where it was determined that the failure was associated with the recall. The contact was advised that the vehicle would be repaired at the owner's expense because the part for the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 126,000.

My wife went to a friends house to drop something off, pulled in the driveway, pushed the Park button, got out of the vehicle, as she was walking away the car drove through their garage door. We paid about $3300 to have their door replaced. We just recently received a recall 26V402 that talks about this issue and it currently says there is not a remedy for it at this point.

The contact owns a 2020 Lincoln Aviator. The contact stated that after restarting the vehicle, the transmission was shifted to drive (D), but the vehicle failed to move while the accelerator pedal was depressed, and the engine was revving. The messages "Park Brake Malfunction Service", "System Braking Issue", "Service Advancetrac", "Park Malfunction Service Now", and "Check Brake System" were displayed. Additionally, the vehicle previously hesitated to accelerate while driving. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 89,635.

The 3rd row headrest will no longer stay in the up position, creating a safety hazard during a accident. I've already had to repair it once. Seems to be a common problem in Ford's.

I own a 2020 Lincoln Aviator. After starting the vehicle, I exited without intentionally placing the vehicle in gear. The vehicle began rolling backward unexpectedly after I exited. I was struck and injured by the vehicle, resulting in a laceration to my shin requiring eight stitches. At no point did I intentionally place the vehicle in a position that would allow it to move. The vehicle did not adequately engage Park or activate any automatic safety features to prevent movement when the driver exited. This incident raises serious concerns about the reliability of the electronic shifter system and automatic park/braking safety features. This failure created a dangerous condition and resulted in physical injury. The dealership states it cannot reproduce the problem nor can they determine what caused the vehicle to roll back. There were no warnings prior to the failure.

To Whom It May Concern, Please see attached formal notice regarding recurring defects, safety-related recall issues, Certified Pre-Owned representations, and financing concerns associated with my 2020 Lincoln Aviator Reserve VIN [XXX] . This matter involves: • recurring suspension and electrical concerns; • safety-related rearview camera/SYNC recall issues; • repeated dealership repair activity; • diminished reliability and value; • Certified Pre-Owned reliance; • and unresolved manufacturer-level concerns despite extensive servicing history. Please escalate this matter immediately to executive customer relations and manufacturer review. I am requesting: • a formal manufacturer investigation, • preservation of all records associated with this VIN, • and review for buyback, goodwill compensation, warranty relief, or other global resolution options. Please confirm receipt and provide a case number immediately. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am filing a safety complaint regarding a 2020 Lincoln Aviator Reserve VIN [XXX] involving recurring safety-related electrical and visibility concerns. The vehicle has experienced repeated service-related issues involving suspension systems, electrical inspections, camera/display concerns, and manufacturer customer satisfaction programs. Most significantly, the vehicle is subject to an active manufacturer safety recall involving the SYNC/rearview camera display system. The recall states that the rearview camera image and display may become inverted or flipped, impairing rear visibility and increasing crash risk. This defect directly impacts driver visibility and safe vehicle operation while reversing. The vehicle has undergone repeated dealership servicing and diagnostic evaluations, yet the broader operational and safety concerns remain unresolved. The vehicle was also sold as a Lincoln Certified Pre-Owned vehicle, creating reasonable reliance that the vehicle met enhanced inspection and safety standards. I believe the recurring nature of these defects, combined with the active recall and repeated repair activity, demonstrates a broader safety-related defect pattern warranting regulatory review and investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

while moving in reverse, the vehicle automatic breaking system engages on and off giving a jerking movement of the car and makes you feel like you hit something. Once the vehicle is placed into Drive mode the same thing happens with the breaking system. because of this the check vehicle lights come on and gives a "Hill start assist warning" also "Pre-collision Assist Not Available". Also all wheel drive mode is not available and the drive mode selection no longer works. Took the car to the Lincoln dealership and they said it is a known problem and that there is a TSB out on this issue. The vehicle has only 66,000 miles on it and it is out of warranty. How can there not be a recall on this issue? They said they need to replace two shafts in the front end costing $5,000.

replaced 2 valve bodies, and now the CDF has an open statement bulletin on it, and I have to do an entire transmission replacement

Suddenly car is excessively loud when first started for roughly 30 seconds and then quiets to normal. However when placed in Drive there is a loud "clunk" that takes place to allow the car to shift into gear. While driving the car shakes vigorously. These issues all point to the enigine mount recall that did not include my vehicle, but should have. NHTSA Recall Number 20V788000 should be expanded to include my vehicle.

Backup camera is not working properly and the lane departure system doesn’t work

On January 29, 2026, at approximately 4:00 PM, the vehicle experienced unintended movement while in PARK and powered off. The vehicle had been placed in Park, the engine was turned off, and the driver exited. Shortly afterward, the vehicle rolled unexpectedly while unattended. The vehicle remained parked and was not driven due to safety concerns. Wheel blocks were placed behind the tires until the scheduled dealer appointment on February 4, 2026. The dealer inspected the vehicle and was able to replicate the condition. The failure was diagnosed as a malfunctioning parking pawl solenoid within the transmission system. The dealer confirmed the vehicle could be physically rolled after being placed in Park and powered off. This condition presents a serious safety risk, including risk of injury or death if a person, child, or object were behind the vehicle. There were no prior warning messages or alerts before the incident. The vehicle is available for inspection upon request.

We purchase car on [XXX]. On [XXX] there is a significant leak in the panoramic sunroof that completely floods the trunk (unsure if this is related to the next problem). Our car is at the dealer for repairs 12/12/25 - 1/8/26 and is "fixed" as per the dealer. On [XXX] it starts running independently in the driveway when we are not home and both keys are untouched inside our locked home. We return a call from a concerned neighbor to enter our home, get the key, and turn off the car. After this incident the car is nearly undriveable because so many error messages begin to populate the screen. With the unpredictable nature of the car starting it is extremely frightening to depend on this car and know if it is going to suddenly start running (or driving!) unsupervised which could lead to all different kinds of compromised safety situations, especially since our driveway has easy access to the main street where kids often play. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driver side and passenger seats will not recline. The back will move forward and all other parts will adjust properly, but it always stops at a certain point that is clearly not as far as it will recline. I had this issue fixed at the dealership under warranty in December and less than a month later, the drivers side it doing the same thing. I see that the car's system automatically updated on 12/29 and I'm wondering if the system updates are causing this. This could be a safety issue if someone was stuck in a position where the seat is leaned too far forward.

Transmission slipped and lost all power

Upon starting the vehicle around 7p on Friday, 10/31/25, the following errors flooded the screen: Hill start assist not available Service advancetrac 4WD Malfunction service required Pre-collision assist not available Rear sense breaking not available Additionally, cruise control could not be turned on and utilized. There was no incident to trigger these. The car had been sitting parked and off for ~2 hours prior to being turned on. No issues or errors prior to this date and time of turning on the vehicle. The warnings detailed describe how our safety was put at risk. All of these safety and basic features no longer functioned and our children’s safety was put at risk due to this electronic issue causing major functionality breaks/discontinuation of functions. Reproduced and confirmed by Capital Mazda of Cary (NC). Quoted to repair at our expense and “remove and throw out the electronic and replace with a manual.” Furthermore we’ve been informed verbally by our service associate that Ford (parent company) is aware of this safety issue. A TSB was located with a summer 2023 date. Lincoln customer service has stated this would’ve been covered under warranted “if it had come up while under warranty.” This dealership is the only place that has reviewed the vehicle and conditions and provided the explanation and information.

Driving on interstate, a flex pipe (part of the exhaust) fell off at the forward end, Dragging the ground and damaging the catalytic converter and rear exhaust pipe. This was repaired by the dealership, but the flex pipe was not covered under the extended Warranty program. The vehicle had just over 50,000 miles on the odometer.

Glass portion of passenger side rear view mirror fell off as vehicle was exiting driveway possibly due to defective adhesive much like the safety recall on the door pillar trim. Incident was captured on home surveillance camera.

My engine lost power and would not start. It was determined that it needed a new fuel pump. The fuel pump was replaced and the car is starting to lose power again while driving.

See attached document for complaint.

Axle shaft Seal no warning besides loud grinding noise. Electrical issues- causing speakers to not work and the lights coming on and going off. Then it causing the crash detection to not have sound.

No one was in the back seat when this happened. The back passenger door flung open while driving down the road. Immediately pulled off the road and it would not latch! Drove immediately to the dealership and got a loaner. Dealership stated it was the latch and repaired in a day or two.

I don't know the component or system that failed but sometimes when I am parked and put my car into reverse, the brakes lock up but my car will roll backwards. I have to either jam both feet on the brake pedal or quickly shift the car back into park and turn the car off and restart it. This usually will correct the problem. It feels like the brakes are locked and they are really hard to press. I drop kids off at school and this has happened in the parking lot several times with children walking behind me as I am getting ready to leave. I no longer am able to pull in forward to spots and have to back in to avoid reversing with people/cars behind me. I would rather hit a curb then potentially roll into a person or another car. I've taken it to the Lincoln dealership and they were not able to reproduce it or diagnose anything with it. Nothing shows up on their system as an error. It happens infrequently but I've owned the car since Nov 2024 and it's happened at least 10 times. My husband thinks its an electronic issue because it corrects itself when the car is restarted. It also randomly allows me to turn the wheel but the wheel does not turn back to 12. It stays at 3 but drives straight. This also is corrected by turning off the car and restarting. It has also been looked at by the dealership without any fixes.

The vehicle doors lock on their own. Also the keyless entry keypad on the drivers door does not respond so entry cannot be made using that method. This is very dangerous and possibly fatal if one of us were to exit the car let's say to pump gas and all the doors locked with a grandchild still in the car. I have spoken to the Lincoln service department but their response is that they do not know of any such issues. I believe this first happened once or twice last year but it now seems to happen monthly. We have changed the battery in the key fob with no improvment.

The C-pillar trim applique/window division bar has detached on passenger rear side door. The C-pillar trim applique/window division bar is separating from the vehicle on driver rear side door. There is an open recall for this exact problem for 2020-2025 Lincoln Aviators. Despite having the issue on one side and the indication of warning on the other side, I am being told my VIN (for 2020 Lincoln Aviator) is not included in the recall. The separating trim on drives side poses a risk for other drivers if it falls off of the vehicle while driving.

The inside electric push-button switch that opens the door behind the driver was intermittent and is now completely inoperative. The inoperative switch means that anyone in the seat behind the driver must either roll down the window, reach out, and push the outside door button to open the door, or must slide across the rear seat and open the rear door on the right-hand side of the vehicle. The inoperative switch could be extremely dangerous when people must exit the car quickly.

The contact owns a 2020 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

I got an alert on the dash that said tire pressure sensor fault. It is for the passenger side rear tire. I had a dealership look at it and they said the sensor was fine and the battery was fine. They could not find anything wrong with it but it is still alerting. Now my husbands Lincoln MKZ 2017 is doing it as well for the same tire, passenger rear.

On 4/17/25 at approximately 450pm eastern standard time the information hub on the dash indicated a door fault alarm and as i was turning left the doors unlocked and the passenger side door opened causing the passenger to almost fall out of the vehicle. If the passenger would have not had his seat belt on he would have fell out of the vehicle and potentailly been run over. I am worried about driving tbe vehicle as this sitiation could cause serious injury and cause a vehicle accident and loss of life.

I came to a stop a light in a busy intersection. The auto start/stop feature turned off the engine. When the light turned green, the car would not start and put us in danger from traffic approaching from the rear. When trying to start the car with the push button, it made one click and nothing more. The lights and other electrical systems seemed to behave and appear as normal. No warning lights or messages about errors or failures. I turned the car completely off, opened and closed the door to "reset" the car and still would not start. I tried this four times. I then opened the hood, got out of the car (all while at this busy intersection of multiple lanes of traffic, now working their way around me) and checked the battery connection just to be sure. Both positive and negative leads checked solidly connected. I then got back in the car and was able to start the car and move out of the way of traffic. I have not yet had it repeat and have not taken it to a service center yet. Very concerning to be stuck at that busy light with what appears to be a fully functioning car that would not restart after the auto start/stop feature activated.

The contact owns a 2020 Lincoln Aviator. The contact stated while pulling out of a driveway at 5 MPH, the vehicle lost power steering functionality, the tires locked up, and the vehicle veered to the right into rocks and bushes, causing damages to the front passenger's side axle. The message "Steering Assist Fault" was displayed. The contact stated that the Forward Collision Avoidance and other unknown warning lights were illuminated. The vehicle was towed to the residence, where a mobile independent mechanic replaced the front passenger's side axle. Additionally, the mechanic informed the contact that the battery had experienced an electrical shortage, and the battery was replaced. The vehicle was then towed to the dealer, where it was diagnosed that the steering harness and knuckle had failed. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for the VIN to be added in Ford Campaign Number: 20S69. The failure mileage was approximately 96,000.