Kia Sorento 2017 — Problemas relatados

The back hatch will not latch completely and will not reopen, then requires a manual unlatch from the inside.

1. Headlight Failure (Recall Malfunction): Last year, my headlights began intermittently shutting completely off while driving at night, creating an immediate visibility hazard. Kia of Palmdale performed the designated recall repair, but the dangerous defect remains. The headlights still shut off unexpectedly while the vehicle is in motion. 2. Shift Lock Failure: In May 2024, just two months after purchasing the vehicle, the shift lock mechanism failed completely. This intermittently prevented the vehicle from shifting properly out of park, creating an entrapment and stalling hazard. 3. Catastrophic Engine Failure: Last week, the 3.3L V6 engine suffered a sudden, catastrophic mechanical failure while driving. This caused an immediate loss of motive power, putting me and other drivers in severe danger.

The contact owns a 2017 Kia Sorento. The contact had received notification of Kia Voluntary Emissions Service Campaign: SC340 Electronic Control Module (ECM). After the vehicle received the software update, the vehicle started jerking while depressing the accelerator pedal. After the initial failure, the vehicle was taken back to the dealer five times for diagnostic tests. The contact stated that a transmission flush, transmission reset, and other repairs where performed; however, the failure reoccurred. The manufacturer was notified of the failure and the contact was referred to the dealer for additional assistance. The failure mileage was 46,519.

Only 13,245 miles on vehicle warning dash light EBS came on, after Hilltop Ford/ KIA dealer inspection $279.00 recommended fix is replacing “Distance Sensor/Cruise Control Unit” cost for part $4,808.59.

Faulty cameras to allow the AEB and LDWS to work accordingly. Warning lights are on due to faulty system

Check engine light flashing going into limp mode

The contact owns a 2017 Kia Sorento. The contact stated that while the vehicle was stopped and idling, the engine oil warning light illuminated, and the Apple CarPlay, radio, and HVAC system became inoperable. The vehicle was taken to the dealer, and the oil pressure switch was replaced under warranty. The dealer determined that the electrical system had failed due to the oil pressure switch leaking oil onto the wiring harness, and that the wiring harness needed to be replaced. The manufacturer was notified of the failure by phone. The failure mileage was approximately 131,000.

Yesterday our car was making a knocking noise. It lost power temporarily. Upon pressing the gas pedal to the floor we were able to get up to 30 mph. We made it to a repair shop. They looked at it today. The Dip stick showed no oil. The did an oil change and it was down 3 quarts of oil. We just had the oil changed 3 months ago on June 20. No check engine light came on. No warning at all . We were driving on a road with no shoulder, so this was dangerous if the engine were to fail before we got to repair shop. They said we need a new engine and it will cost just under $10,000. It seems that many people are having this exact same problem.

Issue 1: The front passenger airbag sensor is faulty. The ODS light is staying on. I took my car to a Kia dealership and they informed me that the passenger airbag would most likely not deploy in the event of an accident due to the faulty sensor. Kia has had this exact issue with other models and they issued a recall for those other models. This is a huge safety issue. Kia said it would cost me $3000 to fix the issue. Issue 2: My car is painted with the Snow White Pearl color. The paint is peeling and delaminating. This is a widespread defect with this paint color. Kia has not yet issued an extended warranty over this issue even though Hyundai (their sister company)i did extend the warranty for vehicles with this exact issue.

The contact owns a 2017 Kia Sorento. The contact stated that the vehicle had started independently. While the vehicle was in the driveway, the contact became aware that the vehicle had been running for a while. While driving at 45 MPH, the vehicle shut off but restarted independently. While driving 35 MPH, the vehicle stalled. The failure had occurred on several occasions. The vehicle was towed by AAA to the local dealer, where it was determined that the ignition switch was melted. The vehicle failed to turn off as needed. The dealer stated that the failure was a fire hazard. The contact was informed that the wiring harness and the pigtail starter button needed to be replaced. The dealer ordered the part. The failure mileage was approximately 149,000.

In early July, my vehicle's check engine light turned on. I took it to a reputable local mechanic in Sachse, Texas, who had the vehicle for approximately two weeks. He was unable to determine the cause of the issue but informed me that there was an existing recall and that the dealership should be able to address the problem at no cost to me. I then took the vehicle to the Kia dealership. The dealership informed me that there was an extended warranty for the engine and that if their diagnosis determined that the issue was covered under the warranty extension, they would repair it. This is what they texted me: Tech performed Compression test 1 .205psi, 2. 220psi, 3. 260psi, 4. 255psi all cylinders have excessive reading for dry compression test. Tech performed leak down test on all cylinders 1. 21% leak down coming from exhaust side, 2.61% leak down coming from exhaust side, 3. 10% normal, 4. 10% normal. Air leakage from exhaust system defective exhaust valves. Tech performed Cooling system pressure test for 20 minutes with no pressure loss. Ruling out head gasket. Tech evaluated Intake/Exhaust CVVT current and setpoints. Tech determined timing is jumping from back pressure of Clogged Catalyst Converter. Recommending replacing engine due to mileage and exhaust manifold. The dealership's recommended solution was to replace the entire engine. Currently, there is a recall concerning 2017 Kia Sorentos involving engine crankshaft issues. See NHTSA Recall No. 17V586000. I contacted the manufacturer, and they stated that they do not believe my vehicle is covered by the recall. However, I believe the issues identified with my vehicle may be related to the same underlying engine problems addressed by the recall, and I am concerned that the manufacturer is denying coverage rather than properly addressing the issue under the applicable recall or warranty. My engine is experiencing issues that appear similar to those described in the current NHTSA.

The contact owns a 2017 Kia Sorento. The contact stated that the vehicle experienced excessive oil consumption. The vehicle was inspected several times; however, no oil leaks were found. The contact stated that while driving 30 MPH, the vehicle shuddered, and the check engine warning light illuminated and flashed on the instrument panel. The vehicle was taken to an independent mechanic, where it was determined that there was a hole in a valve and a piston was fractured. The vehicle was then towed to a dealer, where the failure was confirmed. The dealer determined that the engine needed to be replaced and the repair was not covered under warranty. The vehicle was not repaired due to the cost. The contact notified the manufacturer via telephone and was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.

Vehicle steers with more resistance to the left but very loose and easy to the right. Dealership diagnosed that a new steering column is required. Kia also issued a new vehicle limited warranty extension on the motor driven power steering. I believe the warranty extension should apply; however, dealer says it does not apply. The warning light required for the extended warrant is not on in my vehicle but there is a clearly diagnosed issue with the electronic steering as indicated in the repair quote.

I am writing to file a formal complaint against Kia America, Inc. regarding the mishandling of a warranty repair dispute for my 2017 Kia Sorento (VIN [XXX]). This complaint documents a pattern of misinformation, unreturned communications, and unprofessional conduct by Kia representatives that has left my vehicle sitting at the dealership for over two weeks without resolution or accommodation. My vehicle was brought to Kia of Nutley for a confirmed MDPS (power steering) motor failure. The dealership quoted approximately $3,400–$3,500 out of pocket to repair it, as the vehicle is outside its standard warranty. I opened Kia Consumer Affairs Case #[XXX] on August 10, 2026 & have since attempted repeatedly to reach a resolution or goodwill consideration, given the age and history of the vehicle. The car has been at the dealership since August 6, 2026 without a loaner or rental accommodation. On August 10, 2026, I spoke with representative Liz, who told me she would send my case number to a supervisor to determine next steps. I have since learned that Liz apparently logged my vehicle's issue as a head gasket problem, rather than the actual power steering failure that is documented & confirmed by the dealership. I also spoke with representatives Kiyah (Total Kia Specialist) & Ivory (Customer Service, California), neither of whom was able to provide consistent or accurate information about my case status. I emailed Michele Cameron, Kia's Executive Director of Consumer Affairs &Warranty Operations, on August 10, 2026. As of this letter, I have received no responseAfter repeated hang-ups & my request for escalation, I received a callback today, August 19, 2026, from a Kia supervisor named Stephanie. Stephanie confirmed that there are two open recalls on my vehicle: Recall SC330, for the multi-function switch, & Recall SC340 (THETA), for a software upgrade. Stephanie stated that someone from the escalation team will reach back out to me within 1–2 Business days. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My kids and I were driving when my engine started making a loud noise. I pulled over and turned it off for a few minutes then I turned it back on. It worked for another mile or so then started making the noise again and died while I was driving at about 55-60 miles an hr. I was able to pull over, put it in park and turned the key off....it wouldn't turn back on and the check engine light came on. When I had someone check it out for me it was about 4 quarts low on oil (it never gave me a warning about the oil and the oil light never came on) and the check engine code was P0024. Oil was added and the camshaft position sensor has been replaced. It starts now but it won't stay on and when it is on it makes a loud screeching sound that isn't coming from the serpentine belt and a loud knocking sound.

Steering wheel airbag failed to inflate

I am writing to escalate an unresolved issue regarding a Voluntary Emissions Service Campaign performed on my vehicle at Bulldog Kia on July 14, 2026. Shortly after leaving the dealership, my Check Engine Light illuminated. An independent mechanic scanned the vehicle and confirmed that the active fault code directly relates to the components/logic altered during the corporate emissions campaign. I have called the dealership multiple times over the last few weeks and left voicemails for two different service representatives, but my calls are being ignored. I also contacted Kia corporate customer service who responded saying that they could not do anything and that I needed to continue contacting the local dealership (Bulldog Kia). From what I understand this could be a safety issue because it prevents me from being alerted to other safety issues that would trigger the check engine light, and there are also ways in which this could potentially cause the vehicle to slow way down or stop running while driving. As noted above the dealer has been unresponsive to my repeated contact attempts and the check engine light remains illuminated.

My high beams and low beams are starting to shut off randomly while driving. They are burning out weekly and having to be replaced. 1 of my tail lights is doing the same exact thing. I replace it. It works for a couple weeks and then goes out. When the headlights shut off my dash shows that i am trying to turn my headlights from auto to another setting, which is not the case. It has happened at night multiple times and that poses a danger because i cant see the road and people cant see my car. I have not had it looked at yet. I do see multiple complaints online for multiple different kia models and years. There is no recall and i do not see a TSB. Just curious with so many issues seen online why anything has not be accomplished or a recall available.

Fuel injectors become unseated randomly causing gas to be sprayed inside engine compartment. Issue can be seen upon request. This issue could cause a fire/explosion as fuel sprays out. The issue was repaired once by an Independent shop, then the issue reoccurred and has now reoccurred again. The issue fails randomly and fully with the symptom being the vehicle not wanting to start.

2017 Kia Sorento 2.4L GDI engine seized due to connecting rod bearing failure confirmed by P1326 diagnostic code multiple times. Vehicle entered limp mode limiting RPMs to 1800-2000 exactly as described in PI1802 campaign. Engine subsequently fully seized. Battery tested 98% healthy ruling out electrical cause. Vehicle towed to [XXX] Kia Avon Indiana. Kia Techline and Consumer Affairs denied PI1802 lifetime warranty claim citing used vehicle reconditioning despite PI1802 explicitly stating coverage applies to both new AND used vehicle owners per official Kia corporate document dated XXX. Consumer Affairs appeal case XXX opened but Kia states no further appeals possible. Kia is wrongfully denying lifetime warranty coverage guaranteed under PI1802 Product Improvement Campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Kia Sorento. The contact stated that while seated inside the vehicle with three other occupants and the engine turned off, there was black smoke quickly coming from underneath the hood. The contact and the passengers exited the vehicle. The contact stated that a fire had started in the engine bay on the passenger’s side of the vehicle and another vehicle was damaged in the fire. The fire was extinguished by the Fire Department. The contact stated that a Police report was filed. The contact believed that the vehicle was destroyed, but the insurance company had not yet deemed the vehicle a total loss. There were no injuries sustained. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 138,000.

My 2017 Sorento has sticky/notchy steering. When trying to move the steering wheel, it initially sticks and requires extra force to get it to provide a steering input. Once it gets past the initial resistance, it jerks the car in the direction you are trying to go which required compensation in the other direction. Upon correction, it jerks the car in the opposite direction causing a continual need to correct the steering wheel to keep the car straight and causing the car to not be able to maintain perfectly straight travel. On large sweeping corners, this problem is even more pronounced and feels dangerous. The sticking issue can be felt while stationary and in motion.I am constantly correcting, left to right to keep it straight. I cannot hold the wheel in one position for any length of time. Went to a KIA dealership and they said it needed the steering rack replaced. Others have reported this issue since the Sorento released this series in 2016 for higher trims (SX, SXL). KIA closed my case without notice. Reopened today. A person on kia Forms had to have there rack replaced at 65k miles to correct issue. Asking for a class action against KIA if they refuse to fix this ongoing safety issue they constantly deny. Dealership said this is not the first time this has been replaced for others. KIA needs to own this RECALL!!!

My 2017 Kia Sorento experienced a catastrophic, sudden engine lockup on the roadway due to a known manufacturing defect involving rod bearing failure. This defect caused complete loss of motive power and stalled the vehicle on the road, creating an extreme safety hazard for myself, my passengers, and surrounding motorists.Prior to the failure, the vehicle heavily consumed its own motor oil at a dangerous rate of nearly 5 quarts every 1,000 miles. I repeatedly attempted to address this with Kia, completing three separate official oil consumption and combustion tests. The vehicle failed all three tests. Despite documented failures of these critical safety components, Kia Corporate and the local dealership, court Kia, issued bad-faith warranty denials. As a direct result, I was forced to drive a dangerously unstable vehicle for 8,148 additional miles until the engine permanently and violently seized on the road.After being towed, the engine was confirmed to be completely locked up. My husband subsequently dropped the engine's oil pan and discovered a pieces of physical rod bearing debris and pieces of a snapped timing chain floating inside. The vehicle had full engine oil at the time of failure, as we were constantly topping it off to counteract the severe consumption defect.Manufacturer and Dealer Misconduct / Safety Cover-Up:The servicing dealer, Regal Kia, and Kia Corporate Case Manager Jennifer (who previously denied the vehicle after the consumption test failures) have actively colluded to falsify safety records to escape their lifetime warranty obligations under the federal engine class action settlement.The dealership deliberately withheld the vehicle's diagnostic trouble codes (specifically camshaft codes triggered when the timing chain snapped), falsely telling Kia Corporate that "no codes" existed. They fabricated a false history, claiming I stated the vehicle "stalled and the oil light flickered" prior to arrival, despite the vehicle being towed in with a p

On XXX, the oil warning light was illuminated in our 2017 Kia Sorento SXL and that the vehicle was leaking oil. We brought the vehicle to an independent repair facility (Tire Kingdom, Cairo, NY) for diagnosis on XXX. The repair facility provided an oral assessment with photographs indicating a suspected rear main seal leak. The engine was dry on the top but excessively wet between the engine and transmission, consistent with a significant oil leak in that area. We were advised that the vehicle could be driven in short intervals of approximately 25 minutes, provided that oil levels were closely monitored and topped off as needed. On XXX, we began driving the vehicle to transport our daughter to a train station 25 minutes away. Halfway through the trip, the vehicle began producing a metallic noise from the engine compartment. We immediately pulled over safely and turned off the engine. After stopping, we discussed next steps and then attempted to restart the vehicle. The engine started but immediately produced a severe mechanical rattling noise. It was shut off within approximately one second of startup. The vehicle was not driven further. The vehicle was then towed to Romeo Kia in [XXX]. Kia performed a diagnostic assessment and determined that the engine required complete replacement, with an estimated repair cost of approximately $10,000. This vehicle previously had a remanufactured engine installed in 2023 following a prior catastrophic engine failure. Between installations, the vehicle was maintained in normal service and was not overdue for scheduled oil changes at the time of this incident (27 days to go). At no point prior to the failure event was there clear indication of immediate catastrophic engine failure beyond the initial oil warning and leak condition. The failure progressed from a diagnosed external oil leak to immediate mechanical failure upon restart, requiring towing and full engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On February 16, 2023, the engine in our 2017 Kia Sorento SXL developed a sudden, loud knocking noise while driving. No dashboard warning lights illuminated at any time, including no oil pressure warning, check engine light, or other engine-related alerts. The vehicle remained fully operable and did not lose power or seize. I continued driving approximately 20 minutes home, including highway speeds up to ~75 mph. The following day, with the knocking noise worsening but still no warning indicators present, I drove approximately 25 minutes to an independent repair facility. The vehicle was then diagnosed with catastrophic engine failure attributed to oil starvation and was towed. Because the vehicle had fewer than 100,000 miles and was within the expected powertrain warranty period, we pursued a warranty review through Kia. Kia requested maintenance records, which we provided in full after gathering documentation from all service providers over a two-week period. Despite this, the warranty claim was denied, first citing gaps in initial records and later questioning oil type based on older receipts that did not explicitly state “synthetic oil.” At Kia’s recommendation, we authorized an oil pan inspection at our expense. Kia concluded that the oil filter appeared to be more than two years old, which conflicted with our documented maintenance history showing multiple oil changes during that period. Kia denied warranty coverage and quoted approximately $10,500 for engine replacement. We were advised that the replacement engine would be a remanufactured unit and that it was on backorder with no estimated delivery timeline. After approximately ten weeks without resolution, we located a compatible replacement engine at another Kia dealership and arranged transport of the vehicle there. The engine was replaced within three days for approximately $9,000. The repair included installation of a replacement engine, new spark plugs, and a passed state inspection.

To Whom It May Concern, I am writing to formally dispute a repair charge and report unacceptable service at Courtesy Kia (Mesa, AZ) regarding my vehicle. Timeline of Events: June 12, 2026: I brought my vehicle to Courtesy Kia for a mandatory software recall. Prior to this appointment, my fuel gauge worked perfectly. Immediately upon picking up the vehicle, the fuel gauge ceased to function. After calling customer service, I brought the vehicle back for inspection. The dealership kept my car for three days. Despite the issue being caused during their previous service, I was denied a loaner vehicle, forcing to come to take the car and use it during the weekend or I can wait until Monday 29 until the service manager back but I asked them I can’t use the car with this error as it’s not safe for me and my kids and that should be fixed by them since that’s their mistake and unfortunately I’ve had paid out-of-pocket for my family's transportation. June 26, 2026 (Diagnostic): The service department initially claimed the issue was a broken fuel pump and quoted me $1,210. I informed them this was impossible, as the fuel pump was completely replaced just 3 months ago. I requested to speak to the service manager, but was told he was unavailable until Monday. And the gentleman Michael who was taking care of my car said let me speak with the technician and back to me again with different quote The diagnosis was suddenly changed to a "fuel sending unit and gasket," with a new quote of $546?? But if I want I can wait until Monday to check with service manager. June 29, 2026: After receiving no follow-up call, I contacted the dealership myself. I spoke with Service Manager Shane Hackelton, who refused to take responsibility for the damage caused during the recall service and insisting that not related to recall software and should be fixed by myself. I look forward to your prompt response and a resolution to this matter.

bought car from carmax. engine knock sensor went bad and engine is knocking. kia states engine is not origional and was taken from a junk yard, both kia and carmax are refusing to fix eventhough I am doing payments and it is a known kia issue for this car. Kia charged me 350$ to run test and cleared the light but informed me my engine is going to blow. carmax is refusing to do anything but still wants us to pay the 9k we owe on the car eventhough its broke.

Following an engine replacement performed at Billion Auto Kia in Rapid City, SD, I began experiencing persistent electrical system failures in my 2017 Kia Sorento. The vehicle alarm would activate randomly without cause, including while I was inside the vehicle with the engine running. Additionally, the door locks would engage spontaneously, trapping me inside the vehicle and preventing me from exiting. The only way to exit was to forcibly pull the door handle, which triggered the alarm. I have video documentation of these incidents. I presented the vehicle to Billion Auto Kia in Rapid City, SD — an authorized Kia dealership with these exact symptoms. The service department was unable to identify a root cause and provided no repair path, returning the vehicle to me unrepaired. 7 months later, Courtesy Kia of Brandon in Brandon, FL, another authorized Kia dealership diagnosed the root cause as a failed Body Control Module (BCM). During the service visit, a Kia dealership technician personally witnessed the alarm activating spontaneously while operating the vehicle, further confirming the defect. The BCM failure was present and active at the time of the prior authorized dealer visit and was not detected. The failed BCM has also caused the gear shifter to become completely stuck, unable to shift out of Park, leaving the vehicle fully inoperable. This vehicle has had 6 recall actions performed since purchase — 4 completed after my purchase in August 2023, and two completed prior to my purchase. Despite this recall history, the vehicle has experienced an engine failure and a BCM failure within less than 3 years of my ownership. Being trapped inside a vehicle with a malfunctioning lock system represents a serious safety hazard, particularly in the event of an accident or emergency requiring rapid exit. I am requesting NHTSA investigate whether a safety defect exists in the Body Control Module of 2017 Kia Sorento vehicles and whether additional recall action is warranted.

While driving on the highway on Mother’s Day weekend with my wife and daughter, the vehicle suddenly lost acceleration and engine power while traveling on a 5-lane beltway. The vehicle would not accelerate and I was unable to maintain normal highway speed. I had to coast to the side of the road with the hazard lights activated because of the safety risk. The vehicle was eventually restarted after being towed to a dealership, but it continued to have severe loss of power and could not safely travel above approximately 45 mph. The suspected failure involves the engine and emissions system. The vehicle has a history of engine-related issues and previously received engine-related repairs. The current engine has developed excessive oil consumption. This condition has resulted in fouled spark plugs and a catalytic converter becoming severely restricted/clogged from oil contamination, causing significant loss of engine performance. A dealership inspected the vehicle and documented the oil-burning complaint and catalytic converter-related fault. The dealership performed diagnostic work, including spark plug replacement, but the problem continued. An independent repair facility also inspected the vehicle and confirmed excessive oil consumption and catalytic converter restriction. The vehicle remains available for inspection. This condition presents a safety concern because the vehicle experienced a sudden loss of power while traveling at highway speeds and was unable to maintain normal traffic speed.

The contact owned a 2017 Kia Sorento. The contact stated that while driving at an undisclosed speed, the contact noticed an abnormal fuel odor, and there was white smoke coming from underneath the hood. The contact was able to safely pull into a driveway, and the contact noticed flames coming out of the hood. The contact stated that the fire caused property damage to the driveway, including debris and burn marks. The entire vehicle was engulfed in fire and deemed destroyed. The fire department extinguished the fire. A fire department incident report was filed. The police arrived at the scene, assisted in directing traffic, but did not file a report. The contact further stated that while attempting to exit the vehicle, the contact's mother fell on the ground. No medical treatment was sought, and no injuries directly related to the vehicle fire were reported. The manufacturer was notified of the failure. The approximate failure mileage was 150,000.

Sunroof/Moonroof After a stop light, while driving at less than 30mph, sunroof/moonroof exploded outwards. There were no surrounding cars in front or beside or in other lane direction. It was not hot or cold out. Evening time. No weather issues. If the fabric shade screen had not been closed all the glass would have fallen all over driver. There was no warning of any kind. Glass just exploded outward into a point like a mountain peak. Then glass started falling inwards into car. Took to dealership, had insurance company evaluate for repairs, insurance approved repairs performed by dealership. Dealership service writers said this has happened on other kia's.

Vehicle has a recurring P0018 fault code (Crankshaft Position - Camshaft Position Correlation Bank 2 Sensor A). Dealer diagnosed loose cam pins on Bank 2 requiring major engine repair. This fault creates a safety risk as improper camshaft timing can cause unexpected engine stalling while driving, resulting in sudden loss of power, power steering, and brake assist. The manufacturer has denied warranty coverage despite the vehicle being within the 10-year/100,000-mile powertrain warranty. This appears to be a known widespread issue on the 3.3L V6 engine. Vehicle has 96,000 miles and is still within warranty coverage period.

I found that he ignition key can be removed from my 2017 Kia Sorento while the transmission is not in the Park position. This is a shift interlock failure. Under FMVSS 114, the key must be trapped in the ignition unless the transmission is confirmed in Park. This defect caused the vehicle to roll down my driveway after my wife & daughter exited the car & were unloading groceries. The vehicle was purchased in April 2026 from a used car dealer lot. The defect was discovered shortly after purchase. No dealer repair has been performed yet. I am contacting Kia Consumer Affairs requesting a goodwill safety repair under FMVSS 114. Component affected: Power Train — Automatic Transmission — Shift Interlock System

While I was driving my 2017 Kia Sorento, the R.P.M suddenly maxed out and then it rapidly went down to zero. My car lost power completely and stopped. There was a burning smell. Now it is dead. There is no clicking sound. Repair place tells me I need a new engine now.

The vehicle's electronic variable valve timing actuator (E-CVVT motor) failed, triggering a severe "Limp Home" engine mode. This defect causes dangerous vehicle surging/jumping during acceleration, limits engine output to 1500 RPM while idling, generates abnormal engine noise, and prevents the vehicle from exceeding 60 mph. This makes merging onto fast-moving highways or maintaining the flow of traffic highly hazardous. The component defect was formally diagnosed at an authorized dealership (Herson’s Kia) on March 30, 2026. The manufacturer, Kia America, was formally notified of this powertrain hazard but has delayed providing a remedy under the PI1802/KSDS warranty extension for over 49 days by demanding unrelated fluid maintenance histories for this non-lubricated electronic component. Because of the manufacturer's procedural obstacles, I am forced to operate an inherently unsafe powertrain configuration for essential transportation.

The car is consuming oil under the 3,000 mile mark.

The car started sticking when driving then a knocking in the engine. Upon investigation/ diagnostics we found that the engine is blown and needs replacing. I have owned this car for 3 years to date and have keep up on all maintenance which you can find on carfax there is no reason at 136,000 an engine should blow. I would like this fixed asap

Incident Details: While traveling on MD-152 (Mountain Road) in Fallston, MD, the vehicle suffered a sudden and complete loss of motive power without any prior warning or dashboard indicators. There were no warning lights, no temperature spikes, and no mechanical noises before the engine seized. This sudden failure occurred in active traffic on a busy road, creating an immediate risk of a rear-end collision. Reason for Denial & Safety Risk: The vehicle is currently at a certified Kia dealership. I am being denied a remedy for this catastrophic engine failure due to "insufficient maintenance records." However, the Kia service department has confirmed in writing that "sludge is not a factor" in this case. Mechanically, the absence of sludge proves the engine was not neglected. Manufacturer Failure: After being denied and exploring other avenues, I have learned that the 2017 Sorento 3.3L V6 is covered under Kia Warranty Extension WTY035 (15 years/180,000 miles) for catastrophic engine failure related to head bolt and gasket defects. By using a lack of paperwork to deny a claim for a "sludge-free" engine, Kia is bypassing its safety obligations for a documented manufacturing flaw. I am reporting this as a dangerous "loss of motive power" defect that mirrors existing Kia engine safety recalls across their product line, and warrants federal oversight.

adaptive cruise control warning lites. In the beginning it started sending warnings after it was on for a while. Now the warning is when I start the car. this has been fixed once under warranty but it is no longer working again. the warning lites for the aeb system is also on. Also I have pearl white sorento and the paint is peeling off the hood.

Upper fuel pump module, on top of fuel tank, is leaking fuel from a crack in fuel pump port where fuel hose connects. Fuel can be seen on top of upper fuel pump module and can be seen leaking from fuel pump port, and can be seen on exterior of gas tank. Also fuel odors were present. This could be a fire hazard. The manufacturer issued TSB FUE 064 for this exact issue for vehicles produced from March 31, 2017 through July 24, 2019. Local dealer will not cover the vehicle because it was manufactured in February of 2017. The vehicle has not been inspected by manufacturer, police, of insurance company. There were no warning lamps, messages prior to failure. The symptoms were fuel on top of module, fuel odor, and fuel stain on exterior side of fuel tank

Timeline of Maintenance & Failure: • October [Year]: I purc Timeline of Maintenance & Failure: • October [Year]: I purchased this vehicle. • February 11, 2026: I performed a full oil service (documented receipt attached). • April 3, 2026: While transporting my two grandsons—one of whom has autism—the vehicle suffered total engine failure while in traffic. • The Safety Defect: Despite the engine running out of oil, the vehicle provided zero warning lights or signals. No "Low Oil Pressure" light or "Check Engine" light ever appeared. This "silent failure" left me stranded in a high-risk traffic situation with a child who has special needs, as I had no warning to pull over safely. • April 8, 2026: The Kia dealership confirmed the engine is seized. Improper Handling of the Claim: The dealership is currently refusing to honor Warranty Extension WTY026 (15-year/150,000-mile Oil Pressure Switch). Their refusal is based on an outdated service sticker in the window that is over 9,000 miles old, while they are ignoring my verified paper receipt from February 11, which proves the vehicle was serviced less than two months ago. The dealership is requesting a full breakdown (teardown) of the engine at my expense to determine the cause. It is my position that requiring a consumer to pay for a mechanical breakdown is an unreasonable barrier to a warranty claim—especially when they have not yet performed non-invasive diagnostic tests, such as a videoscope/borescope inspection, to check for the known oil pressure switch leak covered under WTY026. Significant Safety Concern: The failure of the Oil Pressure Switch (WTY026) to trigger a dashboard warning is a critical safety defect. This failure led directly to a seized engine while I was transporting children. I am requesting that the Department of Transportation investigate this safety-system failure and that Kia Corporate override the dealership’s request for a consumer-funded teardown, given that I have provided proof of maintenanc

The car gets stuck and will not shift out of park. I've had to use the manual override. And when the ambulance came to my house, I could not move my car out of the way fast enough and this delayed emergency response team. I thought it was a one time fluke, but it started happening again this week (4/1/26) Every time I use the car. This cannot be safe.

The contact owned a 2017 Kia Sorento. The contact stated that while her husband was driving at an undisclosed speed, the vehicle hesitated to accelerate as needed. No warning light was illuminated. The contact's husband noticed a cloud of smoke in the rearview mirror, but the contact stated that the smoke was coming from the engine compartment. The contact's husband pulled over, and she, her husband, and daughter all exited the vehicle safely. Before the vehicle was engulfed in flames, the contact checked underneath the hood and discovered a piece of plastic on fire. The contact dialed 911, and police and firefighters arrived on the scene. The firefighters extinguished the fire. The contact was unaware whether a police or fire department report had been filed. The vehicle was towed to a tow yard, and the insurance company was made aware of the fire. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 117,000.

I am submitting a safety complaint regarding a **2017 Kia Sorento SXL** equipped with a **3.3L Lambda V6 engine**, which experienced **sudden and catastrophic engine failure** at approximately **137,000 miles**. Prior to failure, the vehicle exhibited **progressively worsening engine knocking and vibration**, indicating internal engine damage. Despite these warning signs, the failure occurred **abruptly while driving at highway speed**, resulting in a **sudden loss of power**. This incident created an **immediate safety hazard**, as I was traveling in active traffic and was forced to quickly maneuver to avoid surrounding vehicles. The unexpected loss of propulsion significantly increased the risk of a collision. The nature of the failure appears to be consistent with **internal engine component failure (such as connecting rod bearing failure)**, which is not typical for a properly maintained modern engine at this mileage. Importantly, my vehicle was manufactured in **November 2016**, placing it within an early production period for this engine. There is evidence from technical service information and consumer reports suggesting a **pattern of premature internal engine failures** in this engine family, particularly involving **rod bearing wear leading to catastrophic failure**. This raises concern that the issue may represent a **systemic defect** rather than normal wear and tear. I am concerned that other vehicles with this engine may experience similar failures **without sufficient warning**, potentially resulting in dangerous driving situations, especially at highway speeds. I am requesting that NHTSA: • Review this incident as a **potential safety-related defect** • Evaluate whether similar complaints exist involving the **3.3L Kia Lambda V6 engine** • Determine if an **investigation or recall** is warranted I am able to provide supporting documentation, including maintenance records, diagnostic findings, and repair estimates upon request.

The contact owns a 2017 Kia Sorento. The contact stated that while driving at 35 MPH, there was an abnormal knocking sound coming from the engine, and the vehicle lost automotive power. The oil pressure warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with excessive oil consumption. An oil consumption test and combustion cleaning were performed; however, the failure persisted. The vehicle was taken to an independent mechanic, who confirmed the failure. The contact was advised to park the vehicle outside. The manufacturer was not notified of the failure. The failure mileage was 19,000.

On 3-21-26 I noticed the smell of gasoline after driving the vehicle. Upon inspection a noticeable fuel leak from the top of the fuel tank was evident from underneath the vehicle. Further inspection found fuel leakage at the fuel pump outlet line. After online research it was found that other vehicles of this type have hairline cracks on the fuel pump outlet causing fuel to spray out under pressure. Fuel pump assembly replacement has repaired the problem. No indication other than the smell of gasoline was noted at any time. This is a safety hazard that should be addressed ASAP. Part removed has only been inspected by me. Part is available. If I had not been diligent in addressing this problem the consequences could have been catastrophic. The fuel outlet on a high pressure pump should have never been allowed to be made of plastic. People's lives are at risk!