Kia Optima 2004

Had some noise coming from the front of the car, had my mechanic look at it, he said we needed a control arm. When he took off the cover to replace the control arm, he found the sub frame had rotten and was cracking. As I looked online, I saw that KIA had a recall for this issue. When I contacted KIA, their respons…

Door lock/unlock mechanism has failed. Unable to unlock and open door from outside or inside. This defect causes the door to stay locked and unable to open. This can trap people inside of the car if they are unable to crawl out a window or exit from another door. There are many reports of this on Kia forums and genera…

The contact owns a 2004 Kia Optima. The contact stated that after refueling, the vehicle would not start. The vehicle was not taken to a local dealer. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 04V180000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer…

I WAS REPAIRING BRAKELINES, WHILE OBSERVING UNDER CARRIAGE I NOTICED SUSPENSION RUST, FRAME. LOOKED UP RECALLS AND THIS IS ONE. I INCLUDED SCREENSHOT OF PROOG

WHILE DRIVING ON A HIGHWAY WITH CRUISE CONTROL ACTIVE, I WAS UNABLE TO TURN OFF THE CRUISE CONTROL WITH THE STEERING WHEEL CONTROL BUTTONS. THE CANCEL AND SET BUTTONS HAD NO EFFECT WHEN PRESSED. THE CAR REMAINED TRAVELING AT THE SET SPEED. TAPPING ON THE BRAKE PEDAL DID CANCEL THE CRUISE CONTROL.

WHILE STATIONARY - DRIVER'S SIDE DOOR WILL NOT OPEN FROM INSIDE OR OUTSIDE WITH KEY, MANUAL LOCK OR ELECTRONIC LOCK CONTROLS (STUCK CLOSED). UNABLE TO EVACUATE CAR FROM DRIVER'S SIDE. SAFETY CONCERN - LACK OF EGRESS

TL* THE CONTACT OWNED A 2004 KIA OPTIMA. WHILE DRIVING 25 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE FROM THE FRONT. THE PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED STOMACH AND CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT TAKEN TO THE D…

UNABLE TO OPEN PASSENGER DOOR DUE TO DOOR LOCK ACTUATOR STOPPED WORKING. UNSAFE TO DRIVE.

TL* THE CONTACT OWNS A 2004 KIA OPTIMA. WHEN THE VEHICLE WAS TAKEN TO BILL DORATY KIA (2925 MEDINA RD, MEDINA, OH 44256, (330) 721-9500) FOR ROUTINE BRAKE SERVICE, THE TECHNICIAN FOUND A CRACK IN THE FRONT FRAME. THE DEALER STATED THAT THE VEHICLE WAS SAFE TO DRIVE AT THAT TIME. THE CONTACT WAS INFORMED THAT THE FRAME…

DRIVER DOOR DOES NOT OPEN FROM INSIDE NOR FROM OUTSIDE. WHEN UNLOCKING THE DOORS, ALL DOORS WILL OPEN EXCEPT THE DRIVER'S DOOR. CENTER LOCK MECHANISM OR MANUAL USE OF KEYS DOES NOT HELP. THIS IS WITHOUT A DOUBT A SAFETY PROBLEM WHERE DRIVER CAN BE TRAPPED IN THE CAR IN CASE OF EMERGENCY. THIS IS VERY COMMON IN KIA OPT…

CANNOT ADD FUEL BECAUSE THE PUMP STOPS FROM FILLING UP THE TANK. IT TOOK ME ABOUT 7 TIMES TO GET IN $7 WORTH OF GAS. EVEN THOUGH THIS CAR ONLY HAS 25,830 MILES ON IT. IT HAS HARDLY BEEN USED. WE PUT GAS IN ABOUT EVERY 3 OR 4 WEEKS - NOT THAT OFTEN.

TL* THE CONTACT OWNS A 2004 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE FAILED INSPECTION DUE TO SEVERE CORROSION OF THE SUBFRAME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION) AS A POSSIBLE SOLUTION T…