Kia Optima Plug-in 2019 — Problemas relatados

I have a 2019 Kia Optima S with the 2.4L engine and 117,000 miles. The vehicle has diagnostic codes P1326 and POOOB. The check-engine light is continuously flashing, the engine is knocking, and the vehicle has lost acceleration and will not go over approximately 65 mph. I believe this may be related to the KSDS connecting-rod bearing issue under Kia campaign PI1805.

2019 Kia Optima EX, 1.6L turbo, 7-speed dual-clutch transmission. Second owner, purchased August 2019 at Jeff Wyler near Cincinnati, Ohio, not Certified Pre-Owned. Transmission was previously replaced under warranty in my first year of ownership. In spring 2026 I reported rough low-speed shifting. The dealer performed a DCT fluid service and software reset on April 27, 2026, $478.72. That shifting issue was not resolved immediately, but it eventually went away. Kia Consumer Assistance Case #26051125 replied on May 22, 2026 that the dealer was unable to duplicate any issue and the transmission was operating normally. On September 30, 2026, at about 70,000 miles, the transmission failed and the car stopped in the middle of the road in my community. It would not engage first gear and was diagnosed as a mechanical failure of the odd gear fork. No crash, no injury. It was towed to Ourisman Chantilly Kia. Replacement parts were $4,094.67 on October 11, 2026 and labor was $3,180.46 on October 20, 2026, total $7,275.13. Two transmissions have failed by about 70,000 miles. The September odd gear failure may or may not be related to the earlier shifting issue. I am filing this as a defect and safety complaint, not a reimbursement request. I authorize NHTSA to share my contact details with Kia.

Car smelled of what seemed like motor oil while driving. Parked, saw white smoke, and confirmed an engine fire. I was clearly in life threatening danger, especially with a full tank of gas. Fire developed rapidly into a roaring blaze. Entire front of car melted. Car is currently being investigated by manufacturer and cause is unknown. No warning lamps illuminated.

VEHICLE SHUT OFF WHILE DRIVING AT 40MPH, ENGINE SEIZED ,WILL NOT CRANK .SUSPECTED CONECTING ROD BEARING FAILURE UNDER SAFETY RECALL SC200, I CALL KIA 18003334542 DENIED RECALL REPAIR AND BEARING CLEARANCE TEST STATING VEHICLE IS REBUILT TITLE. FEDERAL SAFETY RECALL CANNOT BE DENIED DUE TO REBUILT TITLE PER NHTSA .REQUESTING RECALL REMEDY.

On XXX, Towbin Kia Service (Henderson, NV) officially diagnosed my 2019 Kia Optima (VIN: [XXX], Mileage: 118,325) with a critical component failure: "LOW PRESSURE FUEL PUMP IS LEAKING FROM TOP HAT" (Invoice #XXX). Despite documenting a severe, volatile raw fuel leak that presents an immediate fire and explosion hazard, the dealership refused to keep the vehicle. They explicitly released this active safety hazard back to me. The service department even arranged a third-party Lyft ride to transport my children and me to the dealership to pick up the leaking car and force us to drive it home. The vehicle is currently parked outside my residence, actively leaking raw fuel and filling the cabin with toxic gas fumes. It is entirely un-driveable and a public safety threat. Kia Corporate must immediately bypass standard dealership timelines, authorize a flatbed tow to retrieve this fire hazard, and directly provide an emergency corporate rental vehicle line (Enterprise/Hertz) for my family's safety today. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that NHTSA review this matter because the vehicle experienced a sudden loss of power at highway speeds, followed by a documented “NO PASS BCT” result from the manufacturer’s diagnostic procedure. The vehicle remains an unresolved safety concern. I am also requesting review of whether Kia is properly applying the applicable P1326/BCT engine-replacement procedure and associated coverage to this vehicle. The vehicle and all diagnostic and service paperwork are available for inspection upon request.

On December 26, 2023, this vehicle received a complete engine assembly replacement at an authorized dealership under a manufacturer warranty repair order. Following the engine overhaul, the vehicle developed a severe, raw gasoline smell entering the passenger cabin through the climate control AC vents while sitting at an idle.The vehicle was brought back to Kia Store East on September 10, 2026, specifically to report this volatile safety issue. On September 17, 2026, the dealership technician explicitly duplicated and confirmed the raw fuel odor coming from the engine area in writing. Despite confirming the gasoline smell, the dealership is refusing to perform a manual high-pressure fuel system pressure-drop test to isolate the physical vapor leak. Instead, they have listed a high-pressure Fuel Pipe Assembly (Part # 35305 2GGA0) on a customer-pay estimate paired with an unrelated $1,819.12 timing cover oil seal repair.The dealership is claiming the failure is out of warranty and is holding the vehicle while forcing daily rental car fees onto me, refusing to isolate the active fuel leak unless I authorize the out-of-pocket repair. The vehicle currently sits un-repaired at the dealership as an active cabin fire and occupant chemical exposure hazard that the manufacturer and dealer refuse to properly diagnose or cover under repair workmanship guidelines.

My car was parked when my Kia Optima Panoramic sunroof exploded. It was between 8:00-8:30 a.m. Friday XXX. It sounded like an explosion. I was sleeping and the explosion woke me up. The sunroof was closed and the car was parked. We r not aware of anything coming in contact with the sunroof. Actually the sunroof exploded from inside the car. The broken glass was pointed upwards. I’m concerned that this is a serious hazard if it occurs while I was driving it would have caused a serious accident or even a death. I notified KIA Customer Care Center. XXX Case # XXX. I also sent them a letter concerning the event with photos. I have found information that other reported KIA panoramic sunroof failures and concerned that this may be part of a bigger problem. Customer Care rep [XXX] told me to take the car to a dealer. Cannot see me for 3 weeks and charge $209.99. Called customer care again talked to Risha, told me not to take to dealer and not pay anything. Then wait for someone to get back to me. That was XXX. If I haven’t had any contact from Kia I’m supposed to call back XXX. Still waiting. I am asking NHTSA to document this incident and review whether there is a safety- related defect or pattern involving panoramic sunroofs on KIA vehicles, including the 2019 KIA OPTIMA. Car is 7 years olds an 72,400 mi. The warranty is 5yrs -60,000. Please include this complaint in NHTSA’s records concerning the 2019 Kia Optima and Panoramic sunroof failures. I authorized NHTSA to share my complaint and identifying vehicle information with Kia if that is necessary to investigate the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, my vehicle suddenly began shuddering and shaking. The vehicle lost power and would not accelerate properly. I had to press the brake pedal unusually hard. After parking, the vehicle would not move properly in reverse or drive. I turned the vehicle off and restarted it, and it moved only a short distance before shuddering again and losing power. The engine was making a loud buzzing or scooter-like sound. The vehicle became undrivable and had to be parked. I am concerned about a potential safety defect involving sudden loss of power while driving.

The contact owns a 2019 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle was towed to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 200,000.

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds on two occasions, the vehicle lost power with the check engine warning light illuminated. The vehicle was driven over to the side of the road and then towed to the dealer twice; however, the failure was not duplicated on the first visit. During the second visit, the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 146,000.

Strong smell of gasoline from the rear of the vehicle started around 60,000 miles . Car dealership said it’s normal but I don’t smell other cars like this

Blind spot forward collision detection lane departure warning rear cross traffic warning

Unknown was just driving to go to my husband to work and it came on when I was coming back home and when I went to pick my husband up from work and was stopped at a stop sign the lights came back on

Oil is needing added on a weekly basis to keep up with how much the engine is burning, Spark Plugs and Coils have been changed excessively, the dealership says we may end up being covered by a recall but the engine needs to completely fail first.

The paint on my car is delaminating. There are bubbles throughout the car and a few huge bubbles have popped and now the bare body is visible. I have called Kia corporate and they have denied my request to repaint the car. They are telling me that the is a three-year warranty on the paint. My car is only seven years old, and the paint should not peeling/bubbling. I have taken my car to a collision center, and they believe it is caused by a defective manufacturer paint. After looking online, it is a nationwide chronic problem with snow white pearl. Kia is totally aware of this and doesn't want to address the problem. I do know there are many lawsuits against Kia for this particular problem. I am seeking help to get this resolved. Pictures attached.

I was driving down the highway when I kinda noticed speed changed. ABS lights, foreword collision light, and rear end lights, so I turned around went back home. I rarely drive my car and I never had any problems with it. I purshased it brand new.

I am reporting a recurring safety hazard involving my 2019 Kia Optima following a repair for diagnostic code P064A (Fuel Pump Control Module). Despite the dealership attempting to repair the fuel system, the vehicle remains in a 'limp mode' state. While driving, the vehicle began shaking violently and lost significant power, refusing to accelerate above 50 mph. This creates an immediate safety risk, as the vehicle cannot maintain highway speeds or safely merge, increasing the danger of a rear-end collision. The P064A code and subsequent 'limp mode' symptoms persist even after professional service. I am concerned that the existing Kia warranty extensions (such as WTY028 for the low-pressure fuel pump) or current repair procedures are insufficient to resolve this underlying mechanical/electronic failure, leaving the vehicle unpredictable and hazardous to operate in traffic.

Engine failure, metal leaking into oil which caused engine to fail

The low beam headlight assembly failed on my 2019 Kia Optima LX with no prior warning, while the high beams and LED daytime running lights continue to function normally, indicating an isolated component failure within the assembly. Notably, the headlight assembly shows no physical damage whatsoever, and both independent licensed repair facilities that inspected the vehicle were unable to identify or repair any specific failed component — both independently concluded that a full assembly replacement is necessary. The fact that no specific component could be identified as the cause, combined with the absence of any physical damage, suggests this may be an internal failure not consistent with typical wear and tear. Prior to complete failure, the low beam would intermittently illuminate and then cut off unexpectedly during normal operation, which was the only symptom present before the headlight stopped functioning entirely. This creates a genuine safety concern as low beams are the primary source of nighttime illumination and cannot be substituted with high beams in normal traffic conditions. The failure occurred suddenly during normal nighttime driving and could not be fixed with bulb or pigtail replacement as both were in good condition. The vehicle and component remain available for inspection upon request.

Drove roughly an hour from Roseville MI to Temperance MI. Car was fine. No issues on the drive. Gauges were all fine. Got to my friend’s house and took my stuff inside. Came back out immediately and saw dark smoke now coming from the hood. Attempted to open, but couldn't unlatch the hood after it was popped. Saw flames and called 911. Entire car burned down to the back seats. Car seat, Reading glasses and personal items destroyed. Fire fighters put it out and police took report. KIA after review states they dont know why it happened. Also has taken forever and not offered to compensate me in any way shape or form. Received their “findings” a day ago, April 30. Date of fire was Feb 11th 2026.

The contact owned a 2019 Kia Optima. The contact stated that while her daughter was driving at 60 MPH, she noticed there was smoke emerging from the engine. The driver pulled over safely. but was alerted by a good Samaritan who ran across four lanes of traffic to extinguish the fire with a fire extinguisher to no avail. The fire department was on the scene to eventually extinguish the fire. There were no reported injuries. The vehicle was towed to a towing lot. The local dealer was called, but there was no response. The contact called another local dealer: 4747 S Yale Ave, Tulsa, OK 74135, but there was no answer. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 133,000. The vehicle was deemed a total loss by the insurance company.

Even after regular oil changes car requires an additional 4 bottles of oil every 2 weeks. Now the car is jumping and having a misfire.

The engine of vehicle repeatedly failed, causing the vehicle to stall while driving, which posed a serious risk to my safety and others on the road. The vehicle had approximately 65,000 miles and was maintained routinely and on schedule. The failure first occurred before November 18, 2025, when I reported stalling issues to Kia authorized service & parts. The vehicle was returned as “fixed” on December 12, 2025, but the engine stalled again during normal operation. The vehicle was returned to Kia authorized service & parts multiple times (December 12, December 18, December 23, January 9, January 12, 2026, and March 4, 2026), with repeated assurances that it had been repaired. Each time, the car continued to stall, including during a test drive at Subaru, demonstrating that the failure persisted despite repeated dealer intervention. The stalling created a significant hazard, as the car could lose power while on public roads, including highways, potentially leading to accidents. There were no consistent warning lights or messages prior to the engine stalling; the first symptom was intermittent loss of power while driving. The failure has been reproduced and observed by multiple service personnel at Kia authorized service & parts and by Subaru during the trade-in test drive. The component(s) causing the failure were inspected by Kia authorized service & parts staff, but no effective repair was made. Documentation of repair orders and dealer inspections is available for review.

Our car paint started peeling out of no where and very bad. I just found out that it is a manufacturing issue with the bonding of the paint.

The car had a complete engine failure at 92,000 miles. I was the second owner so this was not covered by any warranties. Well serviced and maintained vehicle.

The vehicle experienced a sudden engine failure one day after undergoing a manufacturer emissions/service campaign at an authorized dealership. Prior to service, the vehicle operated normally with no warning lights, knocking, or drivability issues. After the failure, the dealership denied coverage and declined to inspect the engine oil. The vehicle was towed for an independent inspection, which found metal shavings in the engine oil, indicating internal mechanical engine failure. The sudden failure created a safety risk due to unexpected loss of engine function. The issue has been confirmed by an independent service center and the vehicle remains available for inspection. No warning lamps or symptoms were present prior to the failure.

The paint is bubbling and falling off in spots. This is ruining our trade-in value. The dealer says it always happens to white vehicles.

The contact owns a 2019 Kia Optima. The contact stated that while the vehicle was parked, there was sputtering sound coming from the engine compartment, with the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the vehicle was running rough. The vehicle was taken to the independent mechanic where it was diagnosed with a cylinder misfire and burned spark plug, and that there was oil inside the cylinder and on the spark plug. The contact was informed that the parts needed to be replaced. The vehicle was repaired but the failure reoccurred months later. The vehicle was taken back to the same independent mechanic where it was diagnosed with oil consumption, oil intrusion into the firing chamber, and that another spark plug needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 112,000.

I purchased this vehicle on [XXX], with approximately 170,150 miles. On [XXX], during a routine oil change at approximately 172,636 miles, it was discovered that the engine had no oil present. Shortly afterward, the oil warning light began flickering intermittently while driving. On November 4, 2025, at approximately 175,495 miles, a certified mechanic again confirmed that there was no oil present in the engine. At no point were there visible external oil leaks, indicating excessive internal oil consumption. This condition creates a serious safety risk, as sudden engine failure while driving could lead to loss of power, stalling, or accidents. Based on my experience and publicly known issues involving Kia engines, this appears to be a systemic defect rather than normal wear. I am requesting that NHTSA document and review this issue as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car was affected by emergency theft system locked car down when moving and caused airbags to deploy in which fractured my spine vertebra causing spinal fusion

Paint peeling off hood.

Brought vehicle in for Recall-SC340 Theta II 2.4L GDI ECM S/W Upgrade. After service was performed I took my vehicle back home and noticed that my down shifting was different, jolty and clunky. Prior to the upgrade my vehicle shifted flawlessly. Took my vehicle back in to have them check it out and they told me that they couldn't feel it and that the upgrade wouldn't cause that. Called Kia Corporate and filed a complaint.

I purchased a used 2019 Kia Optima from a dealership in January 2025 with 103,000 miles. 11 months later it's burning oil. Every 2 weeks I have to add a quart of oil. I took it to my mechanic and they found cylinder 4 has been burning oil. They also found a technical service bulletin related to engine oil consumption. They recommended replacing long block assembly. They referred me to a Kia dealership. Currently, my vehicle is at a Kia dealership. They performed a "leak down test" and found cylinder 4 has been burning oil and recommend a long block assembly. I have a 3rd party warranty on my car. They are currently reviewing this claim. If they decide to replace the long block assembly, there will be additional uncovered costs that I feel Kia should be responsible for. I have only put 7,000 miles on this car since I bought it 11 months ago. The car currently has 110,500 miles on it. I understand this is a used vehicle but engines should last 200,000+ miles. I'm trying to figure out my rights. By law isn't the dealership responsible for this oil consumption loss and long block assembly replacement?

The contact owns a 2019 Kia Optima. The contact stated that the catalytic converter was previously replaced. The contact stated that while driving at 60 MPH, two weeks later, the check engine warning light illuminated, and the vehicle started misfiring. The contact drove to the residence. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced. The mechanic related the failure to an unknown engine recall, and the contact was referred to the dealer for assistance. The vehicle was taken to the nearby dealer, where it was diagnosed with engine damage. The dealer acknowledged the unknown engine recall, but the engine was not replaced. The manufacturer was notified of the failure and informed the contact that the part of the engine that was damaged was not covered. The vehicle was not repaired. The failure mileage was approximately 179,000.

Unknown needing help with new purchased car. Bought this car October/2025 with 93k on engine. Already been to dealership i Bought it from to have current issues im dealing with checked out and they only listen to it and said it was injector ticking clatter. Since then ive seen white smoke and the car burning excessive oil. I am adding oil to the car every 2-3 days. Still noticeable smoke and smell of burning oil. No recall on this vin. It seems as if this is a huge problem with this engine. Please help

Engine burners oil at about 1qt per 1000 miles. There is no leak, and no repair to stop the oil from burning quickly. I have to refill my engine with oil several times in between oil changes. Paint is peeling in various spots on my hood and bumper. I first noticed a small area along the border of the hood nearest the windshield (mostly visible from the driers seat). Then 3 more spots on the opposite side of the hood and eventually all over the bumper.

After routine maintenance replacing the valve cover gasket, the low pressure GDI fuel line developed a leak in an area away from where the maintenance had occurred. After a 10 minute drive, the car developed a fire in the engine compartment. Upon investigation by an independent auto mechanic, it was determined that the fuel line had become brittle and developed a crack that had sprayed fuel into the hot surfaces of the engine compartment. This appears similar to the scenario affecting earlier Kia Optima models with the 2.0L Turbo engines. The heat from the fire caused the brakes to start to fail and the amber check engine light to come on within about 5 seconds before smoke was observed coming from the engine compartment. Fortunately, the fire occurred as the vehicle was pulling into the owner's driveway and a fire extinguisher was nearby and used to put out the fire. The vehicle's occupants were able to exit the vehicle with no injuries.

My vehicle is consuming oil excessively. I have to put a whole quart of oil in my vehicle every 2 weeks. I am adamant about getting regular maintenance oil changes as well. My car had to be towed to a local auto shop due to the engine stalling and accelerator not working. They had to replace all 4 coil packs and 4 spark plugs due to dark, tarry oil covering the parts. The repairman told me my engine was at risk of failing, and that the repairs he did would not last without a new engine. I am worried about the car stalling or failing while driving, which puts an accident occurring at greater risk. My complaints resemble symptoms tied to previous Hyundai/Kia engine recalls. I am requesting investigation and manufacturer action related to this issue.

The motor burn oil even after the oil change is done. Also, the car shaking and is not damage to be found.

Red oil light came on along with check engine light took to shop got oil change and they test pressure all is good but oil light and engine light still on replaced oil pressure sensor switch and variable valve solenoid lights still on took to kia dealership they said say thing as first shop replaced oil pressure sensor switch again because they said the aftermarket one doesn't work on my car so bought part from dealer changed it light still on.

I just recently purchased my 2019 Kia optima sx turbo. After purchase, I immediately began experiencing issues with the braking system and the forward collision warning light coming on. The cruise control stopped working as well. I googled and saw that there was a recall on the forward collision warning system but the local Kia dealership to me says there is not one. I almost had a head on collision in this car with my granddaughter coming from daycare as I completely lost brakes. I have put so much money into purchasing this car believing it to be a good car.

I recently had the engine replaced less than a year ago due to an engine recall on this model car, today 11/11/2025 the engine caught fire. We’ve kept up with oil changes on time and I had no alerts in the vehicle on the dash claiming the engine was hot.