Kia Carnival 2022 — Problemas relatados

Driving down the road and the digital instrument cluster went out. Newer Kia carnivals have a recall on this but my 2022 is doing it. I can’t see speed, rpm, blinkers, high beam indicator, gas gauge, notifications or anything

The factory installed Kia 12v battery specification (AGM80L - 80Ah, CCA 800A, RC 155min) was not adequate for the SX Prestige trim-level required (powered liftgate). This created voltage dips over time which required replacement of power liftgate system, blown fuses for infotainment system, numerous “limp mode” occasions. Required 12v battery spec’s per Kia website: 90Ah, CCA 850A. We brought this up with dealership service department and Kia customer care multiple times and were laughed at.

On June 20, 2026, the instrument cluster in my 2022 Kia Carnival became completely inoperative. The failure prevents me from viewing vehicle speed, fuel level, gear position, warning indicators, mileage, and other information normally displayed by the cluster. Because the cluster is the driver's primary source for operating and warning information, I believe the complete loss of the display creates a safety risk while driving. An authorized Kia dealership confirmed the failure on August 17, 2026. The dealer documented the complaint as “cluster inop” and “unable to get miles.” The technician found no diagnostic trouble codes and checked the fuse, wiring harness, and connectors, all of which were documented as OK. The dealership concluded: “CLUSTER INTERNAL ISSUE. REC REPLACE CLUSTER.” The dealer recommended replacement and programming of the complete instrument cluster at a customer-pay cost of $9,783.40. Kia has been notified. Customer Care twice declined assistance based on the vehicle being outside warranty. My concern is that this has been treated only as a warranty matter rather than evaluated as a potential safety-related defect. The precise internal cause is UNKNOWN. The cluster has not been disassembled or subjected to engineering analysis. It has not yet been replaced and remains available for inspection upon request. I request that NHTSA review this failure with any similar complaints, manufacturer communications, warranty claims, field reports, Techline cases, or failed-component data involving 2022 Kia Carnival instrument clusters to determine whether a broader safety-related defect pattern exists. Prior warning lamps, messages, or symptoms before complete failure: UNKNOWN.

The power sliding door actuator motor drive cables on my 2022 Kia Carnival snapped on both the passenger and driver sides. The doors are stuck shut, even in manual mode, creating a safety hazard for passengers since the only way to exit in an accident would be through the rear hatch or the front doors. The Kia dealer said they couldn’t open the doors without removing the interior sliding door panels, which would require damaging them because the doors are stuck shut. There were no warning signs before either cable broke. I have also researched online and it seems many Kia Carnival Owners are having the same sort of issue.

The rear latch on both sliding doors rusts and the buildup prevents the door from closing eventually because the latch mechanism stays up. There is a video on this from a Kia master tech.

The power sliding door on my Kia Carnival has repeatedly failed to reopen when an occupant was caught in the doorway. On multiple occasions, my young child has become trapped by the sliding door after it began closing. Instead of consistently detecting the obstruction and reversing as expected, the door continued to close and pinned my child until an adult intervened. This creates a serious safety hazard because children can become trapped or injured by the power sliding door. The issue has happened several times, making me concerned that the anti-pinch/obstacle detection system is not functioning properly or consistently. The problem appears intermittent but has occurred often enough that I no longer trust the safety feature. The vehicle is available for inspection upon request. I am submitting this complaint because I believe this is a widespread safety defect affecting Kia Carnival sliding doors and understand other owners have reported similar incidents. I am concerned that a child could suffer a serious injury if this defect is not addressed.

The contact owns a 2022 Kia Carnival. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V908000 (Latches/Locks/Linkages, Structure); however, the failure persisted. The contact stated that the rear passenger’s side power sliding door failed to latch securely. The contact used force while pushing the rear passenger’s side sliding door from the outside to latch the sliding door properly. The dealer was made aware of the failure and informed the contact that it was unrelated to the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

SC368 CROSS OVER FUEL PIPE recall incomplete by kia of des moines

I am writing to formally complain about the delay in repairing my vehicle under an active recall involving the fuel system/crossover fuel pump. I have been informed that the required part is on backorder and that the repair may not be available until the end of July. My concern is that I am experiencing strong fuel fumes in and around the vehicle. The odor is severe enough that it is causing headaches, and I do not feel it is safe for me or my children to ride in the vehicle. Given that this recall involves a fuel-related component, I am extremely concerned about both the health effects of continued exposure to the fumes and the potential risk of fire. At this time, I do not believe the vehicle is safe to operate. I am requesting that Kia provide an immediate solution, including one or more of the following: A loaner vehicle until the recall repair can be completed; Rental vehicle reimbursement; Expedited repair assistance; or Any other reasonable accommodation that ensures my family's safety.

Fuel leak at pipe connection between the fuel pipe and fuel rail. Nuts securing the high-pressure crossover fuel pipe to the fuel rail loosened, leaking raw fuel, leading to risk of fire. This has been reported and confirmed by Ron Bouchard Kia, of Lancaster, MA, USA. It is a part of Kia Recall SC368 (NHTSA ID: 26V232). We noticed the vehicle was leaking a substance in April 2025. After receiving recall notice in April 2026, we brought the vehicle in to be check on XXX. We were informed on XXX by phone that our vehicle was affected and fell under this recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2022 Kia Carnival, approximately 80,000 miles, had intermittent dashboard warning lights and grinding brake noise for a few weeks. I brought the vehicle to Tasca Kia White Plains first time on 4/14/26 then again on 5/8/26. The dealership initially could not reproduce the issue, then later suspected an ABS sensor issue and ordered the part. On 5/12/26, before the repair was completed, I was driving downhill with my children in the vehicle when the brakes failed to respond properly. I had to steer off the roadway and go over rocks/boulders to stop the vehicle. At that time, the brakes would not respond normally, and I could not immediately shift the vehicle into Park. Police and towing services were involved. The dealership later replaced an ABS sensor. However, when I reviewed the codes with the service manager, I was told the ABS sensor code did not appear on the date of the brake incident. I was also told that an ABS sensor failure itself would not typically cause hydraulic brake failure. I am concerned that the sensor replacement does not explain the brake failure and that this may involve a brake/ABS/electronic stability control safety issue.

The contact owns a 2022 Kia Carnival. The contact received notification of NHTSA Campaign Number: 26V320000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Engine light turns on every couple months. The Kia either stops accelerating and goes into “limp mode” or gives code for misfiring cylinders. Took to dealership several times, they did nothing but reset battery so light goes off. Unsafe when driving my family around and has turned into an unreliable vehicle. SO frustrating for a new vehicle to have these issues.

I am submitting this complaint regarding the failure of the Kia Connect telematics system and the cessation of critical navigation support for my vehicle. Despite opening a formal support case with Kia (Ticket #25923650), the following issues remain unresolved: Loss of Trip History (Since January 2026): The Trip History feature within the Kia Connect suite has been completely non-functional since January 2026. This prevents the tracking of vehicle usage, mileage, and driving behavior data, which are core features of the paid subscription service. Failure of Connected Routing & Software Obsolescence: The "Connected Routing" feature is no longer operational. Kia support has stated this is due to the vehicle requiring a navigation update; however, Kia has ceased providing all navigation and software updates for this model as of April 2025. Safety Concern: The lack of software support and the failure of "Connected Routing" forces the vehicle to rely on navigation data that is nearly a year out of date. This creates a safety risk when the vehicle provides incorrect guidance on one-way streets, closed roads, or altered traffic patterns. Furthermore, the persistent failure of these telematics services raises serious concerns about the reliability of the vehicle's emergency communication systems, such as Automatic Collision Notification and the SOS Emergency Assistance button, which utilize the same underlying cellular module and software framework. Corrective Action Requested: I am seeking a mandatory software update from Kia that restores full functionality to the Kia Connect suite (specifically Trip History and Connected Routing) or a final navigation map update to ensure the vehicle’s guidance systems remain safe and accurate for the remainder of the service's lifecycle.

My engine smells like fire and fuel my can will not start or do anything. There was smoke coming out of it. The van has had several issues since buying it. Now it’s completely disabled I heard a popping noise as I was driving and then it died and has not started since.

The driver side passenger door will open by itself when the key fob is near. Today it injured me while pumping gas and almost knocked the gas tank door off and gas pump out. I locked my vehicle to go inside to pay for gas. When I came back to my car to open the gas tank door and inserted the gas pump, the sliding door opened and smashed my wrist in between it and the gas tank cover door. It almost knocked the tank door off but I was able to keep fighting it and pushing it back and it closed. I have deep indents in my wrist and it scuffed the gas tank cover. The sliding doors do not stop when someone is going in or out. It is a safety hazard and should function like a garage door. Stop when it senses something there. I almost lost my wrist today!!!

I am unsure as for what is wrong with my car the dealership keeps saying its running rich and there is a recall on several 2022 Kia Carnivals that say it could be a faulty fuel rail tube. They have also said my map sensor is failing. My check engine light appeared a few days ago and has since been cleared and hasn't came back on, however it is just a matter of time. My children ride in this car as it is my daily driver and I have extremely head headaches. The dealership inspected the car and stated it did not smell like fuel however it definitely does.

Fuel door will not open, there is no manual override, vehicle cannot be refueled and since there is no emergency release it caused me to be stranded at a gas station at night with my 4 kids which is a huge safety concern and should be taken seriously as this is a safety and drivability issue that I should not be held responsible to pay for when it is at no fault to me it is a design/system failure.

The dealer is attempting to classify the torn rubber and pulled-out wiring as “non-recall wear and tear,” but the damage is a direct result of: a latch that sticks, a door that does not close smoothly, a malfunctioning power sliding mechanism, and the repeated force required to compensate for the defect. Under recall law, when an unresolved defect causes additional damage, the owner cannot be held financially responsible for the resulting deterioration. This is a mechanical consequence of a defect, not a cosmetic issue.

Vehicle: 2022 Kia Carnival Component: Liftgate — right-side support/strut (shoulder) failure Safety Issue: The right-hand side trunk strut/support has completely broken, causing the liftgate to drop unexpectedly. The trunk will not stay open and can fall abruptly during use. This creates a significant safety hazard for adults and children standing underneath, and while loading/unloading cargo. There was no prior warning or misuse. The failure is structural and sudden. Resulting Risk: Risk of head/neck injury, especially for children or anyone attempting to open or hold the liftgate. The sudden drop makes the rear of the vehicle unsafe to use. Request: Investigation into whether this is a defect affecting other 2022 Kia Carnival vehicles.

In October 23, 2025 I started to notice a fuel smell while I was driving the vehicle. The smell of fuel seemed more strong while I had the air conditioning running.I would shut off the AC and put the windows down. There was no leaks of fuel on the ground or close to the motor. No check engine light or messages was displayed on dash at anytime. My concern was that I’m constantly driving my small children in car seats to and from school, sports, and appointments the smell the fumes will cause headaches or worse car will catch fire were we would need to make a fast exit out the vehicle. So I made an appointment with Kia of Stockton and they scheduled me for 10/29/26 at 9:30am. Kia first diagnosis was undetermined and charged me another $315 just to keep diagnosing on top of there first fee of $315. Kia discovered after removing the foam that protects the fuel rail the leak was coming from fuel injectors and fuel rail. Fuel injector leaking where injector inserts into rail. Repair was needed due to failure of fuel rail housing not sealing properly. Kia also replaced associated components with the fuel rail clips, bolts, flanges, high pressure sensor, foam, and injector wire harness. According to Kia there tech found short in the injector harness.

Frame of drivers side seat broke in half. I weigh under. 200 pounds and am the primary driver of the car

I went to use my vehicle horn when another driver pulled out in front of me and the sound was way off...it sounded like a clown horn. I subsequently took to the Kia dealer where they diagnosed that one of the horns failed and it was replaced under an extended warranty with a deductible payment. The failure of the horn compromised my safety and the other driver's as the other driver may not have heard my warning that my vehicle was where it was. There was no warning that the horn failed until I went to use it.

Left sliding door window (Drivers side) exploded while driving down the highway. Nobody was around us on a sunday afternoon at [XXX]. [XXX] We were on a flat road so no tension. There is no reason for it to have shattered (my daughter was sleeping laid back in the seat) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Dealer says recall sc211 doesn’t apply to this vehicle, however CEL is displaying (once again) with DTC “P0191 Fuel Rail Pressure Sensor Range/Performance”. Kia dealer has does minimal investigation/diagnosis with no resolution.

The Kia Carnival was parked a slight decline and when the button to close the passenger sliding door the door closed rapidly like a guillotine. Thankfully no children or body part were in the path of the door because it would have severely damaged them. After it closed rapidly the door was unable to be opened. The dealership is still working on the Carnival and it has been over 3 weeks and they said they have never seen anything like this since it tore off a bolt in the body frame and caused damage to the body frame and they were unable to open it. Still don't have a timeline for repair. Also concerned it may happen to the other side and the safety issues around it.

When traveling on the highway, the vehicle would not shift into a higher gear limiting the control of the vehicle to accelerate to the flow of traffic. The transmission would not shift for approximately 1/4 of a mile and was stuck at a max speed of ~35 mph and it would not accelerate. This loss of control almost caused an accident and put my family and self at extreme risk. Eventually the vehicle did finally shift gears allowing us to accelerate with the flow of traffic (60mph) This issue with a delay in shifting gears has intermittently happened on prior occasion when accelerating from a full stop, however, this was the first time it happened at an accelerated speed. The vehicle is not safe to operate and was towed to a service center; however, the issue is intermittent and not easily reproducible -- making it even more dangerous as you do not know when it will happen next.

While driving my 2022 Kia Carnival Prestige, the engine started knocking and the vehicle started sounding like it was going to turn off. There was no alert or light on until we got to the service center where the check engine light came on. I took to the nearest dealer with service center for Kia for inspection and repair which the dealer's service center indicated it was an engine failure at 62,203 miles. This failure was hundreds of miles away from my home. I had to return to my state on a rental vehicle. The vehicle remained at the service center for 2 months for engine replacement. Prior to this event, I had serviced the vehicle at my home dealer's service center since I bought it. I performed all maintenance and my home dealer never alerted to an engine trouble before this event. Once I retrieved my vehicle, the vehicle was fine for few weeks and at 66,427 miles the vehicle started having issues with a check engine light on again. I took to my home dealer's service center and after inspection they indicated it was a bad fuel injector. The vehicle became unreliable and unsafe for my regular commute. Once I received the vehicle with the new engine the performance and sound was very different than my old engine had been since I bought the car. I believe the original engine has been faulty since I bought the vehicle.

My front windshield on my 2022 Kia Carnival has shattered in two places from a small hit. I have owned lots of cars and never had a windshield break in two places all the way across. There must be an issue or problem.

The contact owns a 2022 Kia Carnival. The contact stated while driving 50 MPH, the driver's side windshield exterior A-Pillar trim flew off and struck the vehicle behind, almost causing a crash. The contact pulled over to the side of the road temporarily. The vehicle was taken back to the dealer, and the vehicle was inspected. The dealer determined that the trim needed to be replaced; however, the repair was not covered under the bumper-to-bumper warranty. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer. The failure mileage was approximately 22,023.

My car was jerking between 1-2 rpm while driving on the highway, on other roads as well. It was very hard to accelerate and merge with traffic with this issue. Check engine light came on two days later and it’s says it’s the torque converter.

Driver side sliding door closed COMPLETELY on daughter's finger causing significant damage and laceration down to the bone. Required extensive laceration repair.

On [XXX], my kids were getting into the vehicle to go to a playdate. My [XXX] got in the car and into his seat. I was on the driver's side buckling my [XXX] in her car seat and my [XXX] was climbing into the door/her seat on the passenger side. The passenger side sliding door shut on my [XXX] 's hand. I immediately tried to open the door with the button next to the steering column and it would not respond. I then ran around to the other side of the car and used the button on the handle, but the door did not respond to open. I had to manually pull on the handle to force it open off of her hand. No fingers were broken, but the door was shut on her hand completely and she had bruising. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The passenger side sliding door would not respond to any button pushed to open the door. Once I get it manually opened, it will not latch upon closure resulting in a beeping and warning in my dash. I can turn off power doors and manually force it to shut and most of the time that works but this specific incident it was not working. I ensured that there was nothing blocking the door from shutting and finally got it to shut and latch. I drove out of the location I was at and the sliding door flew open at about 20mph.

The sensor on the sliding doors failed to detect that my daughter’s hand was in the way. She hit the button to close the door, carefully was getting herself down, and did not get her tiny hand out of the way in time. The door slid closed and latched on my daughter’s thumb. It was stuck in between the drivers door and the sliding door. Attached you will find a photo of her hand and the instant bruising that it caused. It was not just a finger tip. It was her entire thumb that was stuck. I took her to the emergency dept at Children’s Hospital in Pittsburgh, to where she received X-rays. Thankfully her hand was as not fractured or broken. I posted this in my KIA carnival Facebook group and multiple families said that this is happening to their children as well.

I was driving down the highway, and I heard what sounded like a seal breaking. I thought that someone had put one of the windows down on accident. After pulling up on all the buttons, I determined no window was open. When I got out of the car, the plastic molding on the driver side A pillar had flown off. I don’t know if this would have caused damage to another vehicle. I didn’t know until I was several miles down the road what had caused that sound. It does affect my car in that the wind catches in those holes and will push my car around.

The back tailgate door, when opened, will go up to desired height set in car settings, then slam back down 1/4 to 1/2 of the total height. Turning off auto open and close it continues to do so. When manually pushing the door to the open position, it will continue the problem. We have had numerous incidents of heads being hit by the door, arms and hands have also been hit. We took the car to the dealership and they said the door actuator would be over $2000 to fix. It seems like this is a similar issue to the side door actuators that had to be replaced via recall.

En lo que vade compra me ha dañado 2 baterías las que he tenido que comprar. También daño la bomba de la gasolina. Tuve que pagar la limpieza de las líneas. Casi alrededor de $ 1,000.00 dólares he tenido que pagar de mi bolsillo para un vehículo que lo tengo desde nuevo y que aún pago. También quemó los fusibles y ahora tampoco le funciona la bocina. Es obvio que el problema es eléctrico . Tampoco me han llamado para revisión de las puertas corredizas que no retroceden en muchos de estos vehículos.

While driving spare tired became detached causing vehicle to have major damage to undercarriage. If speed was higher it would have caused a major accident with injury to passengers in vehicle and other vehicles.

air condition system was putting refrigerant into cab over the summer making us sick. We could not tell ,because there was no smell. I was in car with a/c on and got a blast of refrigerant in my face were in I almost pasted out. I turned of a/c and opened windows. My being a retired mechanic helped me to control the situation, but average person probably would have passed out and recked the car. I was treated for exposer to a chemical and my wife was too. I can not tell if a/c is fixed, as there is no smell or visibale way to tell.08

We have been having an acceleration issue for over a year now. The vehicle will be running fine and the randomly not go over 30 MPH. You could have your foot the floor and the vehicle will not shift or go above 3 rpm’s. This has caused us to be in many dangerous scenarios getting onto an interstate. This has almost caused us to be rear ended multiple times. Problem has be reproduced at the dealer and “repaired” though the problem continues to happen. Sometimes the engine warning light is on when it happens, others times it is not and happens with zero warning.

The sliding doors do not reverse like they should. The sensors are not good. Yes Kia added the warning sounds but it isn’t good enough. My LO’s entire hand was shut in the door.