Hyundai Tucson 2005 — Reported problems

Caught on fire. Started under passager floor board. Burnt completely up

I acquired my vehicle as a used car. Although, to my knowledge my vehicle air bags have not deployed, the air bag light is illuminated on my dash panel and this issue is preventing me from obtaining an updated vehicle registration in my state of residence (Delaware). Since the year make and model are listed under the "recall" section of the NHTSA website, specifically for an airbag issue, I am requesting information regarding what nest-steps I nay take to have this problem repaired by Hyundai without any cost to me.

The contact owns a 2005 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front passenger side air bag wiring harness; however, the part was discontinued. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 75,880.

This car accelerates while unattended. Most likely due to an ECM malfunction and unable to properly respond/send signals to the motor. On 4 occasions, the car has accelerated, even if in park. It will go 25mph on its own and to stop I had to put it in neutral. I’ve seen that my car isn’t the only one experiencing this. Considering it’s an ECM issue there should be a recall because that is not a part you change during the life of a car.

ESP off ligh comes on and off have to turn suv off to ture light off Had report it to nhtsa twice but no one replied 2/28/22 # 05V119000 2/14/22 #11454471

The contact owns a 2005 Hyundai Tucson. The contact stated that on several occasions while driving 65 MPH and attempting to accelerate, the RPM failed to raise, and the vehicle failed to respond. No warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 105,000.

Air bag light on dashboard Esp light comes on and off

The contact owns a 2005 Hyundai Tucson. The contact stated while driving 45 MPH, the Electronic Stability Program (ESP) warning light was illuminated. The contact parked on the side of the road and restarted the vehicle. The contact stated that after restarting the vehicle, the warning light disappeared. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 109,000.

Brake light no coming on when brake pedal is being push

INITIAL ISSUES ON VEHICLE PRESENTED IN JANUARY 2021 WITH VARIOUS CHECK ENGINE LIGHT CODES INCLUDING P0133. ALTHOUGH VEHICLE PASSED EMISSIONS IN 2020, VARIOUS CHECK ENGINE CODES FOR MASS AIR FLOW SENSOR, OXYGEN SENSORS, MISFIRE FOR VARIOUS CYLINDERS. AFTER REPLACING INDICATED MASS AIR FLOW SENSOR, OXYGEN SENSORS INDICATED VIA OBD II TOOL, BATTERY, ALTERNATOR (MORE THAN ONCE), BOTH FRONT CV BOOTS, HEAD GASKET SEALS FOR BOTH CYLINDER BANKS, MORE CHECK ENGINE LIGHT ISSUES APPEAR ACCORDING TO THE VEHICLE. CURRENTLY ANOTHER CYLINDER MISFIRE CHECK ENGINE CODE HAS APPEARED AFTER ALL SPARK PLUGS HAVE BEEN REPLACED WITH OEM RECOMMENDED BRAND REPLACEMENTS (NKG PRE-GAPPED SPARK PLUGS). THE MISFIRE CODE HAS CLEARED AT THIS TIME. THE CURRENT CHECK ENGINE CODE FROM THE OBD II TOOL IS ERROR CODE FOR DRIVE TRAIN DRIVEABILITY P0420 REGARDING CATALYST SYSTEM OPERATING BELOW THRESHOLD AT BANK 1. I HAVE UTILIZED LOCAL STORE CATALYTIC CLEANER LIQUIDS TO CLEAN THE SYSTEM, WHICH HAS NOT RESOLVED THIS ISSUE. ADDITIONALLY, BEGINNING IN JANUARY 2021, THE VEHICLE WAS TAKEN TO THE CLOSEST LOCAL DEALSHIP FOR A LARGE MAJORITY OF THESE REPAIRS INCLUDING A $150 DEALERSHIP FEE JUST TO HAVE THESE CODES REVIEWED AND ADDITIONAL FEES FOR THE LABOR TO ADDRESS FOR EACH ISSUE FOR EACH REPAIR.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE WOULD NOT IMMEDIATELY START. ONCE THE VEHICLE WAS STARTED, THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE NOX, PURGE VALVE, FUEL TRIM AND CAMSHAFT SENSORS WERE FAULTY AND NEEDED TO BE REPLACED. THE SENSORS WERE REPLACED HOWEVER, TEN DAYS LATER THE FAILURE RECURRED. LAUREL HYUNDAI LOCATED AT 998 EISENHOWER BLVD, JOHNSTOWN, PA 15904 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.

VEHICLE WILL START MOVING IF ON AN INCLINE WHILE IN PARK. DEALER HAS ADJUSTED SHIFTER CABLE SEVERAL TIMES AND KEEPS RETURNING TO THE BEING ABLE TO PUSH THE CAR WHILE IN PARK CONDITION 9-12 MONTHS LATER. THEIR APPEARS TO BE NO FIX.

DRIVER AIR BAG LIGHT STAY ON WILL NOT TURN OFF HEAD LIGHT SLIVER MELTED

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT TOOK THE VEHICLE TO VISION HYUNDAI WEBSTER (755 RIDGE RD, WEBSTER, NY 14580, (585) 787-2111) FOR AN UNKNOWN NHTSA CAMPAIGN FOR CORROSION ON THE REAR SUBFRAME. THE DEALER TOOK PHOTOS TO SUBMIT TO THE MANUFACTURER FOR REPAIR APPROVAL. THE DEALER INFORMED THE CONTACT THAT THERE WAS AN 80% CHANCE THAT THE SUBFRAME COULD FRACTURE AND THE VEHICLE WOULD BE UNDRIVABLE. THE DEALER OFFERED NO GUARANTEES THAT ANOTHER VEHICLE WOULD BE PROVIDED FOR THE CONTACT IF THE SUBFRAME WAS FRACTURED BEYOND REPAIR AND WOULD CHARGE THE CONTACT FOR FURTHER REPAIRS. THE CONTACT CALLED THE MANUFACTURER AND WAS ASSIGNED A CASE NUMBER AND CASE MANAGER. THE MANUFACTURER HAD NOT CALLED BACK AND THE VEHICLE WAS CURRENTLY UNREPAIRED AT THE CONTACT'S HOME. THE CONTACT CONTINUED TO DRIVE THE VEHICLE AND THE DEALER REFUSED TO PROVIDE A LOANER VEHICLE. THE FAILURE MILEAGE WAS 161,000.

REAR SUBFRAME IS ROTTED. MY 17 YEAR OLD WAS DRIVING ON THE HIGHWAY, SHE LOST CONTROL, IT COULD HAVE BEEN TRAGIC.THE CAR HAS BEEN TOWED AND SITTING IN A PARKING LOT FOR 2 MONTHS AS I CAN NOT FIND THIS PART! MY MECHANIC SAID IT WAS A RECALL WITH THESE CARS.

FRONT RIGHT CONTROL ARM BROKE WHILE DRIVING STRAIGHT AT 40 MPH, CAR SWERVED OFF THE ROAD. CAR HAD TO BE TOWED. MECHANIC STATED IT BROKE DUE TO RUST AND ROT. BOTH FRONT CONTROL ARMS WERE REPLACED. CAR HAS 115K MILES. OTHER COMPLAINTS FOUND FOR SAME ISSUE. APPEARS TO BE NO RECALL FOR THIS. IF TRAVELING ON A HIGHWAY AT HIGHER SPEEDS, IT COULD OF BEEN A MUCH WORSE ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. WHILE DRIVING 65 MPH THE AIR BAG WARNING LIGHT ILLUMINATED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 101,842.

SEVERELY RUSTED REAR SUB-FRAME. NYS INSPECTION STATION ADVISED THE VEHICLE WILL LIKELY NOT PASS THE NYS SAFETY INSPECTION IN 2020.

I WANT TO HAVE A FOUR WHEEL ALIGNMENT SERVICE COMPLETED. THE AUTOMOTIVE TECHNICIAN INVITED ME BACK TO VIEW THE UNDERSIDE OF MY VEHICLE. WHAT I SAW WAS VERY DISTURBING. THE WHOLE REAR LEFT SIDE OF MY VEHICLE IS RUSTED SOMETHING AWFUL. THIS SUBFRAME IS TOTALLY RUSTED THROUGH AND THROUGH. I ALSO RECENTLY HAD TO REPLACE RUSTED OUT LOWER CONTROL ARMS.

WELL TRANMISSION ITS SHAKING WHEN I GO OVER 65MPH AND THIS IS NOT NORMAL.

TL* THE CONTACT OWNED A 2005 HYUNDAI TUCSON. WHILE DRIVING 25 MPH, THE PRECEDING VEHICLE APPLIED THE BRAKES UNEXPECTEDLY, CAUSING THE CONTACT TO REAR END THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE LEFT WRIST AND CHEST PAIN. THE CONTACT WAS TRANSPORTED VIA AMBULANCE TO SEEK MEDICAL ATTENTION. THE CONTACT WAS UNAWARE OF THE INJURIES TO THE OTHER DRIVER. A POLICE REPORT WAS FILED. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO AN IMPOUND LOT. THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 150,942.

HEAD LIGHT INSIDE BOTH SLIVER AREA ARE BURN ?? CAN'T FIND WHAT CAUSES IT NEED HELP PICTURE ATTACHE

MY ESC LIGHT KEEPS COMING ON. I SEE THERE WAS A RECALL ON IT. CAN YOU TELL ME IF AND WHEN THAT RECALL WAS PERFORMED ON MY CAR?

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 184,000. THE VIN WAS INVALID.

CAR TAKES 6 TIMES TO START CAR LOSSES POWER ON EXPRESSWAY ALMOST CAUSING ACCIDENT CODES COME UP AND FIX PROBLEM BUT ISSUE ALWAYS COMES BACK WAS TOLD WIRING PROBLEM SPENT OVER 1000.00 TO FIX THE PROBLEM AND NO MENTION PRICELESS IF NOT SAFE TO DRIVE

HAVE A RECALL ON MY AIR BAGS BUT HAVE NOT RECEIVED ANY NOTICES.

THE FIRST TIME THIS HAPPENED I WAS PULLING INTO A PARKING PLACE IN A SHOPPING CENTER. AS I WAS TURNING INTO THE PARKING PLACE I VERY LIGHTLY TAPPED THE ACCELERATOR AND THE ENGINE REVED UP AND I APPLIED THE BRAKE ONLY TO HAVE THE CAR CONTINUE FORWARD AND GO UP THE CEMENT CURB. I THEN PUSHED DOWN ON THE BRAKE PEDAL AS HARD AS I COULD AND ONLY THEN DID THE CAR STOP. IF THE CEMENT BLOCK HAD NOT BEEN THERE, I WOULD HAVE HIT THE CAR PARKED DIRECTLY IN FRONT OF ME. THE FRONT TIRES HAD GONE ABOUT TWO FEET UP ON THE CEMENT BLOCK. THE NEXT TIME THIS HAPPENED I WAS ONCE AGAIN PARKING. THIS TIME I WAS PARKING PARALLEL TO THE CURB. I PULLED INTO AND IN FRONT OF THE SPACE I WAS GOING TO PARK IN. I PUT THE CAR IN REVERSE AND BEGAN TO BACK UP SLOWLY WITH MY FOOT OVER THE BRAKE PEDAL. SUDDENLY, THE ENGINE REVED UP AND THE CAR LURCHED BACKWARD. THIS TIME I APPLIED THE BRAKE VERY HARD AND I WAS ABLE TO STOP MY CAR BEFORE I HIT CAR IN BACK OF ME.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME AND SUSPENSION WERE SEVERELY RUSTED AND CORRODED. THE OIL PAN, FUEL TANK, FUEL TANK CLAMPS, REAR CHASSIS CRADLE, AND FRONT END SUSPENSION (INCLUDING THE STRUTS, SWAY BARS, SWAY BAR CLAMP, SWAY BUSHINGS) WERE REPLACED BY AN INDEPENDENT MECHANIC. GARBER HYUNDAI (5450 BAY RD, SAGINAW, MI) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE STILL EXPERIENCED FRONT END VIBRATION WHILE DRIVING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 155,000.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. AFTER THE CONTACT RELEASED THE BRAKE PEDAL AND DEPRESSED THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT STATED THAT THE FAILURE ALSO OCCURRED WHILE DRIVING UP A HILL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ALTERNATOR AND SERPENTINE BELT WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE PLANT THAT BUILT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 159,000.

REAR SUBFRAME OF THE CAR IS VERY ROTTEN .

2005 HYUNDAI TUCSON. CONSUMER WRITES IN REGARDS TO STOP LAMP SWITCH ASSEMBLY. *LD THE CONSUMER STATED THE VEHICLE WAS NOT INCLUDED IN THE STOP LAMP RECALL EVEN THOUGH THE VEHICLE EXHIBITED A FAILURE. *JS

ON MY 2005 HYUNDAI TUCSON GLS (94.5K MILES, SINGLE OWNER, GARAGE KEPT AND REGULARLY CAR WASHED), LOWER LEFT CONTROL ARM WAS SO RUSTED (HOLES) TO A POINT THAT IT CAN BE BENT WITH LITTLE PRESSURE WHEN PUSHED AGAINST HARDWARE SURFACE. MY YOUNG ADULT SON WAS DRIVING THE CAR AND IT STARTED PULLING TO SIDE ON LOCAL STATE HIGHWAY. VERY VERY DANGEROUS!! THANK GOD MY KIDS WERE NOT IN A MAJOR CRASH DUE TO THIS. THE LOWER RIGHT CONTROL WAS RUSTED AS WELL TO A POINT IT MAY NEED A REPLACEMENT IN NEXT YEAR OR TWO. REPLACED BOTH LOWER CONTROL ARMS AND BALL JOINTS AT MY EXPENSE AS I FIGURED HYUNDAI WILL NOT COVER THIS. THERE IS JUST SO MUCH AMOUNT OF RUST UNDER THIS CAR THAT IS UNBELIEVABLE. IN APRIL 2018, LOCAL HYUNDAI DEALER VOLUNTARILY REPLACED THE FUEL TANK BANDS (TSB#18-01-015) UNDER A RECALL #952 (NO RECALL NOTICE RECEIVED FROM HYUNDAI) WHEN I WENT FOR AN OIL CHANGE, HOWEVER THEY MADE NO MENTION ABOUT RUSTED LOWER CONTROL ARMS AND OTHER RUST. I FEEL THAT HYUNDAI AND IT'S DEALERS ARE AWARE OF SEVER RUSTING ON 2005 HYUNDAI TUCSON, BUT KEEPING THEIR CUSTOMERS IN DARK AND RISKING THEIR CUSTOMERS LIVES!! BTW, I OWN 2006 HONDA ODYSSEY EX-L WITH 130K MILES HAS SOLID CONTROL ARMS WITH MINIMAL TO NO RUST. I THINK HYUNDAI MAY HAVE USE A LOWER QUALITY AND LOW COST MATERIAL!!

MY AXLE NUTS ARE SERIOUSLY CORRODED, TO THE POINT THEY NO LONGER LOOK LIKE NUTS. I'M VERY CONCERNED THE AXLES MAY SEPARATE FROM THE WHEELS.

3 OUTSIDE AND 3 INSIDE DOOR HANDLES HAVE BROKEN OFF. MOTOR FOR ELECTRONIC WINDOWS [DRIVER, FRONT PASSENGER AND REAR PASSENGER] ALL QUIT WORKING WITHIN A WEEK OF EACH OTHER. AND NO, IT WASN'T FUSES. HEADLIGHT HOUSING, PASSENGER SIDE IS BREAKING INSIDE THE HOUSING.

AIR BAG WARNING LIGHT ON

I HAVE A HYUNDAI THAT HAS A SEVERE SUBFRAME RUST. THE DEALER STATES IT WILL ONLY REPLACE THE PART AND NOTHING MORE. THE SUBFRAME IS SO RUSTED THAT THE PART CANNOT BE ATTACHED. THEY NEED TO REPLACE MORE THAN THE PART ON RECAP TO FIX IT. THEY HAVE HAD MY VEHICLE FOR 3.5 WEEKS OF NOTHING BUT THE RUNAROUND. I NEED YOUR ASSISTANCE TO GET THIS SERIOUS SAFTEY ISSUE FIXED. THERE WILL BE A CRASH IF THEY DON'T FIX IT

BRAKE LIGHT AND BATTERY LIGHT ARE STAYING ON

THERE ARE MULTIPLE RECALLS ON THIS VEHICLE, BUT WHEN I RESEARCHED ON THE NHTSA WEBSITE. IT CLAIMED 0 RECALLS... I'M CONFUSED!!!!! WHEN I RESEARCHED ON ANOTHER SITE IT GAVE ME 4 DIFFERENT RECALLS. AND THIS VEHICLE IS DISPLAYING PROBLEMS THAT DESCRIBES AT LEAST 2 OF THESE RECALLS. BRAKE LIGHTS NOT WORKING. AND ALSO SLIGHT PULL WHEN ACCELERATING. RECALL NUMBERS 05V119000 AND 09V122000. I WAS IN MOTION WHEN ANOTHER DRIVER PULLED ON SIDE OF ME AND INFORMED ME THAT MY BRAKES LIGHTS WERE NOT WORKING. AND I ALSO BELIEVE THAT I AM HAVING PROBLEMS WITH MY ELECTRONIC STABILITY CONTROL.

THE CAR STALLS THEN CUTS OFF WHILE IN MOTION.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. WHILE DRIVING AT AN UNKNOWN SPEED, THE REAR OF THE VEHICLE "FISHTAILED" AND ALMOST CRASHED. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE CROSS MEMBER WAS SEVERELY CORRODED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT TO TOW THE VEHICLE TO A LOCAL DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.