Hyundai Sonata 2021 — Reported problems

My 2021 Hyundai Sonata N Line suffered a catastrophic, sudden total loss of drive power while operating at speed on a public roadway, creating an immediate crash hazard. The vehicle lost forward propulsion and the gear selector flashed a blinking 'R' when reverse was attempted. The vehicle was towed to an authorized dealer, [XXX] Hyundai Southtowne, where their factory GDS tool pulled transmission code P283601 (Shift Fork 'B' Position Circuit). This matches the exact critical safety failure path targeted by Federal Safety Recall 236 (NHTSA Campaign 22V-746) for the 8-speed wet-DCT high-pressure electric oil pump circuit failure. The vehicle previously received the 2022 software patch, but the underlying physical hardware has now actively degraded. The dealership is attempting to deny the federal safety recall remedy based on the vehicle's high mileage. An active corporate consumer affairs investigation has been opened under Case #XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DESCRIPTION OF SAFETY DEFECT & IMMEDIATE HAZARD:My 2021 Hyundai Sonata SEL is currently exhibiting the most severe, catastrophic symptoms of the fuel tank expansion defect covered under NHTSA Campaign 25V796000. The fuel tank has expanded so drastically that it physically warped the structural interior of the cabin, violently popping the rear passenger seat completely out of its assembly while the vehicle was in motion. Furthermore, there is a constant, heavy, raw gasoline odor inside and around the vehicle. The vehicle is a documented, active fire, explosion, and vapor inhalation hazard. It is currently physically located at Sterling Hyundai in Lafayette, LA.DESCRIPTION OF MANUFACTURER NON-COMPLIANCE & REFUSAL TO REMEDY:Hyundai Motor America and Sterling Hyundai are in direct violation of their legal obligation to provide a safe, accessible remedy or interim safety accommodations under federal recall guidelines. An Executive Case Manager from Hyundai Corporate has officially refused to provide a direct-billed rental vehicle or a dealer loaner.Initially, a third-party rental vehicle was provided. However, that vehicle was compromised in an accident and wrecked through absolutely no fault of my own. Despite my lack of fault, Hyundai Corporate and the dealership are now explicitly using that accident to refuse any further direct-billed rental accommodations or dealer loaners.Instead, they are demanding that I pay out-of-pocket for a rental vehicle at a rate of $60/day for a repair process expected to take multiple weeks, knowing I do not possess the upfront financial means to cover these costs. By imposing this insurmountable financial barrier due to an accident I did not cause, Hyundai has effectively stranded me. Because I must maintain my livelihood and have no other means of transportation, Hyundai’s bad-faith refusal to direct-bill an accommodation is actively forcing me to retrieve and operate a verified, explosive fire hazard.REMEDY SOUGHT:I request that the NH

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign: 25V796000 (Fuel System, Gasoline); however, parts were on back order. The contact stated that while driving at an undisclosed speed, the vehicle jerked with an abnormal gasoline odor inside the vehicle. An unknown warning light was temporarily illuminated. Upon further inspection, the contact became aware that the fuel level had dropped. The vehicle was taken to a local dealer where it was diagnosed with an expanded fuel tank. The contact stated that the O2 sensor, spark plugs, and ignition coils were replaced by a local independent mechanic; however, the failures persisted. The contact had headaches while driving the vehicle. Medical attention was not needed. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Transmission replaced twice and all of them continue to fail. Several Hyundai service centers are unable to determine the cause and are only able to update/relearn and replace whenever they are able to replicate the issue. The issue is that at a cold start, the car makes a popping sound, jerks and shakes. The car hesitates to accelerate. You can hear the noise of acceleration but RPM does not go past 3 and MPH doesn't go past 30mph. I'm unable to upload docs because of the upload limit. If there's another way to send docs, please let me know

Massive loss of coolant in closed loop cooling system Heat soak. Fail safe mode

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated and decelerated while the accelerator pedal was depressed. The check engine warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed with an expanded frame due to an expanded fuel tank. The vehicle was deemed too expensive to repair per the local dealer and was towed for a buy-back. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 55,000.

I took my vehicle in for the safety recall due to an expanding fuel tank on 08/03/2026. I received my vehicle back on 8/12/2026. Hyundai performed an improper repair on the vehicle that will not correct the fuel tank expansion. They replaced the same check valve that was replaced last time I brought the vehicle in for recall on 11/20/2024 repair order # 107221 at Jones Hyundai of Belair. This valve did not and will not correct the fuel tank expansion issue. The expansion issue is caused by fuel getting past the check valve and entering the purge control system. The correct repair is to replace the fuel tank and the purge control system, as the check valve has already allowed fuel to bypass it and enter the system causing the expansion issue. . Replacing the valve that failed & allowed fuel into the system & caused the tank to expand will not correct the issue caused by the failed valve. My fuel tank has not decompressed. I still have the same problem I brought the vehicle in for because the repair Hyundai advised NHTSA on was NOT performed.

Gas tank expansion and pcv melted. Car smells like gas when I was driving earlier, and my garage was flooded with the fumes of gasoline.

The Left blinker switch keeps going in and out, working about 50% of the time. Both the light and the blinker sound do not turn on. When getting it checked out at an auto repair shop, the maintenance tech said this was more and more common for 2021 sonatas and it was not due to anything I did. It was a multifunction switch problem.

The contact owns a 2021 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the fuel gauge indicated that the tank was half full. The contact stated that the gauge erroneously indicated that the tank was empty, and the check engine warning light was illuminated. The vehicle was driven to the gas station, and while attempting to refuel the vehicle, the fuel did not go into the tank. The vehicle was towed to the residence. The vehicle was later towed to the dealer, where it was diagnosed with a failed fuel system and a failed fuel tank. The contact was informed that the fuel system and fuel tank needed to be replaced. The vehicle was not repaired. The contact was informed that the failure was associated with the unrepaired recall. The contact was informed that the vehicle was a fire risk. In addition, the contact was informed that there was a hole in the fuel tank that caused the fuel to leak out of the fuel tank. The contact was informed that the parts were ordered to repair the vehicle. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline). The manufacturer was not made aware of the failure. The failure mileage was approximately 50,200.

Going down the road driving the car lost power and went in limp mode with no warnings on the dash at all!

1. Component Failed: Panoramic Sunroof Glass Assembly (Structure / Visibility / Glass). Details: While traveling at highway speed on the freeway, the panoramic sunroof glass spontaneously exploded outward without warning or impact from any foreign object. Inspection: I have not had the vehicle repaired yet so it is currently available. I also took a picture of it. 2. Safety Risk: The sudden, loud explosion (sounding like a gunshot) at freeway speeds caused immediate driver distraction and severe disorientation. Shattered tempered glass was mostly restricted from the cabin by the curtain barrier but some rained down into the passenger cabin. Most blew backward onto the highway, posing a major hazard to occupants as well as trailing motorists. Furthermore, this is a recurring defect in our household: my wife experienced an identical spontaneous sunroof explosion on her 2024 Hyundai Palisade, demonstrating a pattern of hazardous glass failures across multiple late-model Hyundai vehicles. 3. Reproduced or confirmed: I have not had it inspected by anyone. I am awaiting quotes for repairs. I have taken a picture of the vehicle that has not been driven since the incident. 4. Inspection: No one else has inspected it. I have a picture and can take more as needed. Hoping to not have to drive it until I take it to a shop for repairs. It has been reported to a dealership, but they did not seem too concerned or interested in helping. They insisted that they would not give a repair quote until I drove it the 20 miles for them to inspect. 5. Any Warning: No warning. There were no warning lights, abnormal noises, visible cracks, or previous symptoms prior to the sudden explosion. The failure occurred completely spontaneously under normal highway driving conditions.

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The vehicle was taken to the local dealer, and the contact was informed that the fuel tank was swollen and needed to be replaced. The vehicle was not yet repaired. The failure mileage was 80,484.

Engine revving at a complete stop. Surging engine while braking. I was forced to put into neutral when stopping. I had check engine prior that read P049D85. It went away. The Hyundai dealer said to be the EGR valve. Nick Hayes at D'Arcy Hyundai and Hyundai Motor America (HMA) agreeing to a 75% goodwill split of cost to repair.

The panoramic sunroof spontaneously exploded while driving without any external impact

The contact owns a 2021 Hyundai Sonata. The contact stated that while driving 10 MPH and attempting to make a right turn, the brakes independently activated. Neither the dealer nor an independent mechanic was contacted. The check engine warning light was illuminated. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the dealer and an independent mechanic to be diagnosed. The manufacturer was not notified of the failure. The approximate failure mileage was 42,000.

At approximately 130,000 miles, vehicle developed and internal coolant leak caused by a failed Exhaust Heat Recovery System (EHRS) in the center muffler assembly, matching TSB 23-EM-009H - a known manufacturing defect documented by Hyundai. Coolant has been slowly leaking internally into the exhaust system. The authorized Hyundai dealership initially failed to diagnose the internal leak and told me there was no leak and wanted to send me home. After pushing back, the internal leak was confirmed. If not caught, this defect could result in engine overheating or complete engine failure without warning. Hyundai Motor America has denied goodwill coverage despite this being a documented manufacturing defect.

The car will idle high around 1200 rpms. The car will most of the times fix the issue when you turn the car off and back on but it will start again after driving. This is a known issue with the car. I have had the egr valve replaced since it will pop up the codes P240F and P049 for egr slow response and control position exceeded learning limit but the problem came back within two days. I did find a forum that deals with the joint connector repair but this needs to be a recall as I have come across many people who have this problem and paying out of pocket to fix it.

The vehicle has experienced repeated transmission and Electronic Oil Pump (EOP) failures resulting in loss of propulsion, loss of acceleration, and transmission-related malfunctions. The vehicle currently has approximately 69,000 miles. On September 3, 2022, the vehicle lost propulsion while traveling approximately 31 MPH in traffic and would not respond normally to accelerator input. This created a dangerous situation and increased the risk of a collision. On the same date, while backing out of a parking space, the vehicle displayed a "Shifter System Malfunction" warning message and unexpectedly stopped while in reverse. The vehicle had to be powered off before it would operate again. Following these incidents, the vehicle was towed to a Hyundai dealership and the transmission was replaced in September 2022. Despite the transmission replacement, the vehicle continued experiencing issues involving the same system. The Electronic Oil Pump (EOP) was replaced in 2023 and again in 2024 due to recurring transmission-related concerns and diagnostic codes. In 2026, the check engine light returned and the vehicle was again diagnosed with a transmission-related failure. The dealership determined that the transmission requires replacement for a second time despite the previous transmission replacement and two separate EOP replacements. Internally, Hyundai has since revised its repair guidance for this condition, suggesting that prior repair procedures may not have fully addressed the underlying defect. The repeated failures of the transmission and EOP system despite multiple repairs suggest an underlying defect that has not been corrected. These failures create a significant safety risk because the vehicle can unexpectedly lose propulsion or fail to accelerate while operating in traffic. The vehicle is available for inspection upon request.

I took my car to dealer to repair recall. Dealer told me if it failed they would keep car and report stolen if I tried to take it. They failed it. I didn't trust them based on their report it stolen statement. I had the police get my car back. I took it to another dealer where it passed recall easily. I believe they wanted my car for a customer, and tried to get away with this ruse.

The contact owns a 2021 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the engine shuddered and the engine stalled. In addition, the engine seized. No warning lights were illuminated. The contact stated that the vehicle was seized in the middle of the road. The contact stated that while attempting to start the vehicle, the vehicle started. The failure reoccurred. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.

The Exhaust Heat Recovery System (EHRS) has failed for the second time on this vehicle. The first failure occurred at approximately 35,000 miles and was repaired under Hyundai Technical Service Bulletin 23-EM-009H, which Hyundai issued to address this exact defect across 2020-2023 Sonata Hybrid models. The vehicle has now reached 71,000 miles and is experiencing the identical symptoms: coolant loss, overheating, and white exhaust smoke. The EHRS shares a coolant loop with the hybrid battery thermal management system. Coolant loss from this failure puts the hybrid battery and power electronics at risk of overheating, creating a potential fire and safety hazard. The recurring nature of this failure following an official TSB repair suggests the root cause has not been adequately addressed by Hyundai's current repair protocol.

• I experienced trouble with my splash guard being damaged from hanging and scraping the ground about a month after purchasing the vehicle. Also, my hood paint started chipping after a recent cold front experienced in my state earlier this year. Yes it is available for inspection upon request. Regarding the splash guard, not applicable. • It’s was very inconvenient to drive with a portion of my car scraping the ground. I had to be more mindful of my driving in the higher speed limit areas incase the splash guard detached. I had it re-attached multiple times. Regarding the chipped paint, not applicable. • It it counts, for my splash guard, during a servicing, I asked Hyundai to re-attach it. For the chipped paint, no. • The splash guard has during a past servicing. The chipped paint is more recent so it hasn’t • No. Splash guard, a month after purchasing vehicle. The chipped paint, earlier this year, January-February 2026.

I was notified of a recall on my from vehicle by Hyundai via email some time in March of 2026. The message said mentioned my vehicle may have a defective/worn purge control check valve that would cause the fuel tank to deform. Potentially leading to a release of fuel over time, which then could ignite. NHTSA Recall #25V796000 My car showed now signs of problems, but I brought it into a Hyundai dealership on March 13th where they confirmed my vehicle had the issue. They said the situation required I not drive my vehicle and gave me a rental in the meantime. I assumed it would be a simple swap of the fuel tank and everything would be fine. I was offered a buyback from my Hyundai claims manager over the situation, but I figured since its a simple fix, I'd keep my car and have it fixed. Two weeks went by with no update from the dealership, so I walked in for answers. Turns out, the subframe of my car has been damaged by the expanding fuel tank and they are still waiting for updates from Hyundai on how to proceed as they themselves don't know how to fix my vehicle. My Hyundai claims manager did not mention this when we talked over the phone and he offered a buyback. None of their recall notices mention structural damage anywhere or even as a possibility. I asked the dealership again on April 1, 2026, and they are still waiting on guidance on how to proceed. Neither does my Hyundai claims manager handling this situation on their end.

The internal core of the Exhaust Heat Recovery System (EHRS), part of the center muffler/front pipe assembly (#28600-L5210), suffered a catastrophic failure. This allowed approximately 9 gallons of engine coolant to leak directly into the hot exhaust stream. Safety Risk: This failure creates a severe visibility hazard. During acceleration from stop lights and stop signs, the vehicle emits massive, thick clouds of white glycol smoke. The smoke is so dense that it completely obscures the driver's view of trailing vehicles and prevents following drivers from seeing the roadway or my vehicle's brake lights, creating a high risk of rear-end collisions. Additionally, the rapid loss of coolant caused the engine to overheat and lose power while in motion, nearly causing a stall in active traffic. Confirmation: The failure was confirmed by the service department at Washington Hyundai (Invoice #174281). This is the second failure of this specific component (previously failed in Jan 2025). The manufacturer issued TSB 23-EM-009H for this defect, acknowledging it affects 2020-2023 Sonata Hybrids, but no safety recall has been issued. Symptoms: The issue was preceded by a "sweet" burning smell and a sudden "Engine Overheating" warning on the dashboard. The failed component has been replaced by the dealer, but the manufacturer refused to replace the coolant-poisoned Oxygen (O2) sensors, leaving the vehicle in a technically compromised state. The failed unit is likely held by the dealer for warranty parts return.

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that the vehicle was unrepairable, and there was no further information provided. The manufacturer was made aware of the issue, and a case was filed. The manufacturer informed the contact that the field engineers had reviewed the vehicle and advised that a buyback was the best option. Additionally, the manufacturer offered an 8 percent discount on the purchase of a new vehicle. The contact declined the offer because the vehicle had not experienced a failure, and the vehicle would be paid off after two additional payments.

Hyundai technical service bulletin 23-EM-009H (EHRS COOLANT LEAK) - AKA a faulty heat exchange that causes the coolant to leak into the exhaust and burn away. Resulting in a very hard to diagnose coolant disappearance. This should be a recall. They have literally already acknowledged a manufacturer defect with the service bulletin. The problem is that in most cases, it occurs out of the 60k or 100k warranty. The dealer seems to have discretion as to which of the mileage limits apply. One dealer in NC told me 60k and my local in SC told me 100k. My problem started at 90k, but was just topped off on fluid and repaired as "normal evaporation". Now 12k later at 102k, they acknowledged the TSB but claimed I was out of warranty. With me being out of warranty, they claimed that Hyundai would not send them tsb parts and that I would need to replace the whole system with the normal skus around 3k.

P0471 code before 55k miles even after repair is made

The contact owns a 2021 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was driven to the shoulder of the road. The contact stated that the fuel level indicated empty, and the low fuel warning light was illuminated. The passenger seated in the rear seat noticed that the rear seat was out of place and that the seat was very hot. The vehicle was refueled prior to the failure. The contact and the other occupants in the vehicle exited the vehicle. The vehicle was towed to the residence. The dealer was made aware of the failure. The contact was informed that the failure was like the failure listed in NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline). The contact was unaware of the open recall because a recall notification was not received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

On i believe 1/14/26, my check engine light came on. Scheduled appt.for 1/16/26 for diagnostic. Several things were wrong. I decided to come back due to not having the money at the time. Over the wked, I remembered a recall notice i received around November that I asked about in November during my oil change & was told the parts aren't in & they'd give me a call. Upon viewing the recall it seemed some things I was told on 1/16/26 could be a result of the recall. I called my service person Linda on 1/20/26, she spoke to her supervisor & they informed me some of the issues seem to stem from the recall. Linda gave me the manufacturer recall contact information. I contacted them on 1/20/26. She explained there was indeed a recall, there wasn't a remedy yet, it was safe to drive & if something changes, to call back. On 1/28/26 around 5:30am I left home for work & my car all of a sudden experienced a loss of power. It wouldn't go past 30mph. I returned back home & called out of work. I called the manufacturer recall & informed them. She made an appt. to take my car in the follow day, 1/29/26. I decided to drop it off that same day, 1/28/26. I had someone follow me being i could only go 30mph on a flat road & 10mph on a slight hill. I found out my service person Linda was no longer employeed there. I spoke with another employee. He said they would have to do another diagnostic. I left my car. I called the dealership on 1/29/26 for an update, they had not looked at my car. I called the manufacturer recall, they assigned a case manger to my case. Jay from the NCA, called me on 1/30/26 I believe. We've communicated several times without me receiving a adequate update. He's saying the issue seems to be steamed from the recall, there is now remedy yet, & they are still investigating. I've been without a car since 1/28/26, still making payments, missing work, haven't been offered a loaner & have no idea when or if I will get my car back.

The EHRS coolant system failed and had a leak causing the coolant to be excessively burned off as thick white smoke. This caused me to not be able to see anything behind me and forced others to stop or slow down dramatically to avoid colliding with me. I had my engine overheat and force me to pull over on the side of an unsafe road because the exhaust system burned off my entire tank of coolant in less than a mile. I have taken this to a Hyundai dealership and they confirmed it was the EHRS system failure and told me it was a fairly known issue with the 2020-2023 Sonata Hybrids. I was told that even if I get it replaced the possibility of having it happen again are pretty high. This seems extremely unsafe to myself and others.

Vehicle suddenly lost heat in 30 degree weather. No warnings, check engine light, or temperature gauge indicators came on. Lucky made it to a parts store and found out I was extremely low on coolant. Bought coolant and put it in. Made it back to the house and was immediately low again. No visible leaking. Oil was completely fine (1 gallon of coolant would have have left some kind indicator). Realized it was more than likely the ehrs. If this happened during the summer, my engine could have blown due to a poor design causing a major accident.

The contact owns a 2021 Hyundai Sonata. While driving at various speeds, the vehicle unexpectedly shut off without warning. There was an abnormal popping sound coming from the vehicle with an abnormally strong fuel odor inside the vehicle. The contact stated that the vehicle was consuming an excessive amount of fuel. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer and the manufacturer were not notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 70,000.

The contact owns a 2021 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the contact stated that the vehicle was shaking abnormally. The vehicle was taken to the dealer; however, the contact was informed that the part was not available to repair the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part was not available for the recall repair. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 92,000.

Will be driving the car and suddenly hear a beep. Then the dashboard will flash with the ABS light engine light tire pressure light check Blindspot sensors, forward collision sensors. once all the lights appear on the dashboard, I can no longer accelerate. i’ve cleaned the throttlebody. I’ve replaced the gas pedal and it’s still kicking back the same code it still does it the same identical thing. It’s given out on me three times since December with an infant in the car. We are now in February.

I took my car to the dealer on [XXX] with concerns about the strong gas smell that I have been smelling. The Hyundai dealership kept my car for 3 days and stated they could not smell the gas after driving the vehicle themselves. They did repair a cracked cylinder head however they did tell me that it wouldn't have been the cause of the fuel smell. They stated next time I am out driving, and I notice the smell to "pop" into the dealership to have it checked again. While this is good in theory, it is not something I am just able to do. I am [XXX], one of which is still in a car seat and unable to unbuckle themselves to get out if something terrible like a fire was to arise. This was the 2nd time taking my car in, as it was previously fixed in Feb 2025 due to another recall on the gas tank expanding. I do not feel safe transporting my children in a vehicle that is still reeking of gas and a possible hire hazard with no resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Component or system involved and availability for inspection: The issue involves the transmission / drivetrain system. When I entered my VIN on Hyundai’s official dealership website, a safety recall related to the transmission appeared. I took a screenshot of this recall. When I later contacted Hyundai Motor America and spoke with my assigned case manager, I was told that no such recall existed for my VIN. A few days after that call, the recall no longer appeared when checking the VIN online. The vehicle is available for inspection upon request. How safety was put at risk: A transmission-related safety recall presents a risk of loss of power, inability to accelerate, or sudden mechanical failure, which could increase the risk of a crash, especially during normal driving conditions such as merging, accelerating, or driving at highway speeds. The uncertainty and inconsistency regarding whether a safety recall applies to my vehicle has put my safety and the safety of others at risk. Confirmation by dealer or service center: The problem has not been repaired by a dealer, as Hyundai denied that a recall existed despite it previously appearing under my VIN on their official website. Independent service centers that recently serviced the vehicle did not identify or report any transmission warnings or failures. Inspection by manufacturer or others: The vehicle has not been physically inspected by Hyundai for this recall issue. My only interaction with the manufacturer was a phone call + email with a Hyundai case manager, who stated that no recall applied to my VIN. Warning lamps, messages, or prior symptoms: There were no warning lights, messages, or symptoms prior to this issue. The vehicle recently received routine maintenance, including an oil change, tire balancing, and tire rotation, and none of the service providers reported any problems or concerns related to the transmission or overall vehicle condition. I am 34 weeks pregnant with no way to the hospital.

I was driving my 2021 Hyundai Sonata at approximately 3:00 AM when the vehicle suddenly began shaking and vibrating. While stopped at a traffic light, the check engine light illuminated, and the engine was shaking severely. I immediately pulled over and shut off the engine. After waiting approximately one hour, I restarted the vehicle, but it was only able to drive very slowly. The following day, the vehicle was towed to a local repair shop. Diagnostic testing showed a cylinder 3 misfire, along with EVAP system errors and faulty fuel injector issues. This failure occurred without warning and created a potential safety risk while driving. I am concerned this may be related to a defective fuel system.

Engine makes rattling and knocking noises. Transmission hesitates and jerks Suspension front struts and rear shocks are bad. Possible the isolators. Having horrible back pain when riding in car. Starter intermittently doesn't work Lane keep assistance goes over small bump in road will make car drive in opposite lane into on coming traffic. Took car to Tameron hyundai in Birmingham on the 29th of December 2025. Told them everything thats going on with the car. They did nothing about any of the issues. Car has 55,000 miles on it as that is when all problems have incurred. 60000 mile Warranty expires in February of this year.