Hyundai Sonata 2011 — Reported problems

On September 24, 2026, I brought my vehicle to Kelly Hyundai Service Center for two recall repairs: IBU/BCM Anti-Theft Software Upgrade and Decal Application Anti-Theft Ignition Cylinder Protector and Decal Installation My vehicle was at the dealership all day. At the end of the day, I received a call from the technician advising me that the recall work could not be completed due to an electrical issue. When I returned home, I immediately noticed several problems that did not exist prior to the service appointment. Specifically: The high beams no longer worked. The dashboard illumination was not functioning properly. The automatic door lock system stopped working. The trunk could only be opened with the key. I contacted the service center and was informed that the only way they could determine the cause of these issues was for me to bring the vehicle back and pay a $200 diagnostic fee. I explained that I did not believe I should be charged to diagnose problems that appeared immediately after their attempted recall repair. I requested to speak with the service manager, but I was told he was unavailable. I never received a return call from management. On October 1, 2026, I returned to the service center and spoke with the manager. He recommended that I leave the vehicle for further evaluation. I did so, but later that day I received another call stating that the recall still could not be completed and that I would again need to pay a $200 diagnostic fee. I picked up my vehicle because I did not believe I should be responsible for that expense. The problems began only after the dealership attempted the recall repair and that I should not be required to pay diagnostic charges to identify or correct issues that may have been caused during that process.

While driving home and negotiating an ordinary turn onto our residential street, we heard a loud popping sound. We immediately pulled over and discovered that the driver’s-side rear wheel was leaning inward substantially. Upon inspecting the suspension, I discovered that the cylindrical bushing attachment on a rear suspension control arm had fractured, allowing the suspension connection to separate. I subsequently walked back to the location where the noise occurred and recovered the detached metal fragment. The fracture surfaces exhibit distinctly different coloration, suggesting that part of the fracture may have existed for some time before the final separation. Of greater concern, upon inspecting the corresponding suspension component on the passenger side, I discovered a substantial crack along what appears to be the same fracture path as the failed driver’s-side component. Both sides appear to exhibit a common structural weakness. The failure occurred during ordinary driving without a collision or known impact immediately preceding the event. A similar failure at highway speed could cause a serious crash, injury, or death. I understand Hyundai previously conducted rear lower control arm replacement Service Campaign TP3 for certain 2011–2013 Sonata vehicles. I request that NHTSA investigate whether this failure is related to a known defect or represents a broader safety concern. Photographs of the failed driver’s-side component, recovered fragment, and corresponding passenger-side crack are available. The vehicle and recovered fragment are being preserved for further inspection. I request that this incident be reviewed as a potential safety-related structural suspension defect.

My 2011 Hyundai Sonata with the 2.4L Theta II GDI engine developed an engine failure at 99,928 miles. On XXX Hyundai’s dealer (McFarland Hyundai, [XXX]) ran Hyundai’s T3G connecting-rod-bearing test, and the engine returned NO PASS. Hyundai’s own test recorded the oil level as full. This engine family is the subject of Hyundai’s connecting-rod-bearing safety campaigns and its extended engine warranty. Hyundai declined the repair (#XXX) as “exceptional maintenance neglect,” although the oil and filter were changed about 730 miles before the failure, with two more documented oil changes in the prior 16 months. Connecting-rod-bearing failure in this engine can cause engine seizure or stalling while driving, which creates a crash risk. The vehicle is at the dealer and has not been repaired. I am reporting this so NHTSA has a record of a Theta II failure in a vehicle covered by these campaigns that was denied repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The passenger frontal airbag deployed on its own while the vehicle was being driven, with no collision or impact that the driver is aware of. The driver airbag did not deploy. The incident occurred on October 4, 2026, at about 11:14 PM, shortly after the driver refueled at a gas station and was heading toward the highway. The airbag tore open the dashboard panel and cracked the windshield from the inside where the bag struck the glass. The driver brought the vehicle back to the gas station and it was towed. It has not been driven since. Safety risk: The sudden deployment startled the driver and the cracked windshield reduced visibility while the vehicle was moving. Anyone in the passenger seat would have been struck at close range. Recall history: This vehicle received the Recall 174 / NHTSA 18V-137 airbag control unit remedy (ACU main wiring harness installation, part 91700-4R100-QQH) at a Hyundai dealer in September 2025, at about 305,800 miles. The deployment occurred about 13 months and 18,400 miles later, at 324,243 miles. Warning signs: No airbag warning light or other warning appeared before the deployment. The vehicle was serviced at a Hyundai dealer about one month earlier (oil change and multi-point inspection), and no airbag or restraint-system problem was reported. Inspection: The vehicle is at a Hyundai dealer and is available for inspection. We have asked that the airbag control unit, airbag module, and stored crash data be preserved. A case has been opened with Hyundai Motor America. As of this report, the vehicle has not been inspected by the manufacturer, police, or an insurer, and no dealer has confirmed the cause. Cause: UNKNOWN. Our best assessment is an electrical fault in the airbag control unit or its wiring, which received recall work in 2025.

I was driving down the road going the speed limit and all of a sudden it felt like I hit a brick wall my car staked out and I was stuck in the middle of the road for about 20 minutes and finally I got it to start and drove home it did it again 2 months later

I had taken my Sonata to Mike Miller Hyndia in Peoria,I'll and they agreed to do the recall although they had my vehicle for two weeks. They did not service it and when I picked it up they said I had to drive it till the service engine light come on. I was driving it five days later and heard a loud noise and car started malfunctioning I was stuck in a middle of a intersection and I had to push vehicle off road. I broke my right hand in this process and I have also lost my job I am very concerned why they did not service it after they agreed too and sent me off in it in that condition ..The car is currently parked and unsure what to do with it ..

The vehicle suffered an internal connecting rod bearing failure, a known manufacturing defect affecting the Theta II GDI engine. The failure was explicitly diagnosed via the manufacturer - specific OBD-II fault code p1326 Knock Sensor Detector System. This defect causes sudden engine stalling poses an immediate risk of catastrophic engine failure or fire while driving. Hyundai Motor America has denied financial reimbursement for the required engine repair because the work was completed by an independent shop and third-party arbitration deadline (BBB Auto Line) communicated to me. The manufacturer is actively refusing to remedy an acknowledged safety defect.

On the freeway at night when headlights and back lights quit working. Got off freeway and were able to temporarily fix it. A few months later while parked in driveway and not in use for a couple of days, lights came on without our knowledge and drained our battery. Neighbor alerted us to the situation.

Intermittent and sudden loss of power steering nearly caused an accident for both of sons when each one was driving on two separate occasions this past week. "EPS" and traction control warning lights both illuminate on the dash when steering goes out. Sometimes the codes will clear themselves out after restarting the vehicle, but not always. Had it inspected by an independent service center and they cleared out the codes with their scanner. Steering worked fine for a few days afterwards, but then suddenly lost power steering again yesterday. It is very dangerous to drive and it is very unpredictable. I see that there was a recall for this issue for certain manufacture dates for 2011 Hyundai Sonata, but mine was not part of the recall. I believe that it should be part of that recall before someone dies or is injured.

I test drove the vehicle at an auction, watched several other people test drive the vehicle. Before the auction I test drove it one more time and put my obd scan tool on it to make sure there were no hidden codes or problems. I won the bid,and picked up the vehicle. I drove it approximately 6 miles from the auction and the falshing engine light popped on. I immediately pulled over in heavy freeway traffic. Put my scan tool on it and found out the knock sensor had triggered. The vehicle was shaking and making a terrible racket. It was inoperable in the worst possible spot on Highway 51 during rush hour traffic. I managed to slowing coast down the offramp and roll into a parking lot. I then called Purdy Hyundai and spoke with a service advisor and provided the VIN#. He (Vue Kue) informed me that the vehicle qualified for the recall and warranty work based on exactly that issue. I had the vehicle towed to the Purdy dealership on July 8th 2026. I was told today that it was unlikely that Hyundai would honor the recall because I did not have service records of a vehicle I had owned for 6 miles of driving. I filed a complaint with Hyundai corporate. Claim#43010067 and awaiting the reconciliation of this situation. Of which they appear to to be avoiding.

I purchased fgis car from a used car dealership, for over $6,000.00 , which is not a ton of money, but plenty enough to not have instant issues. Since my purchase in june 30, 2026, i have already had all of these issues occur. There is white smoke coming from the left tail pipe, it is sluggish when you push on the gas, there is black soot constantly on my rims that is extreamly hard to remove, the high pressure fuel pump jas failed, I can tell because the oil is higher then it was when o had the oil freshly changed, and it smells of gasoline.inside the oil. The exhaust has stron smell of gasoline. My steering wheel has a loud clinking noise everytime I go over a speed bump on pull into my driveway. Just so many items consistently needing repair or replacement, even though I just had the fuel system cleaned, the oil changed, and filters, and.oil filter too. I checked to see if any of my issues are covered by a recall warranty, because they all are recalled items for my car year, make, and model, but apparently Hyunfai is only covering these dangerous recall items for ul to 10 years. These items shkuld be covered longer, because my carfax states that at least one of these recalled items had already been changed in 2018, and is already broken again!! Hyundai should have covered these extreamly high wear out car parts for a longer period of time, or for the life of the vehicle, if every 5 years your replacing a $1000.00 part, not including labor, like the (HPFP) I was quoted by auto zone for over that price point!! "Ridiculous"! Another item is the air bag cover on the driver side windows area, of the body frame it is loose and keeps un-clipping, i am afraid that it is going to possibly just go off and kill me or something!! Very disappointed right now, that i cannot get any of these recalled items replaced by the manufacturer!!

I was heading to work when suddenly smoke started pouring from the air conditioning vents, and the ABS and traction control warning lights came on. I hit the brakes to pull over, only to realize I had lost braking power. I managed to steer to the side of the road as carefully as possible and bring the car to a stop—despite having no brakes and a fire burning under the hood. I tried downshifting to slow the vehicle, but the transmission didn't respond, and the cabin began filling with smoke. Once I stopped, there was nothing I could do to extinguish the fire, as the car was completely consumed within seconds. It was a fire in the engine bay; I lost the brakes, and the ABS and traction control lights lit up. I assume it was a critical failure in the braking system, most likely involving the ABS module.

Rod bearing issue due to particles in engine causing engine to not accelerate as normal and jerk when goes over 10 MPH can’t exceed 50 miles causing safety issues and knocking/clicking noise took it to Hyundai and was informed it is apart of the recall but wont replace engine my vehicle has ALL the same issues as the Hyundai recall but my VIN isn’t registered on the site for recall on carfax it shows a pattern of the previous owners being car in for maintenance and engine issues but engine never being replace under recall

Once again I am having to replace a bulb for my vehicle. This will be the second time in 3 months I have had to replace my rear blinker bulb. Not including the 4-5 times per year I have to replace headlight bulbs. This time the wiring has melted and the bulb has nearly melted the lens cover. I only buy the exact OEM recommended bulb every time. Nothing fancy. Just the basic old school bulbs. Every year model around mine has been recalled for this exact issue.

Randomly all controls on my steering wheel (I.e. cruise control, volume for sound, Bluetooth phone controls etc) just stopped working. Now I cannot control the radio, phone or even toggle to see mpg, mileage driven, use cruise control etc. I read there was an extended warranty regarding this issue and my vehicle was or is affected. However it has since expired and upon contacting local dealership they did not even have the parts for that recall.

The clock spring went bad causing failure of horn and all buttons on the steering wheel including cruise control. It also caused the airbag light to illuminate.

My 2011 Hyundai Sonata (VIN [XXX] ) was brought to Gateway Hyundai in [XXX] for the mandatory P1326/KSDS engine recall inspection. I had a confirmed appointment on XXX at 7:30 AM. The dealership acknowledged the P1326 code and that the KSDS test was required.Instead of performing the recall, the dealership refused to inspect the vehicle. They contacted a third party who was not in possession of the vehicle and released the vehicle to that person without my authorization. The plates were removed and the vehicle was later sold without my consent. The recall was never performed and the engine defect was never inspected.This is a failure to perform a required safety recall and a violation of chain-of-custody procedures. A vehicle with a known engine failure risk was put back into public circulation without inspection. This creates a safety hazard for the public.I also suffered financial harm including $1,500 in towing, parts, labor, and storage fees. I have a signed tow invoice showing the VIN and the total amount paid.I am requesting that NHTSA investigate Gateway Hyundai’s handling of recall vehicles, review their authorization and release procedures, and take enforcement action if violations are found. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On my 2011 Hyundai Sonata GLS, both rear tail lights have melted to the point that the lightbulbs cannot be extracted and the brake and tail lights no longer work. When I looked into this, I found out this is a common issue on 2011 Hyundai Sonatas. It is almost always caused by excessive heat from the standard incandescent bulbs, which damages the wiring harness and deforms the plastic housing. When I called the closest Hyundai dealer (in Chico, California), they told me the warranty had expired last year and that I should have received a notice about it after I obtained ownership of the car in March 2025 (a little over a year ago). However, I did not receive a notice about this. Since the tail lights do not work properly as a result of this problem, it is a safety issue as it could cause an accident. It should be a recall repair instead of a warranty that expires. My car is still well under the 200,000 mile limit that was set on the extended warranty, but they're refusing to honor that because of the warranty being expired.

My 2013 Hyundai Sonata suffered engine failure consistent with Hyundai Theta II engine defects. The vehicle became inoperable/unsafe. Hyundai denied warranty coverage despite my maintenance records and documentation.

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at 60 MPH, the vehicle lost automotive power. There was no warning light illuminated. The vehicle failed to restart and had to be towed. The vehicle was towed to the dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 190,000.

The vehicle’s airbag warning light is illuminated. The steering wheel also makes a clicking noise, which appears related to an internal clock spring/coil connector failure. This defect may prevent the driver airbag from deploying properly in a crash, creating a serious safety risk. I contacted O’Brien Hyundai of Normal on 4/23/2026 and was denied repair assistance solely due to vehicle mileage. The vehicle has been well maintained, and this issue involves a critical safety component that should not fail under normal use. I am submitting this complaint due to concerns about airbag system failure and occupant safety.

Car is stuck in the drive position and won't change into neutral not park even with pushing the shift lock release button. I turned it off and now it won't even start.

The contact owns a 2011 Hyundai Sonata. The contact stated that the vehicle stalled while driving at various speeds on four occasions. During the first occasion, the vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was diagnosed, and it was determined that the low-pressure fuel pump needed to be replaced. The vehicle was repaired, but approximately a year later, the failure recurred. The vehicle was then towed to an independent mechanic, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired, and the contact was advised to contact a dealer for assistance. The vehicle was then towed to a dealer, where it was diagnosed and it was determined that the high-pressure fuel pump and electrical wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 167,000.

On March 18, 2026 I brought my vehicle to AutoNation Hyundai for an oil change and full diagnostic. Your dealership’s own diagnostic report showed no knock sensor code, no engine issues, and no active warning lights. My car was fully drivable when I dropped it off. Within 30 minutes of picking my vehicle up, the check engine light began blinking and the car became completely undrivable. It has not moved since March 20, 2026 at the dealership. The dealership did an additional diagnostic and found a knock sensor that was not there during the first diagnostics and have stated that my engine has too many miles to be covered uder warranty.

The vehicle suddenly stopped and died while driving. The mechanic confirms that the engine is gone, contact Hyundai. Ourisman of Rockville and Hyundai Motor America (HMA) refuses to replace the engine for free. The vehicle has now developed a severe engine knock consistent with the well-documented defect affecting Hyundai’s Theta II engines. Hyundai has publicly acknowledged this issue and issued a major recall covering approximately 470,000 vehicles with the following specifications: • Model Years: 2011–2012 • Engines: 2.0L and 2.4L • Manufacturing Period: December 11, 2009 – April 12, 2012 Hyundai and federal regulators identified the safety concern as manufacturing debris that could restrict oil flow to rod bearings. This defect can lead to engine knocking and eventual engine failure. Critically, Hyundai has acknowledged that engine failure may stall the vehicle while driving, significantly increasing the risk of a crash. Hyundai’s official remedy for this defect required dealerships to: • Inspect engines for bearing noise • Replace the engine if necessary • Honor Hyundai’s extended engine warranty of 10 years / 120,000 miles for affected vehicles. This issue has also been the subject of significant litigation, including the class action lawsuit Case No. [XXX], filed January 23, 2018, against Hyundai Motor America (HMA), Kia Motors America, Inc. (KMA), Hyundai Motor Company (HMC), and Kia Motors Corporation (KMC). Despite these well-known issues, Ourisman of Rockville failed to disclose any of the following when selling my daughter's this vehicle: 1. The widespread engine defects associated with the 2011 Hyundai Sonata. 2. The recall and safety concerns related to debris restricting oil flow to rod bearings. 3. The extended Hyundai engine warranty covering affected vehicles up to 120,000 miles. This omission is particularly concerning because this defect presents a serious safety hazard and a clear and present danger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2011 Hyundai Sonata. While driving at an undisclosed speed, the vehicle lost power, an alarm sounded for the braking system, and the vehicle went into LIMP Mode and the vehicle failed to exceed 15 MPH. After originally paying out-of-pocket for an ABS module at the dealer and was informed that the engine needed to be repaired and the brakes needed to be replaced. The vehicle was towed to the residence where an independent mechanic repaired the vehicle. There was a recall for the ABS module and the contact returned to the dealer, and the dealer confirmed that the independent mechanic had correctly installed the part. The dealer performed the official recall repair and refused to reimburse the contact for the previous expenses. Three months later, the braking system failed again. The contact stated that the vehicle temporarily returned to normal after a restart, but the failure worsened and required a return trip to the dealer for another repair. In January 2026, the failure recurred for a third time with a loud squealing sound. The dealer was not notified of the third failure. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.

My 2011 Hyundai Sonata experienced sudden engine failure and the engine is now locked up. The vehicle became inoperable and had to be taken to a Hyundai dealership. The dealership confirmed the engine is locked and not drivable. Hyundai denied the engine replacement claim stating the vehicle has A04/A08 branding indicating the engine originates from a scrapped or rebuilt vehicle. However, Hyundai refused to provide any documentation supporting this claim. They also refused to verify the engine serial number against the VIN to confirm whether the engine is original to the vehicle. A NMVTIS vehicle history report shows the title status as ACTIVE with no salvage, junk, or rebuilt branding. Despite this, Hyundai continues to deny the claim without documentation. This vehicle contains the Hyundai Theta II engine that has been the subject of recalls and settlement actions related to premature engine failure. The failure pattern in this case matches the known defect where engines seize or lock up unexpectedly.

The steering column gets loose because of a commonly defective bushing. The steering bangs and has free play making full control more difficult.

My car was broken into and they broke off my door handle and took out ignition parts, a police report was done

My Hyundai Sonata has encounter two failing cylinders (compression loss) due to scoring. When driving in the highway I got engine shudder and loss of power (speed) that could have put me in dangerous driving condition, accident or other. These GDI engines are notorious for poor oil circulation due to faulty designed piston rings. Hyundai has long history with these poorly manufactured engines and class action lawsuits. I notified Hyundai but they are not willing to remedy the situation. I have worked with local dealership Miller Hyundai, as well as corporate. All I get are excuses and that I’m not covered. These engines are completely problematic with oil consumption and oil blow by, causing seizing, rod bearing failure, carbon buildup, cylinder damage, etc. The info on the internet over customers and these GDI engines is overwhelming. Oil related Fires are another issue as well. Hyundai needs more accountability than the class action for rod baring failures. Because of the damage to my pistons, I could have gotten in accident with loss of power on highway…full due to poor piston rings, damage from improper oil flow and near complete engine failure.

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving approximately 65 - 70 MPH, there was a grinding sensation coming from the front wheels, and the grinding sensation was felt in the steering wheel. The vehicle was taken to the dealer, who diagnosed that the rod bearings and hubs had failed, causing the grinding sound. The contact was informed that the rod bearings and hubs needed to be replaced. The vehicle was towed to a certified mechanic, and the vehicle was repaired. The contact stated that while driving at various speeds the following day, there was a loud grinding sound coming from the vehicle. The sound also occurred while the vehicle was parked. While attempting to accelerate from 25 - 35 MPH, the engine started knocking, and the vehicle clunked and jerked. The vehicle decelerated, and the contact pulled over to the side of the road. The contact became aware that the accelerator pedal was not operating as needed. While on the side of the road, the contact turned off the vehicle and attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to a certified mechanic, who diagnosed that the engine had failed, and the mechanic recommended the engine replacement. The vehicle was not repaired. The vehicle was towed to a different dealer, Capital Hyundai of Greensboro (801 E Bessemer Ave, Greensboro, NC 27405), and the contact was informed of NHTSA Campaign Number: 15V568000 (Engine). The vehicle was not repaired because the manufacturer stated that the maintenance history was not satisfactory enough to warrant an engine replacement. The failure mileage was approximately 138,000.

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving approximately 30 MPH, the vehicle unexpectedly lost motive power. There was no warning light illuminated. The vehicle became inoperable and could not be restarted, and the vehicle was towed. The vehicle was towed to a dealer, where it was diagnosed with engine failure. The dealer stated that the failure was related to a previous recall associated with the VIN; however, the recall number was not provided. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The contact was referred to the manufacturer for assistance. The manufacturer was notified of the failure but denied coverage for the repair and alleged that the engine failure was a result of negligence in the maintenance records. The approximate failure mileage was 183,000.

UNKNOWN - I noticed DASHBOARD crack over time and the AIR BAG light remain on at all times. The AIR BAG light on the passenger side shows OFF. The entire dashboard is cracked. I fear that I can no longer drive my car distances due to air bag issue. I did not report the issues to a dealer yet, I was waiting until next oil change time. I do not know the date that it started.

CRUISE controldoesnt work due to design defect dirt getting in and stopping the function.

I am reporting a safety-related engine failure involving my 2011 Hyundai Sonata 2.0T. In November 2025, at approximately 90,000 miles, the vehicle experienced a sudden engine failure while driving, including loss of power and abnormal engine noise. This created an unsafe driving condition and required the vehicle to be removed from service. Component/System Involved: The engine (Theta II 2.0T) suffered a catastrophic internal failure. The engine and internal components remain available for inspection upon request. Safety Risk: The sudden loss of engine power reduced my ability to maintain speed and maneuver in traffic, posing a safety risk to myself and other motorists. Confirmation and Inspection: The failure was confirmed by an authorized Hyundai dealership, which inspected the vehicle and documented the internal valve train condition through photographs. Hyundai Motor America reviewed the claim and issued a written denial. No independent third-party technical inspection was performed. Prior Symptoms: Before the failure, the vehicle had a history of excessive oil consumption requiring frequent monitoring and oil addition despite regular maintenance. Abnormal engine noise was present for approximately one minute before failure. No warning lights adequately predicted the sudden failure. Additional Context: This vehicle is equipped with a Theta II engine, which has been the subject of prior recalls and settlements related to internal engine defects. Hyundai denied warranty coverage alleging “exceptional maintenance neglect”; however, inspection photos show a well maintained valve train with no sludge or oil flow obstruction, only light surface varnish consistent with normal engine aging. I am concerned this failure represents a continuation of a known Theta II engine defect (confirmed by Hyundai technician who performed inspection with OBD code P1326 followed by engine failure) and poses a serious safety risk due to sudden loss of engine power while driving.

The contact owns a 2011 Hyundai Sonata. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended, and the contact noticed a strong fuel odor coming from underneath the hood. Upon inspecting underneath the hood, the contact noticed a leak. An independent mechanic diagnosed the vehicle and determined that the fuel line was leaking. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was contacted, but only the automated system was available. The failure mileage was unknown.

There was no accident .Airbag light on the dash, on the driver side, remains on at all times. The airbag indicator on the passenger side says off. Dashboard has completely cracked, both sides and the center. Unknown incidents- I don’t know of any incidents.

The contact owns a 2011 Hyundai Sonata. The contact stated that while the vehicle was parked, an inspection revealed that the rear frame of the vehicle, located near the passenger’s side, was severely corroded. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The approximate failure mileage was 148,757.

The Vehicle: "I have a 2011–2014 Hyundai Sonata with massive underbody rust." The Failed Fix: "Service Campaign 946 was completed on this car in 2017, but it did not work. The rust is now worse." The Safety Risk: "The structural metal is so rusty that I am afraid it will snap while I am driving. This makes the car unsafe." Hyundai is refusing to fix it because the car has a 'branded' (abandoned) title, even though the structural safety issue is still there."

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated, and the vehicle shut off. The vehicle was taken to the dealer, where it was confirmed that the failure was due to an unrepaired recall. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The repair was performed. The failure reoccurred. The dealer was made aware of the failure; however, the failure was not duplicated. The contact was informed that the recall was closed. The vehicle was taken to an alternate dealer, where it was diagnosed with a failed hydraulic ABS booster sensor. The contact was provided DTC: C1237/HPU. The contact was informed that the hydraulic ABS booster sensor needed to be replaced. The vehicle was repaired. The vehicle was released to the contact; however, the failure reoccurred. The contact stated that the ABS warning light illuminated and then went off. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to take the vehicle for a second inspection. The dealer declined to perform the second inspection. The contact was informed that the repair was not associated with the recall repair. In addition, the contact referenced several unknown recalls; however, the contact was informed that the repair was not related to a recall. The failure mileage was approximately 149,000.

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle experienced a loss of motive power. The contact was able to restart the vehicle; however, an abnormal knocking sound was heard, and there was smoke coming from under the hood. The contact was able to drive the vehicle to a nearby residence, where it temporarily remained. The contact attempted to drive the vehicle a few miles to qualify for towing, per the vehicle insurance provider. The vehicle was towed to a local dealer, where it was diagnosed with a rod bearing failure. The vehicle was not repaired due to insufficient engine oil maintenance records. The contact related the failure to NHTSA Campaign Number: 20V746000 (Engine). The manufacturer was made aware of the failure. The failure mileage was approximately 137,600.

The vehicle experiences a recurring defect where the brake light turns on suddenly and the engine shuts off while driving. The failure appears related to the braking system (brake switch circuit), electrical system (CAN-bus/ECU communication), and engine control (shutdown/stall). The system remains installed and is available for inspection upon request. The shutdown poses a serious safety risk, including possible rear-end collision or loss of power in traffic. The problem has occurred multiple times. The dealership inspected the vehicle briefly but failed to diagnose or document the defect and returned the vehicle within hours, stating “it shouldn’t be a problem,” even though the issue continues. Hyundai has refused to provide recall documentation or authorize a re-inspection. The only warnings prior to shutoff are the sudden activation of the brake warning light just before the engine cuts off.

While driving home from work after 7 PM on the 215 NB freeway, the oil warning light suddenly illuminated, and the vehicle immediately lost engine power. Within seconds, the engine shut off completely, leaving me unable to accelerate or safely maneuver. I was forced to coast across lanes with no power, creating a significant risk of collision and nearly resulting in a rear-end accident. After the incident, I performed a crankshaft rotation test, which the engine failed, confirming that the crankshaft would not turn. I also verified that the timing chain remained intact. The vehicle has since been inspected by Hyundai technicians, who confirmed the engine failure under Service Campaign 953. Hyundai further communicated via email that my vehicle is eligible under the TXXI Theta Engine Settlement Agreement and expressed a willingness to discuss my recent engine concerns and the details of the settlement.