Hyundai Sonata 2009 — Problemas reportados

My 2009 Hyundai Sonata was taken to the Hyundai of Lincolnwood dealership on May 19th. The certified technician formally diagnosed severe structural corrosion on both front and rear subframes (engine cradles), declaring the vehicle completely unsafe to drive. The dealership is withholding the vehicle under safety custody but refuses to provide a loaner or rental car. Hyundai Motor America states the replacement parts are on indefinite backorder with no ETA, leaving me stranded with no safe alternative transportation since May 19th. This severe structural corrosion poses an imminent risk of suspension failure while driving

Passenger seat belt doesn’t click in. Miss fire Poor acceleration Exhaust leak Power lost Mechanic can’t find the problem Check engine light on

Once the car gets slowed down and reaches 20 mph of speed by applying the brake or not. It gives a sudden jerk, which causes immediate reduction in speed.

Brakes seize up while driving and then cannot move the vehicle. This causes a dangerous situation while driving and then breaks lock up and cannot move car even though vehicle is on and then stopped for a stop light. Car must then be turned off and sit for about 30 minutes so it can unseize and when that happens, you can then resume driving and then check engine light comes on. Brake lights were staying on even when vehicle is shut completely off. ABS and ESC lights stay on consistently and never turn off. Vehicle brake switch was replaced at Carolina Hyundai of high point, NC. So break lights have been repaired. They had to order the stop switch lamp replacement for recall as it was never done and will be fixed in next week. 3 door handles fell off and cannot open the rear driver side door at all. Window electric system won’t let windows go up and down and had to make a latch pull string to open driver door. Passenger door will not open at all and no handle and is a dangerous situation. Break switch not being replaced would have cause an electrical fire and is a complete dangerous vehicle even after being inspected less than a week ago

Brake Calipers are getting stuck often damaging the rotors and pads. This happens even for new calipers and rotors that won't last more than one year after replacement. The parts were original from manufacturer. The rear and front brakes were randomly getting stuck on one wheel after a period of using brakes. This put the vehicle in danger of getting fire from overheating rotors or increasing the risk of a crash because of an unusable brake system. This incident has repeated over time from 2017 till 2025 inducing big spendings for fixing brakes

Engine leaking oil from the front cylinder bank’s valve cover or leaking from the valve cover’s gasket onto the alternator. A sufficient amount of oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven with a disabled charging system, the engine can shut off, increasing the risk of a crash.

Oil Leak on Alternator Engine leaking oil from the front cylinder bank’s valve cover or from the valve cover’s gasket onto the alternator. An unknown amount of oil damaged the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven with a disabled charging system, the engine can shut off, increasing the risk of a crash.

The contact owned a 2009 Hyundai Sonata. The contact stated that while his daughter was driving at 45 MPH, the vehicle was turning the corner. It was unknown if any warning lights were illuminated. As a result, the vehicle was T-boned by a vehicle that was turning the corner, then crashed and the vehicle came to a stop at an unknown location. Most of the impact was received from the front passenger side. The other divers speed was unknown. None of the air bags deployed. The contact suffered injuries to the head and the lungs when she impacted the steering wheel. The contact was taken to the hospital by an ambulance. The contact's daughter was in a coma and had brain trauma and a punctured lung. A police report was filed. The vehicle was towed to a tow yard. The other vehicle owner was injured as well, the extent of his injuries was unknown. There was no property damage. The manufacturer was not made aware of the failure. The failure mileage was 140,000.

Excessively cracked dashboard. The entire dash in my 2009 Hyundai Sonata is cracked and a replacement has been denied by Hyundai USA. A cracked dashboard could cause reduced structural integrity. The dashboard is a structural component designed to help absorb and distribute some of the forces in a collision. Cracks can compromise this ability to perform this function potentially increasing the force experienced by the occupants and the and other parts of the vehicle. It can also cause increased risk of debris and shrapnel. During a collision the cracked dashboard may break apart more easily causing sharp or jagged pieces to become projectiles inside of the cabin these fragments can pose a serious injury risk to occupants. It can also result in an impaired airbag deployment. Many vehicles have airbags in the dashboard a severely cracked dashboard could obstruct or improperly deploy airbags for example the air bag may not fully deploy reducing its effectiveness and the dashboard may puncture or otherwise interfere with the airbag as it inflates creating additional safety hazards. Cracks may expose sharp edges or materials under the dashboard which could harm occupants during a collision, especially in areas where passengers may come into contact with the dashboard. A cracked dashboard could also cause a compromised electrical system dashboards house numerous electrical systems, sensors and controls cracks could indicate underlying damage to these components. In a collision these systems may fail or behave unpredictably which could further reduce safety features. Cracked dashboards present a significant risk during a collision and should be addressed by the manufacturer promptly to ensure its customer safety.

The contact owns a 2009 Hyundai Sonata. The contact stated while driving approximately 30 MPH, the steering wheel suddenly became stiff and failed to turn in either direction. No warning light was illuminated. The contact stated that an appointment was scheduled with the dealer to inspect the vehicle. The vehicle was not yet diagnosed or repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 10V426000 (Steering); however, the VIN was not included. The manufacturer was notified of the failure. The failure mileage was approximately 151,000.

5/18/24 in the afternoon, driving the car on freeway. the car lost power. AC stopped. Heat and check engine lights came on. Pulled car to shoulder. Driver’s window was foggy. Smoke coming from front. Exited the car. Flames seen underneath front of car and passenger compartment. Smoke worsened and within minutes 10 foot high flames engulfed the car. Fire department had to extinguish the flames. And California Highway Patrol blocked off several lanes. The vehicle totally was incinerated. I filed a police report number 240518LA2144. I do not have the report yet. It is not ready. It was filed with the California highway patrol.

Vehicle sat in driveway for one week while on cruise. The day of return the sonata caught on fire without any person touching the car for one week. Brother who’s house it was at was woken by neighbors at 7sm. Home had minor damage, but it could of been bad if it was in someone’s garage. Fire started in engine and console. Fire department could not find out a reason. Car was totaled. Had to rent a car to get home that was 2 hours away. Never had an issue with this vehicle in the 12 years I owned it.

The contact owns a 2009 Hyundai Sonata. The contact stated that while her daughter was driving 60 MPH, the vehicle lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. After calling AAA, the technician determined the vehicle had run out of gasoline however, the instrument panel was reading a half tank. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the instrument panel. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 184,500.

I see that the manufacturer has an "Open Service Campaign" on their Sonata's shark fins. I've taken mine to the local dealership and they want a min. $700 to replace the shark fin. It just came off somewhere (a couple of years ago) and, now, my car has to be jumped off if I let it sit more than two days. I have had it inspected by the dealer and an individual garage. No one would tell me what was draining my battery. I am a senior citizen and fear I will get stranded on the road somewhere. The missing fin lets water into my car, soaking the carpets, etc. Finally, it was suggested that the car cover I keep on it touches the exposed fin components and that's what was draining my battery. It seems that the manufacturer was aware enough of this faulty part to want to prevent complaints by voluntarily replacing problematic parts (thus the service campaign). And, there are a lot of videos on YouTube from DIY folks who've suffered through replacing the shark fins (many different models) themselves. It seems, however, the manufacturer only notified dealers with said "open service campaign," not the public, as in a proper Recall process. That way, they get to make more money off the public when the part falls off? Please advise how one might get the dealers to do the right thing. Thank you.

The contact owns a 2009 Hyundai Sonata. The contact stated that in February 2022 there was an unknown recall campaign for the Stop Lamp Switch replacement and the recall repair was completed. The contact stated that the failure ha reoccurred, and the warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 146,000.

Valve cover gasket leaks and oil leaks on to the alternator which can cause the alternator to fail and the battery to not maintain a charge and the car can stall and then not start. This is the same exact problem problem that is in your recall on 2007-2012 Veracruz Recall number 20V705000 & 14V415000 And 2007-2009 Santa Fe vehicles have the same issue and Service Campaign 936 SB-10058931-4495 (TSB# 15-01-031).

The contact owns a 2009 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the passenger's side front wheel was seized due to a malfunctioning yaw sensor. The ESC warning light was illuminated. The contact deactivated the traction control to prevent the failure from recurring. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and sent the contact a gift card for a diagnostic test. The failure mileage was approximately 175,000.

The contact owns a 2009 Hyundai Sonata. The contact stated while driving 50 MPH, the vehicle inadvertently lost motive power and stalled. There was no warning light illuminated. The vehicle failed to restart. The contact pushed the vehicle to the side of the road with the assistance of her father. The vehicle was towed to an independent mechanic who referred the contact to the local dealer. The vehicle was then towed to the local dealer where it was diagnosed that the fuel pump needed to be replaced. The fuel pump was replaced; however, the failure persisted. The dealer then diagnosed that the gasoline needed to be pumped out. The repair was completed; however, the failure recurred. The battery was replaced; however, the failure persisted. The dealer diagnosed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had been at the dealer for 3 months. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 140,000. The dealer stated the car needs a new engine.

Passenger outside door handle fell off a couple years ago. Today the internal mechanism for the driver's side door broke so door will not open from the inside.

We purchased this vehicle used 9/2022. A week later it began to jump upon accelerating and slowing down. We took it in and they said it was the power train control module and our warranty would not cover it. So it would cost us around $1600. We can’t afford that. We have only driven it a few times since. We were parked in front of a curb and the car accelerated us into a curb. Now, the ESC OFF, ABS, and engine light are illuminated. This is not a. It also wear and tear issues, as I’ve seen many others posting similar experiences. Our car is an ‘09 with almost 90,000 miles on it.

The sunroof detached from the vehicle at highway speed. The sunroof was not open or otherwise in operation when it detached. A mechanic concluded that the adhesive holding the glass to the sun roof assembly failed. The sunroof assembly was completely intact after the incident and did not appear to be damaged.

My door handles are breaking off. I was climbing in and out from my passenger seat..now my passenger and rear passenger door handles have broken off in the same day. I have no way in my vehicle now except through the window that I had to take off track to slide down to crawl in and out..im in a loss for words. This is humiliating.

The contact owns a 2009 Hyundai Sonata. The contact stated that while his grandson was holding the inside rear driver's side door handle to exit the vehicle, the door handle cut his hand and he started bleeding abundantly. The contact and other family members were able to provide first aid to his grandson. The contact also stated that while holding the inside front passenger's side door handle to exit the vehicle, the door handle cut his hand. The contact immediately sought medical assistance at the nearest pharmacy. The contact stated that the vehicle door handles shining coating had peeled off and the remaining part of the coating had curled up and formed sharp blades. The vehicle was taken to the dealer where it was diagnosed that all four door handles needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact that they would send out a field technician to inspect the vehicle. The contact stated that the manufacturer followed up and inquired for his signature so they could proceed with the inspection of his vehicle. The failure mileage was approximately 90,000.

Car was making a loud ticking noise while running and increased when accelerating. Also would shut off while accelerating. Auto shop ran a diagnostic and said there is a rod bearing failure.

The contact owns a 2009 Hyundai Sonata. The contact stated while attempting to start the vehicle, the vehicle failed to start. The contact stated that the check engine warning light was illuminated. The vehicle was jump-started and driven to a local mechanic where it was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 193,000.

The contact owns a 2009 Hyundai Sonata. The contact stated while driving 60 MPH, there was a loud popping sound coming from underneath the vehicle. The contact pulled over and inspected the vehicle. The contact became aware that the driver’s side front ball joint had detached from the vehicle. The vehicle was towed to an autobody shop to be repaired but the contact thought that there was a recall for the lower control arm ball joint that might have caused the failure. The vehicle was instead towed to the local dealer to be diagnosed. The contact was informed that the driver’s side front ball joint needed to be replaced out of pocket. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 58,000.

The contact owns a 2009 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the contact heard a loud grinding noise coming from the rear of the vehicle. The contact took the vehicle to a local dealer to be inspected. The contact later discovered that the dealer only did a visual inspection of the brake pads and rotors. The mechanic stated that there were metal shavings from the brake pads and that the contact should wash the wheels to clear the metal shavings. The wheels were washed as instructed; however, the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 181,000.

P 215/60R16, TPMS IS ON , LOSS OF CONTROL OF VEHICLE FRONT RIGHT CONTROL ARM FAILURE ACTION # PE13007 NHTSA CODE: 13V354000

The contact owns a 2009 Hyundai Sonata. The contact stated while attempting to open the front driver’s side door, the outside door handle detached from the vehicle. The contact also stated that all four door handles had detached from the vehicle. The contact called the local dealer and made them aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 180,000.

Dash pad directly above the passenger side airbag has cracked with an approximately 12 inch vertical long crack

None of my lights on my dash has changed. Areas affected: Service Brakes, Hydraulics, and exterior lighting, Failure to illuminate the stop lamps during braking or inability to engaged the cruise control could increase the risk of a crash. As mentioned in the recall from 4/1/13. 2nd recall For Suspension: control arm separation May suddenly changed the rear wheel alignment affecting the handling of the car increasing the risk of a crash. Another main common issue is The rusted out subframe, lower control arms, cam bolts, bushings, control arm, subframe, and sway bar. This is causing me to drive unstable and hold the steering wheel forcefully in order to remain straight.

The problem as reported by so many others that the rear brake system has an inherent failure in the caliper/rotor/brake pads. I have vested nearly $2500.00 on the three for mentioned parts and labor over last 4 years. Between Midas and now a private mechanic have tried better lube on slide pins but the problem still persists. A little research states that the caliper piston doesn't retract from the rotors and in turn heating up the brake components to the point of failure. Some Law firms have stated the problem is a production flaw my problem with a system with this failure rate isn't recognized by the Hyundia. Calipers should simply last 80 to a 100 thousand miles under most driving conditions. Looking forward to your response. Kerry yakel

All car systems flashed and car went completely dead. Nothing worked. First time it happened mechanic said alternator and battery had to be changed. A year and a half later exact same thing happened and again new mechanic says the alternator needs to be changed. BIG SAFETY ISUUE AS CAR DIED IN THE MIDDLE OF HIGHWAY WITH CARS GOING ALL AROUND ME TRYING TO AVOID ME. This is Second time the alternator has to be replaced with only 2000 miles on the car after the alternator was replaced the first time.

STEERING WHEEL WOULD LOCKS UP FOR A SECOND OR 2 WHILE MAKING A RIGHT TURN AROUND 15MPH THEN I WOULD HAVE TO LET MY FOOT OF THE GAS JUST TO GET THE STEERING WHEEL BACK TO NORMAL. HAD THIS HAPPEN TOO MANY TIMES ALREADY. TRIED FIXING THE PROBLEM BY HAVING A MECHANIC SHOP CHANGE THE AXLES AND BUYING A NEW RACK N PINION AND TIRES AND GETTING A ALIMENT DONE IN MARCH OF THIS YEAR. STEERING IS STILL GETS STIFF WHILE MAKING TURNS EVEN WITH ALL THE NEW PARTS ON THE CAR NOW

TL* THE CONTACT OWNS A 2009 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE HIS SON WAS ATTEMPTING TO PARK AT THE CAR WASH, THE VEHICLE INADVERTENTLY ACCELERATED CAUSING THE VEHICLE TO JUMP THE PARKING BARRIER HITTING THE VACUUM MACHINE. NO INJURIES WERE SUSTAINED HOWEVER THE VACUUM MACHINE WAS DAMAGED ALONG WITH THE FRONT BUMPER WAS CRACKED AND SCRATCHED. THE MANUFACTURER WAS NOTIFIED AND THE VEHICLE WAS INSPECTED AT RICK CASE (180 SATELLITE BLVD DULUTH GA, 30096) WHERE NO FAILURE WAS DETERMINED. THE FAILURE MILEAGE WAS 142,000.

I HAD TAKEN THE VEHICLE FOR ALIGNMENT. THEY SAID BOLTS RELATED TO REAR TIE RODS WERE RUSTED AND THEY COULD NOT DO IT. I TOOK IT TO ANOTHER MECHANIC FOR INSPECTION AND POSSIBLE REPAIR. HE SAID THE SAME. IN ADDITION HE ALSO SAID THAT THE STRUTS ARE LEAKING. I LOOKED INTO THE HISTORY OF MY VEHICLE, AS I BOUGHT IT USED 2 YEARS AGO. I FOUND THAT THE VEHICLE HAD BEEN RECALLED IN 2013 FOR SUSPENSION RELATED ISSUES. AND SOME 239000 VEHICLES WERE AFFECTED. I BELIEVE ITS THE SAME ISSUE WHICH HAS RESURFACED AGAIN. THE VEHICLE IS PERFECTLY FINE OTHERWISE. BY THE WAY I HAVE A SALVAGE TITLE OF THE VEHICLE ON MY NAME IF THAT IS IMPORTANT INFORMATION.

BRAKE PEDAL LIGHT FAULTY STAYS ON ALWAYS.

BRAKE LIGHT FAULTY IT STAYS ON CONTINUOUSLY.

THE VALVE COVER GASKET LEAKS OIL ONTO THE EXHAUST.

INSTALLED FOUR (4) BRAND NEW GENERAL ALTIMAX RT43 TIRES. NEW TIRES HAD 3877 MILES ON THEM WHEN THE DRIVER'S SIDE REAR TIRE SUFFERED A SUDDEN, RAPID LOSS OF AIR TRAVELING ON A MAINTAINED COUNTY HIGHWAY AT 55 TO 60 MILES PER HOUR. THE TIRE WAS EXAMINED AT THE DEALERSHIP AND DETERMINED TO HAVE A SLICE OR CUT IN THE SIDEWALL RESULTING IN EXTREME, RAPID TIRE FAILURE. THERE WAS NEITHER NO POTHOLE OR FOREIGN OBJECT TRAVERSED PRIOR TO THE EXTREME, SUDDEN TIRE FAILURE. HAVING BEEN A CERTIFIED EMERGENCY VEHICLE OPERATIONS INSTRUCTOR, AND HAVING SERVED AS A COMMITTEE MEMBER FOR THE STATE OF WISCONSIN, DEPARTMENT OF JUSTICE AS AN ADVISOR FOR EMERGENCY VEHICLE OPERATIONS, I AM MOST CONFIDENT IN MY OBSERVATION AND ASSESSMENT. THE TIRE SIMPLY FAILED FOR NO IDENTIFIABLE, RATIONAL REASON.