Honda Pilot 2025 — Problemas reportados

The AC compressor went out on a new car

When I am driving my Honda sometimes will change gears "hard" or sometimes when I press the gas pedal it will hesitate and not go when I am trying to go around another car. I have had my car for less than a year and it has happened through out my ownership.

Engine is mis-firing and Honda has dreamed the vehicle inoperable until the back ordered parts arrive. I took the var to the dealership on Aug 28, 2026.

My 2025 Honda Pilot Steering Rack was recently replaced for the second time due to failure/grinding of the bearing. First steering rack was replaced at 500 miles and second rack was replaced at 33,000 miles.

RAPID FEEDBACK FROM STEERING WHEEL WHEN GOING OVER BUMPS. WHEN LOW SPEED TURNING, POWER STEERING WOULD NOT ACTIVATE AND ALL DASHBOARD LIGHTS WOULD SHUT OFF FOR A BRIEF MOMENT. INCIDENT HAS BEEN VERIFIED AND REPAIRED BY REPLACING THE POWER STEERING RACK ASSEMBLY

The contact owns a 2025 Honda Pilot. The contact stated that the vehicle recently received routine maintenance by the dealer; however, approximately one month later while driving at an undisclosed speed, the vehicle lost power and came to a complete stop. The messages “Transmission Temperature -Avoid Heavy Acceleration and High Speeds”, “Transmission System Problem”, “Apply Parking Brake When Parked”, “Emissions System Problem”, and “Power May Be Reduced - See Your Dealer” messages were displayed. The vehicle was towed to a dealer and was diagnosed with transmission. The contact was informed that the transmission needed to be replaced. The manufacturer was notified of the failure, and the vehicle was repaired. The failure mileage was 52,646.

The air conditioning system on my 2025 Honda Pilot stopped producing cold air at approximately 21,374 miles. The A/C failure also affects the vehicle’s ability to adequately clear fog and condensation from the windshield during humid or rainy conditions, reducing visibility while driving. On XXX, [XXX] Honda diagnosed the problem and documented on the repair order that the A/C clutch and coil need to be replaced. The repair order states that the parts are “currently on backorder with no ETA.” The vehicle was returned to us without the repair completed and without functioning A/C. We were advised to continue driving the vehicle while waiting for the backordered parts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The spring coil in the steering wheel started clicking and making more noise as I make every turn. I took it in to Honda dealership and the replaced the part. The next day it has started making the same noise but worse. It is louder and makes me now feel uncomfortable driving my vehicle.

All of the safety feature lights turned on. The dealer's solution was for me to pay attention when I drive and wipe the senor because everything works fine. I was also told to bring it in and they can get the lights to turn off by turning off all of the safety features.

Ac compressor, my 2025 Honda pilot elite, with 23k miles, AC stop working, went to Honda to get it fixed, but items are back ordered so car is not able to be repaired. Apparently multiple owners who have 2023-2026 pilot are having same issues of premature failing due to parts. And vehicle can’t be driven in SoCal heat.

The seat does not signal that a child is seated in the seat or to put on a seat belt. Shows as if no one is in the passenger right hand seat. Then when my child has the seat belt connected it signals to reconnect multiple times on the dash blinking red and green with sound. Please see picture below. My child is in the right passenger seat with the dealt belt on and shows no one is seated on the dash. When we are turning it blinks red and green.

I have a 2025 Honda Pilot. The air conditioner stopped working late evening on August 26th, 2026. I made an appointment and took it to the Honda dealership service center on August 28th 2026. I was informed of the problem and that the vehicle would be fixed by 9/1/26 or 9/2/26 the latest. I did not hear back from the service center so I repeatedly called Honda service on 9/2/26. I then received a phone call and was told that the repair parts were in back order and that I could pick up my car and drive it without air conditioner as it is not a safety issue. My car sat at Honda service for 6 days and I was never told the parts were in back order. I also spoke to service manager explained that I had recently had knee replacement surgery and still dealing with swelling which worsens in heat. I have now been without air conditioner in my 2025 Honda Pilot since late August. This is unfair and unacceptable. I have bought this to the attention of the corporate offices and yet have not been given any updates. I am still paying for a 2025 vehicle with no working air conditioner. I am concerned of other safety issue and/or the reliability of this vehicle.

Lost power on steering wheel while driving, unable to turn left/right. All of the warning lights related to braking, lane assist, hill descent, adaptive cruise control, trailer stability assist, hill start assist, low speed breaking, auto-high beam, parking sensor detector, etc.. "All wheel drive system problem. Only front wheels may be powered. See your dealer."

The moonroof of my car exploded on my panoramic sunroof. It was a hot summer day and I had the AC on. I opened the panoramic sunshade and as soon as it was fully open the moonroof glass upfront exploded. My family and I were very shaken, showered in glass and I almost swerved into a car that was passing me to the left. My wife had a minor cut on her arm that initially looked worse than it was. My younger son got glass in his mouth and said he swallowed some by mistake. The poor kid was crying for days thinking he was going to die. This was not a busy highway. There was no sign of debris hitting the car / moon roof. Pictures were taken after I cleaned up the broken glass around the rim of the moonroof so I could drive 2.5 miles to get off the highway without more glass falling on us.

On Friday August 21,2026 at approximately 10:00am I departed my house. Approximately 4 minutes later while traveling the engine lost power and began misfiring. Steering and braking capabilities were both reduced. Numerous system failure lights were flashing. The vehicle is currently at the dealership awaiting Honda repair plan.

We bought our 2025 Pilot in XXX. Within the first 500 miles, the steering wheel was locking up when trying to turn left or right. I was very concerned driving it that it could have locked up during driving and caused an accident. It was taken to Honda East in [XXX] where they agreed the steering rack was bad and replaced it. Currently it has 33,000 miles and is making a grinding/growling sound when turning. Took it back to Honda East (same location) on XXX, where they again stated that there is something wrong with the steering rack and it needs to be replaced. I am currently waiting on a new one to be delivered and they told me I would have to bring it back in for repair. I am concerned with the safety of our Pilot and think there needs to be some type of investigation of the Honda steering racks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I presented the vehicle to a Honda service shop for a squeaking noise from the front of the vehicle. The technician diagnosed a 'loose crash bar/reinforcement bar.' The technician tried to tighten the bar but noted it did not tighten enough to stop the movement, and that the bar will need to be replaced to resolve the complaint. When I spoke to the service manager, he indicated that other vehicles had presented with loose crash bars recently and it 'was on their list.' This vehicle is 37,000 miles and has not been in any accidents. It seems unreasonable and a safety concern that a crash bar has loosened after 37,000 miles and cannot be tightened. This suggests a defect in the hardware or torque specifications that could affect how the crash bar performs in an accident.

The contact owned a 2025 Honda Pilot. The contact stated that while the vehicle was parked on a neighborhood street, a vehicle crashed into the front driver’s side of the vehicle. The vehicle was driving approximately 60 MPH at the time of the crash and came to a stop upon impact. The air bags did not deploy. The vehicle was towed a local law enforcement parking lot. No warning lights were illuminated. A Police report was filed. The vehicle was destroyed. The contact and mother were injured. The contact was seated in the driver’s seat and suffered injuries to the left arm, back, and ribs, and the contact’s mother was seated in the rear driver’s side seat and suffered injuries to the left arm and both knees. No injuries were reported outside of the vehicle. Medical Treatment was required for the injuries sustained. The air bag warning light was not illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The manufacturer was notified of the failure. The failure mileage was 16,000.

The vehicle has suffered a life-threatening, complete loss of power steering while driving under identical, hazardous conditions on two separate occasions. There were no warning lights or inductors prior to either event. 1. The vehicle suffered a complete steering failure while driving over railroad tracks with a child inside the vehicle. A full replacement of the steering gearbox and power steering rack was performed under warranty (Defect Code: 03001 [Binding/Sticking], Symptom Code: 03217 [Not Operating]). This failure occurred only 20 days after receiving routine manufacturer maintenance from a Honda service department. 2. The exact same dangerous defect recurred, causing another complete loss of power steering while driving over railroad tracks with a child in the vehicle. The service department confirmed they successfully duplicated this power steering failure twice during active diagnostics.

The automatic breaking sensor put on my brakes at random times. It happens when going over a small rise in the road and also happened on a 2 Lane road when a semi truck was coming the opposite direction totally within its lane and the sensor for some reason thought maybe the vehicle was in my lane. This caused a sudden breaking and could’ve caused an accident by either me reacting to that breaking or by Vehicle following me hitting my car. This has happened multiple times and is very disconcerting. I took it to the dealer, but they could not find anything wrong with the car.

I was driving and I heard a loud bang and then sounds on the top of my roof. I pulled over and found the sunroof had exploded. There is a large portion that is gone. The glass that is left is spider cracked around where the glass is gone. There are pieces of glass that are angled upwards

My Ac went out and upon taking it to the dealership, it was determined that my clutch and coil are melted into my compressor. They ordered the part but there were over 1,000 other dealerships that put in an order for the same part so I was told it could take over two months to get this sort in. They also said this was highly abnormal and it normal wear and tear so it definitely feels like a malfunction of the equipment Honda has that should be considered a recall.

Driving down country road doing about 45 mph when all of a sudden the brakes slammed on throwing me into the seat belt. There was no vehicle or other obstacle insight. Called dealer to see if there was a safety bulletin on this problem. They said there were no safety bulletins on this. They said to check for bugs on the emblem. No bugs on Honda emblem or in front of the rear view mirror on the windshield. Just glad I was not on the interstate doing 70 mph when this happened. It definitely would have caused a wreck.

the right rear seat safety belt warning keeps going off as if the passenger does not have the seat belt fastened although they do have it fastened.

the seatbelt alarm on the passenger side middle row seat keeps beeping and flashing the seatbelt warning despite the passenger being bucked in. The dealer says the belt is covered under warrant but the buckle is not. The sensor in the buckle is supposedly the issue. Its a system... Am I supposed to tie my kid in with just the strap? The constant alarming while driving is a distraction. Failure to address is going to result in people not buckling into the seat.

1. What component or system failed or malfunctioned and is it available for inspection upon request? The Air Conditioning (A/C) compressor seized completely, causing the A/C compressor clutch to overheat and melt. Yes, the vehicle and the failed components are available for inspection upon request.2. How was your safety or the safety of others put at risk? A completely seized A/C compressor pulley creates a severe mechanical hazard while driving. Because the compressor is driven by the engine's serpentine belt, a locked pulley can cause the belt to melt, snap, or throw off entirely while the vehicle is in motion. If the belt fails, it results in an immediate loss of power steering assist, loss of alternator charging, and engine overheating. This creates an abrupt, catastrophic loss of vehicle control on the road, putting my family and other drivers at extreme risk. Furthermore, dealership staff dangerously misinformed us that the vehicle was "safe to drive" despite this critical failure.3. Has the problem been reproduced or confirmed by a dealer or independent service center?Yes. The problem was officially diagnosed and confirmed by a local authorized Honda dealership service center (8/17/26).4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, the vehicle was inspected, and the failure was documented by an authorized Honda dealership representative. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The primary symptom was a sudden failure of the air conditioning system to blow cold air (afternoon of 8/14/26).

On 05/01/2026 the battery failed and the car needed to be jumped and immediately driven to a dealership for battery replacement. The battery would not hold a charge. On 8/15/2026 the A/C went out and upon a diagnostic service appointment at the dealership on 8/17/2026 it was determined that the compressor suffered a catastrophic failure and melted.

during a routine trip thru the [XXX]/[XXX] section of [XXX] our 2025 Honda Pilot suddenly lost power steering capability, we could hardly control the vehicle and had to manage an exist to a side street. We received a message on the dash board of a lost of power steering assistance and to notify the dealer. We shut the car off, restarted and gained control of the vehicle less the lane departure feature. At this time we made an appointment with Fred Beans in Abington for service, we have lost confidence in the vehicles safety after this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

my vehicle since the first week verhicle stops for no reason comes into a sudden dangerous stop the vehicle in the highway turn off and vehicle take off on its own 0 to 40 miles on its own

Message Emissions System Problem – Avoid Heavy Acceleration and High Speed. See Dealer. Car has been dropped off at dealer on 7/12/26 and has still yet to be returned. Dealer stated they contacted Honda corporate and they need to take the engine apart and submitt photos

I am writing to formally report a potential safety-related defect involving the front windshield of my 2025 Honda Pilot. The windshield has demonstrated what I believe to be an abnormal susceptibility to cracking and chipping under what appear to be normal driving conditions, including ordinary interstate highway travel. The damage has occurred from relatively minor road debris and/or without a significant impact that would reasonably explain the severity or rapid progression of the cracking. I contacted Honda regarding this issue and requested assistance with the windshield repair/replacement as well as further investigation into whether there may be a defect involving the windshield glass, its installation, mounting, or related vehicle components. Honda declined to provide assistance or initiate any further investigation. My concern is not simply that windshield glass can occasionally be damaged by road debris. Rather, I am concerned that the windshield may be unusually susceptible to cracking under conditions that should reasonably be expected during normal operation of the vehicle. A windshield is a critical safety component, and repeated or unusually easy cracking could potentially affect driver visibility and the structural integrity of the windshield. I am also aware of other reported complaints involving windshield cracking on 2025 Honda Pilot vehicles. The existence of similar reports raises additional concern that this may not be an isolated incident and that the issue may warrant further investigation. I respectfully request that Honda: 1. Review the circumstances surrounding this windshield failure; 2. Determine whether similar windshield complaints have been reported for the 2025 Honda Pilot; 3. Investigate whether there may be a defect involving the windshield glass. Because the windshield is an essential safety component, I believe this matter deserves more than a determination that the damage is simply ordinary road debris.

The steering wheel became extremely difficult for my husband to turn. Power steering went out on my 2025 Honda Pilot Trailsport. Numerous warnings were then displayed on the vehicle's dashboard screen, it was impossible to drive, and caused us to have to get towed. We had it towed to a Honda dealer for repair, where it was discovered that the steering wheel had more turns in one direction than the other, the shaft boot was misplaced, non-factory pins on the steering rack were noted, and the clock spring was stuck reading 508 degrees. Furthermore, the steering wheel rack gearbox had to be replaced following a steering angle sensor failure in my 2025 Honda Pilot Trailsport. This is a serious safety issue and should have never have happened in such a new vehicle. This incident not only put my family's lives at risk, but also everyone else on the roadway. Why did my vehicle that I bought brand new and have only serviced at Honda have non-factory parts?

I was driving on a somewhat bumpy road (due to construction works in that location), when suddenly several warning lights came on. Driver assist was disabled, power steering and electrical braking were disabled as well. I was driving at 10mph (this was at a roundabout) so was able to control the vehicle and safely navigate it to a place where I could park. I turned off the vehicle and waited a few moments. When I turned it back on the warning lights cleared and I had power steering wheel/brake control as normal. I brought the vehicle to a certified Honda service station first thing in the morning. The report states an error code C0051-96 has occurred. The wheel sensor was recalibrated and the vehicle was cleared to drive by a Honda certified technician.

Safety Complaint – 2025 Honda Pilot EX-L Brake/Electric Parking Brake System Warning I am filing this complaint regarding a serious safety issue with my 2025 Honda Pilot EX-L, which I purchased brand new from Paragon Honda in Queens, New York, approximately one year ago. The vehicle currently has only 47,089 miles and has never been involved in an accident. While driving, multiple warning lights suddenly appeared on the dashboard, including a Brake System warning indicating a problem with the Electric Parking Brake system and that the parking brake was unavailable. This occurred unexpectedly while the vehicle was in operation and created a serious safety concern. A brake-related warning and loss of parking brake availability on a nearly new vehicle is unacceptable and requires immediate investigation. I immediately brought the vehicle to Paragon Honda Service Center in Queens for diagnosis. The dealership informed me that I may be responsible for diagnostic fees and possible repair costs, despite the vehicle being approximately one year old and covered by the Honda factory warranty. I am requesting that NHTSA investigate whether this issue represents a potential safety defect affecting 2025 Honda Pilot vehicles. I believe Honda should address this problem promptly and ensure that affected customers are protected from safety risks and unexpected repair expenses. Vehicle Information: Make/Model: 2025 Honda Pilot EX-L Mileage: 47,089 miles Dealer: Paragon Honda, Queens, NY

What System Failed: The automatic emergency braking system (EBS) engaged without warning, causing my car to stop abruptly on a public road. How was Safety of Myself/Others at Risk: I was turning right at a 4-way stop intersection after coming to a complete stop. There were other vehicles parked/driving on the street but none of them were close enough and no one was going fast enough to be a danger/trigger the EBS. The EBS on my car engaged without warning, stopping my car completely and blocking the intersection. Luckily the vehicles behind me and approaching the intersection were going slow enough to avoid a collision. Has the Problem been Confirmed: The Honda dealer where I bought the car brand new refuses to inspect the system, claiming it's normal for emergency braking to occur due to reasons other than to avoid a collision (snow in the air/a bird flying past/etc.). Vehicle inspected: No. Warnings/Symptoms: None

On multiple occasions, under different driving conditions, the vehicle has experienced significant and rapid deceleration without any warning lights, diagnostic codes, or dashboard messages. The deceleration has occurred unexpectedly and creates a dangerous situation, particularly in traffic where a car or semi behind me is not anticipating the sudden decrease in speed. This requires me to fully depress the gas pedal which then creates a slingshot effect once acceleration takes hold. This situation was almost continuous on a recent long-distance drive and only stopped once I parked the car in my garage. The only “fix” for now is to drive in cruise control where speed will be maintained. Since then, I’ve only driven locally and it has happened almost daily but much more intermittent with local driving. It's happened at speeds from 12 mph-74 mph. This is NOT an adaptive cruise control issue and I drive with only my right foot.

Right passenger seatbelt doesn’t show it’s full engaged and dings when passenger moves

Collision Mitigation Braking System has activated numerous times while traveling on a straight road with no other vehicles around. The brakes activated hard where items shifted in the vehicle and the seatbelts locked. Occupants were thrust forward at the time of braking. Contact was make with the dealership and there are is not any fixes advised.

My Seat Belt Reminder System Not Operating Properly. In fact, the second-row seat belt behind the passenger seat is malfunctioning. I learned that Honda put out a service bulletin (26-027) (https://dot.report/bulletins/MC-11028510-0001.pdf) in regards to the safety issue. I contact Honda and was told the issue was covered under a warranty claim. However, my vehicle has 39,000 miles and is no longer under warranty. I asked if the issue was a safety concern and was told not to drive the vehicle as it was 100% a safety issue. However, the repair would not be covered until Honda recalls the vehicle. I'm concerned that I can no longer safely drive my vehicle until Honda initiates a recall. The service bulletin was dated January 21, 2026. As such, Honda has had seven months to issue a safety recall. The Honda representative stated I would likely be eligible for "Goodwill Assistance" if I couldn't afford to fix the vehicle myself until I am eligible for reimbursements via a safety recall. Why is the NHTSA allowing Honda to funnel safety costs through warranty claims and delaying a recall?

Not long after we purchased the vehicle, there was a crackling noise that comes up at different speeds. I reported this to the dealership (I can't recall exactly when). A mechanic (I believe) took the car for a test drive. He acknowledged hearing the sound 0n/off but could not determine its origine. Each time I go there for oil change, I re-state the problem. I had also reported this to Honda Corporate office. There was a recall at that time, and it was serviced. I thought this would take away the noise, but it is still there. I am not sure what to do next. I will continue to raise the isse each time I go to the dealership.