Ford Transit Connect 2020 — Problemas relatados

The contact owns a 2020 Ford Transit. The contact stated that while driving 50 MPH, the vehicle unexpectedly lost motive power and came to a complete stop in traffic. There was no warning light illuminated. The vehicle was unable to be restarted. The vehicle was towed to the dealer and was diagnosed with internal transmission failure involving the sleeve and cylinder of the 10-speed transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure by email, and a case was opened. The failure mileage was approximately 87,000.

The contact owns a 2020 Ford Transit Connect. The contact stated that while attempting to pull into a parking lot, the brakes locked up. There was no warning light illuminated. The contact stated that several attempts were made to forcefully engage and unlock the brakes. After restarting the vehicle, there was a burning odor coming from the brakes. The contact stated that the brakes slowly released after the vehicle was turned off. The vehicle was taken to the dealer, where it was diagnosed and determined that the valve assembly modulator had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,484.

Odometer Fraud. The contact purchased a 2020 Ford Transit. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 69,000, which was confirmed by a fraudulent Carfax report the seller provided to the contact. However, upon searching the VIN on a Ford mobile app, it was discovered that the mileage was 168,000.

Intermittent Electronic issues are: 1) Rear view backup camera malfunction. Works sporadically. Camera some times clear as bell, and stays on when in drive moving forward. Other days camera fails to blue screen, then turns gray with message that camera is unavailable, contact dealership. Defect is not currently not listed for this vehicle as a recall. Definite safety hazard with camera staying on when vehicle is in drive and moving forward. 2) Auto start, stop feature was functioning when vehicle was purchased November of 2025, but as of April 2026, system began to turn itself on and off, no longer can be activated or deactivated via command button on console.

My Tire pressure Monitor give me alert while driving I select to view tire pressures for display show 3 tires fail send reading One of the three back sending reading two stay off For few days same then all tires reading went off just 1 tire send reading on /off every few miles This is first time happened

Rear brake issues. Upon taking off the brake pads on the driver's back the caliper piston would not turn in as it should. So I ordered a new one. Then I started on the passenger rear. When I tried to press and turn the piston back in it did the same thing as the other one. The piston came out of the passenger rear caliper. Upon further inspection I noticed the interior housing for the piston has a portion of it missing.

The bolts holding the axle together to the driveshaft failed on the rear right wheel, nearly causing an accident but fortunately it was 6am with little traffic on the interstate. The axle came out and destroyed our driveshaft, requiring a full replacement. We have had the vehicle serviced regularly since our purchase.

The windsheild is not properly sealed. It has caused water to leak into the vehicle. The water leaking in has caused electrical problems with the radio and backup camera. Also causing mold inside the vehicle.

Transmission intermittently struggling to reach 3rd, 4th, 5th gears. Performed IDS diag at shop, found hitorical code P0734 for "Incorrect gear 4 ratio" TSB 26-2046 to overhaul transmission.

ABS Hydraulic control unit pump malfunction. vehicles brakes locked up on the highway and could of caused an accident. this is a known and common issue with these vans. this type of thing shouldnt happen my vehicle has only has 67,000 miles on it. I have seen other report this issue with less miles than that. vehicle is now having the unit replaced.

The contact owns a 2020 Ford Transit Connect. The contact stated that while driving in a rainstorm, rainwater poured into the vehicle from the front passenger’s side windshield. The vehicle was taken to the local Satellite Auto Glass repair shop, and it was discovered that the front windshield adhesive had failed, causing the passenger’s side front windshield to become unsecured. The contact was advised that the windshield needed to be replaced. The vehicle was not yet repaired. The contact stated that several electrical features were damaged due to the water, including the audible warnings and 911 assist from the inoperable Bluetooth. The local dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 22V192000 (VISIBILITY). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 189,000.

Vehicle shakes violently on or about 65 to 70 mph. Upon slowing to approximately 60 mph the shaking stops. Also at slower speeds the vehicle pulls to the right. Contacted Ford Fairfield, California dealer two days ago; left voicemail no reply at this writing.

Water leaking through front windshield. Internet shows there is a recall for improper adhesive of windshield on 2020 Transit Connect but when my 2020 Transit Connect VIN Nm0ls6e25l1446922. Was taken to Ford dealership they are advising there is no recall on my vehicle.

I started experiencing a sluggishness and jerking sensation upon acceleration. I took my van to Starling Ford who diagnosed it to be a transmission issue. An estimate was given for either replacing or repairing the transmission. Shock. I took the van to Premier Auto Care, for a second opinion. They then referred me to Quality Transmission after driving the van. I asked Ford for some assistance since the quote was so much and it was out of warranty at 60,784 miles due to "wear and tear". After about a week, Ford responded with $5,984.37. I decided to have Quality Transmission replace the transmission after hearing from 2 mechanics that they had seen other Ford Transit Connect vans, with more mileage than mine, having the same transmission problems. I find it hard to believe that a transmission had to be replaced before 100,000 miles, which seems to be the magic number for miles. My van is used for personal use only.

We started experiencing slight transmission shifting issues in early-mid 2024. More issues in December 2024/January 2025 - this time it was really hard and jerky shifting. It was sporadic at this time, but it was often. My wife and I have 7 children. This vehicle is usually driven by my wife to pick up kids from school, run errands, etc. At the beginning of March 2025, my wife was merging onto the highway, but it didn't want to shift. She stated that a big rig was coming behind her and the van was not shifting and picking up speed. She said the engine was revving but just was not shifting up. She said the big rig honked and had to change lanes or else he would have hit her and my kids. Several seconds after the big rig passed was when the transmission hard shifted and jerked and it began to pick up more speed, but from that point on, the transmission was not operating properly. We have not driven it since March 2025. I have been saving up to fix the transmission, but I read so many other Ford owners have the same issue with this particular transmission. The Ford dealer confirmed it had a TSB on this exact issue and that many other 10r80 transmissions were doing the same. The issue was reproduced by the Ford dealer. It states the CDF issue in the invoice. There were no warning lamps or messages prior to the experience merging on to the highway. I reached out to a local independent mechanic and he upgrades the parts in these Ford transmissions all the time - proving it is a very common issue. This is a huge safety risk for anyone operating or riding in a Ford with this transmission.

Back up camera image is reversed, distorted and goes black/blue from time to time.

Transmission failure in my 2.0L Ford Transit Connect at approximately 94,000 miles. When I shift into reverse, the van sometimes drives forward instead of backing up — as if the transmission is confused or stuck in the wrong gear. Over time, reverse completely stopped working altogether. Additionally, after coming to a full stop (such as at a red light), the van occasionally stalls or becomes unresponsive when pressing the gas pedal. This creates dangerous situations in traffic. All recommended maintenance has been done on time, including a full transmission flush performed by a Ford dealer at around 80,000 miles. There were no warning lights or error messages before the issue began. After researching, I found many other Transit Connect owners with the same problem, especially in models with the 2.0L engine. This points to a potential defect in the transmission system. A full transmission replacement may be necessary, and I believe Ford should issue a recall to address this recurring failure.

The brake pedal went down far and there was poor braking. The brake fluid was found to be leaking from the left front brake jounce hose. This was unsafe due to extended braking stop time and less braking ability. I am an ASE certified master technician and I work in a private vehicle fleet repair facility. I did not interview the driver if the BRAKE warning light came on but most likely it did due to brake fluid leaking fast from this line. We also had a failure of this type on a 2019 Ford Transit Connect which is also in our fleet. So it appears Ford has another problem with front brake jounce hose failures.

The rear back up camera stopped working completely I took it to Faricy boys Ford in Canon City Co Waited 45 days for them to get the part and then they told me they weren’t comfortable changing the camera out so I have been with out back up camera on this 22 foot van needing assistance for almost every single move Please help me get this vin on the recall Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Transit. The contact stated that whenever the vehicle was started, the contact stated that several unknown warning lights and the ABS warning light were illuminated. The contact stated that the right front wheel activated, and the ABS activated while making a hard right turn. The contact was not depressing the brake pedal during the failure. In addition, the contact was informed that the brake lights remained activated. The contact stated that several functions were deactivated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 33,000.

My 8F35 transmission failed at 95,000 miles, a new unit was put in and that transmission failed at about 175,000 miles, a new transmission was not put in for replacement, but was rebuilt by Ford and currently I have 185,000 miles and as I slow down the transmission starts to jerk and I am slammed forward in my seat. This transmission does this everyday, without fail. Just a matter of time before this transmission fails.This transmission is acting like the last 2 transmissions that failed.

Only I have 88,000 k on 2020 transit the transmission have problems with shifting while driving on highway start with delay on 2nd gear now fault code for gear 10

Driveshaft both front and rear failed as pieces broke off while driving at different times requiring tow and repair

Loss of power while driving with no warning. Almost crashed. Shifting violently. After a few months it wasn't safe for anyone and was happening all the time . It's at the dealer getting the transmission rebuilt with re engineered parts . That's what the dealer told me . He said this will resolve the problem for good . 8000$$ 67k miles ford is not helping with cost. Ford had to re engineer the parts that are going in my van , isn't that them admitting they have a transmission that was no good from the start

Mid 2023 the backup camera would sporadically stop working and produce a blue screen and a message "camera is unavailable contact your dealership". I would check for an update and then it would start working. This has happened 8 times since 2023- 2024, in August 2024 it has quit working completely.

The contact owns a 2020 Ford Transit Connect. The contact discovered moisture leaking into the vehicle on the passenger’s side. The vehicle was taken to several dealers and independent mechanics who were unable to determine the source of the leak. An independent mechanic eventually discovered that the leak was coming from the windshield, which needed to be replaced. Upon investigation, the contact discovered NHTSA Campaign Number: 22V192000 (Visibility); which the contact linked to the failure. The dealer was notified of the failure,e and the contact was informed that there was no recall on the VIN. The manufacturer was also notified of the failure but offered no additional assistance. The contact was referred to the NHTSA Hotline for assistance. The vehicle was repaired. The failure mileage was unknown.

While I driving my 4-year-old Ford Transit Connect with 65,000 miles, I noticed a transmission issue. At low speeds, the vehicle struggled to accelerate, which caused me significant stress and felt very unsafe. However, once on the highway, the transmission gradually returned to normal. In March, I took it to a Ford dealership, where it was diagnosed with a faulty transmission. After discussing this issue with others, I found that many people have also complained about serious safety concerns with Ford’s transmissions.

A few months ago, my 2020 Ford Transit had a transmission issue, and the dealer replaced the torque converter. Now, at 101,300 miles, I’m experiencing loss of power, jerking, and rough shifting, and I have to replace the entire transmission. After researching online, I’ve found that many others have experienced the same issue.

The contact owns a 2020 Ford Transit. The contact stated that while attempting to drive from a complete stop, the vehicle briefly hesitated before suddenly jolting forward, prompting the contact to pull over to the shoulder of the roadway. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 136,000.

The left front wheel locked up. The dealership first replaced the brake line. When that didn’t repair the problem they said they’d need to replace the ABS Module. The vehicle has less than 30,000 miles. Online it appears that ABS Module failure is a common problem in Ford vehicles with the 2.0 four cylinder engine dating back to 2010.

The contact owns a 2020 Ford Transit. The contact stated that the AWD and air bag warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the actuator and sensor needed to be replaced, and a software update needed to be performed. The vehicle was repaired, but the failure recurred. The dealer determined that the transfer switch, new air bag, and seat repair kit were needed. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 68,000.

The van will not start on a regular basis. Usually within a week the battery voltage has depleted to the point the van will not start. Have to put a charger on it often. This is a commonly reported problem on many forums.

The contact owns a 2020 Ford Transit equipped with Hankook Tires, Tire Line: Dynapro HT, Tire size: 205/75/16, DOT Number: (NA). The contact stated that while pulling into a gas station there was a thumping noise coming from the trailer. The contact inspected the trailer and observed that the front driver’s tire was flat. A mobile mechanic was called to the location and replaced the flat tire with the spare tire. The vehicle was then taken to a tire shop where it was determined that the front driver’s tire was worn down to the metal and experience a blowout. The tire was replaced. The contact stated that on the same day while driving 62 MPH, the tire pressure warning light illuminated, indicating that the tire was deflating quickly. The vehicle was pulled over to the side of the road and the contact became aware that the front passenger’s tire was flat. The vehicle was taken to tire shop and the front tires were replaced. The manufacturer was notified of the failure. The vehicle and tire failure mileages were approximately 20,250.

The contact owns a 2020 Ford Transit Connect. The contact stated that while the vehicle was parked, there was condensation leaking from the top of the windshield. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 22V192000 (Visibility). The manufacturer was notified of the failure. The failure mileage was 19,000.

My Balmar 2nd alternator on my Winnebago Ekko has just failed. This is a Winnebago installed electrical system component mounted in the Ford Transit chassis engine bay that provides electrical charging to the RV coach batteries. There was an initial NHTSA Safety Recall 23V-234 issued in 2023 after numerous Balmar units failed; in some cases the Balmar unit failure caused a fire in the engine bay. I had the Safety Recall work performed in July 2023 by authorized dealer Dennis Dillion RV in Boise Idaho per the attached invoice and the Balmar charging system had been working well until now. I am aware that there are ongoing reports by other Ekko owners of the Balmar alternator failures reoccurring after the Safety Recall work was performed, and in some cases even after Balmar 2nd alternators' were replaced, which suggests the initial solution provided by the Safety Recall was not sufficient to prevent a failure. Within minutes of starting to drive my RV today I noticed an unfamiliar whining sound from somewhere under the hood that I had not heard before and immediately checked my coach batteries while driving a short distance and went from the batteries discharging significantly to not charging at all. I opened the engine hood and had smoke visible and a strong burning smell coming from the passenger side of the engine bay where the Balmar unit is located. I was very concerned about the potential for an engine bay fire, but fortunately was very close to my home, so my RV is now parked in my driveway. See attached screenshots showing the initial voltage discharge while driving and then the batteries not getting any charge while under power. Also attached is the Recall 23V-234 repair instructions. I plan to unplug the Balmar alternator to prevent the potential for a fire while awaiting a response from Winnebago how to proceed. Despite the NHTSA Safety Recall having been performed, there are reports of alternator's failing and risk of vehicle fires remains.

At highway speeds (55-70), light brake pressure resulted in major frontend vibration and front left caliper seized. After pulling off the road, the front left wheel rim was too hot to touch. Vibration and seized caliper could result in loss of control of vehicle while braking, especially at highway speeds. Repair shop initially replaced the caliper and overhauled the brakes. Problem was not resolved, and same symptoms recurred after less than 100 miles. Mechanic determined that Anti-lock Brake System (ABS) Module had failed. No warning lights, and no inspection by anyone but my mechanic. Replacement ABS module from Ford Dealer was installed by independent mechanic and problem is resolved. Ford Dealer reported two other ABS module replacements same week as mine and internet search identified others with same problem (ABS module failure). My vehicle is four years old and has around 40,000 miles. It seems to be a premature ABS module failure causing collateral damage (e.g. caliper) with multiple reports of same problem.

In march 2024 my vehicle unexpectedly cutoff on [XXX] heading into wash. Dc. Called a tow to my mechanic and had the alternator and battery replaced. Mechanic noticed that the vehicles battery light remained and investigated further. After amonth in the shop we observed that components were utilizing battery power when the system should be off. We heard mechanical diagnostic sounds, and the battery would not maintain a charge after being driven. Upon getting it home and a day later upon jump starting again and when i began to turn the wheel, a violent jerking response came from the steering column. Cheched the dash and several popup windows had to be closed. AWD, BATTERY, and low fuel. There was also the wrench light on the dash itself. Went on the Ford forum and many others were describing the same issues, mainly battery drain. I thought i had disconnected the cargo area lights only to find out i did disconnect part but not them all only to further discover Ford engineered the vehicle where most of the features that were described in the forum not so accessible such as the fuse panel 'fuse 32' because theres no clear indication of where that is exactly on the diagrams. Ive have pretty much used the vehicle on occasions where im moving my equipment. As of september, i received a letter from fords "Customer Satisfaction Program" in which i responded only to be told from Bannister Ford that the Software Update that would fix High-Torque launches would not be installed because the battery light was on. Now to me, this sounds like a catch-22 because the issue is with their electrical design where if one problem occurs they have a fix but you wont get it until you fix the prom (ideally with them). all the while I'm setting up the appointment im being served ads for add-on services. Its october 2024 and i am just sick of this van. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Transit. The contact stated that whenever it rained, the door seal towards the rear of the passenger’s side sliding door was leaking. The contact stated that the leak was allowing water to accumulate in the pillar located at the rear on the passenger’s side. The contact stated that the pillar was filling nearly to where the pillar joined the ceiling. The contact stated that water was forming puddles on the floorboards and was draining from the pillar. The contact had taken the vehicle to a local dealer but had not had the vehicle diagnosed. The vehicle was not repaired. Additionally, the contact had observed that the seam on the roof of the vehicle where the two roof panels were joined was also showing extreme deterioration of the caulking; however, there was no water leaking into the vehicle yet. The manufacturer was informed of the failure. The failure mileage was approximately 3,100.

The contact owns a 2020 Ford Transit Connect. The contact stated that while his wife was driving at an undisclosed speed, the braking system erroneously activated causing the front driver side and the rear passenger side brakes to overheat and the vehicle to decelerate. The contact stated that after his wife exited the vehicle, she discovered smoke coming from the front driver’s side wheel well. Additionally, during the failure the Forward Collision Avoidance system warning light activated. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 28,000.

I have encountered an issue multiple times now on multiple Ford Transit vans. The "lug wrench" included with the vehicle as part of the spare tire tool kit does not allow me to remove the lug nuts. I am a Fleet customer and I own many Ford Transit AWD vans. When they are brand new, the spare tire lug wrench barely reaches the lug nut as it is not a very deep socket. After a couple of tire rotations I believe the lug studs possibly stretch slightly and the lug wrench tool no longer reaches the lug nut. This issue has caused my drivers to be stranded multiple times. I believe it is an oversight by Ford and it should be addressed. Thank you

We own a fleet of these vans and 5 out of the last 7 purchased from 2020-2023 have had total rear brake system failure. The calipers are not retracting and are overheating and freezing up the rear brake system. In some cases leaving our employee(s) stranded on the side of the road in the middle of winter storm waiting to get towed putting their safety at risk. The problem has been reproduced as it has happened on 5 of the last 7 vehicles we purchased. Our local Ford dealer has inspected these issues and we contacted the Ford Consumer phone today - spoke with Rena at Ford on 6/19/24 at approximately 2pm - 2:15pm PDT. No warning lamps or message alerts. Brakes are making a squeaky noise and hot smell prior to seizing. We have had to pay thousands of dollars for some of these repairs and towing. We wanted to alert Ford and you as we are noticing an alarming trend. In speaking with Ford Motor Company, they correlate this issue as a maintenance issue but if it was a maintenance issue, the front brakes would have failed before the rear. I will be completing this form for the additional VIN numbers. Thank you.

We own a fleet of these vans and 5 out of the last 7 purchased from 2020-2023 have had total rear brake system failure. The calipers are not retracting and are overheating and freezing up the rear brake system. In some cases leaving our employee(s) stranded on the side of the road in the middle of winter storm waiting to get towed putting their safety at risk. The problem has been reproduced as it has happened on 5 of the last 7 vehicles we purchased. Our local Ford dealer has inspected these issues and we contacted the Ford Consumer phone today - spoke with Rena at Ford on 6/19/24 at approximately 2pm - 2:15pm PDT. No warning lamps or message alerts. Brakes are making a squeaky noise and hot smell prior to seizing. We have had to pay thousands of dollars for some of these repairs and towing. We wanted to alert Ford and you as we are noticing an alarming trend. In speaking with Ford Motor Company, they correlate this issue as a maintenance issue but if it was a maintenance issue, the front brakes would have failed before the rear. I will be completing this form for the additional VIN numbers. Thank you.

The contact owns a 2020 Ford Transit. The contact stated that on several occasions while in reverse(R), the rearview camera became static, blue, and black and failed to work as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the rearview camera needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 28,000.

The contact owns a 2020 Ford Transit Connect. The contact stated that while driving at 65 MPH, the brakes locked up. After releasing the brake pedal, the vehicle began to shake abnormally. While driving, the power steering became inoperable. The Hill Assist, traction control, and steering assist became inoperable. The traction control warning light was illuminated. The contact is a former mechanic and determined that the ABS module hydraulic pump needed to be replaced. The vehicle was repaired, but the failure recurred. When the vehicle was taken to the independent mechanic, there were no codes displayed. The contact called the local dealer and was referred to the manufacturer and the NHTSA Hotline. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 68,000.

2020 Ford Transit Connect with 80,000 miles. Wrench light came on dashboard and car experiences some shuddering and hesitation when going uphill.Warranty expired at 60K miles Dealer says that it is a power train issue and the transmission needs to be fully replaced. There was never any type of warning that the transmission. I did have a code for a EGR valve, which was replaced. Requested Ford Goodwill assistance to pay for this expensive repair but was denied and need to replace at full cost. Vehicle has been serviced every 5,000 miles at dealership. Supposedly transmission doesn't ever need servicing. There is no dipstick to check and when I asked when it needed fluid changed, I was told it didn't. Obviously that isn't true.

The contact owns a 2020 Ford Transit. The contact stated that while driving at an undisclosed speed, the rear camera unavailable message was displayed. The vehicle was taken to the dealer; however, the failure was unable to be duplicated. The vehicle was not repaired. The contact stated that the vehicle had been taken to the dealer several times because of the persistent failure. The manufacturer was made aware of the failure and the contact was informed about an unknown recall however, the VIN was not associated with the recall. The contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 3,000.

Powertrain fault Transmission torque converter clutch is not operating as expected. Transmission not shifting properly. Fixed many times and still same issue, now it needs new transmission.

The Vehicle head light comes on while the vehicle head light switch is at off position and when you hit the remote on off button the light turns off. And later comes back on again . And at night driving the light goes off and on some time .it just black out on road can we get advise if this is recall issue since we seen many customers having complaints about the same issue on website and also on ford forums

Windshield wiper motor, working only in high speed, found overheated ground wire, melted insulation for approximately 1 foot of wire. If dry leaves were nearby there would be a possibility of a fire. Replaced wiper motor and wire harness work done by Brewster Ford in New York found that the new motor has not been updated which means this problem may happen again went on Google website found many owners having same problem. As you can see from the wiper motor connector, there is a pin that shows signs of overheating the wiper motor was the cause of the problem as the wiper motor was drawing excessive current

Tire was a Continental 235/65 R16 C 121/119R Van Light Truck M.S Radial Tubeless - Name of Tire was Con Vancontact A/S - On October 07 2023 [XXX] was driving on IH35 North South of Waco TX at around 70 MPG and the tire had a blowout/explosion doing multiple damage to the vehicle before it could be brought to a full stop INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

While driving on the freeway at about 75 mph, the rear passenger tire exploded causing our driver to almost lose control of the vehicle before coming to a stop on the side of the road. No lamps or warnings were given. No inspections have been completed but I have retained the tire if needed.

The contact owns a 2020 Ford Transit. The contact stated while starting the vehicle and shifting into drive, the vehicle failed to accelerate. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the transmission coolant was leaking, and that the transmission needed to be replaced. The contact was advised to contact the local dealer. The dealer was contacted and advised that there was a service bulletin for the failure, but the VIN was not included in the service bulletin. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle needed to be diagnosed. The contact was also informed that there was no recall on the VIN for the failure. The failure mileage was 95,000.

The seats have sank into the springs making it undriveable. This has happened on all our Ford Transit Vans. Ford dealerships won't repair because they are now out of warranty but this was reported prior to warranty expiration but we were told parts were not available.

The battery's junction box in the engine compartment is melting. While I was driving, I heard a loud pop, I opened the hood, and saw smoke coming from the junction box. I noticed the box was melting around a fuse. The melting is significant, and the vehicle looked to be on fire. The smoke stopped, but I feel the vehicle could easily have caught on fire completely. There are recalls for this same exact issue but for other Ford Models. I have a fleet of these vans, and this has now occurred to 6 of them. I know other owners that this occurred to as well. I have called Ford Goodwill and they have declined to cover it under the 3-year, extended warranty. The melting was so bad on one that the actual harness was burnt as well. This is a dangerous issue that Ford already knows this happens. I have receipts for all of these repairs and the technician acknowledging the junction box melting. I have emails from Ford where they apologize for the issue, and they say they cannot cover it under warranty. They refuse to comment on the safety danger this poses on all. This is an amazon delivery van and there are thousands of these that could catch fire in someone's house or business.

THIS IS A SECOND CASE FOR A DIFFERENT VIN WITH THE SAME ISSUE. 11524889. The battery's junction box in the engine compartment is melting. While I was driving, I heard a loud pop, I opened the hood, and saw smoke coming from the junction box. I noticed the box was melting around a fuse. The melting is significant, and the vehicle looked to be on fire. The smoke stopped, but I feel the vehicle could easily have caught on fire completely. There are recalls for this same exact issue but for other Ford Models. I have a fleet of these vans, and this has now occurred to 6 of them. I know other owners that this occurred to as well. I have called Ford Goodwill and they have declined to cover it under the 3-year, extended warranty. The melting was so bad on one that the actual harness was burnt as well. This is a dangerous issue that Ford already knows this happens. I have receipts for all of these repairs and the technician acknowledging the junction box melting. I have emails from Ford where they apologize for the issue, and they say they cannot cover it under warranty. They refuse to comment on the safety danger this poses on all. This is an amazon delivery van and there are thousands of these that could catch fire in someone's house or business.

Bad Torque Converter - There seems to be a systemic problem with this part on Ford Transits. Ford is not standing behind their parts so we need your help please.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

The contact owns a 2019 Ford Transit Connect. The contact stated while driving 20 MPH, the transmission was shifting very rough. There was no warning light illuminated. The contact pulled over on the side of the road and had the vehicle towed to the dealer. The dealer stated that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the manufacturer stated that the vehicle was not included in a recall regarding the failure. The contact was advised to contact the NHTSA Hotline for assistance. The failure mileage was 102,000.

The contact owns a 2020 Ford Transit Connect. The contact stated that the windshield was leaking. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 22V192000 (Visibility) but the vehicle was not repaired. The dealer was unable to locate a mechanic to compete the recall repair. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 31,122.

While traveling at highway speed the vehicle suddenly and without any warning lost propulsion and died forcing the driver to pull over. As a result of how sudden the failure was the driver was just barely able to find a safe place to pull off the road. The vehicle would not start or run leaving the driver and his passengers stranded in the hot weather. This very easily could have resulted in an accident as the vehicle was going up hill on a mountain road with many curves. After taking the vehicle to the Ford dealership it was determined that the throttle body had failed suddenly and without warning. There were never any service lights that illuminated when the problem occurred. We are reporting so that there is a record in case this becomes a common issue with other vehicles of this type.

The contact owns a 2020 Ford Transit Connect. The contact stated while driving 20-30 MPH, the message "Pro-Collision Assistant is Unable" was displayed. The accelerator pedal was depressed but the vehicle jerked and hesitated to respond. The contact veered to the side of the road and turned off the vehicle. Upon restarting the vehicle, the vehicle operated as needed and the contact continued driving. However, the failure reoccurred on four different occasions. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.

The contact owns a 2020 Ford Transit Connect. The contact received a notification for NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue and an appointment was scheduled for the recall repair. The contact arrived for the appointment but was informed that the appointment was canceled. The contact was informed to bring the vehicle back once he experienced the failure stated in the recall. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

Three summers in a row now the transmission "overheats" causing warning lights and errors to pop up while driving, then going away. Sometimes disabling vehicle power altogether. When control does come back, transmission gear changes happen at the wrong rpm , stuttering the vehicle and making erratic driving behavior. Ford ignored my requests to investigate for two years, and now that it's out of warranty, tell me I need to pay them to install a brand new transmission

The contact owns a 2020 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 12,000.

Transmission failed with only 17,000 miles (mostly highway) on the car. The car did not move forward from a parked location. It only moved in reverse. It had to be towed to the nearest dealership and when they examined it, it did not move in reverse either. Even though it is under warranty, the dealers are taking a long time to repair the car.

ON TWO DIFFERENT OCCASIONS THE DASH INDICATOR STATED AS FOLLOWS: "PRE-COLLISION ASSIST NOT AVAILABLE". WHEN THIS ERROR MESSAGE APPEARS, THE CAR DOES NOT ACCELERATE PROPERLY. THE TRANSMISSION SEEMS TO FLUCTUATE BETWEEN GEARS, AND THE CAR WILL NOT ACCELERATE, AND THE VEHICLE SEEMS AS IF THE PRE-COLLISION ALERT IS ENGAGING OR ATTEMPTING TO ENGAGE, BUT DOES NOT HOWEVER, STOP THE VEHICLE, RATHER, THE VEHICLE HESITATINGLY OR HALTINGLY WILL NOT ACCELERATE PROPERLY UPON PRESSING THE ACCELERATOR PEDAL. ON BOTH OCCASIONS , I IMMEDIATELY STOPPED THE VEHICLE IN A SAFE LOCATION, TURNED THE VEHICLE OFF, AND TURNED THE VEHICLE BACK ON AGAIN. IT SEEMS AS IF THE COMPUTER MODULE IS RESET UPON TURNING THE VEHICLE OFF AND THEN ON AGAIN. UPON TURNING THE VEHICLE ON AGAIN, IN BOTH INSTANCES, THE PROBLEM DISAPPEARED. HOWEVER, THE MOST RECENT INSTANCE OF THIS PROBLEM, UPON TURNING THE VEHICLE BACK ON, THE ERROR MESSAGE DISAPPEARED, AND THE ACCELERATION OF THE VEHICLE RETURNED TO NORMAL, BUT THE YELLOW ENGINE LIGHT REMAINED ON, UNTIL RESTARTING THE VEHICLE THE NEXT DAY.

ON SATURDAY AUGUST 1, 2020, ME AND MY WIFE DROVE A CAR AFTER WORK AROUND 6:30PM. THIS FORD TRANSIT CONNECT HAS BEEN DRIVING A MONTH SINCE WE BOUGHT IT. WHEN WE TOOK ON THE ROAD WITH AROUND 30MILES SPEED 10MINUTES AFTER WE LEFT, SUDDENLY A WARNING MESSAGE CAME UP SAID THAT "PRE-COLLISION ASSIST NOT AVAILABLE". AS WE SAW THE MESSAGE WE HAD NEVER SEEN BEFORE, WE SLIGHTLY REDUCED A SPEED BELOW 25MILES AND KEPT DRIVING. WE SLOWLY PUSH AN ACCELERATOR TO SPEED UP AGAIN, HOWEVER SUDDENLY WE HEARD CLUNK SOUND, AND THE CAR SHOOK BACK AND FORTH. RPM INDICATOR MOVE ABNORMALLY. WE TRIED TO FIND A RIGHT PLACE FOR PULLING OFF A CAR, HOWEVER WE COULDN'T FIND IT IMMEDIATELY. AROUND 3 MILES DROVE, WE PULL OFF A CAR AND TURNED ENGINE OFF. AFTER A WHILE, TURN IT ON AGAIN. A WARNING MESSAGE IS STILL ON. A CAR STILL SHOOK BACK AND FORTH WHILE WE DROVE AND RETURN TO HOME.

VEHICLE OPERATOR WAS TRAVELING TOO FAST WHEN MERGING, 65 MPH, THEN LOST CONTROL AND STRUCK A SAFETY BARRIER. A FEW MINUTES AFTER THE CRASH, A FIRE STARTED FROM THE FRONT OF THE VEHICLE. SEE ATTACHMENT. *TR*DT

FAILURE WITH THE TRANSMISSION WITH ONLY 8000 MILES

AFTER THE DRIVER I STOPPED AT A STOP LIGHT AFTER GETTING OFF THE FREEWAY, HE THE ACCELERATOR PEDAL AND THERE WAS BARELY ANY POWER. THE VEHICLE HAD TROUBLE ACCELERATING AND WAS PUTTING. THE DRIVER PULLED OVER AND CHECKED THE TEMPERATURE GAUGE, WHICH WAS FINE, AND THERE WERE NO BLINKING LIGHTS INDICATING ANY MALFUNCTION. THE DRIVER THEN PROCEEDED BUT THE VEHICLE WAS STILL PUTTING. AFTER PASSING THE NEXT INTERSECTION, THE DRIVER SMELLED AN ODD FUME. THEY PULLED OVER AND SAW SMOKE COMING OUT FROM UNDER THE HOOD. AS THEY PARKED THE VEHICLE, THE SMOKE TURNED BLACK. THE DRIVER THEN HURRIEDLY GOT OUT OF THE VEHICLE. THE VEHICLE WAS NOW ON FIRE AND THE DRIVER BELIEVES THEY SAW SOMETHING WAS LEAKING FROM THE VEHICLE. A BYSTANDER CALLED 911 AND FAIRLY QUICKLY, THE FIRE DEPARTMENT PUT OUT THE FIRE.