Ford Transit Connect 2016 — Problemas reportados

Upon auto inspection, I was informed that the subframe of the van was rotted and needed to be addressed. As the vehicle was not put into service until 2017, the van had less than 7 years on it at the time yet this bolt in member which supports the front lower control arms as well as the steering rack was severly compromised. Due to financial constraints, the member wasn't replaced until recently at which point there were multiple locations that the decay was so severe that one could fit both hands through the voids created by the rust. I spoke numerous times with Ford customer care which quoted body, not frame, rust through warranties. The cost to replace this is well over $3k and most dealerships refuse to do them. As has been reported to you before, this item has such a history of rust through that there is an open class action suit. I was lucky. The issue was found and repaired, at great expense, before either my steering or suspension failed.

The rearview camera on my 2016 Ford Transit 150 intermittently fails while the vehicle is in reverse. At times, the rearview mirror display shows a blue/blank screen instead of the rear camera image. At other times, the camera image appears reversed/inverted. Ford Safety Recall 25S89 includes certain 2016 Ford Transit vehicles for a rearview camera condition that can result in a distorted, inverted, or blank image. My vehicle is exhibiting these same symptoms, but VIN [XXX] is not currently included in the recall. I am concerned that the population of vehicles included in recall 25S89 may not include all 2016 Ford Transit vehicles affected by this rearview camera defect. The intermittent loss or incorrect orientation of the rearview image reduces rear visibility while backing and creates a safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford Transit. The contact stated that while reversing, the back over prevention camera malfunctioned and displayed an upside down or distorted image, with the distance being inaccurate. The contact stated that due to the failure, the vehicle reversed into a fence. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 25,000.

The contact owns a 2016 Ford Transit. The contact stated that while driving 50 MPH, the rubber-flexible coupling between the transmission became shredded into pieces and the vehicle swerved off the road. There were no warning lights illuminated. The vehicle was towed to the independent mechanic, who confirmed that the rubber transmission coupler had failed and needed to be upgraded to the metal version by the manufacturer. The local dealer was contacted and confirmed that the vehicle was previously repaired under NHTSA Campaign Number: 17V408000 (Power Train). The vehicle was not diagnosed or repaired. The contact called another local dealer, Winner Dover Auto Body Shop (591 S Dupont Hwy, Dover, DE 19901), but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 197,000.

The backup camera and parking collision warning periodically do not work and this resulted in a collision with a parked car.

On XXX at 1820 hrs CST I was traveling westbound on HWY XXX between [XXX] and Central [XXX] [XXX]. The weather was sunny, temp 88 degrees. As I was driving between 60 and 65 MPH with cars in front as well as behind me I heard a very loud “explosion” type noise. It was loud and quite scary and unexpected. The car then became very loud and windy. I was able to keep the car on the road, when I looked up I realized the panoramic window on the roof was mostly gone and damaged as well as the shade that covers the window. Looking in the rear view mirror I didn't see any other cars stopping or slowing and it appeared as if I was the only one affected. Backtracking to before my trip, I took my vehicle to Ford in [XXX] on XXX for three recall issues. Door latches, backup camera and panorama window issues. Later that day they called me to pick it up and said they had ordered parts for the recall items and would contact me when the parts were in. I advised the service tech I was going on a trip with the vehicle on XXX and needed to get things done before that time. He said the roof would need to be fixed by a glass company and they would coordinate when the other parts were installed. The vehicle went back to Sill- Terhar Ford on XXX and was returned on XXX. I asked about the window repair and was then told I would have to contact the body shop to get that work done. This work could not be done before my trip. I feel this recall is NOT been taken seriously by Ford or the dealerships and this could have killed someone behind me or I could have lost control of the vehicle INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I bought the car in 2017 with 7800 miles within the first few months. The rear camera began to freeze sometimes I once went to the dealer but they said they can’t find it because at that point in time it wasn’t freezing so they couldn’t do anything about it now at least 95% of the time the rear camera does not work either is upside down or it doesn’t work at all I see there has been a recall for my year similar vehicles for this problem of the rearview camera. For some reason my car was not included and I would like to log the complaint and hopefully get my car included. thank you so much.

The contact owns a 2016 Ford Transit. The contact stated that while attempting to reverse, the back over prevention camera was inoperable. The screen displayed a black screen or a blue screen. Occasionally, the back over prevention camera operated intermittently or displayed a message that the camera was currently unavailable. The contact referenced NHTSA Campaign Number: 25V572000 (Back Over Prevention); as a possible cause for the failure; however, the VIN was not included in the recall. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 170,000.

My 2016 Ford Transit experienced a sudden loss of engine power while I was driving on the highway. The vehicle entered limp mode, stalled, and emitted excessive black smoke from the exhaust, creating a hazardous situation for me and surrounding motorists. I was forced to pull off the roadway because the vehicle could no longer operate safely. When a warning first appeared, I promptly took the vehicle to an authorized dealer, the dealership preformed some type of update and a DPF regeneration and instructed me to drive the vehicle on the highway for 50 miles to complete the regeneration process, I followed these instructions. The light returned and the vehicle was inspected by another authorized Ford dealership, All-State Ford, which confirmed the condition covered under Ford Customer Satisfaction Program (CSP) 23M01 involving the catalytic converter system. The dealership confirmed that the required repair cannot be completed because Ford has not supplied the necessary replacement part after I called to get an update. Approximately five months have passed since the vehicle was diagnosed, and the required part remains unavailable. During this time, my vehicle has remained unusable. Ford has been unable to provide a repair date or any estimated timeline for when the part will become available. Ford’s response has been to direct me back to the dealership. However, the dealership has confirmed that it cannot obtain the part, provide a repair timeline, authorize reimbursement, or offer any alternative remedy because those decisions are controlled by Ford Motor Company. In researching this issue, I found online discussions from owners describing similar catalytic converter failures and extended delays across multiple Ford vehicle models. While I cannot independently verify those reports, they suggest this may not be an isolated incident. I respectfully request the NHTSA review whether the remedy offered under CSP 23M01 is adequately addressing the safety issue.

The back up camera is upside down

2 years ago (approx.) I brought my van to Sound Ford in Renton, WA. for the windshield recall. Two employees inspected my windshield and said they could not do the recall because they found a micro-pit in the glass. They told me to get my insurance to replace the windshield. I called my insurance but they said they won't replace the windshield unless it is cracked and I would have to pay a $100 deductible and Sound Ford is off the hook to do the recall. Since then I have been waiting for a crack to form but the windshield started to leak and on gravel and dirt roads the windshield started to vibrate. The vibration got so bad I had to duct tape the windshield on and tried to stop the leak with plumbers putty. I would like Sound Ford to complete the recall with no cost to me as stated in the recall. "FORD MOTOR COMPANY HAS AUTHORIZED YOUR DEALER TO RESEAL THE WINDSHIELD FREE OF CHARGE PARTS AND LABOR."

I purchased this vehicle, used, back in 2024 from STG Auto Group of Montclair. At the time I purchased the vehicle, they informed me there were no open recalls and ensured me the vehicle was safe to operate. About a year later, the driveshaft coupling (NHTSA 17V408000) completely sheared and I lost control for a bit on the freeway while trying to stop safely. Before I got the vehicle towed, I noticed the coupling was destroyed and it was all made of rubber. At the time I didn’t know about the recall repair that was supposed to replace this rubber coupling with a more robust version. Since I had a service contract with STG, they performed the repair and installed the same type of rubber coupling that had just been destroyed. I got the vehicle back and it drove fine for a few months, and last month the coupling blew out again. I did some due diligence and found out about the recall. I informed STG about it and they said the vehicle was sent to a dealership that is now out of business for the recall repair. The car has been sitting on their lot for over a month while they “source” parts and try to figure out who’s going to pay for repairs. Please help, I need the vehicle back to transport my family.

The contact's son-in-law owns a 2016 Ford Transit. The contact stated that while her son-in-law was driving at highway speeds, an abnormal, popping sound began to emit from the vehicle. The contact also stated that white steam began to emit from the engine as her son-in-law pulled over and had the vehicle towed to an independent mechanic. The mechanic performed an inspection and determined that the driveshaft flexible coupling had cracked which lead to transmission damage. Upon investigation, the mechanic discovered NHTSA Campaign Number:19V767000(Power Train) which he linked to the failure. The contact then had the vehicle towed to a dealer where they acknowledged the recall; however, they informed the contact that the transmission was not covered under recall and the contact was given an estimate for the transmission repair. The contact contested that her son-in-law never received a recall notice about the recall; therefore, the manufacturer should be responsible for the repair. The manufacturer was notified of the failure and stated that it was the owner's responsibility to alert them of any address changes and they are not responsible for the contact not being aware of the recall. The contact was given a case number. The vehicle was not repaired. The failure mileage was approximately 105,000.

Recall Number: 19S38 (Ford Transit Driveshaft Flexible Coupling) Subject: Inaccurate Recall Reporting Statement of Fact: I am reporting a discrepancy between physical vehicle evidence and official dealership records regarding the completion of Safety Recall 19S38. Conflicting Records: On April 8, 2026, Crossroads Ford of Apex issued Invoice #XXX stating the recall was performed with parts CK4Z-4602-N , CK4Z-4421-F , CK4Z-4635-A , and JK4Z-5A669-A. However, on April 14, 2026, the Service Manager issued a "corrected" Invoice (#XXX) stating: "No parts were installed for Recall 19S38." Physical Evidence: A video documented physical inspection of the vehicle on April 15, 2026, confirms that all recall-specific parts are currently installed on the vehicle and they appear in new condition. The dealership’s written denial of the April 8 recall repair appears intended to avoid refunding a $6,394.33 retail repair for the same components, which was performed while Safety Recall 19S38 was active and unaddressed. Implications: The dealership has issued a formal written denial of a safety repair that is currently physically present on the vehicle. This falsifies the safety maintenance history of the vehicle and misrepresents the status of the safety remedy to federal authorities. Physical Documentation: The following link is an unlisted video documentation of the physical parts currently installed on the vehicle (VIN [XXX] ). It is provided for regulatory investigation purposes only: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear camera image has inverted, unable to see clearly, FORD did not add my vehicle to NHTSA RECALL CAMPAIGN 25V572000

I own a 2016 Ford Transit (VIN [XXX] ) and the rear camera goes blank when the car is going in reverse. Currently, my VIN is not included in the recall even though the year, make, and model is within the range. It has the same issue as described here on your page [XXX] and I am hoping that Ford will extend it to my VIN as well. I have contacted them separately to let them know of the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The backup camera on my Transit does not work. When in reverse the screen turns blue or says camera not available. It has shown the image upside down a few times, but it never works for more than a few seconds. I just bought this vehicle in November, and it has been doing this the entire time it has been in my possession.

The contact owns a 2016 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that while shifted to reverse(R), the rearview camera image failed to display a clear image. The local dealer advised the contact that the recall warranty had expired. The vehicle was not repaired because the VIN was no longer under recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

Rear view camera has sometimes screen has inverted view, totally blank, and even blue screen, sometimes works for a few seconds and then goes blank

The contact owns a 2016 Ford Transit. The contact stated that while driving at various speeds and accelerating, the vehicle was shaking and vibrating abnormally. The vehicle was slowly driven to the local mechanic to be diagnosed, and it was determined that the driveshaft coupling had failed and needed to be replaced. The driveshaft coupling was replaced, and the vehicle was repaired; however, months later, the failure reoccurred. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 19V767000 (POWER TRAIN). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 100,000.

This complaint is specifically related to Ford Recall 16S32 / NHTSA Campaign 16V618000 regarding the High-Pressure Fuel Pump (HPFP) failure. ​My vehicle (VIN: [XXX] ) has experienced the exact mechanical failure described in this recall, resulting in metal debris throughout the fuel system and a sudden loss of engine power while driving. This created an immediate safety hazard on the road. ​Ford is currently denying assistance because my vehicle’s production date falls just one day (24 hours) outside the official recall window. It is mechanically impossible for a manufacturing defect present in the recalled batch to not exist in a vehicle produced only 24 hours earlier. ​I am requesting that NHTSA investigate this arbitrary 1-day exclusion. Ford should not be allowed to avoid responsibility for a known safety defect based on a marginal production date error, especially when the failure and the parts involved are identical to those covered under the recall INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Was driving to work passenger front wheel locked overheating brakes and smoking had to have towed to jones ford in Shalotte North Carolina today

The rear view camera freezes or distorts or is just blank very often. I see a recall for Transit vans from my year for this problem but mine isn’t included.

The contact owns a 2016 Ford Transit. The contact stated that while driving at various speeds, the vehicle stalled. During the failure, the warning message "Reduced Power" was displayed. The contact stated that after restarting the engine, the vehicle operated as intended; however, the failure reoccurred later. The vehicle was taken to the local mechanic who replaced the fuel injector, but the failure reoccurred. The vehicle was later towed to the local dealer, where it was diagnosed that there were metal shavings in the fuel system. The dealer determined that the entire fuel system needed to be replaced, including the fuel pump, the fuel valves and the fuel injector. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 16V618000(Fuel System, Diesel, Engine and Engine Cooling), which the contact related to the failure. The vehicle was not yet repaired. The failure mileage was 165,000.

The contact owns a 2016 Ford Transit. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the engine revved, and the vehicle lost motive power. The vehicle was driven to the shoulder of the roadway. No warning lights were illuminated. The vehicle was turned off; however, while the contact's wife was attempting to restart the vehicle, the vehicle failed to restart. In addition, the contact stated that the failure had occurred while his wife was driving with children inside the vehicle. The vehicle was towed to the dealer where the failure was associated with an unrepaired recall. The contact was notified of NHTSA Campaign Number: 19V767000 (Power Train). The VIN was associated with the recall. The dealer submitted the repair request to the manufacturer. The manufacturer was made aware of the failure, and a case was file,d but the repair was denied. The contact was informed that the repair was not covered under warranty. The contact then submitted a copy of the recall to the manufacturer and was informed that the repair was not covered because the recall was not performed in the required time frame. The failure mileage was approximately 160,000.

See attached document for complaint.

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, the glass panel from the sunroof unexpectedly detached from the vehicle. The vehicle was taken to the dealer, where it was determined that the adhesive securing the sunroof glass had failed, causing the panel to detach. The contact was informed that the adhesive needs to be replaced to reattach the glass panel. The vehicle was not repaired. The contact expressed concerns that the failure had made the vehicle unsafe and that the children no longer wanted to ride in the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 165,000.

The car has the same problem it had before the recall. The dealer who supposedly fixed it says it's no longer under the recall warranty.

All these problems started when the rear camera quite working.

Rear view camera either goes out or is upside down. Went out so hit something. Luckily no real damage. Went to dealer and they said it’s not part of recall

The vehicle back up camera goes out when reversing. Not every time, but intermittently, maybe 50% of the time. The screen goes blue, followed by the message "Rear View Camera Not Available." This makes it incredibly challenging to see pedestrians or cars directly behind the vehicle. It has not had it confirmed by a dealer; the local dealer said there was nothing yet in their system stating a recall on the vehicle. The NHTSA Advance Notice Safety Recall 25S89 specifically calls out the vehicle as being potentially affected, based on assembly plant and build dates. I have not had it inspected by the manufacturer, police, insurance representatives, or others. There have been no warning lamps. Just the screen going blue, followed by the message "Rear View Camera Not Available"

The brakes suddenly locked up while I was driving which could have caused an accident. Luckily it did not cause me to swerve into oncoming traffic and no one was behind me at the time. This was caused by the ABS unit hydraulic control assembly. It was the right front and left rear calipers locking. My vehicle only has 44,401 miles on it. The diagnosis has been confirmed at the dealer. There are other 2016 Ford Transit connect models that have had a safety recall for this specific component, but mine is just outside of the vehicle recall time period by a few months. It was manufactured at the same plant. Additionally, I wanted to add that there were no warning lights, though I noticed a very slight drag when first accelerating (a few days prior) but didn't think much of it. I wondered if I was just imagining things. It wouldn't have been noticeable to someone who wasn't used to driving it. I contacted Ford and they would not provide any assistance other than me having to start a case (in other words, I have to spend $2,100 to get it fixed at the dealer; also I can't get it fixed anywhere else because the dealer has to program it.)

The rear back up camera is very hit and miss….. works sometimes and not other times. Shows blue screen color,black screen color when it does not work.

Summary of Complaint: The brake lines on my vehicle failed at highway speed (75 mph on I-65) while my wife and eight children were inside. This sudden failure created an extremely dangerous, life-threatening situation. Fortunately, we were able to avoid a crash, but this could easily have caused multiple fatalities. Details: We purchased this vehicle used at approximately 60,000 miles. I was never notified by Ford, the dealership, or NHTSA/DMV of any requirement for interim recall repairs every 40,000 miles. During a service at Antioch Ford, I was told there was an open recall but that parts were unavailable. I was never contacted again by Ford or the dealership with instructions to remedy the defect. Ford has since confirmed in writing that the recall requires interim repairs every 40,000 miles but claims they will not assist financially since my vehicle has not had those interim repairs. As a second owner, I had no knowledge of this requirement because I never received recall letters or notices. Safety Concern: This is a serious safety defect that nearly caused catastrophic injury or death to my family. The manufacturer has acknowledged the recall but is refusing assistance, citing “policy,” even though I was never notified of the required interim repairs. Ford has also attempted to close my case as “inactive” without resolution. Requested Action: I am requesting that NHTSA investigate Ford’s handling of this recall, specifically: Whether Ford properly notified subsequent owners about interim recall repair requirements. Whether Ford should be compelled to remedy this defect at no cost, given the severity and risk to public safety.

I am a victim of odometer tampering, the odometer has been rolled back and I traded my truck for it under the premise that it had 57000 miles. I am currently taking the perpetrator to civil court to recuperate the money that is owed me by the low mileage fraud, in Cincinnati OH, Hamilton County. I would like to see this scum prosecuted because of this horrible crime. I have talked to the local police but they did nothing at all about it and said they couldn’t, I was trying to look at other outlets and hopefully I have found the right one because it seems like nobody can do anything about it and even though a crime happened people want to sweep it under the rug, I want justice and to see this scum go to jail.

Ford automotive previously repaired the flexible driveshaft coupling, on my vehicle at about 57k miles, under recall 19S38. That exact same part failed prematurely, yesterday, at about 110k miles. I just contacted Ford and they said it was a permanent fix and no further recalls have been issued.

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving at various speeds, the rear sliding door failed to remain securely closed. The local dealer was contacted; however, the contact was advised that the failure was not related to a recall. The vehicle was not repaired. The contact related to the failure to NHTSA Campaign Number: 23V502000 (Latches/Locks/Linkages). The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 20V260000 (VISIBILITY). The contact stated that while one of the employees was driving at various speeds, the sunroof collapsed. The local dealer was contacted. The vehicle was repaired. The contact noticed that the sun visor was not installed. The contact returned the vehicle to the dealer however, the dealer refused to complete the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 91,387. Parts distribution disconnect.

The contact owns a 2016 Ford Transit. The contact stated that while driving 45 MPH, the vehicle lost motive power. The vehicle was pulled over to the side of the road and restarted. The contact stated that when the vehicle was shifted into drive(D), and the accelerator pedal was depressed, the vehicle failed to accelerate. The vehicle was towed to a dealer where it was diagnosed that the axle was severed in two and needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 96,000.

The contact is a lawyer whose client owned a 2016 Ford Transit. The contact stated that while driving at 30 MPH, the drive shaft coupling detached from the transmission. The contact stated that the air bags deployed in his vehicle. The contact stated that he sustained head and back injuries. Medical attention was required. The contact stated that a police report was filed. The contact mentioned the seat belt retracking was unknown. The contact mentioned the vehicle was towed to an unknown location. The vehicle was deemed a total loss. The manufacturer was not notified of the failure. The contact related to the failure to NHTSA Campaign Number: 19V767000 (Power Train). The failure mileage was unknown.

I am writing to report a serious and recurring safety issue with my 2016 Ford Transit Connect. On four separate occasions, the rear sliding doors on both the driver and passenger sides have completely detached from the vehicle during the normal process of closing them. These incidents occurred without the application of any excessive force or unusual use. The doors unexpectedly slid off their tracks and fell from the vehicle, creating a dangerous situation. Each time this occurred, my family was left stranded, unable to complete our trip or return home safely. As a result of this repeated failure, I have avoided using one of the sliding doors for over a year out of fear that it was not properly re-secured and could fall off again. This issue represents a significant safety concern, particularly for families relying on this vehicle for daily transportation, and I believe it warrants immediate attention and investigation.

I was driving for approximately 6 hours in the rain. When I returned to my home location and filled my vehicle,I only got 14 mpg. Nirmally 17-19mpg. So I figured its been a while since Ive changed thecair filter. So I proceeded to change the air filter. It was completeky saturated with water.I am surprised I made it back through the mountanious area w no cell phone connectivety w passengers. I research what I believe is the oroblem The air intake is located directly behind the front grill next to passenger side headlamp. It has a plastic tube (as a air tunnel) that goes into the botton of the air intake bosmx, in which the filter is on to, letting aur to get through to the engine. From the firce of driving, raining and the engine sucking in air. It almost cacumed the rain into as well. The air intake needs to be revised. Befire a engine stall occurs and loss power and control.

Recurring Intermittent abrupt downshifting to first gear at highway speeds.

DRIVING DOWN THE HWYWAY THE TRANSMISSION WILL KICK OUT OF SIXTH GEAR . SOMETIMES IT GOES TO FIFTH. SOMETIMES IT GOES TO FORTH. SOMETIMES IT JUST DISCONNECTS. IT IS THE SAME PROBLEM YOU Are reporting on with the F150. MINE IS THE SAME YEAR AND THE SAME MOTOR AND TRANSMISSION AS THE F150 BUT I HAVE THE TRANSIT VAN T350. WHEN IT DOES THIS IT SAYS MOTOR FAILURE ON THE DASH, SERVICE IMMEDIATELY. BUT IT IS NOT THE MOTOR. THE MOTOR IS RUNNING FINE. IT IS THE TRANSMISSION. THIS HAPPENS EVERY 30 TO 70 MILES OF DRIVING FOR THE LAST TWO WEEKS. THE PROBLEM STILL EXISTS. WILL FORD FIX IT OR DO I HAVE TO.

The contact owns a 2016 Ford Transit. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.

The contact owns a 2016 Ford Transit. The contact stated that while driving at an undisclosed speed, an abnormal sound was coming from the vehicle while turning to the left or the right. The vehicle was taken to an independent mechanic; however, no cause for the failure was found. The contact stated that the failure persisted. The contact stated that on a separate occasion, the front driver's side seat belt failed to latch securely. The "Seat Belt" warning light was not illuminated. The vehicle was not repaired for the most recent failure. The manufacturer was not notified of the failure. The failure mileage was approximately 42,000.

I was going up hill and I heard a pop and smoke started to come out form the center console and then the truck burst into flames

Failed Reductant Heater, poor SCR performance (requiring a new SCR) and EGR failure at 8 years, 132k miles

dealership AL Packer Ford on 1530 N Military Trl, West palm Beach FL 33409 refuse to fix the Manufacturer Recall Number 22S20 (NHTSA Recall Number 22V192), they have to remove the windshield and resealed but they hire an company to do it, so the "company' went and check my windshield and they said they can not do it bc they find and crack(which I've never see) and the windshield can the windshield can collapse in the process, the dealer says they won't take care of the windshield if this happens, I called Ford but they say they won't take care of it either, that I can only resolve it with the dealer but they refuse to cover it, and it's not my fault that they used the wrong adhesive for the windshield and now they have to remove it, they recommended that I talk to my insurance but insurance won't cover it and it's crazy that they won't cover it when it's their fault, how do they know that the windshield doesn't have the crack because of the defect in the adhesive

I was not made aware of the recall. The driveshaft separated while I was driving, causing significant damage to other parts of the vehicle, including the transmission, motor and transmission mount, cooling, electrical and brake and transmission lines, oil and fuel parts, and much more underneath the van. This happened after a very brief hard vibration moments before it “exploded” and sent me flying into the air and coming to a very quick stop, which also caused medical issues. Ford is refusing to repair all that their recalled part damaged claiming they “notified me” but I haven’t received such notice. I stay up on all maintenance and repairs for my van, and the dealership acknowledged that when looking at the vehicle history reports.

•What component or system failed or malfunctioned, and is it available for inspection upon request? Unknown •How was your safety or the safety of others put at risk? Van completely shuts down, lights on dashboard shut off, can’t not accelerate or brake, and hazard lights do not turn on. •Has the problem been reproduced or confirmed by a dealer or independent service center? Problem could not be reproduce at Ford the second time. The first time this happened, the Van was serviced at Ford for over 2 months for the same issues. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been serviced by Penske & Ford. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights or messages, these issues comes up randomly and shuts the vehicle down completely.

The contact owns a 2016 Ford Transit Connect. The contact stated that the ABS warning light was illuminated. The contact stated while driving at undisclosed speeds, the vehicle stalled. There was smoke coming from the rear of the vehicle. The vehicle was taken to an independent mechanic, who determined that the brakes and calipers needed to be replaced. While the mechanic was test driving the vehicle, the vehicle stalled. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact called another local dealer, Wayne Ford (444 US-46, Wayne, NJ 07470); but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 33,000.

The contact owns a 2016 Ford Transit. The contact stated while driving 40-45 MPH, the message "High Temperature - Pull Over Safely" was displayed. The contact stated that upon decelerating, the temperature gauge dropped, then started fluctuating from normal to high temperature. The contact was able to drive to the nearby residence. The contact stated while driving to the dealer the following day, the check engine warning light illuminated. The dealer diagnosed that the EGR was fractured. The vehicle was not repaired. The dealer informed the contact of Ford Campaign Number: 18M06; which the contact related to the failure. The manufacturer was notified of the failure and informed the contact that the campaign had expired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 150,000.

The vehicles front driver side wheel brakes keeps receiving too much pressure causing the brake pads to stick and the wheel to get hot and to shake the steering wheel. I have had the caliper replaced twice, the flex bake hose replaced as well, replaced brake pads and rotor and after the most recent diagnosis, I was told that the issue is the HCU. Ford has had issues with this model and you can see under campaigns 16C10/16V482 where this exact issues was happening was being experienced. I believe that they failed to fix the issue when they produced the car I have and are refusing to fix it. When I first experienced the issue my rotor was smoking and the wheel was extremely hot which is an extreme hazard that ford should be made responsible for.

The contact owns a 2016 Ford Transit Connect. The contact stated while driving 65 MPH, the transmission downshifted to 1st gear without warning. The contact continued driving and while coming to a stop light the failure recurred. The contact attempted to accelerate when the light turned green, and the vehicle inadvertently shifted into neutral, and the contact nearly crashed into another vehicle. The contact pulled the vehicle over at a gas station and had the vehicle towed to a local dealer where the cable shifter bushing was replaced. The vehicle was repaired. The manufacturer was notified of the failure; however, no assistance was provided. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Transit Connect. The contact stated that while her husband was operating the vehicle, the front driver side door failed to shut closed. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that the door latch needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V502000 (Latches/Locks/Linkages). The dealer informed the contact that the recall was expired. The manufacturer was made aware of the failure and confirmed that the recall had expired. The failure mileage was approximately 200,000.

While driving on the highway, the Panoramic Roof Window started lifting up along the leading edge of the glass panel. I was to slow down and get off the highway before the panel came completely out of the recessed window frame. Ford has told me that my VIN shows the recall repair on the roof was performed already by Ford for a previous owner. A local Ford dealership looked into redoing the repair under a replacement warrenty, but was told it is not covered because the recall work was down more than 2 years ago. This seems a problem to me. The panoramic window is a fixed glass pane. Recall repair for this should last for the life of the car, not two years. I beleive the repair of the window does not actually solve the documented recall problem effectively.

Ford Transit Connect passenger van with a panoramic view roof window. Driving on the highway, when air starting rushing into the cabin via the glass roof. I was able to pull over before the whole panel blew off. The Front (leading) edge of the glass roof panel is now loose. I can push up on the glass panel and the front edge comes up at least a 1/2 inch now. Ford has a recall listed on the roof panel aleady, but they say my car is not covered by the recall. Campaign/NHTSA# 20S22/20V260 Issue Date 2020-05-08 Description On your vehicle, the panoramic roof glass panel may not be properly bonded to the vehicle, which may result in wind noise, water leaks, and in some cases, separation from the vehicle. Safety Risk This may result in separation of the entire panoramic roof panel from the vehicle while driving increasing the risk of a crash or injury. Remedy Parts are now available to repair your vehicles. Ford Motor Company has authorized your dealer to remove, clean, and reinstall the panoramic roof glass free of charge (parts and labor).

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving 65 MPH, the vehicle lost motive power. The accelerator pedal was depressed but the vehicle was slow to move. The engine HOT message was displayed. There was an unknown running sound detected. The vehicle was towed to an independent mechanic, and an unknown repair was performed. The vehicle was towed to the local dealer, where it was diagnosed that water had leaked into the engine from the front windshield. The vehicle was repaired. Additionally, the contact stated that the window was replaced but was installed incorrectly. The weather strip was detached. The manufacturer was contacted, and informed the contact that there was no warranty coverage on the vehicle. The failure mileage was approximately 73,000.

The contact owns a 2016 Ford Transit Connect. The contact stated that while initially starting the vehicle and while driving at various speeds, the main computer screen displayed the “Hill Stop Assist Not Available" and "Parking Assist Not Available" messages. The check engine and ABS warning lights were illuminated. The speedometer, power steering, and several other unknown messages were displayed intermittently. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to the dealer after the original failure and was diagnosed and determined that the front passenger’s side wheel position sensor had failed and needed to be replaced. The vehicle was taken to an independent mechanic after the second failure, and it was determined that the same front passenger’s and driver’s side wheel position sensors had failed and needed to be replaced. The contact was informed that the steering wheel position sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The approximate failure mileage was 70,000.

Going down highway at 70 mph, no power all of a sudden. No warning. Made it to the side, stranded. Transmission needs to be replaced, 83000 miles

The contact owns a 2016 Ford Transit Connect. The contact stated that cracks had formed in both taillights which lead to water accumulation inside the taillight housing. The vehicle was taken to a dealer and the contact was informed that moisture had leaked into the taillight wiring harness and both taillight sensors and sensor harnesses need to be replaced. In addition, the taillight wiring had begun to hang from the rear of the vehicle, causing the exhaust pipe to melt the wiring harness. The dealer informed the contact that the taillight sensor could not be repaired due to the part being on backorder. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

Calipers and brake pads were replaced and still front brakes locking up. Unable to drive. Also, I had to replace a brand new brain on the van over $3000 electrical. The contact stated the vehicle is not working and needs help.

The contact owns a 2016 Ford Transit Connect. The contacted stated that while driving approximately 55 MPH, the braking system malfunctioned, causing the vehicle to abruptly stop in the middle of the freeway. The vehicle was later towed to the local mechanic who diagnosed that the brake system HCU pump had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electronic Stability Control). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not contacted. The failure mileage was 91,000.

Recall Issue with Vehicle Door Latch and Delays in Repair - NHTSA Recall Number 21V376 To whom it may concern, I am writing to report a significant safety concern regarding my vehicle. Specifically, the driver's door latch is malfunctioning and no longer securely locks the door, rendering the vehicle undriveable. This issue directly aligns with the advanced recall notice identified as NHTSA Recall Number21V376 and Manufacturer Recall Number 21S24. To seek a resolution, I reached out to local Ford dealerships, but initially faced challenges in even having a conversation about potential recalls. Fortunately, Future Ford of Roseville accepted to inspect my vehicle and I delivered it to their facility on August 23rd, 2023. One of their service managers indicated that they should be able to address the problem, especially since my car exhibits the symptoms detailed in the recall notice. However, it's September 1st now, and my vehicle remains in their possession with little to no updates. The only communication I received was a work order summary. Troublingly, this document states: "FORD DECLINED AUTHORIZATION TO REPAIR AT THIS TIME" regarding the advanced recall. Attempts to discuss this update with the service manager, [XXX] , have been unproductive. She briefly left a voicemail without pertinent details and despite promising a follow-up call, failed to do so. Furthermore, I reached out to Ford corporate for clarity but to no avail. I've consistently received vague answers, with most indicating a lack of direction from Ford. This is both alarming and frustrating. I am at a loss as to why the dealership can't take an interim measure, such as replacing the defective door latch—which has been acknowledged to degrade over time—to temporarily remedy the situation. This could serve as a temporary solution until an official fix is determined. Attached is the aforementioned work order summary for your reference. I urge you to consider the safety implications of INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Van was taken to Mooresville Ford for routine maintenance. When picking up the van the service mng informed me that some of the lug nuts are "swollen" and the tire iron supplied with the vehicle will no longer fit on the lug nut. I will not be able to change a flat tire until they are are replaced. I have both a premium extended warranty and platinum service contract but the dealer would not cover the lug nuts and if I wanted to pay out of pocket they would be replaced with the same lug nuts that would eventual become "swollen" again. I was advised to buy aftermarket lug nuts and put them on. It's pretty clear after doing a little research that this is a common problem that should result in a recall and replacement of the lug nut to avoid leaving car owners stranded in remote locations or anywhere for that matter. Also the tire rotation portion of the service which is part of the service contract was not able to be done due to the swollen lug nut. We were told that the lug nuts will be damaged when they attempt to remove them and won't be able to put them back on. I don't understand why Ford doesn't fix this problem but they won't until they are forced too. Please issue a recall.

Vehicle was taken into the Fleet Division of Joe Cooper Ford on or around March 30th 2023 for the Active Windshield recall. On that visit, they were notified that the windshield had already been replaced by Safelite on March 18th 2021 due to a crack that compromised the windshield's integrity. After the vehicle being in their possession for ~13 days, they stated that all they needed was a copy of the invoice and that the recall information would be sent to Ford and the recall alert cleared. I provided a physical copy at the same time I picked it up and as of this moment the recall still has not been cleared. This is a fleet vehicle, so I am notified regularly that I still have not had this taken care of. I called Joe Cooper back on two occasions to check up on the status, with the last time being July 3rd, 2023 in which they requested I email copies of the Safelite Invoice again. Attached is the Invoice from Joe Cooper as well as the invoice from Safelite confirming full windshield replacement using an aftermarket Fuyao windshield. I cannot get an answer as to why there is a hold up so I cannot tell if this is an issue on Ford's part or the dealership. I am, however, looking to resolve this issue.

The contact owns a 2016 Ford Transit Connect. The contact stated while an employee was driving 55 MPH, the vehicle decelerated unintendedly. The contact stated no warning light was illuminated. The contact took the vehicle to an independent mechanic however, the mechanic was unable to duplicate the failure. The contact stated on July 14, 2023, while the same employee was driving the vehicle and was releasing the brake pedal, the vehicle started losing motive power and slowed unintendedly. The contact stated no warning light was illuminated. The employee continued driving to the independent mechanic and was informed that the brake rotors, brake pads, and the front driver’s side and the rear passenger’s side calipers needed to be replaced. The vehicle was repaired however, the mechanic then stated that the Hydraulic Control Unit (HCU) pump was faulty. Upon investigation, the mechanic associated the failure with NHTSA Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electrical System) however, the VIN was not included. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the Hydraulic Control Unit (HCU) pump to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 50,000.

The contact owns a 2016 Ford Transit Connect. The contact stated while driving at an undisclosed speed, the vehicle was vibrating. The rotors then overheated, causing the brakes to seize. The vehicle was taken to an independent mechanic, who replaced the calipers, brakes, and rotors; however, the failure recurred. The vehicle was then taken to the dealer, where it was diagnosed that the hydraulic control unit (HCU) needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and confirmed that the vehicle had previously been serviced under NHTSA Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electronic Stability Control). The manufacturer informed the contact that the vehicle was out of warranty. The failure mileage was approximately 128,000.

The ABS control/hydraulic unit failed over a period of months. At first I thought it was a master cylinder issue and replaced that but it did not cure the problem. My wife had an issue several times where she thought the transmission was acting up but I could not replicate it, until the brakes really started to lock up. It got to the point where the brakes would stay locked up after any application and would slowly release after five to fifteen minutes. I had the dealership look at it and explained what I had found. If you cracked the metal brake line to hose connection at the right front and left rear, the brakes would release. The dealer did not agree with me, they wanted to replace the entire base braking system. I pulled it out of the dealer and took it to an independent repair shop. The part is presently in the hands of the repair garage but has a core charge on it. The component has not been inspected by anyone. No warning lamps appeared at any time.

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving at an undetermined speed, the ABS, stability control, and traction control warning lights illuminated. There was an abnormal dinging sound detected. The brakes, power steering and speedometer became inoperable. The vehicle was taken to an independent mechanic who was unable to duplicate the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electronic Stability Control). The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

The contact owns a 2016 Ford Transit Connect. The contact stated while driving at 20 MPH and coming to a complete stop, the brake pedal was depressed and the vehicle stopped. However, as he released the brake pedal to drive from the complete stop, the vehicle failed to move. The contact depressed the accelerator pedal and the vehicle responded at a significant low speed. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle was towed to an independent mechanic where it was diagnosed that the front brakes and the rear driver's side brake were not releasing pressure upon depressing the brake pedal. The independent mechanic diagnosed that the brake hydraulic control unit (HCU) pump had failed and needed to be replaced. The dealer and the manufacturer were notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electronic Stability Control) as the VIN was not included. The vehicle was not repaired. The failure mileage was approximately 72,000.

The contact owns a 2016 Ford Transit Connect. The contact stated that while making a right turn, the steering wheel seized and excessive force was required to turn the steering wheel. No warning lights were illuminated. The vehicle was then taken to an independent mechanic, where it was diagnosed that the electronic power steering (EPS) needed to be replaced. The vehicle remained with the independent mechanic awaiting the repair. The manufacturer was made aware of the failure and confirmed there was no power steering recall for his VIN. The approximate failure mileage was 102,000.

The contact owns a 2016 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 20V260000 (Visibility) and 22V192000 (Visibility). However, the parts to do the recall repairs were not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact called another local dealer, McLarty Daniel Ford (2609 S Walton Blvd, Bentonville, AR 72712) who informed the contact that the repairs may be completed at the body shop. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact called in regard to a 2016 Ford Transit Connect vehicle owned by the U.S. Army. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 22V192000 (Visibility) however, upon contacting the dealer four weeks later, the dealer informed the contact that the vehicle had been taken to a third-party technician where the windshield was cracked in the process of completing the recall repair. The dealer informed the contact that they were awaiting the part to replace the windshield. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was made aware of the issue and informed the contact that the part would be available in October 2022. The contact stated that the vehicle had been at the dealer since June 15, 2022. The vehicle was not repaired. The failure mileage was approximately 23,296. Parts distribution disconnect.

The contact owns a 2016 Ford Transit Connect. The contact stated while at a stop light and attempting to accelerate, the vehicle would not accelerate due to the anti-lock braking system not releasing as needed. No warning light was illuminated. The vehicle was taken to an independent mechanic and he stated that the vehicle was experiencing the failure stated in NHTSA Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electronic Stability Control). The vehicle was not repaired. The manufacturer was contacted and stated that the VIN was included in the recall. The failure mileage 110,000.

Some portion of the brakes master cylinder degraded into small pieces and were found in the brake lines by a Ford Dealership technician. While traveling on highway at highway speeds (70mph), about an hour into a trip, the brakes locked on which caused vehicle to travel into the median and slide sideways. The vehicle had to be coaxed (put in manual mode), to get it off highway and limped to dealership. The technician replaced the master cylinder and noted the debris in the brake lines, therefore, he bled all the brake lines to clear the debris. There was no accident (luckily it was avoided), therefore, no insurance or police inspection. Only inspected by Ford dealership personnel. The only warning lamp that was illuminated was the tire pressure warning, since a spare tire was being used at the time.

My Passenger Seat Occupancy Sensor failed. Caused my airbag system to throw a code and become inoperative and SRS light on. Took to Middleton Ford in Middleton, WI and they confirmed the code indicated the OCS sensor has failed and required replacing to make the airbag system operable again. Meaning if I got into an accident, no airbags would deploy while the defective OCS sensor is in place. My insurance refused to inspect or cover the sensor as the failure wasn't related to an accident. Middleton Ford refused to cover the replacement cost regardless of cause of failure and said I must pay for the repair as my van was out of warranty. The sensor was replaced on 08/22/22 and see attached pics to prove the sensor had no visual issues and the cause of said failure is a manufacturer defect. Consumers should never have to pay for a defective part that failed due to no fault of their own.

My SRS system has thrown the SRS light with code B00C0:11AB Passenger Occupancy sensor A short to ground. According to The weight pad is faulty and requires a $989 part replacement. The SRS system is disabled with the light on which is a safety issue in today's vehicles as none of the airbags will deploy in an accident with the SRS light currently on. No consumer related malfunction detected meaning there were no broken wires found nor evidence of a consumer triggered fault found such as wet or previously wet pad which could have caused the fault. It is an internal part failure.

The contact owns a 2016 Transit Connect. The contact stated that while attempting to operate the vehicle, the transmission failed to shift into either drive or reverse. The vehicle was taken to an independent mechanic who diagnosed that the transmission was faulty and needed to be replaced. The transmission was replaced and the failure was remedied but eventually the failure reoccurred. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 180,000.