Ford Ranger 2019 — Reported problems

Rear Camera - Back Over Prevention - I took it to the dealer, they said there is no recall for my vehicle. It is currently available for inspection but I will need to get it fixed. Safety risk is elevated due to inability to fully see surroundings/people/children/pets, etc. behind the vehicle. The dealer saw that it is not working but I did not pay them to diagnose or inspect so they did not. There were no warning lamps, messages or other symptoms prior to the failure. The first appearance was today, 10/7/2026 while at the dealer for an oil change.

Defective heat/ac blend box assembly. No heat or, more importantly, windshield defroster. Appears to be a common issue on this vehicle model.

Driver side rear leaf spring cracked at front mount. This happened with low mileage 20k and no towing or off-road driving. In town driving only.

My 2019 Ford Ranger with 10 speed transmission has been harsh shifting and will not always find the right gears. It will sometimes Surge forward or at other time not respond to acceleration. It has 100,000 miles. Never used it for towing or hawling heavy items.

My 2019 Ford Ranger, VIN 1FTER4FH2KLA63893, experienced a major transmission failure at approximately 35,000 miles. I took the vehicle to a Ford dealership for diagnosis and was advised that the transmission required major repair/replacement, with an estimated cost approaching $9,000. I also obtained an independent transmission repair estimate of approximately $6,700–$7,000. Given the extremely low mileage and the repair cost relative to the vehicle’s value, repairing the truck no longer made financial sense. The transmission failure substantially reduced its trade value and is forcing me to replace a vehicle that I otherwise intended to keep. I estimate the resulting loss of equity at approximately $7,000, in addition to the financial impact of prematurely taking on another vehicle and associated financing. After the failure, I learned of ongoing litigation involving Ford’s 10R80 10-speed transmission, including allegations involving 2019 and 2020 Ford Rangers. I am reporting my experience so this failure is formally documented and can be considered in connection with any investigation, litigation, warranty extension, recall, or other potential remedy involving the 10R80 transmission.

The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the necessary limited movement. This low-tech hose solution causes outsized damage when it fails, effectively disabling the vehicle which creates a safety concern and undue hardship from an unnecessarily cascading damage effect. Ford acknowledges this defect by redesigning this feature for 6G Rangers but will not proactively correct through manufacturer recall 5G Rangers. If Ford will not correct, I believe the NHTSA should get involved and force Ford's hand at addressing this repair.

Auto transmission is failing to shift when taking off from a stop or hesitating to shift to next year causing traffic behind me to get close to rear bumper.

1st I reported to Ford that when my truck was in park and off, it started rolling down a hill. I jumped in and stopped it. Ford said they see nothing and everything looks fine. Since then I use the emergency break every time. 2nd, you feel the transmission shifting hard. Jerks truck. Also, if you drive around 25 mph, the truck starts jerking like it cant make up its mind what gear to be in.

Weak steel from connection point of rear leaf springs failed, leaving the springs unconnected at front eye of connection point

I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had to do my own preventative measures to seal the windshield cowl. I contacted Ford and they were only willing to reimburse me $725 dollars of my repair bill which was 100% their fault.

The Ford 10R60 and 10R80 transmission has become a hazard on the road. Please see TSB 23-2250. My Ranger only has 43,000 miles on it and is dangerous to drive because of the stuttering and lunging of the transmission. Ford is perfectly aware of this situation but won't fix vehicles that are out of the 5 year warranty at no cost to the owner. No transmission should be faulty after only 43,000 miles. I am requesting that you please investigate this situation as I believe it should be a recall. - Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The transmission has issues not shifting gears and having loss of power when pulling out into intersections that are getting worse with time.

I am submitting this complaint regarding my 2019 Ford Ranger because I discovered what I believe to be a serious safety defect involving the rear leaf spring mounting system. My vehicle has approximately 55,000 miles and has been used primarily as a commuter vehicle for driving to and from work in the city. The truck is originally from Virginia and has very minimal rust exposure. While replacing my rear brake pads, I noticed that the area where the rear leaf spring connects to the body/frame of the truck had broken away and was no longer properly attached. This was completely unexpected. A critical suspension component such as the leaf spring mounting point should not fail on a relatively low-mileage vehicle with only 55,000 miles, especially one that has not been subjected to severe corrosion or extreme use. Had I not been performing brake maintenance myself, I likely would not have discovered this defect. I fear that many other Ford Ranger owners may be driving their vehicles unaware that they could be experiencing the same dangerous condition. A failure involving the leaf spring mounting system has the potential to affect vehicle stability, handling, braking, and overall control. This creates a significant safety risk not only for the driver and passengers of the affected vehicle, but also for everyone sharing the roadway. I respectfully urge your agency to investigate this issue and determine whether a broader defect exists involving the rear leaf spring mounting components on 2019 Ford Rangers. If warranted, I ask that Ford be required to issue a recall to inspect and repair affected vehicles before a catastrophic failure results in serious injury or loss of life. Thank you for your attention to this matter and for your efforts to protect the safety of the driving public.

Hash Shifting and at times kicks into gear hard at a stop light nearly hitting vehicle in front of me

The contact owns a 2019 Ford Ranger equipped with Dunlop Tires. Tire Line: AT2O, Tire Size : 265/65R17 110HI, DOT number DAAH D31R. The contact stated that while driving 65 MPH, the passenger-side rear tire blew out. The thread separated and was on the roadway. The contact was able to continue to drive. The contact called a tire center, but they failed to respond. The local dealer was not contacted. The manufacturer was not contacted. The tire mileage was unknown. The failure mileage was approximately 97,000.

My 2019 Ford Ranger is equipped with the 10R80 10-speed automatic transmission that experiences hard/erratic shifting (as if it can't decide what gear it wants to be in), jerking/lunging especially in 1-2 gear when making a brief stop-and-go (stop sign or a crosswalk). The first couple time it happened, it felt like I got rearended or hit a curb.

The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.

Mileage is at 86980. I have been having issues for a good 10k miles that are slowly getting worse. Transmission is slamming into reverse from park. Shifting is slow from 1st to 2nd gear. Has begun revving engine but not engaging. I have had the transmission fluid changed 3x and flushed and changed the last time. No leakage or overheating. I do not drive her hard, off road or tow. She always gets warmed up before driving. My mechanic believes it is the PCM.

Rear rear leaf spring broken/cracked completely and disconnected from vehicle. The vehicle was unsafe to drive as the axle was not not connected to the vehicle on one side. The defective component was inspected by Firestone Auto and submitted and approved by SilverRock automotive for warranty replacement and is currently at a Ford Dealership completing repairs because Firestone Auto failed to complete the repair properly. There were no warning lamps or messages and it the problem was only noticeable when the vehicle was on a lift or floor jack. The incident is unknown and it the broken part was poor design/materials.

JULY 2024 THE RIGHT SIDE BACK LEAF SPRING WAS BROKEN. WAS REPLACED UNDER WARRANTY. APRIL 2026 THE LEFT SIDE BACK LEAF SPRING IS BROKE. WAITING TO HEAR FROM FORD IF IT WILL BE COVERED OR NOT. LEAF SPRINGS SHOULD NOT BE BREAKING. I DO NOT HAUL THINGS OR EVEN GO OFF ROAD WITH MY 2019 RANGER. IT HAS 74012.10 MILES ON IT NOW.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated, and the transmission was shifting hard. Additionally, the vehicle vibrated abnormally while shifting from 1st to 3rd gear. The vehicle was taken to the dealer, where the TCM was reprogrammed, and various fluids were replaced; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 951.

On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan lowers the temperature of the engine. The cooling fan motor is an electric motor that turns the fan blades. When the vehicle is in traffic or under heavy load, the engine relies on the fan to cool itself. Some vehicles may use multiple electric fans for better control of the cooling system. For the most part, electric cooling fans are controlled by the same computer that controls the engine. However, in some engines, the fans are turned on and off by a temperature-sensitive switch mounted in either the radiator or elsewhere in the cooling system. Spark Plug Replacement 4 Cylinder: 4 Cyl Tune Up The platinum spark plug is a type of spark plug. The platinum is a precious metal that is used in the composition of the spark plug. The center electrode is made of platinum.

Restraints indicator lamp warning. Air bag warning is on due to a problem with the front passenger side airbag. The front passenger airbag may not function.

both rear springs broken at the front eye mounts. the rear leaf springs hold the rear axle in place need I EXPLAIN MORE? I have not had the truck inspected, I have been in the automotive industry for over forty years. I first heard a noise from the springs when entering a parking lot and drove over a curb. No electronics attached to the springs.

The transmission failed prematurely (my point-of-view) at around 115,000 miles. A Ford dealer diagnosed and determined the transmission needed replaced. The vehicle was a 2019 Ford Ranger XL with a 10-speed automatic transmission. The transmission would get stuck in 2 gear, sometimes upshifting and sometimes downshifting. Driving highway speeds the speed needle would also drop to zero even though I was moving. They noted that solenoids were bad but replacement was needed. I had the transmission replaced with a new warrantied transmission but it was very expensive at 9,650. It did come with a 2-year warranty. That is half the value of the truck! This is the fourth Ford truck I have owned. I do use it as a truck and haul a few things around as projects dictate but do little towing, drive it reasonably, and do not take it off-roading. I have never had a transmission fail before. The Ford dealer, and three area shops, noted they see "a lot of 10-speeds" come in for transmission rebuild or replacement. As a now review many Ford forums I see many people with issues surrounding the durability of the 10-speed transmission.

Since owning the vehicle, I have experienced a range of serious transmission issues. These include harsh or delayed gear shifts, inconsistent downshifts, and transmission slipping. The vehicle also frequently jerks or lurches during gear changes. Of particular concern is the vehicle’s behavior during downshifting. At times, the transmission downshifts abruptly and causes the vehicle to lunge forward unexpectedly. This unpredictable behavior presents a significant safety concern, particularly in traffic situations where smooth and predictable vehicle response is essential. These transmission issues negatively affect the safety, drivability, and reliability of the vehicle and are not consistent with normal operation.

My transmission has failed at 131,000 miles on my vehicle. It roughly shifts into reverse and harshly shifts while in drive and the vehicle is in motion. My truck shakes while the transmission searches for gears and shifts slowly requiring extra power to move in normal operating conditions.

Airbags: passenger rear and front side airbags did not deploy after being struck on the passenger side by another vehicle. Seatbelts: were ineffective Vehicle was sold due to system failures and equipment issues. Safety: Head and body trauma due to non deployment. Inspection: Unknown No system messages before collision

10th gear, gear ratio incorrect. CDF drum failure. Rough shifts from 3-4 struggles to shifts into park and reverse.

Vehicle has around 50K miles and driver rear leaf spring corroded and broke, review of right rear leaf spring also showed corrosion and metal thinning. Truck has no off road time nor heavy loads in bed. I had to replce both springs at my cost even though Ford is aware of the 2019-2020 Ranger spring issues and refused to replace the springs. This is a serious safety issue that places the occupants and other drivers at risk. The mechanic said he’s replaced over a dozen broken leaf springs on model years 2019 and 2020. The manufacturer is being intentionally negligent and even the dealer parts counter agreed the springs are faulty, saying they sell quite a few regularly.

My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.

he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle is experiencing a severe power train failure involving erratic and violent gear selection. The transmission unexpectedly jumps from 2nd, 3rd, or 4th gear directly up to 7th or 8th gear, resulting in a total loss of acceleration. This is immediately followed by the transmission "slamming" down into lower gears, usually 1st or 2nd gear without driver input. This behavior is accompanied by a strong burning smell and a dashboard "wrench" warning light. The symptoms match the manufacturing defect documented in Ford TSB 24-2101 (CDF clutch drum). Diagnosis & Manufacturer Response: The issue began in October 2025 with a noticeable transmission shudder. I paid for two transmission flushes at Big O Tires to attempt to resolve the issue, but the mechanical failure has since escalated. When the "wrench" light appeared, an independent diagnostic computer was unable to retrieve an error code, as the light is a proprietary Ford powertrain indicator. Furthermore, the wrench light clears upon restarting the vehicle, despite the violent shifting and burning smell remaining. Ford Corporate agents claim there are "no known issues" and have refused to assist with towing, despite an active NHTSA Engineering Analysis (PE 24-001) regarding this exact 10R80 transmission. Safety Risk: This defect creates an extreme safety hazard. Violent downshifting into low gears at highway speeds can cause a loss of vehicle control or a rear-end collision. The burning smell indicates internal friction and fluid oxidation, posing an immediate fire risk or the potential for a catastrophic mechanical lock-up.

The transmission stutters at sustained modest speed (25-45 mph). It was taken to the dealer, who determined it was affected by tsb 25-2134. This is a widely known issue and the dealer refused any servicing without payment. This should have been a recall, since hundreds of known issues in and out of warranty have occurred.

The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the failure, warning messages and drivability symptoms were present. Specifically, the transmission control module detected an issue when attempting to shift into 4th gear, triggering a failsafe mode that disabled 4th gear for the remainder of the key cycle. These symptoms appeared before the full transmission failure and progressively worsened over time.

2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.

During a PA State inspection, a leaf spring was discovered to be broken.

Transmission shifting issues. Will shift out of gear or delay shifting several seconds and sometimes limited power. The 1080r 10 speed transmission has a know design flaw that was finally fixed in 2023. My 2019 is now having the issue and is $8000 to fix for a bushing that moves out of place

The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.

Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.