Ford Mustang 2001 — Reported problems

ABS light came on, sometimes when braking/slowing down at freeway speeds, the brakes won't catch and it feels like I'm going to ram into the cars ahead, I've replaced the rotors, the calipers, the brakes, the wheel bearings, ABS light won't go away, I've looked into it on the bullitt community forums, and this is a common problem that most just decide to live with, cause no solution has been found.

Anti lock brake pump leaking brake fluid from what appears to be a vent /weep hole resulting in rapid brake fluid loss and low/ soft pedal and significant loss of braking.

TL* THE CONTACT OWNS A 2001 FORD MUSTANG EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS V2 EVO2, TIRE SIZE: 275/35/R18, DOT NUMBER: 5MRKYBH. THE CONTACT STATED THAT THE TIRES WERE PURCHASED IN MARCH OF 2020 AND INSTALLED IN APRIL OF 2020. AFTER DRIVING THE VEHICLE FOR APPROXIMATELY 3,000 MILES, THE TIRES SHOWED EXCESSIVE UNEVEN TREAD WEAR. THE CONTACT STATED THAT THE VEHICLE FAILED THE STATE INSPECTION DUE TO THE TREAD WEAR FAILURE. THE CONTACT STATED THAT THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE ISSUE. THE MANUFACTURER RECOMMENDED THAT THE TIRES BE INSPECTED BY AN AUTHORIZED HANKOOK DISTRIBUTOR. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE EXCESSIVE TREAD WEAR WAS NOT DUE TO A TIRE MANUFACTURING DEFECT BUT AN ISSUE WITH THE VEHICLE. THE TIRES WERE NOT REPLACED AND REMAINED ON THE VEHICLE. THE VEHICLE FAILURE MILEAGE WAS UNKNOWN.

1. THERE IS A DREADFUL GAS FUME ODOR INSIDE THE CAR EVERY TIME I PUT FUEL IN THE CAR ESPECIALLY WHEN I FILL THE TANK. 2.THE EMERGENCY BRAKE DOES NOT WORK PROPERLY. WHEN ENGAGED MY CAR STILL ROLLS A LITTLE. 3. THE SEAT BELTS DO NOT RETRACT PROPERLY AND TEND TO TWIST AND TANGLE WHEN I TRY TO DO IT MANUALLY.

WHEN BACKING OUT OF THE DRIVEWAY, I HAD NO CONTROL OVER THE VEHICLE, EVEN WHILE PRESSING ON THE BRAKES. I LOST CONTROL, WENT INTO A YARD AND HIT A TREE.

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. WHILE THE CONTACT'S DAUGHTER WAS PLACING FUEL IN THE VEHICLE, SHE NOTICED FUEL LEAKING FROM THE FUEL TANK WITHOUT WARNING. THE CONTACT MANAGED TO DRIVE THE VEHICLE HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 189,000.

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. AFTER REFUELING THE VEHICLE, A FUEL LEAK WAS DISCOVERED UNDERNEATH THE VEHICLE. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DISCOVERED THAT A RUBBER WASHER IN THE FUEL SYSTEM WAS FAULTY AND NEEDED TO BE REPLACED. THE WASHER WAS REPLACED AND THE FAILURE WAS REMEDIED. WHILE DRIVING AT NIGHT, THE LOW AND HIGH BEAM HEADLIGHTS WERE VERY DIM AND THE DRIVER WAS UNABLE TO SEE THE ROAD. ALSO, WHILE THE VEHICLE WAS PARKED ON A INCLINE WITH THE EMERGENCY BRAKE ENGAGED, IT ROLLED DOWN THE DRIVEWAY AND INTO THE STREET. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. ESTABROOK FORD (3689 14TH ST, PASCAGOULA, MS) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 64,000.

WHERE IT SHOWS HOW MANY MILES IT'S DIGITAL AND IT CONSTANTLY GOES OFF. SMELLS OF GASOLINE AND LIKE SOMETHING IS BURNING EVERY TIME DRIVE IT. HAS A VERY ROUGH IDLE AND WHEN A /C IS ON THE CAR HAS ABSOLUTELY NO POWER, ALSO BURNS GAS VERY QUICK. EXTERIOR HEAD LIGHTS LIGHTS ARE DIM AND I JUST INSTALLED NEW ONE YET STILL DIM

I WAS LOSING A LARGE AMOUNT OF FUEL EVERY TIME I FILLED UP. THE LEAK STARTS IMMEDIATELY UPON TURNING ON THE FUEL NOZZLE. I AM ALSO EXPERIENCING A CHECK FUEL CAP WARNING AND A LOW PRESSURE IN THE FUEL SYSTEM. THIS HAS CAUSED THE CAR TO NOT START AND SEVERAL BACKFIRES WHEN IT DOES TURN OVER. THERE IS ALSO FUEL LEAKING DIRECTLY ONTO MY EXHAUST PIPE AT EVERY FILL UP WHICH COULD CAUSE A FIRE. THIS LEAK WAS CAUSED BY THE PLASTIC COVER OVER THE METAL FILLER NECK. MOISTURE AND DIRT CAUGHT IN THE PLASTIC CAUSED THE METAL TO ERODE AND BREAK A PART.

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO A RESTART A FEW MINUTES LATER. THE FAILURE RECURRED SEVEN TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. WHILE DRIVING AT LOW SPEEDS, ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER SIDE OF THE CONTACT'S VEHICLE. DURING THE INCIDENT THE BACK OF THE DRIVER SEAT FRACTURED. AS A RESULT, THE DRIVER SUSTAINED A BRUISED HIP THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 155,283.

I SMELLED STRONG GASOLINE ODORS WHILE DRIVING FROM WORK. THE CAR HAD BEEN FILLED WITH FUEL RECENTLY. THE FUEL TANK IS LEAKING NEAR THE FILL TUBE. FURTHER RESEARCH INTO THIS ISSUE HAS SHOWN THAT IT IS A COMMON OCCURRENCE WITH THIS MODEL. THE CAR CANNOT BE FILLED ABOVE HALF FULL OR GASOLINE LEAKS ALL OVER THE BACK OF THE CAR AND ON THE GROUND ONCE PARKED. THIS LEAK IS TOO NEAR THE EXHAUST PIPE FOR SAFETY. FORD DOES NOT REPAIR THIS SAFETY ISSUE UNDER ANY RECALL. IT IS A CHEAP PART BUT LABOR IS VERY EXPENSIVE SINCE THE FUEL TANK MUST BE REMOVED TO REPLACE THE LEAK. THIS IS A MANUFACTURING ISSUE AND FORD SHOULD BE REQUIRED TO REPAIR IT FREE OF CHARGE. *TR

THE PASSENGER SEAT HAS RARELY BEEN USED IN THIS VEHICLE. HOWEVER, THE WEEK THE SEATBELT FAILED (BECAME JAMMED IN PANEL AS THOUGH I HAD HIT BRAKES AND WOULD NOT RELEASE) I WAS THE DRIVER FOR AN 88 YEAR OLD FEMALE FRIEND RUNNING HER ERRANDS WHILE HER CAREGIVER WAS OUT OF TOWN., THE SEAT BELT WAS USED FOR SEVERAL DAYS. I WENT ON LINE AND FOUND NUMEROUS ARTICLES AND RECALLS. I CONTACTED MY LOCAL FORD DEALER. THEY IMPLIED ON THE PHONE IT WOULD BE REPAIRED AT NO CHARGE BECAUSE, ONCE I WAS ON SITE, RENT CAR ARRANGED I WAS TOLD MY PARTICULAR VEHICLE WAS NOT A SPECIFIC RECALL AND INDICATED I MUST PAY. NOW AFTER 5 DAYS OF PAYING FOR A RENT CAR. I WAS INFORMED REPLACEMENT SEATBELT HAD NOT BEEN ORDERED PENDING MY APPROVAL. (PREVIOUSLY IT WAS NOT EXPLAINED TO IT WOULD HAVE TO BE ENTIRELY REPLACED. COST OF SEATBELT $260.42 TOTAL COST TO INSTALL $584.63. MY VEHICLE WILL NOT PASS INSPECTION AS THIS IS A MAJOR SAFETY ISSUE. I FEEL I HAVE BEEN MISLEAD AND RIPPED OFF BY DEALER. AT THIS POINT I AM PICKING UP THE PART ONLY, TURNING IN THE RENT CAR AND SEEKING A LESS EXPENSIVE INSTALL. THIS IS A WELL DOCUMENTED DEFECT WITH THIS VEHICLE AND COULD HAVE EASILY BEEN IN AN ACCIDENT WITH NO RESTRAINT FOR MY PASSENGER. *TR

WHILE ON FREEWAY CAR STARTED SMOKING SO I EXITED FREEWAY WHEN CAR STALLED AND WOULDN'T RESTART. HAD TO TOW BACK TO CAR LOT WHERE I PURCHASED CAR 3 DAYS PRIOR. PLASTIC INTAKE MANIFOLD HAD A CRACK. *TR

DRIVING ON FREEWAY SUDDENLY CAR GOT HOT SO I SLOWED DOWN GOT INTO SLOW LANE THEN SHIFTED TO NEUTRAL CAR STALLED AND WOULD NOT RESTART ENGINE SEIZED. *TR

PLASTIC COVER ON ELBOW HOLDS WATER/DUST WHICH DOESN'T DRAIN LEAVING FILLER ARM CONSTANTLY DAMP RUSTING THROUGH PIPE LEAKING GAS ALL OVER WHEN FILLING TANK....BAD DESIGN AND THOUGHT PUT INTO THIS. ITEM SHOULD BE RECALLED, COST TO REPLACE AT ANY REPAIR SHOP IS UPWARD OF $800.00 CANADIAN. *TR

SEAT BELT ON PASSENGER SIDE ALWAYS RETRACTED SLUGGISHLY SINCE NEW, OFTEN JUST HANGING LOOSELY FROM THE UPPER HANGER. THEN IT WOULD RETRACT WITH HELP. FINALLY IT JAMMED AND WILL NOT RELEASE IN ORDER TO CONNECT THE BELT FOR USE. WHEN AN ATTEMPT IS MADE TO USE THE BELT, I HEAR A METALLIC CLUNK AND THE BELT WILL NOT COME OUT FAR ENOUGH TO USE. *TR

IDLES TOO FAST

THE MANUAL TRANSMISSION IS EXTREMELY DIFFICULT TO SHIFT FROM FIRST TO SECOND GEAR WHEN COLD. THIS IS A SAFETY ISSUE BECAUSE I NEED TO MAKE A LEFT TURN ONTO A BUSY STREET WHEN THE CAR IS COLD. THE DIFFICULTY IN SHIFTING HAS LEFT ME VULNERABLE AS I CAN'T ACCELERATE AS I INTEND AND I AM IN DANGER OF COLLIDING WITH ONCOMING TRAFFIC THAT EXPECTS ME TO ACCELERATE AT A REASONABLE RATE. *TR

MY GAS FILLER TUBE HAS RUSTED DUE TO THE PLASTIC SHIELD, DIRT AND MOISTURE HAS BEEN TRAPPED ON THIS PART OF MY 01 MUSTANG AND NOW THERE IS A HUGE HOLE ON THE FILLER TUBE. I'VE DONE MY RESEARCH ON A COUPLE FORUMS AND APPARENTLY I'M NOT THE ONLY ONE WITH THIS SAME ISSUE ON MODELS FROM 2000-2004 I'M PRETTY SURE WE ALL KNOW HOW SERIOUS THIS PROBLEM IS SEEING THAT FUEL IS LEAKING TO THE GROUND WHICH IS A FIRE HAZARD AND CAN RESULT IN A FATALITY. *TR

WHEN FILLING UP I NOTICED GAS LEAKING FROM MY GAS FILLER NECK IT IS VERY BADLY RUSTED. *TR

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. THE CONTACT STATED THAT THE VEHICLE FRONT PASSENGER SEAT BELT SENSOR BROKE. THE DEALER WAS NOTIFIED OF THE FAILURE WHO STATED THAT THE VEHICLE WAS NOT UNDER ANY WARRANTY FOR THE FAILURE TO BE REPAIRED AND OFFERED NO ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 111,530 AND THE CURRENT MILEAGE WAS 111,570.

FUEL FILLER NECK PIPE RUSTED THROUGH AND THERE WAS A PILE OF GAS UNDER MY CAR AND FUMES OF GAS EVEN AFTER DRIVING HOME. *TR

FUEL FILLER LINE HAS A PLASTIC COVER THAT TRAPS DIRT AGAINST THE METAL FILLER HOSE. THIS RESULTED IN THE METAL FILLER HOSE RUSTING CAUSING A HOLE IN THE LINE. WHEN FILLING UP WITH FUEL THE VEHICLE LEAKS FUEL THROUGH THIS HOLE. WHEN TANK IS FULL FUEL LEAKS THROUGH THIS HOLE WHILE DRIVING. *TR

4.6 LITER V8. SPARK PLUG BLEW OUT OF CYLINDER HEAD. COULD HAVE RESULTED IN A FIRE BUT LUCKILY DID NOT. SPARK PLUGS WERE LAST CHANGED OVER 30,000 MILES PREVIOUSLY. *TR

TL* THE CONTACT OWNS 2001 FORD MUSTANG GT. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE SPARK PLUGS SHOT OUT OF THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 100,000.

I JUST HAD TO PAY APPROX $700 TO REPLACE MY INTAKE MANIFOLD WHICH CRACKED AND CAUSED A COOLANT LEAK. UPON FIXING THIS ISSUE, I WAS INFORMED THAT THIS WAS A FORD RECALL A FEW YEARS AGO. SEEING AS THIS PART HAS NEVER BEEN REPLACED ON MY VEHICLE, I WOULD LIKE MORE INFORMATION ON THIS RECALL AND WHAT CAN BE DONE. *TR

WHILE DRIVING AT 30 MPH, THE VEHICLE SPARK PLUG EXPLODED OUT OF THE ENGINE. *TR

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT STOPPED THE VEHICLE AND NOTICED A HOSE WAS DETACHED FROM THE ENGINE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THAT THE BYPASS HOSE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED WHILE THE VEHICLE WAS STILL AT THE DEALER. THE TECHNICIAN THEN STATED THAT THE MANIFOLD WAS FRACTURED AND THE HEAD GASKET WOULD HAVE TO BE REPLACED. THE MANIFOLD WAS REPLACED BUT NOT THE HEAD GASKET. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 12/06/11*LJ THE CONSUMER STATED THE REPAIR TECHNICIAN WAS INJURED WHILE REPAIRING THE CRACKE MANIFOLD INTAKE. UPDATED 06/13/2012 *JS

S # 1 SPARKPLUG EJECTED FROM HEAD UPON ENGINE START-UP. *TR

THE FILL TUBE BETWEEN THE FUEL TANK AND THE NOZZLE INPUT HAS RUSTED THRU THE ENTIRE LENGTH, WORST UNDER THE PLASTIC/RUBBER WRAP AT THE TANK INLET, CAUSING FUEL TO SPILL ONTO THE GROUND WHEN FILLING THE TANK. DEALER ESTIMATES REPAIR COST AT $340. ON LINE INQUIRIES REVEALED "MANY-MANY" OTHER COMPLAINTS. NO FORD RECALLS OR SERVICE BULLETINS. IF PARKED FOR A FEW DAYS , THE BATTERY RUNS DOWN. CHECKED FOR HEAD/PARKING/BRAKES LIGHTS LEFT ON AS WELL AS THOSE INSIDE PASSENGER AREA AND IN TRUNK. NONE FOUND. MECHANIC BELIEVES DUE TO RADIO/CD PLAYER AMP DRAW TO SUPPORT CLOCK (ETC) EVEN WHILE OFF???? INSTALLED NEW BATTERY, OK FOR AWHILE, NOW DOING IT AGAIN. *TR

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. THE CONTACT STATED THAT THE FRONT DRIVER SEAT BELT WAS STUCK IN A PARTIALLY RETRACTED POSITION. THE CONTACT ALSO STATED THAT THE SEAT BELT WOULD NOT PULL OUT ANY FURTHER OR RETRACT ANY FURTHER. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 11,000.

TL* THE CONTACT OWNS A 2001 FORD MUSTANG. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT SMELLED A BURNING ODOR. THE ABS LIGHT ALSO ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE ABS COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

FUEL NECK OF 2001 MUSTANG GT RUSTED THROUGH BENEATH A PLASTIC BLACK SHEET POSSIBLY BECAUSE OF ROAD SALT BUILD UP. THIS LEAD TO FUEL LEAKAGE AND EMISSION CODE FAILURE DUE TO LOW TANK PRESSURE. THE FUEL NECK AND FUEL NECK GASKET WERE CHANGED. *TR

TL* THE CONTACT OWNS 2001 FORD MUSTANG. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL ABNORMALLY. UPON FURTHER INSPECTION, THE CONTACT DISCOVERED THAT THE FUEL TANK FILLER NECK WAS RUSTED AND A HOLE WAS IN THE FILLER PIPE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR LOCAL MECHANIC FOR INSPECTION OR REPAIRS. THE CONTACT STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE DUE TO THE FAILURE. THE FAILURE MILEAGE WAS 92,000.

ENGINE IDLES ABOUT 3000 RPM AT START UP UNTIL ENGINE IS SHUT OFF. *TR

THE FRONT SEAT BELT RETRACTORS ARE DEFECTIVE IN DESIGN. THE SEAT BELT TWISTS INSIDE THE RETRACTOR, MAKING IT VERY DIFFICULT TO USE FOR ITS INTENDED PURPOSE. THE SEAT BELTS WILL NOT RETRACT PROPERLY AND GET STUCK CAUSING PASSENGERS NOT TO BE PROPERLY RESTRAINED. CONSUMER TOOK VEHICLE TO DEALER FOR WARRANTY REPAIR, HOWEVER THE DEALER REFUSED TO REPAIR VEHICLE UNDER WARRANTY. THE FAILURE BEGAN APPROXIMATELY 1-2 MONTHS AFTER PURCHASE AND HAS WORSENED OVER TIME. PROBLEM HAS GONE UNREMEDIED BY MANUFACTURER OR DEALER. *TR

A LOUD FOG HORN SOUND COMING FROM UNDER THE HOOD. RAISED RPM HELPED TO REDUCE OR STOP NOISE. THE ABS LIGHT (AMBER) COMES ON AND DISENGAGES THE TRACTION LOC FOR THE REAR END (DRIVE WHEELS). OVER A PERIOD OF APPROX. 1 MONTH THE ABS LIGHT STAYS ON WITH TRACLOC DISENGAGED. I GOT THE SYSTEM CHECKED AND THEY STATED NO ELECTRIC SIGNAL IS COMING OUT OF THE CONTROL MODULE BUT POWER IS GOING IN. I WAS TOLD FOR A MORE DETAILED ANALYSIS I SHOULD TAKE IT TO FORD BECAUSE THERE ARE 2 ITEMS THAT COULD BE REPLACED AND IT COULD BE $2600.00 OR MORE. *TR

WENT TO FILL UP WITH GAS, NOTICED GAS LEAK. UPON INSPECTION FOUND FUEL FILLER NECK RUSTED THROUGH TO POINT WHERE IT BECAME TWO PIECES. REPLACED FUEL FILLER NECK @ $230 PLUS LABOR, ISSUE SOLVED. 2001 FORD MUSTANG 3.8L PICTURES AVAILABLE. *TR

I HAVE A 2001 FORD MUSTANG. ABOUT 6 MONTHS AGO, I NOTICED A SMALL AREA THAT THE CLEARCOAT WAS PEELING. NOW IT IS COMING OFF IN SHEETS AND MY PAINT HAS FADED THAT IS LOOKS LIKE A COMPLETELY DIFFERENT COLOR. I'VE READ NUMEROUS COMPLAINTS ON OTHER MESSAGE BOARDS FROM OTHERS HAVING THE SAME ISSUE. I EVEN FOUND A SERVICE BULLETIN THAT FORD ISSUED INSTRUCTING PAINT VENDORS HOW TO CORRECT THE PROBLEM. I WOULD THINK THAT IF THAT MANY PEOPLE ARE HAVING THIS ISSUE THAT FORD HAD TO ISSUE A BULLETIN OF THIS SORT, THAT THERE WOULD BE RECALL AND FORD WOULD BE FINANCIALLY RESPONSIBLE. IT IS THE RIGHT THING TO DO. NOW, I HAVE TO PAY FOR A PAINT JOB THROUGH NO FAULT OF MY OWN. *TR