Ford Focus 2016 — Reported problems

The vehicle experienced a catastrophic failure of the canister purge valve (CPV), causing an excessive vacuum that violently deformed and collapsed the plastic fuel tank. The deformation was so severe that it breached the fuel system, causing raw gasoline to pour directly out of the filler area and onto the ground when fueling was attempted, presenting an immediate fire hazard. Furthermore, the structural collapse of the fuel tank pinched and shorted out the fuel pump electrical wiring harness. This short circuit caused a massive electrical spike that blew the high-amperage master mega-fuses located on the front of the battery box, causing a total loss of electrical power to the entire vehicle. The manufacturer's initial safety recall remedy (Recall 18S32) failed to prevent this dangerous recurrence, and the vehicle is currently at a dealership being evaluated under Customer Satisfaction Program 24N07.

The DPS6 transmission started out shuddering in low gears even after clutch replacement early on. This made pulling out into traffic slower than it should be. Received “transmission overheating” message “pull over for 5 minutes” in heavy traffic. Prior to the message car would shudder and lose power. This happened suddenly going at highway speeds on the interstate. Replaced clutch actuators and TCM only to have the clutch adaptive learn procedure fail and after inspection by the dealer was told needs new transmission. These problems have been present at very low mileage and Ford now wants to charge a ridiculous amount to replace transmission that should have been fixed long ago. Several times the car stalled in traffic almost causing me to get in accidents.

The contact owns a 2016 Ford Focus. The contact stated that the vehicle stalled while in active traffic. There was no warning light illuminated. Prior to visiting the dealer, the vehicle was taken to two independent mechanics and the vehicle was inspected. The contact was informed that the fuel tank had collapsed. The vehicle was subsequently taken to an authorized dealer for the repair. The dealer diagnosed the vehicle with a failed canister purge valve, but the fuel tank was not damaged. The dealer replaced the canister purge valve and EVAP parts. However, shortly after the repair, the vehicle stalled while driving in traffic. The vehicle was taken to another Ford dealer; however, the dealer experienced the same issue. The manufacturer was notified of the failure and referred the contact back to the dealer for assistance. The contact referenced NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline); but the recall repair was already performed on the vehicle. The failure was not repaired. The vehicle had lost motive power and would not restart and had to be towed. The failure mileage was unknown.

I WAS DRIVING 75MPH DOWN I-10 AT 11:30PM AND MY FOCUS SUNDDENLY DIED, I HAD TO PUSH THE CAR TO THE SHOULDER. INFORMATION FLASHED NOT IN PARK AND STARTED GHOSTLY TRYING TO START ON ITS OWN, I BELIEVE THE TCM FAILED. I HAD TO HAVE IT TOWED.

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stopped accelerating. The contact safely pulled into a parking lot and turned off the vehicle. There was no warning light illuminated. The vehicle was inoperable and was waiting to be towed. The contact associated the failure with NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The dealer was previously contacted about the recall but was informed that there was no part available for the recall repair. The dealer was not contacted after the failure. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

My duel clutch transmission started acting up took it to a mechanic they said it needed the TCM and Actuators and possibly transmission replaced that they should be recalled tried taking it to Thirnhill Ford because I received a letter for this to be changed and they refused without me paying up front this has been going on with my car for over 2 years its setting in a driveway being paid on and cant even be drove

The car would not accelerate when pressing accelerator, they said the clutch assembly malfunctioned, confirmed by documentation. Myself and others had our safety at risk because the car could not be controlled properly while on the road. The car was taken to the dealer and they confirmed the problem. The dealer's service center gave inspection, and confirmed the problem. The warning message did not appear until after the problem put myself and others' safety at risk.

Transmission is taking to change gears and when going up a hill it jerks with you the problem was worked on by dealership and it still does same thing after work on it was done and dealership kept making excuses It was a recall on it about 3 years ago and it wasn't fixed and still does the same

Transmission overheated. Transmission fluid leaked but the computer in the car didn't let me know there was a leak. Couldn't move my car into reverse so I had to get a tow to Ford. They said it was a Transmission leak which caused the overheating. But once the car received Transmission fluid the car did not go into reverse. Clutch failed.

While driving at highway speed, the transmission slipped, skipping gears. Very difficult to drive care safely. Could not accelerate vehicle safely. Had to stay in right lane with hazard lights on. Basically, using only gears 1, 3 & 5. Later discovered intermittently no reverse. DTC P090C Clutch Actuator B - Circuit Low.

When I bought the car it stuttered it ended up being the clutch then my transmission went out The bolt in my engine mount broke and my engine was basically on the ground

So I had check engine light I took it to the mechanic the code was p1450 the mechanic told me it’s the purge valve and it’s recall with ford book and appointment from the website witch is I did after I checked my vin I found out that’s this purge valve has recall and it’s free of charge I went to dealer they denied and said they have to do their diagnostic that will cost 190$ and they did not accept the car

We bought this vehicle from Carvana in February 2023. Since very early on owning this vehicle, the engine hesitated and stuttered when trying to shift from first to second gear, and would lunge forward slightly. In December 2024, I received a letter from Ford Motor Company about a customer satisfaction program, Campaign 24N07. The letter addressed the symptoms my vehicle exhibited, including engine hesitation, engine running rough, and engine stalling at low speeds, though the check engine light was not on. The letter states that Ford Motor Company provides a one-time replacement of the canister purge valve, given these symptoms and the check engine light being on. When I called all the local Ford dealerships, they refused to do it because the check engine light was not on, and that Ford Motor Company issued this as a customer satisfaction program, rather than a safety recall.Everything that was listed in Campaign 24N07 is MOST DEFINITELY a safety issue, and should not be taken lightly. It is highly concerning that Ford Motor Company didn’t think to consider ENGINE ISSUES a safety recall. The class action lawsuit Vargas et al v. Ford Motor Company had a deadline of November 4, 2020, which was 2 years and 3 months prior to us buying the vehicle, so any vehicles of the affected years and models should have been either repaired, or not allowed to be sold unless the repairs were done by an authorized Ford dealership. This information was not told to us when we bought the vehicle.On May 25, 2026, while driving, the engine fault and steering assist fault warnings came on, as well as the check engine light. When we were able to safely park the car, we discovered the entire power train is non operational. The engine no longer turns over, and we are now having to buy a new car.

My car Transmission dual clutch went out in 2024. Car makes a loud winding noise car hesitate when stops Yes,confirmed by dealership and Coleman's transmission. Yes, by the manufacturer. No warning lamps or messages.

[XXX] driving her 2016 ford focus hit me [XXX] she claims her btakes did not work hitting multiple times she hit me so hard her car flew many feet back. I believe her car was defective it was alittle snowy but nothing bad. [XXX] said her brakes did not work at all. Me and multiple cars were able to come to complete stop with no skidding i have toyota rav4. I think her car might have been told my car needed repairs. I was severely injured severe permanent concussion brain neck back shoulder arm hand chest back muscle nerve damage. Dunno if [XXX] was also injured INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission is slipping. Dealer reported cluthes going out. This is a known issue with all of these cars.

Ford Motor issued two safety recalls regarding this, but has since closed them without providing a safe resolution for consumers. July 8 2019 Ford issued Ford Safety Recall program 19S22 (following 18S32) for stuck open canister purge valve (CPV). This can result in a failure to bleed the vacuum from the gas tank, and deforms the gas tank upon failure. This has been confirmed, reproduced, and recalled by Ford before, but continues to happen nationwide to Ford Focus ST owners as a small subset of their vehicles. A stuck open CPV can result in a number of codes. In my case, I got a P1450, Ford-Specific check engine light on the MIL. This can cause inability to start, along with rough idle and stalling while driving. Ford reports closing these safety recalls and provides no further support for the issue.

The powertrain/transmission in my 2016 Ford Focus is malfunctioning. Specifically, the vehicle shudders and hesitates when accelerating in low gears, causing delayed engagement and unpredictable power delivery. This issue occurs at low speeds, such as when entering traffic or moving through intersections, creating a potential safety risk for myself and other drivers. The problem has been officially diagnosed by a Ford dealership as a transmission/clutch issue, with a repair estimate of approximately $3,700. The issue has been reproduced consistently and confirmed by the dealer. No warning lights appeared prior to the malfunction, but the shuddering and hesitation are noticeable during normal driving. The vehicle currently has approximately 26,000 miles, which is very low for transmission failure, and the manufacturer has denied goodwill assistance despite the early and confirmed failure.

The car shakes when I turn the car on. I always thought it was normal until they told me it wasn't. Also ive smelled like a burn oil smell... Ive gotten stuck on intersection, guessing its the transmission.. i had to put the car it park and put it drive to see if it moved. When it did moved the whole front car shook while doing the turn. That happened like 2x. Both times I've parked afterwards and I tried to put it in reverse and nothing. It did not reverse. And that was the last of it moving.

The transmission in this model is horrible they already have recall for the 1.0L mine of course is the 2.0L its 2016 Ford Focus it has last than 165,000 miles. I already replaced put new transmission in it last year and here I am again transmission is out. And of course no repair shops will touch my car deal this known issues

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle shuddered unexpectedly. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with dual clutch failure. The contact was informed that the dual clutch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced NHTSA Campaign Number: 18V169000 (Power Train); however, the VIN was not associated with the recall. The failure mileage was approximately 65,000.

My car is showing signs of recalls but it’s stating that it doesn’t have any recalls. There is a recall of the transmission failing because of the clutch and causing the car to just randomly cut off while driving putting risk of a crash to me and my kids There is a recall on the fuel pump being messed up causing the car to cut off randomly while driving because of the vapors and that’s what my car has been doing also putting danger to me and my kids while driving.

NHTSA Recall Number23V905 Recall Status recall Incomplete Ford performed an interim engine repair in 2024. Due to the unavailability of parts when the recall was initiated, it took approximately 8 months for the interim engine and repair to be completed. I received my car back in August 2024 and then a supplement to the recall was placed. After getting the car back, my check engine light came on but Ford advised that it didn't have anything to do with the engine replacement and associated parts. Then I began experiencing symptoms of a valve purge issue and received an EVAP code. I attempted to address this at the dealership during routine maintenance but it was not checked or repaired. In January 2026, my engine failed again with similar symptoms. It was towed to the same dealership where they informed me that I was out of warranty on the engine and my new issue had to do with coolant intrusion. When I checked my service records, they had noted that a coolant hose was broken and replaced during recall repairs. Additionally there is a recall for other 2016 Ford Focus coolant intrusions caused by a heater block. This leads me to believe that the repair may have been faulty. Additionally, the 23V905 recall is still open with a supplement to the original.

The contact owns a 2016 Ford Focus. While operating the vehicle, the vehicle was shaking abnormally while idling, while low on fuel, while driving long distances, or while driving uphill. The vehicle shut off unexpectedly intermittently. On several occasions, the RPM increased; however, the vehicle failed to respond, and the vehicle eventually stalled. The accelerator pedal was depressed to the floorboard, but the vehicle failed to respond. The brake pedal became firm. The contact stated that the vehicle stopped and restarted several times or shut down unintendedly. After refueling, the contact had to wait for approximately 2 to 10 minutes before the vehicle responded as needed. Occasionally, the contact had to wait for over an hour before the vehicle was restarted. The check engine warning light illuminated intermittently and later turned off. While depressing the accelerator pedal, the engine revved excessively without the vehicle responding as needed. An abnormal sound was coming from the vehicle. The Oxygen sensor error code was displayed. The failure persisted over time. The vehicle was previously repaired at an unknown dealer under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). Additionally, the high-pressure fuel pump was replaced. The local dealer was not contacted regarding the current failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 150,000.

The vehicle experienced failure of the DPS6 dual-clutch automatic transmission. The transmission began slipping during acceleration, hesitating between gear engagement, and triggering a “Transmission Overheat” warning. Eventually, the vehicle lost the ability to reliably shift between Drive and Reverse and would not consistently engage gears. The vehicle can start and move forward but cannot reliably switch directions within the same ignition cycle. The vehicle is available for inspection. The transmission malfunction created safety concerns due to delayed or failed acceleration when entering traffic. The vehicle hesitated and slipped under throttle input, which could prevent timely acceleration when merging or crossing intersections. Additionally, the inability to reliably shift between Drive and Reverse could create hazardous situations in parking lots or emergency maneuvering scenarios. The sudden transmission overheat warning and gear disengagement could result in loss of power in traffic. The issue has been confirmed by an independent mechanic who diagnosed transmission failure. The vehicle has a known history of prior clutch replacement under similar symptoms. The transmission malfunction is consistent with documented DPS6 transmission failures in 2016 Ford Focus models. The vehicle has been inspected by an independent service center. The manufacturer has not inspected the vehicle. Prior to failure, the vehicle exhibited shuddering during acceleration from a stop, particularly at low speeds. This condition has been intermittently present for several years following a prior clutch replacement. In the days leading up to failure, the vehicle experienced difficulty accelerating and hesitation under throttle. A “Transmission Overheat” warning message appeared while driving. After cooling, the vehicle temporarily resumed operation but subsequently lost reliable gear engagement.

I am writing to file a formal complaint regarding an ongoing mechanical issue with my 2016 Ford Focus. Although my vehicle currently shows zero active recalls, I have experienced a recurring and concerning problem. Each time I turn on the air conditioning and the air begins to blow cold, my engine temperature rises significantly and causes the vehicle to overheat. This issue occurs consistently and makes it unsafe to operate the vehicle while using the air conditioning. Overheating poses a serious safety risk and may lead to engine damage or sudden breakdowns. Given that this problem appears to be directly connected to the operation of the air conditioning system, I am concerned that this may be a known defect or design issue that has not been addressed through a recall. I am requesting that this issue be formally documented, investigated, and addressed. I would appreciate guidance on next steps, including inspection, repair options, or whether this issue has been reported by other 2016 Ford Focus owners. Thank you for your time and attention to this matter. I look forward to your prompt response.

Transmission is slipping. Check engine light is on. Code P07A5 (3/3) Permanent Transmission Friction Element B Stuck on.

When driving my car all of a sudden it loses power almost like it’s struggling to go but the RPM revs up and makes a loud noise and my car kind of got stuck for a minute and there were cars behind me then it started going but every couple minutes it would do that again rev up really loud even when I barely push the gas and lose power and then go I have no idea why it was doing that I took it to get it looked at, but there was no light on then a light finally came on and it came up with P07A3. Transmission friction element A stuck on. It starts end doing that with no notice. Light came on later after I tried to get it scanned. There seems to be extended warranty satisfaction things offered on vehicles at the same time mine was made. Same vehicle. But my number is not on the vin recall. But it exhibits same symptoms. The ford customer satisfaction program 14m02 covers same issues but my vin is not listed. This is a driving hazard unsafe that I feel is issues from their manufacturing.

This vehicle been having problems with heater

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle unexpectedly stalled with the message "Transmission Overheating" displayed. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer was not contacted regarding the failure. The failure mileage was 55,000.

Fuel purge valve is malfunctioning. Vehicle loses power and is sluggish. Idles very rough and sometimes has a loss of power. My car has been at Ford twice in the last six months and problem still isn't fixed. Complete engine was replaced about a year and a half ago due to recall issue which I don't want happening again. I do not feel safe driving this car. I made an appointment with Ford a month ago for tomorrow for same stalling issue. I went to drop off and explain I wanted the repairs done for the recall to see if that fixed the problem. I filled up my gas tank on Sunday. The car wouldn't start and engine light came on saying engine failure service now. I let it sit for about ten minutes and it hesitantly cranked and engine light went off but accelerates slower with loss of power. It keeps doing this intermittently and sometimes loses power, and struggles when idling. I cut off let sit and then is okay until I pump gas again. I told the service repair person what happened and handed him the key to drop off the vehicle. He said if the light was not on at the time he would not be able to fix it and they couldn't schedule my vehicle for any additional recalls that are greatly needed for the car. It is running terrible. It idles and intermittently loses power while driving. Evan at Ford (Greer) response was to wait until it got bad enough that the engine light came on and stayed on. This was at D&D Ford in Greer, SC. He said it was Ford's policy the light had to be on to replace under recall with no charge. I told him it is unsafe to drive if it gets any worse it could cause an accident. I have two children and his recommendation to wait until it gets worse was appalling. He kept backlashing Ford and stated he doesn't work for Ford he works for D&D and only represents Ford. I said to him he was not representing Ford very well and that it was highly unlikely they would agree with his statements. I asked for documation of this policy--it contradicts what he says.

Having fuel problems with this ford se. Adding gas after starting the car it doesn't run right. It misses n doesn't have power. Plus Transmission went out two times again. First time it went out. It was about a year ago. Now the second time [XXX]. First time was about a year ago. It was repaired. Because I had a car warranty from the car dealer ship. Now they won't repair it again. This ford focus Se had the double clutch in it Plus the notorious speed shifter known to go out. These transmissions are known to have problems. But the car place never told me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Something wrong with the transmission the one that Ford extended warranty on and my car is a 2016 and Ford extended it 10 years and they said it ended a few months ago as well as the TCM replacement I didn't know about because I just purchased the vehicle a little over a year ago.

The car is stalling randomly with no engine lights coming on

Lee County was working on the road and were replacing a section of Lazy D Farm Road and there was a section cut out and try to get across the section the transmission over heating light came on

In the Ford 3 cylinder 1.0L Ecoboost engines there is a terrible wet belt system, there is a recall on the automatic models but nothing for the manual models, regardless of the fact that the manual models are designed far more poorly than the automatic models in the sense that the manual models have no tensioners and rely solely on the factory tension of the screws, keeping in mind that the belt is both rubber and sitting in hot oil when in use, if not a money grab, my best guess is that they hoped the wet rubber belt would simply not not stretch in good faith. 4 days after getting basic maintenance, the wet belt failed, clogging the oil pickup causing engine failure, and temporary loss of power steering, after the engine was given time to warm up, luckily the road was nearly empty, and i was driving at a slower pace. However the fact that Ford Motor Company has gone nearly a decade without dealing with the issue, and then denies having knowledge of this design flaw, is absolutely and abundantly absurd. I have all vehicle maintenance records, as well as mechanic testimony, all of which point to this incident being caused by poor engine design. In addition to the estimated cost to replace the engine is 8,500$, or about 140% the cars total value prior to the engine failure. This a NOT a minor issue, this is not even a uncommon fail point on many other manual models, this IS a major safety concern, that god forbit it, could lead to a major accident. I simply think that the Ford Motor Company should be made accountable for cheaping out for profit, at the cost of customer’s safety.

The transistor arm or tensioning arm for the wet belt, which drives the oil pump in the oil pan failed, leading to oil starvation to the engine, causing total catastrophic engine failure, and temporary loss of power steering, while driving, fortunately, I was moving at a slow pace in minimal traffic, however, this is a known fail point in Ford 1.0 L ecoboost 3 cyl engines, that Ford claims my vehicle does not have, and refuses to cover, regardless of the fact that it did happen, and I have pictures in mechanic testimony to prove this to be true, had I’ve been on a different road, or had more traffic, this could have to a fatality. The engine replacement would cost a estimated 4500-7500$

The clutch had to be replaced a second time and the engine became disabled while driving due to parts failure and it blowing up. This is all happening with 60,000 miles on the vehicle. My safety came into question with both failures disabling my car while I was driving on the interstate. The clutch was replaced and paid for out of pocket and I have been trying to work with ford about the engine but they have not helped at all. The issues just popped up and failed immediately while driving. This engine failure issue is covered for my vehicle, but my VIN is not covered. The only explanation I have received is that it is because my car is a manual transmission, which has no link to the part that failed on the engine. I was also notified by the ford service manager that my vehicle was made in the exact location and time frame that the recall covers, but my VIN still is not covered. I have received absolutely no help or solution with my vehicles failure and have been without a vehicle for 9 months because of the large price on replacing an entire engine, right after I had to pay for a very expensive clutch replacement.

Fuel pump went out and caused car to stall and leave me stranded on the side of the road when dash indicator showed 23 miles left to travel. I had this fixed through the dealership Drive Time sent me to mechanic shop as was still under dealership warranty.

The contact owns a 2016 Ford Focus. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle hesitated. The contact also stated that while attempting to start the vehicle, the vehicle failed to respond as intended. Additionally, while driving at an undisclosed speed and attempting to make a left or right turn, the lost motive power. An independent mechanic was contacted, and the vehicle was taken to the independent mechanic to be diagnosed. The mechanic retrieved DTC: P2872 (Clutch "A" Stuck Engaged). The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14N02 (Extended Warranty Coverage for PCM Reprograming in the Event of ABS Vehicle Speed Signal Related Communication Loss that Disables OBDII System Monitors); however, the VIN was not included in the CSP. The manufacturer was notified of the failure, and informed the contact that the VIN was not under warranty or recall. The failure mileage was 108,000.