Ford Focus 2015 — Reported problems

The contact owns a 2015 Ford Focus. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the failure occurred after the recall repair. While starting and driving at an undisclosed speed, the check engine warning light illuminated. The vehicle stalled after refueling, and the RPM fluctuated while idling. The contact turned off the vehicle and waited before restarting the vehicle. Additionally, the contact discovered that the fuel tank was deformed. The contact retrieved DTC: P1450. The vehicle was taken to the dealer, who determined that the canister vent valve needed to be replaced. The dealer informed the contact that the failure was not associated with the recall. The manufacturer was notified of the failure by phone. The failure mileage was approximately 57,800.

I am NOT filing in regards to the clutch fracture recall on previous page . I AM filing a complaint regarding the 1.0 L Ecoboost engine "wet timing belt " system which is currently under NHTSA Engineering Analysis . My vehicle has 147,000 miles and still has the original wet timing belt . Ford`s original maintenance schedule states this belt is a standard wear item that lasts 150,000 miles . However , independent and federal data shows these belts degrade prematurely , shedding rubber teeth that clog the oil pump pickup tube screen .This creates a severe safety hazard , including sudden engine seizure and an immediate loss of power braking assist while driving . Because this is a systemic design flaw creating an unreasonable safety risk , Ford should expand safety recall 23S64 / 23V905 to cover 2015 manual transmission models . This engine is EXACTLY the same engine as the ones covered in the 2016-2018 recall with the same " wet belt " design . Ford has already insinuated to many owners that the belt degradation is due to wrong oil types used in these engines . The owner`s manual clearly states to use a Ford oil specification ( WSS-M2C945-B ) which I have used religiously . Ford later recommended a newer oil specification ( WSS-M2C948-B) after the fact . They also have recently recommending changing the belts at 100,000 miles instead of 150,000 miles after the fact . Interestingly , newer versions of this engine are using a METAL timing chain instead of a rubber belt that degrades . I wholeheartedly believe Ford should be forced to recall these cars and fix this belt safety issue before someone gets seriously injured or killed .

Back in July 2026 there was a rerecall for the 2018 recall that was not done correctly and my vehicle was not recalled for this when in fact that my vehicle should have it shows n I have proof that the recall number for that recall is the same recall they did on my vehicle but yet logged in under fuel tank defective but the recall number from 2018 match the new recall numbers issued in July for the recall that was performed in 2018 but yet I keep being told my Vin is not in the recently issued when it is decently is and should be cuz the recall number match and that is exactly what the issue is with my vehicle i have called since Feb 2026 about this issue and ever since the rerecall was issued but never showing my vehicle and it should be n I have proof that it match the recall numbers but logged in as different the. It should. Also my info is been correct since I got in feb2025 n yet only recall that was ever mailed was for a back up cam and that issued April 2026 n went to pervious owner which is my father address not mine like should I have proof of several recall that has been put out by either yall or manufacturer that never repaired or was never told it had my slef or my father when he purchased it I 2020 may n gave to me in feb2025 an was told that if he got car in 2020 that the dealer ship would fix the issue so was told after if it keep shuttering.Go to open rd safe give gas start at low gear n move up as speed increase it will clean off shutter will stop but yet still comes back so I have that along with it sticking in one gear idle in park high n then all sudden battery dies stalled got jump then lost reverse when out on a main rd real scary cuz if busy like normal it did that someone could been hurt cuz the problem that is causing issues is from 2018 recall that is july26 new recall number for the 2018 recall done didn't include mine should been i got proof big safety issue so parked cant drive risky need revised an fixed free an correct

My 2015 Ford Focus SE with the 1.0L EcoBoost engine and 6-speed manual transmission is experiencing a loss of engine lubrication/oil flow. The camshafts are not receiving adequate oil, there appears to be insufficient oil flow/pressure reaching the cylinder head. I am concerned that continued driving could result in engine damage, engine seizure, or a sudden loss of power while driving. I am aware that NHTSA Recall 23V-905 / Ford Recall 23S64 covers certain 2016-2018 Ford Focus vehicles equipped with the 1.0L EcoBoost for oil-pump drive belt or tensioner failure that can cause loss of engine oil pressure. My 2015 Focus is not currently included in that recall. I am submitting this complaint because my vehicle has a similar loss-of-lubrication condition and I believe NHTSA should document and evaluate failures occurring in 2015 Ford Focus 1.0L vehicles as well.

The contact owns a 2015 Ford Focus. The contact stated that while attempting to reverse, the vehicle failed to respond, with the check engine warning light illuminated. The vehicle was towed to an independent mechanic to be diagnosed, and the contact was informed that the TCM was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 56,990.

The vehicle experienced a sudden and complete loss of motive power due to an internal engine failure while stopped at an idle in active traffic. The engine stalled completely and would not restart, creating an immediate safety hazard as the vehicle was stranded in the roadway. This failure is directly related to the known issue where the 1.0L EcoBoost wet timing belt degrades, shedding debris that clogs the oil pump screen and starves the engine. Ford's Customer Satisfaction Program 26L02 acknowledges the component failure but does not offer a remedy or safety recall for my specific model year, leaving an unaddressed safety risk on the road.

The contact's daughter owns a 2015 Ford Focus. The contact stated that the vehicle stalled while the transmission was in reverse(R), and the vehicle rolled backwards downhill while depressing the brake pedal. The vehicle came to a stop once the vehicle was steered over into the grass, and the vehicle rolled into bushes and stopped. During the failure, the contact’s nephew exited the vehicle in a panic and sustained a scrape to the left hip. No medical attention was sought. The contact’s daughter experienced severe mental anguish, and the one-year-old child was also inside the vehicle. No Police report was filed. The vehicle was not towed. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline). The dealer acknowledged the similarity between the failure and the recall and stated that the vehicle was not included in the recall campaign. The vehicle was not repaired. The manufacturer was not notified of the issue. The failure mileage was approximately 163,951.

The transmission was repaired at 48k and I am now at 76k having severe issues with jerking, shuddering, and so forth. The car has undergone excellent maintenance for the CARFAX proves this. I bought this car with the very last of my inheritance money thinking I was getting a reliable product and come to find out, I got screwed and am on the hook for EVERY foregoing transmission repair.

My transmission gave out for the 3rd time on 8-1-26 as I was driving it slow down while on the highway busy street and studder it only goes into 2nd and 3rd gear when slowing down I can hear things clicking i know its the duel clutch because this is the 3rd time it happen both times it was fixed by a ford dealer. No message prior to problem but when it happen this message showed up " transmission fault service now"

This diagnostic code B00C0-11 Passenger Seat Occupant Classification Sensor A - Circuit Short to Ground - Not Current DTC came up when I took it to the transmission service center for another issue. I was not aware of this until then. I bought this car about 4 months ago from a private owner who did not disclose this issue either.

Clutch not shifting and was told by Lincoln for the TCM neede to be replaced. Got a second option and it was to by AAAMCO that it was clutch and it was replaced and now it’s says transmission which I’m told is external and insurance is not willing to pay for it but I keep coming up with all the information that’s says there is a recall and letters went out July 6 2026 on 2015 ford focus for these parts on the car.

Inside of door latch malfunctioned and my driver side door opened up while driving.

The contact owns a 2015 Ford Focus. The contact stated that the vehicle failed to shift into reverse and failed to properly shift gears. The vehicle failed to accelerate above 9 MPH. The vehicle was shifted to neutral and coasted to the residence. The contact stated that there was an abnormal whining sound coming from the vehicle. The check engine warning light was illuminated. The contact stated that the failure was associated with Customer Satisfaction Program: 14M02; extended warranty coverage for the Transmission Control Module. The vehicle was taken to an independent mechanic, who determined that the transmission needed to be replaced. The contact called the local dealer and was provided the cost of a diagnostic test, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and confirmed that there was no recall, warranty, or customer satisfaction program associated with the failure. The failure mileage was approximately 140,000.

I bought my car last Feb and didn't know there was a recall on it was never told I have had shutter problems with it as well as sticking in gear when parked it ide high then battery jus goes dead get a jump n the check engine light comes on n have no reverse this hasn't been safe to drive my sister was perivous owner nnwhen she bought it they told her that when it would shutter she jus needed to go through the gears on an open rd to make it stop shutter n now it is showing that there no recall on this site but showing on my credit n other platforms as well as ford that there is a recall for this along with other but ford refuses to fix this n had never sent a letter about this to my self or my sister who bought it In 2020 this needs to be fixed or car bought back

The contact owns a 2015 Ford Focus. The contact stated that while driving in the rain, the front windshield wipers were inoperable. The failure occurred intermittently prior to the complete failure. The vehicle was taken to an independent mechanic, where it was diagnosed that the windshield wiper module needed to be reprogrammed. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was 130,000.

I made an initial post on 06/18/2026 so please reference that as well as this. I have not been able to drive the car since it died on me on the 18th of June. The car has been looked at a few times (actually stalling a third time while idling but was able to turn back on.) It has also displayed symptoms associated with the Ford Recall #26S40 / NHTSA recall #26V369 but it is listed at NOT included in the recall as of 07/06/2026. MIL is pulling Code P0420 (catalytic system efficiency below threshold) while only having 40k miles. It is also putting out an inaccurate fuel level for miles driven. The fuel tank itself is misshapen (concave bottom of the fuel tank). Again, reiterating here that it stopped twice while driving within 2 days on major PA highways/interstates and stalled for a third time while in idle mode as described earlier in this post. This has all happened within 28 miles of the TCM being replaced.

Power clutch failure resulting in $6500 repair for a known issue by Ford. Ford refused to cover the repair or any part of the repair.

own a 2015 Ford Focus that has experienced repeated transmission-related problems over several years. The symptoms have included harsh shifting, hesitation, failure to shift properly, and at one point the vehicle would not shift into reverse. These transmission issues have caused ongoing concerns about the vehicle's safety and reliability. I have brought the vehicle to Ford dealerships on multiple occasions seeking diagnosis and repair. Ford replaced the Transmission Control Module (TCM) on November 16, 2024 under Ford Field Service Action 14M02 after diagnosing transmission-related problems, including Diagnostic Trouble Code P087A. Despite that repair, the vehicle continued to experience transmission-related concerns. Approximately one year later, another Ford repair order documented multiple TCM-related diagnostic codes and directed that the vehicle be returned to a Ford dealership for further evaluation. The transmission concerns persisted even after the previous TCM replacement. Most recently, I again presented the vehicle to a Ford dealership because of continuing transmission issues. I was provided an estimate of approximately $2,000 for additional transmission repairs. At the time of the estimate, I was not provided the complete diagnostic trouble codes or technician findings explaining why another major transmission repair was necessary. Over the course of ownership, I have made multiple appointments, diagnostic visits, and repair visits related to the transmission and have incurred significant out-of-pocket expenses, including diagnostic charges, towing costs, and repairs. The repeated failures and recurring transmission concerns have required multiple visits to Ford dealerships and have not resulted in a lasting repair. My concern is not only the financial cost but also the safety of operating this vehicle. Unexpected transmission malfunction can affect acceleration, shifting, and the vehicle's ability to move normally in traffic, creating a potential safe

Car wants to stall out when "shifting gears" like a loss of power

The contact owns a 2015 Ford Focus. The contact stated that the fuel tank was cracked and leaking fuel. The fuel warning light was illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 246,000.

My engine is the same 1.0 that is in the recall for these cars getting a new short block. TheRecall Numbers: Ford recall 23S64 (NHTSA Campaign 23V905). . For some reason the 2015 is not covered in this whileine had the same catastrophic failure and I have been have a hard time (over 5 years) to get it repaired or find a replacement engine. The 2015 eco boost 1.0 should be included in this recall

Engine Stalls: the engine stalls unexpectedly while driving at highway speeds and city/street speeds. Loss Of Power: Sudden loss of motive power creates an immediate crash hazard. Starting Issues: the car struggles to start or cranks excessively after refueling. Erratic Fuel Guage: The fuel gauge fluctuates wildly and gives inaccurate readings. Malfunction Indicator: The Check Engine Light is illuminated with emission-related codes. Fuel Tank Noise: Loud clunking or thumping noises come from the fuel tank area. The problem began in September 2025 and I took the car to a local mechanic and they fixed the issued, however the issue has started again. The fix did not solve the problems.

There were two times within a week where the car stopped in the middle of traffic. One was on Route 100 in a merge lane and the other was on the offramp of route 30 to 100 Exton. This happened in the middle left turn lane with traffic behind me causing me to need immediate police assistance to ensure my safety. The Check Engine light was popping from the TCM indicator which I was told I could still drive on without repairing it immediately. This came directly from Fred Beans Ford of West Chester PA. My car has been in the shop multiple times since December 2025 beginning with the original CPV recall and things got worse from there. It's caused lots of anxiety and ptsd while driving to the point I want to sell the car after it is repaired because I just don't feel safe anymore in it.

The contact owns a 2015 Ford Focus. The contact stated that while driving 30-70 MPH, the transmission was shuddering. No warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 18V169000 (Power Train). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 56,000.

I got a 2015 ford focus titanium. I bought it 2 years ago. Well about 2 months after I bought it the transmission started jerking and not really wanting to go out of 1st gear. Well I had to get a TCM replaced and then I was told about the studder wasn't under no warranty and the recall has expired. So now its 6-1-26 and now the transmission is messing up again. This is ridiculous on people who buys cars hoping they will last for a long time but instead we pay 7,000 for a car and drive it for 2 years. WOW THANKS A LOT FORD

No warning lamps until catastrophic engine failure. Power loss and that puts myself and others at risk. I have had multiple issues going back to first year owned when I had power loss while driving through interactions and on the freeway. Dealership tried to state it was due to bubble in coolant system. Then first engine failure occurred and was replaced by Ford

I am reporting a serious safety issue involving a 2015 Ford Focus equipped with the PowerShift transmission. The vehicle has experienced repeated failures of the transmission control module (TCM) and clutch system despite multiple repair attempts. The vehicle has been repaired at least three times for the same issue, yet the failure continues. While driving at highway speeds (approximately 65–70 mph), the transmission failed without warning. The vehicle lost power and was unable to properly shift gears, creating an immediate safety hazard. I was forced to navigate traffic with limited acceleration and was left stranded. This condition significantly increases the risk of a crash, especially when merging, accelerating, or maintaining speed in traffic. The failure occurs unpredictably and without sufficient warning. This issue is not isolated. The 2012–2016 Ford Focus models equipped with the PowerShift transmission have a well-documented history of similar failures, including prior complaints and manufacturer acknowledgment of defects. Despite multiple repair attempts, the defect has not been resolved, and the vehicle remains unsafe to operate. I am requesting that this issue be investigated as a safety defect, as it poses a serious risk to drivers and others on the road. I have found that many of the vehicles that recieved a replacement TCM, reported the problem came back, worsened, or the car had to be totalled all together. Even worse, took a huge hit.

Bought in 2024 ..few days later car wouldn’t change gears transmission overheats shutters jerks and won’t go when giving gas at times. Had the car in 5 times to fix, didn’t work.. I’ve almost been in accidents one of which was with a tractor trailer This car is a death trap had to quit job due to this .. and have a 7500.00 loan on a car I can barely drive. I want this loan paid off and given a check or car that has no problems and is reliable plus compensation for lost wages Im also willing to file suit immediately if this isn’t taken care of IMMEDIATELY!!!!

03/25/2026 Driving down the street card started jerking and acting like it did not want to move kept slowing down like it wasn't getting any gas. like the transmission was going out. There is nothing wrong with my transmission. The car had been on a recall for a part that has been replaced 2 different times. I tried to have it checked out the Ford dealers here where I live wanted to charge me $200.00 insisting that its my transmission. I know it is not my transmission. Its the same part they have replaced 2 times that was on the recall list for my car. What can I do? It is dangerous for me to drive.

After my car was left on idle for a couple minutes ( about 5), it began to shake, the check engine light came on, then it completely died. When I went to restart it, it stalled and then finally turned on but when I began to take off it began to shake and died on me again while driving. I was left in the middle of rode. I put my blinkers on and had to leave my car off for a couple minutes so it would restart again. Then I pulled over to the side so I wouldn’t be in harm’s way. My mechanic believes there is something wrong with thee fuel pressure system whether it be a fuel pump or a fuel pressure sensor.

While driving steering suddenly stopped working. Red light came up onto dash stating "steering down safely pull over"

The contact owns a 2015 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while accelerating and changing gears. The vehicle was driven to an independent mechanic, where it was diagnosed, and the failure was associated with NHTSA Campaign Number: 13V523000 (POWER TRAIN); however, the VIN was not associated with the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.

My name is [XXX] I own a 2015 ford focus 4dr sedan It has 131908 miles and the issue I've been having is with The TCM module on the transmission it won't go into sleep mode and it's draining the battery is have gotten a customer care warranty notice on my car but the local Ford dealer said it's expired in November of last year and I've been having family issues and personal issues we're i wasn't able to take care of it but I need this issue fixed on my car it's my only means of transportation for me and my mom because she has altzimers and dementia Here's my number [XXX] this my cell to contact me I live in Portland Oregon And also right now I have no way of paying for the repairs on my car because I lost my job because of a lower back injury I thought it was going to be a easy fix but it something I'm not able to do And thought it was going to be covered under the so called warranty which it's actually part of the recall I've gone through something like this with a previous car I owed and it was supposed to be taken care of through a recall but the dealer wouldn't do anything about they wanted me to pay on my vehicle I have i need this repaired I should not have to pay for the repairs that should be done through warranty or a recall it's been happening since the past couple years INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2015 Ford Focus. The contact stated that the vehicle had experienced transmission failures, including the transmission slipping, the vehicle stalling, and the check engine warning light being illuminated. Additionally, after starting the vehicle, the vehicle failed to respond after shifting to the reverse or drive. The vehicle was towed to the residence and examined by an independent mechanic, who diagnosed the vehicle and determined that the transmission power shifter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 149,000.

I am in possession of Recall18S32/NHTSA recall18V-735 notice that has not been repaired but it is not showing up on my VIN and Model lookup.

At 116,500 miles, the oil pump failed on my Ford Focus. This was verified by an auto repair shop. The car has the Ford ecoboost 1.0 engine. Ford has a recall on this engine with a build date of March 24, 2015 to May 4, 2018. My car was built on Aug 4, 2015 within the range of the recall. The recall states that cars with automatic transmission are included. My car has a manual 6 speed. I don't believe that the transmission has anything to do with the oil pump failure. The car "check engine" and "check oil" lights came on and there were multiple instances where the car stalled and I became stranded, often on busy roads. It has been well documented on the internet that Ford has had issues with this engine. I am not planning on repairing this car as the shop explained it probably will be in the range of $7000 which way more than the value of this car that is almost 10yrs old and 116500. The car is currently sitting in my garage non drivable with a scrap value of pennies compared what trade-in value or extend life of the car.

Vehicle acceleration dies out during normal pressure of gas pedal. Coding showing transmission Actuators malfunctioning. Odometer Reading 120,631 check engine light came on. Date of malfunction 11/24/2025 , Vehicle was taken to Affordable Transmission on 11/25/2025

I was getting ready to leave the grocery store and I crank up my car and I had a light come on stating that my car was overheating transmission turn off the car and as I tried to pull out of the parking lot, the car would barely accelerate it would barely go to mountain and it was stuttering up the heels I had to turn off the vehicle. Let it sit for five minutes to let it cool off and then I had to crank the car back up and then it started to drive again, but I did get a indication on my front dash stating that it was transmission

2015 Ford Focus with DPS6 automatic transmission failure. 109,### miles only. Symptoms: No reverse gear, severe clutch slip (high RPM but car barely moves), strong burnt clutch smell, check engine light on. DTC codes: P07A3, P07A5, P087A, P087B, P090C. Ford dealer (Camelback Ford, Phoenix AZ) diagnosed the issue but quoted $3,175 just for labor to open the transmission for inspection, refusing any goodwill assistance after 14M02 program expired in August 2025, despite low mileage and known widespread DPS6 problems covered by TSB 16-0129. Note : "November 20, 2025 – Date I purchased the vehicle. The transmission problem (no reverse, clutch slip, burnt smell) was present immediately upon purchase." Requesting NHTSA investigate Ford's refusal to offer reasonable post-warranty assistance for this well-documented safety-related transmission defect.

Transmission overheating and internal wear (metal particles in fluid) following electrical/TCM malfunction in Ford Focus DPS6. Transmission failure recurred after earlier repair under 14M02. Current failure includes overheating messages, shudder, and loss of safe drivability. Ford acknowledges issue relates to known PowerShift defect but refuses coverage. Vehicle unsafe.