Ford Focus 2001 — Problemas relatados

The contact owns a 2001 Ford Focus. The contact stated that while driving her vehicle at approximately 35 MPH, the ball joint snapped on the vehicle's passengers side. The contact stated there were no warning lights illuminated nor any indication of a failure prior to the ball joint snapping. The contact stated that when the failure happened to her vehicle it caused her to crash into a ditch. The contact stated that no injuries were sustained and the vehicle was towed to the residence where it remains currently. The contact stated that she did contact the dealer as well as the manufacturer who advised her to contact NHTSA. The failure mileage was 190,000.

The front dashboard and steering wheel airbags went off. if I was moving this could’ve ended even worse but luckily I was stopped. My hearing was affected. I was parked at a red light and my airbags went off. I did not hit anything nor was my car moving. Witnesses at a restaurant and auto repair shop say the same. My car had passed that years inspection and there was no signs of this happening. No lights, sounds, anything. It was very sudden.

KEEPS SHUT OFF N OVER HEATING

ON 9/2/2020 AROUND 10 PM IN MICHIGAN I WAS MAKING A PIZZA DELIVERY, I PULLED INTO THE SUBDIVISION WHERE I HAD TO MAKE THE DELIVERY, ALL THE SUDDEN MY CAR COMPLETELY SHUT OFF. I COULDN'T ACCELERATE OR BRAKE. I GOT MY CAR FO SAFTEY AWAY FROM THE HOUSES BECAUSE MY FIRST INSTINCT WAS SAFETY. I GRAB MY PHONE TO CALL MY BOSS, I THOUGHT MY CAR JUAT BROKE DOWN. THEN I SAW SMOKE AND SPARKS. I CALLED THE EMERGENCY SERVICES AND THE CARS SMOKE GOT DARKER AND THE FLAMES GOT BIGGER. I WAS VERY SCARED. ALL MY WINDOWS EXPLODED AND THE CAR MELTED TO GROUND. BY THE LOOKS OF MY PHOTO THE FIRE STARTED NEAR THE BATTERY AND CABLES. EVER SINCE THAT NIGHT, I'VE BEEN SCARED OF FIRES, HOT SURFACES, AND WEARY AROUND CARS. I'M LUCKY TO BE ALIVE BUT IT WAS VERY DANGEROUS AS THE FLAMES REACHED ABOUT 10 FEET HIGH. LUCKILY IT DID NOT CATCH ANYTHING NEAR BY ON FIRE.

THERE ARE NUMEROUS ELECTRICAL PROBLEMS WITH MY REAR LIGHTS. MY LICENSE PLATE LIGHTS WILL NOT WORK AT ANYTIME AND SOMETIMES NONE OF THE REAR LIGHTS WORK AT ALL.

SEE COMPLAINT 11338120 I WANTED TO ADD PICTURES

WHILE I FIND RUST RECALLS FOR 2001 FOCUS FUSIONS AND WINDSTARS FORD CLAIMS THERE IS NO RECALL FOR FRAME COLLAPS FROM EXCESSIVE RUST PROBLEMS. WE PULLED OUT OF OUR DRIVE HEADED UP A BLIND HILL AND THE FRONT END TOTALLY COLLAPSED LEAVING US AS AN EASY TARGET. SEVERAL GOOD FOLKS JUMPED INTO ACTION TO HELP US GET THE MESS SAFELY OFF OF THE STATE HIGHWAY BY BLOCKING TRAFFIC AND HELPING US DRAG IT BACK INTO OUR DRIVEWAY. WE ARE IN OUR 70'S AND ONLY DRIVE THE CAR 7-8 THOUSAND MILES A YEAR. IT HAS BEEN BABIED AND MAINTAINED BY THE BOOK IT ENTIRE LIFETIME . CONVERSATIONS WITH FORD HAVE GOTTEN US NO WHERE! WHERE DO WE TURN ?

KEEPS OVER HEATING. *TR

2001 FORD FOCUS ZX3 STALLS WHEN DRIVING AND ALMOST CAUSED SOMEONE TO REAR END MY CAR. NOW WONT STAY RUNNING WHEN IDLING. CAR CUTS OFF AT LIGHTS OR STOP SIGNS OR WHEN BREAKING OR ENGAGING CLUTCH.

AFTER DRIVING FROM WORK TO HOME, ABOUT 4.6 MILES, I TURNED RIGHT INTO MY PARKING SPACE IN FRONT OF MY HOME WHEN THE BRAKES FAILED WHILE THE CAR ACCELERATED DIRECTLY INTO THE ROCK WALL THAT SERVES AS A BARRIER BETWEEN THE PARKING, WALKWAY AND BUILDING; I IMMEDIATELY PULLED UP THE EMERGENCY BRAKE, PUT IT INTO PARK AND TURNED THE CAR OFF. I HAD IT TOWED INTO MY MECHANIC AND WAS NOTIFIED THAT THEY FOUND "THROTTLE CABLE WAS BOUND UP" AND THEY "RE-ROUTED CABLE PROPERLY." I WOULD LIKE TO KNOW IF ANYONE HAS EVER HAD THIS EXPERIENCE WITH THEIR VEHICLE ACCELERATING WHEN BRAKES ARE APPLIED ON THIS MODEL. I WOULD LIKE TO KNOW HOW THE CABLES CAN BECOME BOUND UP. THIS WAS A VERY FRIGHTENING EXPERIENCE. I HAVE TAKEN VERY GOOD CARE OF THIS AUTOMOBILE AND HAVE MAINTENANCE PERFORMED ACCORDING TO MANUFACTURER SUGGESTIONS IN THEIR GUIDE BOOK.

MY DRIVER SIDE PASSENGER DOOR HAS BEEN ACTING UP FOR MANY YEARS NOW AND FORD WILL NOT FIX IT. NOW MY DOOR WILL NOT CLOSE. MANY OF THE 2001 FORD FOCUS HAVE BEEN RECALLED FOR THIS ISSUE AND THEY SAY MY VIN NO. IS NOT ONE OF THEM. PLEASE HELP ME GET MY DOOR FIXED. WHEN I WENT TO GET IT INSPECTED ON 11.2.18 THEY OPENED MY DOOR AND NOW IT WILL NOT CLOSE AND AGAIN THEY SAY THAT I HAVE TO FIX IT. AS MENTIONED, THIS HAS BEEN AN ISSUE FOR YEARS AND I AM STILL DEALING WITH IT. MY CAR IS IN EXCELLENT CONDITION AND DO NOT WANT TO GET RID OF IT. I BELIEVE THAT FORD IS RESPONSIBLE FOR FIXING THE LATCH. MY CAR HAS HAD A FEW RECALLS THAT WERE FIXED, ONE OF WHICH WAS A FEW YEARS AGO THAT THEY HONORED. I HOPE TO GET THIS ISSUE RESOLVED QUICKLY AND THEY WILL NOT PASS MY CAR FOR INSPECTION AND I NEED MY VEHICLE. THANK YOU.

CAR WAS DRIVING FINE RUNNING A FEW ERRANDS. STOPPED AT A STORE FOR ABOUT FIVE MINUTES , WHEN I GOT BACK IN AND STARTED THE ENGINE ALL I HEARD WAS A LOUD CLANKING NOISE AND THE IDLE WAS ROUGH. DID A LITTLE RESEARCH ABOUT THE CAR AND DISCOVERED ALL THE COMPLAINTS ABOUT ENGINE FAILURE . SO THATS WHAT HAPPENED TO MINE . DROPPED VALVE SEAT.

WAS ON MY WAY TO THE VA HOSPITAL 04/04/2018 STARTED CAR, IT WOULD SHAKE VIGOROUSLY. CHECK ENGINE LIGHT AND OIL FUEL LIGHT KEEP COMING ON AND OFF. HAD A COMPLETE TUNE UP. GOING TO THE VA HOSPITAL ON 4/16/2018 START CAR, CHECK ENGINE LIGHT CAME ON AND FUEL LIGHT CAME ON AGAIN. HAD INNER TIRE RODS REPLACED. GOING TO A VA APPT, ON 05/10/2018 START CAR CHECK ENGINE LIGHT CAM ON, CV VALVES REPLACED. 5/30/2018 ON MY WAY AGAIN TO THE VA HOSPITAL, START CAR CHECK ENGINE LIGHT CAME ON AGAIN. PLEASE ADVISE, SINCE IT VERY DIFFICULT TO MISS AND RESCHEDULE APPTS AT THE VA HOSPITAL. THANK YOU.

MY MECHANIC IDENTIFIED EXCESSIVE DANGERS CORROSION OF THE ENGINE CRADLE AND ADVISED THAT THE ENGINE COULD FALL OUT WHILE DRIVING. I CALLED THE FORD DEALER WHO SENT ME TO FORD. THE TOOK MY INFORMATION, FORD REF. RFF14807554. THEY WOULD NOT COMMIT TO EXAMINING THE CAR. I AM AFRAID THIS PROBLEM COULD BE WIDESPREAD AND DANGEROUS TO OTHERS. THIS DETERIORATION OF THE STEEL IS NOT NORMAL. I HAVE A BACKGROUND IN WORKING IN METALS FOR 30 YEARS. I OFFERED TO DONATE MY CAR FOR REVIEW AND FORD WAS NOT INTERESTED. MANY OLD FOCUS ARE ON THE ROAD. MY CAR HAS BEEN GARAGED AND HAS ONLY 82,640 MILES. I DO NOT WANT ANYONE HURT BECAUSE OF THIS PROBLEM FORD HAS HAD RECALLS IN THE PAST FOR ESCAPES & WINDSTARES FOR SUBFRAME CORROSION ON THE ENGINE CRADLE.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE LOW AND HIGH BEAM HEADLIGHTS FAILED TO ILLUMINATE BRIGHTLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO METRO FORD OF MADISON (5422 WAYNE TERRACE, MADISON, WI 53718, (608) 246-3600), BUT THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

THIS CAR HAS ELECTRICAL ISSUES,THE DASH AND TAG LIGHTS FLICKER,THE CAR HAS BEEN TURNING OFF WHILE I'M DRIVING WITH MY SON IN THE CAR OVER 3 TIMES NOW,ON THE HIGHWAY AND ON MAIN STREET,ITS SO SCARY I'VE HAD PANIC ATTACKS AND GOT A STRESS RASH ON MY FACE. IM SO SCARED THAT I CAN'T DRIVE IT,I'VE HAD THE FUEL PUMP REPLACED,SPARK PLUGS,MOTOR FILTER.I JUST TRY TO KEEP GETTING IT REPAIRED COSTING ME MY BILLS MONEY BEING A SINGLE PARENT. I'M OVERWHELMED AND DON'T KNOW WHAT TO DO.

KEY WON'T TURN IN IGNITION SO CAR CAN'T MOVE. VEHICLE WAS STATIONARY AND PARKED ON THE STREET

MY CAR IS 2001. I STARTED TO HAVE PROBLEMS WHEN TURNING ON. I THIUGHT IT WAS STARTER. BUT MINES THATS STILL GOOD. I THOUGHT ALTERNATOR OR BTTERY BUT THEY ARE NEW. SO THEY CHECKED WITH CAMERA AND VALVE PISTNS NOT WORKING. I LOOKED UP REVIEWS ABOUT CAR MAKE AND YEAR. MANY COMMENTS READ VALVE BENT. PISTONS GONE BAD. NOW IM ANOTHER OWNER WITH SAME PROBLEM. THIS CAR IN REVIEWS IS CONSIDERED A LEMON. GOOD THING IT DIDNT WANT TO TURN ON WHEN IT WAS PARKED ALREADY AT HOME. I READ OTHERS OCCURRED IN MOTION.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE REAR DRIVER'S DOOR LATCH CEASED TO FUNCTION. THE FAILURE OCCURRED WITHOUT WARNING. KUNES FORD WAS CONTACTED (1234 E GENEVA ST, DELAVAN, WI) AND REFERRED THE CONTACT TO NHTSA. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 199,000.

THIS HAS HAPPENED SEVERAL TIMES. THE VEHICLE ACCELERATES TO 2000-3000 RPM BY ITSELF. SOMETIMES WHILE AT IDLE AND SOMETIMES WHILE DRIVING AT ANY SPEED IN TOWN OR THE HIGHWAY. I HAVE NOT BEEN ABLE TO RESOLVE THE ISSUE AND HAVE SPENT MONEY ON TPS, THROTTLE BODY, SPARK PLUGS AND WIRES, COIL PACK, FUEL PUMP AND FILTER AND IT STILL DOES THE SAME SUDDEN ACCELERATION. THE LOCAL DEALER SAID THEY HAVE NOT BEEN ABLE TO CORRECT THAT ISSUE WITH OLDER FORD FOCUSES. IS THERE A FIX TO THIS ISSUE AVAILABLE? MAYBE A RECALL? I HAVE BEEN CLOSE TO HITTING A MOVING VEHICLE, AFTER EXITING IH 35 AND COMING UNTO A TRAFFIC LIGHT ON THE ACCESS ROAD. I ALMOST REAR ENDED SEVERAL VEHICLES STOPPED AT THE TRAFFIC LIGHT. UPON EXITING THE INTERSTATE I WAS APPROACHING THE INTERSECTION, MY VEHICLE ACCELERATED TO ABOUT 3500 RPM AND I COULD NOT STOP IT USING THE BRAKES EVEN THOUGH I WAS PRACTICALLY STANDING ON THE BRAKE PEDAL. I WAS ABLE TO PUT THE GEAR IN NEURAL AND THUS DID NOT HIT THE VEHICLES AT THE TRAFFIC LIGHT. THE VEHICLE EVENTUALLY IDLED DOWN BUT IT WAS VERY DANGEROUS AND AN EXTREMELY SCARRY SITUATION. I HAVE NOT USED THE VEHICLE SINCE EVEN THOUGH I HAVE SPENT A LOT OF MONEY ON REPAIRS. I WOULD PROBABLY NOT BUY A FORD AGAIN. I AM GOING TO SELL THE CAR BUT WILL TELL THE BUYER THAT THE ISSUE HAS NOT BEEN FIXED. THANKS FOR ANY HELP AVAILABLE

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE IDLING AT A STOP SIGN, THE VEHICLE STALLED AND THE BATTERY AND OIL WARNING INDICATORS FLASHED ON AND OFF. THE VEHICLE WAS PUSHED BY A BYSTANDER TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED A UNKNOWN LOCAL FORD DEALER AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. UPON DRIVING OVER A SPEED BUMP AT AN UNKNOWN SPEED, THE CONTACT HEARD AN ABNORMAL NOISE AND THE VEHICLE SWERVED. AFTER REACHING HER DESTINATION, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE SUBFRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS INSPECTED BY AN INSURANCE ADJUSTOR WHO CONFIRMED THAT THE REAR SUBFRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 115,909.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND THE VEHICLE RESTARTED NORMALLY AFTER SOME TIME. THE FAILURE RECURRED SEVERAL OTHER TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 107,333.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT OBSERVED THAT THE CROSSMEMBER FAILED WITHOUT WARNING. THE VEHICLE WAS DIAGNOSED BY THE CONTACT, WHO WAS AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NO DASH LIGHT TAIL LIGHTS OR MARKRR LIGHTS

THE CAR JERKS WHEN I PUT IT INTO REVERSE. THE CARS STALLS WHEN I PUT IT INTO DRIVE. I HAVE TO TAKE OFF IN 2ND GEAR. THEN I CAN PUT IT INTO DRIVE AND IT TAKES OFF JUST FINE.

CAR WILL NOT IDLE WHEN STOPPED AT A LIGHT IN THE CITY, WHEN SHIFTING INTO DRIVE FROM PARK, RUNS ROUGH AT LOW SPEEDS WHILE IN TRAFFIC AND GOING THOUGH PARKING LOTS. STARTED ONE MORNING, RAN HORRIBLY, STALLED AND HASN'T STARTED SINCE. THE BACK DOOR DOESN'T STAY LATCHED WHEN SHUT.

IGNITION KEY GETS STUCK AND WILL NOT TURN. FORD HAS KNOWN OF THIS PROBLEM SHOULD HAVE TO PAY FOR REPAIRS AND REIMBURSEMENT.

I BOUGHT THE CAR DROVE IT OFF THE LOT ABOUT 3 HOURS I HAD TO GET IT TOWED. THE DEALER GOT IT BACK FOR 6 MONTHS AN FINALLY I GOT IT BACK. NOW IT IS DOING THE SAME THING. BATTERY CABLES HAVE DAMAGE. CRANKS BUT WON'T START.

THE FRONT PASSENGER SIDE AIRBAG MALFUNCTIONED IN THAT IT DEPLOYED WITHOUT REASON. I WAS DRIVING (IN MOTION) STRAIGHT DOWN A CITY ROAD. IT MADE AN EXTREMELY LOUD NOISE THAT AFFECTED MY HEARING, EXPELLED A LOT OF WHITE POWDER THAT SMELLED BAD, AND TORE UP THE SIDE OF THE PASSENGER SEAT. THE AIRBAG WARNING LIGHT WENT ON.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.

HAD GOOD TUNE UP,CAR WAS DOING GOOD AND NOW JUST AS I HAVE READ PROBLEMS WITH THE FUEL SYSTEM,IS EXACTLY WHAT HAPPENED OUT OF NOWHERE STARTS GIVING ME ISSUES STARTING AND STAYING RUNNING.AFTER TESTING I HAVE 90%OF FUEL PRESSURE WHICH SHOULD ONLY BE 40-45 MAX????WAS CHECKED IN SHOP OVER A WEEK AND LOOKING THROUGH RECALLS I BELIEVE IT IS A DEFECT IN THE FUEL SYSTEM THE FUEL IS GOING SOMEWHERE BUT NOT ALLOWING CAR TO RUN.TO TAKE OFF THERE IS NO TAKING OFF ,LIKE THE OEDAL DOES NOTHING JUST FOR LOOKS.WOULD LIKE TO HEAR BACK.

AS DESCRIBED IN NHTSA ACTION NUMBER EA02022, CAR STALLS AT BELOW 1/4 TANK, PARTICULARLY ON RIGHT HAND TURNS.

2001 FORD FOCUS WITH 146K MILES. ADULT DRIVEN ONE OWNER AND WELL CARED SINCE NEW. NOTICED CLUNKING SOUND SO TOOK IT IN FOR BRAKES TO THE FORD DEALER. WAS TOLD BY DEALER THEY CAN'T FIX AS ENTIRE SUBFRAME IS ROTTED AND "I WAS ONE POTHOLE FROM THE ENGINE FALLING OUT". IT APPEARS THAT DEALERS USE THIS LINE AS I FOUND OTHER COMPLAINTS WITH THE EXACT SAME WORDING. HOW CAN YOU RECALL THE ESCAPE AND WINDSTAR FOR THE SAME PROBLEM AND NOT THE FOCUS? BECAUSE FOCUS OWNERS DON'T HAVE THE SAME MONEY THAT THOSE OTHER HIGHER END CARS HAVE? I WAS DRIVING MY NEW BABY AROUND IN THIS CAR AND THANK GOD I DIDN'T HIT THAT ONE MORE POTHOLE OR BOTH OUR LIVES COULD HAVE BEEN ENDED! ALL IT TAKES IS AN INTERNET SEARCH TO REALIZE THAT THIS IS A COMMON PROBLEM. THE SUBFRAME IS A VERY IMPORTANT COMPONENT TO A CAR THAT SHOULD NOT JUST RUST AWAY IN 14 YEARS! CLEARLY THE DESIGN OR MATERIALS USED WERE AT FAULT FOR THIS. FORD NEEDS TO RECALL THESE CARS BEFORE MORE PEOPLE ARE KILLED OR INJURED!

TAKATA AIRBAG DEPLOYED AFTER THE CAR HAD COME TO A STOP. ALI STOPPED TO AVOID HITTING A CAR THAT HAD SUDDENLY BRAKED IN FRONT OF HER. THERE WAS NO DAMAGE TO THE CAR IN FRONT HER AS ALI WAS ABLE TO STOP IN TIME, BUT THERE WAS MAJOR DAMAGE TO HER CAR. WHEN THE TAKATA AIRBAG DEPLOYED IT BURNT HER LEFT FOREARM/HAND AND INCURRED $107.00 IN MEDICAL EXPENSES. CALIBER COLLISION SAYS THAT TO REPAIR THE CAR IT WOULD COST ALI $7,639.37.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING, THE VEHICLE PULLED TO THE RIGHT INDEPENDENTLY AND THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE LOWER CONTROL ARM, BALL JOINT ASSEMBLY, AND AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT DID NOT KNOW IF THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 02V289000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,611.

DRIVING FORD FOCUS SLOWLY IN SNOW,A JEEP SPUN OUT OF CONTROL HIT THE DRIVERS SIDE FRONT OF CAR SPUN AROUND AND HIT US AGAIN FROM THE REAR.AIRBAG DEPLOYED AND IT MY PASSENGER FULL IN FACE. DAMAGED HER FACE WITH CHEMICAL BURNS AND CREATED A COROIDITAL TEAR IN HER EYE THAT IS PERMANENT AND PERMANENT VISION LOSS IN ONE EYE. THE IMPACT OF THE AIRBAG JARRED HER BRAIN AND SHE NOW HAS A BRAIN INJURY CALLED CHIARI MALFORMATION,

ON 5/2/15 DURING A COLLISION WHERE MY CLIENT STUCK ANOTHER DRIVER THAT FAILED TO YIELD AND RAN A STOP SIGN, THE AIRBAG INSIDE MY CLIENT'S 2001 FORD FOCUS DEPLOYED. DURING ITS DEPLOYMENT IT BURNED THE RIGHT VOLAR (INSIDE) FOREARM OF MY CLIENT, CAUSING A FULL THICKNESS BURN. SHE HAD TO UNDERGO SURGICAL TANGENTIAL EXCISION OF THE BURN AND SKIN GRAFTING, WHERE THEY HARVESTED THE SKIN FROM HER RIGHT THIGH TO HER RIGHT VOLAR FOREARM. THE AIRBAG IS DANGEROUS AS IT CAUSED FULL THICKNESS BURN TO HER SKIN, FOR WHICH SHE IS STILL RECOVERING.

AFTER A 2~ HOUR DRIVE, ENGINE WAS TURNED OFF AND RESTARTED 5MIN LATER. AN INTAKE VALVE SEAT DROPPED AND IT INSTANTLY SMACKED THE PISTON ON THE FIRST TURN OF THE ENGINE, IT HIT HARD ENUF TO BLOW THE PISTON APART AND THE CONNECTING ROD PUT A HOLE THRU THE PISTON LINER. PUTTING COOLANT IN TO THE CRANK CASE, AS IT WAS NO LONGER CONNECTED TO THE PISTON ANY MORE. NEEDLESS TO SAY IT WAS NOT ABLE TO DRIVE. I REPAIRED THE AUTO WITH A AFTERMARKET HEAD FROM HTTP://CIFICINC.NET/ AND A SHORT BLOCK OUT OF A PARTS CAR. AFTER DOING SOME RESEARCH IM NOT THE ONLY PERSON TO HAVE THIS FAILURE, THERE ARE FOCUS ALL OVER THE NET THAT HAVE HAD THIS FAILURE. I SEEM TO BE LUCKY AS ITS MUCH MORE COMMON FOR IT TO HAPPEN AROUND 110/140K THEN 206K THE ESCORT ALSO HAS THE SAME ENGINE OR ONE OF THE SAME SPI SOHC 1.9/2.0 ENGINE FAMILY AND CAN ALSO HAVE THIS FAILURE. . . I REPAIRED THE AUTO ONLY BECAUSE OF ITS ABOVE AVERAGE MPG, HAD IT NOT GOTTEN HIGH 30S OR BETTER, I WOULD HAVE GOTTEN RID OF IT. AS THE VALUE OF THE AUTO IS AROUND 1,400~ AND THE REPAIR WAS ABOUT HALF THAT, DOING ALL THE WORK MY SELF...TAKING IT TO A SHOP WAS OUT OF THE QUESTION AS THE COST TO REPAIR WOULD HAVE BEEN 2X THE VALUE OF THE AUTO OR WORSE....

MY CAR WILL LOSE SPEED GOING UP HILLS AND START TO ACT LIKE IT'S RUNNING OUT OF GAS. I HAVE HAD IT GO DEAD WHILE GOING DOWN THE ROAD AND THE STEERING BECOME HARD TO MOVE. IT SURGES GOING AT VERY LOW SPEEDS OF ABOUT 10-15 MPH AND JERKS. SOMETIMES THE EVEN GOING ON STRAIGHT ROADS WHERE THERE ARE NO HILLS THE CAR STARTS TO ACT LIKE IT'S RUNNING OUT OF GAS AND DIE. THE ONLY THING THAT SHOWED WHEN I HAD IT CHECKED WAS THE THROTTLE BODY POSITION SENSOR WHICH I REPLACED AND NOW SAYS OUT OF RANGE AND NO ONE KNOWS WHY.