Ford Explorer 2014 — Problemas reportados

My drivers seat belt will only fasten at the perfect angle about 10% of the time or less. I called form to open a claim but they said it was a “wear and tear” item. I don’t think a SEATBELL is a negotiable.

My steering wheel suddenly became really loose causing the control of the vehicle to be really difficult and it make a very loose hollow noise.

Engineering design flaw. Water pump connected to the timing chain, knowing that it would cost thousands of dollars to fix.

Vehicle Safety Hazard Report: Toxic Cabin Fumes & Engine Hazard Following Improper Franchise Repair My 2014 Ford Explorer (VIN: [XXX]) was serviced at Sawgrass Ford in Sunrise, FL for an initial internal water pump replacement. Immediately following this repair, the vehicle began emitting heavy white exhaust smoke and filling the passenger cabin with toxic chemical fumes. I returned immediately to Sawgrass Ford to address this severe safety hazard. The service advisor conducted a "courtesy check," explicitly falsely assured me that the vehicle was safe, and released it back to me. Due to the continuous heavy white smoke and toxic interior cabin fumes, the vehicle represents an immediate public road hazard and toxic inhalation danger. I have permanently parked the vehicle to avoid further hazardous exposure and imminent secondary internal engine destruction. The dealership completely failed to diagnose the internal coolant breach after servicing that exact internal system. A formal dealer compliance investigation has been filed with the Florida Bureau of Dealer Services. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Power Assist Steering fails and becomes very difficult to turn the steering wheel, requiring much force to initiate a turn and requires just as much force to disengage/return the steering to a straight ahead direction. It cuts out unexpectedly and often. Dealer has examined and says cannot be repaired without replacing the whole steering shaft, gear and rack as well as the tie rods. Vehicle only has about 80,000 miles and steering rack and gears should not wear out this soon.

I was driving down the highway, and I heard what sounded as if something had fallen on vehicle and cracked my window. However, there wasn't anything, so I got out of the car and saw that my B pillar trim had come off and was hanging down by the wires on the driver side of vehicle. This was very frightening as this could have resulted in an accident due to this piece falling apart on the side of the car.

My 2014 Ford Explorer experienced a serious electric power steering failure. While driving, the vehicle displayed “Power Steering Assist Fault” and the steering became extremely difficult to turn due to loss of steering assistance. I was driving with my child in the vehicle when this occurred. I believe this created a potentially life-threatening situation. If I had needed to make an emergency maneuver or avoid another vehicle or obstacle, I may not have been able to control the vehicle normally. I could have been killed and my child could have been seriously injured or killed. The Power Steering Control Module was scanned and produced these DTCs: U3000-96 – Control Module: Component Internal Failure; U2011-49 – Motor: Internal Electronic Failure; U3000-49 – Control Module: Internal Electronic Failure. I replaced the battery with a brand-new battery and replaced a corroded EPAS fuse, but the steering remained extremely difficult and the problem continued. The vehicle is currently at Howell Ford in [XXX]. I have been given an estimated repair cost of approximately $2,700 plus tax. The repair has not yet been authorized. I previously contacted NHTSA and received Request #XXX, concerning “2014 Explorer Electric Power Steering Failure / Matching EPAS DTCs.” I am concerned this may be a safety-related defect and may be related to electric power steering failures reported on other Ford Explorer model years. I am requesting that NHTSA compare my vehicle, symptoms, and DTCs with other Ford Explorer EPAS complaints, investigations, recalls, and manufacturer information and determine whether the 2014 Explorer requires further safety review. I can provide the VIN, diagnostic scan, photographs, dealership information, and repair estimate. This was an actual loss of steering assistance, not merely a warning light, and occurred while I had my child in the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2 incomplete recalls

Steering simply shutoff and locked up while driving. I seen there's a recall on 2013 Ford exploers but not for 2014 even though its the same problem. Now im without a vehicle and it will be a expensive repair.

I own a 2014 Ford Explorer, VIN [XXX]. In approximately 2020, I reported damaged exterior A-pillar appliqué trim clip(s) to a Ford dealer and requested repair. I was told the needed part was on backorder. The condition was not permanently repaired. Ford later issued Safety Recall 24S02 / NHTSA Recall 24V-031 for certain 2011-2019 Ford Explorers involving exterior A-pillar appliqué trim retention clips that can allow the trim to loosen or detach. This is the same or substantially similar condition I reported years earlier. At a later dealer visit, the dealer verified the damaged A-pillar trim. Instead of completing a permanent repair, black duct tape was applied as a temporary measure. I was again told the recall repair parts were on backorder and that I was on a waiting list. The recall repair remains incomplete. I am concerned the exterior A-pillar trim could loosen or detach while driving, creating roadway debris and a hazard to other motorists. I believe the continued delay is unreasonable because I first reported this condition in 2020, the dealer verified it, and the issue is now covered by a safety recall. I request that NHTSA review Ford’s and the dealer’s continued inability to provide the required recall repair and the reliance on duct tape as a long-term temporary measure. I request prompt availability of the correct parts and completion of the recall repair at no cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Recall issued and notified via mail by Ford for faulty A-pillarsin 2024. A-pillars can fall off vehicle while driving and can cause safety issue. Vehicle was taken to dealer for inspection in March of 2025 to verify issue and was informed that no parts are available. After several visits to service department and phone calls, still no parts available for now 2+ years. Ford apparently has no intention of providing parts for the recall.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 55 MPH, the front driver’s side A-pillar trim had detached. The local dealer was contacted on several occasions. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 127,000.

There are often times that there is a strong exhaust odor inside the vehicle, especially when idling

This complaint concerns a failed federal safety recall repair that has resulted in structural damage and rendered my vehicle unsafe to drive. I am the original owner of this vehicle (since XXX). On XXX, Riverside Ford ([XXX]) performed a federal safety recall repair on my vehicle's A-pillars. On January 28, 2026, the vehicle began leaking water. On that day the dealership find the leak due to cracked A-pillar from the clip not holding.In May 2026 I had 4 inches of standing water on the passenger side while in Florida on vacation, and smeared excessive, unprofessional adhesive on the exterior trim. Took it to the dealership the Monday after returned from vacation to have them figure out why it was leaking again. They charged me $218 to have a diagnostic check even though it was part of the recall. Couldn't find any leaks. Took the headliner down. Said that they cleaned out the sunroof tubes but didn't verify if anything ever came out of them. Went back again because of the adhesive that was seeping and dried onto it and you look it's very sloppy. Contacted Ford corporate office opened a case. On XXX, during a another attempt, the dealership replaced the A-pillars again. Upon pickup, the interior sunroof headliner was completely sagging and unseated from its rails. There are massive structural gaps on all sides where I can stick my hand through to the sunroof rails. The dealership service manager, Connie Tell, denied responsibility and refused to let me view the shop video. The vehicle is no longer weather-tight, poses an interior electrical/mildew hazard, and cannot be driven in the rain due to the dealership's faulty execution of a federal safety recall. They also chipped paint off of my vehicle again taking the pillars off to replace them. Connie, when I had mentioned it said you already have paint chips on your car. What difference would it make that's not the point at all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sudden and complete loss of power steering assist while vehicle was in operation. Vehicle became extremely difficult to steer, creating safety hazard for driver and child passenger. Inspection revealed 150A EPAS Mega Fuse, Part #L0114875AA, was melted due to electrical short in Power Steering Control Module. This is identical to the defect described in NHTSA Safety Recall 14V316000 / Ford 14S06. Fire risk confirmed by melted/burned fuse condition. Photos of failed component attached. Component is available for inspection. Ford Customer Service denied assistance under Recall 14S06 on 07/10/2026, claiming vehicle was not covered despite physical evidence of the exact defect described in the recall. Vehicle manufacture date is 06/2014. Ford Technical Service Bulletin 15-0082 acknowledges some 2014 vehicles may still have defective modules installed. Vehicle is currently inoperable. Owner has dependent child with medical therapy appointments requiring reliable transportation. Current mileage approximate as vehicle cannot be driven. Request immediate NHTSA investigation and enforcement under federal safety law 49 USC 30120.

The contact owns a 2014 Ford Explorer. The contact received the notification letter for NHTSA Campaign Number: 24V031000 (Structure). The contact stated that the driver’s side exterior trim was loose. The vehicle was taken to the local dealer, and the contact was informed that the part was on back order. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but the line was busy. The failure mileage was approximately 70,000.

I am the owner of a 2014 Ford Explorer. There is an open recall on the vehicle; Recall number: 24S02. The plastic retention clips holding the exterior A-pillar moldings may not be properly engaged, which can allow the pieces to loosen and fly off at highway speeds. During the period following receipt of the recall notices I have made attempts to have the recall resolved. I made the attempts during routine safety and emissions testing, scheduled and unscheduled maintenance service visits. I have been advised by the dealer that the parts are unavailable and Ford has provided no timeline for parts availability. I contacted Ford Corporation directly and have been unable to obtain a date when parts would be available and was redirected to the dealer. My understanding is that the dealer is unable to perform the requisite service because it is unable or unwilling to provide the necessary parts.

While sitting at a stop light, waiting to turn, the steering wheel went stiff, then I was forced to make the turn without the power steering. it started working again but made a very loud grindy noise. the noise has not gone away. I took it to a shop, and they assesed everything, and stated the power steering rack has a fault code, and that the inner tie rods are loose, along with they can hear the power steering rack motor making a lot of noise. while going down the road the steering wheel shakes, and when making turns the steering wheel sticks and I have to yank the wheel back to unstick it. the vehicle is available to be inspected, at any time. I was almost in an accident multiple times due to the steering sticking and the wild vibration in the wheel. please help

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The defective recall items outlined in NHTSA Recall 24V031 (safety recall notice 24S02) continue to remain unrepaired and unresolved. The original notice was dated January 2024 and advised that parts and repairs should be available by late 2024. As of May 26, 2026 parts are not available and the windshield trim attachments and related rubber seals are not in place. The safety recall notice details the risks associated with this unrepaired and unresolved recall item.

My pillar are coming off to the point when it rains water get inside my car. It’s messed up my system in my car. I can’t close my sun roof and water comes down from my lights that’s above my head where you put your sunny sunglasses in. I been calling around and still haven’t got no where.

When driving, the steering wheel became less responsive. The next day, we drove a few hundred miles and got gas. After turning the car back on, the steering became even less responsive, resulting in a lot of force being needed to be used in order to turn the vehicle. In addition to this, the car was extremely difficult to keep straight, making driving on a single-lane road extremely dangerous. We have dropped the car off at the dealership and are waiting until Monday or Tuesday for a diagnosis and repair.

Backup camera failed, screen turns black or freezes when the car is put in Reverse. While driving or in reverse the screen becomes pixelated with red, green stripes. The camera is unuseable which creates a safety hazard. A recall is currently active for Ford 2015 explorers but not 2014 ford explorers. It is the exact problem the 2015 explorers are experiencing. The recall needs to be expanded to include the 2014 models.

The dashboard will randomly not work upon start up or stop working while driving... this only occurs for no longer than 1 min and will self correct. I have had multiple mechanics look for the cause of the issue and have replaced everything short of the instrument cluster and the wiring harness of the truck. While this doesn't seem to interfere with the function of my vehicle, this is/can be very dangerous. Please advise

The contact owns a 2014 Ford Explorer. The contact received a recall notification, NHTSA Campaign Number: 24V031000 (Structure) however the parts were unavailable. In addition, the contact stated that the recall repair was initiated in 2024, and the parts were still unavailable. The manufacturer was contacted, and a complaint was filed. The contact's vehicle had not experienced any failure regarding the open recall repair.

The contact owns a 2014 FORD Explorer. The contact stated while operating the vehicle the contact noticed the pillar was flapping on both driver side and passenger side, both sides are now fully gone including the top strip. The contact received notification of NHTSA Campaign Number: (24V031000 (STRUCTURE) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 129,000.

This recall has been open since 2024 with no available repair. My vehicle already experienced the failure while driving twice. I need this escalated to a regional service manager for resolution, or an alternative remedy if parts are still unavailable.”

issue with driving between speeds of 25 to 45 mph. Believe that there is a problem with the torque converter as it feels as though it's shuttering during those speeds. speeds of 50 or higher miles per hour feel fine while driving.

I had the toe link recall performed in 2022. Since that time, I have replaced brakes twice, tires twice (two full sets in less than 50k miles), control arms, sway bars, and bushings. The car will not come into alignment. There is ample evidence all over the internet that the toe link recall has been a failure. There are numerous stories just like mine of secondary suspension issues and burning through tires, especially in the rear, at an alarming rate. To my knowledge Ford has done nothing to correct the issues with the toe link, once and for all. To my knowledge, Ford is not reimbursing owners for the related losses they experience because of the issue with toe links.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the driver’s and passenger’s side A-pillar trim clips detached from the vehicle. The vehicle was not repaired. The failure mileage was unavailable.

Back up camera goes blank with black screen

There is a strong fuel order coming from passenger side after every fuel fill, affects everyone in the car while moving, especially affecting my grandchildren and my family. Backup camera rarely comes on while backing up, gives a black screen which can cause accidents especially in reverse. Rear driver side makes loud squeaky sound while driving over speed bumps slowly or bumpy roads. I purchased this vehicle used June 2025. It has an active molding recall that hasn't been fixed and I have contacted a Ford dealership last year.

Airbag light is activated and controls do not work.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

The back up camera turns black when the car is in reverse. Other times the screen has red, yellow, green horizontal stripes displayed which make the screen hard to see any objects behind me. This is the same problem ford has experienced with other explorer models and there is an activr recall for those models. My car is a 2014 model and is experiencing the same problems.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the A-pillar trim had detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 115,000.

The A pillar molding flew off the passenger side of my car while traveling down the interstate.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Both the driver side and passenger side exterior a-pillar applique molding came while driving down the highway and almost caused an accident. This has happened twice because FORD says they can't fix it because they don't have the parts. Anyone can get the parts online that are after market but that does not fix the issue. I did buy the after market ones and those came off on the interstate and almost hit a motorcycle driver. This has been going on Since January of 2024 and FORD is not doing anything about it. You are unable to call FORD, email FORD, and no one will escalate this. Now it has become even more of a safety issues because my rubber seals for my windshield are wearing and tearing off at a fast pace. It is causing more damage that FORD will not be responsible for fixing. Why do safety recalls not get fixed and are not forced to be fixed? Safety recall and no one cares to get it fixed.

When I'm driving on the freeway. I could be on flatland and it will stall, I could be going down a hill and it stalls, I could be on a regular road, turning a corner, hitting a bump. And it stalls when I'm on the freeway, I have to get over very scary happens all the time when It happens I coast, I put it into park, i turn it off, and it restarts immediately every time. This is constantly happening. IHave a video and picture but it will not upload on this.But it says hell descending control fail

EXTERIOR A-PILLAR APPLIQUE TRIM CLIP ATTACHMENTS ARE NOT PROPERLY ENGAGED DUE TO IMPROPER ASSEMBLY OR REPAIR. REAER TOE LINK REAR TIRES TILTED INWARD due to potential fractures from corrosion or broken welds on TOE LINK.

I have noticed Ford has recalled the back up camera for many makes and models however, my back up camera will not work when the car is hot. The make and Model is 2014 Ford Explorer Sport. Would this be considered?

The contact owns a 2014 Ford Explorer. The contact stated that while driving at an undisclosed speed, the windshield trim was fractured. The contact stated that the trim was flapping. The dealer was made aware of the failure, and the contact was informed that parts were not yet available. The contact used sealant to prevent the fractured windshield trim from detaching and separating from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not available. The manufacturer was made aware of the failure. The failure mileage was130,000.

ABS MODULE failure. Dealer states this I s a known problem. 581 on backorder with Ford with no ETA of new stock. No sense of urgency to resolve known problem. Online sources state heavy wire harness breaks solar joint at positive and negative contacts in module.