Ford Explorer 2003 — Problemas reportados

The contact rented a 2003 Ford Explorer. The contact stated that while driving at an undisclosed speed with the seat warmer activated, after arriving at a Rest Stop and exiting the vehicle, the contact became aware that a blister had formed on the back of her left thigh. The contact attributed the blister to a burn sustained while using the driver's side seat warmer. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic, but instead was returned to the rental company. The manufacturer was not notified of the failure. The failure mileage was 43,253. The VIN was not available.

There is a crack down the middle section of the liftgate for quite some time. The liftgate has been unlocking and opening automatically by itself. On only rare occasions has the liftgate opened all the way while driving. On the morning of 7/28/2022 while the vehicle was parked in my driveway the liftgate was discovered to have again unlocked by itself and opened slightly and now with one of the two hinges holding the glass sheared leaving the liftgate glass hanging by only one hinge. With the glass now hanging without having both hinge supports functioning and the inability to close and lock the liftgate, 1) the glass could fall out while driving and 2) with the liftgate unable to now close and lock, contents of the back storage area could fall out of the vehicle while driving. On 8/1/2022 the vehicle was inspected by the foreman of the Service Dept. at Healy Ford, Goshen, N.Y. I was told to take it to a body shop for realignment repair. Apparently a recall on 9/13/2022 # 04V442000 did not include my Vin. However, In driving around I do see many 2003 explorers with the identical crack on the liftgate.

Head lights are cloudy given poor visibility. Back hatch door has a crack.

The contact owns a 2003 Ford Explorer. The contact stated that while driving at approximately 25-35 MPH around a curb, the driver thought that the tire was flat. The contact pulled off the road and noticed that three of the wheel studs on the driver’s side rear wheel had sheared off. The vehicle was towed to an independent mechanic and it was confirmed that the studs had sheared off and that there was also a fractured wheel stud on the passenger’s side rear wheel. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 115,000.

Hello my name is [XXX] just writing you cause my neighbors have program my vehicle meaning they hack my 2003 explore pretty much they want to take over my driving they trying to dominate me in this matter when in reality is not going to be possible that's why I come to your people's corporate plus they have invade my family privacy they have a gang organization watching me every where I go had few confrontation they just want me to confront them so they could put me in jail this is not going to happen i apologize for the inconvenience I told police regards this matter they didn't do nothing about it . INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

drivers side rear brake line developed a hole caused by the emergency brake cable rubbing against it causing all the brake fluid to leak & the brakes failed. Fortunately my husband was driving on our rural road & not out on the main highway. We have not been able to get it repaired yet.

The driver was driving down the expressway and her back tire blew out causing her vehicle to spiral out of control and the vehicle then flipped and started rolling downhill, the vehicle airbags did not deploy in the vehicle at all. The driver and her mother are in critical condition. Yes, the safety of others safety was put at risk. I did contact Ford Manufacturer on her behind of the airbags and they said there is nothing they can do for her with the vehicle being totaled out. But my main problem is why these airbags did not deploy. The vehicle is going to be inspected by her insurance company here in the next few days. There were no prior lamps, messages, or anything that would have indicated that the airbags were defective.

WAS CLOSING BACK HATCH AND GLASS WINDOW LITERALLY EXPLODED! VEHICLE WAS PARKED IN MY YARD.

THE TRANSMISSION IS SHOT I CANT PUT IT IN GEAR AND ME AND MY HUSBAND WERE ALMOST KILLED BUT WERE ABLE TO PUT IT IN 2ND GEAR TO ROLL IT TO THE SHOP. THE 4WHEEL DRIVE GOT STUCK IN 4 WHEEL LOW AND WOULD NOT SHIFT AT ALL. WHEN WE TURNED THE CAR ON IT WOULD REV UP TO 5 BUT ONLY GO 2 MILES AN HOUR.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE WHEEL DETACHED DUE TO THE CONTROL ARM BEING CORRODED. THE CONTACT CALLED ELDER FORD (777 JOHN R RD, TROY, MI 48083, (248) 825-8646) AND WAS ADVISED TO SCHEDULE AN APPOINTMENT. THE VEHICLE WAS LATER TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE METAL OF THE UPPER CONTROL ARM WAS NOT A GOOD METAL; THEREFORE, THE CONTROL ARM WAS CORRODED THROUGH AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.

TAKATA RECALL .. THE SMELL OF FUEL INSIDE THE CAB AND OUTSIDE IS REALLY BAD. IT'S MAKING ME SICK AND GIVING ME HEADACHES. THE TRUCK DOESN'T RUN RIGHT AND THE MILEAGE IS AWFUL.

SHIFTER BROKEN INSIDE STEERING COLUMN. STOPPED AT A GAS STATION WHEN PUTTING INTO PARK IT BROKE. HAD TO KEEP MY FOOT ON BRAKE PADDLE FOR 2 HOURS UNTIL TWO TRUCK ARRIVED

"TAKATA RECALL" AIRBAG LIGHT KEEPS BLINKING WITH THE SEAT BELT NOISE. CHANGED THE LIGHT BULB FROM THE DASH BOARD AND NOW THE AIRBAG LIGHT STAYS ON BUT WILL NOT CONNECT WITH MILEAGE.

2003 FORD EXPLORER. CONSUMER WRITES IN REGARD TO DEFECTIVE THROTTLE IN MODEL VEHICLE. *AS *TR

VEHICLE WAS IN MOTION, MOVING THROUGH AN INTERSECTION ON A CITY STREET AND INVOLVED IN AN ACCIDENT. NO AIR BAGS DEPLOYED AT ALL.

ENGINE STOPS WHILE DRIVING (STALLS IN MOTION WHILE TURNING ON STREET AND HIGHWAY) RESTARTS WITHOUT PROBLEM, HAS HAPPENED TWICE NOW 30 DAYS APART.

BODY MOUNTS DETERIORATED CRUMPLED.BODY DOWN ON FRAME CAUSING IRREGULAR RIDE CONTROL

2003 FORD EXPLORER. CONSUMER WRITES IN REGARD TO MALFUNCTION TO COMPANY'S REAR WHEEL BEARING. *AS *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WITHIN A MONTH OF OWNING THE VEHICLE, AN INDEPENDENT MECHANIC STATED THAT THE BRAKE SYSTEM NEEDED SERVICING, INCLUDING THE ROTORS AND BRAKE PADS. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE MANUFACTURER WAS NOTIFIED AND HAD NOT ISSUED ANY BRAKE SYSTEM RECALLS; HOWEVER, THERE WERE TEN TSBS FOR THE BRAKE SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

REAR WINDOW LOWER PANEL PLASTIC CRACKING UP, REPLACED THREE TIMES, STILL CRACKING DUE TO NO SUPPORT AND BENDING TOO MUCH, I CALLED FORD DOES NOT CARE IF CONTINUES CRACKING UP, IT LOOKS UGLY ALSO PANELS CAN CAUSE AN ACCIDENT TO OTHER CARS GETTING INTO THEIR WINDSHIELDS LOOSE PARTS. THEY KNOW ABOUT THE PROBLEM AND NOT FIXING IT.

THE PROBLEM THE SEAT BELTS DOES NOT HAVE ENOUGH TENSION TO RETRACT CONSEQUENTLY GETTING ON THE DOOR LOCK MECHANISM, CAUSING THE DOOR NOT TO LOCK, TO STAY OPEN UNSECURED ALSO DAMAGING THE SEAT BELT, IT DOES NO HAVE A WAY TO INCREASE THE TENSION WHICH IT SHOULD HAVE. IT DAMAGED MY DOOR SEAL, MY LOCK MECHANISM AND THE BELT TOO.

THIS SUV'S ARE GETTING HOT DURING THE TEXAS WEATHER, WHY ARE NOT INCLUDING A SOLAR FAN INSTALLED TO KEEP THE AIR CIRCULATING IN THE SUV, TECHNOLOGY IS CHANGING WHY ARE NOT ADDING THE SYSTEM ???

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHEN ATTEMPTING TO CLOSE THE REAR WINDOW, THE CONTACT NOTICED THAT THE REAR LIFTGATE WINDOW HINGES WERE CRACKING AND WERE TILTED ON ONE SIDE. THE CONTACT, A CERTIFIED MASTER TECHNICIAN, STATED THAT THE WINDOW NEEDED TO BE REPLACED. THE CONTACT CALLED FORT MILL FORD AT (866) 680-5276 (LOCATED AT 801 GOLD HILL RD, FORT MILL, SC 29708) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

EXHAST MANAFOLD HAS CRACK IN IT AND SCREWS CAME LOSE AND FELL OUT WIHICH CREATED FUMES IN CAR.

ALL SIDE AIRBAGS DEPLOYED WITHOUT ACCIDENT. DEPLOYMENT HAPPEND WHILE MY WIFE AND 4 YEAR OLD SON WAS IN THE VEHICLE DRIVING APPROXIMATELY 30-40 MILES PER HOUR DOWN A STRAIGHT ROAD IN LONG VALLEY NEW JERSEY. THIS ROAD IS SMOOTH, LEVEL AND FREE OF POT HOLES ETC. UNABLE TO SEE BECAUSE OF THE DOWNED AIRBAGS AND SMOKEY DUST LIKE MATERIAL FROM THE AIRBAGS SHE PULLED OFF THE ROAD AS BEST SHE COULD.

WHENEVER WE ARE DRIVING IN THE CAR, MY WIFE AND I GET DIZZINESS AND NAUSEA. MY WIFE AND DAUGHTER SAY THERE IS AN EGGY SMELL SOMETIMES. MOSTLY, NO ODOR BUT AN OVERWHELMING SENSE OF DIZZINESS ONLY WHEN WE ARE IN THAT CAR TO THE POINT WE AVOID DRIVING AS MUCH. THIS HAS BEEN ONGOING FOR YEARS. I THOUGHT IT WAS A SEAL ISSUE CREATING A WEIRD PRESSURE INSIDE THE CAR UNTIL IN MY RESEARCH FOR A SOLUTION I CAME ACROSS NEWS STORIES ON CARBON MONOXIDE IN OTHER FORD EXPLORERS.

WE HAD PURCHASED THIS VEHICLE BOUT A YEAR AGO AND WHEN WE GOT IT WE WENT TO GET TIRES AND FRONT END ALIGNMENT AND THEY ENDED UP REPLACING UPPER ND LOWER BALL JOINTS, CONTROL ARM AND SWAY BAR ON PASSENGER SIDE.THIS WAS 6/20/2017. IT WASN'T MAKING ANY NOISE UNTIL 1/3/2018. I WAS GOING DOWN CITY STREET AND SOMETHING POPPED AND THEN IT STARTED ROARING. IF YOU PUT IN 4WD IT ROARS LOADER AND JERKS. 1/23/18 REPLACED DRIVERS SIDE WHEEL HUB AND BEARINGS. IT STILL ROARS WHILE ACCELERATING SPEED BUT NOT AS BAD IN 2WD BUT PUT IN 4WD ITS REAL LOUD AND JERKS YOU . I HAVE DONE RESEARCH ONLINE FOR THIS YEAR MODEL SPORT TRAC AND IT SEEMS LIKE THERE ARE SEVERAL COMPLAINTS ABOUT THIS SAME ISSUE. EVERYTIME GET ONE THING FIXED ON FRONT END SOMETHING ELSE HAPPENS TO IT. YOU CAN DRIVE IT BUT IF YOU GET OVER 10-15 MPH THE ROARING GETS WORSE AND IT LOCKED THE THE WHOLE WHEEL UP AND JERKED THE TRUCK TO THE SIDE OF THE ROAD

CAR HAS AN INTERMITTENT PROBLEM AND WILL STALL AND BOTH HIGH AND LOW SPEEDS, OR WHEN IDLING. WHEN THIS HAPPENS AND POWER ASSIST FAILS, IT'S ALMOST IMPOSSIBLE TO STEER OR TO BRAKE POSING A SERIOUS RISK TO SAFETY. THIS FIRST STARTING HAPPENING ABOUT ONCE A WEEK LAST NOVEMBER, AND NOW IT'S PRETTY OFTEN. STOPPED DRIVING THE CAR, EXCEPT TO TEST DRIVE AS WE'RE TRYING TO FIND THE SOURCE OF THE PROBLEM. WE THINK IT'S EITHER THE FUEL OR VACUUM SYSTEM AND ARE CONTINUING TO NARROW DOWN THE PROBLEM. I AM NOT SURE IF BRAKING WILL WORK AT ALL WHEN IT FAILS, AS FORTUNATELY IT HASN'T STALLED GOING DOWNHILL. I PUT ALL MY STRENGTH INTO BOTH BRAKING AND STEERING (I'M A PRETTY STRONG WOMAN) TO GET IT TO SAFETY. IT MAY SIMPLY BE STOPPING DUE TO INERTIA.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 65 MPH, THE TEMPERATURE GAUGE INCREASED TO HIGH AND THE VEHICLE CAUGHT FIRE UNDER THE HOOD WITHOUT WARNING. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES DUE TO THE FIRE. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

VEHICLE WAS PARKED WHEN REAR WINDOW EXPLODED AFTER DOOR CLOSED. SHARDS OF GLASS FLEW OUTWARD

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

BROKEN GEAR SHIFTER

SHIFT LEVER BROKE OFF INSIDE STEERING COLUMN OF MY WIFE'S EXPLORER WHEN CHANGING FROM PARK TO DRIVE TO EXIT FROM A BOAT LAUNCH RAMP WITH NO BOAT ON THE TRAILER. VEHICLE WAS TOWED ON A FLATBED WRECKER TO MY GARAGE. BROKEN ELEMENT ( SEE PHOTOS) WAS NOT REPLACEABLE BY ITSELF. STEERING COLUMN HAD TO BE REPLACED. THIS WAS NOT NORMAL WEAR AND TEAR, BUT RATHER A FAULTY /WEAK COMPONENT THAT REPRESENTS A DANGER. I HAVE NOTED REPORTS OF IDENTICAL INCIDENTS ONLINE. THUS FAR, NEITHER THE DEALER NOR FORD NATIONAL "CUSTOMER SERVICE" IS PREPARED TO REIMBURSE.

I CONTACTED FORD REGARDING RECALL WITH THE LIFT GATE. THERE WAS RECALL IN 2004 FOR MY VEHICLE THAT WAS TAKEN CARE OF IN 2005. IN 2016 THE SAME THING HAPPEN WHERE THE LIFT GATE BOLTS BROKE AND THE GATE FELL AND THE GLASS SHATTERED ALL OVER ME. I WENT THROUGH MY INSURANCE COMPANY AND GOT IT REPAIRED. AT THE TIME I DIDN'T KNOW IT WAS RECALL I BOUGHT THE CAR USED SO I HAD NO IDEA OF THE CALL. FORD TOLD TO CONTACT A DEALER THE DEALER SHOP MANAGER TOLD ME FORD WILL NOT REFUND MY DEDUCTIBLE SINCE THEY REPAIRED IT UNDER THE RECALL. ALL I WANT IS MY 250 BACK BECAUSE THE SAME THING HAPPEN THAT THEY SO CALLED REPAIRED. IS THERE ANY WAY YOU CAN ASSIT ME. I DO HAVE MY BILL FROM THE REPAIR SHOP THAT MY INSURANCE STATE FARM TOOK CARE OF. THE VEHICLE WAS PARKED I WAS CLOSING THE LIFT GATE WHEN IT FELL DOWN AND GLASS SHATTERED.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING AND CRASHED INTO A DITCH. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT AND FOUR BYSTANDERS PUSHED THE VEHICLE INTO A RESIDENTIAL DRIVEWAY. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,412.

GREETINGS THE PROBLEM THE CABIN NOT WELL SEALED FROM ANY FUMES PLUS THE A/C DOOR INSIDE TO KEEP THE AIR RECYCLE FALLING OFF NOT WELL SECURE CONSEQUENTLY GETTING FUMES FROM THE OUTSIDE AND ALSO I CAN SMELL THE CABIN IN THE MORNING WHEN I GET INSIDE FROM EITHER OIL LEAKS AND EXHAUST BURNS, IT NEEDS ATTENTION PROMPTLY SINCE FORD DOES CARE OR GET CONCERN ON ANY PROBLEM. IT HAS BEING HAPPENING MORE SINCE 2006 AND ALSO THE TRUCK INSULATION IT IS BAD SINCE MOST COLD WEATHER PENETRATES THE CABIN WHEN YOU DRIVING YOU CAN FEEL THE AIR COMING IN. IT NEEDS TESTING AND RECALL, IT HAS BEING INCREASING THE AMOUNT OF FUMES COMING IN FROM THE OUTSIDE OTHER TRUCKS. YOU MAY HAVE TO DO THE FUME SMOKE TEST HOW MUCH IT GOES INSIDE THE CABIN.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 55 MPH, THE LUG NUTS BECAME DETACHED FROM THE REAR PASSENGER WHEEL, WHICH CAUSED THE VEHICLE TO SHAKE VIOLENTLY. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND WAITED FOR A TOW TRUCK. THE CONTACT STATED THAT THE FAILURE OCCURRED ON MORE THAN ONE OCCASION AND INCLUDED ALL OF THE WHEELS. THE CONTACT PREVIOUSLY REPLACED THE LUG NUTS ON ALL OF THE WHEELS. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 140,000.

AWOKE THE MORNING OF MAY 10, 2017 TO FIND THE ENTIRE BACK LIFTGATE AND WINDOW EXPLODED OUTWARDS AND INWARDS OF OUR FORD EXPLORER. THE VEHICLE WAS PARKED IN FRONT OF OUR HOME, WE ARE RURAL, SO NO EVIDENCE OF SOMEONE PURPOSELY BREAKING IT. OUR SHERIFF IN CASCADE COUNTY, MONTANA, STATED IT APPEARS TO BE SOMETHING INTERNAL PROBABLY THE LIFT STRUTS EXPLODING. THIS SEEMS TO BE A PROBLEM AS STATED ON MANY ONLINE SITES, AND MANY FORD EXPLORERS HAVE THIS PROBLEM. THIS PARTICLAR MODEL VIN NUMBER DID NOT SHOW UP AS RECALLED, ALTHOUGH WE SIT HERE LOOKING AT THE DAMAGE CAUSED BY THIS PROBLEM. WE WOULD APPRECIATE SOMEONE LOOKING INTO THIS, AS IT COULD HAPPEN TO ANYONE AND PROVE TO BE VERY DANGEROUS IF THIS VEHICLE WERE BEING DRIVEN WHEN THIS EXPLOSION OCCURED. PLEASE CHECK INTO THIS ASAP.

TRANSMISSION SHIFTS HARD AND CLUNKS, IS NOT SAFE TO DRIVE. THE ESTIMATE REPAIR IS AROUND $ 3,400. WILL NEVER BUY A FORD AGAIN.

THE BACK LIFT GATE HAS A CRACK. I HAVE NOTICED THIS ON PRACTICALLY EVERY OTHER EXPLOER OF THIS YEAR. I CONTACTED FORD SEVERAL YEARS AGO AND THEY SAID SINCE IT WAS A DEFECT THAT WAS NOT A DANGER THEY WOULD NOT RECALL OR REPAIR IT.