Ford Expedition 2000 — Reported problems

On XXX my 2000 Ford Expedition caught on fire at around 2am. It had not been driven or turned on since XXX, and was sitting parked that whole time. It was parked in the parking lot of my apartment building, right outside of my unit. I was woken up by a loud pop which I believe was the tire exploding, and the flames were tall enough to see outside my second story bedroom window. My entire apartment building was evacuated by the fire department, and some doors were kicked in by them, including mine. After they put the fire out, the fire inspector looked for two hours to determine a cause and were only able to determine that the fire started under the hood, on the drivers side, close to the dashboard area. The vehicle was completely totaled in the fire, and my other car parked next to it was damaged from the fire as well, and the apartment building had a lot of damage from the fire and heat spreading to it. Multiple residents were displaced for a few days at the advice of the fire department, to let units air out from the carcinogenic fumes. The vehicle has been towed and signed over to AutoMoto Salvage yard. I was researching what could have started this fire and found this article where the NHTSA investigated over 600 spontaneous Ford vehicle fires including year 2000 Ford Expeditions, caused by cruise control deactivation switches, which are located in the same place under the hood that the fire department determined my fire originated. [XXX] My vehicle was not listed in any recall, but that article states that over 200 vehicles that caught fire were not either. I'm unsure if the salvage yard still has it available for inspection. It has not been reproduced or confirmed by a dealer. It was inspected by the fire department and police department - insurance did not do their own inspection. There were no warning signs and the vehicle was running like normal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

while driving smoke came from under my hood by the time i opened it was a full blown fire on the passenger side near the fuel injectors and spark plugs. we called 911 police and fire department came a nearby business owner loaned a fire extinguisher and we got the fire out. the fire men say it was caused by a spark plug that had came out caught spark with oil or gas it damaged hoses electrical and not sure what else yet.

The contact owns a 2000 Ford Expedition. The contact stated while driving 30 MPH, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to prevent oversteering. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering shaft. The vehicle was repaired, but the failure reoccurred because the aftermarket replacement part was too short. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 315,000.

The contact owns a 2000 Ford Expedition. The contact stated that the vehicle would not start-up. The contact attempted to jump start the vehicle with assistance, but he was not successful. The check engine warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 300,000.

MY 2000 FORD EXPEDITION WAS PARKED AT MY JOB PARKING LOT FOR 3HRS, WHEN IT CAUGHT FIRE UNDERNEATH THE HOOD NEAR THE MASTER CYLINDER, DRIVERS SIDE, NEAR THE FIREWALL. I CONTACTED FORD MOTOR COMPANY, BBB, AND CONSUMER AFFAIRS, WHICH ALL ATTEMPTS WERE IGNORED.

MY CAR SHUTS OFF RANDOMLY AS I'M DRIVING. I'VE HAD MECHANICS LOOK AT IT AND SEE NOTHING WRONG. THERE ARE NO CODES COMING UP EITHER.

ODOMETER BLANKS OUT NO DIGITAL READ OUT FOR MILEAGE, SEATS ARE TORN BADLY DON'T USE OR DRIVE THAT OFTEN 1 OR TWICE A WEEK IT HAS ONLY 145K MILES. NOW, THE AIR LINE HAS BEEN REPLACED AND IT LOW IN REAR WITH COMPRESSOR CAN'T FIND LEAK AND BELIEVE THE AIR BAGS WILL NEED REPLACED TRYING TO FIND OUT WHERE ISSUE IS AND NO WARNING LIGHT THIS TIME ON DASH LIKE USUAL. *TR

MY TRUCK HAS BEEN RUNNING FINE WITH NEW PARTS ON IT. I WENT TO MY FRIEND'S HOUSE WENT IN TO SWITCH MY LAUNDRY, LOOKED OUT HER WINDOW AND MY WAS ON FIRE!! TRUCK OFF AND KEYS WERE NOT IN IGNITION AND IT WAS PARKED IN A DRIVEWAY UNDER A CARPORT. IT POSED NO PROBLEMS ON THE WAY OVER THERE, NO SMELLS, NO SOUNDS, NO NOTHING. AND THEN BAM! HOOD SHOOTING OUT FLAMES.

MY EXPEDITION CAUGHT ON FIRE PARKED IN MY DRIVEWAY AT LEAST 30 MINUTES AFTER DRIVING IT. I WAS ABLE TO PUT THE FIRE OUT WITH A FIRE EXTINGUISHER AND A WATER HOSE, BUT THE PLASTIC PARTS WERE WERE MELTED ON THE DRIVER SIDE. THE BATTERY WAS DISCONNECTED AND I WAS TOLD BY A MECHANIC THAT IT WAS THE CRUISE CONTROL RELAY.

I WAS DRIVING THE DOWN THE STREET GOING TO WAL-MART ON PENDLETON PIKE IN INDIANAPOLIS INDIANA THE CAR SHIFTED FROM DRIVE TO NEUTRAL ON ITS OWN. I SHIFTED IT BACK IN GEAR DROVE ON TO WAL-MART THEN TO WENT TO ALDIS. WHEN I CAME OUT OF ALDIS ALSO ON PENDLETON PIKE THE CAR WOULDN'T COME OUT OF PARK WITHOUT KEY BEING IN ACC POSITION FOOT ON BRAKE AND PLAYING WITH GEARSHIT FOR APPROX 15 MINS IT WAS LOCKED. THEN THE POWER WINDOWS ALSO WENT OUT IN THE SAME TIME THAT THIS ALL HAPPENED. NOW MY CAR WILL NOT GO INTO GEAR WITHOUT MESSING WITH GEARSHIFT FOR SEVERAL MINUTES AND MESSING WITH IGNITION SWITCH MUTIPLE TIMES BEFORE I CAN GET CAR INTO MOTION.

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE CRUISE CONTROL SWITCH UNDERNEATH THE HOOD THAT WAS CONNECTED TO THE BRAKE MASTER CYLINDER CAUGHT ON FIRE. THE CONTACT STATED THAT THE IGNITION WAS OFF AT THE TIME. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS NOT FILED. THE CONTACT, A CERTIFIED MECHANIC, STATED THAT THERE WAS BRAKE FLUID COMING OUT OF THE CRUISE CONTROL SWITCH. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 201,000.

I WAS DRIVING ON A HIGHWAY IN MY EXPEDITION AND I WENT TO DISINGAGE MY CRUISE CONTROL AND MY ENGINE JUST SHUT OFF IT'S BEEN 4 WEEKS NOW AND I CAN'T GET ANYONE TO TELL ME WHAT'S WRONG. MY VEHICLE IS A NO CRANK NO START NOW

TRIED TO START WITH KEY OUT OF THE IGNITION. LIGHTS WOULD NOT TURN OF. HAD TO DISCONNECT THE BATTERY. THIS WOULD BE LIFE THREATENING IF HAPPENED IN A CLOSED GARAGE

BATTERY WILL NOT KEPT A CHARGER HAVE TO TAKE OFF CABLE WHEN CUTTING THE TRUCK OFF. LIGHTS NOT WORKING IN BACK ,NO PICK UP SPEED

THROTTLE FEELS LIKE ITS STICKING. THE BREAKS FEEL LIKE THEY GET HARDER THE LONGER YOU DRIVE OR USE THEM. ITS BEEN EXTREMELY COLD THE LAST FEW WEEKS (AIR TEMP OF -28F LOWS TO -3F FOR HIGHS). YOU LET OFF THE BREAK FROM A STOP SIGN OR STOP LIGHT AND IT WILL SUDDENLY ACCERLERATE BY ITSELF. SEEMS TO HAPPEN ANYTIME AFTER 40MPH, EVEN IF YOU SLOW BACK DOWN TO 10-15MPH IT WILL ACCELERATE BACK UP ON ITS OWN, UP TO AS FAST AS 65MPH!) I NEED TO DOWNSHIFT AND RIDE BRAKES (WHICH ARE HARD AS A ROCK!!!) TO KEEP IT FROM EXCELLING THOUGH TOWN AND TO TRY TO KEEP THE RPMS AT BAY. WHEN COMING TO A STOP AND TURNING ITS HARD TO STEER AND IT MAKES JUMPY/JERKY MOVEMENTS FORWARD WHEN BRAKES ARE APPLIED. WHEN VEHICLE COMES TO A STOP THE RPMS SKYROCKET UNTIL YOU SHUT DOWN THE ENGINE. IF YOU HAVN'T GIVEN IT ENOUGH TIME BEFORE YOU START IT AGAIN, THE ENGINE AND RPMS SOAR UP AGAIN. THINGS WE'VE TRIED WITH NO LUCK ARE, DISENGAGING THE CRUISE CONTROL, REPLACING THE SPRING UNDER HOOD WHERE THE THROTTLE CABLE IS. THOUGHT MAYBE IT WAS STRETCHED AND NOT DEPRESSING FULLY TO ALOW DECELERATION. AFTER THAT WE REPLACED THE THROTTLE BODY ITSELF. AGAIN, NO LUCK ON TEST DRIVE. YOU CAN HEAR A CLICK/PING IN THE PEDAL AND SEE IT COME UP ONCE TRUCK IS IN PARK, GIVE IT TIME. PEDAL SEEMS TO BE PARTIALLY DEPRESSED AND THERE IS PLAY. HAVE TRIED TO STICK FOOT UNDER THE PEDAL TO TRY AND GET IT TO DISENGE. WORKED THE FIRST FEW TIMES THAT'S ALSO WHY THOUGHT IT WAS THE SPRING. NO LONGER WORKS TO DO THAT. CAN SEEM TO HEAR A DIFFERENCE EITHER IN MOTOR OR TRANY, ACTING AS IF IT'S WORKING HARDER WHEN IT SEEMS TO TAKE CONTROL OF ITSELF. STARTED HAPPENING 12-24-17. BEEN TO THE SHOP MANY TIMES WITH NO ANSWERS AS TO WHY THIS IS HAPPENING. IT'S VERY SCARY AND DANGEROUS! AFTER READING ABOUT ALL THE OTHERS THIS IS HAPPENED TO ITS HARD TO IMAGINE THAT THERE HASN'T BEEN A RECALL OR AT THE VERY LEAST AN ANSWER YET!

I HAVE OWNED A 2000 FORD EXPEDITION FOR APPROX. 3 YRS. AND ON NOV. 22, 2017 WHILE MY VEHICLE WAS SITTING IN THE PARKING LOT AT MY WORK(APPROX. 3HRS) IT DECIDED TO LIGHT ITSELF ON FIRE! I LATER FOUND OUT THAT THERE HAD BEEN A RECALL ON THE SPEED CONTROL DEACTIVATION SWITCH. I HAVE NEVER BEEN NOTIFIED OF THIS RECALL AND AM EXTREMELY ANGRY AS I HAVE PUT OVER $10,000 WORTH OF UPGRADES TO THE VEHICLE. HAD I BEEN NOTIFIED OF THIS RECALL I WOULD HAVE TAKEN CARE OF IT IMMEDIATELY. THE RECALL NUMBER IS 05V017000 AND FORD RECALL NUMBER IS 05S28. I HAVE CONTACTED FORD ABOUT THIS AND HAVE NOT HAD ANY RESPONSE. BEFORE I CONTACT AN ATTORNEY I WOULD LIKE TO KNOW IF THERE IS ANYTHING THE NHTSA CAN DO TO HELP? THANK YOU FOR YOUR TIME.

TAKATA RECALL. IGNITION MECHANISM ON STEERING COLUMN IS LOCKED. CAN PUT KEY IN, BUT ABSOLUTELY CANNOT TURN IGNITION MECHANISM. STEERING WHEEL IS LOCKED AND TRANSMISSION LOCKED IN "PARK". THESE ARE SAFETY FEATURES AND WILL NOT UNLOCK UNTIL IGNITION IS TURNED. VEHICLE IS PARKED SO IT IS STATIONARY AND TURNED OFF.

THE INTAKE MANIFOLD NEEDS TO BE REPLACED MY MECHANIC TOLD ME AND IT LEAKS ANTI

MY VEHICLE WAS PARKED IN THE DRIVEWAY AND I WAS ALERTED BY MY DOGS BARKING. I OPENED MY GARAGE DOOR TO SEE THE ENTIRE ENGINE COMPARTMENT ON FIRE. THE FIRE WAS SO INTENSE THAT EVERYTHING UNDER THE HOOD HAD MELTED.THE FIRE MARSHALS SAID THE ALTERNATOR CAUSE IT

DRIVING DOWN THE ROAD AT ABOUT 30MPH AND SUDDENLY MY ENGINE SOUNDED LIKE IT THREW A ROD. MY HUSBAND LOOKED AT IT AND FOUND A SPARK PLUG BLEW OUT OF THE MOTOR. THIS SEEMS TO BE AN ONGOING ISSUE THAT FORD REFUSES TO ACKNOWLEDGE. SOMETHING NEEDS TO BE DONE.

STARTS THEN STALLS WAS TOLD SECURITY SYSTEM PROBLEM CAN'T GET IT TO RUN NO MORE THAN 20 SECONDS

THE VEHICLE WAS PARKED IN A STORE PARKING LOT, NOT RUNNING/IGNITION OFF, AND IT CAUGHT FIRE UNDER THE HOOD NEAR THE BRAKE MASTER CYLINDER. THE FIRE DAMAGED EVERYTHING IN THE UPPER PORTION OF THE ENGINE COMPARTMENT, THE HOOD, THE COWLING AND THE GRILL. PROBABLY NOT REPAIRABLE.

#7 SPARK PLUG BLEW OUT DESTROYING THE COIL ON PLUG WITH IT. ALL THE THREADS ARE STRIPPED OUT AND THERES NO WAY TO PUT A NEW PLUG IN IT. WAS LUCKY I DIDN'T HAVE AN ENGINE FIRE FROM FUEL VENTING OUT OF SPARK PLUG HOLE. THIS IS A TRITON 5.4L V8

THE TREAD IS SEPARATING FROM THE TIRE ON ALL FOUR TIRES. THERE IS ABOUT 30K ON THE TIRES WHICH HAVE A 70K MILE WARRANTY. THE SAME TIRE ALTHOUGH DIFFERENT SIZE ARE RECALLED FOR THE SAME ISSUE.

VEHICLE CAUGHT FIRE AROUND 10:25 PM. VEHICLE WAS PARK AND COLD SINCE THE LAST TIME IT WAS USED WAS AROUND 1:00 PM THE SAME DAY. MY WIFE GOT HOME AND WAS PARKING HER CAR A SUDENLY SAW THE FORD EXPEDITION CACHING FIRE AND FLAMES COMING OUT OF THE ENGINGE COMPARTMENT. VEHICLE IS TOTAL THERE ARE NO POSSIBILITY OF REPAIR.

WHILE DRIVING THIS EXPEDITION I BEGAN NOTICING STRANGE INTERMITTANT ELECTRICAL BEHAVIOR LIKE THE WINDSHIELD WIPERS NOT WORKING, RADIO TURNING OFF, WINDSHIELD WASH LIGHT BLINKING, AND 4X4 LIGHT BLINKING. SEVERAL TIMES IN THE MIDDLE OF THE NIGHT I'D NOTICE THAT THE HEADLIGHTS WOULD COME ON ON THEIR OWN. ALSO THE AIR RIDE WOULD TURN ON AND OFF WHILE THE CAR WAS OFF, AND THE HEATER FAN WOULD ALSO COME ON. THIS WOULD KILL THE BATTERY. SEVERAL TIMES WHILE DRIVING THE 4X4 WOULD TURN ON IN THE LOW GEAR MAKING IT DIFFICULT TO MANEUVER. ON SEVERAL OCCASIONS THE STARTER WOULD TURN ON WHILE THE CAR WAS ALREADY RUNNING. I REPLACED THE GEM MODULE AND HAD THE WINDSHIELD RESEALED SEVERAL TIMES, BUT AFTER JUST A FEW MONTHS THE PROBLEMS WOULD RECUR. THE FINAL NAIL IN THE COFFIN WAS WHEN THE STARTER KICKED ON WHILE RUNNING AND IT TOOK A MINUTE TO GET THE CAR SAFELY STOPPED. I COULD SMELL SMOKE FROM THE BURNED UP STARTER MOTOR. THE EXPEDITION HAS SAT FOR 1.5 YEARS AS I AM UNABLE TO SELL IT AND AM UNWILLING TO PUT ANY ADDITIONAL MONEY TO FIX THIS LEMON.

TL* THE CONTACT OWNED A 2000 FORD EXPEDITION. WHILE STATIONARY, THE VEHICLE ERUPTED INTO FLAMES. THE CONTACT WAS ALERTED OF THE FIRE BY NEIGHBORS. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FLAMES. THE VEHICLE WAS DESTROYED. AN INVESTIGATOR ASSESSED THAT THE FAILURE WAS DUE TO A DEFECTIVE CRUISE CONTROL DEACTIVATION SWITCH WHICH WAS RELATED TO AN UNKNOWN MANUFACTURER RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

WHEN IT RAINS REAL HEAVY IT LEAKS THROUGH THE SUNROOF THROUGH THE WALL ON THE SIDE OF THEODORE WITH IS CONNECTED TO THE WINDOW

ANTI-LOCK BRAKE SYSTEM ACTIVATED WHILE DRIVING ON INTERSTATE WITH CRUISE CONTROL SET AT 65 MPH, CAUSING UNCONTROLLED STOP IN MOVING TRAFFIC WITHOUT WARNING. NEVER HAD ANY PREVIOUS PROBLEMS WITH ABS SYSTEM. THE ABS WARNING LIGHT WAS NOT ON (AND IS STILL NOT ON). FORD'S CUSTOMER RELATIONS CENTER SUGGESTED I TAKE MY VEHICLE TO A FORD DEALERSHIP FOR TO DETERMINE THE CAUSE OF THIS PROBLEM. THEY ALSO SAID THERE ARE NO WARRANTIES, RECALLS OR PROGRAMS THAT WOULD PROVIDE COVERAGE FOR THIS CRITICAL SAFETY ISSUE WITH THE ABS SYSTEM. BEFORE I DO ANYTHING ELSE TO MY VEHICLE I WANTED TO NOTIFY NHTSA FIRST. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT WHILE ATTEMPTING TO REFUEL, THE FUEL NOZZLE WOULD CONSTANTLY CLICK OFF. AFTER REMOVING THE FUEL FILLER TUBE, THE CONTACT DISCOVERED THAT THE FUEL FILLER SCREEN WAS CLOGGED WITH PLASTIC DEBRIS FROM THE INNER LINING OF THE FILLER TUBE. THE CONTACT INDICATED THAT THE DEBRIS HAD ALSO CLOGGED UP THE FUEL FILTERS AND CAUSED THE ENGINE TO SPUTTER AND HESITATE WHILE DRIVING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, A LOUD POPPING NOISE WAS HEARD COMING FROM THE ENGINE ALONG WITH THE ODOR OF FUEL INSIDE THE VEHICLE. THE CONTACT DISCOVERED THAT THE COIL ON PLUG TO THE ENGINE WAS OUT OF POSITION AND A SPARK PLUG HAD POPPED OUT OF THE ENGINE HEAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

I BEGAN NOTICING ELECTRICAL PROBLEMS WITH THE LIGHTS GOING ON AND OFF, DASH GAUGES GOING ON AND OFF, RADIO GOING ON AND OFF, HEATER GOING ON AND OFF, DOOR ALARM STAYING ON WHEN DRIVER'S DOOR IS OPEN, BUT NO KEY IN IGNITION OR LIGHTS ON, DOOR LOCKS NOT WORKING PROPERLY, 4WD ENGAGING AUTOMATICALLY, CD PLAYER GOING OFF AND ON, WINDSHIELD WIPERS GOING ON AND OFF, AND WATER ON DRIVER'S SIDE FLOOR AFTER RAINS. IT HAS BECOME MORE OF A PROBLEM. I DID NOT KNOW WHAT WAS CAUSING THE PROBLEMS UNTIL I BEGAN REPLACING PARTS AND FOUND ON THE INTERNET THAT THIS HAS BEEN A KNOWN PROBLEM WITH THE EXPEDITION AND FORD BEING AWARE OF THE PROBLEM FOR MANY YEARS. I JUST WROTE THE FORD COMPANY AND THEY TOLD ME THEY KNEW NOTHING ABOUT SUCH PROBLEMS!!! REFERENCE NUMBER IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHILE I PULLED IN A PARKING LOT AFTER FREEWAY DRIVING THE THROTTLE STICKS. THIS ONLY HAPPENS IN LOT TEMPERATURES. THIS MAKES THE VEHICLE UNSAFE TO DRIVE. YOU HAVE TO PUSH THE BRAKE EXTREMELY HARD TO STOP AND THE MOMENT YOU REMOVE YOUR FOOT FROM THE BRAKE THE VEHICLE SPEEDS UP. WHEN THIS HAPPENS ON SNOW COVER ROADS THE ABS KICKS IN. WHEN THE ABS RELEASES THE BRAKES THE VEHICLE JERKS FORWARD 2 TO 3 FEET. THIS IS A MAJOR SAFETY ISSUE MAKING THE VEHICLE UNSAFE TO DRIVE. FORD HAS ISSUES A TSB ON THE PROBLEM (TSB 01-21-5) SUGGESTING A PVC REPAIR KIT. THE PROBLEM IS NOT BEING CAUSED BY A DEFECTIVE PART, IT IS A DEFECTIVE DESIGN ALLOWING MOISTURE TO ENTER THE SYSTEM FROM THE PCV AND ICE UP THE THROTTLE PLATE. THIS NEEDS TO BE A RECALL. *TR

SUMMARY: WATER LEAKED AROUND THE LEFT SIDE OF WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE STARTER, RADIO, WINDSHIELD WIPERS, HEADLAMPS, ETC. THE WATER ENTERING THE VEHICLE WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM). THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE. THE VEHICLE CONTINUED TO ATTEMPT TO START ITSELF WITHOUT ANY KEY IN IGNITION UNTIL IT RESULTED IN THE STARTER BURNING UP AS WELL AS DAMAGING ASSOCIATED WIRING AND BATTERY. VEHICLE'S WINDSHIELD HAD TO BE REPLACED AS WAS THE STARTER, ASSOCIATED WIRING AND BATTERY AFTER VEHICLE WAS TOWED TO REPAIR FACILITY. *TR

5 PEOPLE IN MY VEHICLE DRIVING 55MPH ON I40 AROUND MIDNIGHT WHEN AIR SUSPENSION WENT OUT AND EVERYTHING IN THE DASH WENT CRAZY. THINGS CUTTING OFF AND ON MOVING BACKWARDS AND FORWARDS, WHEN I CUT IT OFF SO TO NOT DRIVE WITH AIR SUSPENSION DOWN IT WOULD NOT RESTART UNLESS YOU STARTED IT IN NEUTRAL BUT THE BATTERY KEPT DYING AND EXPLODED DRIVING TO SHOP,.GOT ANOTHER BATTERY, IT EXPLODED TO. NOTHING ELECTRICAL WORKED. DOOR LOCKS, WINDOWS,SPEEDOMETER, STEREO WOULDN'T COME ON THEN WOULD COME ON BY ITSELF, LIGHTS TO. AIR SUSPENSION WOULD NOT WORK, BEEN IN THE SHOP TWICE. FIRST TIME THEY DIDN'T KNOW WHAT WAS WRONG. THIS TIME THEY KNOW BUT I CAN AFFORD TO FIX IT. THE GEM MODULE AND FUSE BOX IS OVER 600.00 PLUS LABOR! IM DISABLED WITH A FIXED INCOME AND I HAVEN'T DRIVEN ANYWHERE SINCE FEB I CANT GET TO MY DOCTOR, GROCERY STORE, TO GET MEDICINE FOR HEART ATTACK AND OTHER DISABLING ILLNESSES. I CANT AFFORD ANOTHER CAR OR TO FIX MY EXPO. THIS COULD HAVE BEEN DANGEROUS I SURE NEED SOME HELP WITH THIS.ELECTRICAL SYSTEM FAILURE NHTSA PRELIMINARY EVALUATION #PE05033 STATUS:CLOSED DATE OPENED:JUNE 15, 2005 DATE CLOSED: OCTOBER 13, 2005 RECALL: NO RECALL ISSUED COMPONENT(S): ELECTRICAL SYSTEM EQUIPMENT:ELECTRICAL VISIBILITY:WINDSHIELD SUMMARY: ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.NHTSA: FOR DETAILED INFORMATION & SUPPORTING DOCUMENTS, SEE THE OFFICIAL NHTSA INVESTIGATION#PE05033. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE DRIVING 5 MPH, AN UNKNOWN NOISE EMITTED FROM THE REAR DRIVER SIDE OF THE VEHICLE AND IT BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRAILING ARMS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

JUST STOPPED AT STOP LIGHT, PULLED AWAY AND HEARD A SMALL POPPING NOISE, SLOWED DOWN TO TURN CORNER TO TRY TO PULL OVER AND LOOK AND VEHICLE STARTED POPPING LIKE A POPCORN POPPER. THOUGHT IT WAS MUFFLER(S). GOT UNDER CAR TO LOOK NOTHING WRONG THERE, PROCEEDED TO GO BACK HOME. ( LESS THAN 5 BLOCKS AWAY) DRIVING ON (COASTING) ONLY USING GAS PEDAL TO MAKE IT INTO DRIVEWAY. GOT UNDER HOOD AND SEEN SPARK PLUG LAYING ON ENGINE, COIL LOOING LIKE IT HAD CAUGHT FIRE. REPLACED WIRE, PLUG AND PUT A HELIX COIL ON IT. DROVE FOR ABOUT A MONTH. SAME THING HAPPENED AGAIN. HAD MECHANIC "RETHREAD" THE HEAD AND USE "SLEEVE". THIS LASTED ABOUT ANOTHER MONTH. HAD TO REPLACE IT 3 MORE TIMES (ALWAYS THE SAME PLUG THAT POPPED OUT) UNTIL AUGUST 2 WHEN IT DIDN'T EVEN MAKE IT OUT OF MY DRIVEWAY BEFORE IT POPPED AGAIN. NOW IT IS SITTING IN MY DRIVEWAY, A 5100 POUND "LAWN ORNAMENT" NOT LOOKING FORWARD TO REPLACING THE HEAD. *TR

DRIVING NORMALLY DURING HEAVY RAIN WIPERS AND RADIO WENT DEAD AT HIGHWAY SPEED AND WORKED INTERMITTENTLY AFTER THAT. AFTER THE RAIN STOPPED AND CAR DRIED OUT WIPERS AND RADIO WORKED NORMALLY AGAIN. CARPET ON LEFT SIDE UNDER FUSE PANEL AND GEM MODULE, BOTH OF WHICH HAVE ALREADY BEEN REPLACED WAS WET. THIS IS A SAFETY CONCERN AS IT IS EXTREMELY DIFFICULT TO SEE WHEN THE WIPERS STOP WORKING UNEXPECTEDLY. THE CAUSE SEEMS TO BE THE WINDSHIELD WASN'T SEALED PROPERLY AT THE FACTORY, AS MY FATHER BOUGHT THE VEHICLE NEW AND SAID THE WINDSHIELD HAS ALWAYS LEAKED. I PURCHASED THE VEHICLE FROM HIM. *TR

EXHAUST MANIFOLDS LEAKING AND FUMES ENTERING VEHICLE. *TR

ON MAY FIRST OF 2014 MY CHECK ENGINE LIGHT AND OIL LIGHT CAME ON. I ASSUMED I NEEDED OIL, SO I WENT TO THE ADVANCED AUTO STORE AND PURCHASED SOME OIL. I PUT THE OIL IN AND BEGAN TO PROCEED HOME. I WAS DRIVING AND THE OIL LIGHT WAS SHOWING AS HOT. THE CAR WOULD NOT GIVE ENOUGH POWER FOR ME TO DRIVE, IT BEGAN TO SHAKE. THE CAR IS NOT DRIVABLE ANYMORE. IT IS STILL DOING THE SAME THING. AFTER SOME RESEARCH I DISCOVERED THAT THIS CAR'S MAKE AND MODEL IS A RECALL CAR. I NEED TO KNOW WHAT TO DO. *TR