Ford Escape 2020 — Reported problems

Our 2020 Ford escape cowling is separated from the windshield. I took it to a body shop to see if they could fix it. The strip groove that connects the cowling to the windshield has separated from the glass. The only way to fix it is replace the windshield. This is a know issue with Ford cars researching. I was in recently for the windshield motor replacement warranty. I asked the service tech about it and stated not covered considered a "body issue." This is does not sit well. Is there anything that can be done. We take very good care of our car. This is cosmetic but it appears to be a known defect.

The contact owns a 2020 Ford Escape. The contact stated that while driving, the vehicle began shuddering and nearly lost power. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part for the recall repair was not yet available. The local dealer was contacted, and the vehicle was taken to the dealer for an interim repair. The contact stated that there was an abnormal rotten egg odor coming from the vehicle after the repair. The vehicle was sputtering while accelerating, and there was a delay with the engine responding. The manufacturer was notified of the failure. The failure mileage was 130,000.

The sunroof moulding of my 2020 Ford Escape has come loose. I can’t find any clips to restick the moulding to the sunroof. I see that others have also had this issue and for some the moulding has gone to the back of the visor housing. Luckily I took out the moulding before this happened, but I can’t place it back without new clips which are not available online.

When driving, the car will shudder and jolt when shifting gears, particularly from 2nd to 3rd. It will not accelerate properly at times and has almost caused me to be rear ended when merging on highways at highway speeds. This might be tied to the transmission issues that other 2020 ford escapes are dealing with.

I am noticing an obvious lurching while accelerating at low speeds after being stopped. It also happens when slowing down. It is happening with and without adaptive cruise control engaged. This may cause someone to rear end me if my brake lights are not activated because I am not braking. Inversely it may cause me to rear end someone in front of me

There is a malfunction in the AWD system that gives a code for low voltage. I tracked down the issue to a factory defect where the connector to the AWD module doesn’t have a ground wire. Ford has acknowledged the issue under “Ford Customer Satisfaction Program 21B19” but it has since expired. (Expired after the vehicle was purchased) As a result of the fault, It disables AWD, hill start assist, forward collision assist.

Vacuum pump went and replaced then rpms spiking between 1500 and 2000. Then traction control light came on and noise in from end. All within a week.

Vehicle: 2020 Ford Escape I am experiencing a recurring drivability issue with my 2020 Ford Escape. During normal or light acceleration, primarily between approximately 1,000 and 2,000 RPM, the vehicle intermittently jerks, surges, or hesitates. At the same time, I can observe slight RPM fluctuation. The condition continues to occur even when the vehicle is driven in Sport mode. On some occasions, the vehicle has also accelerated suddenly and more aggressively than expected, making the vehicle’s response unpredictable. I have had situations where I nearly collided with another vehicle because of the unexpected acceleration. The vehicle has displayed diagnostic trouble code P0600 – Serial Communication Link. The ignition coils and spark plugs have already been replaced, but the condition remains unchanged. I am concerned because the hesitation, jerking, surging, and unexpected acceleration occur while the vehicle is being driven and could affect safe and predictable vehicle control in traffic. I have not yet received a final diagnosis confirming whether the cause is related to the transmission, torque converter, PCM/TCM, communication system, speed control system, or another component. I am reporting this issue so that NHTSA has a record of the condition in case other owners of 2020–2021 Ford Escape vehicles are experiencing similar drivability and unexpected acceleration problems.

These are the failed systems since the recall was being repaired since July 27th 2026. The car is presently still at the dealer today. Sept 18 2026. Sync Screen goes black Instrument cluster goes black. Auto-hold fails Pre-collision emergency assist not available Forward camera not available Drive mode not available Powertrain Control Module fails with error to Ford App Service Engine light on at all times We have all repair times it went back total of 4 times. No replacement vehicles was provided. Here are the additional files in this link there are approximately 16 repair files 3 are Ian pictures below uploaded https://acrobat.adobe.com/id/urn:aaid:sc:VA6C2:4e092f62-ba12-4fac-888f-d529227f810a

I purchased four brand new tires Douglas touring AS 102 H all season tires on September 12, 2024 with my mileage at 48,906 miles. On July 14th 2026 I went to Portsmouth Ford used car for a recall the inspected my tires and said I had 7/32 of tread life left. Today on September 17, 2026 I was told by Walmart in Portsmouth New Hampshire I had hardly any tread left on all four tires and they needed to be replaced. The tires I had bought from Walmart on September 12, 2024 it cost me $501 for Ford tires with a 50,000 mile warranty or five years Natalia brand is Douglas touring AS102H all season tire number is 1M62YPH13324 . The mileage on my car today is 79,768 miles so if you do the calculations 79,768-48,906 when I bought the tires you're looking at roughly the tires only got 30,000 miles out of those tires. . I'm reporting this because those tires should've lasted longer than 30,000 miles where I didn't drive a whole lot from September 2024 to September 2026. I think I was sold defective tires. And I'm looking for a refund from Walmart or a prorated refund so I can buy better ties someplace else. You can see from all my documentation that I did tire rotations twice a year since I got the tires in 2024 so I took care of the tires with the maintenance.

After a dealership diagnostic visit involving my 2020 Ford Escape, I discovered that a connector in the vehicle's Smart Data Link/Gateway area underneath the dashboard had been left disconnected when the vehicle was returned to me. The vehicle had been at Gullo Ford of Conroe on September 9–10, 2026 for an intermittent idle/sputtering concern and a rear-suspension concern. The dealership performed electronic diagnostic work and documented no DTCs. After pickup, I inspected the vehicle and photographed the disconnected connector before reconnecting it. I am concerned that releasing a vehicle with a vehicle-network/diagnostic gateway connection disconnected could affect diagnostic communication, stored fault reporting, or other electronic/network functions. I am submitting this report as a potential safety/electrical-network concern. I am not asking NHTSA to adjudicate my billing dispute with the dealership. Photographs showing the condition as discovered and the dealer service invoice are available.

White foggy smoke from exhaust. Backing sensor or driving sensor are off when sensing environment. Car suspension not fully stable sorta drift to left or right.

I am submitting a safety complaint regarding my 2020 Ford Escape, which currently has an unrepaired safety recall involving the fuel injectors. Recall Information: Manufacturer Recall Number: 25S76 NHTSA Recall Number: 25V467 Recall Date: July 16, 2025 According to the recall notice, a fuel injector may crack and cause fuel to accumulate on top of the engine. The notice states that liquid fuel and/or fuel vapor near hot engine or exhaust components could ignite and cause an under-hood fire. I am very concerned because this recall has remained unrepaired since 2025, and as of September 2026, the remedy is still listed as unavailable. I am also currently experiencing a problem with my vehicle. Whenever I put gas in the vehicle, it has a difficult time starting afterward. The engine struggles to start after refueling, which is concerning to me because there is already an open recall involving the vehicle's fuel system. I understand that I cannot personally determine whether the starting problem is directly related to the recalled fuel injector issue. However, because the vehicle has an open fuel-system safety recall involving a potential fuel leak and fire risk, I believe these symptoms should be documented and investigated. I am concerned about continuing to operate this vehicle while the recall remains unrepaired, especially since the recall warns of the possibility of fuel or fuel vapor accumulating near hot engine components. I am requesting that NHTSA document and investigate my complaint and provide any available guidance regarding this unresolved recall and the symptoms I am experiencing. I would also like my concerns documented regarding the length of time this safety recall has remained without an available permanent repair.

The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check engine warning light was intermittently illuminated. The vehicle was taken to a certified mechanic who diagnosed that the spark plugs had failed and needed to be replaced. The mechanic replaced the spark plugs; however, the failure persisted. The dealer was contacted, and it was confirmed that the part was not yet available for the recall repair. The manufacturer was made aware of the issue and was unable to provide an expected date when parts would be available.

I consistently get an AWD failure warning and then it turns off multiple different safety features of the car, traction control, hill assist, AWD, collision detection etc. I have seen a lot of people complain about the same thing. This is dangerous and ford needs to provide a solution to the bad ground of the AWD module.

The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed, the message that the door was unlocked was displayed. The vehicle was taken to a dealer, and the contact was informed of an unrepaired recall associated with the VIN. The contact was informed that an unknown device was installed, and the vehicle was repaired; however, the failure reoccurred. The contact stated that the front driver's and passenger's side doors failed to unlock. The contact stated that the family crawled into the vehicle through the trunk. The vehicle was taken back to the dealer. The contact was informed that the driver’s and passenger’s side front doors needed to be replaced. The vehicle was taken to an auto body shop as per the dealer. The driver’s and passenger's side front doors were replaced but the failure reoccurred. In addition, the transmission shift to park warning light was illuminated. The vehicle was taken back to the dealer. The contact was informed that the auto body shop had clipped the wiring harness from an unknown sensor. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with battery failure. The battery was replaced, and the vehicle was repaired. The failure reoccurred. The contact stated that the front driver's and passenger's side doors failed to unlatch occasionally. The doors unlatched and the transmission shift to park error messages were displayed. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the dealer was an independent dealer. The failure mileage was approximately 58,986.

My passenger headlight assembly seal has failed. Since the seal failed, the light has water buildup that caused the entire assembly to short out and stop working. There are not cracked in the headlight at all. My car only has 46,407 miles on it. My car has been to the service department at Town N Country Ford in [XXX]. Since we purchased the extended warranty, Town N Country submitted my claim to the warranty department, but they are refusing to pay because, they say it's a moisture problem. The moisture in the headlight is only there because the seal failed. Ford knows this is a problem, but yet they refuse to pay of the headlight replacement or make a recall for this problem. This is a major flaw and needs to be corrected by Ford, the consumer should not have to bear the brunt of this burden when it is clearly a defect with the headlight assembly itself. Please make Ford take responsibility for this issue immediately. Town N Country Ford said the cost to replace this headlight assembly will be $1,962.34 whenever they can receive the part. If these parts are on back order, clearly Ford has an issue and should be held accountable to replace these headlights free of charge by making a RECALL. I've requested the warranty denial report from Town N Country Ford, but I have not received anything as of this being filing XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Escape. The contact received notification for NHTSA Campaign Number: 26V117000 (Visibility); however, the part to perform the recall repair was not yet available. The dealer was notified of the issue and confirmed that the part was not yet available. The contact stated that upon starting the vehicle, the windshield wipers failed to operate as intended. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure; however, no assistance was provided. The failure mileage was approximately 85,000.

Wipers will swipe a couple times then stop half way and not descend all the way. Then begin to “flutter” have to shut off for them to descend and turn on again, over and over.

I had complete brake failure while driving my vehicle yesterday I had new brakes installed on XXX by Mr tire auto service centersStore Number: #XXX ([XXX]) ​Invoice Number: XXX ​Guest ID: XXX ​Vehicle details: 2020 Ford Escape Titanium. They have deemed that PARTS were defective ( calipers and pads) . This situation ended up okay however if I was on open road I could have killed myself or others. The manufacturer of these parts needs to be flagged. We have requested a detailed list of the parts that were used to do this job and have also reached out to Monro who is their corporate affiliate. We have not heard back from them yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN, just here to make a complaint. Fuel Injectors have not failed yet but Ford Motor Company has not yet found a remedy even after 12+ months since recall was initiated. Recall was sent out August 18th, 2025 and no remedy has become available. Currently still waiting

The contact owns a 2020 Ford Escape. The contact stated that upon shifting into drive(D), the vehicle jerked significantly. The contact continued to drive the vehicle despite the failure, which intensified while coming to a stop. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 130,000.

2020 ford fusion taken to Bessemer Ford dealership July 20 2026 with issues to vehicle sputtering. The vehicle was returned as no problem found On August 15, 2026vehicle ran hot and shut down 140 miles away from home. The vehicle was then towed to Huntsville Ford. I was sent a video by the dealership of the coolant being milky brown but have had no contact with them at this time. When I call or text I receive a message stating they will get back with me when they can.

I have a 2020 Ford escape all-wheel-drive, it only has 42,000 miles on it, and I had to have the differential replaced.

The contact owns a 2020 Ford Escape. The contact stated that while stopped at a red light, upon depressing the accelerator pedal, the vehicle failed to move, with an abnormal beeping sound coming from the vehicle. There was no warning light illuminated; however, the message "Place Vehicle in Park to Restart Engine" was displayed. The local dealer was contacted; however, the vehicle was not diagnosed due to the cost. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 101,000.

The contact owns a 2020 Ford Explorer. The contact stated that while stopped at a red light, upon depressing the accelerator the vehicle would not move and an abnormal beeping sound was emitted, no warning lights were illuminated however a warning message was displayed on the instrument panel "Place vehicle in park to restart engine". The local dealer was contacted however the vehicle was not diagnosed due to cost. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 101,000.

Transmission developed severe Shuddering in and out of Lockup. Was told Ford was aware of problem. Check engine light came on intermittently. Took car to dealership. Was diagnosed with Shuddering in and out of lockup. Estimated repair bill totaled $11,321.25.

On 8th of June 2026, exiting I35W onto Convery Dr. I notice my dash gauges failed in proving any information. I immediately pulled over turned off the vehicle and turn it on. Gauges did not work, but vehicle did start and was running normal. I utilize the Waze app to monitor my speed and arrived home safely while putting no one at risk. I had to take a different vehicle to Hopps automotive for repairs, upon return my vehicle gauges were working as normal. Two days after the incident started the vehicle and the gauges were not working, but vehicle did make it to the auto shop for repairs and was told the gauge clusters were out. Took roughly a few weeks for the repair because the clusters still wouldn't work after repair. had a safety recall went to ford for the software updates. After the updates everything seem to be running just fine. Ford Cleburne did a curtsey inspection, Transmission passed, but now my transmission is having issues. I have a zip file full of reports on my vehicle maintenance, but unable to upload all the information.

The panoramic sunshade does not work & also droops down.

While I was driving on a highway the ADAS (IPMA) suddenly stopped working creating a dangerous situation as I was using adaptive cruise control at the time. It has never worked since. Ford has told me that there is no software fix and the hardware needs to be replaced at a cost of $1500. Unless I pay that amount I will lack key safety features like forward collision warning and automatic emergency braking.

The contact owns a 2020 Ford Escape. The contact received notifications of NHTSA Campaign Numbers: 25V467000 (Fuel System, Gasoline) and 26V123000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. While the contact’s son was driving approximately 45 MPH, the screen on the radio went black. The vehicle was pulled over to the side of the road, and the radio independently reset and displayed the correct information. The failure had occurred approximately 3 - 4 times. The radio screen often displayed erroneous information with distorted images. The contact stated that the vehicle was included in a recall for the door, and after the recall repair was performed, the key fob failed to lock and unlock the doors. The vehicle was taken to the dealer, and the contact was informed that the manufacturer had not provided the parts for the recall repairs. The manufacturer was not informed of the failure. The failure mileage was approximately 71,000.

My husband I originally purchased this vehicle around October 2020. We are the only owners and when we purchased it, it had 78 miles on it. Since I purchased it I have had to pay out of pocket for all the tire sensors to be replaced, I have had to purchase a new heater fan, and a sensor for a seat belt that prevented my adaptive cruise control from working. A while back, a warning light came on saying my adaptive cruise control was no longer working. I took it to Ford and was told it would cost $1600 to fix it. Surprisingly, it started working on it's own a few days later. Currently I took the car in because my rear passenger window wouldn't go up. I was told that it would cost almost $1800 to fix it. I have taken it to Ford to have 2 of the 3 recalls fixed. They do not show that it was fixed and I was told they weren't able to fix it. I pushed the button one day to send the cloth covering on the moon roof back. It snapped and no longer works, their is a crack in my dash, and I frankly don't have the money to fix a window motor that should have not quit after six years. I take excellent care of my car. I have all the maintenance taken care of. I expect to have the brakes fixed, new tires, new battery. What I don't expect is for the sensors and motors to go out. I have been driving for over 40 years, owned multiple vehicles and I have to say I am so disappointed with Ford. I understand that the problems I am having is not just me, that many Ford Escape owners are having similar issues. I would just like some assistance.

The contact owns a 2020 Ford Escape. The contact stated that while driving at an undisclosed speed and turning the steering wheel, the vehicle failed to accelerate as needed with an abnormal popping sound coming from the vehicle. There was no warning light illuminated. The contact was stopped before resuming normal driving. The vehicle was taken to the dealer, and the failure was associated with the rear differential. The contact stated that four repairs had been performed on the rear differential; however, the failure persisted. Recently, the contact was informed that the rear differential needed to be repaired, and that the repair was not covered under warranty. The dealer reached out to the manufacturer, and the manufacturer agreed to cover a portion of the cost of the repair. The vehicle was not yet repaired. The failure mileage was approximately 30,000.

Issue: that the sunroof shade got, detach from the rig that slide it forward. This looks like it’s caused by the guard plate between the sunroof and the moonroof falling off, landing on top of the shade. This integral piece that keeps the mechanism functioning kept together by double sided adhesive, so virtually scotch tape. That’s ridiculous. This is a safety risk, because with the shade sagging, it blocks my view of the rear. Additionally, when it first happened the adhesive piece fell while driving causing a distraction while driving. This is a design flaw that Ford should cover.

We have experienced fuel leaks and engine stalling, and three separate dealerships have refused an interim safety fix or alternate transportation. This is our primary vehicle for transporting our children and it's no longer safe. The RPMs jump all over, we occasionally smell gasoline, and the entire car shakes. Everybody tells us they can't replicate the problem and claim it's okay. It stalled on me when I was driving down a busy highway during rush hour and a tractor trailer almost hit me from behind WHILE MY KIDS WERE IN THE BACKSEAT.

The contact owns a 2020 Ford Escape. The contact stated that after the dealer performed an unknown recall repair on the front driver’s side door, the failure occurred. The contact stated that the front driver’s side window intermittently failed to roll up or roll down and made a squeaking sound while operating. The dealer was made aware of the failure and informed the contact that the front driver’s side door motor needed to be replaced, and the repair would be an out-of-pocket expense. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

When the car sits in the sun and the gear shifter gets hot from the heat, the gear shifter locks up and you cannot get it out of park until it is cooled off. No matter how hard I try to turn the dial, until I completely cool the shifter down it will be stuck in park. I have started having to cover the shifter when I get out of the car to prevent this issue and if I forget, I have to point the air vents down towards the shifter, cover the shifter and the air vents with a jacket and then the ac to max ac for at least 5 minutes. This traps the cool air in with the shifter and helps cool it down so it will release and can shift into any other gear besides park. I have researched this issue and found many other owners of this similar year, make, and model who complain about the issue as well.

I've taken my car 3 times for the same recalls 1st time was to jack Kisse for power train and fuel injector he told me the recall wasn't to my car I argued I can tell something was wrong with my car it keeps stalling and it's going to end up killing me in traffic from the fuel injectors so I take it too [XXX] of Norton and broken arrow they tell me after sitting there for 8 hours that the powertrain is not taking it takes 4 hours to do it and they only have 30 minutes left and all of a sudden it takes that's a bunch of crap cuz there was only 30 minutes anyway I leave still notice something then a wrench and engine light come on so I take it again were I was charged 've taken my car three different times to get my powertrain recall and fuel injector recall fixed they have failed to do so... and now I have a wrench and engine light showing up on my car I take again cuz my app is still tells me that I have recalls for a powertrain and fuelI injector recalls all they did was charge me to get the code when I knew it was for the recalls over $200 the very next day the lights come right back on my powertrain and fuel injector never been fixed my they told me I have an open fuel line and let me drive off with it now I'm concerned that my car is going to catch on fire especially in the heat and what do I do if you just taking it back for them to not do anything to my car and now I have the ranch and the engine light coming on and off a different time one day one minute will be the ranch next will be the engine sometimes it's both and I have records of it I keep trying to report it to you guys and I'm not hearing anything back I don't know what else to do I believe that my car is a lemon and they're not going to be able to fix it since I'm taking it three times already please contact me back to let me what I should know where I should do thank you you reach me at [XXX] or at my email [XXX] I prefer you contact me through email thank your INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The transmission on my 2020 Ford Escape began shuddering around 30 mph and occasionally shifted harshly during acceleration without any warning lights or messages. I took the vehicle to Beechmont Ford, where the technician confirmed the concern, found metal contamination in the transmission fluid, and determined the transmission has internal damage consistent with a failed output planetary bushing, requiring a complete transmission overhaul. The vehicle has approximately 65,000 miles, and the estimated repair cost is $7,200. This issue creates a safety concern because the transmission could unexpectedly lose power, fail to shift properly, or stop propelling the vehicle while driving, increasing the risk of a crash.

Got recalls notice but the local dealership in st george SC (family ford) told me they wont do the brake or fuel injector recall until i have issues so i guess until my car catches on fire with my kids in it then they will do something