Ford Crown Victoria Police 2002 — Problemas reportados

..

Driving down the roadway at 55 mph a spark plug in cylinder 2 blow out. The car started making a popping noise and started to lose power. After a while the car shut off. The car was able to restart and be driven home. Upon inspection by a mechanic they found the spark plug had came dislodged and shot out of the cylinder and caused damage to the cylinder head the ignition coil and fuel rail. A new Heli coil was installed. A year later while in Texas driving down the road around 35 mph car made a pop noise and shot a spark plug out of cylinder 5 cause the car to lose power and start smoking with a heavy smell of fuel. Car was stopped and inspected. Found a spark plug was blown out of cylinder 5 with damage to the ignition cylinder and fuel rail. repaired the heli coil and placed with new spark plug ignition coil and fuel rail. 2019 while driving down road at 75 mph vehicle makes a loud pop and starts to lose power. Upon inspection by mechanic find spark plug blown out of cylinder 1 with damaged ignition coil. Having mechanic is now replacing both cylinder heads on the engine.

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO MAKE A TURN, THE TURN SIGNALS AND HEADLIGHTS FAILED TO WORK, EXCEPT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO NOTICED THAT THE TAIL LIGHTS DID NOT WORK AND THE DASHBOARD WAS BLACKED OUT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO SCHEDULE THE VEHICLE FOR A DIAGNOSTIC EVALUATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. UPDATED 10/06/16*LJ ** UPDATED 10/19/16*LJ *TR

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE HEADLAMPS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LIGHTING CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 197,000.

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING 35 MPH AND PROCEEDING TO STOP AT A RED LIGHT, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MANIFOLD WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,218.

I HAD DRIVEN UP A STEEP MOUNTAIN DIRT ROAD TO SERVE SOME LEGAL PAPERS, AFTER REACHING THE TOP, I CONTINUED DOWN THE OTHER SIDE TO THE ADDRESS I WAS LOOKING FOR. I THOUGHT I STARTED SMELLING SOMETHING BURNING, IT SMELLED ELECTRICAL. WHEN I ARRIVED AT THE ADDRESS, I STOPPED THE CAR AND SHUT IT OFF WHILE I WAS SPEAKING WITH THE RESIDENT. MY WIFE YELLED AT ME THAT THE CAR WAS ON FIRE, IT STARTED FILLING UP WITH SMOKE FAST, MY WIFE AND DOGS WERE STILL IN THE CAR. I OPENED THE DRIVERS DOOR TO POP THE HOOD WHILE MY WIFE STARTED GETTING THE DOGS OUT, I THEN NOTICED IT WAS MY FLOOR THAT WAS BURNING, JUST ABOUT UNDER THE GAS PEDDLE, A HOLE HAD BURNED THROUGH AND THE METAL WAS GLOWING RED WHERE THE PADDING HAD BURNED AWAY. I POURED A CUP OF COFFEE TO PUT THE FIRE OUT WHILE THE RESIDENT GOT SOME WATER FOR ME. THE PADDING AND RUBBER MAT HAD BURNED AWAY AND A HOLE ABOUT 3 INCHES LONG HAD MELTED AWAY FROM THE FLOOR BOARD. THE CATALYTIC CONVERTER IS DIRECTLY BENEATH THE HOLE BUT THERE DOESN'T SEEM TO BE ANY HOLES IN THE CONVERTER AND THERE IS A EMPTY SPACE ABOUT 1.5 - 2 INCHES FROM THE MELTED HOLE TO THE CONVERTER. WE LET EVERYTHING COOL DOWN BEFORE DRIVING HOME, HOWEVER THE ENTIRE WAY HOME, (49 MILES) WE WERE AFRAID THE CAR WAS GOING TO BURST INTO FLAMES. ONCE WE WERE BACK ON THE PAVED ROADS AND WERE ABLE TO DRIVE THE NORMAL SPEED LIMIT, THERE WERE NO MORE ISSUES NOR ANY FURTHER BURNING, JUST THE LINGERING SMELL. I LOOKED UP AND FOUND A RECALL FOR AN ISSUE IN THE SAME LOCATION HOWEVER THAT WAS FOR 2003 - 2005 VEHICLES. *JS

TL** THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER AND PASSENGER SEAT BELT BECAME UNLATCHED SPORADICALLY. THE CONTACT MENTIONED THAT THE FAILURE COULD HAVE BEEN DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS). THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

BOUGHT THE CAR FROM A FELLOW FRIEND HE ADVISED ME THAT THE CAR HAS HAD A ISSUE WITH THE STEERING WHERE THE STEERING WHEEL HAS PLAY TO IT AND ITS VERY DANGEROUS WHEN I DRIVE OVER 50MPH IM SCARED I MAY CRASH CAUSE THE CAR MOVES LEFT TO RIGHT, AND THE ABS BRAKES HAVE A PROBLEM THE BRAKE JUMP WHEN I HIT THEM IDK WHAT TO DO IM LOW ON FUNDS AND I WANT TO KNOW IF THIS IS A DEFECT THESE CARS ARE KNOWN FOR STEERING AND BRAKES DEFECTS..... *TR

POWER STEERING STARTED CATCHING AND COULDN'T TURN THE STEERING WHEEL SMOOTHLY. HIT A CURB WITH MY TIRE AND ALMOST HIT ANOTHER CAR. STILL JAMMING BUT I DON'T HAVE ENOUGH MONEY TO TAKE IT INTO A DEALERSHIP. HELP! *TR

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE STEERING FAILED AND THE WHEEL BECAME TIGHT. THE VEHICLE WAS REPAIRED BY THE CONTACT AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE DRIVER'S SEAT BELT CAME UNDONE. THE CONTACT RE-SECURED THE SEAT BELT AND THE FAILURE RECURRED. THE CONTACT HAD TO PURCHASE A SEAT BELT EXTENSION IN ORDER TO KEEP THE SEAT BELT BUCKLED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT NOTIFIED OF THE ISSUE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUT OF THE VEHICLE SAFETY WARRANTY AND HE WOULD HAVE TO REPLACE THE SEAT BELT HIMSELF. THE FAILURE MILEAGE WAS 40800.

POWER WINDOWS FRONT ELECTRIC WHEN YOU TOUCH REAR WINDOW BUTTON THE DRIVERS WINDOW GOES DOWN. *TR

THE ENGINE STALLED WHILE DRIVING, FOR NO APPARENT REASON. DRIVER (MY RETIRED MOTHER, AGE 72) HAD TO GET CAR OFF ROAD AND RESTART CAR TO CONTINUE. THE POWER STEERING DISABLED WHEN THE CAR ENGINE STALLED. THIS HAS HAPPENED MULTIPLE TIMES (2-3) OVER THE PAST MONTH, AND THE LOCAL FORD DEALERSHIP CANNOT REPLICATE THE PROBLEM AND IS UNABLE TO CORRECT IT. ON ANOTHER OCCASION THERE WAS A THUMPING NOISE AND THE CAR SLOWED CONSIDERABLY, BUT THEN PICKED BACK UP AGAIN. THE "ENGINE HEAT/THERMOMETER" LIGHT HAS FLASHED ALSO, BUT THE ENGINE TEMPERATURE HEAT IS NORMAL. I CONSIDER THIS A VERY DANGEROUS SITUATION FOR MY MOTOR IF IT WOULD HAPPEN IN A HEAVILY CONGESTED, HIGH TRAFFIC AREA AND COULD CAUSE A VEHICLE CRASHES. IT IS A VERY STRESSFUL SITUATION.

I HAD BEEN DRIVING 250 MILES OR SO AND DROVE DOWN A LONG WINDING INCLINE, AS THE ROAD FLATTENED OUT I HEARD A NOISE FROM THE ENGINE COMPARTMENT. THE NOISE SOUNDED LIKE A HOLE IN THE FIRST PART OF THE EXHAUST SYSTEM. I FOUND A SAFE PLACE TO PULL OVER AND TURNED OFF THE VEHICLE. THERE WAS A SLIGHT ODOR OF NATURAL GAS AS THIS VEHICLE IS FUELED WITH NATURAL GAS. AFTER THE ODOR PASSED, I OPENED THE HOOD TO FIND THAT THE #2 IGNITION COIL MOUNT WAS BROKEN, AND THE COIL AND SPARK PLUG ASSEMBLY WERE LOOSE IN THE SPARK PLUG WELL. MY INITIAL THOUGHT WAS THE SPARK PLUG HAD LOOSENED AND EJECTED. I ATTEMPTED TO RE-INSTALL THE SPARK PLUG BUT THE THREADS IN THE CYLINDER HEAD WERE INEFFECTIVE. THE SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD. I HAVE SUBSEQUENTLY FOUND OUT THAT THIS IS NOT AN UNCOMMON DEFECT FOR THESE FORD ENGINES. THE REPAIR INVOLVED REAMING AND TAPPING THE SPARK PLUG HOLE AND PLACING AN INSERT IN THE HOLE. THE SPARK PLUG COIL HAD TO BE REPLACED TOO. THE REPAIR COST WAS $450 AND THE REPAIR SHOP WARNED THAT THIS MAY HAPPEN AGAIN. THIS IS A DESIGN DEFECT THAT COULD POTENTIALLY BE DANGEROUS UNDER DIFFERENT CIRCUMSTANCES. IF I WAS NOT ABLE TO STOP IN A SAFE PLACE FAIRLY QUICKLY, THERE COULD HAVE BEEN MORE FUEL AIR MIXTURE ACCUMULATION UNDER THE HOOD AND SINCE THE SPARK PLUG WAS STILL OPERATIVE, AN IGNITION SOURCE WAS PRESENT TOO. *TR

2002 FORD WINDSTAR REAR AXLE PROBLEM WE WERE DRIVING ON 78E AND WERE APPROXIMATELY 30 MINUTES BEFORE ALLENTOWN. ALL OF A SUDDEN WE HEARD A CRACK, SMELLED SMOKE, AND HEARD METAL SCRAPING. THE CAR STARTED FISHTAILING AND MY HUSBAND VIRTUALLY HAD NO CONTROL OF THE CAR AS THE WINDSTAR REPEATEDLY CROSSED 2 LANES AND ALMOST HIT THE MIDDLE BARRIER AND THEN FISHTAILED TOWARD THE OTHER SIDE. LUCKILY THERE WERE NO CARS OR TRUCKS IN FRONT OR IN BACK OF US AND WE WERE AT A SLIGHT UPHILL. FINALLY, MY HUSBAND WAS ABLE TO GAIN CONTROL OF THE VAN AND PULL OVER TO THE SMALL SHOULDER WHICH WAS BARELY BIG ENOUGH TO FIT THE VAN. WE CALLED 911 AND AAA. WHILE WE WAITED ON THE SIDE, WE FEARED THAT WE COULD GET HIT IN THE EVENT THAT A TRUCK OR CAR SWERVED TO THE SIDE. WE WERE SHOCKED TO FIND OUT THAT THE REAR AXLE WAS CRACKED AND THE REAR TIRES WERE CAVED IN. MY AUTO DEALER GILBOY IN WHITEHALL OFFERED TO TOW AND REPAIR THE PROBLEM, BUT ONLY AT MY EXPENSE. FORD EXPLAINED TO ME THAT THERE WAS NO COVERAGE FOR THIS SITUATION BECAUSE THE VEHICLE IS OUTSIDE OF WARRANTY AND THERE CURRENTLY IS NO RECALL FOR THIS PROBLEM. BOTH GILBOY AND FORD TOLD ME THEY WERE NOT AWARE OF THIS PROBLEM WITH THE REAR AXLE. I HAD 3 CHILDREN IN THE CAR, 2 OF WHICH WERE MY OWN. THIS WAS THE SCARIEST MOMENT OF MY LIFE AS I FEARED WHAT POTENTIALLY COULD HAPPEN. LUCKILY, SOMEONE FROM ABOVE WAS LOOKING AFTER US BUT I FEAR THE NEXT FORD WINDSTAR OWNER MAY NOT BE SO LUCKY. PLEASE DO NOT WAIT FOR SOMEONE TO GET KILLED BEFORE TAKING ACTION. PLEASE HAVE THE PROBLEM CORRECTED AS SOON AS POSSIBLE AND ALERT ALL FORD WINDSTAR OWNER OF THE SERIOUS POTENTIAL RISK. *TR

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 TO 50 MPH ON NORMAL ROAD CONDITIONS PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL. THE "ABS" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND THE DRIVER WAS ABLE TO COAST INTO THE EMERGENCY LANE. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE FAILURE WAS RELATED TO THE REAR DRIVE SHAFT AXLE. NHTSA CAMPAIGN ID NUMBER 04V328000 (SUSPENSION;REAR) WAS RELATED TO THE FAILURE; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THERE WERE CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

1. WHILE DRIVING ,LED CIRCUITBOARD ,( UNDER DASHBOARD)BURNED UP EMITTING SMOKE INTO THE PASSENGER COMPARTMENT. IT BURNED A ONE INCH HOLE IN THE CIRCUITBOARD PLASTIC COVER . 2. FAILURE,THE PART BURNED UP, IT MAY HAVE BURNED BEFORE ALSO,BECAUSE WE HAVE HAD A BURNING SMELL BEFORE. 3. CAR WAS PARKED,TURNED OFF FOR ABOUT ONE-HALF HOUR , THEN DRIVEN 6 MILES HOME.,NO ADDITIONAL SMOKE WAS SEEN AT THIS TIME. PART HAS BEEN REMOVED BY OWNER .OLD PART IS AVAILABLE,PART # F8VB-14A597-AB. FUSE DID NOT BLOW AND CAR IS DRIVABLE WITH PART REMOVED. I THINK THIS PART IS A COMPONENT OF THE FACTORY INSTALLED ALARM SYSTEM. *TR

ABS AND BRAKE LIGHTS HAS CONTINUED TO BE ON AND CRUISE CONTROL HAS STOPPED WORKING. *TR

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING BETWEEN 55-60 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE BEGAN TO HESITATE AND VIBRATE. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THERE WAS AN INTERNAL COIL SHORTAGE. THE MISFIRE CYLINDER 5, COIL PACK, AND SPARK PLUGS WERE REPLACED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A SEPARATE OCCASION FOR THE IDENTICAL FAILURE AND THE MISFIRE CYLINDER 7, COIL PACK, AND SPARK PLUGS WERE REPLACED AT THAT TIME. THE FAILURE MILEAGE WAS 67,425 AND CURRENT MILEAGE WAS 68,045. UPDATED 03-27-09 *BF UPDATED 03/31/09.*JB

WHILE DRIVING THE LOW BEAMS WENT OUT ON CAR,20 MINUTES LATER HIGH BEAMS WENT OUT. ALL OTHER LIGHTS WORK PROPERLY, HEADLIGHTS HAVE NOT WORKED SINCE. CURRENTLY IN THE PROCESS TO REPLACE PART. *TR

I HAVE SEVERAL ISSUES, BOTH BACK DOOR WINDOWS HAVE FALLEN OFF TRACK AND WON'T STAY UP. THIS HAPPENED IN SEPTEMBER OF 07 AND A FEW MONTHS LATER THE SECOND REAR WINDOW DID THE SAME. I HAVE TO USE CLEAR PACKAGING TAPE TO HOLD THEM UP. THE KEY TO THE IGNITION WILL NOT TURN UNLESS I USE SOMETHING WITH A HARD END AND TAP IT SEVERAL TIMES. WHEN THE IGNITION PROBLEM FIRST HAPPENED IN SEPTEMBER OF 2006 I CALLED FORD ROAD SIDE SERVICE AND THEY RECOMMENDED TAPPING THE KEY SEVERAL TIMES AND SAID THEY HAD A GROWING COMPLAINT OF THIS. MY TRUNK LOCK LATCH OFTEN GETS STUCK TOO. JAN OF 2003 THE RADIO SHORTS IN AND OUT, I NEVER KNOW IF IT'S GOING TO STAY ON. LASTLY THE PASSENGER REAR DOOR LOOK DOESN'T LATCH, I THINK THIS HAPPENED IN LATE 2003 OR EARLY 2004. *TR

JUST CRUISING THROUGH A PARKING LOT ON MY WAY INTO WORK AND HAD A SPARK PLUG BLOWOUT. DAMAGED THE SPARK PLUG COIL AS WELL. HAD TO BUY A NEW COIL, AND A HELICOIL KIT TO RE-TAP THE SPARK PLUG HOLE. *TR

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT OPENED THE HOOD, BUT IT FAILED TO OPEN AUTOMATICALLY. HE PLACED HIS HAND ON THE FENDER AND THE HOOD SUDDENLY FELL AND SLAMMED DOWN ON HIS HAND. THE CONTACT SUSTAINED SEVERAL BRUISES, CUTS, AND BLISTERS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 56,000. UPDATED 03/18/08. *LJ THE CONSUMER STATED AT THE TIME OF THE INCIDENT THE HOOD WAS RAISED TO THE FULL CAPACITY AND VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED STRUTS WERE REPLACED AT CONSUMER'S EXPENSE. UPDATED 03/18/08 *TR UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR

1) I NOTICED THAT MY RPMS WERE NOT RETURNING TO NORMAL AND MY VEHICLE WAS UNABLE TO STOP COMPLETELY. 2) I OWN A 2002 FORD EXPLORER XLS 4X4 WITH THE SOHC 4.0 LITER ENGINE. THE THROTTLE CABLE STUCK IN THE OPEN POSITION CAUSING THE ENGINE TO SURGE UNCONTROLLABLY AT APPROXIMATELY 5000 RPMS. I HAD TO TURN OFF MY IGNITION TO AVOID CRASHING THE VEHICLE INTO NEARBY TRAFFIC. OTA HAS RECEIVED REPORTS OF THIS PROBLEM, NHTSA ACTION NUMBER: PE05037, BUT CLOSED THE CASE ON NOVEMBER 2, 2005. THIS IS A SERIOUS DEFECT THAT COULD HAVE RESULTED IN A SERIOUS CRASH. I BELIEVE THAT OTA SHOULD ISSUE A RECALL FOR THIS PROBLEM AS IT DID FOR CAMPAIGN #03V280000. 3) I WILL BE CONTACTING FORD TOMORROW TO RESOLVE THIS PROBLEM. MY VEHICLE IS CURRENTLY NOT SAFE TO DRIVE. *TR

2002 FORD CROWN VICTORIA LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. *KB THE VEHICLE WAS DAMAGED AS A RESULT OF THE WHEEL COMING OFF. OHIO TRAFFIC CRASH REPORT# 10-89-0577. *JB

I PUT MY KEY IN, TURNED IT ON AND WENT TO SHIFT IN TO DRIVE AND THE SHIFTER CAME RIGHT OUT OF THE STEERING COLUMN. THE VEHICLE WAS IN BETWEEN GEARS.*CN

WHILE DRIVING MY 2002 FORD TAURUS I EXPERIENCED THE FAILURE OF BOTH FRONT COIL SPRINGS WHICH CUT OPEN LIKE A CAN OPENER ONE FRONT TIRES AND DAMAGED THE OTHER. I HAD TO HAVE BOTH TIRES AND SPRINGS REPLACED. IF I WAS TRAVELING MORE THAN 15 MPH I FEAR I WOULD NOT BE HERE TODAY.*CN

2002 EXPLORER XLT PURCHASED 1/03 WITH 37,995 MILES. NOW ONLY 39,996 I AM DISABLED AND DON'T DRIVE MUCH. HAD VEHICLE IN DUE TO WARRANTY OVER 11/26/07 TO CHECK THINGS OVER. WHEN I PICKED UP CAR AIR BAG WARNING LIGHT FLASHING. THOUGH IT WAS DUE TO THEIR WORK BECAUSE IT STOPPED. NEXT TIME USED VEHICLE LIGHT FLASHING THEN STAYED ON PERMANENTLY. TOOK TO DEALERSHIP AND THEY CLAIM IT THROWS A CODE #B2292, THEY ALSO SAID A BULLETIN OUT FROM FORD ON THIS #TSB03-11-03 ISSUED TO ALL MECHANICS - THAT THE PRETENSIONER SAFETY HARNESS BOTH NEED TO BE REPLACED (DEFECT). I ADVISED THEM I WILL DISPUTE THIS DUE TO THE FACT THEY ALSO STATED FORD MAY BE DOING A RECALL. I CLAIM VEHICLE FINE TILL THEY WORKED ON IT. PART COMES IN TOMORROW, THEY SAY IT SHOULD BE READY IN A FEW HOURS, AND COST IS AROUND $295.. PLUS TAXES. ALSO HAD TO HAVE A REBUILT TRANY DONE LAST YR. ON THE AIR BAG LIGHT - I READ ALL THESE COMPLAINTS AND I AM SHOCKED THAT FORD HAS NOT ISSUED A RECALL. THIS IS NUTS. WHAT IS SCARY IS ALL THE FIRE REPORTS. *TR

ALL FOUR WHEELS BEARINGS ON A 2002 FORD EXPLORER WITH ONLY 70,000 MILES HAD TO BE REPLACED. ONE INCIDENT INCLUDED A WHEEL FALLING OFF DUE TO THE FAILURE OF THESE BEARINGS. *TR

VEHICLE PARKED IN PARKING LOT AT 9:30P.M. SHERIFF WOKE US UP 2:00 A.M. BANGING ON WINDOWS STATING SUV WAS ON FIRE. 3 OTHER VEHICLES WERE DAMAGED BECAUSE OF FIRE. I AM BLESSED MYSELF AND MY CHILDREN WERE NOT IN SUV AT THAT TIME. ALSO DAMAGED PARKING AREA. *TR

THE FIBERGLASS PIECE ON THE HATCHBACK OF THE VEHICLE IS CONSTANTLY CRACKING AND FALLING OFF WHILE THE VEHICLE IS MOVING. THIS IS A ROAD AND SAFETY HAZARD, AS MY PIECE CAME OFF WHILE DRIVING 55MPH. I AM CONTINUOUSLY SEEING OTHER EXPLORERS OF THE SAME MODEL AND YEAR THAT HAVE THE SAME ISSUE. FORD NEEDS TO TAKE RESPONSIBILITY FOR THEIR DEFECTIVE PRODUCT AND CONDUCT A RECALL. FURTHERMORE, THIS FAULTY PIECE IS OFFERED AT A FORD DEALERSHIP FOR REPLACEMENT AT OVER $300! *TR

VEHICLE TRANSMISSION FAILED AT 75,000- WE HAD TAKEN THE VEHICLE IN 2 SEPARATE OCCASIONS THE FIRST YEAR OF OWNERSHIP CONCERNING THE TRANSMISSION BUT WAS ADVISED NOTHING WRONG. *TR

BEGINNING OF 2006, I PURCHASED MY USED 2002 FORD EXPLORER. AROUND 70,000 MILES, ABOUT 9 MONTHS LATER, THE ROARING NOISE IN THE REAR WAS UNBEARABLE. I PUT ALL NEW TIRES,I PUT ALL NEW BRAKES THINKING THIS WAS CAUSING THE NOISE. FINALLY I WENT ONLINE TO FIND THE MANY, MANY COMPLAINTS ABOUT THE REAR END NOISE. I CALLED FORD CUSTOMER SERVICE AND THEY SAID THERE WAS NO RECALLS, EVEN THOUGH THERE ARE MANY COMPLAINTS ON THIS ISSUE, BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. THEY SUGGESTED I HAVE IT DIAGNOSED AT A FORD DEALERSHIP. ON 10/20/07, I HAD THIS DIAGNOSIS DONE, AND WAS TOLD IT WAS THE REAR AXLE DIFFERENTIAL AND WAS ADVISED NOT TO DRIVE, OR DRIVE AS LITTLE AS POSSIBLE BECAUSE IT COULD CEASE UP WHILE DRIVING, AND CAN BE A SAFTEY ISSUE IF UNIT FAILS. THE COST OF THIS REPAIR, PARTS AND LABOR IS ABOUT $1200. IS FORD WAITING FOR THIS TO CEASE UP, CAUSING INJURIES OR DEATHS BEFORE THEY DEEM IT A SAFTEY ISSUE, AND RECALL THESE VEHICLES FOR REPAIR. I CANNOT AFFORD TO REPAIR MY VEHICLE AT THIS TIME AND NEED MY VEHICLE. *TR

DOOR AJAR LIGHT COMES ON RANDOMLY, TURNING ON INTERIOR LIGHTS AND LOCKING AND UNLOCKING DOORS WHILE DRIVING. IN ADDITION TO BEING DISTRACTING, IT IS PARTICULARLY UNSAFE AT NIGHT TO SUDDENLY HAVE THE INTERIOR LIGHTS COME ON AND UNABLE TO KEEP DOORS LOCKED. FORD SAYS ISSUE IS A DOOR SENSOR, BUT CANNOT TELL WHICH ONE IS BAD. THIS USED TO HAPPEN OCCASIONALLY, NOW IT HAPPENS AT LEAST EVERY OTHER DAY. *TR

I AM AN OWNER OF A 2002 FORD EXPLORER 2WD. AT THE BEGINNING OF OCTOBER THE VEHICLE STARTING MAKING A HORRIBLE NOISE. THE LOUD NOISE WAS COMING FROM THE REAR PASSENGER WHEEL. COME TO FIND OUT, THIS IS A MAJOR WHEEL BEARING ISSUE. I HAVE RECENTLY GOTTEN ONLINE AND DISCOVERED HOW MANY OTHER PEOPLE ARE ALSO HAVING THE SAME ISSUE. WHAT CAN WE DO TO GET THE FORD COMPANY TO BE HELD RESPONSIBLE FOR THIS VERY DANGEROUS DEFECT IN THEIR PRODUCT THAT YOU ARE SUPPOSED TO TRUST NOT ONLY YOUR LIFE BUT THE LIVES OF ALL YOUR PASSENGERS. HOW CAN COMPANIES CONTINUE TO SELL THEIR UNSAFE VEHICLES TO THE PUBLIC. IT IS ENOUGH TO HAVE TO WORRY ABOUT GETTING MY 1 YEAR OLD TO AND FROM HER NANA'S WITHOUT HAVING TO WORRY ABOUT GETTING HIT BY SOMEONE, BUT TO WORRY THAT ANY MOMENT YOUR VEHICLE CAN CAUSE A MAJOR ACCIDENT WITHOUT YOU EVEN BEING AT FAULT BECAUSE OF FAULTY PARTS. PLEASE, CAN SOMEONE WITH ANY KIND OF DECENCY DO SOMETHING TO GET THIS COMPANY TO RECALL EVERY VEHICLE WITH FAULTY PARTS. COMMON SENSE WOULD SAY IT'S THE RIGHT THING TO DO. *TR

WHILE ATTEMPTING TO SHIFT FROM REVERSE TO DRIVE, THE GEAR SHIFTER ON THE COLUMN BROKE IN 1/2 WHILE PASSING INTO THE NUETRAL POSITION. BROKEN PIECE IN POSSESSION. TRUCK WAS THEN STUCK IN NUETRAL WITH SHIFTER HANGING BY A WIRE. FOUND 2ND 2002 EXPLORER AT DEALER # 2 WITH GEAR SHIFTER BREAKING IN 1/2. *TR

I BOUGHT A USED 2002 FORD ESCAPE 2 MONTHS AGO AND IT WAS CARFAXED AND ALL AND NOTHING WAS WRONG. THREE WEEKS AGO THE ENGINE WOULD STALL OUT WHEN I STARTED THE VEHICLE OR WHEN I WAS DRIVING, I THOUGHT IT WAS BAD GAS, SO I FIXED IT. THEN IT HAPPENED AGAIN AND I THOUIGHT IT WAS THE BATTERY, SO I FIXED IT. I WAS FRUSTRATED AND WHEN IT HAPPENED AGAIN ON OCT. 3RD, 2007 IN THE MIDDLE OF A 7 LANE HIGHWAY. I WAS SCARED AND UPSET, AND I ENDED UP TAKING IT IN AGAIN! WE FOUND OUT THAT THERE IS A RECALL ON 2002 FORD ESCAPES WITH 3.0L V6 ENGINES FOR THE PCM ON DECELERATIONS BELOW 40 MPH BECAUSE OF FUEL-AIR MIXTURES BEING SENT TO THE ENGINE. IT WAS ISSUED IN APRIL OF 2004. I CALLED FORD MOTOR COMPANY, MY DEALER THAT I BOUGHT THE VEHICLE FROM, AND ANOTHER DEALER CLOSE TO ME; THEY ALL SAID THAT THERE WERE NO RECALLS ON MY ESCAPE. I LOOKED IT UP MYSELF AND THEY WERE CORRECT, BUT IF THIS RECALL WAS ALREADY FIXED THEN IT WAS OBVIOUSLY NOT FIXED CORRECTLY BECAUSE THE EXACT DEFINIATION OF THE RECALL IS WHAT IS HAPPENING WITH MY ESCAPE. MY COMPLAINT IS THAT I THINK FORD NEEDS TO ACKNOWLEDGE MY EXCEPTION AND KNOW THAT THIS IS NOT BECAUSE THE ENGINE NEEDS TO "RE-PROGRAM" ITSELF FOR A FEW WEEKS. IT IS A RECALL AND I THINK IT NEEDS TO BE FIXED FOR FREE, LIKE IT IS SUPPOSED TO BE. I DON'T LIKE TO BE IN THE MIDDLE OF A 7 LANE HIGHWAY AND LOOSE CONTROL OF MY STEERING AND EVERYTHING WITHIN MY CAR. *JB

PULLED 2002 FORD EXPLORER INTO COVERED SPACE AT APARTMENT COMPLEX AND PROCEEDED TO PUT THE CAR INTO PARK. WHILE ATTEMPTING TO PUT THE CAR INTO THE PARK THE GEAR SHIFT BROKE OFF FROM THE STEERING COLUMN. I COULD NOT BELIEVE WHAT HAD JUST HAPPENED. EXCESSIVE FORCE WAS NOT USED AND NEVER IN MY WILDEST DREAMS DID I EVER IMAGINE THIS TYPE OF FAILURE ON A CAR. LATER I RESEARCHED THE PROBLEM ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2002 FORD EXPLORER. I CAN'T START THE CAR SINCE IT IS NOT IN PARK OR NEUTRAL. HAD TO HAVE THE CAR TOWED AND ACCORDING TO THE INTERNET THE REPLACEMENT PART IS BACK ORDERED UNTIL MID NOVEMBER. SO, FORD IS OK WITH HAVING A PRODUCT ON THE ROAD THAT I CANNOT DRIVE FOR 1.5 MONTHS BECAUSE OF A BAD PART? IT APPEARS THE BAD PART IS MADE OF ALUMINUM WHICH IS SHOCKING. WILL HAVE TO GET A RENTAL FOR THE ENTIRE TIME I AM WITHOUT THE CAR. THIS KIND OF FAILURE IS UNACCEPTABLE AND THERE SHOULD BE A RECALL ON THIS PROBLEM. *TR

2002 EXPLORER AIR BAG LIGHT STAYS LIT CAME ON AND NEVER WENT OFF WAS WONDERING IF THERE'S A RECALL TO HAVE FORD FIX THERE MISTAKE. *TR

TL*THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING ON AN UNPAVED ROAD, THE CONTACT'S HUSBAND STOPPED THE VEHICLE AND APPLIED THE PARKING BRAKE. HE THEN RELEASED THE BRAKE AND APPLIED THE ACCELERATOR PEDAL. HE NOTICED THAT THE BRAKES FELT LOOSE AND THE CONTACT EXITED THE VEHICLE. SHE DISCOVERED A PUDDLE OF BRAKE FLUID UNDERNEATH THE VEHICLE. THE VEHICLE HAS NOT BEEN TAKEN TO THE MECHANIC. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 82,063.