Ford Crown Victoria Police 2000 — Reported problems

Purchased 2 Cooper Endeavor tires July 2022 from a highly popular national retailer, 225/60-R16. The tires were installed professionally by a Ford Dealership. The first of the 2 tires developed a hazardous outer sidewall "egg" within a few weeks of installation (under 1k mi). Having no visible or known damage it was reluctantly replaced by the tire retailer under their provided Road Hazard warranty. Rolling forward to present, following documented tire rotation schedule and documented monthly tire pressure checks, the 2nd Cooper Endeavor "60k mi marketed tire" developed a hazardous outer sidewall egg 29 mo later with only 21.6k mi. driven. The new tire tread depth was 10.5/32 in. and remaining tread depth is 7/32 in. at it's greatest wear area. This 2nd sidewall egg tire was removed by a reputable tire dealership and inspected showing no visible damage to the inner or outer sidewall, tire tread or the rim bead.

I WAS DRIVING ND I DIDN'T SEE A POT HOLE SO AFTER I DROVE ACROSS IT LIKE A MILE OR MORE MY HEAD LIGHT STARTED FLICKING ND AFTER WEN I DROVE FOR LIKE 30MIN THEY TURNED OF ND IT ALSO CAUSED ALL THE LIGHT TO TURN OFF INSIDE ND OUT THE CAR

TL* THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE ORIGINAL WINDSHIELD HAD SOME CRACKS AND CHIPS, SO HE DECIDED TO HAVE THE WINDSHIELD REPLACED. THE CONTACT STATED THAT THE REPLACEMENT WINDSHIELD IMPAIRED HIS VISION WHILE DRIVING BECAUSE HE COULD NOT SEE THE ROAD CLEARLY. THE CONTACT STATED THAT THE WINDSHIELD HAD A FOGGY, HAZY SMOKE SCREEN AND WAS NOT CLEAR. THE CONTACT TOOK THE VEHICLE BACK TO THE INDEPENDENT MECHANIC WHERE THE WINDSHIELD WAS PURCHASED; HOWEVER, NO DEFECT WAS NOTICED. THE MECHANIC OFFERED TO REPLACE THE WINDSHIELD, BUT STATED THAT IT WOULD BE NO DIFFERENT THAN THE ONE THAT WAS ORIGINALLY SOLD TO HIM. THE CONTACT TOOK THE VEHICLE TO ANOTHER INDEPENDENT MECHANIC WHO STATED THAT THEY WERE FAMILIAR WITH THESE PARTICULAR FUYAO WINDSHIELDS (PRODUCT NUMBER: AS1M848 DOT-459 SOLAR TINT DW1506). THE CONTACT DROVE TO THE DISTRIBUTION WAREHOUSE AND WAS INFORMED THAT THE WINDSHIELDS WERE NOT FACTORY REPLACEMENT WINDSHIELDS, BUT WERE AFTERMARKET WINDSHIELDS. THE FORD MANUFACTURER WAS NOTIFIED AND INFORMED THAT THE CONTACT'S WINDSHIELD WAS NOT A FACTORY AUTHORIZED WINDSHIELD REPLACEMENT. THE CONTACT HAD THE REPLACEMENT WINDSHIELD FOR THREE WEEKS AND HAD VISIBILITY ISSUES EACH TIME WHILE DRIVING. THE FAILURE MILEAGE WAS UNKNOWN.

WHILE DRIVING AT VARIOUS TIMES ELECTRICAL PROBLEMS OCCUR, HEADLIGHTS WILL GO OUT ALONG WITH INSTRUMENT PANEL. SOMETIMES THE FAN ON WILL COME ON AND WILL CUT OFF EVEN WHEN IT IS OFF. WHEN TEMP IS COLD HEATER BLOWS COLD AIR. HOT OUTSIDE HEATS WORKS. AC WORKS FINE IN BOTH CLIMATES. DRIVERS SIDE WINDOW WILL NOT COME DOWN IN CERTAIN TEMPERATURES. HEADS HAVE LOW VISIBILITY AND LENS COVER GETS MOISTURE INSIDE. YOU HAVE TO DRIVE AT NIGHT WITH HIGH BEAMS TO TRY AND SEE AT ALL. SUSPENSION IS DEFINITELY A PROBLEM ON STEERING CAR HAS A SWAYING MOTION AT TIMES ESPECIALLY IN WARM WEATHER POPPING, SQUEAKY NOTICES CAN ALSO BE HEARD. VEHICLE HAS 92,000 ACTUAL MILES BUT IS BECOMING A HAZARD TO DRIVE. VEHICLE HAS BEEN INSPECTED BY A REPUTABLE REPAIR SERVICE WHO STATES SUSPENSION LOOKS GOOD, PARTS HAVE GREASE IN JOINTS, ETC AND HEATER PROBLEM EVERYTHING WAS IN SPECS. LARGE FORD DEALERSHIP 35 MILES AWAY WOULD NOT SCHEDULE AN APPOINTMENT DUE TO CAR BEING AN OLDER MODEL. IF PROBLEMS ARE NOT FOUND, AN ACCIDENT IS WAITING TO HAPPEN! NOTE : ELECTRICAL PROBLEMS HAVE BEEN ONGOING AND HAVE INCREASINGLY BECOME WORSE.

BROUGHT USED JULY 26,2017 FIRST TIME DRIVING AT NIGHT HEADLIGHTS FLASH OFF AND ON THEN GO OUT COMPLETELY WHILE DRIVING ON A MAIN HIGHWAY.FORD HAS PROBLEM WITH LIGHT MODULE TRIED GETTING VKP-31F32-Z01 RELAYS BUT MY RESEARCH FOUND DISCONTINUED 2009 I'M SCREWED BY FORD & RELAY MANUFACTURE.MAY NOT BE IN YOUR DATA BASE BUT IT'S STILL A SAFETY HAZARD & PREVIOUS OWNER SHOULD HAD THIS RESOLVED.

SEAT BELTS DON'T HAVE ELASTICITY. STEERING COLUMN STEERING FEELS LOOSE, GEAR SHIFTER FEELS SLOPPY. HAPPENS WHEN THE CAR IS STATIONARY OR IN MOTION.

WHEN DRIVING FOR ABOUT 30-45 MINUTES, ALL LIGHTS GO OFF FOR 1-2 MINUTES, FUSE GETS VERY HOT UNDER DASH.

I WAS DRIVING ACROSS THE CAUSEWAY WHEN MY CAR STARTED SHAKING. I TURNED DOWN THE RADIO AND IT SOUNDED LIKE IT BACK FIRING. I PULLED OVER AND CALLED MY MECHANIC TO MEET ME WHERE I BROKED DOWN. H IMMEDIATELY SAW THE PROBLEM BUT HE COULD NOT FIX IT. I HAD TO BRING IT TO ANOTHER SHOP TO GET IT REPAIRED. LUCKILY WHEN THIS HAPPENED I WAS GETTING OFF THE CAUSEWAY BECAUSE THAT BRIDGE IS 24 MILES LONG.

DEFECTIVE PLASTIC INTAKE MANIFOLD PRONE TO CRACKING AND LEAKING COOLANT. THIS ITEM WAS PREVIOUSLY REPORTED TO NHTSA AND FORD WAS REQUIRED TO PAY FOR REPAIRS ALREADY DONE AND TO EXTEND WARRANTY. I'M TOLD THAT WARRANTY EXPIRED FOR SOMETHING THAT A RECALL SHOULD HAVE TAKEN CARE OF. I'M TOLD THAT COST TO REPAIR IS IN EXCESS OF $1400. CONTACTED DEALER AND FORD ASKING FOR REPLACEMENT OF PART AND I WILL PAY LABOR BUT BOTH DECLINED. *TR

TL* THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTING FLICKERED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING 10 MPH AND ATTEMPTING A TURN, THE PASSENGER'S SIDE LOWER BALL JOINT FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN VERIFIED THE FAILURE AND STATED THAT IT WAS DUE TO THE BOLT JOINT NOT GETTING ENOUGH GREASE SINCE IT WAS NOT EQUIPPED WITH A GREASE FITTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000. *TR

THE RIGHT REAR (PASSENGER SIDE) OF THE VEHICLE BODY CONTINUES TO RAISE UP HIGHER THAN THE LEFT SIDE. IT IS NOW ABOUT 5 INCHES HIGHER. HAVE NOTICED THIS ON OTHER CROWN VIC CARS IN METRO AREA. SUSPECT A WEAK OR BROKEN SPRING. *TR

I WAS MAKING A RIGHT HAND TURN AT A SLOW SPEED (>10MPH) WHEN THE INTERMEDIATE STEERING SHAFT SEPARATED FROM THE LOWER STEERING SHAFT, RESULTING IN A LOSS OF STEERING. *JS

WAS STEERING INTO AN ISLE OF PARKING SPOTS WHEN SUDDENLY AND WITHOUT WARNING, THE STEERING WHEEL BEGAN TO SPIN FREELY AND EFFORTLESSLY. I IMMEDIATELY STOPPED THE CAR BECAUSE IT COULD DO NOTHING BUT GO IN THE DIRECTION THE TIRES WERE TURNED AT THE TIME OF THE STEERING FAILURE, WHICH IN MY CASE, WOULD HAVE BEEN RIGHT INTO THREE PARKED CARS. UPON INSPECTION, THE STEERING COLUMN HAD COME LOOSE FROM THE REST OF THE CAR, CAUSING A LOSS IN CONTROL AS FAR AS STEERING WAS CONCERNED. IF THIS HAD HAPPENED WHILE ON THE FREEWAY, THE RESULTS MAY HAVE BEEN CATASTROPHIC, NOT ONLY TO ME, BUT TO OTHER DRIVERS AROUND ME AS WELL. WILL TAKE IT DIRECTLY TO FORD TO SEE WHAT THEY HAVE TO SAY ABOUT THIS SITUATION. *TR

MY WIFE WAS ON HER WAY HOME FROM WORK AND SHE CALLED ME SAYING THAT SOMETHING WAS WRONG WITH THE CAR. SHE SAID IT WAS SWAYING BACK AND FORTH ON THE HIGHWAY AND WAS VERY DIFFICULT TO DRIVE. SHE MADE IT HOME AND PULLED INTO THE DRIVE WAY. WHEN SHE TURNED THE STEERING WHEEL STRAIT THE FRONT DRIVER SIDE OF THE CAR HIT THE GROUND. WHEN I GOT HOME I LOOKED AT IT AND SEEN THAT THE LOWER BALL JOINT HAD COME OUT OF THE SOCKET. I LOOKED UP MY VEHICLE ONLINE AND SEEN THAT I WASN'T THE ONLY ONE WITH THIS PROBLEM. UPON FURTHER INSPECTION OF MY CAR I NOTICED THERE IS NO GREASE PORT TO DO REGULAR GREASING OF THE PARTS. AS I LOOKED CLOSER TO THE SOCKET I SEEN THAT THE SOCKET WAS COMPLETELY DRY. NO GREASE AT ALL IN THE JOINTS. AS I INSPECTED THE PASSENGER SIDE LOWER BALL JOINT I NOTICED THAT IS VERY CLOSE TO FAILURE ALSO. I BOUGHT A NEW LOWER CONTROL ARM HOPING IT WOULD HAVE A GREASE PORT AND SURE ENOUGH IT DOESN'T. THERE IS NO WAY TO DO REGULAR MAINTENANCE ON THE JOINTS. SO THIS PART WILL HAVE TO BE REPLACED OVER AND OVER. AND IT IS NOT CHEAP. *TR

TL* THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH WHEN THE VEHICLE EXHIBITED A LOUD BANG. THE VEHICLE WAS PULLED OVER AND UPON EXAMINATION HE NOTICED THAT THE FRONT PASSENGER SIDE TIRE WAS SLANTED INWARD TOWARD THE VEHICLE. IN ADDITION, THE FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 146,013.

INTAKE MANIFOLD FAILURE, CRACKED IN REAR AT HEATER HOSE BOSS THAT RESULTED IN COOLANT LOSS. ALSO, THE #4 IGNITION COIL WAS DAMAGED BY COOLANT LEAKING ON TO IT FROM CRACKED MANIFOLD... *TR

CROWN VICTORIA 2000 HAS A CRACK INTAKE MANIFOLD RESULTING IN A LEAK COOLANT WHICH IS GOING INSIDE OF PLUG #8 CAUSING A MALFUNCTION AND CAR START SHAKING LOOSING POWER. *TR

ON 15 NOV 2009, MY CAR STARTED SPITTING AND SPUTTERING, I THOUGHT IT WAS BAD GASOLINE. ON 16 NOV 2009, I HAD MY CAR CHECKED BY MY GARAGE, WAS TOLD THAT #5 SPARK PLUG AND COIL WAS BAD DUE TO LEAKING COOLANT AT MY INTAKE MANIFOLD. AFTER CONTACTING MY LOCAL FORD DEALER THINKING I COULD JUST BUY A PART VS. A WHOLE MANIFOLD (LIKE I WAS TOLD I NEEDED), I LEARNED THAT THERE HAD BEEN A RECALL FOR THIS PROBLEM AND REPAIRS WERE COVERED BY FORD FOR ONLY 7 YEARS OF AUTO'S LIFE. WELL NATURALLY, MY CAR IS 9 YRS OLD NOW AND I'M FACING A $1100.00 REPAIR BILL. I WAS TOLD THE MANIFOLD COULD RUPTURE AT ANY TIME LEAVING ME AND MY 2 YR OLD GRANDSON STRANDED AT ANY TIME. I FEEL LIKE FORD IS HOLDING ME HOSTAGE. WITH THE SPITTING AND SPUTTERING THE CAR WAS DOING, WE COULD HAVE BEEN IN A SERIOUS ACCIDENT. I HAVE ALWAYS DRIVEN FORD/MERCURY PRODUCTS, BUT I'M NOT IMPRESSED WITH WHAT'S JUST HAPPENED. I DON'T WANT TO BE "FOUND ON ROAD DEAD" (FORD).

SPARK PLUG BLEW OUT OF THE ENGINE DUE TO WEAK THREADING IN THE CYLINDER HEAD. *TR

WHILE DRIVING AT A LOW SPEED (< 25 MPH) ON A LOCAL RURAL ROAD THAT LEADS TO MY HOUSE, I HEARD A SUDDEN SCRAPING NOISE AND HAD A DIFFICULT TIME TURNING THE VEHICLE INTO MY DRIVEWAY. UPON INSPECTION I FOUND THE FRONT PASSENGER SIDE TIE ROAD DISCONNECTED FROM THE FRONT WHEEL AND DRAGGING ON THE GROUND. UPON REPLACEMENT THE MECHANIC NOTED THE TIE ROD HAD FAILED DUE TO CORROSION AND MATERIAL LOSS. IF THIS FAILURE HAD HAPPENED AT HIGHWAY SPEED, THIS WOULD HAVE RESULTED IN LOSS OF CONTROL OF THE VEHICLE AND A SEVERE CRASH. *TR

2000 FORD CROWN VICTORIA LEAKS COOLANT FROM THE INTAKE MANIFOLD. CONSUMER WANTS TO KNOW WHY THE WARRANTY IS ONLY SEVEN YEARS FOR THIS PART. *NJ

VALVE STEM FAILURE THE STEMS WERE CRACKED ON ALL 4 TIRES MY HUSBAND HAD A BLOWOUT AND 7 DAYS LATER HE HAD A FLAT WHICH IS WHEN WE SEEN THE CRACKS. THE MANAGER OF TIRE KINGDOM KNEW OF PROBLEM WITH TR413 LOT BUT WAS NOT AWARE OF THE RECALL WHICH WE FOUND OUT ON THE INTERNET. HE IS GOING TO REPLACE THE LAST 2 STEM VALVES TOMORROW 7/26 AND WE ARE GOING TO KEEP THE OLD ONES. HE WILL NOT REIMBURSE FOR THE BLOWOUT TIRE. WE BOUGHT THE TIRES NEW 5/29/07 FROM THEM. *TR

WHEN I PLACE THE LEFT TURN SIGNAL IT BLINKS VERY FAST. THE RIGHT TURN SIGNAL DOES NOT FUNCTION LIKE THE LSIDE. I HAVE CHECK OTHER VEHICLES THAT ARE THE SAME MAKE AND MODEL AND THEY HAVE THE SAME PROBLEM. *TR

HAVE EXPERIENCE ELECTRICAL PROBLEM FOR YEARS. A BLOWER CONTINUES TO RUN EVEN WHEN THE VEHICLE IS TURNED OFF, CAUSING THE RADIO AND WINDSHIELD WIPERS NOT TO WORK PROPERLY. *TR

TL*THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. WHEN THE CONTACT DEACTIVATES THE WINDSHIELD WIPERS, THEY WILL NOT COMPLETELY RETURN TO THE OFF POSITION. THE WIPERS REMAINED UPRIGHT ON THE WINDSHIELD. THE DEFECT BEGAN SPORADICALLY, BUT NOW OCCURS WHENEVER THE WIPERS ARE ACTIVATED. THE DEALER STATED THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN ID NUMBER 00V138000 (VISIBILITY:WINDSHIELD WIPER/WASHER). THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM THE RECALL AND NOTHING COULD BE DONE. THE FAILURE AND CURRENT MILEAGES WERE 84,000.

I WENT TO START MY CAR ONE NIGHT AND THE KEY WOULD NOT FIT IN THE IGNITION. MY COUSIN HAS TRIED WORKING ON IT AND HE CAN'T EVEN GET THE OLD IGNITION SWITCH OUT OF THE CAR TO REPLACE IT WITH A NEW ONE. I HAVE BEEN OUT OF A CAR FOR A WEEK AND AFTER RESEARCHING FOUND THIS IS A COMMON PROBLEM THAT FORD HAS NOT FIXED. I FIND THIS UNACCEPTABLE. *TR

THE TREAD ON A TIRE FAILED FOR THE SECOND TIME. THE TREAD PEELED OFF AND CAUSED DAMAGE TO MY BUMPER, AIR CONDITIONER, WASHING FLUID RESVERVOIR, SPARE TIRE AND HEADLIGHT/FOGLIGHTS ON PASSENGER SIDE OF VEHICLE. *TR

MY 2000 FORD EXPEDITION CAUGHT FIRE WHILE IT WAS PARKED AND BURNED UNTIL IT WAS TOTALED. THERE WAS ALSO DAMAGE DONE TO MY HOUSE. MY FAMILY ALSO SUFFERED FROM MENTAL TRAUMA. *TR

TL*THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP TO HAVE THE BRAKES SERVICED. THE REPAIR SHOP STATED THAT THE VEHICLE HAD A RECALL AND THEY MADE THE REPAIR. HE DID NOT KNOW WHAT RECALL WAS SERVICED OR WHAT PART WAS REPLACED. THE VEHICLE WOULD NOT START AFTER A YEAR. THE VEHICLE WAS TAKEN TO ANOTHER REPAIR SHOP WHO STATED THAT THE INTAKE MANIFOLD KIT, THE IGNITION COIL AND SPARK PLUGS NEED TO BE REPLACED. THE FAILURE MILEAGE WAS 76,375. THE CURRENT MILEAGE WAS 89,113.

TL*THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. WHILE DRIVING 65 MPH, THE CRUISE CONTROL FAILED TO ACTIVATE. APPROXIMATELY ONE MONTH AGO, THE CRUISE CONTROL FAILED WHILE DRIVING DOWNHILL. THE VEHICLE HAS BEEN TAKEN TO THE DEALER APPROXIMATELY SEVEN TIMES FOR THIS FAILURE. THE CRUISE CONTROL NO LONGER WORKS. THE CURRENT MILEAGE WAS 33,000 AND FAILURE MILEAGE WAS 1,000.

VEHICLE DIED DURING TRAVEL WITH NO WARNING, FORD ISSUED RECALL. HOWEVER DUE TO THE LIMITED NUMBER OF CONSUMERS WITH THIS YEAR AND SPECIFIC MODEL COMPLAINTS WERE OVERLOOKED. DEALER SHOULD OFFER RECOURSE. *AK

2000 WINDSTAR. ABS LIGHT KEEPS COMING ON. HAVE HAD CAR LOOKED AT 4 TIMES AND TOLD "PROBLEM" (A SEAL IN THE MECHANISM) WAS REPLACED AND PROBLEM FIXED. BUT IT'S NOT - ABS LIGHT KEEPS COMING ON. EXPENSIVE TO "FIX". ALSO, BRAKE FLUID LEAKS AND HAVE HAD TIMES WHEN DRIVING AND BRAKE PEDAL GOES ALL THE WAY TO FLOOR WITHOUT WARNING AND DELAYED STOPPING. LUCKILY HAVE NOT HAD ACCIDENTS WHEN THIS HAS HAPPENED. HAVE ALSO HAD BRAKE PADS WEAR OUT - NO PRE-WARNING ON THIS MODEL WINDSTAR WHEN BRAKE PADS ARE WEARING OUT. HAD TO HAVE BRAKE PADS REPLACED, AND ROTORS REPLACED - AGAIN AND EXPENSIVE FIX TO A PROBLEM WITHOUT WARNING. ALSO, BRAKES KEEP SQUEALING WHEN BRAKES APPLIED - AM TOLD THIS IS AIR IN THE LINES (HAVE BEEN TOLD THAT LINES FLUSHED BUT PROBLEM STILL KEEPS HAPPENING). ALSO, WHEN STEERING AFTER THE LAST TIME ABS LIGHT PROBLEM "FIXED" THERE IS A GRATING STEERING NOISE WHENEVER WHEEL IS TURNED. WARRANTY HAS RUN OUT - BUT PROBLEM WITH ABS STILL EXISTS AND I CAN'T AFFORD ANOTHER $700. BILL TO "FIX" PROBLEM. 2000 WINDSTAR SHOULD BE RECALLED FOR THIS ABS PROBLEM AND IT SHOULD BE FIXED FREE OF CHARGE BY FORD. AM VERY DISAPPOINTED AND FRUSTRATED WITH THIS PROBLEM - AND FEEL THAT I AND MY CHILD ARE DRIVING IN AN UNSAFE VEHICLE.

I WAS OPERATING MY VEHICLE ON ROUTE 10 IN PRINCE GEORGE COUNTY. THERE IS NO LIGHT ON THIS ROAD. I WAS HAVING A DIFFICULT SEEING. THE HIGH BEAM SEEMED TO NOT ILLUMINATE THE ROAD SUFFICIENTLY. THE LOW BEAMS WERE GOOD FOR CLOSE UP BUT NOT FAR AWAY. I PULLED THE HIGH BEAM SWITCH BACK TO HIGH BEAM (FLASH HIGH) AND HELD IT SO I COULD SEE BETTER. AS I WAS GOING THROUGH AN "S" CURVE THE ENTIRE ELECTRICAL SYSTEM ON THE CAR SHUT DOWN. I IMMEDIATELY LET GO OF THE CONTROL AND HIT THE BRAKES. I LOST ALL POWER TO THE CAR. I CAN'T REMEMBER IF THE MOTOR CUT OFF OR NOT. I ALMOST WRECKED THE CAR. AFTER A SECOND OR TWO POWER CAME BACK ON. I WAS IN THE ONCOMING LANE OF TRAFFIC WITH NO LIGHTS AND THEN THEY CAME BACK ON. THIS IS AN EXTREMELY DANGEROUS FUNCTION OF THE VEHICLE AND COULD EASILY RESULT IN DEATHS. I WANTED YOU TO BE AWARE OF THIS. I HAVE NEVER DONE THIS AGAIN DUE TO THE RESULTS OF THAT INCIDENT. THE DATE ON THIS INCIDENT IS AN ESTIMATE. I HAVE NO IDEA WHEN THIS HAPPENED. JUST KNOW IT WAS LAST YEAR. *TR

TL*THE CONTACT OWNS A 2000 FORD FOCUS. THE VEHICLE'S RIGHT WHEEL MADE A LOUD NOISE AND VIBRATED WHILE IN MOTION. THERE WERE NO WARNING INDICATORS. THE WHEEL IS CURRENTLY WOBBLING AND MAKING A POPPING AND CRACKING NOISE. THE MECHANIC HAS NOT YET DIAGNOSED THE CAUSE OF FAILURE. SAFETY CAMPAIGN # 01I017000(WHEELS:LUGS/NUTS/BOLTS) INVOLVES THE SAME FAILURE, HOWEVER, THE CAMPAIGN EXPIRED ON DECEMBER 31, 2002. THE MANUFACTURER IS NOT WILLING TO PERFORM THE REPAIR FOR FREE. THE VIN IS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 153,000.

AFTER CAR WAS DRIVEN TO WORK APPROXIMATELY 5 MILES. MY EMPLOYERS SECURITY DEPARTMENT NOTIFIED ME THAT MY CAR HAD CAUGHT ON FIRE, WHILE PARKED ABOUT AN HOUR AND A HALF AFTER ARRIVING TO WORK. FIRE DEPARTMENT WAS CALLED AND PUT OUT FIRE, AND IT RELEASED A REPORT STATING FIRE DEFINATELY STARTED IN UNDER THE THE HOOD IN ENGINE AREA.*AK

FORD 2000 EXPITITION CAUGHT ON FIRE AND WAS TOTALLY DESTROYED AND OCCURED IN MY DRIVEWAY AROUND 7AM AND THE VEHICLE WAS NOT ON AND THE LAST TIME USED AROUND 10:30 PM THE PREVIOUS NIGHT. *NM

#8 SPARK PLUG POPPED OUT OF HEAD CAUSING THE THREADS TO STRIP IN HEAD & BUSTED COIL PACK. CONVERTER WAS GLOWING RED & POPPING. *NM

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE HESITATED AND SPUTTERED BADLY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THAT THERE WAS A CRACK IN THE MANIFOLD, AND THAT THE NUMBER 4 HEATER COIL HAD FAILED.

DT*: THE CONTACT STATED AN INDEPENDENT SERVICE MECHANIC FOUND A MILKY SUBSTANCE IN THE RADIATOR COOLANT RESERVOIR INDICATING A PROBLEM WITH THE INTAKE MANIFOLD. THE ENGINE TEMPERATURE WAS RUNNING HIGH AS WELL. A SERVICE DEALER OFFERED TO CHECK FOR LEAKS, BUT INFORMED THE CONTACT THE WARRANTY HAD EXPIRED.