Chevrolet Traverse 2020 — Problemas reportados

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving 30 MPH through an intersection with a green traffic light, the transmission unexpectedly stopped functioning, and the vehicle failed to move. The contact stated that the hazard lights were activated while the vehicle was in traffic. The vehicle was towed to a service center, where the failure was addressed; however, the vehicle was not diagnosed or repaired. The failure mileage was approximately 157,000.

The contact owns a 2020 Chevrolet Traverse. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured flex pipe. The mechanic informed the contact that the failure was associated with GM Technical Service Bulletin: PIP 5681C and Manufacturer Communication Number: 10211780 (Engine and Engine Cooling), and the contact was referred to the dealer. The vehicle was taken to the dealer, who confirmed the failure was not covered under warranty. The contact spoke with the manufacturer, who also confirmed that the vehicle was not covered under warranty. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was approximately 104,000.

Shift to park message error. Have to start/ stop engine several times until message goes away

Noticed rattling under front hood and exhaust entering the interior of the car. Brought to the dealer and they said there are no recalls on this problem and quoted 4K to replace the CAT and exhaust pipes. There is indeed a tsb document covering Chevy Traverse years 2018-2023 - PIP5681C failed bracket weld on the exhaust pipe causes cracks. This is a dangerous situation with exhaust entering the vehicle. I have 4 children that travel in that vehicle daily! Based on what I have read online, this is an existing problem happening frequently with Chevy Traverses. I would like this repair covered by GM. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was on the interstate trying to merge into traffic and I floored the gas pedal to get into position with the flow of traffic. Upon pushing the gas pedal to its full position the pedal snapped off and I lost my ability to accelerate. I was lucky enough to be able to pull off to the side of the interstate and into the grass. I placed the Traverse into neutral and came to a stop. The gas pedal snapped just above the tab that sticks out where it connects to the module. Very unsafe that this is even a possibility to have happened. I would not recommend plastic for the gas pedal. Thank God the brake pedal is metal.

The contact owns a 2020 Chevrolet Traverse. The contact stated that the exhaust system was sagging due to an improperly welded mounting bracket. The contact became aware that an exhaust system bolt was cracked and missing. The vehicle was taken to the dealer, where a technician confirmed that the weld on the exhaust hanger had separated from the subframe, causing the loud rattling sound of the exhaust system. Additionally, the check engine warning light was frequently illuminated, and the exhaust system was louder than normal. The failure mileage was 82,000.

My 2020 Chevrolet Traverse is experiencing a SHIFT to PARK issue. When the car is placed into PARK, the electrical system does not recognize it and will not shut off the vehicle. There is a defect with the button trigger that allows the gear shifter to move and it is not being recognized. The quick fix is to press this button around 15 times to reset it. Sometimes this works but when on an incline, it does not. It takes turning the vehicle on and off a few times to have this registered. The estimated cost to replace the gear shifter is around $600 to $900 dollars. Please have this item recalled.

The rear power liftgate closed on my finger severing the top part of my finger at the base of the finger nail.

On September 18,2026 owner #3 bought the vehicle on December 9,2026 at the time of purchase it had 46,545 on September 17 check engine light came on and the diagnostic code came up as P0171 lean bank one from Pep Boys.Pep Boys scan found P0171 lean bank 1 meaning that is sucking in too much oxygen, upon inspection found rear exhaust manifold is cracked, creating a vacuum and suck. ng in oxygen,causing the engine light, the exhaust hanger is broken and pictures from PepBoys show the exhaust hanger is broken and was held by poxy putty from previous owner #2 this was not disclosed at the time of sale on December 9,2026 and CarMax failed to complete a 125 inspection before it left the dealership lot.The Poxy putty caused the manifold to crack with catalytic converter and 2 O2 sensors. Further another serious concerns owner #3 has as reported on history from Good Car reported from other consumers owning 2020 Chevy Traverse is the Shift to Park issue which was discovered on August 5,2026 at Affordable Transmission in Lancaster when i got my transmission service. This is also another pre-existing condition that was not disclosed by CarMax at the time of sale on December 9,2025. I feel the car is defective and not safe. The vehicle is at my mechanic getting evaluated. Per Car Facts this vehicle was involved in a minor accident which was not disclosed.

While the gears are shifted to park, as soon as the car is turned off, a message pops up advising me to "Shift to Park". The car will already be in park. I have to with jiggle the gear shift or turn the car back on and cycle gears a couple times in order for the car to recognize that it's in park.

My Autostop feature failed to work and did not restart my car on 2 occasions. 1) My kids and I was a stop sign at an intersection and the car would not turn back on. I had my truck towed. The next business day they told me it started on it own. 2) I was dropping my kids off at camp out of town and came to a red light. My truck would not restart. I was in the middle of the street. The police has to push me to safety until the tow truck driver arrived. After towing my truck 100 miles to the dealer near my home it started back up. The next day the dealer mis informed me that it was a programming that was coming up. I had to pay that fee plus diagnostics. When going out to test my truck the dealer experience the same issue. A severity case had to be opened to determine the solution to fix the issue. It took about 4 days. This issue is very concerning as I and my children safety was at risk while driving. I asked about turning the feature off but was told it's a state emissions law to have it on so they could not help me.

The front intermediate exhaust pipe mounting bracket weld fractured at the engine manifold, causing the exhaust pipe to break completely loose. We can now actively smell raw exhaust fumes inside the passenger cabin while operating the vehicle, creating an immediate safety hazard for carbon monoxide poisoning and driver disorientation. Additionally, the heavy steel exhaust system is completely unsupported at the front, creating an imminent risk of the pipe falling and dragging on the roadway at highway speeds, which could cause a catastrophic crash. The vehicle began getting progressively louder during cold weather between late 2025 and early 2026. A certified Chevrolet dealership technician officially inspected the vehicle, filmed an inspection video confirming this exact structural failure, and attempted to submit it for warranty coverage. GM Corporate denied the claim solely because my VIN is excluded from Special Coverage N212356540, despite the vehicle suffering from the identical manufacturing defect described in the bulletin. I possess the official dealer repair receipt and the technician's inspection video as proof.

I am filing a complaint regarding a persistent safety defect widely known as the "Shift to Park" issue. For over a year, my 2020 Chevrolet Traverse, VIN [XXX] has repeatedly displayed a "Shift to Park" warning message on the instrument cluster when the vehicle is placed in Park and the engine shutoff button is pressed. This occurs multiple times weekly. Despite the vehicle physically being in Park, the internal shifter sensor fails to recognize the gear position. This defect prevents the vehicle from shutting down properly, leaving the electrical system active and causing severe battery drain. Furthermore, because the vehicle does not recognize it is in Park, it creates a roll away risk if the driver exits assuming the vehicle is fully secured. General Motors is aware of this widespread component failure across this vehicle platform but refuses to issue a safety recall or cover the repair costs out of warranty. This is a systemic manufacturing defect that presents a clear financial and safety hazard to consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Bracket on the exhaust pipes just before the flex pipes broke free and there is now a hole in the pipe.

I made an error and incorrectly submitted an issue under the wrong vehicle, with NHTSA Safety Issue ID 11759404. This is the same submission under the correct vehicle and VIN. Issue ID 11759404 can be merged here or canceled.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. The contact stated that over time the sound became louder. The vehicle was taken to the dealer, where it was diagnosed with a cracked front exhaust pipe and battery failure. The contact was informed that the front exhaust pipe and battery needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 84,701.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while operating the vehicle, there was a loud sound coming from the exhaust pipes, and the vehicle failed to properly accelerate, with exhaust fumes inside the vehicle. The vehicle was taken to the local dealer, who diagnosed that the exhaust mounting bracket had failed, causing the exhaust pipes to separate and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact was informed that the vehicle was not covered under a manufacturer-extended coverage that was associated with the failure. The failure mileage was 50,000.

Loses oil between oil changes. No visible signs of leaks or odor of burning oil.

The contact owns a 2020 Chevrolet Traverse. The contact stated that the transmission was slipping and there was a delay while the transmission was shifting gears. The vehicle was sputtering and jerking while driving. While turning out of a driveway and driving approximately 5 MPH, the vehicle stalled. The check engine warning light was illuminated. The vehicle was towed to the residence. The local dealer was contacted and informed that there was no recall on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted but referred the owner back to the local dealer for assistance. There was no additional assistance provided. The failure mileage was approximately 150,970.

I own a 2020 Chevy Traverse with currently 16,000 miles. I am currently dealing with a know shudder issue that has returned. I have already taken the vehicle under warranty to the dealership where the transmission was replaced on 6/29/2022 at 4919 miles for “catastrophic failure” where the fluids were dark, burnt, and several burnt up clutches. Then the torque converter was replaced separately on 9/20/2022 at 8106 miles for engine shudder. Took the vehicle again in on 7/21/26 for shudder returning at 16,450k miles where diagnostic shows dark, burnt fluid, with metal debri. Repair recommendations are to flush again and if not fixed to again replace the torque converter. There are no open recalls on my vehicle when there should. There is the most recent bulletin, Bulletin No.: 23-NA-072 dated May 2023 that covers the 2020 Chevy Traverse for TCC Shudder: (Typically seen on 4th-5th Upshift as ISS Oscillation) which is referenced on my last car diagnostic report. This car is basically brand new and should never have needed a brand new transmission, torque converter replacement and still having shudder problems. These vehicles need to be recalled for their power train.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while parking the vehicle, the gear shifter was shifted into park(P); however, the “Shift to Park” message was displayed. The contact shifted the gear shifter back and forth and then shifted into park(P) before the proper gear was recognized. The vehicle was taken to the dealer, who replaced the gear shifter. The manufacturer was made aware of the failure. The failure mileage was 26,818.

GM published bulletin PIP5681A on 10/05/20 regarding defective welds on the exhaust brackets near the catalytic converter. I had the same exact weld failure and GM is not honoring the warranty coverage, even though their bulletin said that all 2020 Traverse SUVs were included.

There is a well known exhaust issue with the catalytic converter and the separating manifold and no recall has been issue yet. It causes the vehicle to lose pressure and shuts off in the middle of traffic. The seat belt secure locks are malfunctioning and could cause loss of life in the event of an accident.

I own a 2020 Chevy Traverse with currently 16,000 miles. I am currently dealing with a know shudder issue that has returned. I have already taken the vehicle under warranty to the dealership where the transmission was replaced on 6/29/2022 at 4919 miles then the torque converter was replaced separately on 9/20/2022 at 8106 miles for engine shudder. This vehicle is practically brand new. I reached out to GM with no help other than to pay to have it diagnosed again at the dealership. There are no open recalls on my vehicle when there should. There is the most recent bulletin, Bulletin No.: 23-NA-072 dated May 2023 that covers the 2020 Chevy Traverse for TCC Shudder: (Typically seen on 4th-5th Upshift as ISS Oscillation) This car is brand new and should never have needed a brand new transmission, torque converter replacement and still having the exact same problems as before.

The welds that hold the catalytic converter and exhaust pipe together have pinhole leaks. The hose that connects to the exhaust system is also failing. This has been confirmed by the Chevy dealership we took it too. No warning lights were triggered. We heard a rattling noise after having a prior hose replaced. One week later we were back at the same dealership. At this appointment they discovered the pinhole leaks and confirmed there are pinhole leaks while revving the engine to 1,000 RPMs. We requested GM pay to fix the issue and they have refused. Our safety is at risk because no sensors were triggered and we could smell exhaust fumes in the vehicle while using the air conditioning. This is not the first issue we had with this vehicle. Prior to this the whole car died while my wife was driving it with our 2 kids in the car with her. She had no steering or braking.

Getting error message on and off last several weeks - "Shift into park" which does not allow the ignition to be turned off!! The only way to resolve this issue is to jiggle the gear shift or restart the car, changing gears and trying again. Sometimes it works on the second or third try! Frustrating!!! What is it doing to the shift assembly? Have called local dealer they will diagnose and repair at my cost! In the neighborhood of $250.00 for diagnostic, which will be applied to the total repair costs. No idea what that bill will be. General Motors just advises if it needs repair save my receipts in the event of recall for reimbursement. The car only has 21,600 miles!! I have seen other complaints on line and there are videos on You Tube on how to repair this issue, obviously I'm not the only one this is happening to. The gear shift boot and console have to be removed to repair. If the above actions do not work, how do you shut the ignition off??? Just let the car run until it's out of gas??? Not what I would classify as safe! General Motors should be taking steps to rectify this problem immediately but since they have not had "enough" complaints to warrant investigating further they are sitting idly by! HELP!

This is a know issue on 2021 models. The exhaust bracket is breaking away from the muffler/catalytic converter. The weld is breaking causing the exhaust to break away and both pipes must be replaced resulting in a 1500 repair. Why if it bad in later years is there no maintenance bulletin or mandatory fix for the 2020 models? It was repaired and fixed by McClusky Chevrolet in Cincinnati OH.

Flex pipe for exhaust is broken at 61000 miles rattles and makes noise upon start up and acceleration.doesnt make sense repairs for model years before and after 2020 are being repaired for free

While driving the stereo went off, the ac, the car stopped in middle of the road and I lost all electrical. I tried turning back on and the emergency brake light was on and the dash said "Steering Assist is Reduced, Drive with Care.” I was able to put it in neutral and get it out of the way. Battery is good Fuses were all checked 350 replaced Car isn’t starting or Turing over, but some of the lights have turned on.

Brakes have screeching noise Transmission jumps when changing gear The shift to park is so constant can not even go out because it takes more than 20 to 30 tries for it to accept park and turn Vehicle off! I have taken it to the dealer for the concern stated no recall or warranty At this point I am afraid to even leave it in shift to park and walk to the store and it gets stolen or leaves me stranded with my children

I have 37,000 miles and have taken it to a Chevrolet dealer for all suggested routine maintenance. It started shuddering so I took in to dealer. They said known issue and may need a new torque converter which would cost approximately $8500. They suggested I try changing the transmission fluid even though suggested at 45,000 miles. They said to drive 200 miles and see if it goes away. I haven't yet put 200 miles but am very concerned there is a bigger issue with the Traverses out there and afraid this is a band-aid and feel a recall may be inevitable. Just wanted to share with you.

2020 Chevrolet Traverse started to shudder and hard shift between 25 to 30 miles per hour. Vehicle only has 64,925 miles on it (4,925 miles above warranty). Vehicle was taken to garage and told the torque converter along with valve body was needed to be replaced. The torque converter malfunctioned right after warranty expired due to mileage and could have left my family stranded on the side of the road. The components have been inspected by Chevrolet manufacturer and they deemed they needed to be replaced and replaced them. No lights or anything came on the only sign was the shudder and hard shift which if not taken in immediately could put the owner past the warranty mileage. Vehicle was purchased brand new and routine maintenance conducted.

We have had multiple issues with the exhaust system and the brackets that hold the catalytic converter in place. The catalytic converters have been replaced two times in the last 3 years with them currently needing to be replaced AGAIN. This is supposed to be our family car and it is in no way reliable. Not when we have to take it in every couple thousand miles on it to have the exhaust system repaired. We have had it into the dealership multiple times to confirm the problems.

Bracket fell off of the exhaust pipe on my 2020 Chevrolet Traverse LT, which in turn cracked the exhaust pipe, making my car create this loud noise every time the car was accelerating.

The contact owns a 2020 Chevrolet Traverse. The contact stated that upon starting the vehicle, the exhaust system made an abnormally loud sound. There was no warning light illuminated. The vehicle was taken to an unknown dealer, where it was determined that the front clamp on the exhaust system was loose. The dealer tightened the clamp; however, the failure persisted. The contact related the failure to TSB Number: PIP5681A (Exhaust leak, Lean Codes, Rattle Noise, or Catalytic Converter Failures). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 68,000.

Issue documented in PIP5681C

2020 Chevy Traverse High Country Exhaust bank 1 and bank 2. Transmission shudder.

Failing front exhaust pipe mounting bracket. GM has a special coverage program (N212356540) for 2019-2020 Chevrolet Traverse which covers the repair for 15 years or 150,000 miles from the original service date. The coverage is VIN specific. My vehicle has been having this issue for two years now and my VIN is not covered. This is unfair to the consumer/Chevrolet owners who's VIN's are not listed. This is an obvious ongoing problem for many Chevrolet Traverse owners, it should be an active recall on all 2018-2023 Chevrolet Traverse owners. Especially since Chevrolet/GM is aware of the problem. Most of us are paying off our vehicles because we can't afford a new one and GM is not providing assistance for some of us who at no fault of our own are having to pay for a defect they are aware of.

Active GM coverage on exhaust falling off, does not include all vins affected. My car is affected by this exact issue reported and refusal to fix or repair issue, because vin “not included” (n212356540) is gm special coverage for exhaust falling off that isn’t including all vehicles affected

The exhaust has a leak. Loud noise, rattling coming from exhaust. Smell of fumes in the cab of the vehicle. I believe there is a recall for 2018,2019,and 2021 year models for this same issue but no recall for the 2020 model.

A MANUFACTURER RECALL NOTICE NEEDS TO BE ISSUED ASAP. Exhaust is leaking into passenger cab due to a defective exhaust mounting bracket. Was replaced 1 year ago at the dealer at considerable cost to vehicle owner. Now this defective part has failed a second time. A MANUFACTURER RECALL NOTICE NEEDS TO BE ISSUED ASAP. This presents a health hazard as well as financial loss due to defective manufacturing. Other years of this particular vehicle have been recalled and this defective part was repaired/replaced it is supected to replaced with the same defective OEM part due to its repeated failure. It is unclear why this model year has been discriminated against. A MANUFACTURER RECALL NOTICE NEEDS TO BE ISSUED ASAP.

ELECTRIC DOOR LOCK OF FRONT PASSENGER DOOR DOES NOT UNLOCK DOOR. PLUNGER TRIES TO MOVE UP WHEN ENERGIZED BUT STAYS IN LOCKED POSITION. DOOR DESIGN DOES NOT INCLUDE MECHANICAL KEY UNLOCK OVERRIDE. A FIRST RESPONDER WOULD NEED NEEDLE NOSE PLIERS TO LIFT UP THE DOOR LOCK STEM. THIS FAILURE PUTS ANY PASSENGER AT RISK OF DELAYED EXIT. THE LEFT REAR PASSENGER DOOR HAD THIS FAILURE MAY 2024, NO PRIOR SYMPTOMS. THE DRIVER DOOR HAD THIS FAILURE A FEW MONTHS LATER. EACH REPAIR COSTS OVER 700, DEALER IS AWARE OF THESE FAILURES. NO WARNINGS OF THIS FAILURE VISIBLE. NO INSPECTIONS MADE OTHER THAN DEALER

2020 Chevrolet Traverse vehicles may experience a loud, rumbling exhaust leak caused by a failing front exhaust pipe bracket weld, frequently noted in complaints. While special coverage exists for other model years, 2020 owners are experiencing similar issues, with some reports suggesting it may not be covered under the same official, extended recall. My vehicle is experiencing the same issues that the 2019, 2021, and 2022 model are experiencing why is my 2020 and other owners of a 2020 year skipped to be covered for this identical problem.