Chevrolet Suburban 2023 — Reported problems

While driving, the digital driver/instrument display behind the steering wheel went completely black, but the engine continued running and the radio remained on. The vehicle was stopped, turned off and restarted and the display screen came back on. This didn't effect the drivability of the vehicle. In some of the research I've found the cause might be an instrument-cluster software problem or an "Instrument Cluster Missing Graphics Processor". The recommended remedy would be to replace the instrument cluster. There is also one instance where the dealer reportedly determined that the instrument panel control module needed to be reset versus repaired which would not permanently resolve the issue.

The contact owns a 2023 Chevrolet Suburban. While the contact’s husband was driving 70-75 MPH and depressing the accelerator pedal, the vehicle failed to respond, but the RPMs became elevated. The driver shifted transmission into neutral(N), coasted to the side of the road, and the vehicle stalled. A message to “Start Vehicle” was displayed; however, while on the side of the road, the vehicle failed to turn off. The driver was able to shift into park(P) and had the vehicle towed to the dealer, where the transmission failed to shift out of park(P). The dealer determined that a spark plug was burned. The spark plug was replaced; however, before returning the vehicle, the new spark plug was also burned. The dealer then diagnosed the vehicle with engine failur. The dealer informed the manufacturer of the safety issue. The failure mileage was approximately 42,600.

Dear Chevrolet Customer Assistance, I am writing to formally report a serious safety incident involving my 2023 Chevrolet Suburban and to request an investigation by General Motors. My vehicle unexpectedly locked while the key fob was still inside the vehicle. Most concerning, my baby was also inside the vehicle at the time. I was unable to regain access to the Suburban, and because my baby was trapped inside, I had no reasonable option but to break a window to gain immediate access to her. This was an extremely serious and frightening situation. My primary concern is understanding how a 2023 Chevrolet Suburban equipped with a keyless entry system was able to lock while the key fob remained inside the vehicle. I am requesting that Chevrolet/General Motors: 1. Open a formal safety case regarding this incident. 2. Investigate why the vehicle locked despite the key fob being inside. 3. Have the vehicle’s keyless entry, passive locking system, key-detection components, software, and related systems inspected for a malfunction. 4. Determine whether there are any applicable recalls, technical service bulletins, software updates, or previously reported incidents involving similar circumstances. 5. Reimburse me for the cost of the broken window and related repairs, as the window had to be broken solely because immediate emergency access to my baby was necessary. I do not want this incident documented simply as a customer accidentally locking keys inside a vehicle. The key fob was inside the Suburban when the vehicle locked, and an infant was trapped inside as a result. I am asking that this be documented and investigated specifically as a potential vehicle safety or key-detection system issue. I can provide my VIN, photographs of the damage, repair invoices, key fob information, dealership inspection records, and any other documentation necessary for your investigation. Please provide me with a GM case number and written confirmation that this incident has been form

Engine locked up, need engine replaced. We already satisfied the recall with the 0w-40 oil update.

The vehicle experienced an initial incident of significant engine power loss while traveling at highway speeds approximately two weeks prior to the eventual complete engine failure. During that incident, the vehicle unexpectedly lost engine power while traveling at speeds exceeding 65 mph. On Thursday, September 3, 2026, a second incident occurred within approximately one-half mile of leaving my residence. The vehicle again experienced a significant loss of engine power. I had already notified the dealership of the this occurrence and had a scheduled appointment for repairs the following day. I was attempting to drive the vehicle to the dealership as planned. Shortly after leaving my neighborhood, I stopped at a nearby gas station after the vehicle displayed a "Low Oil Pressure" warning on the dashboard. I also subsequently received an email notification from OnStar identifying diagnostic trouble code (DTC) P0016. The vehicle was then driven again and subsequently experienced a catastrophic and complete loss of engine power while traveling at highway speeds above 65 mph. Following this failure, the engine would not turn over or crank and the vehicle could not be restarted. The sequence of events is significant because the vehicle had previously experienced engine power loss at highway speeds, the dealership had been notified of the initial incident, and the vehicle was being driven to the dealership for its scheduled repair appointment when the second power-loss event occurred. The vehicle subsequently suffered complete engine failure. I am documenting these events, including the dates, circumstances, dashboard warning, OnStar diagnostic notification, and sequence of failures, for purposes of establishing the history of the vehicle's mechanical problem and the circumstances leading to the catastrophic engine failure.

Complete engine failure on 2023 Chevrolet Suburban 6.2L. On October 31, 2024 while on the interstate. The truck shut off twice with no warning. I was able to make it to the side of the interstate twice to restart. The truck was taken to Serpentini Chevrolet and they stated no issues were found and send the vehicle back on the road. On December 13,2024 while on a state route, speed limit 55, 12,231 miles the Suburban abruptly slowed down and violently started to shake and knock. I pulled off to the side of the state route and waited approx 2 hours for the vehicle to be towed. The vehicle was towed to Serpentini Chevrolet and they stated the engine was blown and needed replaced. The vehicle was at the dealership until February 13, 2025 when the engine was replaced. The recall was released in April 2025 at which time the vehicle was taken in for the oil change “repair”. The truck now has 20,200 miles and is lacking power and starting to shake when accelerating from 0-50mph. I will be scheduling additional service in the coming week. While going through the blown engine, GM stopped responding to emails, did not compensate for months of payments I incurred while they had the vehicle and they are still selling unsafe vehicle.

The contact owns a 2023 Chevrolet Suburban. The contact stated that while entering a parking lot at a low speed, the engine shut off without warning. The vehicle was towed to a dealer, where it was diagnosed with engine failure, which was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle remained at the dealer for approximately three months before the engine was repaired. The contact stated that while driving recently, the vehicle hesitated upon depressing the accelerator pedal. No warning light illuminated. The dealer and the manufacturer were not notified of the recent failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 50,000.

After having the proper recall performed. The engine locked up while driving on interstate. Total loss of power in heavy traffic nearly causing an accident.

My 2023 Chevrolet Suburban equipped with the 3.0L Duramax diesel engine (LM2) has experienced a recurring engine oil leak involving the rear main seal/lower timing cover area. The vehicle has required repeated dealer repairs for substantially the same oil-leak condition, including major engine-related disassembly, but the leak has returned after repair. This is a safety concern because failure of the rear main seal or lower timing cover sealing system can result in loss of engine oil while the vehicle is being operated. A significant oil loss could potentially cause loss of oil pressure, engine damage or engine failure and resulting loss of propulsion while driving. Leaking engine oil also has the potential to contact hot engine or exhaust components, creating an additional safety concern. The problem has been inspected and confirmed by authorized GM dealerships and documented on multiple repair orders. This does not appear to be an isolated occurrence on this vehicle because substantially the same engine oil leak has required repair more than once. GM has previously issued service information, including Bulletin PIP5795, concerning rear main oil leaks on 3.0L LM2 Duramax engines where the rear main oil seal may move or become severely shifted out of position in the timing chain lower cover. I am concerned that repeated repair of this condition may not adequately address the underlying cause and that the oil leak could recur while the vehicle is being driven. I am requesting that NHTSA review complaints and repair data involving rear main seal/lower timing cover oil leaks on GM 3.0L Duramax-equipped vehicles to determine whether a broader safety-related defect exists.

Car died in middle of nowhere at high speeds

The contact owns a 2023 Chevrolet Suburban. The contact stated that the vehicle had experienced excessive oil consumption. The contact stated that while driving at various speeds, the vehicle chugged, jerked, and lunged forward. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer, where the spark plugs were replaced; however, the failure persisted. The dealer was notified of the failure and advised the contact that the spark plugs might need to be replaced. The contact stated that while driving and coming to a stop, the vehicle chugged, lunged forward, made an abnormal clicking sound, and almost struck another vehicle. The check engine warning light illuminated. The OnStar mobile APP displayed the messages "Engine and Transmission System - Please Schedule Service Now," "Transmission System Issue - Please Schedule Service Now," and "VVT Issue detected - Please Schedule Service Now". The contact was able to pull into a parking lot. The vehicle was taken to the dealer, where it was diagnosed with engine lifter failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 63,000.

6.2 V8 while operating threw multiple error codes, went into crawl mode unexpectedly.

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, the transmission erroneously shifted to neutral(N), and the vehicle decelerated unexpectedly. The vehicle was pulled off the freeway and parked on the shoulder of the road, and the police were contacted and arrived at the scene and assisted with removing the small children from the vehicle. The vehicle was later towed to a nearby towing lot. The contact later received messages on the App for transmission and engine failures. The cause of the failures was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The contact stated that the vehicle was previously serviced under the NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); even though the vehicle had experienced the failure listed in the recall. The failure mileage was 25,300.

The contact owns a 2023 Chevrolet Suburban. The contact stated that the front passenger’s and rear driver’s side rims were cracked. The front passenger’s side rim was replaced by the dealer under warranty, while the rear driver’s side rim was replaced with an aftermarket part. The manufacturer was notified of the failures but declined assistance. The owner expressed concerns that the remaining factory rims might also crack and were prone to failure while driving. The failure mileage was approximately 100,000.

I brought my Chevrolet Suburban High Country in to the dealer pursuant to a recall for engine issues due to a manufacturing defect in connecting rods and crankshafts that can cause catastrophic engine failure. The service center changed the oil viscosity and fill cap and stated that the change should eliminate the issue. I have had persistent engine knocking upon acceleration since then and it is getting louder and more prominent. A suspension warning intermittently flashes as well. Please advise, thank you

We purchased a 2023 Chevy Suburban in January of 2026. In May the vehicle shut off on me at a stop light. The check engine light flashed after I was able to restart it. I took it to the dealer and they said they "couldn't recreate the issue" even though there was an engine misfire code on all cylinders. They told me to come pick it up and bring it back if I had further issues. The second time this happened I had issues getting the vehicle started. This was June 2026 Once I finally got it started and was driving all the service lights started going off and the check engine light started flashing. I took it to a different chevy dealer and was told the same thing. This time I had 23 different service codes that showed up. Including the engine misfire code. So we picked it up and continued to drive it. On July 10th we were towing a 7k lb camper home when we lost all power. Thankfully we weren't driving fast and we're able to stop. This left us stranded at a busy intersection for 2 hours. The car would not go out of neutral. Had we been going 70 on an interstate we could have very seriously been hurt. The car had to be towed back to the dealership where we were told the engine locked up and needed to be replaced. My husband and I had our [XXX] child in the backseat with us. This was a family car that we purchased and told twice that they couldn't find anything wrong with it. The vehicle has been at the dealership waiting on a motor since July 11th. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The fuel pump module on this vechicle failed, and there's a recall for 2021 I believe other years should be considered as well since this was a known issue as soon as we arrived at the dealership and they wanted over $400 to replace this part which is only $45.

My vehicle was met with an accident on June 28, 2026. The accident was very swear and driver get internal injuries like swelling on face pain in head and ribs due to the heavy shock. But non of the airbag has been activated for safety of driver.

The sunroof drains continue to fail. I’ve had multiple occasions where the car has had drains back up or be disconnected.. This is a safety issue because it creates mold as water falls in the headliner and then the cabin. It also creates rust, particularly behind the dashboard. That’s not rust proof. Despite being under warranty, the dealers are useless and helping address the issue because it’s la design flaw. The multiple water intrusions also affect the electronics in the vehicle., potentially disabling critical features like airbags and safety systems.

The engine of this car has been under recall for multiple issues during the time we have owned it. The most recent issue that was experienced was total engine failure and electrical malfunction while driving on a busy street near train tracks. The vehicle was making a loud banging sound moments before this occurred. I wasn't even given time to get to a safe spot to investigate the issue. When it shut down, a quick message flashed across the dash board--stating ability to shift had been lost (or something to that effect)--the vehicle then flipped into neutral and immediately lost power. My safety was put at great risk due to the fact that the entire vehicle shut down moments after I crossed over a very busy railway track. The vehicle had to be towed to a nearby Chevrolet dealership where it has been confirmed there was total engine failure as well as blown main electrical fuse.

My 2023 Chevrolet Suburban Premier is covered under GM recall 25V-274 for the 6.2L L87 engine defect (loss of propulsion from connecting rod and crankshaft failure). In XXX, the dealer notified me my vehicle required a full engine replacement under this recall. Wareing Sheridan Chevrolet in [XXX] replaced the engine, and the vehicle was out of service approximately 12 to 14 days. Approximately 6,000 miles later, on XXX, the replacement engine failed while I was driving on the interstate highway near Billings, Montana. There were no warning indicators of any kind until I suddenly lost power. Only at the moment power was lost did the check engine light come on and a low oil pressure warning appear. I was barely able to get the vehicle off the interstate before it died. I had my family in the vehicle, and losing power on the interstate with no warning created a serious risk of a crash. The vehicle had to be towed to Denny Menholt Chevrolet in Billings, MT. On June 13, 2026, the dealer confirmed the vehicle needs a second complete engine replacement under the same recall. This is the second L87 engine failure and second full engine replacement on this vehicle under recall 25V-274. No crash or injuries occurred. I have an open case with GM (#XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to turn and exhibited resistance, with no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering wheel had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000.

The vehicle was shaking and shuddering when trying to maintain highway speeds. Would have to slow down to maintain safety. The dealership advised the transmission needs replaced however we are seeing this is a widespread problem that GM has refused to admit fault for.

Transmission malfunction. This has appeared several times at highway speeds and low speeds. Driver to limp along in the slow lane to exit ramp and take back roads to get back to base. The current problem has been confirmed with error codes P0747. Check engine light comes on with a screen prompt “Reduced Acceleration Drive with Care”.

With out any warning engine shake and running roughly Loud engine noise more than ticking and losing power with reduce speed

The engine siezed up due to the issues that are related to the recall. Currently waiting for a new engine, it has been almost 5 weeks and no time frame on when it will be fixed.

After performing all preventative, regular, and even proactive maintenance, the vehicle started shaking and shutting down with 2 miles. We are now being told (by 3 separate mechanics) that it needs an entirely new engine.

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the messages “Coolant Control Valve” and “Acceleration Reduced – Stop Vehicle” were displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the coolant control valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 104,849.

While driving on interstate XXX on 4/17/2026 my vehicle lost power I had to pull over on the shoulder thankfully I was able to do so. Restarted the vehicle for just a short bit and it said loss of engine oil pressure and died. would not restart. Ultimately had to be towed to a GM dealership Lynch Chevrolet in [XXX] . Was told the engine was shot and was covered under the safety recall. There was a recall on the motor I had brought it in to get rectified sept 2025.a heavier weight oil was added and filler cap replaced with 40 weight oil identification. . I just had an oil change the day before the incident on 4/16. What is concerning I'm worried about the long wait plus plus online blogs that indicate the engine failed numerous times even after replacement. I was told from the dealership that the engine was on back order and they cannot give me a time on when it's going to be available. But again I'm worried about this vehicle in general in moving forward or trying to anyway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle mileage is approximately 45,000 miles. While driving in the rain the front windshield wipers stopped moving and were stuck in the down position. They would not activated with auto, manual, or wash commands. Rear wiper still functioned. This happened while driving down the interstate which resulted in having to slow my speed in heavy traffic and go out of driver position to see through a clear spot in the windshield, took exit 1 mile later and tried to find gas station, approximately 1 mile after exiting the wipers started to work again. This also happened at approximately 35,000 miles on the vehicle and the wipers did not work for multiple days, even with vehicle turned off for 12 hr period. Took to dealership and by that time they were working again and the dealership could not find anything wrong. Both instances happened on weekends so could not take directly to dealership while issue was present.

The sound in the vehicle goes silent and I'm not able to verify audibly that my turn signals are working or not. Which has led to a couple of near misses while in traffic. Power has been cycled and the call hang up botton has been depressed to soft reset the system and it still isn't working.

The contact owns a 2023 Chevrolet Suburban. The contact stated that the engine and oil warning lights were displayed. The vehicle was taken to the local dealer, and the vehicle was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 100,000.

Car entertainment screen shot down, next day car completely dead, had to get a booster, now the engine sign is on, and car has only 33,000 miles on it

I purchased a 2023 Suburban on March 6, 2026 with 52,980 miles. I drove it home to my house and parked it. On March 7, 2026 about 6pm, I started the vehicle and heard a loud engine noise. I called the dealership and let them know about the noise. On March 9, 2026 I towed it back to the dealership. The vehicle has been in service since then and was told it needs an engine. Metal spun threw the engine block and has to replaced. I just purchased this vehicle and drove it one day.

Sun roof exploded while driving. Temps were not extreme, there were no significant pressure changes. Sun roof had no prior damage. Looking online multiple people reported the sun roof exploding on 2023 tahoes and suburbans.

Regarding a catastrophic engine failure involving my 2023 Chevrolet Suburban equipped with the 6.2L L87 engine. There is an active GM service bulletin that we never received from either Crabtree or GM. Vehicle details: • Purchased in North Carolina in 2024 • Approximately 4,000 miles at purchase (used, still under factory warranty) • Currently at approximately 60,000 miles • Within the 5yr/60k powertrain warranty at the time of failure Incident details: On Friday 2/20, the engine experienced a confirmed catastrophic failure while my wife was driving on the interstate at highway speed. The vehicle abruptly lost power, creating a significant safety hazard. She was able to maneuver to safety, but the situation presented a serious risk of injury. GM has since towed the vehicle and confirmed catastrophic engine failure. We have been provided a rental vehicle - not a comparable one either (they refuse to address that also). Given the safety exposure and warranty status, I am evaluating potential potential claims including breach of warranty, implied warranty of merchantability, and any product liability considerations. I am also interested in understanding leverage for buyback, diminished value, risk of serious injury to my wife, or extended warranty resolution. I have preserved documentation, service records, and a written account of the incident.

The drivers side, female end, of the seatbelt comes undone when cold. This is reproduced every single time it is cold for approximately 5 minutes of driving until the inside of the vehicle warms up. This happens with both primary divers of the vehicle. We took it to the dealership we bought it from but because there is not a current recall and they cannot reproduce the issue since our current temperature is in the 40s, they won’t replace it under warranty. No warning systems go on when this happens while driving.

Transmission, got a message stating the service transmission or won’t be able to shift. Took it in to the dealership was advised that car can shut down at any moment. As that what they have been seeing.

Sun Roof has leaked. The Sun roof leaked a considerable amount of water and it came through the head liner around the ceiling mounted control panel as well as the back of the car. This is the second time it has happened and I have been told it is not covered under warranty. Through online blogs and forums I have found that this is a common issue with 2021 and newer tahoes and suburbans. And that is a reoccurring problem that is commonly not fixed properly by the dealers This causes a safety and health issue as well as an unacceptable vehicle defect. 1.) From a safety standpoint, if I am driving down the highway and a large amount of water starts pouring out of the headliner on the driver it causes a major distraction that could lead to high speed accident. 2.) From a health issue, regular water leaks could lead to vehicle mold and water damage. I have children, if they become susceptible to the mold it could cause health issues for me or my children. 3.) The water that pours out of the ceiling lands on the dash electronics which could lead to more vehicle issues by damaging electronic controls. It is my opinion that this is a major vehicle defect and something should be done by the manufacturer to correct it. I have made a complaint to the Chevy Customer service under reference #890 780 85

Engine rattles and noisy, now auto light and message board states "Add Engine Oil)