Chevrolet Silverado 2002 — Reported problems

my truck won't pick up speed when trying to accelerate. I don't know what it is. I know it's a problem and it's a hazard and accident waiting to happen!!!! Please, fix. I have had nothing but, issues with this Chevy Silverado.

The emergency brake does not work properly. It automatically comes on while I am driving almost causing me to have a accident. Please, fix!!!!

I was driving today and my truck started making a strange noise(like something was loose). I stop the truck to see what was loose, I found nothing. I got back in the truck driving about 20 mph the truck started making the noise again and the truck started dragging( like it wouldn't go faster). I then stop and pulled in a church parking lot where the truck was not drivable. I was told by a concern passerby( mechanic, which happen to be) it's has something to do with the rest axle. The truck gave me no warning whatever. I was told I could have had a major accident and I had NO!!! warning. Please, fix. I have nothing but, issues with this truck.

I pulled the truck out of the garage in working condition, left it running while parked in the driveway. It emptied the entire brake fluid reservoir through a leak in the distribution junction on the rear axle, leaving the truck with no brake function whatsoever. Had I not parked the truck in the driveway, I would have been involved in a serious collision due to sudden complete brake failure.

ABS kicks in constantly at low speeds in dry conditions. This causes longer stopping distances. The ABS grinds or vibrates interfering with normal braking situations. Many near miss collisions at low speeds. The manufacturer should be responsible and replace all the ABS sensors. I purchased this truck brand new in 2002.

The contact owns a 2002 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the contact heard a loud cracking sound coming from the vehicle. The contact noticed the loud cracking sound while driving over a pothole in the road. The vehicle was driven to the residence. The contact completed a thorough inspection of the vehicle and noticed a fracture behind the cab of the vehicle. In addition, the contact noticed corrosion of the undercarriage of the vehicle. The contact stated that the corrosion extended from the front passenger’s side to the rear of the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 250,000.

Had a front end collision going 65 miles per hour. Air bag never deployed

ABS sensors I think are bad cuz my brake pedal fluctuates and hasn't done that in a long time it went away no dash lights for the ABS but it's definitely coming from the brake pedal?

rocker panels rusted out

THE THROTTLE CABLE MAKES CONTACT AND RUB THROUGH THE FLEXIBLE PRESSURIZED FUEL LINE CREATING A PINHOLE LEAK OF NATURAL GAS. I SMELL GAS INSiDE CAB. CAUSES CHECK ENGINE LIGHT TO COME ON

The contact owns a 2002 Chevrolet Silverado 1500. The contact stated while driving 5-10 MPH, the airbag warning light illuminated. The independent mechanic was made aware of the failure and referred the contact to the dealer for diagnosis. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 143,725.

While driving on US60 East of Lexington Kentucky I was preparing to turn left using the left turn lane. There was another car in front of mine and as I approached it I began to lightly apply the brakes. The brake pedal went all the way to the floor with no decrease in speed. Fortunately I was able to switch back to the through lane and avoid an accident. While I was able to avoid an accident there was definitely a risk of injury to myself and the occupants of the other vehicle. When I was able to inspect the vehicle I found that the brakeline adjacent to the fuel tank was rusted through which caused a complete brake failure. I do the vehicle maintenance personally and have since made necessary repairs to the brake system. I was aware of problems with the brakelines on this vintage truck being prone to failure due to rusting. As I was making repairs it was obvious the routing of the brakelines was such as to making the rusting more likely to happen.

HARD BRAKE LINE FAILURE DUE TO CORROSION FROM POOR QUALITY PARTS WITHOUT PROPER CORROSION PROTECTION OR CORRECT MATERIALS (I.E. STAINLESS STEEL VS MILD STEEL) WHEN VEHICLE IS USED IN AREAS WHERE DE-ICER IS USED ON THE ROADS.

THE ABS LIGHT CAME ON AND THE BRAKE LIGHT. THE POWER STEERING IS BAD AND THE STEERING WHEEL SHAKES WHEN I BRAKE, I GOT THE BRAKES AND ROTORS CHANGED AND THE PROBLEM PERSISTED

KNOWN TO GM INJECTOR PROBLEMS WITH CHEVY SILVERADO VEHICLES. MY INJECTOR CRACKED OR FAILED AND DIESEL WENT IN TO MY ENGINE OIL, CAUSING AN OVER FILL OF 2 GALLONS. OIL WAS LEAKING OUT ALL OVER FROM MY TRUCK WHILE I WAS DRIVING. THERE ARE MANY OTHER POST ABOUT THIS PROBLEM AND GM IS AWARE BUT HASN'T ISSUED A RECALL.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT ANOTHER VEHICLE IN FRONT WAS MAKING A LEFT, THE DRIVER SLAMMED ON THE BRAKE PEDAL BUT THE LATCH FAILED CAUSING THE PASSENGER TO GO THROUGH THE WINDSHIELD DURING THE IMPACT. THE DRIVER PROCEEDED TO HIT A THIRD VEHICLE THAT WAS AT A STOP SIGN. THE OTHER DRIVER WAS FOUND AT FAULT BY THE POLICE. THE FRONT PASSENGER SEAT BELT LATCH FAILED TO RESTRAIN AND CAUSED THE FRONT PASSENGER INJURIES AT THE FACE, ARM, AND LEFT WRIST. THE FRONT PASSENGER AIR BAG FAILED TO FULLY DEPLOY AND CAUSED THE PASSENGERS HEAD HIT THE WINDSHIELD. THE DRIVER SUFFERED INJURIES TO THE STOMACH. MEDICAL ATTENTION WAS PROVIDED TO BOTH INJURED. THE POLICE DEPARTMENT WAS PRESENT AND A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO WANTED TO ADD THAT TSB SEAT 10-08-50-003B DESCRIBES THE SEAT BELT FAILURE. THE VEHICLE WAS TOWED TO THE DRIVER'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

MY ABS SPEED SENSOR GOT SHEARED BY BACK OF MY FRONT DRIVERS SIDE TIRE IN WHICH I HAVE SEEN ON MULTIPLE SIGHTS A DEFECT THAT WAS DEEMED A RECALL FOR BEING POORLY SET UP ON THE ASSEMBLY LINE. SECONDLY, IVE SPENT THOUSANDS AND LOOKING ONLINE FOR A VARY SERIOUS ISSUE IVE BEEN HAVING WITH MY VEHICLE DUE TO INTERMEDIATE STALLING, BACKFIRING, AND VEHICLE DIEING DUE TO WHAT HAS FINALLY BEEN FOUND TO BE THE INFAMOUS CRANKSHAFT SENSOR. REPLACED MY COMPUTER, ALL 02 SENSORS, EGR VALVE EXC... THAN UPON LOOKING AND RESEARCHING, I FIND IT WAS A MAJOR ONE ON RECALL AS WELL FOR FAILING ALL THE TIME. I JUST FEEL IF THESE ARE FACTORY ERRORS AND BEEN ON THE RECALL, AND MY WOMAN WHO TRAVELS WITH ME THAT IS PARALYZED DUE TO AN ACCIDENT, I SHOULD BE ENTITILED TO THE RECALLS GIVING THEY WERE KNOWN FLAWS ON THE ASSSEMBLY LINE AND A DANGER TO OTHERS. WHEN THE VEHICLE STALLS OUT, IT STARTS CHOKING, BACKFIRING, AND BUCKING AND WANTS TO LOCK UP AND LOOSE CONTROL. NOT COOL. IVE BEEN CHASING THIS PROBLEM SPENDING THOUSANDS IN PARTS AND REPAIRS TO MAKE THIS TRUCK SAFE FOR WORK AND FEEL IF THERE HAS BEEN RECALLS FOR ALL THIS, WOULD BE NICE TO REAP SOMETHING OUT OF MY INVESTMENT IN THIS TRUCK

VIBRATION IN VEHICLE PRIOR TO TIRE BLOW OUT ON FREEWAY TRAVELING APPROXIMATELY 70 MPH.. APPEARS TO BE A TREAD SEPARATION TYPE FAILURE. TIRES ARE BF GOODRICH ALL TERRAIN TA KO BAZ WITH APPROXIMATELY 27000 MILES ON THEM. SIZE IS LT265/75R16. TIRES WERE ROTATED AND CHECKED FOR PROPER INFLATION BY PROFESSIONAL TIRE SHOP APPROXIMATELY 4 DAYS PRIOR TO FAILURE.

DRIVING UP TO CITY INTERSECTION WAS APPLING BRAKES, CAR IN FRONT APPLIED HIS QUICKER CAUSING HIS REAR TO RAISE UP, INDICATING PANIC STOP, I FOLLOWED AND APPLIED HARD PRESSURE TO MY BRAKES, PEDAL THEN WENT TO THE FLOOR AND LOST ALL BRAKE ACTION, THIS LEAD TO MY TRUCK REAR END OF OTHER CARS

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE ABS SYSTEM ACTIVATED AND THE VEHICLE LOST MOTIVE POWER. THERE WAS NO WARNING LIGHTS ILLUMINATED. A DEALER WAS NOT CONTACTED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

ABS SYSTEM WILL ACTIVATE WHEN APPLYING BRAKES WITHOUT CAUSE SUCH AS A WET SURFACE

HARD BREAK LINES ARE FULLY CORRODED AND NEED FULL REPLACEMENT AFTER A BREAK LINE FAILURE. LOW MILEAGE VEHICLE, CURRENTLY 65K, VEHICLE HAS BEEN IN MILD CLIMATE OF NC AND SC SINCE 2002 WHERE SNOW AND SALT IS INFREQUENT. NEVER DRIVEN IN COASTAL AREA. ONLY RECENTLY DRIVEN ACROSS COUNTRY, WHERE FAILURE OCCURRED. THANKFULLY AT SLOW SPEEDS.

USING THE KEY THE IGNITION TURNS ON AND TRUCK STARTS AS IT SHOULD, ANYTIME THE KEY THEN COULD BE TAKEN OUT OF THE IGNITION AT ANYTIME. IGNITION CAN BE CLICKED BACK TO ACCESSORY AND THE KEY CAN FALL OUT WHEN DRIVING. NOTE CHANGING FROM RUN TO ACCESSORY IT EASILY DONE.

TL* THE CONTACT OWNED A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE IGNITION SWITCH WAS LOOSE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE CONTACT STATED THAT WHILE HER DAUGHTER WAS DRIVING APPROXIMATELY 65 MPH, SHE RAN OFF THE ROAD AND CRASHED INTO A TREE. THE VEHICLE CAUGHT FIRE. THE DRIVER SUSTAINED BURNS AND INJURIES TO HER RIBS, STERNUM, AND PELVIC. THE INJURIES WERE FATAL. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DEEMED DESTROYED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. *TR *BF*JB*DT MEDICAL RECORD XXXXXXXXXXXX CERTIFICATION OF TITLE NO XXXXXXXXXXXX ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

BRAKE LINES STARTED LEAKING BRAKE FLUID OUT OF NOWHERE. BECAUSE OF THIS, THE BRAKE PETAL SUDDENLY STOPPED WORKING AND COULD HAVE RESULTED IN DEATH. I WAS DRIVING AT ABOUT 30 MPH ON A CITY STREET WHEN I DISCOVERED THIS ISSUE. HAD I HAVE BEEN DRIVING AT A HIGHER SPEED I MAY NOT BE HERE TO COMPLAIN. RUSTED BRAKE LINES IS THE PROBLEM WITH THIS ISSUE.

ABS KICKS IN AT LOW SPEED

WHEN WE BOUGHT TRUCK I CHECKED VIN AND ONLY THE TAILGATE RECALL CAME UP BUT LISTED MY TRUCK BEING A CHEVY 800 MODEL, WELL COUPLE WEEKS AGO OUR TRUCK WOULDN'T BRAKE WHILE PARKING MAKING A LEFT INTO A RESTAURANT AND THE TRUCK WOULDN'T STOP AND HIT THE RESTAURANT WINDOW!!! WHEN I CHECKED JUST OUR EXACT VEHICLE 15 PLUS RECALLS CAME UP WITH THIS PARTICULAR DEFECT LISTED, PLEASE HELP ADVISE. THANK THE PARKERD

WHILE SLOWING DOWN COMING TO A STOP - NO BRAKES. CHECKED EVERYTHING. SUSPECT POWER BOOSTER. THIS STARTED SLOWLY ABOUT THREE WEEKS AGO. TODAY IT ACTUALLY WOULD NOT STOP AND I ALMOST HIT THE FIRE HYDRANT.

BRAKE LINES RUSTED THROUGH TO POINT OF FAILURE

MY BRAKE LINES ON MY SILVERADO HAVE BEEN REPLACED 5 DIFFERENT LINES IN 4 YEARS THE TRUCK HAS 90,000 MILES ON IT AND IN THE LAST MONTH 3 TIMES IVE LOST BRAKES THE GUY WHO FIXES MY BRAKE LINES TELLS ME THE LINES ARE RUSTED OUT EACH TIME THIS HAPPENS, HE TOLD ME HE CANT TELL BY SIGHT WHEN THEY WILL FAIL CAUSE THEY LOOK OK BUT THAT'S NOT THE CASE, I'VE READ THIS IS A ISSUE WITH THESE VEHICLE'S IVE BEEN LUCKY SO FAR (KNOCK ON WOOD) BUT THE COST AND THE STRESS OF HAVING YOUR BRAKES FAIL IS UNACCEPTABLE SEEING THE LINES ARE NOT UP TO NORMAL STANDARDS, SOMEONE SHOULD BE HELD RESPONSIBLE FOR THIS ISSUE

SEATBELTS DOES NOT CATCH AND WILL NOT RECOIL. STARTED OUT AS LOOSE NOW IT WILL NOT RETRACT. STARTED WHEN I APPLIED THE BRAKES WHEN A DOG RAN IN FRONT OF ME AND SEATBELTS DID NOT CATCH AND MY CHEST HIT THE STEERING WHEEL. THE SEATBELTS DID NOT RETRACT AFTER IT PULL OUT. I WAS TRAVELING 55 MPH WHEN THE DOG CROSSED THE HIGHWAY.

IN JULY OF 2018, MY 2002 CHEVROLET SILVERADO HAD MAJOR BRAKE FAILURE AS I WAS DRIVING ABOUT 35 MPH APPROACHING A RED LIGHT. I PRESSED ON THE BRAKES, IT WENT TOTALLY TO THE FLOOR AND I WAS UNABLE TO STOP, BLOWING RIGHT THROUGH RED LIGHT. MY MECHANIC TOLD ME THE MY BRAKE LINE RUSTED THROUGH, AND ALL THE BRAKES LINES, AS WELL AS THE FUEL LINE IS TOTALLY RUSTED. I WAS TOLD THAT THIS IS VERY COMMON IN THIS CHEVROLET / GM MODEL ERA. HE SAID IF ALL HE WERE TO DO IS REPLACE BRAKE LINES IN THIS 1999 TO 2006 ERA, IT WAS ENOUGH TO KEEP HIS BUSINESS BOOMING. WHAT SHOCKING STRUCK ME IS THAT HE TOLD ME THEY ALL FAIL UNDER THE DRIVERS SIDE DOOR, ALONG THE FRAME, BEFORE THE ABS MODULE. THIS IS DEFINITELY A SAFETY HAZARD THAT SHOULD BE ADDRESSED. MYSELF, AS WELL AS OTHERS COULD OF BEEN KILLED WHEN I WAS UNABLE TO STOP AT THE RED LIGHT. JOHN D. NORRISTOWN, PA.

THERE IS A MAJOR SAFETY DESIGN FLAW IN THE 1999-2002 BRAKE SYSTEM. THE FRONT TIRES THROUGH THE SALT AND GRIME FROM THE ROADS ONTO THE BRAKE LINES WHERE CHEVROLET HAS LOCATED THEM IN THE DESIGN. THIS CAUSES THE BRAKE LINES TO CORRODE AND BURST DURING DRIVING. MINE HAVE NOW BURST FOR THE SECOND TIME IN THE LAST 5 YEARS. THE FIRST TIME IN 2013 I WAS DRIVING AT ABOUT 35-40 MPH WHEN I WENT TO MAKE A RH TURN AND THE BRAKES WENT TO THE FLOOR. THIS TIME I HAD WENT TO A LOCAL GAS STATION AND WAS ON THE WAY HOME WHEN I STOPPED TO TALK TO A NEIGHBOR AND ONCE AGAIN THE BRAKE PEDAL WENT TO THE FLOOR. I DRIVE THE TRUCK VERY LITTLE SO I HAVE ONLY PUT JUST OVER 17,000 MILES ON THE NEW SET OF BRAKE LINES THAT I HAD INSTALLED BY A CHEVROLET DEALER IN 2013. I LIVE IN SOUTHERN INDIANA, JUST NORTH OF LOUISVILLE, KY SO OUR WINTERS ARE NOT THAT HARSH, SO THE AMOUNT OF SALT FROM ROADS IS PRETTY LIMITED. I HAVE TALKED WITH OTHER CHEVROLET SILVERADO, YUKON AND SUBURBAN OWNERS AND THEY ALL SHARE HAVING THE SAME ISSUES WITH THEIR BRAKE LINES. I HAVE WENT TO YOUTUBE TO SEE HOW TO MAKE THE REPAIRS MYSELF AND HAVE SEEN COUNTLESS VIDEOS ON INDIVIDUALS REPAIRING THEIR BRAKES BECAUSE OF THE CORROSION AND THE BRAKE LINES BURSTING. COME ON NHTSB WHAT ARE YOU WAITING ON BEFORE YOU ISSUE A RECALL, SOMEONE TO DIE OR BE PERMANENTLY DISABLED! DO THE RIGHT THING AND ISSUE A RECALL TO FIX THE BRAKES WITH STAINLESS STEEL LINES, ROTORS, CALIPERS AND BRAKE PADS THAT WILL NOT RUST AFTER A FEW YEARS!

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 2500. WHILE DRIVING 25 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT NOTICED A LEAK COMING FROM THE BRAKE LINE AND RUST. THE CONTACT DID NOT ENGAGE THE EMERGENCY BRAKE. THE CONTACT WAS UNSURE IF ANY WARNING INDICATORS WERE ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE RECURRED, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 75,000.

I FIRST OF ALL ABOUT A YEAR AGO AND NOTICED 2ND GEAR HAS GONE OUT IN IT SINCE I VERY RARELY WENT IN THE REVERSE IT DIDN'T NOTICE THAT TELL HER I WAS IN A PREDICAMENT AND HAD TO PUSH IT OUT AND NOW IT'S STUCK IN FIRST GEAR

WHILE DRIVING, THE ENGINE WILL SUDDENLY SHUT DOWN AND WITHOUT WARNING STOP.

THE UNDERCARRIAGE. THE ROCKER ARMS THE BRAKE LINES ARE AND HAVE BEEN RUSTED OUT. ITS A RUSTED OUT FRAME. THIS NEEDS TO BE HANDLED AND RECALLED TO ALL GM OWNERS . THIS IS A COSTLY TIME CONSUMING MATTER FOR INDIVIDUALS TO HANDLE. GM SHOULD STEP UP TO THE PLATE AND HANDLE THESE ISSUES. KARMA HOPE U DONT NEED BAILING OUT AGAIN I BET THIS ISSUE ALONE AND GM NOT HELPING BY DOING RIGHT THING WILL CAUSE TREMENDOUS HURT TO U IM SURE YOUVE LIST AKOT OF BUSUNESS FROM THIS.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500 HD. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THERE WAS SEVERE CORROSION TO THE BRAKE AND FUEL LINES. THE VEHICLE WAS REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,000.

I WAS DRIVING AT LOW SPEED ON A STREET THAT IS 25MH AS I BREAK TO STOP AT THE STOP SIGN MY ABS ACTIVATED. ALMOST CAUSED ME A SERIOUS ACCIDENT BECAUSE I COULDN'T STOP SO I HAD TO BREAK SO HARD MY BUT WAS ACTUALLY OFF OF THE SEAT. AND THIS CONTINUES TO HAPPEN SO NOW I HAVE TO TAKE THE ABS FUSE OUT TO DEACTIVATE MY ABS.

TAKATA RECALL - HAVE BEEN STRANDED NUMEROUS TIMES AS IT HAS APPEARED TO BE THE FUEL PUMP NOT GETTING GAS TO START THE CAR. SOMETIME CAN HEAR PUMP RUNNING AS I HAVE REPLACE 3-4 PUMPS SINCE 2012 OR 13. SOME TIME BEATING UNDER TANK HELPS. THERE SEEM TO BE NUMEROUS COMPLAINTS ABOUT THIS PROBLEM. SECURITY LIGHT FLASHING AND START SOMETIME WHEN IT IS RESET. SOUNDS WONDERFUL WHEN IT RUNS. CAN IT BE THE COMPUTER? TOWED TO A SAFE LOCATION AFTER NOT STARTING AND DIAGNOSTIC TECHNICIAN SHOW 10% FUEL PRESSURE. I PARKED WENT IN TO MAKE A PAYMENT AT A BUSINESS AND WOULD NOT START FOR 4 DAYS