Chevrolet Malibu 2012 — Reported problems

See attached document for complaint.

Car has 161,848 miles and the seat frame broke on the drivers side of my 2012 Chevy Malibu. It had a slight tilt to the right. It was taken to the Chevrolet Dealership and they inspected and verified that the frame welding was broken. I have a video from the service tech showing the broken frame. I took a screen shot of the video and attached it to this incident repot. I would be happy to share the video but it won't allow me to share on this page. I asked the dealership if there was any recall because I find it hard to believe that a seat frame would just break. I have gone online and read that multiple people have had this issue however, Chevrolet has done nothing about it. A few people have at least gotten somewhat of a compensation for having to replace something that should last the life of the vehicle. I was not one of them. I had to pay over a thousand dollars for a USED frame and labor. What is to keep this frame from cracking too? I think Chevrolet should do better.

Electrical system problems that create unsafe driving conditions!! Vehicle has electrical glitches. Internal warning lights flicker on and off. Battery drains. Car randomly will not start. Multiple incidents. Car stalled on roadway without warning and would not crank. Luckily I was in a residential neighborhood with little to no traffic when this happened. I have had crank sensors replaced, fuel pump module replaced, fuses replaced and still problems occur. If this is a common issue with the 2012 Chevrolet Malibu, could you please issue a safety recall? Thank you

Rear defrost stopped working. Hasn't worked in years. I took it to GM, they had a print out of a kit that I had to purchase to repair. This stopped working back around 2016.

My airbag warning light and notification have came on and sometimes seat belt lights come on unexpectedly and will not go off I feel like this is a safety issue

On March 4, 2026, my wife was driving the vehicle when she suddenly lost power steering. The steering wheel became extremely difficult to turn, creating a dangerous situation that could have resulted in serious injury. She was able to safely pull over and contact me. I carefully drove the vehicle home. The vehicle was taken to Jeff Wyler Chevrolet of Columbus for diagnosis and repair. The dealership confirmed that the problem involved the power steering system. The repair cost was 1,513.03. After researching the issue, I discovered that this 2012 Malibu is subject to a special coverage related to the steering torque sensor. General Motors had reportedly sent notification letters to owners, but we never received one. Had we been aware, we would have addressed the issue immediately. This defect represents a significant safety risk, as sudden loss of power steering could cause an accident or serious injury.

i was driving and the steering wheel locked, the whole steering column has to be replaced it brought up a code saying torque input sensor i've only put 10,000 miles on this car and have only had it for 11 months

I have tried since July of 2025 to have a recall fixed I have been in contact with multiple dealerships for Chevy and none have contacted me to fix my recall I've left messages and still no response

Was driving home on the parkway and the headlights shut off on their own had to call for roadside assistance to get my vehicle home they will work on dim but brights will not work and if I drive for more than an hour and a half they will not work at all the speed sensor keeps going bad after having it replaced multiple times

The “service ESC” light came on while I was driving on the freeway causing the steering wheel to lock up and I couldn’t turn the wheel. It was really stiff after it said “Service ESC” and “ESC Off”

The contact owns a 2012 Chevrolet Malibu. The contact stated that the power steering warning light was illuminated, and the message "ESC OFF" was displayed. The contact stated that the vehicle experienced an intermittent loss of power steering while driving. The contact stated that upon restarting the vehicle, the vehicle operated as intended; however, the failure initially became a persistent failure upon restarting the vehicle and then became a permanent failure. The contact stated that upon taking the vehicle to an independent mechanic for a tire replacement, the contact was also informed that the steering failure was related to Chevrolet Special Coverage Number: 15356. The contact was referred to the dealer, who informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 111,000.

The brake caplier screw came out why driving the vehicle and broke the brake line and the vehicle lost control try to use the emergency brake and it didn't work vehicle crash

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle briefly lost motive power and came to a complete stop. The vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that the ESC warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering wheel angle sensor. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 140,000.

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving approximately 60 MPH and following a slight right turn on the highway, the ESC warning illuminated, and the vehicle slowed down without the brake pedal being depressed. The failure was intermittent but became a recurring failure. The contact stated that the vehicle also slowed down unintentionally while making a left or right turn at slow speeds. The contact stated that in the middle of the turn, the vehicle slowed to a stop without the brake pedal being depressed. The ESC warning light illuminated while the vehicle was still in drive(D) and running. The vehicle came to a stop, and the accelerator pedal was depressed, and the vehicle continued driving. The vehicle was taken to a local dealer and was diagnosed with PSCM failure. The vehicle was repaired; however, the failure reoccurred. The vehicle was not taken back to the dealer. The contact researched online and related the failure to NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control (ESC). The manufacturer was not informed of the failure. The failure mileage was approximately 166,000.

Passenger side headlamp burned out took off bumper to inspect and the wiring pigtail to the headlight has melted causing it to malfunction so now in order to make it work you have to disconnect the daytime running lights so that the melting stops this is supposedly happened to a lot of Malibu's why there isn't a recall on this fire hazard is beyond me and it is a safety issue cuz you can't use your daytime running lights any longer. This issue has not been reported because upon investigation it's been reported many times and nothing gets done about it you have to pay for it yourself. This will be the last GM product.

Rear windowed defroster suddenly start working upon inspection the rear electrical block that's inside the trunk had melted in the fuse to the defroster had gotten stuck and went on pulling it out it broke and after looking up complaints it seems to be an issue with Malibu and it could cause a fire but GM is doing nothing about it you have to pay for it yourself they released a bulletin to bypass the block but you have to install a whole new block which costs hundreds of dollars

The problem started with the steering wheel jerking by itself then the power steering went out. The only way to get power steering back is to turn the car off then turn it back on while turning the steering wheel manually then it’s hard to say how long you have power steering for. To get it fixed is around 1,500 for a 3 hour job.

The contact owns a 2012 Chevrolet Malibu. The contact received notifications of NHTSA Campaign Numbers: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC) and 15V269000 ( SEAT BELTS); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at 50 MPH, the steering wheel vibrated and seized. The "ESC" and “Traction Control" warning lights were illuminated. The contact used a scanner and diagnosed the vehicle with steering failure. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue and wanted to charge the contact for the parts. The manufacturer was not made aware of the issue. The failure mileage was approximately 107,000. Parts distribution disconnect.

The power steering assist has cause the steering wheel to move to its let by its self when not holding the steering wheel. I must hold the steering wheel firmly to keep it strait when driving. If i would let go the car will abruptly turn left and possibly drive off the road or hit a car, pedestrian, or whatever is in the way. It started with uncontrolled vibrating at a stand still motion. The car is 165,000 miles that's 15,000 miles from the recall. The car has been repaired a couple times I think only to have the same power steering assist internal parts break down and fail multiple times. I believe the amount of power (amps) the power steering assist draws is needed is to much and the system fails within a short time. The alternative hydraulic version on the V 6 doesn't put so much stress on the electrical system. This could be also why the headlights bulb sockets melt and why I see a 15 volt constant charge is being created from the charging system. Ruining the alternator and battery. Putting high levels of amps on the wiring. Leading to malfunctioning components that is filed for complaints. A major safety hazard for others. Fires and uncontrolled crash since the power steering assist moves the car into dangerous life threating crashes.

Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is burnt out on bott sides. but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibus and needs a recall initiated to correct these issues. I keep getting pulled over due to need to us high beams and not having low beams. This is reoccurring and getting expensive to be done over and over.

Loss of power steering assist while driving. Safety issue puts driver and others at risk. Problem confirmed to be known by dealer service bulletin 15356. Special coverage has expired however many vehicles with issue still on the road. ESC light accompanies failure, restarting the vehicle resets system and allows function for short period until loss of steering while moving occurs again. Request GM extend the special coverage to all vehicles still in service or recall.

The contact owns a 2012 Chevrolet Malibu. The contact stated that while his son was driving at an undisclosed speed, he became aware that the electronic power steering assist was not functioning properly, requiring an increased effort to maneuver the vehicle. The service power steering warning light was illuminated. The vehicle was taken to the dealer, who diagnosed failures with the power steering control module and power steering torque sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 15356; however, the vehicle had previously been repaired in 2019 and again in 2020, under the special coverage program. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 130,000.

The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at 40 MPH the traction warning illuminated. The contact stated that the ABS and the traction control were disabled. The contact stated that the failure was occurring at any speed. Additionally, the contact stated that the brake lights were randomly illuminating when he depressed the brake pedal. The contact stated that he had to depress the brake pedal with force for the brake lights to illuminate. The contact had taken the vehicle to an independent mechanic was diagnosed and determined that the vehicle needed to have all four brake pads and rotors replaced and two front tires replaced. The vehicle was repaired, however, the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 103,000.

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at 55 MPH, the temperature gauge began to indicate the vehicle was overheating after which the vehicle lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine and air bag warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the oil pan gasket; resulting in damage to the engine, and ABS control module resulting in the air bag warning light. The contact was informed that the engine would need to be replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who again diagnosed a failure with the oil pan gasket. The vehicle was repaired, but again the failure occurred for the third time. The manufacturer was not notified of the failure. The failure mileage was 113,000.

Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is fine but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibu and needs a recall fix.

The catalytic converter and exhaust manifold are suspected to be malfunctioning. These components are part of the vehicle’s exhaust system, and their failure is believed to be contributing to hesitation and skipping during operation. Both components are available for inspection upon request. The hesitation and skipping reduce the vehicle’s responsiveness, creating a safety risk in traffic. This issue could hinder safe merging, overtaking, or maintaining consistent speeds. Additionally, malfunctioning exhaust components may lead to increased emissions and pose a risk of toxic gases entering the cabin if leaks are present. Check engine light displays. The problem has been confirmed by a professional auto mechanic during their inspection and diagnosis. The components have been inspected and diagnosed by an independent service center (the auto mechanic). They have not yet been inspected by the manufacturer, police, or insurance representatives. No warning lamps or error messages were displayed on the dashboard prior to the diagnosis. The symptoms, including hesitation and skipping, began approximately [insert timeline, e.g., two weeks ago] and have been recurring during normal driving, particularly during acceleration or at lower speeds.

The contact called on behalf of her daughter's boyfriend who was driving alongside her daughter in a 2012 Chevrolet Malibu. The contact stated that her daughter's boyfriend was driving on the highway at approximately 75 MPH in the left lane when a tractor-trailer in the right lane veered into their lane and the rear end of the tractor-trailer clipped the front end of their vehicle. The contact vehicle began to spin out of control until it came to a stop on the side of the road. The vehicle was totaled. The air bags were not deployed. The vehicle was towed to a local tow lot. No warning lights were illuminated prior to the crash. A police report was filed. The boyfriend seated in the driver's seat, and the contact's daughter seated in the rear passenger seat were both injured, and the infant in the rear driver's seat in a car seat was not harmed. No other individuals outside of the vehicle were injured. Medical treatment was needed for the daughter's boyfriend and the daughter. The boyfriend injured his nose on the steering wheel, and the daughter's shoulder was injured. A dealer was not contacted. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.

On [XXX], as I was leaving softball tournament in Poway Ca with my kiddos about 6 minutes into driving a message popped up on my dash "ENG PWR REDUCED & SERVICE TRACTION", I lost power to accelerate, I pulled over just before getting on the [XXX] freeway, turned car off and thought car would reset which it didn't. I was stranded with my kiddos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at various speeds and driving over a pothole or an object on the roadway, the front driver’s side headlight became inoperable. There was no warning light illuminated. The vehicle was taken to an independent mechanic but was not diagnosed; however, the contact was informed that there was a failure with the electrical wiring inside the front driver’s side headlight. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic and was diagnosed and determined that the wiring harness inside the front driver’s side headlight needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2012 Chevrolet Malibu. The contact stated while a passenger was seated in the front passenger’s seat, the passenger’s side air bag warning light intermittently illuminated while driving at various speeds. The vehicle was taken to a local dealer where it was diagnosed with an inoperable passenger’s side air bag sensor. The vehicle was not repaired. The manufacturer had been informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 146,000.

First, there is a problem with the transmission. The car will stall or stop abruptly while driving. Second, the automatic turn signals do not work. Third, the driver safety belt does tightly secure the driver.

The front exterior low beam bulbs / wiring harness keeps burning out. I have replaced them twice already and they have blown again. What is going on already a headache just to even get to the headlights, now have to spend MORE money to repair.

The headlights keep.going out. I've replaced everything amd it keeps happening and it's not easy to even get to the headlight. This is a hazard as my 16 year old drives this car. We fix it and then it's out all.over again. This has to be a recall as I've done some research and im.not the only one with this problem. We've been pulled over and we just explained our frustration and they've been nice enough to send us on our way.

For 4 years the car intermittently would turn on all warning lights, shake, become hard to steer and steer in unintended directions. We paid $1500 for the dealer to fix it and we still had the problem. Today, the car will drive less then a mile and die. When we start the car all warning lights come on, the vehicle vibrates and struggles to keep speed of 5 mph or so then will die.

Electrical problem causing the passenger side low beam to keep burning out. Fourth time in one year. Vehicle is available for inspection upon request. This issue causes a safety concern because you can be driving down the highway at night and all of a sudden you have no headlight.

As I was driving my vehicle last Sunday the "Power Steering and the Service ESC" warnings came on my dashboard as well as the "Traction Control light" I audible sound came on and I lost power steering. When I went to drive my car to my service station everything worked fine for a few blocks the problem came back. I drove it to my local service mechanic and his scan tool gave an error code of CO545. I did some research on this issue and found that GM put out a Special Coverage #15356 for the power steering sensor. This coverage expired in 2021 however my vehicle did not have this problem until last week. My car only has 60,000 miles on it. Yesterday I took my vehicle to the GM dealer that I purchased my vehicle from and the said I have to pay $200.00 for them to diagnose the problem (which I understand) but the service writer told me that GM will probably not replace the parts needed because their "Special Coverage" expired in 2021. I am asking if the government can force GM to recall. I thank God that my wife nor my daughter was not driving the vehicle when this happened or they may have been hurt or worse fighting the steering wheel to keep the car going straight until I could stop it saftly.

Driving down the freeway and suddenly I get reduce engine power. I had to wait on the freeway until the car started up again

Passenger low beam keeps going out within a couple days charged wire harness and bulbs keeps happening.

ESC went out on vehicle on the interstate

1. While driving I will lose all steering capability and get a ESC Off 2. Physically difficult to turn the wheel when going around turns and this happens we would be unable to control the vehicle 3. The problem has produced itself by the dealership and there is a Bulletin that provided coverage incase this happens but did not happen until after coverage expired and should have been a recall. 4. No has not been inspected by anyone else 5. Lights that came on were traction control and a notification stating ESC is turned off on the dashboard Marquee.