Chevrolet Colorado 2020 — Problemas relatados

2020 Chevrolet Colorado 2.5L, approximately 81,500 miles. I experienced a sudden loss of power brake assist. There was no warning noise associated with the failure; the brake pedal became extremely hard and required substantially greater pedal pressure to stop the vehicle. The vehicle was inspected by an independent professional mechanic. Inspection found that the brake booster vacuum pump itself was not the primary source of the failure. The failure was at the engine exhaust camshaft interface that mechanically drives the vacuum pump. The camshaft drive was damaged and no longer properly operated the vacuum pump, resulting in loss of brake vacuum assist. This is not normal brake-pad or rotor wear. The hydraulic brakes remained functional, but without the vacuum assist the pedal effort increased dramatically, creating a significant braking safety concern. The vehicle has been removed from normal use pending repair. I am reporting this because failure of an engine component that drives the brake vacuum pump can cause sudden loss of power brake assist.

Vacuum pump for brakes failed and damaged the whole engine to be replaced because of faulty vacuum pump design

The engine malfunctioned, specifically the 4 camshaft actuator solenoid valves, making the car unable to safely drive. The check engine light came on, likely indicating the car was unsafe to drive. GM issued GM Special Coverage N232430470 covering 2020 Colorado's with a 3.6L V6 engine for the Bank 2 exhaust camshaft actuator solenoid up to 15 years/150,000 miles. This was confirmed by a Chevy dealership. The vehicle was not inspected by the manufacturer, police, or insurance representative. My check engine light first came on 09/05/26, however, the check engine light did disappear later in the week. It came on again 09/27/26, so i decided to have the car inspected, despite the fact that the check engine light later went away.

Coupling on vacuum pump broke off while in motion. Pieces fell near engine. Camshaft, vacuum pump and brake booster will need to be replace. Vehicle mileage is at 65124 miles. No reason to have such a failure so early

My 2020 Colorado at 14k miles, the dealer did the transmission oil flush and it helped till the warranty ran out. Now I have the same problem again at 32k miles. I bought the truck because GM said the problem with 8L/45 trans was fixed in 2019. To my knowledge there has been no update to the slipping clutch in GM's torque convertor. If I were to replace the convertor with another one just like it I could have the same problem. My Dealer ([XXX])says my lifetime warranty (that I got with my new Colorado) doesn't cover the transmission? And that if they do another $600 oil flush they don't guarantee it will fix anything. I think when the flush is done, they don't change the trans filter. I'm sure the clutch particles that are left behind after the flush are probably stopping up the filter. I just replaced the DOD/AFM cam and lifters in my GM car's 6.2 liter. It's a shame that manufacture's can get away with these kind of problems. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On September 4, 2026, I experienced an extremely serious and frightening braking failure while driving my 2020 Chevrolet Colorado 2.5L. I was driving my granddaughter to school and was pulling into the school's carpool/drop-off area at approximately 20 mph. This was an especially dangerous location because children, parents, vehicles, and school personnel were in the immediate area. As I attempted to slow and stop the vehicle, the brake pedal suddenly became extremely hard and the vehicle would not stop normally. The dashboard displayed “Service Brake Assist,” and the check-engine light illuminated. I pressed the brake pedal, but the vehicle continued moving. Realizing that the normal brakes were not stopping the truck, I engaged the emergency/parking brake. The emergency brake slowed the vehicle somewhat, but even then the vehicle did not come to a complete stop. I ultimately had to place the vehicle in PARK to get it stopped. Fortunately, I was traveling at a low speed and was able to prevent the vehicle from striking a child, pedestrian, another vehicle, or other property. My granddaughter was also inside the vehicle at the time. This was an extremely frightening situation that could very easily have resulted in catastrophic injuries or death. The fact that this occurred in a school carpool/drop-off area surrounded by children makes the seriousness of this failure especially concerning. There was no reasonable warning that I was about to lose normal braking assistance. I am reporting this incident because I believe this vehicle may have experienced a serious safety-related defect involving the braking/brake-assist system. I am requesting that this incident be documented and that NHTSA investigate whether other owners of 2020 Chevrolet Colorado vehicles, particularly those equipped with the 2.5L four-cylinder engine, have experienced similar sudden losses of brake assist or braking ability.

While driving my 2020 Chevrolet Colorado through [XXX], the truck began having difficulty accelerating. As I exited the highway and turned into a gas station, the truck suddenly lost power. The steering became extremely difficult, and I lost normal brake assist. The brake pedal became extremely hard, and I had to apply extreme force to stop the truck and avoid crashing into a wall at the gas station. Fortunately, no collision occurred. The truck was towed to Ed Corley Ford in [XXX] because I was stranded in a remote area with very limited options. They diagnosed a failed/broken vacuum pump and told me replacing it should make the truck operable so I could drive it home to [XXX]. I authorized the repair. After replacing the vacuum pump, they told me they started the truck and heard an abnormal sound. They shut it off, and when they tried to restart it, the truck would not start. They wanted to perform additional diagnosis, but I declined and had the truck transported back to [XXX] for evaluation by a Chevrolet dealership. Huffines Chevrolet Lewisville inspected the truck. Their technician removed the camshaft position sensor and used a borescope to inspect the camshaft. They documented that the camshaft is damaged at the end where it connects to the vacuum pump and stated the actuator pin was most likely bent due to the vacuum-pump failure, damaging the camshaft and causing it to be slightly out of time. I have also been informed of engine damage. The truck remains inoperable and is currently available for inspection. I am concerned this is a safety defect because the vacuum-pump failure resulted in a sudden loss of normal brake assist while I was driving and was followed by camshaft/engine damage. I am asking NHTSA to investigate this failure and similar Chevrolet Colorado complaints. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

a/c control knocks out tempter senor and gauge goes to zero and check engine light comes on, gas mileage goings to hell, turn off engine clutch fan runs for several minutes, can still touch water hoses by hand and not even hot. This is a big safety problem because I'm looking at the gauge and now causing more smog! Chevrolet Merele Stone in Porterville CA had it all day reporting A GM Strat sticking ,it was a brand new gm delco and senor and still doing it . It's a $1000.00 to repair itThey had to jump start my truck went picking it up. tried to charge the battery over night but dead battery, had to replace it $250.00 expense, and $189.00 to denoised. Called GM for a appointment in Visalia to check the problem 42 mile on way from home and showed up to No APPOINTMENT!

The contact owns a 2020 Chevrolet Colorado. The contact stated that while reversing out of the driveway, the check engine warning light illuminated. The failure recurred while driving 65 MPH. The vehicle was taken to AutoZone, where DTCs P0024 and P0014 were retrieved, indicating exhaust camshaft position system performance issues for Bank 2 and Bank 1. The contact associated the failure with GM Special Coverage Number: N232430470 (Camshaft Position Actuator Valve Solenoid - Bank 2 (Left Side) Exhaust). The vehicle was then taken to the dealer, where the diagnostic result was confirmed. The dealer swapped the camshaft position sensor actuators between both banks and cleared the codes. The contact was advised that the cause of the failure would be determined if the diagnostic trouble codes returned. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the special coverage. The failure mileage was approximately 36,500.

Vacuum pump seized, causing loss of power assist on brakes. This happened as I was approaching an intersection to make a right-hand turn. When I press down on the brake pedal it felt hard, like it was locked up. After pressing down on it with both feet, I was able to slow the vehicle down enough to turn out of the intersection. If this event happened when there was another vehicle in the intersection or approaching the intersection on the side street that I was turning onto, it would have led to a collision. Not being able to slow down adequately, I had to swing wide in the turn. This incident happened at a relatively slow speed. If it had happened at highway speeds it could have been catastrophic. There was no warning light prior to the incident the check engine light did not come on until after the incident. The Pump seizure caused the connecting coupling between the exhaust cam and pump to shatter. The damage was extended to the exhaust cam and valve cover and leaving metal fragments in the engine. The local Chevrolet dealer has given me an estimate for the repair of over $2400

While driving at any speed when steering wheel is at the 1 to 2 o' clock position on a right turn, steering wheel wobbles and regardless of road condition. Stabitrack warning light comes on occasionally.

Plastic fuel supply line leaked from front of fuel tank area . the vehicle (2020 chevrolet colorado) was towed to the chevrolet service facility, after it was discovered leaking on my driveway. Gas was smelled while I was driving. I do have the failed hose. It was indeed damaged. Possibly chewed through by a rodent, mouse or squirrel. The colorado is allways parked in my blacktop driveway. Safety risk is substantial gas leak without any warning while driving or in a garage potential fire or explosion. Dealer service confirmed and replaced the hose. I reported to Chevrolet by phone on (4/30/2026).I was told report started & put in system. No warning light or alarm occured.

The contact owns a 2020 Chevrolet Colorado. The contact stated that while driving at an undisclosed speed, the brake pedal went to the floorboard while depressed, and the vehicle failed to stop immediately. The contact switched to manual driving mode and downshifted the transmission. The vehicle came to a stop after driving over a dirt pile. The brake warning light was illuminated. The vehicle was able to drive to the residence. Upon inspection, the contact discovered that the hydraulic line was rubbing against the parking brake cable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 102,400.

the power brake booster was found broken on 1/29/2026. Through repairs, i've found vacuum pump race being completely damaged and exhaust camshaft end that linked with vacuum pump is also damaged.

The contact owns a 2020 Chevrolet Colorado. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle with camshaft position sensor failure. The contact was informed that the camshaft position sensor needed to be replaced. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not under a Manufacturer Extended Warranty coverage related to the failure. The failure mileage was 119,000.

While driving in grocery store parking lot. The brake booster completely failed with no notice almost causing me to hit someone. I had to throw the truck in park while moving to avoid hitting pedestrians. The brake pedal is completely compressed to the floor as I was stomping the brakes in an attempt to stop. Had I not thought quick enough I would of hit at least 2 people.

The contact owns a 2020 Chevrolet Colorado. The contact stated that the air bag warning had been turning off and on intermittently for almost 2 years. The vehicle was taken to the dealer several times, but the dealer was unable to duplicate the failure. The vehicle was recently taken to an independent mechanic; however, the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 26,000.

My truck has been shuddering and when put into gear it sounds like the bottom is falling out of it. Now when I am driving my truck is shuddering very hard and skipping gears. I have been having this issue since I bought the truck with only 47k miles and I have only put 40k miles on this truck in the past 3 years that I have owned it. I keep the maintenance up on my truck and have since I’ve owned it and I have already put a complaint into GM, when I bought the truck it has had electrical issues and the dealership is not helping. My warranty is out on this truck and GM said there is nothing they can do to help with my transmission or electrical problems. This truck has not even hit 100k and I’m so upset that I am having these many problems and no one is wanting to help, they just want my money. I can’t afford an attorney or I would sue this dealership for selling me a Lemon and for GM knowing about there faulty transmission in my year truck and not standing behind it!

Had transmission serviced, was told the transmission was no good and about to fail Quoted $8000.00 dollars to repair

Vehicle has 54,250 miles. Vehicle has a rear differential bearing going out by hearing and feeling the grinding at all speeds and the transmission jerks shafting gears. Both could cause an accident if totally fail. Chevrolet has a service bulletin out from what my local garage says. Mechanic also says Chevrolet will not warranty the product. Vehicle is now being looked at by a Chevrolet dealer. The vehicle is OUT OF WARRANTY. My son, who is [XXX] and not familiar with vehicles thought it was the tires causing the whining and vibration. Took the vehicle in several times to Chevy and they ignored the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle experienced a sudden and progressive transmission failure during normal driving conditions. Symptoms included harsh shifting, delayed engagement, loss of power transfer, and eventual inability to reliably propel the vehicle. The failure created a safety risk due to unexpected loss of acceleration and unpredictable drivetrain behavior while in traffic. The transmission issue was not the result of improper maintenance. The vehicle was maintained according to manufacturer recommendations. The condition worsened over time and ultimately required dealer inspection. A dealership inspected the vehicle and attributed the failure to a transmission defect, characterizing it as a maintenance issue despite no evidence of neglect. The transmission and related components remain available for inspection upon request. No warning lights provided adequate advance notice prior to the functional failure. The issue occurred without driver misuse and under ordinary driving conditions.

Torque converter shudder. Had dealer do the recommended flush which cost $800 and still has same issue.

The contact owns a 2020 Chevrolet Colorado. The contact stated that while accelerating, the vehicle vibrated and shook abnormally, as if driven over ripples on the roadway. No warning lights were illuminated. The vehicle was taken to the dealer, and the tires were balanced. The contact picked up the vehicle and stated that the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that the transmission oil failed to heat up as intended, and condensation had built up in the transmission. The dealer added Mobil 1 transmission oil to heat up the oil and remove the condensation. The contact was informed by the dealer that the vehicle needed to be driven between 200 and 400 miles to remove the condensation. The manufacturer was made aware of the failure and filed a claim and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 80,000.

Defective Torque Converter at estimated 92k miles even after following all preventive maintenance schedule.

Transmission shuttering mostly at interstate speeds but as slow as 35 mph. Under light to medium light pedal acceleration. Truck feels as if it's going over Road ripples. I'm disappointed to find out this is a common problem with Chevy 8-speed Transmissions. It happens every time I drive it. From time to time it'll shake the truck a little violently

The component that failed is the camshaft position actuator. My check engine light came on. Had my vvt solenoids replaced and the mechanic told me the actuator needs replacing. GM has issued a special bulletin to fix this part for the same year make and model as my truck but my vin doesn’t meet the criteria. I have only owned this vehicle for 8 months.

This vehicle suffers from a torque converter/transmission shudder after the transfer mission fluid heats up. My initial complaint to the selling dealer and they did not follow the GM posted procedure and initially charged me for the service. I’ve changed dealerships and I’ve been told it the temporary fix is to do a flush and there is no permanent fix by GM. I have had situations where and unexperienced driver would have definitely got into a car accident and I don’t let anybody drive my car because I believe it is unsafe. So far the dealer has been accommodating while under warranty but advised I reach out to GM who then advised to review my documents I file an NHTSA complaint. What occurs when the vehicle is not in warranty and the vehicle continues to shudder. I have included the service bulletin and repair invoices.

Unknown. When my truck reaches a certain speed it is jumping or missing, it feels like a brake is sticking but I’m told it is a problem with my transmission, torque converter, going bad. It is getting worse. It cuts the power down on the vehicle. If I can go faster than 60 it doesn’t do it.

Vehicle began exhibiting an intermittent shake between 45-60 MPH which felt like driving on a wash board road. In addition it would shift hard/bog down between 1st and 2nd gear. Took to a dealer for service and was told a TSB had been issued to flush the transmission, this was performed. Condition returned within months and after multiple additional visits where the dealer claimed they couldn't replicate the issue they finally determined the torque converter needed to be replaced at approximately 70,874 miles. By this time the warranty had expired (60,000 mile warranty) and I was told I would have to pay for it.

The contact owns a 2020 Chevrolet Colorado. The contact stated while driving 70 MPH, the check engine warning light illuminated. The contact stated that the vehicle started to lose motive power. The vehicle was taken to Auto Zone and was diagnosed with exhaust camshaft position actuator failure. The vehicle was then taken to a dealer where it was diagnosed with exhaust camshaft position actuator failure. The local dealer was contacted; however, the vehicle was not repaired because the vehicle was not under recall. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.

Driving on the highway speed limit 65-70 my truck started decelerating and breaks got hard and could not use break. Had to get home using emergency petal break and drive. My truck is only 2020 model for this type of problem. Want to see if I can get this fixed with the manufacture defect warranty. Took my truck to a Chevy dealer and they are saying it can be a faulty vacuum pump.

Third brake light seal leaking causing electrical connecs to corode and loose connection rendering the third brake light to stop functioning.

Heard a humming noise ( spaceship like almost) coming form back of the truck. Took it in and mechanic said there was metal shavings in the differential fluid and gears where bad. Had to get the differential replaced. most cars go their entire life without having this issue.

Transmission shuddering shaking almost stopping with 60,292 miles used

This has been an ongoing issue. Truck currently has 45,000 miles on it. When driving on the interstate for 30 minutes, transmission flutters causing the cab to shake. It feels like running over rumble strips. Flutter lasts for several seconds and gets worse (longer duration, harder flutter) as time goes on. Dealer won't diagnose it because no codes are recorded. No dash lights light. The only indication is the flutter itself. Chevrolet cust support says their hands are tied - it is the dealers responsibility. The dealer will not devote personnel for 30 minutes to replicate the issue. Issue comes out of no where startling the driver - not safe. Your first reaction is either to brake or gas to stop the flutter/shake. Flutter is stronger as time goes by. This issue has been identified for other years of the same vehicle, and several GM vehicles. It is still an issue in 2020, but not recognized by GM. Multiple complaints are on the internet for this issue by other 2020 Colorado owners.

Drive ability issues, feels like going over cattle guard,shudders when accelerating around 40-60 mph. the vehicle shudder's abnormally. there are no warning lights illuminated. Took to local Chevrolet dealership where a service bulletin, TSB: 21-NA-047 was discovered to address the issue. The dealer recommended a transmission fluid flush. Mileage on this vehicle was 67,631.

No warning lights are illuminated but have this consistent violent Engine rattle/shuddering that is getting worse and worse. Also when looking under the hood the Crank pulley wobbles/rattles when truck is idle. Was told it could be the harmonic balancer going out due to there being a gap between that and the Crank. The truck only has 100,000 miles on it. I got it used at 88,000 miles and have barely had the truck for a year now, the steering wheel was intermittently difficult to maneuver and no warning lights illuminate, the truck shifts hard from 1st to second gear now and seriously hesitates to accelerate. This is extremely concerning and apparently an ongoing complaint for this vehicle and something should be done about it. Not only does it cause financial destress on the owners of the vehicles but also a safety hazard to the driver

IGNITION LOCKED UP. This situation is the same as another complaint posted earlier this year by another owner. Ignition key will not turn in the igntion switch. Tried all the internet fixes. Turning steering wheel, bumping transmission lever, tried spare key, etc. Nothing worked. $225 to tow to the dealer. Still waiting to hear from back from dealer.

COMPLAINT # 11630574 Transmission Shudder, took to dealership on 09/28/2023 had transmission flushed and changed fluid to new style transmission fluid, per GM under warranty. I was told that if it needed done again that i would have to pay to have it done and would cost approximately $400- $500. On 12/13/2024 the truck is shuddering again at 48,700 miles.

The contact owns a 2020 Chevrolet Colorado. The contact stated that while driving at various speeds and accelerating, the vehicle started shaking abnormally. The vehicle was taken to a local dealer to be diagnosed. The contact was informed that the abnormal shaking was caused by the torque converter. The dealer flushed the transmission; however, the failure has persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 40,000.

Check engine light appeared when starting vehicle. Code read by local auto parts store. Thermostat failed at less than 50k miles, causing fan to run constantly and for an extended period time after turning engine off, despite outside temperature. Causes potential for overheating due to not reading temperature. Thermostats are rated to last 100k miles. Is not covered under Chevrolet's 5 years/100k miles powertrain warranty. Upon research, this has been an extremely common issue for Colorado trucks for many years and has not been addressed by Chevrolet. Many blogs are available online. This vehicle was a certified vehicle bought just over 1 years ago and would not be fixed by any warranty according to the dealership purchased from (Bob Fisher).

Within the last 2 months, I have had momentary steering problems at low speed. They continue to become worse with time, no longer safe to drive. Dealer has vehicle now and informs me that it will cost $3000 for a known/existing corrosion of electrical connections in the power steering assembly. Via the internet, the steering gear torque sensor cover assembly needs to be replaced. Because this cover assembly has leaked, the wiring harness also has to be replaced. 7 hours of labor, front end alignment, etc! The loss of power steering in a turn has nearly caused several accidents till I got it home. Dealer confirms what I experienced in test drive, internet has many examples of same problem and solution. There are no warnings of impending loss of control, one minute everything is fine, the next you are fighting for control.

See attached document for complaint.