Chevrolet Cavalier 2003 — Reported problems

There is a recall on the vehicle I need to get fixed.

THE STEERING WHEEL IS LOOSE. PINS ON TILT MECHANISM ARE GONE. DON'T KNOW WHEN IT FELL OUT. NOTICED WHEN CLEANING CAR WHEN I TILTED THE STEERING WHEEL UP.

MY CAR HAS THE SAME PROBLEM WITH THE INSTRUMENT CLUSTER THAT WAS RECALLED FOR OTHER GM VEHICLES. THE FUEL LEVEL GAUGE, TEMPERATURE GAUGE, RPM, SPEEDOMETER.... NONE OF MY GAUGES WORK. THEY GAVE THE WRONG READINGS, THE HAND WOULDN'T RETURN TO THEIR STARTING POSITIONS, THEN THE HANDS WENT LOWER THAN THEIR STARTING POSITIONS TO THE POINT THEY ALL DIDN'T WORK ANYMORE. THIS CAR NEEDS TO BE ADDED TO THE GM RECALL LIST FOR THE SAME PROBLEM.

TAKATA RECALL

CLUSTER OF DASHBOARD INDICATORS (SPEEDOMETER, GAS GUAGE , ENGINE TEMP, RPM) ALL ARE NOT WORKING NOW. THEY WERE GOING OFF AND ON AT TIMES WHEN DRIVING BUT NOW NOTHING WORKS...MY MECHANIC INFORMS ME THIS IS A COMMON PROBLEM WITH THIS MAKE AND MODEL. NO RECALL FOUND. VERY DANGEROUS TO DRIVE WHY WASN'T THIS COMMON PROBLEM LISTED AS A RECALL WHEN MANY HAVE COMPLAINED??

I WAS ONE BLOCK FROM HOME AND MY CAR STALLED IT WOULDN'T START BACK UP. I FOUND MY SELF AT THE INTERSECTION. THE MECHANIC SAID IT IS A BAD FUEL PUMP. THE CAR ONLY HAS 60,000 MILES. THIS HAPPENED ABOUT THIS TIME LAST YEAR . ALSO LAST YEAR MY GAUGE TO MY ENGINE TEMPERATURE WENT OUT OF CONTROL. I CAN'T TELL THE ENGINE TEMP. ANYMORE.

MY 2003 CHEVROLET CAVALIER RECENTLY BEGAN TO MAKE A CLUNKING NOISE, WHICH CAN ALSO BE FELT, IN THE FRONT END. WHEN I PUT IT UP ON A LIFT, I NOTICED THAT THE SUB-FRAME WAS RUSTING (DETERIORATING). I KNOW IT IS 13 YEARS OLD, BUT MY PARENTS OWNED A 1989 CAVALIER Z24 FOR 20 YEARS, AND THEY DIDN'T HAVE ANY PROBLEMS WITH ITS FRAME. I'VE READ THAT OTHER PEOPLE HAVE HAD THIS SAME ISSUE WITH THEIR 2003 CHEVY CAVALIERS. WHY IS THIS? WHY HAS THERE NOT BEEN A RECALL? MY FAMILY HAS OWNED SEVERAL NEW AND USED VEHICLES, ALL GM, AND WE HAVE NEVER SEEN A SUB-FRAME RUST TO THIS EXTENT. WE ARE A GM FAMILY AND ARE EXTREMELY DISAPPOINTED IN GM'S LACK OF RESPONSE TO THIS SAFETY HAZARD.

"CHECK ENGINE" LIGHT KEEPS COMING BACK ON FOR THE SAME ISSUE, SUPPOSEDLY THE "AIR INTAKE TEMP SENSOR, REPLACED THAT ONE AND SEVERAL SENSORS REPEATEDLY, HAD THE COMPLETE WIRING HARNESS CONNECTIONS CHECKED AND CLEANED, EVEN REPLACED MY ECM AND BCM [NEITHER OF WHICH WAS CHEAP], AND STILL HAS "CHECK ENGINE" LIGHT, EVEN AFTER BEING "CLEARED" OVER AND OVER AGAIN -- THIS CAR WAS WELL MAINTAINED AND THE BODY AND SUB-FRAME ARE SEVERELY ROTTING OUT LEFT AND RIGHT -- HAD A WEIRD LEAK ON THE PASS. SIDE FRONT, UNDER THE DASH. IT COMES AND GOES. THE CAR SMELLS LIKE AN OLD SNEAKER INSIDE. WATER WOULD POUR OUT OF THE PASSENGER SIDE HEATER DUCT, BUT THERE WAS NO RHYME OR REASON TO IT. ONE I EVEN HAD SOAP FOAM FROM A DRIVE THRU CAR WASH LITERALLY COME BLOWING IN TO THE CABIN, THRU THE VERY SAME HEATER DUCT. THANKFULLY IT HAS SEEMINGLY CLEARED UP, BUT IT IS STILL A HEAD SCRATCHER. I'VE TAKEN MY CAR TO SEVERAL DEALERSHIPS, PRIVATELY OWNED SHOPS, AND EVEN HAD SOME "CAR SAVVY" FRIENDS LOOK HER OVER, AS WELL AS MY DAD [ANDS ASE CERTIFIED TECH], AND THE CHECK ENGINE LIGHT STILL COMES BACK EVERY TIME. IF I WOULD HAVE KNOWN I'D PUT THIS MUCH MONEY INTO A CAR THAT LITERALLY READY TO BREAK APART, I WOULD HAVE SAVED MY MONEY TO PUT TOWARDS ANOTHER CAR. LIVE AND LEARN, I GUESS. SHE WAS DOING SO WELL FOR 10 OR 11 YEARS AND IT'S LIKE SHE JUST STARTED "GIVING UP" ON ME. SHE'S GOT 165K ON HER AND THE PAIN HAS GONE TO CRAP, BUT THAT'S GM FOR YOU, KEPT HER GARAGED, WAXED REGULARLY, HAD HER LOOKING SHOWROOM NEW, UNTIL RECENTLY, THE PAINT'S CLEAR COAT STARTED TO "STIPPLE" [SHARP BUMPS] AND BUBBLE ALL OVER TOP PANELS, STARTING WITH THE ROOF, THEN HOOD, AND NOW TRUNK. IT'S EMBARRASSING TO DRIVE HER, AND I AM NOT PAYING TO REPAINT HER, I ALREADY HAVE WAY TOO MUCH INTO A CAR THAT LIKELY WILL NOT PASS INSPECTION COMING UP IN AUGUST. I'M NOW HANDICAP'D AND DISABLED, FIXED INCOME, CAN'T AFFORD A NEW CAR.

INSTRUMET CLUSTER PROBLEMS FOR A FEW YEARS. FUEL SENDING UNIT HAS BEEN REPLACED AT ABOUT 52,000 MILES AFTER QUITING TWICE WHILE DRIVING HIGHWAY SPEED OF 55 MPH. DEALER CLAIMED THE CAR QUIT BECAUSE OF A BAD BATTERY THE FIRST TIME AND DID NOT DIAGNOSE THE PROBLEM CORRECTLY. IT WAS NOT THE BATTERY. THE FUEL SENDING UNIT INTERMITTENTLY READS WELL BEYOND FULL AND INTERFEARS WITH THE TEMPERATURE GAGE FUNCTION. NOW SPEEDOMETER IS STUCK AT 85 MPH WHILE TURNED OFF. I WAS DRIVING WITH THE CRUISE DOING 67 MPH, I SLOWED DOWN TO MAKE A TURN AT AN AT GRADE INSECTION TO A ROAD POSTED AT 55 MPH. I COMPLETED THE TURN AND SPED UP. THE SPEEDOMETER READ 58 MPH BUT IT FELT LLIKE I WAS GONG ABOUT 30 MPH. I STOPPED AT ANOTHER INTERSECTION AND THE SPEED DROPPED TO 40 MPH. I MADE THE TURN AND ACELERATED AND THE SPEED WENT TO 110 MPH BUT I WAS NOT GOING NEAR THAT FAST. THE CAR IS IN DRIVEWAY TURNED OFF BUT THE SPEEDOMETER READS 85 MPH. MOST RECENT ISSUE IS STEERING RACK AND K-FRAME RUSTED OUT AND NEEDED TO BE REPLACED. MECHANIC STATED HE NEVER SAW A STEERING RACK RUST OUT OR A K FRAME RUSTED AS BAD AS THE ONE ON THIS VEHICLE. WE ARE THE ORIGINAL OWNERS.

INSTRUMENT CLUSTER NEEDS TO BE REPLACED. THE CLUSTER BLINKS IN AND OUT

I HAVE NOTICED A LOT AND I MEAN A LOT OF THESE CAVALIERS HAVE HAD HORRIBLE FRAME PROBLEMS I USE TO WORK ON CARS EVERYDAY UNTIL THE LAST YEAR WHEN I GOT OUT OF THE MECHANICS FIELD AN NOW I OWN A 03 CHEVY CAVALIER ITS A TWO DOOR 5 SPEED 2.2 I WAS ON MY WAY HOME FROM THE STORE AND I FELT SOMETHING RUBBING SO I STOPPED AN GOT OUT TO FIND OUT MY K FRAME WAS HORRIBLY ROTTED AN BROKE NOW THIS VEHICLE IS 13 YEARS OLD BUT AS ROTTED OUT AS IT WAS IT WASN'T SOMETHING THAT JUST HAPPENED ITS BEEN BAD I WAS JUST THE LUCKY OWNER THAT THE FRAME GAVE OUT ON AN I DEMAND TO KNOW WHY THIS ISN'T A RECALL ANOTHER THING IS I OWNED A 98 FORD F150 WHICH HAD RECALLS AN WHEN I WAS SENT THE LETTER ABOUT THE RECALLS I ASKED FORD WHY THE FRAMES ON THE F150 OR RANGER WASN'T A RECALL THEY HAD NO ANSWER. I PUT MY CHILD IN THESE AUTO MAKERS CARS AND TRUST THEIR WORK TO KEEP HIM SAFE BUT THEY HAVE NO ANSWER FOR WHY ONE OF THE MOST IMPORTANT PART ON THE WHOLE VEHICLE IS FALLING APART. I DON'T KNOW IF THEY NEED TO USE STAINLESS STEEL, ALUMINUM, OR WHAT BUT IT NEEDS FIXED OR THE VEHICLES NEED REIMBURSED AN CRUSHED. I COULD OF BEEN DOING 70 MPH DOWN THE HIGHWAY WITH MY WOMAN AN SON IN THE CAR AN THE FRAME COULD OF WENT AND KILLED US ALL. IS THAT WHAT ITS GONNA TAKE TO GET THIS [XXX] FIXED SOMEONE ELSE TO DIE/HURT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS LOOKING AT MY LOCAL NEWS STATION AND A MAN HAD CALLED THE INVESTIGATION TEAM ABOUT CRACKS IN HIS DASHBOARD SO THEY COULD GET IN TOUCH WITH GM ABOUT IT BECAUSE NOTHING WAS BEING DONE TO RESOLVE THE PROBLEM. I HAVE CRACKS IN MY DASHBOARD AND PART OF IT WAS CRACKED SO BAD IT CAME OUT AND IT IS BIG ENOUGH FOR ME TO SIT AN APPLE IN. THE MAN WHO BROUGHT THE STORY TO ATTENTION WAS CONCERNED ABOUT THE CRACKS OVER THE AIRBAG THAT IF IT EVER CAME OUT THAT DEBRIS FROM THE DASHBOARD WOULD FLY EVERYWHERE AND THAT WOULD BE HAZARDOUS TO THE OCCUPANTS OF THE CAR. THIS IS A CONCERN TO ME NOW BECAUSE THE CRACKS STARTED OUT SMALL BUT GOT BIGGER OVER TIME. I'M ALMOST SURE THAT THERE WILL BE MORE CRACKS APPEARING ESPECIALLY WHEN THE WEATHER GETS HOT AND MY CAR IS NOT ALWAYS IN THE HEAT OR IN AREAS WHERE THE HOT SUN IS BEAMING DOWN ON IT. TO ME THAT WOULD BE CONSIDERED AS A DEFECT FOR THAT TO JUST HAPPEN. I ALSO HAVE A FORD ESCORT 2000 MODEL AND THE SAME THING IS HAPPENING TO THAT DASHBOARD. I CAN TAKE PHOTOS BUT I DON'T KNOW HOW TO UPLOAD THEM ON THE COMPUTER, TELL ME OTHER WAYS I CAN SEND PHOTOS IF POSSIBLE. MY VEHICLE IS MOSTLY STATIONARY AT MY HOME ADDRESS WHENEVER I AM NOT AT WORK AND I NEVER HARDLY USE THE FREEWAYS. THERE HAS DEFINITELY BEEN NO TAMPERING WITH MY VEHICLE. THE STORY I SAW ON THE NEWS WAS AIRED I BELIEVE LAST WEEK OR THE WEEK BEFORE.

METAL ON METAL NOISE FOUND OUT SHOES AND ROTORS ARE DAMAGEDDAMAGED. I HAVE NO MONEY. V CAN'T FIX THIS. SMELL INSIDE OF LEAK. TEMP RUNNING HIGH. 200.

TL* THE CONTACT OWNED A 2003 CHEVROLET CAVALIER. WHILE DRIVING 5 MPH ENTERING THE HIGHWAY, THE TURN SIGNAL LAMPS FAILED TO ILLUMINATE WHEN ACTIVATED AND RESULTED IN A CRASH. THE CONTACT'S VEHICLE WAS STRUCK ON THE REAR DRIVER SIDE AND SPUN ONTO THE ROADSIDE. THE AIR BAGS DID NOT DEPLOY AND A POLICE REPORT WAS FILED. ALL THREE OCCUPANTS IN THE VEHICLE WERE SEVERELY INJURED AND REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V524000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. ...UPDATED 02/19/16 *BF UPDATED 09/20/16*LJ *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE IGNITION SWITCH FAILED. THE CONTACT WAS UNABLE TO TURN THE KEY TO THE ON FUNCTION AND HAD TO WIGGLE THE KEY TO BE ABLE TO RELEASE THE KEY FROM THE IGNITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. WHILE DRIVING 40 MPH, THE LEFT AND RIGHT TURN SIGNALS BECAME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V524000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

JULY 2009 IGNITION LOCK CYLINDER WAS STUCK. I HAD IT REPLACED FOR $362.75 AT CHEVROLET DEALERSHIP. AUGUST 2014 IGNITION LOCK CYLINDER WAS STUCK. I HAD IT REPLACED FOR $488.83 AT CHEVROLET DEALERSHIP. SEPTEMBER 2015 IGNITION LOCK CYLINDER WAS STUCK, MY KEY CAME OUT OF LOCK AND THE CAR WAS STILL RUNNING. I HAD TO COME OFF OF THE CLUTCH TO PURPOSELY MAKE THE CAR CUT OFF AND HAD TO UNPLUG THE BATTERY. THE 2003 CHEVROLET IS NOT INCLUDED IN THE RECALL BUT IT NEEDS TO BE. MY IGNITION LOCK CYLINDER HAS FAILED ME 3 TIMES IN THE PAST 6 YEARS. THANKFULLY, I'M ALIVE AND ABLE TO TELL YOU ALL ABOUT THIS. CHEVROLET & GM KNEW ABOUT THE LOCK CYLINDER RECALL WHEN I HAD MINE REPLACED LAST YEAR.

THE DASHBOARD PIECES HAVE STARTED TO CRACK BAD. I REPLACED THE CONSOLE PIECE BUT THEY DONT MAKE A REPLACEMENT FOR THE STRIP ALONG THE BOTTOM OF WINDSHIELD. ITS GOT CHUNKS MISSING OUT OF IT.

STEERING WHEEL AND SHROUD BECAME TOTALLY DISENGAGED AND FELL INTO MY LAP WHILE TRYING TO TURN ONTO LIVERNOIS ROAD MAKING IT IMPOSSIBLE FOR ME TO STEER VEHICLE.LUCKY I WAS LEAVING POST OFFICE AFTER MAILING LETTERS AND NOT WHILE ON FREEWAY. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE COULD NOT BE SHIFTED OUT OF PARK. WHEN THE CONTACT INSERTED THE KEY INTO THE IGNITION SWITCH, IT BECAME DIFFICULT TO TURN AND THE OVERHEAD LIGHT DID NOT TURN OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 8,161.

POWER SUDDENLY SHUT OFF, CAUSING POWER STEERING TO FAIL, WHICH MADE ME WRECK INTO A DITCH. IT ALSO CAUSED THE AIRBAGS TO NOT DEPLOY AND PREVENTED SEATBELTS FROM LOCKING INTO PLACE WHEN THE BRAKES WERE HIT. *TR

I HAD BEEN READING ABOUT RECENT RECALLS WITH GM, ESPECIALLY IGNITION SWITCHES. I HAVE A 2003 CHEVY CAVALIER AND IT WAS DIAGNOSED WITH A BAD IGNITION SWITCH. I FIRST NOTICED WHEN I WENT TO START THE CAR IN THE MORNING, A DAY AFTER COMING HOME FROM WORK. GOOD THING IT HAPPENED THEN BECAUSE I WOULD HAVE BEEN STRANDED OFF SITE. I WENT TO START THE CAR, NOTHING HAPPENED EXCEPT WIPERS AND RADIO DID NOT WORK AS WELL WHICH I THOUGHT WAS STRANGE. FINALLY THE RADIO AT LEAST CAME ON AT SOME POINT, BUT CAR STILL WOULD NOT START. AFTER IT WAS FIXED THEY SAID THE IGNITION SWITCH WAS BAD AND THE MECHANIC ASKED IF I HAD LOOKED FOR THE RECALL ON IT. I SEARCHED ONLINE BUT DID NOT FIND IT. I KNOW MY CAR IS OLDER, HOWEVER OF ALL THE CARS I EVER OWNED AND I HAD MANY, I NEVER HAD ANY ISSUES WITH IGNITION SWITCHES! I THINK I HAD ONE OF THE DEFECTIVE SWITCHES AND WOULD LIKE TO LOOK INTO THIS MATTER. UNFORTUNATELY I PROBABLY CAN'T GO BACK TO GET THE PHYSICAL IGNITION SWITCH AT THIS POINT, TOO LATE. I HAVE THE PROPER PAPERWORK FOR IT HOWEVER. ALSO ON ANOTHER NOTE, MY REAR DRIVER SIDE SIGNAL KEEPS GOING OUT, NO MATTER HOW MANY TIMES I REPLACE IT. THAT MIGHT BE SOMETHING GM SHOULD LOOK INTO AS WELL. *TR

INSTRUMENT CLUSTER GAUGES MALFUNCTION PERIODICALLY AND LOCK INTO ONE POSITION OR DON'T WORK AT ALL. CANT TELL WHAT YOUR SPEED IS , TEMP IS, RPM ETC! THIS I THINK IS A SAFETY ISSUE AND SHOULD BE ADDRESSED. I SEE THIS IS HAPPENING TO MANY PEOPLE AS I HAVE INVESTIGATED IT ON LINE. THIS IS PRETTY MUCH WHAT'S HAPPENING... HTTPS://WWW.YOUTUBE.COM/WATCH?V=RZILY3GXEXA. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. THE VEHICLE COULD BE RESTARTED AND THE VEHICLE FUNCTION NORMALLY. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 26,914 AND THE CURRENT MILEAGE WAS 27,914.

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT WHEN ATTEMPTING TO RESTART THE VEHICLE, IT MADE A LOUD POPPING NOISE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 41,000.

2006 CHEVROLET COBALT & 2003 CAVALIER. CONSUMER WRITES IN REGARDS TO BOTH VEHICLES POWER STEERING AND CUTTING OFF PROBLEMS. *SMD THE CONSUMER STATED THE CAVALIER, CUT OFF, JUST LIKE THE COBALT. HOWEVER, THE COBALT WAS RECALLED. THE CAVALIER CUT OFF WEEKLY SINCE IT WAS PURCHASED. THE POWER STEERING WAS REPLACED DURING A RECALL. IT WAS REPLACED AT 35,000 MILES AND AGAIN AT 68,000. *JB UPDATED 08/07/14 *JB UPDATED 09/24/14. *JB

MY SON WAS PULLING INTO A PARKING LOT AND AS HE DESCRIBES IT, EVERYTHING BUT THE RADIO WENT DEAD ALL BY ITSELF (THE ENGINE DIED AND THERE WAS NO POWER STEERING OR BRAKES). OBVIOUSLY THE SAME SYMPTOMS AS THE CURRENT RECALLS. I CALLED THE DEALER AND WAS TOLD THE CAR ISN'T ON THE LIST. I'VE COMPLAINED TO CHEVY AND AM GETTING THE RUNAROUND BY MULTIPLE MEMBERS OF THEIR "CONSUMER SUPPORT TEAM" (WE'VE ASSIGNED YOU A SERVICE REQUEST NUMBER BUT I AM TO WAIT UNTIL IT HAPPENS AGAIN AND THEN BRING IT IN "SO WE COULD START REVIEWING ON YOUR CASE"). I TOOK IT TO MY OWN MECHANIC AND HE RAN A BUNCH OF TESTS BUT COULDN'T FIND ANYTHING THAT WOULD CAUSE THE CAR TO DIE. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE KEY SEIZED IN THE IGNITION AND THEY WERE UNABLE TO SHUT THE ENGINE DOWN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 130,000. UPDATED 08/19/14*LJ UPDATED 08/23/2017*CT

WENT TO START CAR TO GO TO STORE AND IT WOULD NOT START. LUCKILY IT WAS AT HOME WHEN IT DECIDED TO STOP WORKING. TOWED TO GARAGE AND THEY SAID IT WAS THE FUEL PUMP. THE GARAGE REPLACED THE FUEL PUMP AND IT FIXED THE NO START ISSUE. I HAD NO IDEA THAT THIS WAS THE PROCESS TO START A RECALL INVESTIGATION OR I WOULD HAVE SAID LONG AGO. THERE HAS BEEN LOTS OF RECALLS LATELY ON GM AND THIS SAME CAVALIER DECIDED NOT TO START TWICE AFTER THE FUEL PUMP, ONCE IN 2011 WAS THE TIMING CHAIN THEN AGAIN DECEMBER 2012 THAT I STILL HAVE TO DIAGNOSE WHICH LED ME TO RESEARCH RECALLS. EACH TIME THE CAR STOPPED WORKING LUCKILY IT WAS IN MY DRIVEWAY EACH AND EVERY TIME. THE TIMING CHAIN THERE WAS SOME WARNING, IT WOULD SOMETIMES BUCK, OTHER TIMES IT WAS FUSSY ON STARTING AND IT WOULD STALL AT STOP LIGHTS. I WILL REPORT A NEW ISSUE IF I CAN FIND OUT THE 3RD UNKNOWN 2012 ISSUE. *TR

CLUSTER DEFECT: PURCHASED A 2003 CHEVY CAVALIER BRAND NEW OFF THE LOT IN DECEMBER OF 2002. JUST AFTER 5 YEARS AND APPROXIMATELY 55,000 MILES, WE ARE DRIVING DOWN THE HIGHWAY DURING SNOWFALL WHILE THE SPEEDOMETER STATED WE WERE TRAVELING AT 65 MILES PER HOUR, WE DID NOT KNOW THAT THE SPEEDOMETER WAS NOT READING CORRECTLY UNTIL WE GOT TO A CORNER AND THE SPEEDOMETER SHOWED WE WERE DRIVING AT ABOUT 20 MPH WHEN WE WERE FLYING AT ATLEAST 50 MPH WHICH INDICATED THE SPEEDOMETER WAS ABOUT 30 MPH OFF. THEN THE TACHOMETER WOULD STOP WORKING, GET STUCK, OR NOT OPERATE CORRECTLY. I THEN BEGAN TO HAVE PROBLEMS WITH ALL OF THE GAUGES, THE GAS GAUGE NEEDLE WOULD GO BACKWARDS ON TOP OF THE TEMPERATURE GAUGE CAUSING THE TEMPERATURE GAUGE TO STOP WORKING THEN ALL GAUGES WOULD MALFUNCTION, THEN THEY WOULD STOP WORKING COMPLETELY. I TOOK IT INTO THE CHEVY DEALERSHIP, THEY CAME BACK TO ME AND SAID IT'S WORKING FINE, THERE'S NOTHING WRONG WITH IT. AND AGAIN AND AGAIN AND AGAIN THE GAUGES CONTINUE TO GO HAYWIRE CHEVY STATED WHEN I TOOK THE VEHICLE IN THAT THEY HAVE NEVER HEARD OF SUCH A COMPLAINT AND I TOLD THEM TO LOOK IT UP ON THE INTERNET, THERE ARE HUNDREDS/THOUSANDS OF COMPLAINTS REGARDING THIS PROBLEM. CURRENTLY NONE OF MY GAUGES ARE WORKING AND AM HAVING TO USE A GPS TO NAVIGATE SPEED AND FILL MY VEHICLE UP EVERY 4 DAYS BECAUSE I HAVE NO IDEA WHEN THE CAR IS ON EMPTY. IT IS HIGH TIME SOMETHING BE DONE ABOUT THIS. CHEVY RECALLED A BUNCH OF OTHER MODELS, BUT NOT THE CARS. SOMETHING HAS TO BE DONE ABOUT THIS AND QUICKLY BEFORE SOMEONE IS KILLED. OR DOES IT TAKE A DEATH OR MANY MORE TO GET SOMEONE'S ATTENTION THAT THIS PROBLEM NEEDS TO BE ADDRESSED. PLEASE INVESTIGATE THIS DEFECT FURTHER. THERE ARE TOO MANY OF US OUT THERE THAT ARE DEALING WITH THIS PROBLEM AND ARE JUST KEEPING QUIET ABOUT IT. THIS PROBLEM DEFINITELY WARRANTS A RECALL AND FAST. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ERRATIC INSTRUMENT PANEL..SOMETIMES AFTER TURNING IGNITION KEY ON ALL PANEL LIGHTS STAY ON (BEYOND NORMAL)AND ALL GAUGES GO OFF..SOMETIMES OK WHEN STARTING BUT SOME LIGHTS COME ON (AIR BAG, SERVICE ENG, ABS GAS GAUGE, ETC) AFTER DRIVING ..SOMETIMES ALL INSTR GAUGES GO OUT COMPLETELY WHILE DRIVING INCLUDING SPEEDOMETER...THEY SOMETIMES COME BACK ON AND SOMETIMES NOT...I ENTERED MY MAKE AND YEAR ON GOOGLE TO SEE IF OTHER OWNERS HAVE SIMILAR PROBLEM AND FOUND OUT MANY DO..INTERESTING TO NOTE THAT WHILE RESEARCHING ON GOOGLE I FOUND OUT CHEV TRUCKS IN YEAR 2003 HAD A RECALL DUE TO FAULTY INSTRUMENT PANEL CONTROLS BUT THE AUTOS WERE NOT RECALLED.. I FEEL THIS IS A DEFINITE SAFETY HAZARD SINCE I SOMETIMES HAVE TO DRIVE WITH NO SPEEDOMETER, GAS GAUGE AND AN AIRBAG LIGHT THAT STAYS ON. I DO NOT FEEL SAFE DRIVING THIS VEHICLE FOR ANY LENGTH OF TIME AND HAVE TO RESORT TO ONLY SHORT TRIPS (GROCERY STORE, DR APPTS, ETC) I WOULD LIKE TO KNOW WHY GM HAS NOT RECALLED THIS 2003 CHEVY CAVALIER..ESP WHEN THEY HAVE RECALLED THE SAME YR AND MAKE TRUCKS FOR FAULTY INSTR PANELS.. I FEEL THIS FAULTY INSTR PANEL IS PLACING ME IN A VERY DANGEROUS POSITION EACH TIME I GET BEHIND THE WHEEL AND NEEDLESS TO SAY DO NOT FEEL SAFE DRIVING THIS AUTO AT ALL... *TR

ON OR ABOUT MARCH 8TH, 2014, I NOTICED THAT HOLES HAD APPEARED ON THE DRIVERS AND PASSENGER SIDE OF THE VEHICLE ON THE BOTTOM AND WHEN I WENT TO FURTHER EXAM THE HOLE, I THEN REALIZED THE UNDERSIDE OF THE CAR IS COMPLETELY CORRODED. THE SHEET METAL ON THE PASSENGERS SIDE IS COMING OFF IN SHEETS AND THE HOLE HAS BECOME MUCH LARGER IN SIZE. ALSO, THE VEHICLE PULLS TO THE LEFT AND RIGHT PRETTY STRONGLY. THE INSIDE FLOOR OF THE CAR FEELS SQUISHY LIKE THE FLOOR IS GOING TO FALL OUT. HIGHER SPEEDS SEEM TO MAKE MORE SHEET METAL FALL OFF. *TR

AFTER I DRIVE CAR FOR 5 THEN SYSTEM SECURITY LIGHT COMES, AND MANY OTHER LIGHTS COME ON DASH BOARD AND ALL THE GAUGES DROPPED TO ZERO. PEPBOYS SAYS IT IS BAD BCM. *TR

WHEN SHIFTING AUTO TRANSMISSION INTO REVERSE GEAR FROM PARK THE CLIP THAT HOLDS THE SHIFT CABLE ONTO THE SHIFT LEVER ON THE TRANSMISSION BROKE. DEALER TOLD ME THAT ENTIRE SHIFT CABLE MUST BE PURCHASED TO GET THE SMALL CLIP THAT HOLDS CABLE END TO TRANSMISSION SHIFT LEVER. I WENT TO A LOCAL JUNK YARD TO FIND THIS SMALL CLIP (PART) AND WAS ASTONISHED TO FIND THAT EVERY AUTO OF THIS YEAR AND MAKE HAD THE SIMILAR PROBLEM. ALL OF THESE AUTOS HAS THE CABLE WIRED TO THE SHIFT LEVER. SOME USED A WIRE TIE TO SECURE THE LEVER TO CABLE. THE TOW TRUCK DRIVER WHO RESPONDED TO TOW MY VEHICLE SAID HE SEES THIS PROBLEM "ALL THE TIME". WHEN I CALLED THE LOCAL CHEVY DEALER THEY SAID THEY WERE OUT OF STOCK FOR THIS CABLE AND CLIP AND HAD TO ORDER IT. THIS MAY ALSO INDICATE THAT THIS PROBLEM IS WIDE SPREAD. IF THIS SHIFT CABLE WERE TO FALL OFF WHILE TRYING TO MANUALLY SHIFT THE AUTO TRANSMISSION, WELL, I AM SURE YOU UNDERSTAND THE RESULTS. *TR

THE ENTIRE INSTRUMENT CLUSTER PANEL COMPLETELY WENT HAY WIRE AND THE SPEED WOULD INCREASE AND DECREASE. EVERYTHING WAS FLASHING TO THE POINT IT WAS ACTUALLY SCARY. I PULLED OVER TO THE SIDE OF THE ROAD AND IT STILLED CONTINUED. I FINALLY DECIDED TO CONTINUE HOME AND AFTER ABOUT 6 MILES IT FINALLY JUST STOPPED. I RESEARCHED THIS PROBLEM ON THE INTERNET AND HAVE FOUND THAT SO MANY MORE HAVE EXPERIENCED THE SAME THING HAPPENING BUT SOME HAVE HAD THEIR CAR ACTUALLY START ON FIRE. PLEASE ADVISE IF THERE IS ANY RECALL IN THE NEAR FUTURE BEFORE SOMEONE HAS TO LOSE THEIR LIFE OVER THIS. THANK YOU SO MUCH FOR ANY CONSIDERATION. *TR

WAS IN THE FAST LANE AND CAR SHUT OFF AND TRIED TO RESTART BUT IT WOULD NOT. WAS STUCK IN THE ROAD CARS HONKING CAR WOULD NOT RESTART. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE AT AN INDEPENDENT MECHANIC FOR THE REPLACEMENT OF CORRODED BRAKE LINES, THE MECHANIC NOTICED THAT THE FRAME WAS ALSO CORRODED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. *TR

COASTING DOWN HILL ON A DIRT ROAD, GOT TO THE BOTTOM AND ENGINE HAD DIED. ROLLED TO A STOP AND WOULD NOT RESTART. TOWED TO A MECHANIC, REPLACED FUEL PUMP. THIS HAPPENED TWICE MORE AND EACH TIME THE FUEL PUMP WAS BAD. THE LAST FUEL PUMP ONLY LASTED 3 MONTHS AND LIKE THE TWO PREVIOUS PUMPS, IT WAS BRAND NEW!! THIS IS 3 BAD FUEL PUMPS IN A YEAR AND MY WALLET CAN'T AFFORD TO KEEP THIS UP. WHY IS THERE NOT A RECALL ON THIS? *TR

DRIVING AT LOW SPEED. STEERING WHEEL EXPERIENCED EXCESSIVE SIDE PLAY. MADE APPOINTMENT AT LOCAL MECHANIC (NON-DEALER) STEERING HOUSING TAKEN OFF AND FOUND ONE OF TWO PINS IN THE STEERING COLUMN FOR THE TILT MECHANISM HALF WAY OUT OF HOUSING. MECHANIC REINSERTED PIN AND ATTEMPTED TO RESTAKE PIN IN HOUSING. EXPERIENCED NO SIDE PLAY AFTER REPAIR FOR ABOUT 1 WEEK AND PROBLEM HAS RESURFACED. *TR

MY BOYFRIEND WAS DRIVING OUR CAR. I WAS IN THE PASSENGER SEAT. WE HAD BEEN DRIVING ON THE INTERSTATE FOR ABOUT A MILE. THEN THE CAR STALLED. MY FRIEND REALIZED SOMETHING WAS WRONG WHEN HE HIT THE GAS PEDAL AND THERE WAS NO RESPONSE, SO HE PLACED IT IN NEUTRAL, STEERED AND SIGNALED UNTIL HE GOT US AND THE CAR SAFELY OFF THE ROAD. AFTER, THE CAR WAS TOWED INTO THE DEALERS SHOP THE MECHANICS SAID IT WAS THE FUEL PUMP THAT HAD FAILED TO WORK. THEREFORE, A NEW FUEL PUMP WAS INSTALLED IN THE CAR. *TR