Audi Q7 2019 — Reported problems

During summer 2026 the check-engine light on our 2019 Audi Q7 came on BEFORE its first August service/oil-change visit. The light remained on when the dealer returned the vehicle. Within days, the driver found cruise control no longer worked; it had worked before that visit. She called the dealer in mid-August to arrange a return. At the second visit, the dealer reported intake-manifold runner controls for banks 1 and 2 stuck closed and recorded: "water pump has failed internally, causing a vacuum leak". The water pump was replaced. After the second visit, around August 28, 2026, a high-pitched whining/squealing noise began. It occurred while coasting or going downhill and generally when the accelerator was not pressed, not only while braking. The driver initially suspected a brake noise. She recalls the dealer advising measures to remove excess brake material and saying it should not pose a safety risk. The noise persisted after those measures. At a third visit the dealer diagnosed a PCV/crankcase-breather issue. That repair remains outstanding. The earlier reassurance concerned a suspected brake noise before the PCV diagnosis. We request investigation of the persistent warning, cruise-control malfunction, diagnosed vacuum/intake-manifold issues and later PCV/noise complaint, including any safety implications for vehicle operation. Whether these faults are related is UNKNOWN; their timing alone does not establish that service caused them. Our specific concern is abnormal crankcase pressure from the PCV fault, including possible overpressure, oil leakage or seal damage and impaired engine operation in traffic. Actual pressure/vacuum measurements and any resulting damage are UNKNOWN; these are concerns for investigation, not confirmed events. Receipts are available. Actual fault codes, diagnostic tests, and repair records should be reviewed. Availability of removed parts for inspection is UNKNOWN.

See attached document for complaint.

My car has experienced unintended automatic emergency braking while driving in active traffic with no obstruction present. This created a serious risk of a rear-end collision from vehicles behind. Prior to this, the car had ongoing alignment and steering issues beginning shortly after purchase. The car consistently pulls while driving and has required multiple repair attempts, including alignments and inspections of steering and suspension components. These repairs have not resolved the issue. The problem appears to be worsening. In addition to the unintended braking, the vehicle intermittently displays safety system warnings related to driver assistance features. The failure involves both mechanical and electronic systems, including steering alignment and automatic emergency braking. It's believed that incorrect alignment or suspension issues may be affecting sensor calibration and causing false collision detection. The car has been inspected multiple times by the dealership, but the issue has not been diagnosed or permanently repaired. The car's unsafe to operate due to unpredictable braking behavior. The warning signs that the car gives are “Traffic jam assist unavailable” and “Safety system malfunction” while driving.These warning messages and system malfunctions have been occurring intermittently since shortly after purchase in early 2025 and were previously reported to the dealership. The warnings continued after the incident and are documented with photos taken the following day. The safety systems appear to be unreliable and malfunctioning in real-time operation.

The contact owns a 2019 Audi Q7. The contact stated that while in reverse, the back-over prevention intermittently displayed a black screen. The vehicle was not taken to the dealer to be diagnosed or repaired. The contact researched online and became aware of NHTSA Campaign Number: 25V900000 (Back Over Prevention); however, the VIN was not included. The manufacturer was not made aware of the issue. The failure mileage was approximately 138,000.

The starter in my Audi Q7 2019 failed and the car would not start. I was parked in my garage and manually had to put the car in neutral using the tool provided in the trunk and push the car out of the garage until a flatbed tow truck was able to take my car to the shop. If this happened elsewhere, I could have been stranded without the ability to start my car. My car was towed to a certified shop where they confirmed the failure and made the repair by installing a new starter.

While driving, the vehicle’s infotainment system suddenly froze and then rebooted on its own. During the reboot, the display was unavailable for several minutes, causing loss of access to navigation, vehicle status information, and warning messages while the vehicle was in motion. This occurred without warning and distracted the driver while driving, creating a potential safety risk.

Drive System malfunction code appeared while driving. Engine then shut off immediately. Had it towed to Audi dealership. Fuel Pump and Fuel Pump Module Codes reported in diagnostics check: codes P3044, P1158, and P0148. There is a NHTSA campaign number 22V516 (Audi recall number 20DR) that has been reported on this same issue with the fuel pump, however, my model 2019 is one year shy of the 2020 Q7 to 2021 affected vehicle range. Asking NHTSA to look into other repeated fuel pump issues for the same model vehicle, but for 2019 models. I have read of other 2019 model fuel pump complaints that match the 2020-2021 recall. The 2019 models need to be included in the investigation and recall.

Steering malfunction , stop car warning. On the road

Yesterday I bought a 2019 Audi Q7 and today I get a warning light stating my right parking lamp is defective. Upon checking the light I found that it was on and working. Upon researching the issue I found that there are numerous complaints on 2017 and 2018 models of the same vehicle, for the same issue. Dealership stating it is an entire right headlight replacement to the tune of over $ 2500.

Broken front springs at 60000 miles.

Driving down the road at 50 mph and warning light came on stating "Steering Malfunction" and lost all steering capacity and had difficultly safely exiting the traveled road to safe location. No steering and avoiding a rear collision due to unexpected breaking to handle car.

As always, my wife put her purse with the key in the purse in the front seat of the car while she was putting our (3) old grandchild in the care seat. as soon as my wife closed the back door all the doors locked, possibly our granddaughter hit the lock with her foot. The back doors only have a lock feature but not an unlock feature. My wife had to call the fire department to get the doors open. We live in Florida, if this was summer, there could have been a health risk to our grandchild. (1) why with the keys in the car would it lock (2) why isn't there a way to unlock the doors from the back seat? I went on line and it looks like others have had this same issue.

On my 2019 Audi Q7 anytime the headlights are activated either manually or automatically by the vehicle, it will pull up a "Right front parking light defective" error code. This code randomly showed up one day and has persisted ever since. Through research I have done on the issue it sounds like other 2017 Q7 models were also affected and recalled for this exact same issue. Clearly the issue is affecting later models as well that need to be included under the same recall. This issue puts my safety at risk by potentially limiting my visibility at night with a defective headlight.

At approximately 67,000 miles there was a loud bang and the passenger side rear coil spring was broken.

02/04/2025 after work I was driving on local street in rush hours, suddenly the display panel popped out the warning message: Steering: malfunction! Please stop vehicle. Then I found out the wheel couldn't turn right or left any more. I turned on the emergency light immediately and moved my vehicle close to curb pending tow truck. Luckily it was raining evening, traffic was slow at 15~20 MPH, this incident didn't cause crash or injury but blocking the traffic more then one hour for the tow truck. If it happened on highway, I couldn't imagine what the serious fatal accident would be... After the Audi tech inspected, it was the electrical steering failed / the internal control died out--a defective parts.

When the vehicle is connected to a cell phone and reliant on Apple CarPlay for navigation support, the screen will freeze numerous times while in transit. This causes the driver to lose situational awareness. The natural impulse for most drivers is to try to remedy the issue while moving. Once the device is disconnected the application resets and loses the destination. This can happen while driving on a highway at a high rate of speed.

Both rear coil springs broke. Was not obvious when I was backing up. I heard a bang. I thought I hit something, but in fact I didn’t. I never knew what was wrong. The dealer reported that both rear springs were broken. He said it was a safety problem to keep it that way. The Audi dealer said it was a safety problem I think you should believe him. It is a safety problem. The car drove but I had to replace the springs cost thousands of dollars. Videos of spring at. [XXX] There was no crash. There was no heavy use. The spring simply broke the first one broke I believe at 55,000 miles and the second one at 76,000 miles. Everybody on the Internet seems to be having broken springs on Audi Q7 and Q5 models. And when they break, they’re no longer supported mechanic , as you can see from the photographs. One spring is supported in one way on the edge of the retain cup and one spring is pressing against some other component. It’s dangerous. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am filing a complaint and request for a recall on 2019 Audi Q7's side marker light. This is 2019 Model Audi Q7.It has about 60K miles. I start getting a warning message pops up frequently saying "Right front side marker light faulty See owner's manual". Searching online it appears many user with same model years facing the same problem, but could be on the left side. Some say dealer will not cover the repair even with extended warranty. Repair cost ranges from $3000 to $5000. The part is around $30. Due to this What people would normally do is just disable the light with some diagnostic tools. This is against the safety requirement and extremely dangerous in my opinion. This is most likely manufacturer's faulty design or defects since it is so prevailing among car owners of same model. Please see some of the online posts by owners with this issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Rear coil springs broke after just 60,000 miles. Audi refused to cover but dealer said this is very common. Vehicle stability affected. After my 42 years in automotive industry as a supplier my bet is these springs are made in China and supplier is cheating on material specifications and Audi must know.

On October 9, I brought my 2019 Audi Q7 with approximately 79k miles to my dealership service department for an oil change and an inspection sticker. While in for the service, the dealership performed a multi-point inspection. During the inspection, the service technician found that both rear coils were broken off of the base. The technician recommended that these be replaced immediately and need immediate attention. The cost of the repair is over $3,000 and would then require an alignment and calibration, costing an additional over $500. I understand that these coils were recalled in later model Audi Q7's but not my year. Based upon this, it seems that the coils are defective and there should be additional recalls. There really is no reason for coils to break on a car that has such a large towing capacity (though I don't tow anything on the car and don't have a tow hitch). This is a safety issue for the car's performance and control.

During high weather temperature the fuel lines pops off and leaks fuel everywhere.

At 50k miles, in July 2023, I was told by the dealer, Audi, that the rear spring mounts were corroding, and it was not covered by warranty. Everything I have read about spring mounts is that they are not considered a wear and tear part, and should not deteriorate. But I paid about $2,000 for the repair. Now, 11 months later, one spring coil itself has broken, and despite the warranty since it was last replaced less than a year ago, Audi will not honor the warranty at all, because it was the spring mounts and not the springs themselves that were replaced. However, it is the same job to repair, and so I am forced to pay for the same amount of labor again. This seems criminal given the parts are interdependent and the job takes an equal amount of time. I don’t understand why the coils weren’t replaced initially, as I now have to pay for the project to essentially be redone. Yes, it is a safety issue. Was not inspected by police but it was by the manufacturer. There haven’t been any warning indicators in the vehicle.

Lane keeping assistance jerks car into turn lanes at highway speeds. Happens consistently on MN State Hwy 316. I usually disable it to prevent an accident.

On [XXX} Friday morning, I was driving at 35 mph on local road after existing from highway. Suddenly the screen displayed this message: Drive system malfunction. The car was totally broken down. I couldn't start the engine any more so I turned on hazard light and pulled over to the curb pending AAA rescue truck. Luckily it was not happened on highway. Otherwise the car could be wrecked to cause fatal accident. It was the first time since I had this brand new Audi Q7 in November 2019 running 26,600 miles. After Audi certified tech inspected, he concluded the fuel pump defective and needed to replace a new one for $3000+. Here is the link the tech completed his walkaround video [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Both rear spring have broke with a clean break. I would not have noticed except for the piece of spring laying on my garage floor. Seems to be a known issue with Audi 2013-2019

Faulty fuel sensor. Sensor showing low fuel warning while the tank is full

1. Steering malfunction, yes. 2. In the course of driving on [XXX] through a mountain pass in Colorado with snow and poor driving conditions, the steering mechanism on the vehicle failed resulting in not being able to maneuver the vehicle out of the lane or off the road safely. If this happened while other vehicles were in front/behind or to the side of us, or if this would have happened in another mountain road without emergency curbing/exits - we could have easily been killed. 3. The vehicle is at the Audi Denver dealership (had to be towed) and they confirmed the code "Steering: malfunction! Please stop vehicle" that displayed on the panel. 4. No, tried to call Audi but there was a 2 hour wait to talk to someone and even then, not sure I would have reached anyone that could have helped. 5. Warning message "Steering: malfunction! Please stop vehicle" displayed with red steering wheel icon and exclamation mark. No other warning or sign of failure. This is the problem, driving at highway speed, get a steering malfunction warning, can't steer or control the vehicle - have to stop "safely". This could have been catastrophic. In any other vehicle if rack/pinon slips or power steering fluid fails, you can still manage to steer and avoid collision, this Audi under these conditions gave no such option. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Motor mount is leaking hydraulic fluid. Available for inspection. At around 69,000 miles this was found by an independent service center. Motor mount must be replaced. There was no knowledge other than vehicle shaking. No lights. It was detected by other issues and codes being ran.

I have been told that I have a fuel rail leak, which can cause a fire in the engine compartment. This is the same as NHTSA Campaign Number 19V035000, but that campaign only covers model years 2016-2018 for the Audi Q7. This same issue has surfaced with my 2019 Q7.

On [XXX] we were parking the car in the lot at [XXX] , when the car suddenly accelerated despite my foot being on the brake and crashed into a storefront. The fireman said the airbags deploy code was issues but the airbag never deployed, and the automatic emergency braking did not stop the car. It seemed as though the transmission was switched, but we had not touched the gas. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In the first 10K miles the motherboard had to be replaced. Then the volume dial twice. Then the fuel sensor broke and because of its placement the entire gas tank had to be replaced. Next up at 45K the Medtronic (brains of the transmission had to be replaced and then the differential was having problems and they were debating working on it. I went to sell it at 48K miles before the warranty expired and during the inspection it was noted the two engine mounts were leaking and needed to be replaced. After I sold it to an Audi dealer, different than the Audi dealer I had purchased the car from and where I had all the warranty work done, I found out the CARFAX report showed NONE of the repairs made by the original Audi dealer to the car. Seems fradulent to me by the original Audi dealership who did all the major repairs.

The auto brake suddenly braked hard and it was scary. The car reported a collision warning red light for a few seconds. Luckily, there was no car close behind me. While I was driving at about 70 miles per hour on the highway, there was no car in front of me to worry about. There was probably a car driving in the next lane. After the sudden brake, everything seemed to be back to normal. This type of sudden auto brake happened once in late 2019, on a local drive, I thought it was a falling leaf or something. But this time on the highway, there was nothing in front the car.

Filling up the tank registers only half a tank. It seems similar to this recall which wasn't for my car's year. NHTSA campaign number: 22V155

Seat belts are fraying. The seatbelt in the second row on the driver side cannot be used because it has frayed and the tear is halfway through the width of the seat belt. The same issue is developing in the 3rd row on the passenger side. Audi is trying to charge us $1700 to replace the seatbelt in the second row alone.

Backup camera malfunctions, often turns blank or fails to activate

2019 Audi Q7 rear spring broke despite having only 28,000 miles. I heard a loud banging noise when driving on highway which I initially thought was a loose exhaust pipe. Took it to a service center which diagnosed a broken rear spring with high risk of tire puncture. Never driven off road or with heavy loads (heaviest thing in trunk has been my 50 lb dog). Vehicle was only 3 months out of 36 month warranty when this happened. Local Audi dealer and Audi USA failed to stand behind this repair which cost me over $2000 to fix at an independent garage. Online search noted other Audi Q7 with similar problems.

The component that failed was the fuel level sender. The attachment shows that I had it repaired by Audi. They found low static resistance which is the same issue they recalled 46,000 other vehicles for including 2019, just not Q7. The car is available for inspection. My safety was put at risk because the gas and did not work on the safety of others was put at risk because I could have run out of gas anywhere and it anytime. You took over a month to get an appointment. The issue has been corrected in June 2023. Audi was the only one that inspected the vehicle. There was one warning when it failed. .

Rear passenger side coil spring failed during vehicle operation. Vehicle has only 61,000 miles and has never seen any heavy duty including trailering anything.

The contact owns a 2019 Audi Q7. The contact stated that while operating the vehicle the message “emergency vehicle malfunction" displayed and the vehicle began to sputter and hesitate before stalling. The vehicle was towed to the local dealer who diagnosed that the fuel pump had failed and needed to be replaced. The fuel pump was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 51,000.

under 60k miles and have a coolant pump leak/failure due to a faulty bearing with excess movement.