Alfa Romeo Giulia 2017 — Problemas reportados

The intrusment cluster stopped working took it to the dealership they couldn't get it to work they contacted the manufacturer they stopped communicating. Dealership can't get the new updated software to download.

The contact owns a 2017 Alfa Romeo Giulia. The contact stated while driving 35 MPH and depressing the accelerator pedal, the vehicle failed to respond as needed. The message “Service Electronic Throttle Control” was displayed. The contact stated that a dealer was contacted. The vehicle was not taken to the dealer nor an independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall. The failure mileage was 50,000.

This has been an issue slowly getting worse over the last few months and escalated this week. June 20th, 2025 my car has literary died over (4) times during traffic and I had to try and stay calm while using a code reader to clear the codes to get the engine to start. Very scary, I have a 2017 Giulia Ti that just hit 100k miles. Even took it to the dealership and they couldn't explain it. Parasitic draw on my battery and they gave it a pass :( Codes: P2510-ECM/PCM POWER RELAY SENSE CKT RANGE/PERFORMANCE P0103-VAF CIRCUIT HIGH INPUT P0100- VAF CIRCUIT MALFUNCTION P0451-EVAP SYSTEM PRESSURE SENSOR/SWITCH 'A' RANGE/PERFORMANCE P0106-MANIFOLD ABSOLUTE PRESSURE/BAROMETRIC PRESSURE SENSOR CIRCUIT

Fuel pump and module failed and car stalled while on highway almost causing an accident.

Dear NHTSA, I am writing to report a serious safety incident involving my vehicle. On [XXX] at approximately [XXX], while driving to an extracurricular activity for my [XXX] child, my vehicle displayed the following warning messages: “Service Engine,” “Service Electronic Throttle Control,” and “Start/Stop Unavailable.” Immediately after these warnings appeared, the vehicle shut off and shifted into neutral. I lost the ability to steer, creating a highly dangerous situation. I was on a busy road approaching an interstate entrance and had to react quickly to avoid a potential accident. Fortunately, I was able to maneuver the vehicle safely to the side of the road, but I believe this malfunction presents a serious risk to public safety and should be investigated. Please let me know if additional information or documentation is needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Multiple times the check engine light will come on while driving. It shuts engine down at any speed. This usually happens during warm up phase of vehicle. You have to pull over and cycle power off and on multiple times before it starts and runs again. It has stalled in intersections causing traffic delays. Once it starts and codes clear it typically runs fine for long periods. Symptom codes include throttle system failure, fuel pump low pressure, miss fire, bcm communication error. Cycling off and on clears codes and car operates normally until next cold start. Symptoms seem to worsen when driving in n or a mode. Symptoms seem to worsen when remote starting vehicle.

Sudden loss of power while at 45MPH. Was luckily able to pull off into a parking lot. Vehicle was then unable to restart with clear no fuel being pulled. Code reading showed low fuel pressure and fuel pump errors. Was then towed.

On September 1, 2024, I was driving my Giulia over a busy 4-lane overpass. An error code related to the fuel system flashed on the dashboard, and the car stopped nearly instantly in the lane where I was driving. Upon seeing the error code, I was not able to pull over into the breakdown lane - it was that sudden. Attempts to restart the vehicle failed. My wife (who was a passenger) and I quickly walked off the overpass to relative safety and called for a towing service. The police initially thought that the car was left in the way of traffic in the middle of a travel lane, rather than being pulled over into the breakdown lane. I had to explain that my Giulia stopped too quickly for me to be able to pull into the breakdown lane. The vehicle was towed to a local mechanic that same day (September 1st, 2024) who confirmed the failure to restart the vehicle but declined to perform any work, referring me instead to Alfa Romeo service. The vehicle was towed to an Alfa Romeo dealership on September 23rd, 2024, where it sits to this day (November 1st, 2024). The dealership reports that the failure is due to a known issue - a defective fuel pump and associated control module. The dealership reports that they have the new fuel pump on hand, but that the associated control module is still unavailable. The dealership is unable to provide a date when the control module will become available. Looking back, I shudder at the thought that my wife and I were less than 1 minute from getting onto the I495 interstate.

On September 1st 2024 we were faced with a serious problem with our Alfa Romeo Giulia 2.0T leaving us stranded. The culprate was a defect in the fuel pump on which led to the complete stop of the car during our trip abroad. After driving 900 kilometers without problems, various error messages suddenly appeared on the dashboard, including “Have engine checked”, “Start/stop function not available” and “Service throttle control”. A few seconds later, the engine stopped responding to the accelerator pedal and misfires appeared, which caused the engine to come to a complete stop and the power steering noticeably deced. Fortunately, we were just able to get to safety, but the car could not be started from that moment on. This incident occurred while we were far from home and caused significant inconvenience and stress. The diagnosis of our authorized Alfa Romeo dealer was: defective fuel pump and fuel pump module, with replacement costs of €1,294. What is striking is that at the same time another Giulia, with the same year of construction, was at the same dealer with exactly the same problem. In our case, because we were driving on a fairly empty road, we did not incur any injuries or damage to our vehicle or fellow road users, but of course this could have been very different in a busy traffic situation. We think this is a serious safety issue.

Car go in limp mode when accelerating. Lost of power

When I'm driving on the highway, the vehicle suddenly have a notification stating 'Service Electronic Throttle Control' and started to lose power, no matter howbjard the pedal was being depressed, it's notbgiving enough power out and start dropping speed. That drop me almost hit the vehicle behind me and inposing a serious risk because I'm on the highway. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the dealer mentioend it might be a fuel pump problem. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, it start almodt everytime suddenly from nowhere. Usually it will be ok after a few restart, but this t.ime it's persistent

Received multiple code resulting from fuel rail, fuel pump, and fuel control module issue that cuts power when driving leading to unsafe driving situation. The car would stall in the middle of driving starving of fuel.

While driving my Alfa Romeo Giulia on [Insert Date], the vehicle's sunroof unexpectedly shattered without any prior warning or identifiable external impact, posing a sudden and severe safety risk. The shattering glass resulted in minor cuts and significant distress while I was operating the vehicle, thereby jeopardizing my safety as well as potentially that of other road users. Upon the occurrence of the incident, there were no prior symptoms, warning lamps, or messages indicating a potential problem with the sunroof. This issue had not been previously identified during routine maintenance checks, nor had there been any modifications or repairs done to the sunroof since the purchase of the vehicle. The vehicle has since been inspected by a service center where I initially received incorrect information about my warranty coverage, leading to further complications and delays in addressing the issue adequately. No third-party modifications have been made to the vehicle, and all services have been conducted according to manufacturer recommendations. This incident appears to be due to a failure or malfunction of the vehicle's sunroof system, which should be robust enough to withstand normal driving conditions without such occurrences. I am concerned that this could be indicative of a larger issue that may affect other vehicles of the same model.

My wife was driving the alfa on a tree lined winding country road when the car died without warning. The road has no hard shoulder so it was shuck on the road. My wife had to get out of the car and wave at to warn other traffic that the car was stuck on the road just around the bend. this went on for about an hour until the tow truck arrived, she was very stressed out as there was some close calls with traffic braking at the last second. The cause of the problem was the fuel pump failing, code P008. I am trying to source a replacement pump and during my research discovered this failure is common with 2017 and 2018 Alfa Giulia models. I am quite upset that they have not made this a recall, because the risk of being in an accident due to a car suddenly losing power is quite possible.

I was on the highway ramp picking up speed, and the car suddenly started to loose thottle. I pulled over to the side and the car went limp. The car shut off. I attempted to turn on the vehicle and it would not. The car was taken to an Alfa Romeo dealership and they confirmed that the fuel pump and fuel pump relay are both the cause for the vehicle not gaining any power and not remaining on. The car is still with the mechanics.

IN OCTOBER 2023 WHILE DRIVING THE FUEL PUMP SUDDENLY LOST POWER RESULTING THE VEHICLE TO STOP DEAD IN THE ROAD CAUSING A MAJOR SAFETY ISSUE WHICH COULD HAVE RESULTED IN A TRAGIC ACCIDENT. TODATE (1/31/2024) A REPLACEMENT FUEL PUMP CAN NOT BE LOCATED.

when driving at highway speed car stalls. When you pull over car will not restart. Codes that t come up are: U0415,P008A,P062A,P0087 which point to a fuel pump error. This has happened 5 times while driving on highway and is very dangerous.

Fuel pump failed while driving causing car to go into neutral with no power. Had to have it towed after risking my safety on a busy road. Had to pay for a new fuel pump and repairs at dealer. This happened in 2023 a few months back.

Fuel pump fails when hot outside or prolonged use. Has happened multiple times a week. Was driving, get a low pressure fuel code, and then engine sputters and stalls. Dealership said its a known issues and are trying to charge me $2500 to have the fuel pump, fuel control module, and software reprogrammed for the new design that doesnt fail with heat. This is a known issues and I had to pull over with no power, almost got hit by another car. This is dangerous and should be a recall! The dealership said they stock those pumps for this specific problem and alpha is fully aware. Please advise. The fuel pump behaves fine when it is cold out, below 50 deg F.

Auto start stop flashes Throttle body control warning then vehicle stalls

I have a 2017 Alfa Romeo giulia TI on several occasions between the dates of September 2023 to current November 21st 2023 I have had a series of low pressure fuel codes pop up during numerous Diagnostics it was found to be my in tank fuel pump during further research it was found it was a TBS on it and feel it should be cool due to the fact that wild traveling in a high-speed Lane at 80 miles an hour the car shut down I had myself and my family in the vehicle on another occasion I had myself in the vehicle in the slow lane knowing that this may come up or feeling this may come up and it shut down doing 65 miles an hour at any point in time we have been rear-ended and killed. On several occasions it has shut down but luckily turning into a parking lot on secondary roads this unfortunately has caused so much stress for my wife that she will not get into the car my children won't drive in it and my daughter doesn't want to get in any car cuz she doesn't trust them this is very very unsettling even at the fact that I have to pay for it and the stress is caused my family it's crazy to think out of all the vehicles I've ever owned in my life BMWs Porsches Chevrolets and Dodges I've never had to worry about a fuel pump going in this fashion without any safety mechanism set up I really hope to receive a response soon as I am actively getting it fixed and feel I should not even have to be putting out any money for this let alone the amount of time it's going to take for my kids to be able to get back into the car Alfa Romeo you really let me down on this one and as I continue to read and investigate I see that there are many many instances and threads with the same situation please do the right thing I'll be in touch

The Sun roof won’t close and is so distracting while driving on highways You can’t concentrate and this happen before but the dealership fixed under warranty and happens again and again and I did some research and it happens a lot in this cars same problem the last time was today sometimes full open and the most won’t close the corners

Was driving my 2017 Giulia on a busy interstate, and everything was perfectly fine until 3 error messages popped up: service engine, service electronic throttle control, start/stop unavailable. Then the engine cuts off and the car shifted into N gear. It was a very horrifying experience as the semi-truck behind me almost crashed into me since my car lost power. I tried to restart the car but with no success, the engine will sputter for 3-5 seconds and gave up. Plugged in the OBD scanner and received a "P008A low fuel pressure" reading (I had almost a full tank of gas). So it is a fuel pump related issue. Apperantly this is a very popular issue/defect, and Alfa Romeo is well aware of it as they even published a service bulletin for this specific error. Please see the attached PDF file for the service bulletin. Basically, the fuel pump module should be replaced. I am taking my car to an Alfa Romeo dealership for further investigation. I believed that Alfa Romeo should recall and inspect the conditions of the fuel pumps because it is very dangerous when your engine cut off while driving on a busy interstate. I also have another passenger with me while the incident happens and some other video and photo evidence. I can provide more evidence when my dealer finishes inspecting the car.

On July 10 I was driving my car and then suddenly all the brakes came on. There were no objects in front of the car or behind the cars it was early morning at 7 o'clock on my way to the hospital for work. There was no warning that there was an object in front of me or anything. Two days later around the same time in the morning the car could start but the electronic brake system was ON. you can't turn them off. it gave a temporary message about electronic brake system issue. you can start the car and turn it off but the car won't move the even when you put the gear on as if all electronic brake system are engaged and can't turn them off by pushing the electronic parking knob off. after turning the car on and off multiple times, this electronic brakes must have been disengaged. Three days later the car was diagnosed with brake caliper failure in one tire which was repaired. I'm a physician and by no means a car technician but I think these are two completely unrelated issues. I feel that a bad brake caliper in one tire should not cause all four tires and all four brakes to stop the car suddenly on the road or prevent the car from moving when Idol or lock the electronic brake system. I communicated this clearly with Alfa Romeo main office as well as with my local dealership. This has been almost 2-3 weeks ago since ofI communicated with the Alfa Romeo people. I clearly told him that this is a big safety issue and we can't allow cars to stop by themselves in the middle of the road or come to a sudden brake in the middle of the road. This is extremely hazardous to the driver as well as to the people in that car or around the car. the technician thinks that the car is drivable and safe. Again I work on people not cars, but to me sudden irrational activation of the electronic braking system may not be dangerous when the car is idol but is extremely DANGEROUS while driving. Because i didn't hear any listening ears at the Alfa, I decided to contact you.

Hello, I was driving in the highway at highway speed and my engine shutdown with any sort of warning. I almost caused a huge accident. After I took it to the Alfa Romeo dealer, I had to replace the fuel pump according to the dealer, which is a common problem. I think Alfa Romeo should do a recall on the fuel pump. I also,scratched my car due to this incident avoiding a bigger accident. This car needs to be recalled for fuel pump repairs for all the car with the old bad fuel pump design. Thank you

The contact owns a 2017 Alfa Romeo Giulia. The contact stated that the front passenger’s side headlight had failed to function as needed. The contact took the vehicle to the dealer and was informed that water or condensation had gotten into the headlight assembly and that the headlight assembly needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 20,000.

When driving vehicle it randomly goes into Limp mode and gives an “electronic throttle module error”. This in turns decreases the power of the vehicle significantly and causes you to move over lanes as to not cause traffic. This issue is common for a lot of Alfa Romeo Guilia owners.

Engine recently began making a loud ticking sound, that everyone who heard it asked, "What's wrong with your car?" I purchased the vehicle new 5.5 years ago and it presently has 38,475 miles on it. The dealer determined the noise was due to a loose oil pump bolt under the timing cover. It was a 10.5 hour repair to remove a bolt and reapply lock-tite to it and then reinstall. Had the repair not been performed the bolt could have vibrated all the way out and caused internal damage to the engine, which I believe is a safety issue. The repair cost was $1,813.68. Per the dealer this was the first Giulia model that they had to service for this issue, but they had serviced several Stelvio models that were newer but shared the same engine. In today's automotive market such repairs should not be necessary on a vehicle with low mileage. The brand offers a 4 year / 50,000 mile warranty, but not a separate powertrain warranty. In hindsight, it appears the brand does not have a great deal of confidence in the durability of the powertrains it builds.

On August 18, 2022, I was driving the vehicle at a speed of approximately 45 mph when the vehicle motor suddenly and without any prior warning completely shut down. Several warning lights appeared immediately but none prior to the shutdown. I was driving in moderately heavy traffic and had to coast to a spot off the shoulder of the road. This was a dangerous situation and if I had been in heavier higher speed traffic, this would have been a very risky safety situation since I had no power whatsoever to control the vehicle movement. The vehicle would not restart and had to be towed to a repair shop. The problem was with the Fuel Pump Control Module which had to be replaced along with replacing the fuel pump. The manufacturer had previously issued a Technical Service Bulletin (TSB) concerning this but had not issued a recall. I was unaware of the TSB. The manufacturer was obviously aware of issues with the Fuel Pump Control Module but did not issue a recall for vehicles. The TSB was for cars produced prior to August of 2017 and my car was produced in May of 2017.

It is impossible to adjust the headlights so as not to blind oncoming drivers. Some are forced to pull over. This is an ongoing issue, which the dealer says is due to faulty design and cannot be fixed.

* The engine parts melted, yes; its available for inspection at the dealership. * I could have crashed into others from the heavy smoke that blinded my sight, my family and i could have burned up or gotten blown up. * UNKNOWN * NO * NO

Car was being driven on a highway going around a turn and message for “ATV Service” appeared. Shortly after power to the steering wheel and lost jerked the car and came back. All electric lighting flickered and several other messages for service engine and transmission appeared.

My vehicle parking brake came on suddenly and will not go off. I have seen thousands of complaints online about corrosion to the wiring in the electronic brake system and am wondering why a recall has not been issued as this is a serious safety concern. My vehicle is now inoperable because I cannot get the parking brake off and am afraid that it will happen again while driving.

Car started itself. Vehicle was sitting in garage and was Locked. The radiator fans came on and vehicle started on its own. it continued to run until we unlocked and hit the stop button. Since this has happened it does not turnover on the first attempt. It has set several codes, Start stop unavailable, service electronic throttle, service engine now. My concern is if the vehicle were to start in the garage while we were asleep and carbon monoxide would leak into the house.

The battery will not hold a charge significant enough for the rear window defrost to work, and stop/start to work. Have replaced the battery twice and the dealer's answer is that I don't drive enough to get the battery charged enough as battery health is only 30%. I drive 20 miles a day, every day, somedays 100 miles. Others have this same issue in their Forum. Another solution is to constantly put a charger on the battery. The rear window ices over and is a safety issue.

While driving on highway at approximately 65mph, the panoramic sunroof spontaneously exploded causing shards of glass to be propelled through the cabin of the vehicle. All windows including the sunroof had been completely closed. My air conditioner was running, there were no vehicles directly in front of me or near me actually. There was no debris that struck the car nor where there any over pass streets or overhead structures in the vicinity. I was driving and a sudden (very loud) gunshot type bang, startled me followed by the whistling sound of wind and falling glass prompted me to pull over immediately. Fortunately my kids were not on the vehicle or they would’ve been struck by the falling shards of glass as there is plenty in the backseat area. The incident happened today, Sunday December 12, so as of now the vehicle has not been inspected by dealer or police or anyone. There was no previous warning of failure or malfunctions.

The brake by wire system failed, and another component caused the vehicle to accelerate when I hit the brake pedal. I didn't have any proof on the last complaint, but I have it now. This brake failure caused me to rear end someone, which caused a multiple vehicle accident. The dealership I took it to was aware that I was having electrical issues with the car, but they said they couldn't do anything about it because they couldn't find any fault codes. I even sent them a video of it as well. I also believe this car was involved in a prior accident as well by one of the previous owners and fixed by one of them under the table, because the front bumper shock absorber plate broke in half, and had writing on it as well that looked like something a repair shop would do. This car is unsafe.

The driver's side headlight vertical adjuster failed causing the headlight beam to be directed upwards at about a 40 degree angle. I understand from searching the internet, that this is an ongoing problem. I have a new assembly on order and when received I will have it installed. At that time the old, broken assembly will be available for inspection. This causes the light to not be directed to the roadway, causing dark spots and probably hits oncoming drivers in the eyes, blinding them. The dealer is clueless but the internet says that in Europe a circlip installation fix has been devised. The vehicle has not been investigated by the dealer. I am waiting to receive the new assembly before allowing them to work on it. There were no warnings of any kind. This car has automatic headlights so I never noticed it until I came home one night and lit up the trees as I came down the street and lit up my roof as I pulled in the driveway. From research I have discovered the mechanism is a ball and socket arrangement and the ball has a tendency to pop out of the socket due to vibration. This releases the bottom of the adjuster and allows the headlight to swing into full up position.

I was travelling along the road when 3 cars suddenly hit the brakes really hard. I was able to hit my brakes fast, but I did not feel any pressure on the pedal and I was unable to avoid hitting the car in front of me. I also had a problem with the start system. I was randomly unable to start the car (about 3 times.) I would have to wait 10 minutes or longer for the car to be able to start again. I also noticed that the front bumper frame of my car was split in half (as if I had hit a post or something big.) I also noticed that there was writting on the front bumper frame (no foam padding in between,) and the following written on the front (DNR. 01/09/2017 and a time 10:20.) I don't know what's going on with my vehicle. It's frustrating and I've had to take it to the dealership a few time 3 hours away.

My Alfa Romeo only has 29,000 miles on it. It randomly dies on you and does not start. Might happen while you drive with the start/stop and also when you try to turn on the car. When speaking to an Alfa Romeo representative, they inform you that to fix it’s about $600 or higher and they are also aware that is a common problems with their cars. The representative informed me that to turn it back on, I have to disconnect the a wire on top of the battery. I’m not a mechanic and should not have to work with the electrical system of the car. After reconnecting that wire, there’s the electric stability control light that turns on and the steering wheel assist light turns on. It’s crazy that this is a know issue with these cars and the dealers try everything they can to charge you for that repair. Which makes the car completely unsafe.